| Common Name: | LOCTITE SI 5011CL NON-CORROSIVE RTV CLEAR SIL. KNOWN AS NON CORROS CLEAR RTV 300 |
| Manufacturer: | HENKEL |
| SDS Revision Date: | 1/4/2023 |
| SDS Format: | No Format Specified |
| Item Number(s): | 12Z244 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
HENKEL
SAFETY DATA SHEET
REVISION NUMBER: 007.0
ISSUE DATE: 01/04/2023
| 1. PRODUCT AND COMPANY IDENTIFICATION |  |
PRODUCT NAME:
LOCTITE SI 5011CL NON-CORROSIVE RTV CLEAR SIL. KNOWN AS NON CORROS CLEAR
RTV 300ML CQ,
IDH NUMBER: 234325
PRODUCT TYPE/USE: SILICONE
ITEM NUMBER: 51388
RESTRICTION OF USE: NONE IDENTIFIED
REGION: UNITED STATES
COMPANY ADDRESS:
HENKEL CORPORATION
ONE HENKEL WAY
ROCKY HILL, CONNECTICUT 06067
CONTACT INFORMATION:
TELEPHONE: +1 (860) 571-5100
MEDICAL EMERGENCY PHONE:
POISON CONTROL CENTER: 1-877-671-4608 (TOLL FREE) OR 1-303-592-1711
TRANSPORT EMERGENCY PHONE:
CHEMTREC: 1-800-424-9300 (TOLL FREE) OR 1-703-527-3887
INTERNET: WWW.HENKELNA.COM
| 2. HAZARDS IDENTIFICATION | |
EMERGENCY OVERVIEW:
WARNING:
COMBUSTIBLE LIQUID.
CAUSES SKIN IRRITATION.
MAY CAUSE AN ALLERGIC SKIN REACTION.
CAUSES SERIOUS EYE IRRITATION.
HAZARD CLASS HAZARD CATEGORY
FLAMMABLE LIQUID 4
SKIN IRRITATION 2
EYE IRRITATION 2A
SKIN SENSITIZATION 1
PICTOGRAM(S): EXCLAMATION MARK
PRECAUTIONARY STATEMENTS:
PREVENTION:
KEEP AWAY FROM HEAT, SPARKS, OPEN FLAMES, HOT SURFACES - NO SMOKING. AVOID
BREATHING VAPORS, MIST, OR SPRAY. WASH AFFECTED AREA THOROUGHLY AFTER
HANDLING. CONTAMINATED WORK CLOTHING SHOULD NOT BE ALLOWED OUT OF THE
WORKPLACE. WEAR PROTECTIVE GLOVES, EYE PROTECTION, AND FACE PROTECTION.
RESPONSE:
IF ON SKIN: WASH WITH PLENTY OF WATER.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
IF SKIN IRRITATION OR RASH OCCURS: GET MEDICAL ATTENTION.
IF EYE IRRITATION PERSISTS: GET MEDICAL ATTENTION.
TAKE OFF CONTAMINATED CLOTHING.
IN CASE OF FIRE: USE FOAM, DRY CHEMICAL OR CARBON DIOXIDE TO EXTINGUISH.
STORAGE: STORE IN A WELL-VENTILATED PLACE. KEEP COOL.
DISPOSAL:
DISPOSE OF CONTENTS AND/OR CONTAINER ACCORDING TO FEDERAL, STATE/PROVINCIAL
AND LOCAL GOVERNMENTAL REGULATIONS.
CLASSIFICATION COMPLIES WITH OSHA HAZARD COMMUNICATION STANDARD (29 CFR
1910.1200) AND IS CONSISTENT WITH THE PROVISIONS OF THE UNITED NATIONS
GLOBALLY HARMONIZED SYSTEM OF CLASSIFICATION AND LABELING OF CHEMICALS
(GHS).
SEE SECTION 11 FOR ADDITIONAL TOXICOLOGICAL INFORMATION.
| 3. COMPOSITION / INFORMATION ON INGREDIENTS | |
HAZARDOUS COMPONENT(S) CAS NUMBER PERCENTAGE*
SILICONE RESIN PROPRIETARY 30 - 60
SILICA, AMORPHOUS, FUMED, CRYSTAL-FREE 112945-52-5 10 - 20
SILANE DERIVATIVE PROPRIETARY 10 - 20
OXIMINO SILANE PROPRIETARY 10 - 20
* EXACT PERCENTAGES MAY VARY OR ARE TRADE SECRET. CONCENTRATION RANGE
IS PROVIDED TO ASSIST USERS IN PROVIDING APPROPRIATE PROTECTIONS.
| 4. FIRST AID MEASURES | |
INHALATION:
MOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. IF SYMPTOMS DEVELOP AND PERSIST,
GET MEDICAL ATTENTION.
SKIN CONTACT:
WIPE OFF PASTE WITH PAPER TOWEL OR CLOTH. WASH WITH SOAP AND WATER.
IF SYMPTOMS DEVELOP AND PERSIST, GET MEDICAL ATTENTION.
EYE CONTACT:
RINSE IMMEDIATELY WITH PLENTY OF WATER, ALSO UNDER THE EYELIDS, FOR AT
LEAST 15 MINUTES. IF EYE IRRITATION PERSISTS, CONSULT A SPECIALIST.
INGESTION: DO NOT INDUCE VOMITING. GET MEDICAL ATTENTION.
SYMPTOMS: SEE SECTION 11.
| 5. FIRE FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
USE EXTINGUISHING MEASURES APPROPRIATE TO LOCAL CIRCUMSTANCES AND THE
SURROUNDING ENVIRONMENT.
SPECIAL FIREFIGHTING PROCEDURES:
WEAR SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING, SUCH
AS TURN-OUT GEAR.
UNUSUAL FIRE OR EXPLOSION HAZARDS: NONE
HAZARDOUS COMBUSTION PRODUCTS:
OXIDES OF CARBON, OXIDES OF NITROGEN, IRRITATING ORGANIC VAPORS.
FORMALDEHYDE.
| 6. ACCIDENTAL RELEASE MEASURES | |
USE PERSONAL PROTECTION RECOMMENDED IN SECTION 8, ISOLATE THE HAZARD AREA
AND DENY ENTRY TO UNNECESSARY AND UNPROTECTED PERSONNEL.
ENVIRONMENTAL PRECAUTIONS:
DO NOT ALLOW MATERIAL TO CONTAMINATE GROUND WATER SYSTEM.
CLEAN-UP METHODS:
MAINTAIN GOOD VENTILATION FOR LARGE SPILLS. SPILLED MATERIAL WILL SOLIDIFY.
SCRAPE UP AS MUCH MATERIAL AS POSSIBLE. CLEAN RESIDUE WITH SOAP AND WATER.
STORE IN A PARTLY FILLED, CLOSED CONTAINER UNTIL DISPOSAL.
| 7. HANDLING AND STORAGE | |
HANDLING:
PREVENT CONTACT WITH EYES, SKIN AND CLOTHING. DO NOT BREATHE VAPOR AND
MIST. WASH THOROUGHLY AFTER HANDLING. USE ONLY IN AREA PROVIDED WITH
APPROPRIATE EXHAUST VENTILATION. DO NOT WEAR CONTACT LENSES.
STORAGE:
KEEP IN A COOL, WELL VENTILATED AREA AWAY FROM HEAT, SPARKS AND OPEN FLAME.
KEEP CONTAINER TIGHTLY CLOSED UNTIL READY FOR USE.
| 8. EXPOSURE CONTROLS / PERSONAL PROTECTION | |
EMPLOYERS SHOULD COMPLETE AN ASSESSMENT OF ALL WORKPLACES TO DETERMINE THE
NEED FOR, AND SELECTION OF, PROPER EXPOSURE CONTROLS AND PROTECTIVE
EQUIPMENT FOR EACH TASK PERFORMED.
HAZARDOUS COMPONENT(S) ACGIH TLV OSHA PEL AIHA WEEL OTHER
SILICONE RESIN NONE NONE NONE NONE
SILICA, AMORPHOUS, FUMED, 10 MG/M3 TWA 20 MPPCF TWA NONE NONE
CRYSTAL-FREE INHALABLE DUST. 0.8 MG/M3 TWA
3 MG/M3 TWA 50 MPPCF TWA
RESPIRABLE TOTAL DUST.
FRACTION.
5 MG/M3 TWA
3 MG/M3 TWA RESPIRABLE
RESPIRABLE FRACTION.
PARTICLES.
15 MG/M3 TWA
10 MG/M3 TWA TOTAL DUST.
INHALABLE
PARTICLES. 15 MPPCF TWA
RESPIRABLE
FRACTION.
SILANE DERIVATIVE NONE NONE NONE NONE
OXIMINO SILANE NONE NONE NONE NONE
ENGINEERING CONTROLS:
PROVIDE ADEQUATE LOCAL EXHAUST VENTILATION TO MAINTAIN WORKER EXPOSURE
BELOW EXPOSURE LIMITS.
RESPIRATORY PROTECTION:
USE A NIOSH APPROVED SUPPLIED AIR RESPIRATOR IF THE POTENTIAL TO EXCEED
ESTABLISHED EXPOSURE LIMITS EXISTS.
EYE/FACE PROTECTION: SAFETY GOGGLES OR SAFETY GLASSES WITH SIDE SHIELDS.
SKIN PROTECTION:
USE IMPERMEABLE GLOVES AND PROTECTIVE CLOTHING AS NECESSARY TO PREVENT
SKIN CONTACT.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
PHYSICAL STATE: PASTE
COLOR: TRANSLUCENT
ODOR: SLIGHT, ALCOHOLIC
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT APPLICABLE
VAPOR PRESSURE: NOT AVAILABLE.
BOILING POINT/RANGE: >149 DEG. C (>300.2 DEG. F)
MELTING POINT/ RANGE: NOT APPLICABLE
SPECIFIC GRAVITY: 1.0399
VAPOR DENSITY: NOT AVAILABLE.
FLASH POINT: 89 DEG. C (192.2 DEG. F) ASTM D3278 SETAFLASH CLOSED CUP
FLAMMABLE/EXPLOSIVE LIMITS - LOWER: NOT APPLICABLE
FLAMMABLE/EXPLOSIVE LIMITS - UPPER: NOT APPLICABLE
AUTOIGNITION TEMPERATURE: NOT APPLICABLE
FLAMMABILITY: NOT APPLICABLE
EVAPORATION RATE: NOT APPLICABLE
SOLUBILITY IN WATER: NOT SOLUBLE. POLYMERIZES IN PRESENCE OF WATER.
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
VOC CONTENT: 1.69 %; 55.3 G/L
VISCOSITY: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
| 10. STABILITY AND REACTIVITY | |
STABILITY: STABLE UNDER NORMAL CONDITIONS OF STORAGE AND USE.
HAZARDOUS REACTIONS:
NONE UNDER NORMAL PROCESSING. POLYMERIZATION MAY OCCUR AT ELEVATED
TEMPERATURE OR IN THE PRESENCE OF INCOMPATIBLE MATERIALS.
HAZARDOUS DECOMPOSITION PRODUCTS:
OXIDES OF CARBON. OXIDES OF NITROGEN. FORMALDEHYDE. AMMONIA. CONTACT WITH
WATER LIBERATES METHANOL.
INCOMPATIBLE MATERIALS: POLYMERIZES ON CONTACT WITH WATER.
REACTIVITY: NOT AVAILABLE.
CONDITIONS TO AVOID: EXCESSIVE HEAT.
| 11. TOXICOLOGICAL INFORMATION | |
RELEVANT ROUTES OF EXPOSURE: SKIN, INHALATION, EYES, INGESTION
POTENTIAL HEALTH EFFECTS/SYMPTOMS:
INHALATION:
INHALATION OF VAPORS FROM UNCURED SEALANT MAY CAUSE RESPIRATORY TRACT
IRRITATION. WHEN HEATED TO TEMPERATURES EXCEEDING 300 DEG. F (150 DEG. C)
IN THE PRESENCE OF AIR, SILICONES MAY FORM FORMALDEHYDE VAPORS.
FORMALDEHYDE IS A POTENTIAL CANCER HAZARD AND A KNOWN SKIN AND RESPIRATORY
SENSITIZER. VAPORS IRRITATE THE EYES, NOSE AND THROAT. SAFE HANDLING
CONDITIONS MAY BE MAINTAINED BY KEEPING FORMALDEHYDE VAPOR CONCENTRATIONS
BELOW THE OSHA PERMISSIBLE LIMIT.
SKIN CONTACT: CAUSES SKIN IRRITATION. MAY CAUSE ALLERGIC SKIN REACTION.
EYE CONTACT: CAUSES SERIOUS EYE IRRITATION.
INGESTION:
NOT EXPECTED UNDER NORMAL CONDITIONS OF USE. MAY CAUSE GASTROINTESTINAL
TRACT IRRITATION IF SWALLOWED.
HAZARDOUS COMPONENT(S) LD50S AND LC50S IMMEDIATE AND DELAYED
HEALTH EFFECTS
SILICONE RESIN NONE IRRITANT
SILICA, AMORPHOUS, NONE NUISANCE DUST
FUMED, CRYSTAL-FREE
SILANE DERIVATIVE INHALATION LC50 IRRITANT, ALLERGEN
(RAT, 4 H):
>1.49 - <2.44 MG/L
OXIMINO SILANE NONE IRRITANT, ALLERGEN
HAZARDOUS COMPONENT(S) NTP CARCINOGEN IARC CARCINOGEN OSHA CARCINOGEN
(SPECIFICALLY
REGULATED)
SILICONE RESIN NO NO NO
SILICA, AMORPHOUS, NO NO NO
FUMED, CRYSTAL-FREE
SILANE DERIVATIVE NO NO NO
OXIMINO SILANE NO NO NO
| 12. ECOLOGICAL INFORMATION | |
ECOLOGICAL INFORMATION: NOT AVAILABLE.
| 13. DISPOSAL CONSIDERATIONS | |
INFORMATION PROVIDED IS FOR UNUSED PRODUCT ONLY.
RECOMMENDED METHOD OF DISPOSAL:
FOLLOW ALL LOCAL, STATE, FEDERAL AND PROVINCIAL REGULATIONS FOR DISPOSAL.
CURED RUBBER CAN BE INCINERATED OR LANDFILLED FOLLOWING EPA AND LOCAL
REGULATIONS.
| 14. TRANSPORT INFORMATION | |
THE TRANSPORT INFORMATION PROVIDED IN THIS SECTION ONLY APPLIES TO THE
MATERIAL/FORMULATION ITSELF, AND IS NOT SPECIFIC TO ANY PACKAGE/
CONFIGURATION.
U.S. DEPARTMENT OF TRANSPORTATION GROUND (49 CFR):
PROPER SHIPPING NAME: COMBUSTIBLE LIQUID, N.O.S. (POLYDIMETHYLSILOXANE)
HAZARD CLASS OR DIVISION: COMBUSTIBLE LIQUID
IDENTIFICATION NUMBER: NA 1993
PACKING GROUP: III
INTERNATIONAL AIR TRANSPORTATION (ICAO/IATA):
PROPER SHIPPING NAME: NOT REGULATED
HAZARD CLASS OR DIVISION: NONE
IDENTIFICATION NUMBER: NONE
PACKING GROUP: NONE
WATER TRANSPORTATION (IMO/IMDG):
PROPER SHIPPING NAME: NOT REGULATED
HAZARD CLASS OR DIVISION: NONE
IDENTIFICATION NUMBER: NONE
PACKING GROUP: NONE
| 15. REGULATORY INFORMATION | |
UNITED STATES REGULATORY INFORMATION:
TSCA 8 (B) INVENTORY STATUS:
ALL COMPONENTS ARE LISTED AS ACTIVE OR ARE EXEMPT FROM LISTING ON THE
TOXIC SUBSTANCES CONTROL ACT (TSCA) INVENTORY.
TSCA 12 (B) EXPORT NOTIFICATION: NONE ABOVE REPORTING DE MINIMIS
CERCLA/SARA SECTION 302 EHS: NONE ABOVE REPORTING DE MINIMIS.
CERCLA/SARA SECTION 311/312: IMMEDIATE HEALTH, DELAYED HEALTH
CERCLA/SARA SECTION 313: NONE ABOVE REPORTING DE MINIMIS.
CALIFORNIA PROPOSITION 65:
THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
CANADA REGULATORY INFORMATION:
CEPA DSL/NDSL STATUS:
ALL COMPONENTS ARE LISTED ON OR ARE EXEMPT FROM LISTING ON THE CANADIAN
DOMESTIC SUBSTANCES LIST.
| 16. OTHER INFORMATION | |
THIS SAFETY DATA SHEET CONTAINS CHANGES FROM THE PREVIOUS VERSION IN
SECTIONS: 2,8,9,10,11,13,14
PREPARED BY: PRODUCT SAFETY AND REGULATORY AFFAIRS
ISSUE DATE: 01/04/2023
DISCLAIMER:
THE DATA CONTAINED HEREIN ARE FURNISHED FOR INFORMATION ONLY AND ARE
BELIEVED TO BE RELIABLE. HOWEVER, HENKEL CORPORATION AND ITS AFFILIATES
("HENKEL") DOES NOT ASSUME RESPONSIBILITY FOR ANY RESULTS OBTAINED BY
PERSONS OVER WHOSE METHODS HENKEL HAS NO CONTROL. IT IS THE USER'S
RESPONSIBILITY TO DETERMINE THE SUITABILITY OF HENKEL'S PRODUCTS OR ANY
PRODUCTION METHODS MENTIONED HEREIN FOR A PARTICULAR PURPOSE, AND TO ADOPT
SUCH PRECAUTIONS AS MAY BE ADVISABLE FOR THE PROTECTION OF PROPERTY AND
PERSONS AGAINST ANY HAZARDS THAT MAY BE INVOLVED IN THE HANDLING AND USE
OF ANY HENKEL'S PRODUCTS. IN LIGHT OF THE FOREGOING, HENKEL SPECIFICALLY
DISCLAIMS ALL WARRANTIES, EXPRESS OR IMPLIED, INCLUDING WARRANTIES OF
MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE, ARISING FROM SALE OR
USE OF HENKEL'S PRODUCTS. HENKEL FURTHER DISCLAIMS ANY LIABILITY FOR
CONSEQUENTIAL OR INCIDENTAL DAMAGES OF ANY KIND, INCLUDING LOST PROFITS.
THIS SAFETY DATA SHEET HAS BEEN GENERATED BASED ON OSHA HAZARD
COMMUNICATION STANDARD (29 CFR 1910.1200) AND PROVIDES INFORMATION IN
ACCORDANCE WITH U.S. FEDERAL LAW ONLY. NO WARRANTY OR REPRESENTATION OF
ANY KIND IS GIVEN WITH RESPECT TO THE SUBSTANTIVE OR EXPORT LAWS OF ANY
OTHER JURISDICTION OR COUNTRY. PLEASE CONFIRM THAT THE INFORMATION
PROVIDED HEREIN CONFORMS TO THE SUBSTANTIVE EXPORT OR OTHER LAW OF ANY
OTHER JURISDICTION PRIOR TO EXPORT. PLEASE CONTACT HENKEL PRODUCT SAFETY
AND REGULATORY AFFAIRS FOR ADDITIONAL ASSISTANCE.