| Common Name: | SCRUBS GRAFFITI & SPRAY PAINT REMOVER |
| Manufacturer: | ITW DYMON |
| SDS Revision Date: | 8/28/2006 |
| SDS Format: | No Format Specified |
| Item Number(s): | 4HK51 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
MATERIAL SAFETY DATA SHEET
ITW DYMON
HMIS(R*):
HEALTH 2
FLAMMABILITY 3
REACTIVITY 0
PERSONAL PROTECTION B
IDENTITY: SCRUBS(R*) GRAFFITI & SPRAY PAINT REMOVER
FORMULA: B901
PART NUMBERS: 90101, 90130
NOTE:
BLANK SPACES ARE NOT PERMITTED. IF ANY ITEM IS NOT APPLICABLE, OR NO
INFORMATION IS AVAILABLE, THE SPACE MUST BE MARKED TO INDICATE THAT.
| SECTION 1: COMPANY IDENTIFICATION |  |
MANUFACTURER'S NAME: ITW DYMON
ADDRESS (NUMBER, STREET, CITY, STATE, AND ZIP CODE):
805 EAST OLD 56 HIGHWAY
OLATHE, KANSAS 66061
EMERGENCY TELEPHONE NUMBER: 1-800-535-5053
INTERNATIONAL EMERGENCY TELEPHONE NUMBER: 1-352-323-3500
TELEPHONE NUMBER FOR INFORMATION: 1-913-397-9889
SIGNATURE OF PREPARER (OPTIONAL): REGULATORY DEPT.
| SECTION 2: INGREDIENTS/IDENTITY INFORMATION | |
COMPONENTS (CHEMICAL CAS NO. OSHA ACGIH-TLV OTHER LIMITS %
IDENTITY, COMMON PEL RECOMMENDED (OPT.)
NAME(S))
WATER 7732-18-5 NO DATA NO DATA NO DATA 15 - 40%
DIMETHYL GLUTARTATE 1119-40-0 NO DATA NO DATA NO DATA 15 - 40%
DIMETHYL ADIPATE 627-93-0 NO DATA NO DATA NO DATA 10 - 30%
PPG-3 METHYL ETHER 25498-49-1 NO DATA NO DATA NO DATA 10 - 30%
ACETONE 67-64-1 1000 500 PPM 750 PPM STEL 7 - 13%
PPM
METHOXYISOPROPANOL 107-98-2 NO DATA 100 PPM 150 PPM STEL 7 - 13%
2-BUTOXYETHANOL 111-76-2 50 PPM 20 PPM 700 PPM IDLH 5 - 10%
(SKIN DESIGNATION)
AMYL ACETATE 628-63-7 100 PPM 50 PPM 100 PPM STEL 3 - 7%
DIMETHYL SUCCINATE 106-65-0 NO DATA NO DATA NO DATA 3 - 7%
ANY SUBSTANCE LISTED AS HAZARDOUS BY THE STATES OF CALIFORNIA, FLORIDA,
ILLINOIS, MICHIGAN, NEW JERSEY, OHIO, PENNSYLVANIA OR TEXAS IS DESCRIBED
ABOVE IF KNOWN PRESENT IN REGULATED CONCENTRATIONS.
| SECTION 3: HAZARDS IDENTIFICATION | |
ROUTE(S) OF ENTRY:
EYES?: YES
INHALATION?: YES
SKIN?: YES
INGESTION?: YES
ACUTE HEALTH HAZARDS:
WARNING. FLAMMABLE LIQUID AND VAPOR. CAUSES EYE AND SKIN IRRITATION. LIQUID
MAY BE HARMFUL OR FATAL IF SWALLOWED (ASPIRATION HAZARD). MAY BE HARMFUL IF
ABSORBED THROUGH INTACT SKIN. MAY BE HARMFUL IF INHALED. OVEREXPOSURE TO
VAPORS MAY INDUCE CENTRAL NERVOUS SYSTEM EFFECTS. FOLLOW GOOD CHEMICAL
HYGIENE PRACTICES TO AVOID THESE HAZARDS.
CHRONIC HEALTH HAZARDS:
REPEATED OR PROLONGED OCCUPATIONAL OVEREXPOSURE CAN CAUSE DERMATITIS, SEVERE
SKIN IRRITATION, OR PAINTER'S SYNDROME.
CARCINOGENICITY:
CHEMICAL: NONE
OSHA: NO
NTP: NO
IARC: NO
SIGNS AND SYMPTOMS OF EXPOSURE:
REDNESS, TEARING OR BURNING IN EYES. REDNESS, BURNING, DRYING OR CRACKING OF
SKIN. SWALLOWING, OVEREXPOSURE TO VAPORS OR SKIN ABSORPTION MAY CAUSE
DROWSINESS, DIZZINESS, NAUSEA, HEADACHES, FATIGUE, LOSS OF COORDINATION.
INHALATION OF EXCESSIVE AMOUNTS OF VAPORS MAY IRRITATE NOSE, THROAT, LUNGS
AND UPPER RESPIRATORY TRACT. FOLLOW GOOD CHEMICAL HYGIENE PRACTICES TO AVOID
THESE HAZARDS.
MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE:
PRE-EXISTING SKIN, LUNG, KIDNEY, LIVER, AND BLOOD CONDITIONS COULD BE
AGGRAVATED BY OVEREXPOSURE AND MISUSE.
| SECTION 4: EMERGENCY AND FIRST AID PROCEDURES | |
EYES:
FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES LIFTING EYELIDS TO INSURE
COMPLETE REMOVAL. SEE A PHYSICIAN IMMEDIATELY.
INGESTION:
IF LIQUID IS INGESTED CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY.
DO NOT INDUCE VOMITING UNLESS DIRECTED TO DO SO BY A PHYSICIAN OR POISON
CONTROL CENTER. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
INHALATION:
GET TO FRESH AIR. IF BREATHING HAS STOPPED, QUALIFIED PERSONNEL SHOULD
ADMINISTER ARTIFICIAL RESPIRATION. IF BREATHING IS DIFFICULT, GIVE OXYGEN.
SKIN:
FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES WHILE REMOVING
CONTAMINATED CLOTHING AND SHOES. WASH CLOTHING AND SHOES BEFORE REUSE.
IF IRRITATION ARISES AND PERSISTS GET MEDICAL ATTENTION.
| SECTION 5: FIRE FIGHTING MEASURES | |
FLASH POINT, CONCENTRATE (METHOD USED): 64 DEG. F (PMCC)
FLAMMABLE LIMITS: NO DATA
LEL: NO DATA
UEL: NO DATA
EXTINGUISHING MEDIA:
USE CARBON DIOXIDE, DRY CHEMICAL, FOAM, OR WATER FOG. LARGE SPILLS MAY CAUSE
A FLOATING FIRE TO FORM AS IF AN OIL FIRE.
SPECIAL FIRE FIGHTING PROCEDURES:
KEEP CONTAINERS COOL AND VAPORS DOWN WITH WATER SPRAY. PREVENT RUNOFF FROM
ENTERING SEWERS AND PUBLIC WATERWAYS. WEAR SCBA IN CHEMICAL FIRES.
HAZARDOUS PRODUCTS OF COMBUSTION:
CARBON DIOXIDE, CARBON MONOXIDE, SMOKE AND SOOT AND VARIOUS ORGANIC
OXIDATION BY-PRODUCTS.
UNUSUAL FIRE AND EXPLOSION HAZARDS:
FLAMMABLE LIQUID ON A POLYPROPYLENE TOWEL.
| SECTION 6: ACCIDENTAL RELEASE MEASURES | |
SMALL SPILL:
WIPE UP SMALL RELEASES WITH A DRY ABSORBENT CLOTH OR OTHER ABSORBENT
MATERIAL.
LARGE SPILL:
ABSORB LIQUID WITH VERMICULITE, ABSORBENT CLOTH, OR OTHER ABSORBENT
MATERIAL. PREVENT MATERIAL FROM ENTERING SEWERS OR DRAINS. VENTILATE AREA
AND BLOCK TRAFFIC. TRANSFER CONTAMINATED MATERIAL INTO SUITABLE CONTAINER
FOR PROPER DISPOSAL.
| SECTION 7: HANDLING AND STORAGE | |
HANDLING:
DO NOT GET INTO EYES, ON SKIN, OR CLOTHING. WASH THOROUGHLY AFTER HANDLING.
DO NOT SWALLOW. DO NOT SMOKE WHILE USING. AVOID INHALING VAPORS. USE WITH
ADEQUATE VENTILATION. DO NOT DELIBERATELY CONCENTRATE AND INHALE VAPORS.
FOLLOW LABEL DIRECTIONS CAREFULLY.
STORAGE:
STORE IN A COOL WELL VENTILATED AREA. KEEP AWAY FROM HEAT SOURCES. KEEP OUT
OF REACH OF CHILDREN. KEEP CONTAINER TIGHTLY SEALED WHEN NOT IN USE. DO NOT
CONTAMINATE WATER, FOOD OR FEED BY USE OR STORAGE.
| SECTION 8: EXPOSURE CONTROLS / PERSONAL PROTECTION | |
EYE PROTECTION:
IF DIRECT CONTACT IS POSSIBLE, USE GOGGLES OR APPROVED SAFETY GLASSES
(ANSI Z87).
SKIN PROTECTION: YES, IMPERVIOUS.
RESPIRATORY PROTECTIONS:
NOT USUALLY NECESSARY. USE WITH ADEQUATE VENTILATION. USE NIOSH/MSHA
APPROVED RESPIRATOR IF PELS OR TLVS ARE EXCEEDED.
ENGINEERING CONTROLS:
VENTILATION SHOULD BE PROVIDED IN THE EVENT OF OVEREXPOSURE.
| SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE AND ODOR:
CLEAR COLORLESS LIQUID WITH AN AMYL ACETATE SCENT SATURATED ON A TOWEL.
pH: 63
SPECIFIC GRAVITY (70 DEG. F): 0.986
BOILING POINT: >212 DEG. F
MELTING POINT: NO DATA
EVAPORATION RATE (BUTYL ACETATE = 1): NO DATA
VAPOR PRESSURE (MM-Hg @ 70 DEG. F): NO DATA
VAPOR DENSITY (AIR = 1): GREATER THAN ONE (1)
SOLUBILITY IN WATER: MISCIBLE
VOLATILE ORGANIC COMPOUNDS (VOCS):
295.80 GRAMS PER LITER OR 30% BY WEIGHT VOCS.
| SECTION 10: STABILITY AND REACTIVITY | |
HAZARDOUS POLYMERIZATION:
THIS PRODUCT WILL NOT UNDERGO HAZARDOUS POLYMERIZATION.
HAZARDOUS DECOMPOSITION OR BYPRODUCTS:
CARBON DIOXIDE, CARBON MONOXIDE, SMOKE AND SOOT AND VARIOUS ORGANIC
OXIDATION BY-PRODUCTS.
CHEMICAL STABILITY: STABLE
INCOMPATIBILITY (MATERIALS TO AVOID):
STRONG ALKALIS, ACIDS, OXIDIZERS, ALKALI METAL HYDROXIDES AND HEAT.
| SECTION 11: TOXICOLOGICAL INFORMATION | |
2-BUTOXYETHANOL:
ORAL LD50: 470 - 3000 MG/KG, RAT
SKIN LD50: 220 MG/KG, RABBIT
INHALATION LC50: 700 PPM/7H, RAT
| SECTION 12: ECOLOGICAL INFORMATION | |
2-BUTOXYETHANOL:
FATHEAD MINNOW LC50: 1900 MG/L
DAPHNIA MAGNA EC50: 2500 MG/L
SELENASTRUM CAPRICONMUTUM EC50: >1000 MG/L
| SECTION 13: DISPOSAL CONSIDERATION | |
DISPOSAL METHOD:
DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE LOCAL, STATE, AND FEDERAL
REGULATIONS.
RCRA WASTE INFORMATION:
IF THIS PRODUCT BECOMES A WASTE, IT WOULD BE A HAZARDOUS WASTE (D001) AS
DEFINED BY RCRA (40 CFR 261). HOWEVER THE WASTE SHOULD BE PROPERLY
CHARACTERIZED TO EVALUATE WHETHER ITS COMPOSITION HAS BEEN MODIFIED PRIOR
TO DISPOSAL.
| SECTION 14: TRANSPORT INFORMATION | |
DOT INFORMATION - 49 CFR 172.101:
PROPER SHIPPING DESCRIPTION: CONSUMER COMMODITY
HAZARD CLASS: ORM-D
IDENTIFICATION NUMBER: NONE
PACKING GROUP: NONE
WATER TRANSPORTATION:
PROPER SHIPPING DESCRIPTION: PAINT RELATED MATERIAL
HAZARD CLASS: 3
IDENTIFICATION NUMBER: UN 1263
PACKING GROUP: II
AIR TRANSPORTATION:
PROPER SHIPPING DESCRIPTION: PAINT RELATED MATERIAL
HAZARD CLASS: 3
IDENTIFICATION NUMBER: UN 1263
PACKING GROUP: II
| SECTION 15: REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
TSCA (TOXIC SUBSTANCES CONTROL ACT) STATUS:
ALL INGREDIENTS ARE ON THE TSCA INVENTORY OR ARE NOT REQUIRED TO BE LISTED
ON THE TSCA INVENTORY.
CERCLA RQ-40 CFR 302.4 (A):
ACETONE (CAS# 67-64-1) 5000 LBS
SARA 313 COMPONENTS - 40 CFR 372.65:
2-BUTOXYETHANOL (CAS# 111-76-2) 7.4%
STATE AND LOCAL REGULATIONS:
CALIFORNIA PROPOSITION 65: NONE
| SECTION 16: ADDITIONAL INFORMATION | |
DATE PREPARED:
REV. 3 - 08/28/06 - VOC REFORMULATION
REV. 2 - 06/26/06 - CORRECTED SPELLING ERRORS AND REVISED CARCINOGENICITY
TABLE.
REV. 1 - 02/20/06 - NEW FORMAT
WARNING!
THE USE OF THIS PRODUCT IS BEYOND THE CONTROL OF THE MANUFACTURER;
THEREFORE, NO GUARANTEE, EXPRESSED OR IMPLIED, IS MADE AS TO THE EFFECTS OF
SUCH OR THE RESULTS TO BE OBTAINED IF NOT USED IN ACCORDANCE WITH DIRECTIONS
OR ESTABLISHED SAFE PRACTICE. THE USER MUST ASSUME ALL RESPONSIBILITY,
INCLUDING INJURY OR DAMAGE, RESULTING FROM ITS MISUSE AS SUCH, OR IN
COMBINATION WITH OTHER MATERIALS. THE MANUFACTURER WARRANTS ONLY THAT THIS
PRODUCT MEETS THE MANUFACTURER'S SPECIFICATIONS FOR SUCH PRODUCT. THIS
WARRANTY IS IN LIEU OF ALL OTHER WARRANTIES, EXPRESS OR IMPLIED, AS TO
DESCRIPTION, QUALITY, MERCHANTABILITY. FITNESS FOR ANY PARTICULAR PURPOSE,
PRODUCTIVENESS, OR ANY OTHER MATTER, OF THIS PRODUCT. THE MANUFACTURER SHALL
BE IN NO WAY RESPONSIBLE FOR THE IMPROPER USE OF THIS PRODUCT. THE SOLE AND
EXCLUSIVE REMEDY AGAINST THE MANUFACTURER FOR BREACH OF WARRANTY SHALL BE
REIMBURSEMENT OF THE PURCHASE PRICE OF THE PRODUCT IN THE EVENT THAT A
DEFECTIVE CONDITION OF THE PRODUCT SHALL BE FOUND TO EXIST. NO OTHER REMEDY
(INCLUDING BUT NOT LIMITED TO INCIDENTAL OR CONSEQUENTIAL DAMAGES FOR
INJURY TO PERSON OR PROPERTY OR ANY OTHER INCIDENTAL OR CONSEQUENTIAL LOSS)
SHALL BE AVAILABLE.