| Common Name: | LOCTITE THREADLOCKER 2760 HIGH STRENGTH, 32525 |
| Manufacturer: | HENKEL |
| SDS Revision Date: | 12/19/2022 |
| SDS Format: | No Format Specified |
| Item Number(s): | 1LLP9 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
HENKEL
SAFETY DATA SHEET
REVISION NUMBER: 006.0
ISSUE DATE: 12/19/2022
| 1. PRODUCT AND COMPANY IDENTIFICATION |  |
PRODUCT NAME: LOCTITE(R) THREADLOCKER 2760 HIGH STRENGTH
IDH NUMBER: 303440
PRODUCT TYPE/USE: ANAEROBIC SEALANT
ITEM NUMBER: 32525
RESTRICTION OF USE: NONE IDENTIFIED
REGION: UNITED STATES
COMPANY ADDRESS:
HENKEL CORPORATION
ONE HENKEL WAY
ROCKY HILL, CONNECTICUT 06067
CONTACT INFORMATION:
TELEPHONE: +1 (860) 571-5100
MEDICAL EMERGENCY PHONE:
POISON CONTROL CENTER: 1-877-671-4608 (TOLL FREE) OR 1-303-592-1711
TRANSPORT EMERGENCY PHONE:
CHEMTREC: 1-800-424-9300 (TOLL FREE) OR 1-703-527-3887
INTERNET: WWW.HENKELNA.COM
| 2. HAZARDS IDENTIFICATION | |
EMERGENCY OVERVIEW:
WARNING:
MAY CAUSE AN ALLERGIC SKIN REACTION.
SUSPECTED OF CAUSING CANCER.
HAZARD CLASS HAZARD CATEGORY
SKIN SENSITIZATION 1
CARCINOGENICITY 2
PICTOGRAM(S):
HEALTH HAZARD
EXCLAMATION MARK
PRECAUTIONARY STATEMENTS:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. AVOID BREATHING VAPORS, MIST,
OR SPRAY. CONTAMINATED WORK CLOTHING SHOULD NOT BE ALLOWED OUT OF THE
WORKPLACE. WEAR PROTECTIVE GLOVES, CLOTHING, EYE AND FACE PROTECTION.
RESPONSE:
IF ON SKIN: WASH WITH PLENTY OF WATER.
IF EXPOSED OR CONCERNED: GET MEDICAL ATTENTION.
IF SKIN IRRITATION OR RASH OCCURS:
GET MEDICAL ATTENTION. WASH CONTAMINATED CLOTHING BEFORE REUSE.
STORAGE: STORE LOCKED UP.
DISPOSAL:
DISPOSE OF CONTENTS AND/OR CONTAINER ACCORDING TO FEDERAL, STATE/PROVINCIAL
AND LOCAL GOVERNMENTAL REGULATIONS.
3 % OF THE MIXTURE CONSISTS OF INGREDIENT(S) OF UNKNOWN ACUTE TOXICITY.
CLASSIFICATION COMPLIES WITH OSHA HAZARD COMMUNICATION STANDARD
(29 CFR 1910.1200) AND IS CONSISTENT WITH THE PROVISIONS OF THE
UNITED NATIONS GLOBALLY HARMONIZED SYSTEM OF CLASSIFICATION AND
LABELING OF CHEMICALS (GHS).
SEE SECTION 11 FOR ADDITIONAL TOXICOLOGICAL INFORMATION.
| 3. COMPOSITION / INFORMATION ON INGREDIENTS | |
HAZARDOUS COMPONENT(S) CAS NUMBER PERCENTAGE*
METHACRYLATE MONOMER UNKNOWN 60 - 80
SILOXANES AND SILICONES, DI-ME, 67762-90-7 1 - 5
REACTION PRODUCTS WITH SILICA
CUMENE HYDROPEROXIDE 80-15-9 0.1 - 1
1-ACETYL-2-PHENYLHYDRAZINE 114-83-0 0.1 - 1
CUMENE 98-82-8 0.1 - 1
* EXACT PERCENTAGES MAY VARY OR ARE TRADE SECRET. CONCENTRATION RANGE IS
PROVIDED TO ASSIST USERS IN PROVIDING APPROPRIATE PROTECTIONS.
| 4. FIRST AID MEASURES | |
INHALATION:
MOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. GET MEDICAL ATTENTION.
SKIN CONTACT:
IMMEDIATELY FLUSH SKIN WITH PLENTY OF WATER (USING SOAP, IF AVAILABLE).
REMOVE CONTAMINATED CLOTHING AND FOOTWEAR. WASH CLOTHING BEFORE REUSE.
GET MEDICAL ATTENTION.
EYE CONTACT:
RINSE IMMEDIATELY WITH PLENTY OF WATER, ALSO UNDER THE EYELIDS, FOR AT
LEAST 15 MINUTES. GET MEDICAL ATTENTION.
INGESTION:
DO NOT INDUCE VOMITING UNLESS DIRECTED TO DO SO BY MEDICAL PERSONNEL.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. GET MEDICAL
ATTENTION.
SYMPTOMS: SEE SECTION 11.
| 5. FIRE FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
WATER SPRAY (FOG), FOAM, DRY CHEMICAL OR CARBON DIOXIDE.
SPECIAL FIREFIGHTING PROCEDURES:
WEAR SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING,
SUCH AS TURN-OUT GEAR. IN CASE OF FIRE, KEEP CONTAINERS COOL WITH WATER
SPRAY.
UNUSUAL FIRE OR EXPLOSION HAZARDS:
UNCONTROLLED POLYMERIZATION MAY OCCUR AT HIGH TEMPERATURES RESULTING IN
EXPLOSIONS OR RUPTURE OF STORAGE CONTAINERS.
HAZARDOUS COMBUSTION PRODUCTS:
OXIDES OF CARBON. TOXIC FLUORINE COMPOUNDS. IRRITATING ORGANIC VAPOURS.
| 6. ACCIDENTAL RELEASE MEASURES | |
USE PERSONAL PROTECTION RECOMMENDED IN SECTION 8, ISOLATE THE HAZARD AREA
AND DENY ENTRY TO UNNECESSARY AND UNPROTECTED PERSONNEL.
ENVIRONMENTAL PRECAUTIONS:
DO NOT ALLOW PRODUCT TO ENTER SEWER OR WATERWAYS.
CLEAN-UP METHODS:
REMOVE ALL SOURCES OF IGNITION. EVACUATE AND VENTILATE SPILL AREA; DIKE
SPILL TO PREVENT ENTRY INTO WATER SYSTEM; WEAR FULL PROTECTIVE EQUIPMENT
DURING CLEAN-UP. SOAK UP WITH INERT ABSORBENT MATERIAL (E.G. SAND, SILICA
GEL, ACID BINDER, UNIVERSAL BINDER, SAWDUST). SCRAPE UP AS MUCH MATERIAL
AS POSSIBLE. STORE IN A PARTLY FILLED, CLOSED CONTAINER UNTIL DISPOSAL.
REFER TO SECTION 8 "EXPOSURE CONTROLS / PERSONAL PROTECTION" PRIOR TO
CLEAN UP.
| 7. HANDLING AND STORAGE | |
HANDLING:
USE ONLY WITH ADEQUATE VENTILATION. PREVENT CONTACT WITH EYES, SKIN AND
CLOTHING. DO NOT BREATHE VAPOR AND MIST. WASH THOROUGHLY AFTER HANDLING.
KEEP CONTAINER CLOSED. REFER TO SECTION 8.
STORAGE:
FOR SAFE STORAGE, STORE AT OR BELOW 38 DEG. C (100.4 DEG. F)
KEEP IN A COOL, WELL VENTILATED AREA AWAY FROM HEAT, SPARKS AND OPEN FLAME.
KEEP CONTAINER TIGHTLY CLOSED UNTIL READY FOR USE.
| 8. EXPOSURE CONTROLS / PERSONAL PROTECTION | |
EMPLOYERS SHOULD COMPLETE AN ASSESSMENT OF ALL WORKPLACES TO DETERMINE
THE NEED FOR, AND SELECTION OF, PROPER EXPOSURE CONTROLS AND PROTECTIVE
EQUIPMENT FOR EACH TASK PERFORMED.
HAZARDOUS COMPONENT(S) ACGIH TLV OSHA PEL AIHA WEEL OTHER
METHACRYLATE MONOMER NONE NONE NONE NONE
SILOXANES AND SILICONES, 10 MG/M3 TWA 15 MG/M3 NONE NONE
DI-ME, REACTION PRODUCTS INHALABLE TWA TOTAL
WITH SILICA DUST. DUST.
3 MG/M3 TWA 5 MG/M3
RESPIRABLE TWA
FRACTION. RESPIRABLE
FRACTION.
CUMENE HYDROPEROXIDE NONE NONE 1 PPM NONE
(6 MG/M3)
TWA (SKIN)
1-ACETYL-2- NONE NONE NONE NONE
PHENYLHYDRAZINE
CUMENE 5 PPM TWA 50 PPM NONE NONE
(245 MG/M3)
PEL (SKIN)
ENGINEERING CONTROLS:
PROVIDE ADEQUATE LOCAL EXHAUST VENTILATION TO MAINTAIN WORKER EXPOSURE
BELOW EXPOSURE LIMITS.
RESPIRATORY PROTECTION:
USE NIOSH APPROVED RESPIRATOR IF THERE IS POTENTIAL TO EXCEED EXPOSURE
LIMIT(S).
EYE/FACE PROTECTION:
SAFETY GOGGLES OR SAFETY GLASSES WITH SIDE SHIELDS. FULL FACE PROTECTION
SHOULD BE USED IF THE POTENTIAL FOR SPLASHING OR SPRAYING OF PRODUCT
EXISTS. SAFETY SHOWERS AND EYE WASH STATIONS SHOULD BE AVAILABLE.
SKIN PROTECTION:
USE CHEMICAL RESISTANT, IMPERMEABLE CLOTHING INCLUDING GLOVES AND EITHER
AN APRON OR BODY SUIT TO PREVENT SKIN CONTACT. NEOPRENE GLOVES.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
PHYSICAL STATE: LIQUID
COLOR: RED
ODOR: MILD
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT APPLICABLE, PRODUCT IS NON-POLAR/APROTIC.
VAPOR PRESSURE:
<5 MM Hg (27 DEG. C (80.6 DEG. F)) <0.13 MBAR (20 DEG. C (68 DEG. F))
BOILING POINT/RANGE: >149 DEG. C (>300.2 DEG. F) >150 DEG. C (>302 DEG. F)
MELTING POINT/ RANGE: NOT AVAILABLE.
SPECIFIC GRAVITY: 1.14
VAPOR DENSITY: >1 20 DEG. C
FLASH POINT: >100 DEG. C (>212 DEG. F) TAGLIABUE CLOSED CUP
FLAMMABLE/EXPLOSIVE LIMITS - LOWER: NOT AVAILABLE.
FLAMMABLE/EXPLOSIVE LIMITS - UPPER: NOT AVAILABLE.
AUTOIGNITION TEMPERATURE: NOT AVAILABLE.
FLAMMABILITY: THE PRODUCT IS NOT FLAMMABLE.
EVAPORATION RATE: NOT AVAILABLE.
SOLUBILITY IN WATER: SLIGHT
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
VOC CONTENT: 0.22 %; 2.48 G/L
VISCOSITY: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
| 10. STABILITY AND REACTIVITY | |
STABILITY: STABLE UNDER NORMAL CONDITIONS OF STORAGE AND USE.
HAZARDOUS REACTIONS:
NONE UNDER NORMAL PROCESSING. POLYMERIZATION MAY OCCUR AT ELEVATED
TEMPERATURE OR IN THE PRESENCE OF INCOMPATIBLE MATERIALS.
HAZARDOUS DECOMPOSITION PRODUCTS:
OXIDES OF CARBON. TOXIC FLUORINE COMPOUNDS. IRRITATING ORGANIC VAPOURS.
INCOMPATIBLE MATERIALS:
STRONG OXIDIZING AGENTS. STRONG REDUCING AGENTS. ALKALIS. OXYGEN
SCAVENGERS. FREE RADICAL INITIATORS. OTHER POLYMERIZATION INITIATORS.
REACTIVITY: NOT AVAILABLE.
CONDITIONS TO AVOID:
ELEVATED TEMPERATURES. HEAT, FLAMES, SPARKS AND OTHER SOURCES OF IGNITION.
STORE AWAY FROM INCOMPATIBLE MATERIALS.
| 11. TOXICOLOGICAL INFORMATION | |
RELEVANT ROUTES OF EXPOSURE: SKIN, INHALATION, EYES, INGESTION
POTENTIAL HEALTH EFFECTS/SYMPTOMS:
INHALATION:
INHALATION OF VAPORS OR MISTS OF THE PRODUCT MAY BE IRRITATING TO THE
RESPIRATORY SYSTEM.
SKIN CONTACT: CAUSES SKIN IRRITATION. MAY CAUSE ALLERGIC SKIN REACTION.
EYE CONTACT: CAUSES SERIOUS EYE IRRITATION.
INGESTION: MAY CAUSE GASTROINTESTINAL TRACT IRRITATION IF SWALLOWED.
HAZARDOUS COMPONENT(S) LD50S AND LC50S IMMEDIATE AND DELAYED
HEALTH EFFECTS
METHACRYLATE MONOMER NONE NO DATA
SILOXANES AND SILICONES, NONE NO DATA
DI-ME, REACTION PRODUCTS
WITH SILICA
CUMENE HYDROPEROXIDE NONE ALLERGEN, CENTRAL
NERVOUS SYSTEM,
CORROSIVE, IRRITANT,
MUTAGEN
1-ACETYL-2- ORAL LD50 (MOUSE): ALLERGEN, BLOOD,
PHENYLHYDRAZINE 270 MG/KG KIDNEY, MUTAGEN,
SOME EVIDENCE OF
CARCINOGENICITY
CUMENE ORAL LD50 (RAT): CENTRAL NERVOUS
2.91 G/KG SYSTEM, IRRITANT, LUNG
ORAL LD50 (RAT):
1,400 MG/KG
HAZARDOUS COMPONENT(S) NTP IARC OSHA CARCINOGEN
CARCINOGEN CARCINOGEN (SPECIFICALLY
REGULATED)
METHACRYLATE MONOMER NO NO NO
SILOXANES AND SILICONES, NO NO NO
DI-ME, REACTION PRODUCTS
WITH SILICA
CUMENE HYDROPEROXIDE NO NO NO
1-ACETYL-2-PHENYLHYDRAZINE NO NO NO
CUMENE REASONABLY GROUP 2B NO
ANTICIPATED
TO BE A HUMAN
CARCINOGEN.
| 12. ECOLOGICAL INFORMATION | |
ECOLOGICAL INFORMATION: NOT AVAILABLE.
| 13. DISPOSAL CONSIDERATIONS | |
INFORMATION PROVIDED IS FOR UNUSED PRODUCT ONLY.
RECOMMENDED METHOD OF DISPOSAL:
FOLLOW ALL LOCAL, STATE, FEDERAL AND PROVINCIAL REGULATIONS FOR DISPOSAL.
| 14. TRANSPORT INFORMATION | |
THE TRANSPORT INFORMATION PROVIDED IN THIS SECTION ONLY APPLIES TO
THE MATERIAL/FORMULATION ITSELF, AND IS NOT SPECIFIC TO ANY PACKAGE/
CONFIGURATION.
U.S. DEPARTMENT OF TRANSPORTATION GROUND (49 CFR):
PROPER SHIPPING NAME:
RQ, ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID, N.O.S.
HAZARD CLASS OR DIVISION: 9
IDENTIFICATION NUMBER: UN 3082
PACKING GROUP: III
DOT HAZARDOUS SUBSTANCE(S): ALPHA,ALPHA-DIMETHYLBENZYLHYDROPEROXIDE
INTERNATIONAL AIR TRANSPORTATION (ICAO/IATA):
PROPER SHIPPING NAME:
RQ, ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID, N.O.S.
HAZARD CLASS OR DIVISION: 9
IDENTIFICATION NUMBER: UN 3082
PACKING GROUP: III
WATER TRANSPORTATION (IMO/IMDG):
PROPER SHIPPING NAME:
RQ, ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID, N.O.S.
HAZARD CLASS OR DIVISION: 9
IDENTIFICATION NUMBER: UN 3082
PACKING GROUP: III
| 15. REGULATORY INFORMATION | |
UNITED STATES REGULATORY INFORMATION:
TSCA 8 (B) INVENTORY STATUS:
ALL COMPONENTS ARE LISTED AS ACTIVE OR ARE EXEMPT FROM LISTING ON THE
TOXIC SUBSTANCES CONTROL ACT (TSCA) INVENTORY.
TSCA 12 (B) EXPORT NOTIFICATION: NONE ABOVE REPORTING DE MINIMIS
CERCLA/SARA SECTION 302 EHS: NONE ABOVE REPORTING DE MINIMIS.
CERCLA/SARA SECTION 311/312: IMMEDIATE HEALTH, DELAYED HEALTH
CERCLA/SARA SECTION 313:
THIS PRODUCT CONTAINS THE FOLLOWING TOXIC CHEMICALS SUBJECT TO THE
REPORTING REQUIREMENTS OF SECTION 313 OF THE EMERGENCY PLANNING AND
COMMUNITY RIGHT-TO-KNOW ACT OF 1986 (40 CFR 372). CUMENE (CAS# 98-82-8).
CERCLA REPORTABLE QUANTITY:
CUMENE HYDROPEROXIDE (CAS# 80-15-9) 10 LBS. (4.54 KG)
CALIFORNIA PROPOSITION 65:
THIS PRODUCT CONTAINS A CHEMICAL KNOWN IN THE STATE OF CALIFORNIA TO CAUSE
CANCER. THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA
TO CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
CANADA REGULATORY INFORMATION:
CEPA DSL/NDSL STATUS:
ALL COMPONENTS ARE LISTED ON OR ARE EXEMPT FROM LISTING ON THE CANADIAN
DOMESTIC SUBSTANCES LIST.
| 16. OTHER INFORMATION | |
THIS SAFETY DATA SHEET CONTAINS CHANGES FROM THE PREVIOUS VERSION IN
SECTIONS: 2,3,8,9,11
PREPARED BY: PRODUCT SAFETY AND REGULATORY AFFAIRS
ISSUE DATE: 12/19/2022
DISCLAIMER:
THE DATA CONTAINED HEREIN ARE FURNISHED FOR INFORMATION ONLY AND ARE
BELIEVED TO BE RELIABLE. HOWEVER, HENKEL CORPORATION AND ITS AFFILIATES
("HENKEL") DOES NOT ASSUME RESPONSIBILITY FOR ANY RESULTS OBTAINED BY
PERSONS OVER WHOSE METHODS HENKEL HAS NO CONTROL. IT IS THE USER'S
RESPONSIBILITY TO DETERMINE THE SUITABILITY OF HENKEL'S PRODUCTS OR ANY
PRODUCTION METHODS MENTIONED HEREIN FOR A PARTICULAR PURPOSE, AND TO ADOPT
SUCH PRECAUTIONS AS MAY BE ADVISABLE FOR THE PROTECTION OF PROPERTY AND
PERSONS AGAINST ANY HAZARDS THAT MAY BE INVOLVED IN THE HANDLING AND USE
OF ANY HENKEL'S PRODUCTS. IN LIGHT OF THE FOREGOING, HENKEL SPECIFICALLY
DISCLAIMS ALL WARRANTIES, EXPRESS OR IMPLIED, INCLUDING WARRANTIES OF
MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE, ARISING FROM SALE
OR USE OF HENKEL'S PRODUCTS. HENKEL FURTHER DISCLAIMS ANY LIABILITY FOR
CONSEQUENTIAL OR INCIDENTAL DAMAGES OF ANY KIND, INCLUDING LOST PROFITS.
THIS SAFETY DATA SHEET HAS BEEN GENERATED BASED ON OSHA HAZARD
COMMUNICATION STANDARD (29 CFR 1910.1200) AND PROVIDES INFORMATION
IN ACCORDANCE WITH U.S. FEDERAL LAW ONLY. NO WARRANTY OR REPRESENTATION
OF ANY KIND IS GIVEN WITH RESPECT TO THE SUBSTANTIVE OR EXPORT LAWS OF
ANY OTHER JURISDICTION OR COUNTRY. PLEASE CONFIRM THAT THE INFORMATION
PROVIDED HEREIN CONFORMS TO THE SUBSTANTIVE EXPORT OR OTHER LAW OF ANY
OTHER JURISDICTION PRIOR TO EXPORT. PLEASE CONTACT HENKEL PRODUCT SAFETY
AND REGULATORY AFFAIRS FOR ADDITIONAL ASSISTANCE.