| Common Name: | ZINC-IT INSTANT COLD GALVANIZE NO. 18413 (ITEM 1005241) |
| Manufacturer: | CRC INDUSTRIES |
| SDS Revision Date: | 12/3/2018 |
| SDS Format: | GHS-US |
| Item Number(s): | 19MY71 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
CRC(R*)
SAFETY DATA SHEET
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFIER: ZINC-IT(R*) INSTANT COLD GALVANIZE
OTHER MEANS OF IDENTIFICATION:
PRODUCT CODE: NO. 18413 (ITEM# 1005241)
RECOMMENDED USE:
COATING (FOR USE IN SHOP APPLICATIONS OR ON NON-STATIONARY STRUCTURES)
RECOMMENDED RESTRICTIONS: NONE KNOWN.
MANUFACTURER/IMPORTER/SUPPLIER/DISTRIBUTOR INFORMATION:
MANUFACTURED OR SOLD BY:
COMPANY NAME: CRC INDUSTRIES, INC.
ADDRESS:
885 LOUIS DR.
WARMINSTER, PA 18974
US
TELEPHONE:
GENERAL INFORMATION: 215-674-4300
TECHNICAL ASSISTANCE: 800-521-3168
CUSTOMER SERVICE: 800-272-4620
24-HOUR EMERGENCY (CHEMTREC): 800-424-9300 (US)
WEBSITE: WWW.CRCINDUSTRIES.COM
| 2. HAZARD(S) IDENTIFICATION | |
PHYSICAL HAZARDS:
FLAMMABLE LIQUIDS: CATEGORY 2
EEALTH HAZARDS:
SKIN CORROSION/IRRITATION: CATEGORY 2
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 2A
CARCINOGENICITY: CATEGORY 2
SPECIFIC TARGET ORGAN TOXICITY, SINGLE EXPOSURE:
CATEGORY 3 RESPIRATORY TRACT IRRITATION
SPECIFIC TARGET ORGAN TOXICITY, SINGLE EXPOSURE:
CATEGORY 3 NARCOTIC EFFECTS
SPECIFIC TARGET ORGAN TOXICITY, REPEATED EXPOSURE: CATEGORY 1
ASPIRATION HAZARD: CATEGORY 1
ENVIRONMENTAL HAZARDS:
HAZARDOUS TO THE AQUATIC ENVIRONMENT, ACUTE HAZARD: CATEGORY 1
HAZARDOUS TO THE AQUATIC ENVIRONMENT, LONG-TERM HAZARD: CATEGORY 1
OSHA DEFINED HAZARDS: NOT CLASSIFIED.
LABEL ELEMENTS:
FLAME
HEALTH HAZARD
EXCLAMATION MARK
SIGNAL WORD: DANGER
HAZARD STATEMENT:
HIGHLY FLAMMABLE LIQUID AND VAPOR. MAY BE FATAL IF SWALLOWED AND ENTERS
AIRWAYS. CAUSES SKIN IRRITATION. CAUSES SERIOUS EYE IRRITATION. MAY CAUSE
RESPIRATORY IRRITATION. MAY CAUSE DROWSINESS OR DIZZINESS. SUSPECTED OF
CAUSING CANCER. CAUSES DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED
EXPOSURE. VERY TOXIC TO AQUATIC LIFE. VERY TOXIC TO AQUATIC LIFE WITH
LONG LASTING EFFECTS.
PRECAUTIONARY STATEMENT:
PREVENTION:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. KEEP AWAY FROM HEAT/SPARKS/OPEN
FLAMES/HOT SURFACES. - NO SMOKING. KEEP CONTAINER TIGHTLY CLOSED. USE
EXPLOSION-PROOF ELECTRICAL/VENTILATING/LIGHTING EQUIPMENT. USE ONLY
NON-SPARKING TOOLS. TAKE PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGE.
DO NOT ALLOW CONTACT WITH WATER. DO NOT BREATHE MIST OR VAPOR. USE ONLY
WITH ADEQUATE VENTILATION; MAINTAIN VENTILATION DURING USE AND UNTIL ALL
VAPORS ARE GONE. OPEN DOORS AND WINDOWS OR USE OTHER MEANS TO ENSURE A
FRESH AIR SUPPLY DURING USE AND WHILE PRODUCT IS DRYING. IF YOU EXPERIENCE
ANY SYMPTOMS LISTED ON THIS LABEL, INCREASE VENTILATION OR LEAVE THE AREA.
WASH THOROUGHLY AFTER HANDLING. DO NOT EAT, DRINK OR SMOKE WHEN USING THIS
PRODUCT. WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE
PROTECTION. AVOID RELEASE TO THE ENVIRONMENT.
RESPONSE:
IF SWALLOWED:
IMMEDIATELY CALL A POISON CENTER/DOCTOR. DO NOT INDUCE VOMITING.
IF ON SKIN (OR HAIR):
TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. RINSE SKIN WITH
WATER/SHOWER.
IF SKIN IRRITATION OCCURS:
GET MEDICAL ADVICE/ATTENTION. TAKE OFF CONTAMINATED CLOTHING AND WASH
BEFORE REUSE.
IF INHALED:
REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING. CALL A
POISON CENTER/DOCTOR IF YOU FEEL UNWELL.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
IF EXPOSED OR CONCERNED: GET MEDICAL ADVICE/ATTENTION.
IN CASE OF FIRE:
DO NOT USE WATER, AS IT MAY FORM HYDROGEN GAS. COLLECT SPILLAGE.
STORAGE:
KEEP COOL. STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED.
STORE LOCKED UP.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH LOCAL/REGIONAL/NATIONAL
REGULATIONS.
HAZARD(S) NOT OTHERWISE CLASSIFIED:
STATIC ACCUMULATING FLAMMABLE LIQUID CAN BECOME ELECTROSTATICALLY CHARGED
EVEN IN BONDED AND (ENOC) GROUNDED EQUIPMENT. SPARKS MAY IGNITE LIQUID AND
VAPOR. MAY CAUSE FLASH FIRE OR EXPLOSION.
SUPPLEMENTAL INFORMATION: NONE.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
MIXTURES:
CHEMICAL NAME COMMON NAME CAS NUMBER %
AND SYNONYMS
ZINC 7440-66-6 70 - 80
XYLENE 1330-20-7 10 - 20
ETHYLBENZENE 100-41-4 1 - 3
NAPHTHA (PETROLEUM), 64742-49-0 1 - 3
HYDROTREATED LIGHT
ZINC OXIDE 1314-13-2 1 - 3
SPECIFIC CHEMICAL IDENTITY AND/OR PERCENTAGE OF COMPOSITION HAS BEEN
WITHHELD AS A TRADE SECRET.
| 4. FIRST-AID MEASURES | |
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
SKIN CONTACT:
TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. RINSE SKIN WITH
WATER/SHOWER.
IF SKIN IRRITATION OCCURS:
GET MEDICAL ADVICE/ATTENTION. WASH CONTAMINATED CLOTHING BEFORE REUSE.
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. REMOVE
CONTACT LENSES, IF PRESENT AND EASY TO DO. CONTINUE RINSING. GET MEDICAL
ATTENTION IF IRRITATION DEVELOPS AND PERSISTS.
INGESTION:
CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY. RINSE MOUTH. DO NOT
INDUCE VOMITING. IF VOMITING OCCURS, KEEP HEAD LOW SO THAT STOMACH CONTENT
DOESN'T GET INTO THE LUNGS.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
ASPIRATION MAY CAUSE PULMONARY EDEMA AND PNEUMONITIS. MAY CAUSE DROWSINESS
AND DIZZINESS. HEADACHE. NAUSEA, VOMITING. SEVERE EYE IRRITATION. SYMPTOMS
MAY INCLUDE STINGING, TEARING, REDNESS, SWELLING, AND BLURRED VISION. MAY
CAUSE RESPIRATORY IRRITATION. SKIN IRRITATION. MAY CAUSE REDNESS AND PAIN.
PROLONGED EXPOSURE MAY CAUSE CHRONIC EFFECTS.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
PROVIDE GENERAL SUPPORTIVE MEASURES AND TREAT SYMPTOMATICALLY.
THERMAL BURNS:
FLUSH WITH WATER IMMEDIATELY. WHILE FLUSHING, REMOVE CLOTHES WHICH DO NOT
ADHERE TO AFFECTED AREA. CALL AN AMBULANCE. CONTINUE FLUSHING DURING
TRANSPORT TO HOSPITAL. KEEP VICTIM UNDER OBSERVATION. SYMPTOMS MAY BE
DELAYED.
GENERAL INFORMATION: TAKE OFF ALL CONTAMINATED CLOTHING IMMEDIATELY.
IF EXPOSED OR CONCERNED:
GET MEDICAL ADVICE/ATTENTION. ENSURE THAT MEDICAL PERSONNEL ARE AWARE OF
THE MATERIAL(S) INVOLVED, AND TAKE PRECAUTIONS TO PROTECT THEMSELVES. WASH
CONTAMINATED CLOTHING BEFORE REUSE.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
WATER FOG. FOAM. DRY SAND. CARBON DIOXIDE (CO2). DRY CHEMICAL POWDER,
CARBON DIOXIDE, SAND OR EARTH MAY BE USED FOR SMALL FIRES ONLY.
UNSUITABLE EXTINGUISHING MEDIA: DO NOT USE WATER AS AN EXTINGUISHER.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
VAPORS MAY FORM EXPLOSIVE MIXTURES WITH AIR. VAPORS MAY TRAVEL CONSIDERABLE
DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK. THIS PRODUCT IS A POOR
CONDUCTOR OF ELECTRICITY AND CAN BECOME ELECTROSTATICALLY CHARGED. IF
SUFFICIENT CHARGE IS ACCUMULATED, IGNITION OF FLAMMABLE MIXTURES CAN OCCUR.
THIS LIQUID MAY ACCUMULATE STATIC ELECTRICITY WHEN FILLING PROPERLY
GROUNDED CONTAINERS. STATIC ELECTRICITY ACCUMULATION MAY BE SIGNIFICANTLY
INCREASED BY THE PRESENCE OF SMALL QUANTITIES OF WATER OR OTHER
CONTAMINANTS. MATERIAL WILL FLOAT AND MAY IGNITE ON SURFACE OF WATER.
CONTACT WITH WATER MAY CAUSE AN EXPLOSION OR MAY PRODUCE A FLAMMABLE GAS.
DURING FIRE, GASES HAZARDOUS TO HEALTH MAY BE FORMED.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING MUST BE
WORN IN CASE OF FIRE.
FIRE-FIGHTING EQUIPMENT/INSTRUCTIONS:
IN CASE OF FIRE AND/OR EXPLOSION DO NOT BREATHE FUMES. MOVE CONTAINERS
FROM FIRE AREA IF YOU CAN DO SO WITHOUT RISK.
GENERAL FIRE HAZARDS: HIGHLY FLAMMABLE LIQUID AND VAPOR.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
KEEP UNNECESSARY PERSONNEL AWAY. KEEP PEOPLE AWAY FROM AND UPWIND OF
SPILL/LEAK. ELIMINATE ALL IGNITION SOURCES (NO SMOKING, FLARES, SPARKS,
OR FLAMES IN IMMEDIATE AREA). WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND
CLOTHING DURING CLEAN-UP. DO NOT BREATHE MIST OR VAPOR. DO NOT TOUCH
DAMAGED CONTAINERS OR SPILLED MATERIAL UNLESS WEARING APPROPRIATE
PROTECTIVE CLOTHING. VENTILATE CLOSED SPACES BEFORE ENTERING THEM. USE
APPROPRIATE CONTAINMENT TO AVOID ENVIRONMENTAL CONTAMINATION. LOCAL
AUTHORITIES SHOULD BE ADVISED IF SIGNIFICANT SPILLAGES CANNOT BE CONTAINED.
FOR PERSONAL PROTECTION, SEE SECTION 8 OF THE SDS.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
ELIMINATE ALL IGNITION SOURCES (NO SMOKING, FLARES, SPARKS, OR FLAMES IN
IMMEDIATE AREA). KEEP COMBUSTIBLES (WOOD, PAPER, OIL, ETC.) AWAY FROM
SPILLED MATERIAL. TAKE PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGE.
USE ONLY NON-SPARKING TOOLS. PREVENT PRODUCT FROM ENTERING DRAINS.
SMALL SPILLS:
ABSORB WITH EARTH, SAND OR OTHER NON-COMBUSTIBLE MATERIAL AND TRANSFER TO
CONTAINERS FOR LATER DISPOSAL. WIPE UP WITH ABSORBENT MATERIAL (E.G. CLOTH,
FLEECE). CLEAN SURFACE THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
NEVER RETURN SPILLS TO ORIGINAL CONTAINERS FOR RE-USE. PUT MATERIAL IN
SUITABLE, COVERED, LABELED CONTAINERS. FOR WASTE DISPOSAL, SEE SECTION 13
OF THE SDS.
ENVIRONMENTAL PRECAUTIONS:
AVOID RELEASE TO THE ENVIRONMENT. INFORM APPROPRIATE MANAGERIAL OR
SUPERVISORY PERSONNEL OF ALL ENVIRONMENTAL RELEASES. PREVENT FURTHER
LEAKAGE OR SPILLAGE IF SAFE TO DO SO. AVOID DISCHARGE INTO DRAINS, WATER
COURSES OR ONTO THE GROUND. USE APPROPRIATE CONTAINMENT TO AVOID
ENVIRONMENTAL CONTAMINATION.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. DO NOT HANDLE, STORE OR OPEN
NEAR AN OPEN FLAME, SOURCES OF HEAT OR SOURCES OF IGNITION. PROTECT
MATERIAL FROM DIRECT SUNLIGHT. EXPLOSION-PROOF GENERAL AND LOCAL EXHAUST
VENTILATION. TAKE PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGES. USE
NON-SPARKING TOOLS AND EXPLOSION-PROOF EQUIPMENT. DO NOT BREATHE MIST OR
VAPOR. AVOID CONTACT WITH EYES, SKIN, AND CLOTHING. AVOID PROLONGED
EXPOSURE. WHEN USING, DO NOT EAT, DRINK OR SMOKE. SHOULD BE HANDLED IN
CLOSED SYSTEMS, IF POSSIBLE. WEAR APPROPRIATE PERSONAL PROTECTIVE
EQUIPMENT. WASH HANDS THOROUGHLY AFTER HANDLING. AVOID RELEASE TO THE
ENVIRONMENT. OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES. FOR PRODUCT USAGE
INSTRUCTIONS, SEE THE PRODUCT LABEL.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
KEEP AWAY FROM HEAT, SPARKS AND OPEN FLAME. ELIMINATE SOURCES OF IGNITION.
AVOID SPARK PROMOTERS. STORE IN A COOL, DRY PLACE OUT OF DIRECT SUNLIGHT.
KEEP CONTAINER TIGHTLY CLOSED. STORE IN A WELL-VENTILATED PLACE. KEEP IN
AN AREA EQUIPPED WITH SPRINKLERS. STORE AWAY FROM INCOMPATIBLE MATERIALS
(SEE SECTION 10 OF THE SDS).
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
OCCUPATIONAL EXPOSURE LIMITS:
US. OSHA TABLE Z-1 LIMITS FOR AIR CONTAMINANTS (29 CFR 1910.1000):
COMPONENTS TYPE VALUE FORM
ETHYLBENZENE PEL 435 MG/M3
(CAS 100-41-4) 100 PPM
NAPHTHA (PETROLEUM), PEL 400 MG/M3
HYDROTREATED LIGHT 100 PPM
(CAS 64742-49-0)
XYLENE PEL 435 MG/M3
(CAS 1330-20-7) 100 PPM
ZINC OXIDE PEL 5 MG/M3 RESPIRABLE FRACTION.
(CAS 1314-13-2) 5 MG/M3 FUME.
15 MG/M3 TOTAL DUST.
US. ACGH THRESHOLD LIMIT VALUES:
COMPONENTS TYPE VALUE FORM
ETHYLBENZENE TWA 20 PPM
(CAS 100-41-4)
XYLENE STEL 150 PPM
(CAS 1330-20-7)
TWA 100 PPM
ZINC OXIDE STEL 10 MG/M3 RESPIRABLE FRACTION.
(CAS 1314-13-2)
TWA 2 MG/M3 RESPIRABLE FRACTION.
US. NIOSH: POCKET GUIDE TO CHEMICAL HAZARDS
COMPONENTS TYPE VALUE FORM
ETHYLBENZENE STEL 545 MG/M3
(CAS 100-41-4) 125 PPM
TWA 435 MG/M3
100 PPM
NAPHTHA (PETROLEUM), TWA 400 MG/M3
HYDROTREATED LIGHT 100 PPM
(CAS 64742-49-0)
XYLENE STEL 655 MG/M3
(CAS 1330-20-7) 150 PPM
TWA 435 MG/M3
100 PPM
ZINC OXIDE CEILING 15 MG/M3 DUST.
(CAS 1314-13-2)
STEL 10 MG/M3 FUME.
TWA 5 MG/M3 FUME.
5 MG/M3 DUST.
BIOLOGICAL LIMIT VALUES:
ACGH BIOLOGICAL EXPOSURE INDICES:
COMPONENTS VALUE DETERMINANT SPECIMEN SAMPLING TIME
ETHYLBENZENE 0.15 G/G SUM OF CREATININE *
(CAS 100-41-4) MANDELIC ACID IN URINE
AND
PHENYLGLYOXYLIC
ACID
XYLENE 1.5 G/G METHYLHIPPURIC CREATININE *
(CAS 1330-20-7) ACIDS IN URINE
* - FOR SAMPLING DETAILS, PLEASE SEE THE SOURCE DOCUMENT.
APPROPRIATE ENGINEERING CONTROLS:
EXPLOSION-PROOF GENERAL AND LOCAL EXHAUST VENTILATION. GOOD GENERAL
VENTILATION (TYPICALLY 10 AIR CHANGES PER HOUR) SHOULD BE USED. VENTILATION
RATES SHOULD BE MATCHED TO CONDITIONS. IF APPLICABLE, USE PROCESS
ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING CONTROLS TO
MAINTAIN AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS. IF EXPOSURE
LIMITS HAVE NOT BEEN ESTABLISHED, MAINTAIN AIRBORNE LEVELS TO AN ACCEPTABLE
LEVEL. EYE WASH FACILITIES AND EMERGENCY SHOWER SHOULD BE AVAILABLE WHEN
HANDLING THIS PRODUCT.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION: WEAR SAFETY GLASSES WITH SIDE SHIELDS (OR GOGGLES).
SKIN PROTECTION:
HAND PROTECTION:
WEAR PROTECTIVE GLOVES SUCH AS: NITRILE. NEOPRENE.
OTHER: WEAR APPROPRIATE CHEMICAL RESISTANT CLOTHING.
RESPIRATORY PROTECTION:
IF ENGINEERING CONTROLS ARE NOT FEASIBLE OR IF EXPOSURE EXCEEDS THE
APPLICABLE EXPOSURE LIMITS, USE A NIOSH-APPROVED CARTRIDGE RESPIRATOR WITH
AN ORGANIC VAPOR CARTRIDGE. USE A SELF-CONTAINED BREATHING APPARATUS IN
CONFINED SPACES AND FOR EMERGENCIES. AIR MONITORING IS NEEDED TO DETERMINE
ACTUAL EMPLOYEE EXPOSURE LEVELS.
THERMAL HAZARDS:
WEAR APPROPRIATE THERMAL PROTECTIVE CLOTHING, WHEN NECESSARY.
GENERAL HYGIENE CONSIDERATIONS:
OBSERVE ANY MEDICAL SURVEILLANCE REQUIREMENTS. WHEN USING DO NOT SMOKE.
WASH HANDS AFTER HANDLING AND BEFORE EATING. KEEP AWAY FROM FOOD AND DRINK.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: LIQUID.
FORM: LIQUID.
COLOR: GRAY.
ODOR: SOLVENT.
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
MELTING POINT/FREEZING POINT: -138.8 DEG. F (-94.9 DEG. C) ESTIMATED
INITIAL BOILING POINT AND BOILING RANGE: 210 DEG. F (98.9 DEG. C)
FLASH POINT: 45 DEG. F (7.2 DEG. C) TAG CLOSED CUP
EVAPORATION RATE: SLOW.
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS:
FLAMMABILITY LIMIT - LOWER (%): 0.7%
FLAMMABILITY LIMIT - UPPER (%): 22.7%
VAPOR PRESSURE: 3.7 HPA ESTIMATED
VAPOR DENSITY: >1 (AIR = 1)
RELATIVE DENSITY: 2.47
SOLUBILITY(IES):
SOLUBILITY (WATER): NOT AVAILABLE.
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: 550 DEG. F (287.8 DEG. C) ESTIMATED
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
VISCOSITY: NOT AVAILABLE.
PERCENT VOLATILE: 58.1%
| 10. STABILITY AND REACTIVITY | |
REACTIVITY:
THE PRODUCT IS STABLE AND NON-REACTIVE UNDER NORMAL CONDITIONS OF USE,
STORAGE AND TRANSPORT.
CHEMICAL STABILITY: MATERIAL IS STABLE UNDER NORMAL CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS:
NO DANGEROUS REACTION KNOWN UNDER CONDITIONS OF NORMAL USE.
CONDITIONS TO AVOID:
AVOID HEAT, SPARKS, OPEN FLAMES AND OTHER IGNITION SOURCES. CONTACT WITH
INCOMPATIBLE MATERIALS. DO NOT ALLOW CONTACT WITH WATER. HYDROGEN GAS MAY
FORM PRODUCING AN EXPLOSIVE ENVIRONMENT.
INCOMPATIBLE MATERIALS: ACIDS. BASES. OXIDIZING AGENTS. WATER.
HAZARDOUS DECOMPOSITION PRODUCTS:
CARBON OXIDES. CONTACT WITH WATER MAY CAUSE AN EXPLOSION OR MAY PRODUCE
A FLAMMABLE GAS.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INHALATION:
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE BY
INHALATION. MAY CAUSE DROWSINESS AND DIZZINESS. HEADACHE. NAUSEA, VOMITING.
MAY CAUSE IRRITATION TO THE RESPIRATORY SYSTEM.
SKIN CONTACT: CAUSES SKIN IRRITATION.
EYE CONTACT: CAUSES SERIOUS EYE IRRITATION.
INGESTION:
DROPLETS OF THE PRODUCT ASPIRATED INTO THE LUNGS THROUGH INGESTION OR
VOMITING MAY CAUSE A SERIOUS CHEMICAL PNEUMONIA.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
ASPIRATION MAY CAUSE PULMONARY EDEMA AND PNEUMONITIS. MAY CAUSE DROWSINESS
AND DIZZINESS. HEADACHE. NAUSEA, VOMITING. SEVERE EYE IRRITATION. SYMPTOMS
MAY INCLUDE STINGING, TEARING, REDNESS, SWELLING, AND BLURRED VISION. MAY
CAUSE RESPIRATORY IRRITATION. SKIN IRRITATION. MAY CAUSE REDNESS AND PAIN.
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
COMPONENTS SPECIES TEST RESULTS
ETHYLBENZENE (CAS 100-41-4):
ACUTE:
DERMAL:
LD50 RABBIT 15400 MG/KG
ORAL:
LD50 RAT 3500 MG/KG
NAPHTHA (PETROLEUM), HYDROTREATED LIGHT (CAS 64742-49-0):
ACUTE:
DERMAL:
LD50 RABBIT >2000 MG/KG
INHALATION:
LC50 RAT 61 MG/L, 4 HOURS
ORAL:
LD50 RAT >5000 MG/KG
XYLENE (CAS 1330-20-7):
ACUTE:
DERMAL:
LD50 RABBIT >4300 MG/KG
INHALATION:
LC50 RAT 29 MG/L, 4 HOURS
ZINC (CAS 7440-66-6):
ACUTE:
ORAL:
LD50 RAT >2000 MG/KG
ZINC OXIDE (CAS 1314-13-2):
ACUTE:
INHALATION:
LC50 RAT >1.79 MG/L, 4 HOURS
(NO DEATHS OCCURRED)
ORAL:
LD50 RAT >5000 MG/KG
SKIN CORROSION/IRRITATION: CAUSES SKIN IRRITATION.
SERIOUS EYE DAMAGE/EYE IRRITATION: CAUSES SERIOUS EYE IRRITATION.
RESPIRATORY OR SKIN SENSITIZATION:
RESPIRATORY SENSITIZATION: NOT A RESPIRATORY SENSITIZER.
SKIN SENSITIZATION:
THIS PRODUCT IS NOT EXPECTED TO CAUSE SKIN SENSITIZATION.
GERM CELL MUTAGENICITY:
NO DATA AVAILABLE TO INDICATE PRODUCT OR ANY COMPONENTS PRESENT AT GREATER
THAN 0.1% ARE MUTAGENIC OR GENOTOXIC.
CARCINOGENICITY: SUSPECTED OF CAUSING CANCER.
IARC MONOGRAPHS. OVERALL EVALUATION OF CARCINOGENICITY:
ETHYLBENZENE (CAS 100-41-4): 2B POSSIBLY CARCINOGENIC TO HUMANS.
XYLENE (CAS 1330-20-7): 3 NOT CLASSIFIABLE AS TO CARCINOGENICITY TO HUMANS.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1052):
NOT REGULATED.
US. NATIONAL TOXICOLOGY PROGRAM (NTP) REPORT ON CARCINOGENS: NOT LISTED.
REPRODUCTIVE TOXICITY:
THIS PRODUCT IS NOT EXPECTED TO CAUSE REPRODUCTIVE OR DEVELOPMENTAL
EFFECTS.
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE:
MAY CAUSE RESPIRATORY IRRITATION. MAY CAUSE DROWSINESS AND DIZZINESS.
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE:
CAUSES DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
ASPIRATION HAZARD:
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. IF ASPIRATED INTO LUNGS
DURING SWALLOWING OR VOMITING, MAY CAUSE CHEMICAL PNEUMONIA, PULMONARY
INJURY OR DEATH.
CHRONIC EFFECTS:
CAUSES DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE. PROLONGED
INHALATION MAY BE HARMFUL. PROLONGED EXPOSURE MAY CAUSE CHRONIC EFFECTS.
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY: VERY TOXIC TO AQUATIC LIFE WITH LONG LASTING EFFECTS.
COMPONENTS SPECIES TEST RESULTS
ZINC (CAS 7440-66-6):
AQUATIC:
ACUTE:
FISH LC50 RAINBOW TROUT, DONALDSON 0.482 MG/L, 96 HOURS
TROUT (ONCORHYNCHUS MYKISS)
ZINC OXIDE (CAS 1314-13-2):
AQUATIC:
ACUTE:
CRUSTACEA EC50 WATER FLEA (DAPHNIA MAGNA) 0.098 MG/L, 48 HOURS
FISH LC50 RAINBOW TROUT, DONALDSON 1.1 MG/L, 96 HOURS
TROUT (ONCORHYNCHUS MYKISS)
PERSISTENCE AND DEGRADABILITY:
NO DATA IS AVAILABLE ON THE DEGRADABILITY OF ANY INGREDIENTS IN THE
MIXTURE.
BIOACCUMULATIVE POTENTIAL:
PARTITION COEFFICIENT N-OCTANOL / WATER (LOG KOW):
ETHYLBENZENE: 3.15
XYLENE: 3.12 - 3.2
BIOCONCENTRATION FACTOR (BCF):
ETHYLBENZENE: 1
NAPHTHA (PETROLEUM), HYDROTREATED LIGHT: 10 - 25000
XYLENE: 23.99
ZINC OXIDE: 60690
MOBILITY IN SOIL: NO DATA AVAILABLE.
OTHER ADVERSE EFFECTS:
NO OTHER ADVERSE ENVIRONMENTAL EFFECTS (E.G. OZONE DEPLETION, PHOTOCHEMICAL
OZONE CREATION POTENTIAL, ENDOCRINE DISRUPTION, GLOBAL WARMING POTENTIAL)
ARE EXPECTED FROM THIS COMPONENT.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL INSTRUCTIONS:
THIS MATERIAL AND ITS CONTAINER MUST BE DISPOSED OF AS HAZARDOUS WASTE.
COLLECT AND RECLAIM OR DISPOSE IN SEALED CONTAINERS AT LICENSED WASTE
DISPOSAL SITE. DO NOT ALLOW THIS MATERIAL TO DRAIN INTO SEWERS/WATER
SUPPLIES. DO NOT CONTAMINATE PONDS, WATERWAYS OR DITCHES WITH CHEMICAL OR
USED CONTAINER. DISPOSE IN ACCORDANCE WITH ALL APPLICABLE REGULATIONS.
HAZARDOUS WASTE CODE:
D001: WASTE FLAMMABLE MATERIAL WITH A FLASH POINT <140 F
F003: WASTE NON-HALOGENATED SOLVENT - SPENT NON-HALOGENATED SOLVENT
US RCRA HAZARDOUS WASTE U LIST REFERENCE
XYLENE (CAS 1330-20-7) U239
CONTAMINATED PACKAGING:
SINCE EMPTIED CONTAINERS MAY RETAIN PRODUCT RESIDUE, FOLLOW LABEL WARNINGS
EVEN AFTER CONTAINER IS EMPTIED. EMPTY CONTAINERS SHOULD BE TAKEN TO AN
APPROVED WASTE HANDLING SITE FOR RECYCLING OR DISPOSAL.
| 14. TRANSPORT INFORMATION | |
DOT:
UN NUMBER: UN1263
UN PROPER SHIPPING NAME: PAINT, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 3
SUBSIDIARY RISK:
LABEL(S): 3
PACKING GROUP: III
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
SPECIAL PROVISIONS: B1, B52, IB3, T2, TP1, TP29
PACKAGING EXCEPTIONS: 150
PACKAGING NON BULK: 173
PACKAGING BULK: 242
IATA:
UN NUMBER: UN1263
UN PROPER SHIPPING NAME:
PAINT (INCLUDING PAINT, LACQUER, ENAMEL, STAIN, SHELLAC, VARNISH, POLISH,
LIQUID FILLER AND LIQUID LACQUER BASE), LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 3
SUBSIDIARY RISK:
PACKING GROUP: III
ERG CODE: 3L
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
OTHER INFORMATION:
PASSENGER AND CARGO AIRCRAFT: ALLOWED WITH RESTRICTIONS.
CARGO AIRCRAFT ONLY: ALLOWED WITH RESTRICTIONS.
IMDG:
UN NUMBER: UN1263
UN PROPER SHIPPING NAME:
PAINT (INCLUDING PAINT, LACQUER, ENAMEL, STAIN, SHELLAC, VARNISH, POLISH,
LIQUID FILLER AND LIQUID LACQUER BASE) OR PAINT RELATED MATERIAL
(INCLUDING PAINT THINNING OR REDUCING COMPOUND), LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 3
SUBSIDIARY RISK:
PACKING GROUP: III
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: YES, BUT EXEMPT FROM THE REGULATIONS.
EMS: F-E, S-E
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
DOT; IMDG:
LIMITED QUANTITY FOR PACKAGES NOT PREPARED FOR AIR TRANSPORT
IATA: LIMITED QUANTITY MARKING FOR PACKAGES PREPARED FOR AIR TRANSPORT
| 15. REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
TSCA SECTION 12(B) EXPORT NOTIFICATION (40 CFR 707, SUBPT. D):
NOT REGULATED.
SARA 304 EMERGENCY RELEASE NOTIFICATION: NOT REGULATED.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1052):
NOT REGULATED.
US EPCRA (SARA TITLE III) SECTION 313 - TOXIC CHEMICAL LISTED SUBSTANCE
ETHYLBENZENE (CAS 100-41-4)
XYLENE (MIXED ISOMERS) (CAS 1330-20-7)
ZINC (FUME OR DUST) (CAS 7440-66-6)
ZINC COMPOUNDS (CAS 1314-13-2)
CERCLA HAZARDOUS SUBSTANCE LIST (40 CFR 302.4):
ETHYLBENZENE (CAS 100-41-4): LISTED.
XYLENE (CAS 1330-20-7): LISTED.
ZINC (CAS 7440-66-6): LISTED.
ZINC OXIDE (CAS 1314-13-2): LISTED.
CERCLA HAZARDOUS SUBSTANCES REPORTABLE QUANTITY
ETHYLBENZENE (CAS 100-41-4) 1000 LBS
XYLENE (CAS 1330-20-7) 100 LBS
ZINC (CAS 7440-66-6) 1000 LBS
SPILLS OR RELEASES RESULTING IN THE LOSS OF ANY INGREDIENT AT OR ABOVE ITS
RQ REQUIRE IMMEDIATE NOTIFICATION TO THE NATIONAL RESPONSE CENTER
(800-424-8802) AND TO YOUR LOCAL EMERGENCY PLANNING COMMITTEE.
OTHER FEDERAL REGULATIONS:
CLEAN AIR ACT (CAA) SECTION 112 HAZARDOUS AIR POLLUTANTS (HAPS) LIST:
ETHYLBENZENE (CAS 100-41-4)
XYLENE (CAS 1330-20-7)
CLEAN AIR ACT (CAA) SECTION 112(R) ACCIDENTAL RELEASE PREVENTION
(40 CFR 68.130): NOT REGULATED.
SAFE DRINKING WATER ACT (SDWA): NOT REGULATED.
FOOD AND DRUG ADMINISTRATION (FDA): NOT REGULATED.
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA):
CLASSIFIED HAZARD CATEGORIES:
FLAMMABLE (GASES, AEROSOLS, LIQUIDS, OR SOLIDS)
ACUTE TOXICITY (ANY ROUTE OF EXPOSURE)
SKIN CORROSION OR IRRITATION
SERIOUS EYE DAMAGE OR EYE IRRITATION
CARCINOGENICITY
SPECIFIC TARGET ORGAN TOXICITY (SINGLE OR REPEATED EXPOSURE)
ASPIRATION HAZARD
HAZARD NOT OTHERWISE CLASSIFIED (HNOC)
SARA 302 EXTREMELY HAZARDOUS SUBSTANCE: NOT LISTED.
SARA 311/312 HAZARDOUS CHEMICAL: YES
SARA 313 (TRI REPORTING):
CHEMICAL NAME CAS NUMBER % BY WT.
ETHYLBENZENE 100-41-4 1 - 3
XYLENE 1330-20-7 10 - 20
ZINC 7440-66-6 70 - 80
ZINC OXIDE 1314-13-2 1 - 3
US STATE REGULATIONS:
US. NEW JERSEY WORKER AND COMMUNITY RIGHT-TO-KNOW ACT:
ETHYLBENZENE (CAS 100-41-4)
NAPHTHA (PETROLEUM), HYDROTREATED LIGHT (CAS 64742-49-0)
XYLENE (CAS 1330-20-7)
ZINC (CAS 7440-66-6)
ZINC OXIDE (CAS 1314-13-2)
US. MASSACHUSETTS RTK - SUBSTANCE LIST:
ETHYLBENZENE (CAS 100-41-4)
NAPHTHA (PETROLEUM), HYDROTREATED LIGHT (CAS 64742-49-0)
XYLENE (CAS 1330-20-7)
ZINC (CAS 7440-66-6)
ZINC OXIDE (CAS 1314-13-2)
US. PENNSYLVANIA WORKER AND COMMUNITY RIGHT-TO-KNOW LAW:
ETHYLBENZENE (CAS 100-41-4)
NAPHTHA (PETROLEUM), HYDROTREATED LIGHT (CAS 64742-49-0)
XYLENE (CAS 1330-20-7)
ZINC (CAS 7440-66-6)
ZINC OXIDE (CAS 1314-13-2)
US. RHODE ISLAND RTK:
ETHYLBENZENE (CAS 100-41-4)
NAPHTHA (PETROLEUM), HYDROTREATED LIGHT (CAS 64742-49-0)
XYLENE (CAS 1330-20-7)
ZINC (CAS 7440-66-6)
CALIFORNIA PROPOSITION 65:
WARNING: CANCER - WWW.P65WARNINGS.CA.GOV
CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/CARCINOGENIC SUBSTANCE
ETHYLBENZENE (CAS 100-41-4) LISTED: JUNE 11, 2004
US. CALIFORNIA. CANDIDATE CHEMICALS LIST. SAFER CONSUMER PRODUCTS
REGULATIONS (CAL. CODE REGS, TIT. 22, 69502.3, SUBD. (A)):
ETHYLBENZENE (CAS 100-41-4)
NAPHTHA (PETROLEUM), HYDROTREATED LIGHT (CAS 64742-49-0)
XYLENE (CAS 1330-20-7)
ZINC (CAS 7440-66-6)
VOLATILE ORGANIC COMPOUNDS (VOC) REGULATIONS:
EPA:
VOC CONTENT (40 CFR 51.100(S)): 20%
ARCHITECTURAL COATINGS (40 CFR 59, SUBPT. D): NOT REGULATED
STATE:
ARCHITECTURAL COATINGS: NOT REGULATED
VOC CONTENT: 493.7 G/L
INTERNATIONAL INVENTORIES:
COUNTRY(S) OR REGION INVENTORY NAME ON INVENTORY
(YES/NO)*
AUSTRALIA AUSTRALIAN INVENTORY OF CHEMICAL NO
SUBSTANCES (AICS)
CANADA DOMESTIC SUBSTANCES LIST (DSL) YES
CANADA NON-DOMESTIC SUBSTANCES LIST (NDSL) NO
CHINA INVENTORY OF EXISTING CHEMICAL YES
SUBSTANCES IN CHINA (IECSC)
EUROPE EUROPEAN INVENTORY OF EXISTING NO
COMMERCIAL CHEMICAL SUBSTANCES
(EINECS)
EUROPE EUROPEAN LIST OF NOTIFIED CHEMICAL NO
SUBSTANCES (ELINCS)
JAPAN INVENTORY OF EXISTING AND NEW NO
CHEMICAL SUBSTANCES (ENCS)
KOREA EXISTING CHEMICALS LIST (ECL) YES
NEW ZEALAND NEW ZEALAND INVENTORY NO
PHILIPPINES PHILIPPINE INVENTORY OF CHEMICALS YES
AND CHEMICAL SUBSTANCES (PICCS)
TAIWAN TAIWAN CHEMICAL SUBSTANCE INVENTORY NO
(TCSI)
UNITED STATES & TOXIC SUBSTANCES CONTROL ACT (TSCA) YES
PUERTO RICO INVENTORY
*A "YES" INDICATES THAT ALL COMPONENTS OF THIS PRODUCT COMPLY WITH
THE INVENTORY REQUIREMENTS ADMINISTERED BY THE GOVERNING COUNTRY(S)
A "NO" INDICATES THAT ONE OR MORE COMPONENTS OF THE PRODUCT ARE NOT LISTED
OR EXEMPT FROM LISTING ON THE INVENTORY ADMINISTERED BY THE GOVERNING
COUNTRY(S).
| 16. OTHER INFORMATION, INCLUDING DATE OF PREPARATION | |
OR LAST REVISION
ISSUE DATE: 08-24-2015
REVISION DATE: 12-03-2018
PREPARED BY: ALLISON YOON
VERSION #: 05
DISCLAIMER:
THE INFORMATION CONTAINED IN THIS DOCUMENT APPLIES TO THIS SPECIFIC
MATERIAL AS SUPPLIED. IT MAY NOT BE VALID FOR THIS MATERIAL IF IT IS USED
IN COMBINATION WITH ANY OTHER MATERIALS. THIS INFORMATION IS ACCURATE TO
THE BEST OF CRC'S KNOWLEDGE OR OBTAINED FROM SOURCES BELIEVED BY CRC TO
BE ACCURATE. BEFORE USING ANY PRODUCT, READ ALL WARNINGS AND DIRECTIONS ON
THE LABEL. FOR FURTHER CLARIFICATION OF ANY INFORMATION CONTAINED ON THIS
(M)SDS CONSULT YOUR SUPERVISOR, A HEALTH & SAFETY PROFESSIONAL, OR CRC
INDUSTRIES, INC..
REVISION INFORMATION:
PRODUCT AND COMPANY IDENTIFICATION: PRODUCT CODES
PHYSICAL & CHEMICAL PROPERTIES: MULTIPLE PROPERTIES
TOXICOLOGICAL INFORMATION: REPRODUCTIVITY
TRANSPORT INFORMATION: PROPER SHIPPING NAME/PACKING GROUP
MATERIAL NAME: ZINC-IT(R*) INSTANT COLD GALVANIZE
SDS: US