| Common Name: | TAP MAGIC XTRA-FOAMY (AEROSOL) |
| Manufacturer: | STECO |
| SDS Revision Date: | 9/21/2015 |
| SDS Format: | GHS-US |
| Item Number(s): | 1MCU5 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
SAFETY DATA SHEET
ACCORDING TO 29CFR1910/1200 AND GHS REV 3
EFFECTIVE DATE: 10.24.2014
TAP MAGIC XTRA-FOAMY (AEROSOL)
| SECTION 1: IDENTIFICATION OF THE SUBSTANCE/MIXTURE |  |
AND OF THE SUPPLIER
PRODUCT NAME: TAP MAGIC XTRA-FOAMY (AEROSOL)
MANUFACTURER/SUPPLIER TRADE NAME:
MANUFACTURER/SUPPLIER ARTICLE NUMBER: 80017FL
RECOMMENDED USES OF THE PRODUCT AND RESTRICTIONS ON USE:
MACHINING, CUTTING, TAPPING, AND METAL PROCESSING.
MANUFACTURER DETAILS:
THE STECO CORPORATION
2330 CANTRELL ROAD
LITTLE ROCK, AR 72202
501-375-5644
STECO@TAPMAGIC.COM
EMERGENCY TELEPHONE NUMBER:
CHEMTEL:
(24-HOUR): (800) 255-3924
| SECTION 2: HAZARDS IDENTIFICATION | |
CLASSIFICATION OF THE SUBSTANCE OR MIXTURE:
FLAME: FLAMMABLE
GAS CYLINDER: COMPRESSED GAS
H222: EXTREMELY FLAMMABLE AEROSOL.
H304: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
SIGNAL WORD: DANGER
HAZARD STATEMENTS:
EXTREMELY FLAMMABLE AEROSOL.
PRESSURIZED CONTAINER:
MAY BURST IF HEATED.
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
PRECAUTIONARY STATEMENTS:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE.
KEEP AWAY FROM HEAT/SPARKS/OPEN FLAMES/HOT SURFACES. NO SMOKING.
DO NOT SPRAY ON AN OPEN FLAME OR OTHER IGNITION SOURCE.
PRESSURIZED CONTAINER. DO NOT PIERCE OR BURN, EVEN AFTER USE.
DO NOT BREATHE DUST/FUME/GAS/MIST/VAPORS/SPRAY.
IF SWALLOWED: CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
IF ON SKIN: GENTLY WASH WITH PLENTY OF SOAP AND WATER.
IF INHALED:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
IF EYE IRRITATION PERSISTS GET MEDICAL ADVICE/ATTENTION.
IN CASE OF FIRE:
EVACUATE AREA. FIGHT FIRE REMOTELY DUE TO THE RISK OF EXPLOSION.
PROTECT FROM SUNLIGHT. STORE IN A WELL VENTILATED PLACE.
DISPOSE OF CONTENTS AND CONTAINER AS INSTRUCTED IN SECTION 13.
OTHER NON-GHS CLASSIFICATION: NONE
| SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS | |
INGREDIENTS:
CAS: 64742-52-5 HYDROTREATED OIL 70-90 %
CAS: 68476-86-8 PROPANE/N-BUTANE 10-20 %
PERCENTAGES ARE BY WEIGHT
| SECTION 4: FIRST AID MEASURES | |
DESCRIPTION OF FIRST AID MEASURES:
AFTER INHALATION:
SUPPLY FRESH AIR; CONSULT DOCTOR IN CASE OF COMPLAINTS. IF ASPIRATED, SEEK
MEDICAL ATTENTION IMMEDIATELY. PROVIDE OXYGEN TREATMENT IF AFFECTED PERSON
HAS DIFFICULTY BREATHING.
AFTER SKIN CONTACT:
IMMEDIATELY WASH WITH WATER AND SOAP AND RINSE THOROUGHLY. IF SKIN
IRRITATION CONTINUES, CONSULT A DOCTOR.
AFTER EYE CONTACT:
REMOVE CONTACT LENSES IF WORN. RINSE OPENED EYE FOR AT LEAST 15 - 20
MINUTES UNDER RUNNING WATER. IF SYMPTOMS PERSIST, CONSULT A DOCTOR.
AFTER SWALLOWING:
RINSE OUT MOUTH AND THEN DRINK PLENTY OF WATER. DO NOT INDUCE VOMITING.
MOST IMPORTANT SYMPTOMS AND EFFECTS, BOTH ACUTE AND DELAYED:
BREATHING DIFFICULTY. COUGHING. IRRITANT.
INDICATION OF ANY IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT
NEEDED: NONE
| SECTION 5: FIREFIGHTING MEASURES | |
EXTINGUISHING MEDIA:
SUITABLE EXTINGUISHING AGENTS: FOAM. CARBON DIOXIDE. DRY CHEMICAL.
UNSUITABLE EXTINGUISHING AGENTS: WATER JET, AS IT MAY SPREAD THE FIRE.
SPECIAL HAZARDS ARISING FROM THE SUBSTANCE OR MIXTURE: CARBON MONOXIDE.
ADVICE FOR FIREFIGHTERS:
PROTECTIVE EQUIPMENT:
USE SELF-CONTAINED BREATHING APPARATUS (SCBA) AND FULL BUNKER TURNOUT GEAR
IN A SUSTAINED FIRE. WEAR FULLY PROTECTIVE SUIT.
ADDITIONAL INFORMATION (PRECAUTIONS):
INCOMPLETE COMBUSTION IS LIKELY TO GIVE RISE TO A COMPLEX MIXTURE OF
AIRBORNE SOLID AND LIQUID PARTICULATES AND GASES, INCLUDING CARBON
MONOXIDE AND UNIDENTIFIED ORGANIC AND INORGANIC COMPOUNDS.
| SECTION 6: ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
USE RESPIRATORY PROTECTIVE DEVICE AGAINST THE EFFECTS OF RELEASE. WEAR
PROTECTIVE EQUIPMENT. KEEP UNPROTECTED PERSONS AWAY. ENSURE ADEQUATE
VENTILATION. PARTICULAR DANGER OF SLIPPING ON LEAKED/SPILLED PRODUCT.
ENVIRONMENTAL PRECAUTIONS:
FOR SMALL SPILLS, SOAK UP WITH SHOP TOWELS OR ABSORBENT MATERIAL SUCH AS
OIL-DRY OR VERMICULITE. FOR LARGE SPILLS, ANY LEAKS SHOULD BE STOPPED.
SPILL SHOULD BE CONTAINED, THEN CLEANED UP USING VACUUM TRUCK OR ABSORBENT
MATERIAL.
METHODS AND MATERIAL FOR CONTAINMENT AND CLEANING UP:
IF INERT ABSORBENTS ARE EMPLOYED IN SPILL CONTAINMENT OR CLEAN-UP, THESE
ABSORBENTS MUST BE NON-BIODEGRADABLE MATERIALS IF DESTINED FOR LANDFILL
DISPOSAL. SUITABLE ABSORBENTS INCLUDE NATURAL MINERALS (CLAY), ACTIVATED
CHARCOAL, MAN- MADE POLYMERS (HD POLYETHYLENE). PICK UP MECHANICALLY. SEND
FOR RECOVERY OR DISPOSAL IN SUITABLE RECEPTACLES. DISPOSE CONTAMINATED
MATERIAL AS WASTE ACCORDING TO SECTION 13.
REFERENCE TO OTHER SECTIONS: NONE
| SECTION 7: HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
NO SMOKING IN AREA WHERE THIS PRODUCT IS USED. AVOID HANDLING OR USE NEAR
EXTREME HEAT, IGNITION SOURCES OR OPEN FLAME. PREVENT RELEASE OR FORMATION
OF AEROSOLS EXCEPT AS INTENDED. AVOID SPLASHES OR SPRAY IN ENCLOSED AREAS.
USE ONLY IN WELL VENTILATED AREAS. PREVENT FROM FREEZING. DO NOT SPRAY ON
AN OPEN FLAME OR OTHER IGNITION SOURCE.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
STORE AWAY FROM OXIDIZING AGENTS. DO NOT STORE TOGETHER WITH
ALKALIS/CAUSTIC SOLUTIONS. STORE AWAY FROM FOODSTUFFS. KEEP AWAY FROM
HEAT, HOT SURFACES, SPARKS, OPEN FLAMES AND OTHER IGNITION SOURCES.
PROTECT FROM SUNLIGHT.
| SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION | |
CHEMICAL GOGGLES
GLOVES
FULL SUIT
CONTROL PARAMETERS: NO APPLICABLE OCCUPATIONAL EXPOSURE LIMITS.
APPROPRIATE ENGINEERING CONTROLS:
THE PRODUCT DOES NOT CONTAIN ANY RELEVANT QUANTITIES OF MATERIALS WITH
CRITICAL VALUES THAT HAVE TO BE MONITORED AT THE WORKPLACE.
RESPIRATORY PROTECTION: NOT REQUIRED UNDER NORMAL CONDITIONS OF USE.
PROTECTION OF SKIN:
PROTECTIVE GLOVES SHOULD BE WORN. THE GLOVE MATERIAL HAS TO BE IMPERMEABLE
AND RESISTANT TO THE PRODUCT. SELECTION OF THE GLOVE MATERIAL SHOULD BE
BASED ON THE PENETRATION TIME, RATES OF DIFFUSION AND THE DEGRADATION OF
THE GLOVE MATERIAL. THE EXACT BREAK THROUGH TIME HAS TO BE DETERMINED BY
THE MANUFACTURER OF THE PROTECTIVE GLOVES.
EYE PROTECTION: CONTACT LENSES SHOULD NOT BE WORN.
GENERAL HYGIENIC MEASURES:
THE USUAL PRECAUTIONARY MEASURES FOR HANDLING CHEMICALS SHOULD BE
FOLLOWED. KEEP AWAY FROM FOODSTUFFS, BEVERAGES AND FEED. IMMEDIATELY
REMOVE ALL SOILED AND CONTAMINATED CLOTHING. WASH HANDS BEFORE BREAKS
AND AT THE END OF WORK. AVOID CONTACT WITH THE EYES AND SKIN. DO NOT
INHALE GASES / FUMES / AEROSOLS.
| SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE (PHYSICAL STATE, COLOR):
PRESSURIZED LIQUID W/ PROPELLANT, AMBER
ODOR: MILD
ODOR THRESHOLD: NOT DETERMINED. NEUTRAL
PH-VALUE: (NON-AQUEOUS).
MELTING/FREEZING POINT:
BOILING POINT/BOILING RANGE:
FLASH POINT (CLOSED CUP): >150 DEG. C
EVAPORATION RATE:
FLAMMABILITY (SOLID, GASEOUS): FLAMMABLE AEROSOL.
DENSITY AT 20 DEG. C: 1.3G/L
EXPLOSION LIMIT LOWER:
EXPLOSION LIMIT UPPER:
VAPOR PRESSURE AT 20 DEG. C:
VAPOR DENSITY:
RELATIVE DENSITY:
SOLUBILITIES: NONE
PARTITION COEFFICIENT (N- OCTANOL/WATER):
AUTO/SELF-IGNITION TEMPERATURE:
DECOMPOSITION TEMPERATURE:
VISCOSITY:
A. KINEMATIC: 1100 CST@50C
B. DYNAMIC:
| SECTION 10: STABILITY AND REACTIVITY | |
REACTIVITY: FLAMMABLE, PRESSURIZED GAS.
CHEMICAL STABILITY:
STABLE AT AMBIENT TEMPERATURES AND PRESSURE. ELEVATED TEMPERATURE AND
EXPOSURE TO STRONG ALKALIS, OXIDIZERS, AND/OR ACIDS WILL PROMOTE
DECOMPOSITION. AT NORMAL ROOM TEMPERATURES, DECOMPOSITION IS VIRTUALLY
NIL. EXPOSURE TO STRONG DIRECT SUNLIGHT MAY CAUSE DECOMPOSITION AND
DISCOLORATION OF SOME COMPONENTS PRESENT IN THIS PRODUCT.
POSSIBLE HAZARDOUS REACTIONS:
REACTS WITH STRONG OXIDIZING AGENTS. REACTS WITH STRONG ACIDS AND ALKALI.
TOXIC FUMES MAY BE RELEASED IF HEATED ABOVE THE DECOMPOSITION POINT.
CONDITIONS TO AVOID: STORE AWAY FROM OXIDIZING AGENTS.
INCOMPATIBLE MATERIALS: CONTACT WITH ALKALI MATERIALS. OXIDIZERS. ACIDS.
HAZARDOUS DECOMPOSITION PRODUCTS:
INCOMPLETE COMBUSTION IS LIKELY TO GIVE RISE TO A COMPLEX MIXTURE OF
AIRBORNE SOLID AND LIQUID PARTICULATES AND GASES, INCLUDING CARBON
MONOXIDE AND UNIDENTIFIED ORGANIC AND INORGANIC COMPOUNDS.
| SECTION 11: TOXICOLOGICAL INFORMATION | |
ACUTE TOXICITY: NO ADDITIONAL INFORMATION.
CHRONIC TOXICITY: NO ADDITIONAL INFORMATION.
SKIN CORROSION/IRRITATION: NO ADDITIONAL INFORMATION.
SERIOUS EYE DAMAGE/IRRITATION: NO ADDITIONAL INFORMATION.
RESPIRATORY OR SKIN SENSITIZATION: NO ADDITIONAL INFORMATION.
CARCINOGENICITY: SEE SECTION 15.
GERM CELL MUTAGENICITY: NO ADDITIONAL INFORMATION.
REPRODUCTIVE TOXICITY: NO ADDITIONAL INFORMATION.
STOT-SINGLE AND REPEATED EXPOSURE: NO ADDITIONAL INFORMATION.
ADDITIONAL TOXICOLOGICAL INFORMATION: NO ADDITIONAL INFORMATION.
| SECTION 12: ECOLOGICAL INFORMATION | |
ECOTOXICITY: NO ADDITIONAL INFORMATION.
PERSISTENCE AND DEGRADABILITY: NO ADDITIONAL INFORMATION.
BIOACCUMULATIVE POTENTIAL: NO ADDITIONAL INFORMATION.
MOBILITY IN SOIL: NO ADDITIONAL INFORMATION.
OTHER ADVERSE EFFECTS: NO ADDITIONAL INFORMATION.
| SECTION 13: DISPOSAL CONSIDERATIONS | |
WASTE DISPOSAL RECOMMENDATIONS:
DO NOT ALLOW PRODUCT TO REACH SEWAGE SYSTEM OR OPEN WATER. IT IS THE
RESPONSIBILITY OF THE WASTE GENERATOR TO PROPERLY CHARACTERIZE ALL WASTE
MATERIALS ACCORDING TO APPLICABLE REGULATORY ENTITIES (US 40CFR262.11).
DO NOT PIERCE OR BURN AEROSOL CONTAINERS.
| SECTION 14: TRANSPORT INFORMATION | |
US DOT:
UN NUMBER:
ADR, ADN, DOT, IMDG, IATA: 1950
LIMITED QUANTITY EXCEPTION: LTD QTY.
BULK:
RQ (IF APPLICABLE): NONE
PROPER SHIPPING NAME: FLAMMABLE (LIMITED QUANTITIES).
HAZARD CLASS: 2.1
PACKING GROUP: N/A.
MARINE POLLUTANT (IF APPLICABLE): YES
COMMENTS: NONE
ENVIRONMENT
NON BULK:
RQ (IF APPLICABLE): NONE
PROPER SHIPPING NAME: FLAMMABLE (LIMITED QUANTITIES).
HAZARD CLASS: 2.1
PACKING GROUP: N/A.
MARINE POLLUTANT (IF APPLICABLE): YES
COMMENTS: NONE
ENVIRONMENT
| SECTION 15: REGULATORY INFORMATION | |
UNITED STATES (USA):
SARA SECTION 311/312 (SPECIFIC TOXIC CHEMICAL LISTINGS):
NONE OF THE INGREDIENTS ARE LISTED.
SARA SECTION 313 (SPECIFIC TOXIC CHEMICAL LISTINGS):
NONE OF THE INGREDIENTS ARE LISTED.
RCRA (HAZARDOUS WASTE CODE): NONE OF THE INGREDIENTS ARE LISTED.
TSCA (TOXIC SUBSTANCES CONTROL ACT): ALL INGREDIENTS ARE LISTED.
CERCLA (COMPREHENSIVE ENVIRONMENTAL RESPONSE, COMPENSATION, AND
LIABILITY ACT): NONE OF THE INGREDIENTS ARE LISTED.
PROPOSITION 65 (CALIFORNIA):
CHEMICALS KNOWN TO CAUSE CANCER: NONE OF THE INGREDIENTS ARE LISTED.
CHEMICALS KNOWN TO CAUSE REPRODUCTIVE TOXICITY FOR FEMALES:
NONE OF THE INGREDIENTS ARE LISTED.
CHEMICALS KNOWN TO CAUSE REPRODUCTIVE TOXICITY FOR MALES:
NONE OF THE INGREDIENTS ARE LISTED.
CHEMICALS KNOWN TO CAUSE DEVELOPMENTAL TOXICITY:
NONE OF THE INGREDIENTS ARE LISTED.
CANADA:
CANADIAN DOMESTIC SUBSTANCES LIST (DSL): ALL INGREDIENTS ARE LISTED.
| SECTION 16: OTHER INFORMATION | |
NFPA:
2
3
1
HMIS:
2
3
1
GHS FULL TEXT PHRASES: NONE
ABBREVIATIONS AND ACRONYMS: NONE
EFFECTIVE DATE: 10.24.2014
LAST UPDATED: 09.21.2015
CREATED BY GLOBAL SAFETY MANAGEMENT, 1-813-435-5161
WWW.GSMSDS.COM