| Common Name: | LOCTITE 510 GASKET ELIMINATOR 50ML GASKET ELIMINATOR 510, 51031 |
| Manufacturer: | HENKEL |
| SDS Revision Date: | 7/1/2022 |
| SDS Format: | No Format Specified |
| Item Number(s): | 12Z232, 4KM07 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
HENKEL
SAFETY DATA SHEET
REVISION NUMBER: 008.2
ISSUE DATE: 07/01/2022
| 1. PRODUCT AND COMPANY IDENTIFICATION |  |
PRODUCT NAME: LOCTITE 510 GASKET ELIMINATOR 50ML GASKET ELIMINATOR 510
IDH NUMBER: 135474
PRODUCT TYPE/USE: ANAEROBIC SEALANT
ITEM NUMBER: 51031
RESTRICTION OF USE: NONE IDENTIFIED
REGION: UNITED STATES
COMPANY ADDRESS:
HENKEL CORPORATION
ONE HENKEL WAY
ROCKY HILL, CONNECTICUT 06067
CONTACT INFORMATION:
TELEPHONE: +1 (860) 571-5100
MEDICAL EMERGENCY PHONE:
POISON CONTROL CENTER: 1-877-671-4608 (TOLL FREE) OR 1-303-592-1711
TRANSPORT EMERGENCY PHONE:
CHEMTREC: 1-800-424-9300 (TOLL FREE) OR 1-703-527-3887
INTERNET: WWW.HENKELNA.COM
| 2. HAZARDS IDENTIFICATION | |
EMERGENCY OVERVIEW:
WARNING:
CAUSES SKIN IRRITATION.
MAY CAUSE AN ALLERGIC SKIN REACTION.
CAUSES SERIOUS EYE IRRITATION.
SUSPECTED OF CAUSING CANCER.
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
HAZARD CLASS HAZARD CATEGORY
SKIN IRRITATION 2
EYE IRRITATION 2A
SKIN SENSITIZATION 1
CARCINOGENICITY 2
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE 2
PICTOGRAM(S):
HEALTH HAZARD
EXCLAMATION MARK
PRECAUTIONARY STATEMENTS:
PREVENTION:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. DO NOT BREATHE VAPORS, MIST,
OR SPRAY. WASH AFFECTED AREA THOROUGHLY AFTER HANDLING. CONTAMINATED
WORK CLOTHING SHOULD NOT BE ALLOWED OUT OF THE WORKPLACE. WEAR
PROTECTIVE GLOVES, CLOTHING, EYE AND FACE PROTECTION.
RESPONSE:
IF ON SKIN: WASH WITH PLENTY OF WATER.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES,
IF PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EXPOSED OR CONCERNED: GET MEDICAL ATTENTION.
IF SKIN IRRITATION OR RASH OCCURS: GET MEDICAL ATTENTION.
IF EYE IRRITATION PERSISTS:
GET MEDICAL ATTENTION. TAKE OFF CONTAMINATED CLOTHING.
STORAGE: STORE LOCKED UP.
DISPOSAL:
DISPOSE OF CONTENTS AND/OR CONTAINER ACCORDING TO FEDERAL, STATE/
PROVINCIAL AND LOCAL GOVERNMENTAL REGULATIONS.
CLASSIFICATION COMPLIES WITH OSHA HAZARD COMMUNICATION STANDARD
(29 CFR 1910.1200) AND IS CONSISTENT WITH THE PROVISIONS OF THE
UNITED NATIONS GLOBALLY HARMONIZED SYSTEM OF CLASSIFICATION AND
LABELING OF CHEMICALS (GHS).
SEE SECTION 11 FOR ADDITIONAL TOXICOLOGICAL INFORMATION.
| 3. COMPOSITION / INFORMATION ON INGREDIENTS | |
HAZARDOUS COMPONENT(S) CAS NUMBER PERCENTAGE*
SILICA, AMORPHOUS, 112945-52-5 1 - 5
FUMED, CRYST.-FREE
SACCHARIN 81-07-2 1 - 5
CUMENE HYDROPEROXIDE 80-15-9 1 - 5
PROPANE-1,2-DIOL 57-55-6 1 - 5
CUMENE 98-82-8 0.1 - 1
1-ACETYL-2-PHENYLHYDRAZINE 114-83-0 0.1 - 1
* EXACT PERCENTAGES MAY VARY OR ARE TRADE SECRET. CONCENTRATION RANGE
IS PROVIDED TO ASSIST USERS IN PROVIDING APPROPRIATE PROTECTIONS.
| 4. FIRST AID MEASURES | |
INHALATION:
MOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. GET MEDICAL ATTENTION.
SKIN CONTACT:
IMMEDIATELY FLUSH SKIN WITH PLENTY OF WATER (USING SOAP, IF AVAILABLE).
GET MEDICAL ATTENTION. REMOVE CONTAMINATED CLOTHING AND FOOTWEAR. WASH
CLOTHING BEFORE REUSE.
EYE CONTACT:
GET MEDICAL ATTENTION. RINSE IMMEDIATELY WITH PLENTY OF WATER, ALSO UNDER
THE EYELIDS, FOR AT LEAST 15 MINUTES.
INGESTION:
GET MEDICAL ATTENTION. DO NOT INDUCE VOMITING. NEVER GIVE ANYTHING BY
MOUTH TO AN UNCONSCIOUS PERSON.
SYMPTOMS: SEE SECTION 11.
| 5. FIRE FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
WATER SPRAY (FOG), FOAM, DRY CHEMICAL OR CARBON DIOXIDE.
SPECIAL FIREFIGHTING PROCEDURES:
WEAR SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING,
SUCH AS TURN-OUT GEAR. IN CASE OF FIRE, KEEP CONTAINERS COOL WITH
WATER SPRAY.
UNUSUAL FIRE OR EXPLOSION HAZARDS:
UNCONTROLLED POLYMERIZATION MAY OCCUR AT HIGH TEMPERATURES RESULTING IN
EXPLOSIONS OR RUPTURE OF STORAGE CONTAINERS.
HAZARDOUS COMBUSTION PRODUCTS:
OXIDES OF SULFUR. OXIDES OF NITROGEN. OXIDES OF CARBON. IRRITATING
ORGANIC VAPOURS.
| 6. ACCIDENTAL RELEASE MEASURES | |
USE PERSONAL PROTECTION RECOMMENDED IN SECTION 8, ISOLATE THE HAZARD AREA
AND DENY ENTRY TO UNNECESSARY AND UNPROTECTED PERSONNEL.
ENVIRONMENTAL PRECAUTIONS:
DO NOT ALLOW PRODUCT TO ENTER SEWER OR WATERWAYS.
CLEAN-UP METHODS:
REMOVE ALL SOURCES OF IGNITION. EVACUATE AND VENTILATE SPILL AREA; DIKE
SPILL TO PREVENT ENTRY INTO WATER SYSTEM; WEAR FULL PROTECTIVE EQUIPMENT
DURING CLEAN-UP. SOAK UP WITH INERT ABSORBENT MATERIAL (E.G. SAND, SILICA
GEL, ACID BINDER, UNIVERSAL BINDER, SAWDUST). STORE IN A PARTLY FILLED,
CLOSED CONTAINER UNTIL DISPOSAL. SCRAPE UP AS MUCH MATERIAL AS POSSIBLE.
REFER TO SECTION 8 "EXPOSURE CONTROLS / PERSONAL PROTECTION" PRIOR TO
CLEAN UP.
| 7. HANDLING AND STORAGE | |
HANDLING:
USE ONLY WITH ADEQUATE VENTILATION. PREVENT CONTACT WITH EYES, SKIN AND
CLOTHING. DO NOT BREATHE VAPOR AND MIST. WASH THOROUGHLY AFTER HANDLING.
KEEP CONTAINER CLOSED. REFER TO SECTION 8.
STORAGE:
FOR SAFE STORAGE, STORE BETWEEN 0 DEG. C (32 DEG. F) AND 38 DEG. C
(100.4 DEG. F) KEEP IN A COOL, WELL VENTILATED AREA AWAY FROM HEAT,
SPARKS AND OPEN FLAME. KEEP CONTAINER TIGHTLY CLOSED UNTIL READY FOR
USE.
| 8. EXPOSURE CONTROLS / PERSONAL PROTECTION | |
EMPLOYERS SHOULD COMPLETE AN ASSESSMENT OF ALL WORKPLACES TO DETERMINE
THE NEED FOR, AND SELECTION OF, PROPER EXPOSURE CONTROLS AND PROTECTIVE
EQUIPMENT FOR EACH TASK PERFORMED.
HAZARDOUS COMPONENT(S) ACGIH TLV OSHA PEL
SILICA, AMORPHOUS, 3 MG/M3 TWA 20 MPPCF TWA
FUMED, CRYST.-FREE RESPIRABLE PARTICLES. 0.8 MG/M3 TWA
10 MG/M3 TWA 50 MPPCF TWA
INHALABLE PARTICLES. TOTAL DUST.
5 MG/M3 TWA
RESPIRABLE FRACTION.
15 MG/M3 TWA
TOTAL DUST.
15 MPPCF TWA
RESPIRABLE FRACTION.
SACCHARIN NONE NONE
CUMENE HYDROPEROXIDE NONE NONE
PROPANE-1,2-DIOL NONE NONE
CUMENE 5 PPM TWA 50 PPM (245 MG/M3) PEL
(SKIN)
1-ACETYL-2- NONE NONE
PHENYLHYDRAZINE
HAZARDOUS COMPONENT(S) AIHA WEEL OTHER
SILICA, AMORPHOUS, NONE NONE
FUMED, CRYST.-FREE
SACCHARIN NONE NONE
CUMENE HYDROPEROXIDE 1 PPM (6 MG/M3) NONE
TWA (SKIN)
PROPANE-1,2-DIOL 10 MG/M3 TWA NONE
AEROSOL.
CUMENE NONE NONE
1-ACETYL-2- NONE NONE
PHENYLHYDRAZINE
ENGINEERING CONTROLS:
PROVIDE ADEQUATE LOCAL EXHAUST VENTILATION TO MAINTAIN WORKER EXPOSURE
BELOW EXPOSURE LIMITS.
RESPIRATORY PROTECTION:
USE NIOSH APPROVED RESPIRATOR IF THERE IS POTENTIAL TO EXCEED EXPOSURE
LIMIT(S).
EYE/FACE PROTECTION:
SAFETY GOGGLES OR SAFETY GLASSES WITH SIDE SHIELDS. FULL FACE PROTECTION
SHOULD BE USED IF THE POTENTIAL FOR SPLASHING OR SPRAYING OF PRODUCT
EXISTS. SAFETY SHOWERS AND EYE WASH STATIONS SHOULD BE AVAILABLE.
SKIN PROTECTION:
NATURAL RUBBER GLOVES. USE CHEMICAL RESISTANT, IMPERMEABLE CLOTHING
INCLUDING GLOVES AND EITHER AN APRON OR BODY SUIT TO PREVENT SKIN
CONTACT. BUTYL RUBBER GLOVES. NEOPRENE GLOVES.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
PHYSICAL STATE: GEL
COLOR: PINK
ODOR: MILD
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT APPLICABLE, PRODUCT IS NON-SOLUBLE (IN WATER).
PH: NOT APPLICABLE
VAPOR PRESSURE: <5 MM Hg (80 DEG. F (26.7 DEG. C))
BOILING POINT/RANGE: NOT AVAILABLE.
MELTING POINT/ RANGE: NOT AVAILABLE.
SPECIFIC GRAVITY: 1.1784
VAPOR DENSITY: NOT AVAILABLE.
FLASH POINT: >93.3 DEG. C (>199.94 DEG. F)
FLAMMABLE/EXPLOSIVE LIMITS - LOWER: NOT AVAILABLE.
FLAMMABLE/EXPLOSIVE LIMITS - UPPER: NOT AVAILABLE.
AUTOIGNITION TEMPERATURE: NOT AVAILABLE.
FLAMMABILITY: NOT APPLICABLE
EVAPORATION RATE: NOT AVAILABLE.
SOLUBILITY IN WATER: SLIGHT
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
VOC CONTENT: 0.77 %; 8.47 G/L
VISCOSITY: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
| 10. STABILITY AND REACTIVITY | |
STABILITY:
STABLE UNDER NORMAL CONDITIONS OF STORAGE AND USE.
HAZARDOUS REACTIONS:
NONE UNDER NORMAL PROCESSING. POLYMERIZATION MAY OCCUR AT ELEVATED
TEMPERATURE OR IN THE PRESENCE OF INCOMPATIBLE MATERIALS.
HAZARDOUS DECOMPOSITION PRODUCTS:
IRRITATING ORGANIC VAPOURS. OXIDES OF SULFUR. OXIDES OF CARBON.
OXIDES OF NITROGEN.
INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS.
REACTIVITY: NOT AVAILABLE.
CONDITIONS TO AVOID:
ELEVATED TEMPERATURES. HEAT, FLAMES, SPARKS AND OTHER SOURCES OF IGNITION.
STORE AWAY FROM INCOMPATIBLE MATERIALS.
| 11. TOXICOLOGICAL INFORMATION | |
RELEVANT ROUTES OF EXPOSURE: SKIN, INHALATION, EYES, INGESTION
POTENTIAL HEALTH EFFECTS/SYMPTOMS:
INHALATION:
INHALATION OF VAPORS OR MISTS OF THE PRODUCT MAY BE IRRITATING TO THE
RESPIRATORY SYSTEM.
SKIN CONTACT:
CAUSES SKIN IRRITATION. MAY CAUSE ALLERGIC SKIN REACTION.
EYE CONTACT: CAUSES SERIOUS EYE IRRITATION.
INGESTION:
MAY CAUSE GASTROINTESTINAL TRACT IRRITATION IF SWALLOWED.
HAZARDOUS COMPONENT(S) LD50S AND LC50S IMMEDIATE AND DELAYED
HEALTH EFFECTS
SILICA, AMORPHOUS, NONE NO DATA
FUMED, CRYST.-FREE
SACCHARIN ORAL LD50 (MOUSE): NO TARGET ORGANS
17 G/KG
CUMENE HYDROPEROXIDE NONE ALLERGEN, CENTRAL NERVOUS
SYSTEM, CORROSIVE,
IRRITANT, MUTAGEN
PROPANE-1,2-DIOL ORAL LD50 (RABBIT): IRRITANT
18 G/KG
ORAL LD50 (MOUSE):
23.9 G/KG
ORAL LD50 (RAT):
30 G/KG
CUMENE ORAL LD50 (RAT): CENTRAL NERVOUS SYSTEM,
2.91 G/KG IRRITANT, LUNG
ORAL LD50 (RAT):
1,400 MG/KG
1-ACETYL-2- ORAL LD50 (MOUSE): ALLERGEN, BLOOD, KIDNEY,
PHENYLHYDRAZINE 270 MG/KG MUTAGEN, SOME EVIDENCE OF
CARCINOGENICITY
HAZARDOUS NTP IARC OSHA
COMPONENT(S) CARCINOGEN CARCINOGEN CARCINOGEN
(SPECIFICALLY
REGULATED
SILICA, AMORPHOUS, NO NO NO
FUMED, CRYST.-FREE
SACCHARIN NO NO NO
CUMENE HYDROPEROXIDE NO NO NO
PROPANE-1,2-DIOL NO NO NO
CUMENE REASONABLY GROUP 2B NO
ANTICIPATED
TO BE A
HUMAN
CARCINOGEN.
1-ACETYL-2- NO NO NO
PHENYLHYDRAZINE
| 12. ECOLOGICAL INFORMATION | |
ECOLOGICAL INFORMATION: NOT AVAILABLE.
| 13. DISPOSAL CONSIDERATIONS | |
INFORMATION PROVIDED IS FOR UNUSED PRODUCT ONLY.
RECOMMENDED METHOD OF DISPOSAL:
FOLLOW ALL LOCAL, STATE, FEDERAL AND PROVINCIAL REGULATIONS FOR DISPOSAL.
| 14. TRANSPORT INFORMATION | |
THE TRANSPORT INFORMATION PROVIDED IN THIS SECTION ONLY APPLIES
TO THE MATERIAL/FORMULATION ITSELF, AND IS NOT SPECIFIC TO ANY
PACKAGE/CONFIGURATION.
U.S. DEPARTMENT OF TRANSPORTATION GROUND (49 CFR):
PROPER SHIPPING NAME:
RQ, ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID, N.O.S.
HAZARD CLASS OR DIVISION: 9
IDENTIFICATION NUMBER: UN 3082
PACKING GROUP: III
DOT HAZARDOUS SUBSTANCE(S): ALPHA,ALPHA-DIMETHYLBENZYLHYDROPEROXIDE
INTERNATIONAL AIR TRANSPORTATION (ICAO/IATA):
PROPER SHIPPING NAME:
RQ, ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID, N.O.S.
(1,1'-(METHYLENEDI-P-PHENYLENE)BISMALEIMIDE)
HAZARD CLASS OR DIVISION: 9
IDENTIFICATION NUMBER: UN 3082
PACKING GROUP: III
WATER TRANSPORTATION (IMO/IMDG):
PROPER SHIPPING NAME:
RQ, ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID, N.O.S.
(1,1'-(METHYLENEDI-P-PHENYLENE)BISMALEIMIDE)
HAZARD CLASS OR DIVISION: 9
IDENTIFICATION NUMBER: UN 3082
PACKING GROUP: III
MARINE POLLUTANT: 1,1'-(METHYLENEDI-P-PHENYLENE)BISMALEIMIDE
| 15. REGULATORY INFORMATION | |
UNITED STATES REGULATORY INFORMATION:
TSCA 8 (B) INVENTORY STATUS:
ALL COMPONENTS ARE LISTED AS ACTIVE OR ARE EXEMPT FROM LISTING ON THE
TOXIC SUBSTANCES CONTROL ACT (TSCA) INVENTORY.
TSCA 12 (B) EXPORT NOTIFICATION:
NONE ABOVE REPORTING DE MINIMISNONE ABOVE REPORTING DE MINIMIS
CERCLA/SARA SECTION 302 EHS: NONE ABOVE REPORTING DE MINIMIS.
CERCLA/SARA SECTION 311/312: IMMEDIATE HEALTH, DELAYED HEALTH
CERCLA/SARA SECTION 313:
THIS PRODUCT CONTAINS THE FOLLOWING TOXIC CHEMICALS SUBJECT TO THE
REPORTING REQUIREMENTS OF SECTION 313 OF THE EMERGENCY PLANNING AND
COMMUNITY RIGHT-TO-KNOW ACT OF 1986 (40 CFR 372). SACCHARIN
(CAS# 81-07-2). CUMENE HYDROPEROXIDE (CAS# 80-15-9). CUMENE
(CAS# 98-82-8).
CERCLA REPORTABLE QUANTITY:
CUMENE HYDROPEROXIDE (CAS# 80-15-9) 10 LBS. (4.54 KG)
CALIFORNIA PROPOSITION 65:
THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM. THIS PRODUCT CONTAINS A CHEMICAL
KNOWN IN THE STATE OF CALIFORNIA TO CAUSE CANCER.
CANADA REGULATORY INFORMATION:
CEPA DSL/NDSL STATUS:
ALL COMPONENTS ARE LISTED ON OR ARE EXEMPT FROM LISTING ON THE CANADIAN
DOMESTIC SUBSTANCES LIST.
| 16. OTHER INFORMATION | |
THIS SAFETY DATA SHEET CONTAINS CHANGES FROM THE PREVIOUS VERSION
IN SECTIONS: 14
PREPARED BY: PRODUCT SAFETY AND REGULATORY AFFAIRS
ISSUE DATE: 07/01/2022
DISCLAIMER:
THE DATA CONTAINED HEREIN ARE FURNISHED FOR INFORMATION ONLY AND ARE
BELIEVED TO BE RELIABLE. HOWEVER, HENKEL CORPORATION AND ITS AFFILIATES
("HENKEL") DOES NOT ASSUME RESPONSIBILITY FOR ANY RESULTS OBTAINED BY
PERSONS OVER WHOSE METHODS HENKEL HAS NO CONTROL. IT IS THE USER'S
RESPONSIBILITY TO DETERMINE THE SUITABILITY OF HENKEL'S PRODUCTS OR
ANY PRODUCTION METHODS MENTIONED HEREIN FOR A PARTICULAR PURPOSE, AND
TO ADOPT SUCH PRECAUTIONS AS MAY BE ADVISABLE FOR THE PROTECTION OF
PROPERTY AND PERSONS AGAINST ANY HAZARDS THAT MAY BE INVOLVED IN THE
HANDLING AND USE OF ANY HENKEL'S PRODUCTS. IN LIGHT OF THE FOREGOING,
HENKEL SPECIFICALLY DISCLAIMS ALL WARRANTIES, EXPRESS OR IMPLIED,
INCLUDING WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR
PURPOSE, ARISING FROM SALE OR USE OF HENKEL'S PRODUCTS. HENKEL
FURTHER DISCLAIMS ANY LIABILITY FOR CONSEQUENTIAL OR INCIDENTAL
DAMAGES OF ANY KIND, INCLUDING LOST PROFITS.
THIS SAFETY DATA SHEET HAS BEEN GENERATED BASED ON OSHA HAZARD
COMMUNICATION STANDARD (29 CFR 1910.1200) AND PROVIDES INFORMATION
IN ACCORDANCE WITH U.S. FEDERAL LAW ONLY. NO WARRANTY OR
REPRESENTATION OF ANY KIND IS GIVEN WITH RESPECT TO THE SUBSTANTIVE
OR EXPORT LAWS OF ANY OTHER JURISDICTION OR COUNTRY. PLEASE CONFIRM
THAT THE INFORMATION PROVIDED HEREIN CONFORMS TO THE SUBSTANTIVE
EXPORT OR OTHER LAW OF ANY OTHER JURISDICTION PRIOR TO EXPORT.
PLEASE CONTACT HENKEL PRODUCT SAFETY AND REGULATORY AFFAIRS FOR
ADDITIONAL ASSISTANCE.