| Common Name: | LPS KB88 (AEROSOL), 02316 |
| Manufacturer: | ITW PRO BRANDS |
| SDS Revision Date: | 11/13/2017 |
| SDS Format: | No Format Specified |
| Item Number(s): | 1CMX3 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
ITW PRO BRANDS
SAFETY DATA SHEET
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFIER: LPS(R*) KB88 (AEROSOL)
OTHER MEANS OF IDENTIFICATION:
PART NUMBER: 02316
RECOMMENDED USE:
A HIGH PERFORMANCE PENETRANT DESIGNED TO LOOSEN METAL PARTS.
RECOMMENDED RESTRICTIONS: NONE KNOWN.
MANUFACTURER/IMPORTER/SUPPLIER/DISTRIBUTOR INFORMATION:
MANUFACTURER:
COMPANY NAME: ITW PRO BRANDS
ADDRESS:
4647 HUGH HOWELL RD.
TUCKER, GA 30084
COUNTRY: (U.S.A.)
TEL: +1 770-243-8800
IN CASE OF EMERGENCY:
1-800-424-9300 (INSIDE U.S.)
+001 703-527-3887 (OUTSIDE U.S.)
WEBSITE: WWW.LPSLABS.COM
E-MAIL: LPSSDS@ITWPROBRANDS.COM
| 2. HAZARD(S) IDENTIFICATION | |
PHYSICAL HAZARDS:
FLAMMABLE AEROSOLS: CATEGORY 1
GASES UNDER PRESSURE: COMPRESSED GAS
HEALTH HAZARDS:
ASPIRATION HAZARD: CATEGORY 1
ENVIRONMENTAL HAZARDS: NOT CLASSIFIED.
OSHA DEFINED HAZARDS: NOT CLASSIFIED.
LABEL ELEMENTS:
FLAME
GAS CYLINDER
HEALTH HAZARD
SIGNAL WORD: DANGER
HAZARD STATEMENT:
EXTREMELY FLAMMABLE AEROSOL. CONTAINS GAS UNDER PRESSURE; MAY EXPLODE IF
HEATED. MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
PRECAUTIONARY STATEMENT:
PREVENTION:
KEEP AWAY FROM HEAT/SPARKS/OPEN FLAMES/HOT SURFACES. - NO SMOKING. DO NOT
SPRAY ON AN OPEN FLAME OR OTHER IGNITION SOURCE.
PRESSURIZED CONTAINER: DO NOT PIERCE OR BURN, EVEN AFTER USE.
RESPONSE:
IF SWALLOWED:
IMMEDIATELY CALL A POISON CENTER/DOCTOR. DO NOT INDUCE VOMITING.
STORAGE:
STORE LOCKED UP. PROTECT FROM SUNLIGHT. STORE IN A WELL-VENTILATED PLACE.
DO NOT EXPOSE TO TEMPERATURES EXCEEDING 50 DEG. C/122 DEG. F.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
HAZARD(S) NOT OTHERWISE CLASSIFIED (HNOC): COMBUSTIBLE.
SUPPLEMENTAL INFORMATION: NONE.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
MIXTURES:
CHEMICAL NAME COMMON NAME AND SYNONYMS CAS NUMBER %
DISTILLATES PETROLEUM 64742-47-8 20 - 30
HYDROTREATED LIGHT
SOLVENT NAPHTHA 64742-94-5 20 - 30
(PETROLEUM), HEAVY AROM.
DISTILLATES PETROLEUM 64742-46-7 1 - 10
HYDROTREATED MED
CARBON DIOXIDE 124-38-9 1 - 5
| 4. FIRST-AID MEASURES | |
INHALATION:
MOVE TO FRESH AIR. CALL A PHYSICIAN IF SYMPTOMS DEVELOP OR PERSIST.
SKIN CONTACT: NO ADVERSE EFFECTS DUE TO SKIN CONTACT ARE EXPECTED.
EYE CONTACT: NO SPECIFIC FIRST AID MEASURES NOTED.
INGESTION: NOT LIKELY, DUE TO THE FORM OF THE PRODUCT.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
ASPIRATION MAY CAUSE PULMONARY EDEMA AND PNEUMONITIS.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
PROVIDE GENERAL SUPPORTIVE MEASURES AND TREAT SYMPTOMATICALLY. KEEP VICTIM
UNDER OBSERVATION. SYMPTOMS MAY BE DELAYED.
GENERAL INFORMATION:
ENSURE THAT MEDICAL PERSONNEL ARE AWARE OF THE MATERIAL(S) INVOLVED, AND
TAKE PRECAUTIONS TO PROTECT THEMSELVES.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
WATER FOG. ALCOHOL RESISTANT FOAM. DRY CHEMICAL POWDER. DRY CHEMICALS.
CARBON DIOXIDE (CO2).
UNSUITABLE EXTINGUISHING MEDIA:
DO NOT USE WATER JET AS AN EXTINGUISHER, AS THIS WILL SPREAD THE FIRE.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
CONTENTS UNDER PRESSURE. PRESSURIZED CONTAINER MAY EXPLODE WHEN EXPOSED TO
HEAT OR FLAME. DURING FIRE, GASES HAZARDOUS TO HEALTH MAY BE FORMED.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
FIREFIGHTERS MUST USE STANDARD PROTECTIVE EQUIPMENT INCLUDING FLAME
RETARDANT COAT, HELMET WITH FACE SHIELD, GLOVES, RUBBER BOOTS, AND IN
ENCLOSED SPACES, SCBA.
FIRE FIGHTING EQUIPMENT/INSTRUCTIONS:
IN CASE OF FIRE:
STOP LEAK IF SAFE TO DO SO. DO NOT MOVE CARGO OR VEHICLE IF CARGO HAS BEEN
EXPOSED TO HEAT. MOVE CONTAINERS FROM FIRE AREA IF YOU CAN DO SO WITHOUT
RISK. COOL CONTAINERS EXPOSED TO HEAT WITH WATER SPRAY AND REMOVE
CONTAINER, IF NO RISK IS INVOLVED. CONTAINERS SHOULD BE COOLED WITH WATER
TO PREVENT VAPOR PRESSURE BUILD UP. FOR MASSIVE FIRE IN CARGO AREA, USE
UNMANNED HOSE HOLDER OR MONITOR NOZZLES, IF POSSIBLE. IF NOT, WITHDRAW AND
LET FIRE BURN OUT.
SPECIFIC METHODS:
USE STANDARD FIREFIGHTING PROCEDURES AND CONSIDER THE HAZARDS OF OTHER
INVOLVED MATERIALS. MOVE CONTAINERS FROM FIRE AREA IF YOU CAN DO SO WITHOUT
RISK. IN THE EVENT OF FIRE AND/OR EXPLOSION DO NOT BREATHE FUMES.
GENERAL FIRE HAZARDS:
EXTREMELY FLAMMABLE AEROSOL. CONTENTS UNDER PRESSURE. PRESSURIZED CONTAINER
MAY EXPLODE WHEN EXPOSED TO HEAT OR FLAME.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
KEEP UNNECESSARY PERSONNEL AWAY. KEEP PEOPLE AWAY FROM AND UPWIND OF
SPILL/LEAK. KEEP OUT OF LOW AREAS. MANY GASES ARE HEAVIER THAN AIR AND WILL
SPREAD ALONG GROUND AND COLLECT IN LOW OR CONFINED AREAS (SEWERS,
BASEMENTS, TANKS). WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND CLOTHING
DURING CLEAN-UP. EMERGENCY PERSONNEL NEED SELF-CONTAINED BREATHING
EQUIPMENT. DO NOT TOUCH DAMAGED CONTAINERS OR SPILLED MATERIAL UNLESS
WEARING APPROPRIATE PROTECTIVE CLOTHING. VENTILATE CLOSED SPACES BEFORE
ENTERING THEM. LOCAL AUTHORITIES SHOULD BE ADVISED IF SIGNIFICANT SPILLAGES
CANNOT BE CONTAINED. FOR PERSONAL PROTECTION, SEE SECTION 8 OF THE SDS.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
REFER TO ATTACHED SAFETY DATA SHEETS AND/OR INSTRUCTIONS FOR USE. STOP LEAK
IF YOU CAN DO SO WITHOUT RISK. MOVE THE CYLINDER TO A SAFE AND OPEN AREA IF
THE LEAK IS IRREPARABLE. USE WATER SPRAY TO REDUCE VAPORS OR DIVERT VAPOR
CLOUD DRIFT. ISOLATE AREA UNTIL GAS HAS DISPERSED. ELIMINATE ALL IGNITION
SOURCES (NO SMOKING, FLARES, SPARKS, OR FLAMES IN IMMEDIATE AREA). KEEP
COMBUSTIBLES (WOOD, PAPER, OIL, ETC.) AWAY FROM SPILLED MATERIAL. THIS
PRODUCT IS MISCIBLE IN WATER. FOR WASTE DISPOSAL, SEE SECTION 13 OF THE
SDS.
ENVIRONMENTAL PRECAUTIONS:
AVOID DISCHARGE INTO DRAINS, WATER COURSES OR ONTO THE GROUND.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
PRESSURIZED CONTAINER:
DO NOT PIERCE OR BURN, EVEN AFTER USE. DO NOT USE IF SPRAY BUTTON IS
MISSING OR DEFECTIVE. DO NOT SPRAY ON A NAKED FLAME OR ANY OTHER
INCANDESCENT MATERIAL. DO NOT SMOKE WHILE USING OR UNTIL SPRAYED SURFACE IS
THOROUGHLY DRY. DO NOT CUT, WELD, SOLDER, DRILL, GRIND, OR EXPOSE
CONTAINERS TO HEAT, FLAME, SPARKS, OR OTHER SOURCES OF IGNITION. ALL
EQUIPMENT USED WHEN HANDLING THE PRODUCT MUST BE GROUNDED. DO NOT RE-USE
EMPTY CONTAINERS. AVOID PROLONGED OR REPEATED CONTACT WITH SKIN. AVOID
PROLONGED EXPOSURE. USE ONLY IN WELL-VENTILATED AREAS. WEAR APPROPRIATE
PERSONAL PROTECTIVE EQUIPMENT. WASH HANDS THOROUGHLY AFTER HANDLING.
OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
LEVEL 3 AEROSOL.
STORE LOCKED UP. PRESSURIZED CONTAINER. PROTECT FROM SUNLIGHT AND DO NOT
EXPOSE TO TEMPERATURES EXCEEDING 50 DEG. C/122 DEG. F. DO NOT PUNCTURE,
INCINERATE OR CRUSH. DO NOT HANDLE OR STORE NEAR AN OPEN FLAME, HEAT OR
OTHER SOURCES OF IGNITION. THIS MATERIAL CAN ACCUMULATE STATIC CHARGE WHICH
MAY CAUSE SPARK AND BECOME AN IGNITION SOURCE. STORE IN A WELL-VENTILATED
PLACE. STORED CONTAINERS SHOULD BE PERIODICALLY CHECKED FOR GENERAL
CONDITION AND LEAKAGE. STORE AWAY FROM INCOMPATIBLE MATERIALS (SEE SECTION
10 OF THE SDS).
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
OCCUPATIONAL EXPOSURE LIMITS:
THE FOLLOWING CONSTITUENTS ARE THE ONLY CONSTITUENTS OF THE PRODUCT WHICH
HAVE A PEL, TLV OR OTHER RECOMMENDED EXPOSURE LIMIT. AT THIS TIME, THE
OTHER CONSTITUENTS HAVE NO KNOWN EXPOSURE LIMITS.
U.S. - OSHA:
COMPONENTS TYPE VALUE FORM
DISTILLATES PETROLEUM PEL 5 MG/M3 OIL MIST
HYDROTREATED LIGHT
(CAS 64742-47-8)
US. OSHA TABLE Z-1 LIMITS FOR AIR CONTAMINANTS (29 CFR 1910.1000):
COMPONENTS TYPE VALUE
CARBON DIOXIDE PEL 9000 MG/M3
(CAS 124-38-9) 5000 PPM
ACGIH:
COMPONENTS TYPE VALUE FORM
DISTILLATES PETROLEUM TWA 5 MG/M3 OIL MIST
HYDROTREATED LIGHT
(CAS 64742-47-8)
US. ACGIH THRESHOLD LIMIT VALUES:
COMPONENTS TYPE VALUE
CARBON DIOXIDE STEL 30000 PPM
(CAS 124-38-9) TWA 5000 PPM
US. NIOSH: POCKET GUIDE TO CHEMICAL HAZARDS
COMPONENTS TYPE VALUE
CARBON DIOXIDE STEL 54000 MG/M3
(CAS 124-38-9) 30000 PPM
TWA 9000 MG/M3
5000 PPM
BIOLOGICAL LIMIT VALUES:
NO BIOLOGICAL EXPOSURE LIMITS NOTED FOR THE INGREDIENT(S).
APPROPRIATE ENGINEERING CONTROLS:
GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER HOUR) SHOULD BE
USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS. IF APPLICABLE, USE
PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING
CONTROLS TO MAINTAIN AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS. IF
EXPOSURE LIMITS HAVE NOT BEEN ESTABLISHED, MAINTAIN AIRBORNE LEVELS TO AN
ACCEPTABLE LEVEL.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION: WEAR SAFETY GLASSES WITH SIDE SHIELDS (OR GOGGLES).
SKIN PROTECTION:
HAND PROTECTION: WEAR APPROPRIATE CHEMICAL RESISTANT GLOVES.
OTHER: WEAR SUITABLE PROTECTIVE CLOTHING.
RESPIRATORY PROTECTION:
IF PERMISSIBLE LEVELS ARE EXCEEDED USE NIOSH MECHANICAL FILTER / ORGANIC
VAPOR CARTRIDGE OR AN AIR-SUPPLIED RESPIRATOR.
THERMAL HAZARDS:
WEAR APPROPRIATE THERMAL PROTECTIVE CLOTHING, WHEN NECESSARY.
GENERAL HYGIENE CONSIDERATIONS:
WHEN USING DO NOT SMOKE. ALWAYS OBSERVE GOOD PERSONAL HYGIENE MEASURES,
SUCH AS WASHING AFTER HANDLING THE MATERIAL AND BEFORE EATING, DRINKING,
AND/OR SMOKING. ROUTINELY WASH WORK CLOTHING AND PROTECTIVE EQUIPMENT TO
REMOVE CONTAMINANTS.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: GAS.
FORM: AEROSOL.
COLOR: RED.
ODOR: HYDROCARBON-LIKE.
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT APPLICABLE
MELTING POINT/FREEZING POINT: NOT AVAILABLE.
INITIAL BOILING POINT AND BOILING RANGE: NOT AVAILABLE.
FLASH POINT: 159.8 DEG. F (71.0 DEG. C) TAG CLOSED CUP
EVAPORATION RATE: <0.1 BUAC
FLAMMABILITY (SOLID, GAS): FLAMMABLE GAS.
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS:
FLAMMABILITY LIMIT - LOWER (%): 0.6%
FLAMMABILITY LIMIT - UPPER (%): 11.7%
EXPLOSIVE LIMIT - LOWER (%): NOT AVAILABLE.
EXPLOSIVE LIMIT - UPPER (%): NOT AVAILABLE.
VAPOR PRESSURE: <1 MMHg @ 20 DEG. C (EST.)
VAPOR DENSITY: >1
RELATIVE DENSITY: NOT AVAILABLE.
SOLUBILITY(IES):
SOLUBILITY (WATER): NOT SOLUBLE
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE
AUTO-IGNITION TEMPERATURE: >420 DEG. F (>215.56 DEG. C)
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
VISCOSITY: LOW VISCOSITY COMPARABLE TO WATER (WATER = 1CST @ 20 DEG. C)
OTHER INFORMATION:
DENSITY: 7.30 LB/GAL
EXPLOSIVE PROPERTIES: NOT EXPLOSIVE.
HEAT OF COMBUSTION: >30 KJ/G
OXIDIZING PROPERTIES: NOT OXIDIZING.
PERCENT VOLATILE: 92%
SPECIFIC GRAVITY: 0.88 @23 DEG. C
VOC: 24% PER U.S. STATE AND FEDERAL CONSUMER PRODUCT REGULATIONS
| 10. STABILITY AND REACTIVITY | |
REACTIVITY:
THE PRODUCT IS STABLE AND NON-REACTIVE UNDER NORMAL CONDITIONS OF USE,
STORAGE AND TRANSPORT.
CHEMICAL STABILITY: MATERIAL IS STABLE UNDER NORMAL CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS:
HAZARDOUS POLYMERIZATION DOES NOT OCCUR.
CONDITIONS TO AVOID:
HEAT. AVOID TEMPERATURES EXCEEDING THE FLASH POINT. CONTACT WITH
INCOMPATIBLE MATERIALS.
INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS: CARBON OXIDES.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INHALATION: PROLONGED INHALATION MAY BE HARMFUL.
SKIN CONTACT: NO ADVERSE EFFECTS DUE TO SKIN CONTACT ARE EXPECTED.
EYE CONTACT: DIRECT CONTACT WITH EYES MAY CAUSE TEMPORARY IRRITATION.
INGESTION:
DROPLETS OF THE PRODUCT ASPIRATED INTO THE LUNGS THROUGH INGESTION OR
VOMITING MAY CAUSE A SERIOUS CHEMICAL PNEUMONIA.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS: ASPIRATION MAY CAUSE PULMONARY EDEMA AND PNEUMONITIS.
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
COMPONENTS SPECIES TEST RESULTS
DISTILLATES PETROLEUM HYDROTREATED LIGHT (CAS 64742-47-8):
ACUTE:
DERMAL:
LD50 RABBIT >2000 MG/KG
INHALATION:
VAPOR:
LC50 RAT >4.5 MG/L, 4 HOURS
DISTILLATES PETROLEUM HYDROTREATED MED (CAS 64742-46-7):
ACUTE:
DERMAL:
LD50 RABBIT >2000 MG/KG, 24 HOURS
SOLVENT NAPHTHA (PETROLEUM), HEAVY AROM. (CAS 64742-94-5):
ACUTE:
DERMAL:
LD50 RABBIT >2000 MG/KG
ORAL:
LD50 RAT >2000 MG/KG
SKIN CORROSION/IRRITATION:
PROLONGED SKIN CONTACT MAY CAUSE TEMPORARY IRRITATION.
SERIOUS EYE DAMAGE/EYE IRRITATION:
DIRECT CONTACT WITH EYES MAY CAUSE TEMPORARY IRRITATION.
RESPIRATORY OR SKIN SENSITIZATION:
RESPIRATORY SENSITIZATION: NOT A RESPIRATORY SENSITIZER.
SKIN SENSITIZATION:
THIS PRODUCT IS NOT EXPECTED TO CAUSE SKIN SENSITIZATION.
GERM CELL MUTAGENICITY:
NO DATA AVAILABLE TO INDICATE PRODUCT OR ANY COMPONENTS PRESENT AT GREATER
THAN 0.1% ARE MUTAGENIC OR GENOTOXIC.
CARCINOGENICITY: NOT CLASSIFIABLE AS TO CARCINOGENICITY TO HUMANS.
IARC MONOGRAPHS. OVERALL EVALUATION OF CARCINOGENICITY: NOT LISTED.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1052):
NOT REGULATED.
US. NATIONAL TOXICOLOGY PROGRAM (NTP) REPORT ON CARCINOGENS: NOT LISTED.
REPRODUCTIVE TOXICITY:
THIS PRODUCT IS NOT EXPECTED TO CAUSE REPRODUCTIVE OR DEVELOPMENTAL
EFFECTS.
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE: NOT CLASSIFIED.
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE: NOT CLASSIFIED.
ASPIRATION HAZARD: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
CHRONIC EFFECTS: PROLONGED INHALATION MAY BE HARMFUL.
FURTHER INFORMATION: NONE KNOWN.
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY:
THE PRODUCT IS NOT CLASSIFIED AS ENVIRONMENTALLY HAZARDOUS. HOWEVER, THIS
DOES NOT EXCLUDE THE POSSIBILITY THAT LARGE OR FREQUENT SPILLS CAN HAVE A
HARMFUL OR DAMAGING EFFECT ON THE ENVIRONMENT.
COMPONENTS SPECIES TEST RESULTS
DISTILLATES PETROLEUM HYDROTREATED LIGHT (CAS 64742-47-8):
AQUATIC:
FISH LC50 RAINBOW TROUT,DONALDSON TROUT 2.9 MG/L, 96 HOURS
(ONCORHYNCHUS MYKISS)
PERSISTENCE AND DEGRADABILITY:
NO DATA IS AVAILABLE ON THE DEGRADABILITY OF ANY INGREDIENTS IN THE
MIXTURE.
BIOACCUMULATIVE POTENTIAL:
MOBILITY IN SOIL: NO DATA AVAILABLE.
OTHER ADVERSE EFFECTS:
THE PRODUCT CONTAINS VOLATILE ORGANIC COMPOUNDS WHICH HAVE A PHOTOCHEMICAL
OZONE CREATION POTENTIAL.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL INSTRUCTIONS:
COLLECT AND RECLAIM OR DISPOSE IN SEALED CONTAINERS AT LICENSED WASTE
DISPOSAL SITE. CONTENTS UNDER PRESSURE. DO NOT PUNCTURE, INCINERATE OR
CRUSH. DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
LOCAL DISPOSAL REGULATIONS:
DISPOSE IN ACCORDANCE WITH ALL APPLICABLE REGULATIONS.
HAZARDOUS WASTE CODE:
THE WASTE CODE SHOULD BE ASSIGNED IN DISCUSSION BETWEEN THE USER, THE
PRODUCER AND THE WASTE DISPOSAL COMPANY.
D003: WASTE REACTIVE MATERIAL
WASTE FROM RESIDUES / UNUSED PRODUCTS:
DISPOSE OF IN ACCORDANCE WITH LOCAL REGULATIONS. EMPTY CONTAINERS OR LINERS
MAY RETAIN SOME PRODUCT RESIDUES. THIS MATERIAL AND ITS CONTAINER MUST BE
DISPOSED OF IN A SAFE MANNER (SEE: DISPOSAL INSTRUCTIONS).
CONTAMINATED PACKAGING:
SINCE EMPTIED CONTAINERS MAY RETAIN PRODUCT RESIDUE, FOLLOW LABEL WARNINGS
EVEN AFTER CONTAINER IS EMPTIED. EMPTY CONTAINERS SHOULD BE TAKEN TO AN
APPROVED WASTE HANDLING SITE FOR RECYCLING OR DISPOSAL. DO NOT RE-USE EMPTY
CONTAINERS.
| 14. TRANSPORT INFORMATION | |
DOT:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, FLAMMABLE
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
LABEL(S): 2.1
PACKING GROUP: NOT AVAILABLE.
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: NO
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
SPECIAL PROVISIONS: N82
PACKAGING EXCEPTIONS: 306
PACKAGING NON BULK: NONE
PACKAGING BULK: NONE
IATA:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, FLAMMABLE
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
PACKING GROUP: NOT AVAILABLE.
ENVIRONMENTAL HAZARDS: NO
ERG CODE: 10L
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
OTHER INFORMATION:
PASSENGER AND CARGO AIRCRAFT: ALLOWED WITH RESTRICTIONS.
CARGO AIRCRAFT ONLY: ALLOWED WITH RESTRICTIONS.
IMDG:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, FLAMMABLE
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
LABEL(S): 2.1
8PACKING GROUP: NOT AVAILABLE.
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: NO
EMS: F-D, S-U
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
TRANSPORT IN BULK ACCORDING TO ANNEX II OF MARPOL 73/78 AND THE IBC CODE:
NOT APPLICABLE.
DOT: FLAMMABLE GAS, CLASS/DIVISION 2.1
IATA; IMDG: CLASS 2.1 - FLAMMABLE GASES
GENERAL INFORMATION:
AVOID TRANSPORT ON VEHICLES WHERE THE LOAD SPACE IS NOT SEPARATED FROM THE
DRIVER'S COMPARTMENT. ENSURE VEHICLE DRIVER IS AWARE OF THE POTENTIAL
HAZARDS OF THE LOAD AND KNOWS WHAT TO DO IN THE EVENT OF AN ACCIDENT OR AN
EMERGENCY. BEFORE TRANSPORTING PRODUCT CONTAINERS: ENSURE THAT CONTAINERS
ARE FIRMLY SECURED. ENSURE CYLINDER VALVE IS CLOSED AND NOT LEAKING. ENSURE
VALVE OUTLET CAP NUT OR PLUG (WHERE PROVIDED) IS CORRECTLY FITTED. ENSURE
VALVE PROTECTION DEVICE (WHERE PROVIDED) IS CORRECTLY FITTED. ENSURE
ADEQUATE VENTILATION. ENSURE COMPLIANCE WITH APPLICABLE REGULATIONS.
| 15. REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
TSCA SECTION 12(B) EXPORT NOTIFICATION (40 CFR 707, SUBPT. D):
NOT REGULATED.
CERCLA HAZARDOUS SUBSTANCE LIST (40 CFR 302.4): NOT LISTED.
SARA 304 EMERGENCY RELEASE NOTIFICATION: NOT REGULATED.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1052):
NOT REGULATED.
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA):
SARA 302 EXTREMELY HAZARDOUS SUBSTANCE: NOT LISTED.
SARA 311/312 HAZARDOUS CHEMICAL: YES
CLASSIFIED HAZARD CATEGORIES:
FLAMMABLE (GASES, AEROSOLS, LIQUIDS, OR SOLIDS)
GAS UNDER PRESSURE
ASPIRATION HAZARD
SARA 313 (TRI REPORTING): NOT REGULATED.
OTHER FEDERAL REGULATIONS:
CLEAN AIR ACT (CAA) SECTION 112 HAZARDOUS AIR POLLUTANTS (HAPS) LIST:
NOT REGULATED.
CLEAN AIR ACT (CAA) SECTION 112(R) ACCIDENTAL RELEASE PREVENTION (40 CFR
68.130): NOT REGULATED.
SAFE DRINKING WATER ACT (SDWA): NOT REGULATED.
US STATE REGULATIONS:
US. NEW JERSEY WORKER AND COMMUNITY RIGHT-TO-KNOW ACT:
CARBON DIOXIDE (CAS 124-38-9)
CALIFORNIA PROPOSITION 65:
US. CALIFORNIA. CANDIDATE CHEMICALS LIST. SAFER CONSUMER PRODUCTS
REGULATIONS (CAL. CODE REGS, TIT. 22, 69502.3, SUBD. (A)):
DISTILLATES PETROLEUM HYDROTREATED MED (CAS 64742-46-7)
INTERNATIONAL INVENTORIES:
COUNTRY(S) OR INVENTORY NAME ON INVENTORY
REGION (YES/NO)*
AUSTRALIA AUSTRALIAN INVENTORY OF CHEMICAL NO
SUBSTANCES (AICS)
CANADA DOMESTIC SUBSTANCES LIST (DSL) YES
CANADA NON-DOMESTIC SUBSTANCES LIST (NDSL) NO
CHINA INVENTORY OF EXISTING CHEMICAL SUBSTANCES NO
IN CHINA (IECSC)
EUROPE EUROPEAN INVENTORY OF EXISTING COMMERCIAL YES
CHEMICAL SUBSTANCES (EINECS)
EUROPE EUROPEAN LIST OF NOTIFIED CHEMICAL NO
SUBSTANCES (ELINCS)
JAPAN INVENTORY OF EXISTING AND NEW CHEMICAL NO
SUBSTANCES (ENCS)
KOREA EXISTING CHEMICALS LIST (ECL) NO
NEW ZEALAND NEW ZEALAND INVENTORY NO
PHILIPPINES PHILIPPINE INVENTORY OF CHEMICALS AND NO
CHEMICAL SUBSTANCES (PICCS)
TAIWAN TAIWAN TOXIC CHEMICAL SUBSTANCES (TCS) NO
UNITED STATES TOXIC SUBSTANCES CONTROL ACT (TSCA) YES
& PUERTO RICO INVENTORY
*A "YES" INDICATES THAT ALL COMPONENTS OF THIS PRODUCT COMPLY WITH THE
INVENTORY REQUIREMENTS ADMINISTERED BY THE GOVERNING COUNTRY(S)
A "NO" INDICATES THAT ONE OR MORE COMPONENTS OF THE PRODUCT ARE NOT LISTED
OR EXEMPT FROM LISTING ON THE INVENTORY ADMINISTERED BY THE GOVERNING
COUNTRY(S).
| 16. OTHER INFORMATION, INCLUDING DATE OF PREPARATION | |
OR LAST REVISION
ISSUE DATE: 11-01-2016
REVISION DATE: 11-13-2017
VERSION #: 02
DISCLAIMER:
ITW PRO BRANDS CANNOT ANTICIPATE ALL CONDITIONS UNDER WHICH THIS
INFORMATION AND ITS PRODUCT, OR THE PRODUCTS OF OTHER MANUFACTURERS IN
COMBINATION WITH ITS PRODUCT, MAY BE USED. IT IS THE USER'S RESPONSIBILITY
TO ENSURE SAFE CONDITIONS FOR HANDLING, STORAGE AND DISPOSAL OF THE
PRODUCT, AND TO ASSUME LIABILITY FOR LOSS, INJURY, DAMAGE OR EXPENSE DUE TO
IMPROPER USE. THE INFORMATION PROVIDED IN THIS SAFETY DATA SHEET IS CORRECT
TO THE BEST OF OUR KNOWLEDGE, INFORMATION AND BELIEF AT THE DATE OF ITS
PUBLICATION. THE INFORMATION GIVEN IS DESIGNED ONLY AS A GUIDANCE FOR SAFE
HANDLING, USE, PROCESSING, STORAGE, TRANSPORTATION, DISPOSAL AND RELEASE
AND IS NOT TO BE CONSIDERED A WARRANTY OR QUALITY SPECIFICATION. THE
INFORMATION RELATES ONLY TO THE SPECIFIC MATERIAL DESIGNATED AND MAY NOT BE
VALID FOR SUCH MATERIAL USED IN COMBINATION WITH ANY OTHER MATERIALS OR IN
ANY PROCESS, UNLESS SPECIFIED IN THE TEXT.
REVISION INFORMATION:
THIS DOCUMENT HAS UNDERGONE SIGNIFICANT CHANGES AND SHOULD BE REVIEWED IN
ITS ENTIRETY.
MATERIAL NAME: LPS(R*) KB88 (AEROSOL)
SDS US