| Common Name: | BRAKLEEN BRAKE PARTS CLEANER NO. 05151 (ITEM 1003740) |
| Manufacturer: | CRC INDUSTRIES |
| SDS Revision Date: | 4/5/2018 |
| SDS Format: | GHS-US |
| Item Number(s): | 19MX51 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
CRC(R*)
SAFETY DATA SHEET
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFIER: BRAKLEEN(R*) BRAKE PARTS CLEANER
OTHER MEANS OF IDENTIFICATION:
PRODUCT CODE: NO. 05151 (ITEM# 1003740)
RECOMMENDED USE: BRAKE PARTS CLEANER
RECOMMENDED RESTRICTIONS: NONE KNOWN.
MANUFACTURER/IMPORTER/SUPPLIER/DISTRIBUTOR INFORMATION:
MANUFACTURED OR SOLD BY:
COMPANY NAME: CRC INDUSTRIES, INC.
ADDRESS:
885 LOUIS DR.
WARMINSTER, PA 18974
US
TELEPHONE:
GENERAL INFORMATION: 215-674-4300
TECHNICAL ASSISTANCE: 800-521-3168
CUSTOMER SERVICE: 800-272-4620
24-HOUR EMERGENCY (CHEMTREC):
800-424-9300 (US)
703-527-3887 (INTERNATIONAL)
WEBSITE: WWW.CRCINDUSTRIES.COM
| 2. HAZARD(S) IDENTIFICATION | |
PHYSICAL HAZARDS:
FLAMMABLE AEROSOLS: CATEGORY 1
GASES UNDER PRESSURE: COMPRESSED GAS
HEALTH HAZARDS:
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 2A
REPRODUCTIVE TOXICITY (THE UNBORN CHILD): CATEGORY 2
SPECIFIC TARGET ORGAN TOXICITY, SINGLE EXPOSURE:
CATEGORY 3 NARCOTIC EFFECTS
SPECIFIC TARGET ORGAN TOXICITY, REPEATED EXPOSURE:
CATEGORY 2 (CENTRAL NERVOUS SYSTEM, KIDNEY, PERIPHERAL NERVOUS SYSTEM)
ENVIRONMENTAL HAZARDS:
HAZARDOUS TO THE AQUATIC ENVIRONMENT, ACUTE HAZARD: CATEGORY 3
OSHA DEFINED HAZARDS: NOT CLASSIFIED.
LABEL ELEMENTS:
FLAME
GAS CYLINDER
HEALTH HAZARD
EXCLAMATION MARK
SIGNAL WORD: DANGER
HAZARD STATEMENT:
EXTREMELY FLAMMABLE AEROSOL. CONTAINS GAS UNDER PRESSURE; MAY EXPLODE IF
HEATED. CAUSES SERIOUS EYE IRRITATION. MAY CAUSE DROWSINESS OR DIZZINESS.
SUSPECTED OF DAMAGING THE UNBORN CHILD. MAY CAUSE DAMAGE TO ORGANS (CENTRAL
NERVOUS SYSTEM, KIDNEY, PERIPHERAL NERVOUS SYSTEM) THROUGH PROLONGED OR
REPEATED EXPOSURE. HARMFUL TO AQUATIC LIFE.
PRECAUTIONARY STATEMENT:
PREVENTION:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. KEEP AWAY FROM HEAT/SPARKS/OPEN
FLAMES/HOT SURFACES. - NO SMOKING. DO NOT SPRAY ON AN OPEN FLAME OR OTHER
IGNITION SOURCE.
PRESSURIZED CONTAINER:
DO NOT PIERCE OR BURN, EVEN AFTER USE. DO NOT BREATHE MIST OR VAPOR. DO NOT
APPLY WHILE EQUIPMENT IS ENERGIZED. EXTINGUISH ALL FLAMES, PILOT LIGHTS,
AND HEATERS. VAPORS WILL ACCUMULATE READILY AND MAY IGNITE. USE ONLY WITH
ADEQUATE VENTILATION; MAINTAIN VENTILATION DURING USE AND UNTIL ALL VAPORS
ARE GONE. OPEN DOORS AND WINDOWS OR USE OTHER MEANS TO ENSURE A FRESH AIR
SUPPLY DURING USE AND WHILE PRODUCT IS DRYING. IF YOU EXPERIENCE ANY
SYMPTOMS LISTED ON THIS LABEL, INCREASE VENTILATION OR LEAVE THE AREA. WASH
THOROUGHLY AFTER HANDLING. WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE
PROTECTION/FACE PROTECTION. AVOID RELEASE TO THE ENVIRONMENT.
RESPONSE:
IF INHALED:
REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING. CALL A
POISON CENTER/DOCTOR IF YOU FEEL UNWELL.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
IF EXPOSED OR CONCERNED: GET MEDICAL ADVICE/ATTENTION.
STORAGE:
STORE IN A WELL-VENTILATED PLACE. STORE LOCKED UP. PROTECT FROM SUNLIGHT.
DO NOT EXPOSE TO TEMPERATURES EXCEEDING 50 DEG. C/122 DEG. F. EXPOSURE TO
HIGH TEMPERATURE MAY CAUSE CAN TO BURST.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH LOCAL/REGIONAL/NATIONAL
REGULATIONS.
HAZARD(S) NOT OTHERWISE CLASSIFIED (HNOC):
STATIC ACCUMULATING FLAMMABLE LIQUID CAN BECOME ELECTROSTATICALLY CHARGED
EVEN IN BONDED AND GROUNDED EQUIPMENT. SPARKS MAY IGNITE LIQUID AND VAPOR.
MAY CAUSE FLASH FIRE OR EXPLOSION.
SUPPLEMENTAL INFORMATION: NONE.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
MIXTURES:
CHEMICAL NAME COMMON NAME AND SYNONYMS CAS NUMBER %
ACETONE 67-64-1 80 - 90
CARBON DIOXIDE 124-38-9 10 - 20
TOLUENE 108-88-3 1 - 3
SPECIFIC CHEMICAL IDENTITY AND/OR PERCENTAGE OF COMPOSITION HAS BEEN
WITHHELD AS A TRADE SECRET.
| 4. FIRST-AID MEASURES | |
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
SKIN CONTACT:
WASH OFF WITH SOAP AND WATER. GET MEDICAL ATTENTION IF IRRITATION DEVELOPS
AND PERSISTS.
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. REMOVE
CONTACT LENSES, IF PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
INGESTION:
IN THE UNLIKELY EVENT OF SWALLOWING CONTACT A PHYSICIAN OR POISON CONTROL
CENTER. RINSE MOUTH.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE DELAYED:
MAY CAUSE DROWSINESS AND DIZZINESS. NARCOSIS. HEADACHE. NAUSEA, VOMITING.
BEHAVIORAL AND CHANGES. DECREASE IN MOTOR FUNCTIONS. SEVERE EYE IRRITATION.
SYMPTOMS MAY INCLUDE STINGING, TEARING, REDNESS, SWELLING, AND BLURRED
VISION. EDEMA. PROLONGED EXPOSURE MAY CAUSE CHRONIC EFFECTS.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
PROVIDE GENERAL SUPPORTIVE MEASURES AND TREAT SYMPTOMATICALLY. KEEP VICTIM
UNDER OBSERVATION. SYMPTOMS MAY BE DELAYED.
GENERAL INFORMATION:
IF EXPOSED OR CONCERNED:
GET MEDICAL ADVICE/ATTENTION. ENSURE THAT MEDICAL PERSONNEL ARE AWARE OF
THE MATERIAL(S) INVOLVED, AND TAKE PRECAUTIONS TO PROTECT THEMSELVES. SHOW
THIS SAFETY DATA SHEET TO THE DOCTOR IN ATTENDANCE.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
WATER FOG. ALCOHOL RESISTANT FOAM. CARBON DIOXIDE (CO2). DRY CHEMICAL
POWDER, CARBON DIOXIDE, SAND OR EARTH MAY BE USED FOR SMALL FIRES ONLY.
UNSUITABLE EXTINGUISHING MEDIA:
DO NOT USE WATER JET AS AN EXTINGUISHER, AS THIS WILL SPREAD THE FIRE.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
CONTENTS UNDER PRESSURE. PRESSURIZED CONTAINER MAY RUPTURE WHEN EXPOSED
TO HEAT OR FLAME. THIS PRODUCT IS A POOR CONDUCTOR OF ELECTRICITY AND CAN
BECOME ELECTROSTATICALLY CHARGED. IF SUFFICIENT CHARGE IS ACCUMULATED,
IGNITION OF FLAMMABLE MIXTURES CAN OCCUR. STATIC ELECTRICITY ACCUMULATION
MAY BE SIGNIFICANTLY INCREASED BY THE PRESENCE OF SMALL QUANTITIES OF WATER
OR OTHER CONTAMINANTS. MATERIAL WILL FLOAT AND MAY IGNITE ON SURFACE OF
WATER. DURING FIRE, GASES HAZARDOUS TO HEALTH MAY BE FORMED.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
FIREFIGHTERS MUST USE STANDARD PROTECTIVE EQUIPMENT INCLUDING FLAME
RETARDANT COAT, HELMET WITH FACE SHIELD, GLOVES, RUBBER BOOTS, AND IN
ENCLOSED SPACES, SCBA.
FIRE-FIGHTING EQUIPMENT/INSTRUCTIONS:
IN CASE OF FIRE:
STOP LEAK IF SAFE TO DO SO. MOVE CONTAINERS FROM FIRE AREA IF YOU CAN DO
SO WITHOUT RISK. CONTAINERS SHOULD BE COOLED WITH WATER TO PREVENT VAPOR
PRESSURE BUILD UP.
GENERAL FIRE HAZARDS:
EXTREMELY FLAMMABLE AEROSOL. CONTENTS UNDER PRESSURE. PRESSURIZED CONTAINER
MAY RUPTURE WHEN EXPOSED TO HEAT OR FLAME.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
KEEP UNNECESSARY PERSONNEL AWAY. KEEP PEOPLE AWAY FROM AND UPWIND OF
SPILL/LEAK. REMOVE ALL POSSIBLE SOURCES OF IGNITION IN THE SURROUNDING
AREA. KEEP OUT OF LOW AREAS. MANY GASES ARE HEAVIER THAN AIR AND WILL
SPREAD ALONG GROUND AND COLLECT IN LOW OR CONFINED AREAS (SEWERS,
BASEMENTS, TANKS). WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND CLOTHING
DURING CLEAN-UP. DO NOT BREATHE MIST OR VAPOR. EMERGENCY PERSONNEL NEED
SELF-CONTAINED BREATHING EQUIPMENT. DO NOT TOUCH DAMAGED CONTAINERS OR
SPILLED MATERIAL UNLESS WEARING APPROPRIATE PROTECTIVE CLOTHING. VENTILATE
CLOSED SPACES BEFORE ENTERING THEM. USE APPROPRIATE CONTAINMENT TO AVOID
ENVIRONMENTAL CONTAMINATION. LOCAL AUTHORITIES SHOULD BE ADVISED IF
SIGNIFICANT SPILLAGES CANNOT BE CONTAINED. FOR PERSONAL PROTECTION, SEE
SECTION 8 OF THE SDS.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
ELIMINATE ALL IGNITION SOURCES (NO SMOKING, FLARES, SPARKS, OR FLAMES IN
IMMEDIATE AREA). KEEP COMBUSTIBLES (WOOD, PAPER, OIL, ETC.) AWAY FROM
SPILLED MATERIAL. THIS PRODUCT IS MISCIBLE IN WATER. PREVENT PRODUCT FROM
ENTERING DRAINS. STOP THE FLOW OF MATERIAL, IF THIS IS WITHOUT RISK. WIPE
UP WITH ABSORBENT MATERIAL (E.G. CLOTH, FLEECE). CLEAN SURFACE THOROUGHLY
TO REMOVE RESIDUAL CONTAMINATION. FOR WASTE DISPOSAL, SEE SECTION 13 OF THE
SDS.
ENVIRONMENTAL PRECAUTIONS:
AVOID RELEASE TO THE ENVIRONMENT. INFORM APPROPRIATE MANAGERIAL OR
SUPERVISORY PERSONNEL OF ALL ENVIRONMENTAL RELEASES. PREVENT FURTHER
LEAKAGE OR SPILLAGE IF SAFE TO DO SO. AVOID DISCHARGE INTO DRAINS, WATER
COURSES OR ONTO THE GROUND. USE APPROPRIATE CONTAINMENT TO AVOID
ENVIRONMENTAL CONTAMINATION.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. MINIMIZE FIRE RISKS FROM
FLAMMABLE AND COMBUSTIBLE MATERIALS (INCLUDING COMBUSTIBLE DUST AND STATIC
ACCUMULATING LIQUIDS) OR DANGEROUS REACTIONS WITH INCOMPATIBLE MATERIALS.
PRESSURIZED CONTAINER:
DO NOT PIERCE OR BURN, EVEN AFTER USE. DO NOT USE IF SPRAY BUTTON IS
MISSING OR DEFECTIVE. DO NOT SPRAY ON A NAKED FLAME OR ANY OTHER
INCANDESCENT MATERIAL. DO NOT SMOKE WHILE USING OR UNTIL SPRAYED SURFACE
IS THOROUGHLY DRY. DO NOT CUT, WELD, SOLDER, DRILL, GRIND, OR EXPOSE
CONTAINERS TO HEAT, FLAME, SPARKS, OR OTHER SOURCES OF IGNITION. USE
CAUTION AROUND ENERGIZED EQUIPMENT. THE METAL CONTAINER WILL CONDUCT
ELECTRICITY IF IT CONTACTS A LIVE SOURCE. THIS MAY RESULT IN INJURY TO THE
USER FROM ELECTRICAL SHOCK AND/OR FLASH FIRE. DO NOT BREATHE MIST OR VAPOR.
AVOID CONTACT WITH EYES. AVOID PROLONGED EXPOSURE. PREGNANT OR
BREASTFEEDING WOMEN MUST NOT HANDLE THIS PRODUCT. SHOULD BE HANDLED IN
CLOSED SYSTEMS, IF POSSIBLE. USE ONLY IN WELL-VENTILATED AREAS. WEAR
APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT. AVOID RELEASE TO THE
ENVIRONMENT. OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES. FOR PRODUCT USAGE
INSTRUCTIONS, SEE THE PRODUCT LABEL.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
LEVEL 3 AEROSOL.
PRESSURIZED CONTAINER. PROTECT FROM SUNLIGHT AND DO NOT EXPOSE TO
TEMPERATURES EXCEEDING 50 DEG. C/122 DEG. F. DO NOT PUNCTURE, INCINERATE
OR CRUSH. DO NOT HANDLE OR STORE NEAR AN OPEN FLAME, HEAT OR OTHER SOURCES
OF IGNITION. THIS MATERIAL CAN ACCUMULATE STATIC CHARGE WHICH MAY CAUSE
SPARK AND BECOME AN IGNITION SOURCE. AVOID SPARK PROMOTERS. THESE ALONE MAY
BE INSUFFICIENT TO REMOVE STATIC ELECTRICITY. STORE IN A WELL-VENTILATED
PLACE. STORED CONTAINERS SHOULD BE PERIODICALLY CHECKED FOR GENERAL
CONDITION AND LEAKAGE. STORE AWAY FROM INCOMPATIBLE MATERIALS (SEE SECTION
10 OF THE SDS).
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
OCCUPATIONAL EXPOSURE LIMITS:
US. OSHA TABLE Z-1 LIMITS FOR AIR CONTAMINANTS (29 CFR 1910.1000):
COMPONENTS TYPE VALUE
ACETONE (CAS 67-64-1) PEL 2400 MG/M3
1000 PPM
CARBON DIOXIDE (CAS 124-38-9) PEL 9000 MG/M3
5000 PPM
US. OSHA TABLE Z-2 (29 CFR 1910.1000):
COMPONENTS TYPE VALUE
TOLUENE (CAS 108-88-3) CEILING 300 PPM
TWA 200 PPM
US. ACGIH THRESHOLD LIMIT VALUES:
COMPONENTS TYPE VALUE
ACETONE (CAS 67-64-1) STEL 500 PPM
TWA 250 PPM
CARBON DIOXIDE (CAS 124-38-9) STEL 30000 PPM
TWA 5000 PPM
TOLUENE (CAS 108-88-3) TWA 20 PPM
US. NIOSH: POCKET GUIDE TO CHEMICAL HAZARDS
COMPONENTS TYPE VALUE
ACETONE (CAS 67-64-1) TWA 590 MG/M3
250 PPM
CARBON DIOXIDE (CAS 124-38-9) STEL 54000 MG/M3
30000 PPM
TWA 9000 MG/M3
5000 PPM
TOLUENE (CAS 108-88-3) STEL 560 MG/M3
150 PPM
TWA 375 MG/M3
100 PPM
BIOLOGICAL LIMIT VALUES:
ACGIH BIOLOGICAL EXPOSURE INDICES:
COMPONENTS VALUE DETERMINANT SPECIMEN SAMPLING TIME
ACETONE 25 MG/L ACETONE URINE *
(CAS 67-64-1)
TOLUENE 0.3 MG/G O-CRESOL, WITH CREATININE *
(CAS 108-88-3) HYDROLYSIS IN URINE
0.03 MG/L TOLUENE URINE *
0.02 MG/L TOLUENE BLOOD *
* - FOR SAMPLING DETAILS, PLEASE SEE THE SOURCE DOCUMENT.
EXPOSURE GUIDELINES:
US - CALIFORNIA OELS SKIN DESIGNATION
TOLUENE (CAS 108-88-3) CAN BE ABSORBED THROUGH THE SKIN.
US - MINNESOTA HAZ SUBS SKIN DESIGNATION APPLIES
TOLUENE (CAS 108-88-3) SKIN DESIGNATION APPLIES.
APPROPRIATE ENGINEERING CONTROLS:
GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER HOUR) SHOULD BE
USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS. IF APPLICABLE,
USE PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING
CONTROLS TO MAINTAIN AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS.
IF EXPOSURE LIMITS HAVE NOT BEEN ESTABLISHED, MAINTAIN AIRBORNE LEVELS
TO AN ACCEPTABLE LEVEL. PROVIDE EYEWASH STATION.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION: WEAR SAFETY GLASSES WITH SIDE SHIELDS (OR GOGGLES).
SKIN PROTECTION:
HAND PROTECTION:
WEAR PROTECTIVE GLOVES SUCH AS: NITRILE. NEOPRENE. POLYVINYL ALCOHOL (PVA).
OTHER: WEAR SUITABLE PROTECTIVE CLOTHING.
RESPIRATORY PROTECTION:
IF ENGINEERING CONTROLS ARE NOT FEASIBLE OR IF EXPOSURE EXCEEDS THE
APPLICABLE EXPOSURE LIMITS, USE A NIOSH-APPROVED CARTRIDGE RESPIRATOR WITH
AN ORGANIC VAPOR CARTRIDGE. USE A SELF-CONTAINED BREATHING APPARATUS IN
CONFINED SPACES AND FOR EMERGENCIES. AIR MONITORING IS NEEDED TO DETERMINE
ACTUAL EMPLOYEE EXPOSURE LEVELS.
THERMAL HAZARDS:
WEAR APPROPRIATE THERMAL PROTECTIVE CLOTHING, WHEN NECESSARY.
GENERAL HYGIENE CONSIDERATIONS:
WHEN USING DO NOT SMOKE. ALWAYS OBSERVE GOOD PERSONAL HYGIENE MEASURES,
SUCH AS WASHING AFTER HANDLING THE MATERIAL AND BEFORE EATING, DRINKING,
AND/OR SMOKING. ROUTINELY WASH WORK CLOTHING AND PROTECTIVE EQUIPMENT TO
REMOVE CONTAMINANTS.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: LIQUID.
FORM: AEROSOL.
COLOR: COLORLESS.
ODOR: SWEET.
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
MELTING POINT/FREEZING POINT: -138.8 DEG. F (-94.9 DEG. C) ESTIMATED
INITIAL BOILING POINT AND BOILING RANGE:
132.9 DEG. F (56.1 DEG. C) ESTIMATED
FLASH POINT: <0 DEG. F (<-17.8 DEG. C)
EVAPORATION RATE: FAST.
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS:
FLAMMABILITY LIMIT - LOWER (%): 1.2% ESTIMATED
FLAMMABILITY LIMIT - UPPER (%): 12.8% ESTIMATED
VAPOR PRESSURE: 6962 HPA ESTIMATED
VAPOR DENSITY: 2 (AIR = 1)
RELATIVE DENSITY: 0.88 ESTIMATED
SOLUBILITY(IES):
SOLUBILITY (WATER): SLIGHTLY SOLUBLE.
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: 869 DEG. F (465 DEG. C) ESTIMATED
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
PERCENT VOLATILE: 88.2% ESTIMATED
| 10. STABILITY AND REACTIVITY | |
REACTIVITY:
THE PRODUCT IS STABLE AND NON-REACTIVE UNDER NORMAL CONDITIONS OF USE,
STORAGE AND TRANSPORT.
CHEMICAL STABILITY: MATERIAL IS STABLE UNDER NORMAL CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS:
NO DANGEROUS REACTION KNOWN UNDER CONDITIONS OF NORMAL USE.
CONDITIONS TO AVOID:
HEAT, FLAMES AND SPARKS. CONTACT WITH INCOMPATIBLE MATERIALS.
INCOMPATIBLE MATERIALS: ACIDS. ALUMINUM.
HAZARDOUS DECOMPOSITION PRODUCTS: CARBON OXIDES.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INHALATION:
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE BY
INHALATION. MAY CAUSE DROWSINESS AND DIZZINESS. HEADACHE. NAUSEA, VOMITING.
SKIN CONTACT: NO ADVERSE EFFECTS DUE TO SKIN CONTACT ARE EXPECTED.
EYE CONTACT: CAUSES SERIOUS EYE IRRITATION.
INGESTION: EXPECTED TO BE A LOW INGESTION HAZARD.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
MAY CAUSE DROWSINESS AND DIZZINESS. NARCOSIS. HEADACHE. NAUSEA, VOMITING.
BEHAVIORAL CHANGES. DECREASE IN MOTOR FUNCTIONS. SEVERE EYE IRRITATION.
SYMPTOMS MAY INCLUDE STINGING, TEARING, REDNESS, SWELLING, AND BLURRED
VISION. EDEMA.
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY:
COMPONENTS SPECIES TEST RESULTS
ACETONE (CAS 67-64-1):
ACUTE:
DERMAL:
LD50 RABBIT 20000 MG/KG
ORAL:
LD50 RAT 5800 MG/KG
TOLUENE (CAS 108-88-3):
ACUTE:
INHALATION:
LC50 RAT 12.5 MG/L, 4 HOURS
SKIN CORROSION/IRRITATION:
PROLONGED SKIN CONTACT MAY CAUSE TEMPORARY IRRITATION.
SERIOUS EYE DAMAGE/EYE IRRITATION: CAUSES SERIOUS EYE IRRITATION.
RESPIRATORY OR SKIN SENSITIZATION:
RESPIRATORY SENSITIZATION: NOT A RESPIRATORY SENSITIZER.
SKIN SENSITIZATION:
THIS PRODUCT IS NOT EXPECTED TO CAUSE SKIN SENSITIZATION.
GERM CELL MUTAGENICITY:
NO DATA AVAILABLE TO INDICATE PRODUCT OR ANY COMPONENTS PRESENT AT GREATER
THAN 0.1% ARE MUTAGENIC OR GENOTOXIC.
CARCINOGENICITY: NOT CLASSIFIABLE AS TO CARCINOGENICITY TO HUMANS.
IARC MONOGRAPHS. OVERALL EVALUATION OF CARCINOGENICITY:
TOLUENE (CAS 108-88-3): 3 NOT CLASSIFIABLE AS TO CARCINOGENICITY TO HUMANS.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1052):
NOT REGULATED.
US. NATIONAL TOXICOLOGY PROGRAM (NTP) REPORT ON CARCINOGENS: NOT LISTED.
REPRODUCTIVE TOXICITY: SUSPECTED OF DAMAGING THE UNBORN CHILD.
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE:
MAY CAUSE DROWSINESS AND DIZZINESS.
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE:
MAY CAUSE DAMAGE TO ORGANS (CENTRAL NERVOUS SYSTEM, KIDNEY, PERIPHERAL
NERVOUS SYSTEM) THROUGH PROLONGED OR REPEATED EXPOSURE.
ASPIRATION HAZARD: NOT AN ASPIRATION HAZARD.
CHRONIC EFFECTS:
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
PROLONGED INHALATION MAY BE HARMFUL.
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY: HARMFUL TO AQUATIC LIFE.
COMPONENTS SPECIES TEST RESULTS
ACETONE (CAS 67-64-1):
AQUATIC:
FISH LC50 RAINBOW TROUT, DONALDSON TROUT 4740 - 6330 MG/L,
(ONCORHYNCHUS MYKISS) 96 HOURS
ACUTE:
CRUSTACEA EC50 DAPHNIA MAGNA 10294 - 17704 MG/L,
48 HOURS
TOLUENE (CAS 108-88-3):
ACUTE:
OTHER EC50 PSEUDOKIRCHNERELLA SUBCAPITATA 433 MG/L, 96 HOURS
12.5 MG/L, 72 HOURS
AQUATIC:
ACUTE:
CRUSTACEA EC50 WATER FLEA (DAPHNIA MAGNA) 6 MG/L, 48 HOURS
FISH LC50 COHO SALMON, SILVER SALMON 5.5 MG/L, 96 HOURS
(ONCORHYNCHUS KISUTCH)
PERSISTENCE AND DEGRADABILITY:
NO DATA IS AVAILABLE ON THE DEGRADABILITY OF ANY INGREDIENTS IN THE
MIXTURE.
BIOACCUMULATIVE POTENTIAL:
PARTITION COEFFICIENT N-OCTANOL / WATER (LOG KOW):
ACETONE: -0.24
TOLUENE: 2.73
BIOCONCENTRATION FACTOR (BCF):
TOLUENE: 90
MOBILITY IN SOIL: NO DATA AVAILABLE.
OTHER ADVERSE EFFECTS:
NO OTHER ADVERSE ENVIRONMENTAL EFFECTS (E.G. OZONE DEPLETION, PHOTOCHEMICAL
OZONE CREATION POTENTIAL, ENDOCRINE DISRUPTION, GLOBAL WARMING POTENTIAL)
ARE EXPECTED FROM THIS COMPONENT.
| 13. DISPOSAL CONSIDERATIONS | |
HAZARDOUS WASTE CODE:
D001: WASTE FLAMMABLE MATERIAL WITH A FLASH POINT <140 F
F003: WASTE NON-HALOGENATED SOLVENT - SPENT NON-HALOGENATED SOLVENT
CONTAMINATED PACKAGING:
SINCE EMPTIED CONTAINERS MAY RETAIN PRODUCT RESIDUE, FOLLOW LABEL WARNINGS
EVEN AFTER CONTAINER IS EMPTIED. EMPTY CONTAINERS SHOULD BE TAKEN TO AN
APPROVED WASTE HANDLING SITE FOR RECYCLING OR DISPOSAL.
DISPOSAL INSTRUCTIONS:
THIS MATERIAL AND ITS CONTAINER MUST BE DISPOSED OF AS HAZARDOUS WASTE.
COLLECT AND RECLAIM OR DISPOSE IN SEALED CONTAINERS AT LICENSED WASTE
DISPOSAL SITE. CONTENTS UNDER PRESSURE. DO NOT PUNCTURE, INCINERATE OR
CRUSH. DO NOT ALLOW THIS MATERIAL TO DRAIN INTO SEWERS/WATER SUPPLIES.
DO NOT CONTAMINATE PONDS, WATERWAYS OR DITCHES WITH CHEMICAL OR USED
CONTAINER. DISPOSE IN ACCORDANCE WITH ALL APPLICABLE REGULATIONS.
| 14. TRANSPORT INFORMATION | |
DOT:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, FLAMMABLE, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
LABEL(S): 2.1
PACKING GROUP: NOT APPLICABLE.
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
SPECIAL PROVISIONS: N82
PACKAGING EXCEPTIONS: 306
PACKAGING NON BULK: 304
PACKAGING BULK: NONE
IATA:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, FLAMMABLE, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
PACKING GROUP: NOT APPLICABLE.
ERG CODE: 10L
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
OTHER INFORMATION:
PASSENGER AND CARGO AIRCRAFT: ALLOWED WITH RESTRICTIONS.
CARGO AIRCRAFT ONLY: ALLOWED WITH RESTRICTIONS.
IMDG:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 2
SUBSIDIARY RISK:
PACKING GROUP: NOT APPLICABLE.
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: NO.
EMS: F-D, S-U
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
| 15. REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
TSCA SECTION 12(B) EXPORT NOTIFICATION (40 CFR 707, SUBPT. D):
NOT REGULATED.
SARA 304 EMERGENCY RELEASE NOTIFICATION: NOT REGULATED.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1052):
NOT REGULATED.
US EPCRA (SARA TITLE III) SECTION 313 - TOXIC CHEMICAL LISTED SUBSTANCE
TOLUENE (CAS 108-88-3)
CERCLA HAZARDOUS SUBSTANCE LIST (40 CFR 302.4):
ACETONE (CAS 67-64-1): LISTED.
TOLUENE (CAS 108-88-3): LISTED.
CERCLA HAZARDOUS SUBSTANCES REPORTABLE QUANTITY
ACETONE (CAS 67-64-1) 5000 LBS
TOLUENE (CAS 108-88-3) 1000 LBS
SPILLS OR RELEASES RESULTING IN THE LOSS OF ANY INGREDIENT AT OR ABOVE
ITS RQ REQUIRE IMMEDIATE NOTIFICATION TO THE NATIONAL RESPONSE CENTER
(800-424-8802) AND TO YOUR LOCAL EMERGENCY PLANNING COMMITTEE.
OTHER FEDERAL REGULATIONS:
CLEAN AIR ACT (CAA) SECTION 112 HAZARDOUS AIR POLLUTANTS (HAPS) LIST:
TOLUENE (CAS 108-88-3)
CLEAN AIR ACT (CAA) SECTION 112(R) ACCIDENTAL RELEASE PREVENTION
(40 CFR 68.130): NOT REGULATED.
SAFE DRINKING WATER ACT (SDWA): NOT REGULATED.
DRUG ENFORCEMENT ADMINISTRATION (DEA). LIST 2, ESSENTIAL CHEMICALS
(21 CFR 1310.02(B) AND 1310.04(F)(2) AND CHEMICAL CODE NUMBER:
ACETONE (CAS 67-64-1): 6532
TOLUENE (CAS 108-88-3): 6594
DRUG ENFORCEMENT ADMINISTRATION (DEA). LIST 1 & 2 EXEMPT CHEMICAL MIXTURES
(21 CFR 1310.12(C)):
ACETONE (CAS 67-64-1): 35 %WV
TOLUENE (CAS 108-88-3): 35 %WV
DEA EXEMPT CHEMICAL MIXTURES CODE NUMBER:
ACETONE (CAS 67-64-1): 6532
TOLUENE (CAS 108-88-3): 594
FEMA PRIORITY SUBSTANCES RESPIRATORY HEALTH AND SAFETY IN THE FLAVOR
MANUFACTURING WORKPLACE:
ACETONE (CAS 67-64-1): LOW PRIORITY
FOOD AND DRUG ADMINISTRATION (FDA): NOT REGULATED.
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA):
CLASSIFIED HAZARD CATEGORIES:
FLAMMABLE (GASES, AEROSOLS, LIQUIDS, OR SOLIDS)
GAS UNDER PRESSURE
SERIOUS EYE DAMAGE OR EYE IRRITATION
REPRODUCTIVE TOXICITY
SPECIFIC TARGET ORGAN TOXICITY (SINGLE OR REPEATED EXPOSURE)
HAZARD NOT OTHERWISE CLASSIFIED (HNOC)
SARA 302 EXTREMELY HAZARDOUS SUBSTANCE: NOT LISTED.
SARA 313 (TRI REPORTING):
CHEMICAL NAME CAS NUMBER % BY WT.
TOLUENE 108-88-3 1 - 3
US STATE REGULATIONS:
US. NEW JERSEY WORKER AND COMMUNITY RIGHT-TO-KNOW ACT:
ACETONE (CAS 67-64-1)
CARBON DIOXIDE (CAS 124-38-9)
TOLUENE (CAS 108-88-3)
US. MASSACHUSETTS RTK - SUBSTANCE LIST
ACETONE (CAS 67-64-1)
CARBON DIOXIDE (CAS 124-38-9)
TOLUENE (CAS 108-88-3)
US. PENNSYLVANIA WORKER AND COMMUNITY RIGHT-TO-KNOW LAW:
ACETONE (CAS 67-64-1)
CARBON DIOXIDE (CAS 124-38-9)
TOLUENE (CAS 108-88-3)
US. RHODE ISLAND RTK:
ACETONE (CAS 67-64-1)
CARBON DIOXIDE (CAS 124-38-9)
TOLUENE (CAS 108-88-3)
CALIFORNIA PROPOSITION 65:
WARNING: CANCERANDREPRODUCTIVEHARM-VWVW.P65WARNINGS.CA.GOV
CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/CARCINOGENIC SUBSTANCE
ACETALDEHYDE (CAS 75-07-0) LISTED: APRIL 1, 1988
BENZENE (CAS 71-43-2) LISTED: FEBRUARY 27, 1987
CUMENE (CAS 98-82-8) LISTED: APRIL 6, 2010
ETHYLBENZENE (CAS 100-41-4) LISTED: JUNE 11, 2004
NAPHTHALENE (CAS 91-20-3) LISTED: APRIL 19, 2002
CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/DEVELOPMENTAL TOXIN
BENZENE (CAS 71-43-2) LISTED: DECEMBER 26, 1997
TOLUENE (CAS 108-88-3) LISTED: JANUARY 1, 1991
CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/MALE REPRODUCTIVE TOXIN
BENZENE (CAS 71-43-2) LISTED: DECEMBER 26, 1997
US. CALIFORNIA. CANDIDATE CHEMICALS LIST. SAFER CONSUMER PRODUCTS
REGULATIONS (CAL. CODE REGS, TIT. 22, 69502.3, SUBD. (A)):
ACETONE (CAS 67-64-1)
TOLUENE (CAS 108-88-3)
VOLATILE ORGANIC COMPOUNDS (VOC) REGULATIONS:
EPA:
VOC CONTENT (40 CFR 51.100(S)): 2.7%
CONSUMER PRODUCTS (40 CFR 59, SUBPT. C): NOT REGULATED
STATE:
CONSUMER PRODUCTS:
THIS PRODUCT IS REGULATED AS A BRAKE CLEANER. THIS PRODUCT IS COMPLIANT
FOR USE IN ALL 50 STATES. THIS PRODUCT ALSO COMPLIES WITH SOUTH COAST AIR
QUALITY MANAGEMENT DISTRICT RULE 1171.
VOC CONTENT (CA): 2.7%
VOC CONTENT (OTC): 2.7%
INTERNATIONAL INVENTORIES:
COUNTRY(S) INVENTORY NAME ON INVENTORY
OR REGION (YES/NO)*
AUSTRALIA AUSTRALIAN INVENTORY OF CHEMICAL YES
SUBSTANCES (AICS)
CANADA DOMESTIC SUBSTANCES LIST (DSL) YES
CANADA NON-DOMESTIC SUBSTANCES LIST (NDSL) NO
CHINA INVENTORY OF EXISTING CHEMICAL YES
SUBSTANCES IN CHINA (IECSC)
EUROPE EUROPEAN INVENTORY OF EXISTING COMMERCIAL YES
CHEMICAL SUBSTANCES (EINECS)
EUROPE EUROPEAN LIST OF NOTIFIED CHEMICAL NO
SUBSTANCES (ELINCS)
JAPAN INVENTORY OF EXISTING AND NEW CHEMICAL YES
SUBSTANCES (ENCS)
KOREA EXISTING CHEMICALS LIST (ECL) YES
NEW ZEALAND NEW ZEALAND INVENTORY YES
PHILIPPINES PHILIPPINE INVENTORY OF CHEMICALS AND YES
CHEMICAL SUBSTANCES (PICCS)
TAIWAN TAIWAN TOXIC CHEMICAL SUBSTANCES (TCS) YES
UNITED STATES TOXIC SUBSTANCES CONTROL ACT (TSCA) INVENTORY YES
& PUERTO RICO
*A "YES" INDICATES THAT ALL COMPONENTS OF THIS PRODUCT COMPLY WITH THE
INVENTORY REQUIREMENTS ADMINISTERED BY THE GOVERNING COUNTRY(S)
A "NO" INDICATES THAT ONE OR MORE COMPONENTS OF THE PRODUCT ARE NOT LISTED
OR EXEMPT FROM LISTING ON THE INVENTORY ADMINISTERED BY THE GOVERNING
COUNTRY(S).
| 16. OTHER INFORMATION, INCLUDING DATE OF PREPARATION | |
OR LAST REVISION
ISSUE DATE: 05-26-2015
REVISION DATE: 04-05-2018
PREPARED BY: ALLISON YOON
VERSION #: 02
FURTHER INFORMATION: CRC # 668A/1002701
DISCLAIMER:
THE INFORMATION CONTAINED IN THIS DOCUMENT APPLIES TO THIS SPECIFIC
MATERIAL AS SUPPLIED. IT MAY NOT BE VALID FOR THIS MATERIAL IF IT IS USED
IN COMBINATION WITH ANY OTHER MATERIALS. THIS INFORMATION IS ACCURATE TO
THE BEST OF CRC'S KNOWLEDGE OR OBTAINED FROM SOURCES BELIEVED BY CRC TO BE
ACCURATE. BEFORE USING ANY PRODUCT, READ ALL WARNINGS AND DIRECTIONS ON THE
LABEL. FOR FURTHER CLARIFICATION OF ANY INFORMATION CONTAINED ON THIS
(M)SDS CONSULT YOUR SUPERVISOR, A HEALTH & SAFETY PROFESSIONAL, OR CRC
INDUSTRIES, INC..
REVISION INFORMATION:
THIS DOCUMENT HAS UNDERGONE SIGNIFICANT CHANGES AND SHOULD BE REVIEWED IN
ITS ENTIRETY.
MATERIAL NAME: BRAKLEEN(R*) BRAKE PARTS CLEANER
SDS US