| Common Name: | MM AIRBRAKE SYSTEM ANTIFREEZE 4/1GA |
| Manufacturer: | NITEO PRODUCTS |
| SDS Revision Date: | 9/5/2018 |
| SDS Format: | No Format Specified |
| Item Number(s): | 1MRA3 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
NITEO(TM) PRODUCTS
SAFETY DATA SHEET
MOTOR MEDIC(R*) AIR BRAKE SYS ANTIFREEZE & RUST GUARD
VERSION: 2.0
REVISION DATE: 09/05/2018
SDS NUMBER: 600000001407
DATE OF LAST ISSUE:
DATE OF FIRST ISSUE: 07/12/2018
| SECTION 1. IDENTIFICATION |  |
PRODUCT NAME: MM AIRBRAKE SYSTEM ANTIFREEZE 4/1GA
PRODUCT CODE: M2834
MANUFACTURER OR SUPPLIER'S DETAILS:
COMPANY NAME OF SUPPLIER: NITEO PRODUCTS, LLC
ADDRESS: DALLAS TX 75225
EMAIL ADDRESS: EHS@NITEOPRODUCTS.COM
TELEPHONE: 1-844-696-4836
EMERGENCY TELEPHONE NUMBER: 1-800-424-9300 / 1-703-741-5970
RECOMMENDED USE OF THE CHEMICAL AND RESTRICTIONS ON USE:
RECOMMENDED USE: ANTI-FREEZING AGENTS
RESTRICTIONS ON USE: USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA.
| SECTION 2. HAZARDS IDENTIFICATION | |
GHS CLASSIFICATION IN ACCORDANCE WITH 29 CFR 1910.1200:
FLAMMABLE LIQUIDS: CATEGORY 2
ACUTE TOXICITY (ORAL): CATEGORY 3
ACUTE TOXICITY (INHALATION): CATEGORY 3
ACUTE TOXICITY (DERMAL): CATEGORY 3
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE:
CATEGORY 1 (CENTRAL NERVOUS SYSTEM, EYES)
GHS LABEL ELEMENTS:
HAZARD PICTOGRAMS:
FLAME
SKULLS AND CROSSBONES
HEALTH HAZARD
SIGNAL WORD: DANGER
HAZARD STATEMENTS:
HIGHLY FLAMMABLE LIQUID AND VAPOUR.
TOXIC IF SWALLOWED, IN CONTACT WITH SKIN OR IF INHALED.
CAUSES DAMAGE TO ORGANS (CENTRAL NERVOUS SYSTEM, EYES).
PRECAUTIONARY STATEMENTS:
PREVENTION:
KEEP AWAY FROM HEAT/SPARKS/OPEN FLAMES/HOT SURFACES. NO SMOKING.
KEEP CONTAINER TIGHTLY CLOSED.
GROUND/BOND CONTAINER AND RECEIVING EQUIPMENT.
USE EXPLOSION-PROOF ELECTRICAL/ VENTILATING/ LIGHTING EQUIPMENT.
USE ONLY NON-SPARKING TOOLS.
TAKE PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGE.
DO NOT BREATHE DUST/ FUME/ GAS/ MIST/ VAPOURS/ SPRAY.
WASH SKIN THOROUGHLY AFTER HANDLING.
DO NOT EAT, DRINK OR SMOKE WHEN USING THIS PRODUCT.
USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA.
WEAR PROTECTIVE GLOVES/ EYE PROTECTION/ FACE PROTECTION.
RESPONSE:
IF SWALLOWED: IMMEDIATELY CALL A POISON CENTER/DOCTOR. RINSE MOUTH.
IF ON SKIN (OR HAIR):
TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. RINSE SKIN WITH
WATER/SHOWER.
IF INHALED:
REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING. CALL
A POISON CENTER/DOCTOR.
IF EXPOSED: CALL A POISON CENTER OR DOCTOR/ PHYSICIAN.
TAKE OFF CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
IN CASE OF FIRE:
USE DRY SAND, DRY CHEMICAL OR ALCOHOL-RESISTANT FOAM TO EXTINGUISH.
STORAGE:
STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED.
STORE IN A WELL-VENTILATED PLACE. KEEP COOL.
STORE LOCKED UP.
DISPOSAL:
DISPOSE OF CONTENTS/ CONTAINER TO AN APPROVED WASTE DISPOSAL PLANT.
OTHER HAZARDS: NONE KNOWN.
| SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
SUBSTANCE / MIXTURE: MIXTURE
HAZARDOUS COMPONENTS:
CHEMICAL NAME CAS-NO. CONCENTRATION (% W/W)
METHANOL 67-56-1 >=90 - <100
ANY CONCENTRATION SHOWN AS A RANGE IS TO PROTECT CONFIDENTIALITY
OR IS DUE TO BATCH VARIATION.
| SECTION 4. FIRST AID MEASURES | |
GENERAL ADVICE:
MOVE OUT OF DANGEROUS AREA.
CONSULT A PHYSICIAN.
SHOW THIS SAFETY DATA SHEET TO THE DOCTOR IN ATTENDANCE.
DO NOT LEAVE THE VICTIM UNATTENDED.
IF INHALED:
IF UNCONSCIOUS, PLACE IN RECOVERY POSITION AND SEEK MEDICAL ADVICE.
IF SYMPTOMS PERSIST, CALL A PHYSICIAN.
IN CASE OF SKIN CONTACT:
IF ON CLOTHES, REMOVE CLOTHES.
CALL A PHYSICIAN OR POISON CONTROL CENTRE IMMEDIATELY.
IF ON SKIN, RINSE WELL WITH WATER.
IN CASE OF EYE CONTACT:
FLUSH EYES WITH WATER AS A PRECAUTION.
REMOVE CONTACT LENSES.
PROTECT UNHARMED EYE.
KEEP EYE WIDE OPEN WHILE RINSING.
IF SWALLOWED:
GET MEDICAL ATTENTION IMMEDIATELY.
RINSE MOUTH WITH WATER.
DO NOT GIVE MILK OR ALCOHOLIC BEVERAGES.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
IF SYMPTOMS PERSIST, CALL A PHYSICIAN.
MOST IMPORTANT SYMPTOMS AND EFFECTS, BOTH ACUTE AND DELAYED:
TOXIC IF SWALLOWED, IN CONTACT WITH SKIN OR IF INHALED.
CAUSES DAMAGE TO ORGANS.
THIS PRODUCT CONTAINS METHANOL WHICH CAN CAUSE INTOXICATION AND CENTRAL
NERVOUS SYSTEM DEPRESSION. METHANOL IS METABOLIZED TO FORMIC ACID AND
FORMALDEHYDE. THESE METABOLITES CAN CAUSE METABOLIC ACIDOSIS, VISUAL
DISTURBANCES AND BLINDNESS. SINCE METABOLISM IS REQUIRED FOR THESE TOXIC
SYMPTOMS, THEIR ONSET MAY BE DELAYED FROM 6 TO 30 HOURS FOLLOWING
INGESTION. ETHANOL COMPETES FOR THE SAME METABOLIC PATHWAY AND HAS BEEN
USED TO PREVENT METHANOL METABOLISM. ETHANOL ADMINISTRATION IS INDICATED
IN SYMPTOMATIC PATIENTS OR AT BLOOD METHANOL CONCENTRATIONS ABOVE
20 UG/DL. METHANOL IS EFFECTIVELY REMOVED BY HEMODIALYSIS.
| SECTION 5. FIREFIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
WATER SPRAY
CARBON DIOXIDE (CO2)
DRY CHEMICAL
ALCOHOL-RESISTANT FOAM
UNSUITABLE EXTINGUISHING MEDIA: HIGH VOLUME WATER JET
SPECIFIC HAZARDS DURING FIRE-FIGHTING:
DO NOT ALLOW RUN-OFF FROM FIRE FIGHTING TO ENTER DRAINS OR WATER COURSES.
HAZARDOUS COMBUSTION PRODUCTS: CARBON OXIDES
SPECIFIC EXTINGUISHING METHODS:
PRODUCT IS COMPATIBLE WITH STANDARD FIRE-FIGHTING AGENTS.
FURTHER INFORMATION:
USE EXTINGUISHING MEASURES THAT ARE APPROPRIATE TO LOCAL CIRCUMSTANCES AND
THE SURROUNDING ENVIRONMENT.
FIRE RESIDUES AND CONTAMINATED FIRE EXTINGUISHING WATER MUST BE DISPOSED
OF IN ACCORDANCE WITH LOCAL REGULATIONS.
USE A WATER SPRAY TO COOL FULLY CLOSED CONTAINERS.
SPECIAL PROTECTIVE EQUIPMENT FOR FIREFIGHTERS:
IN THE EVENT OF FIRE, WEAR SELF-CONTAINED BREATHING APPARATUS.
| SECTION 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
USE PERSONAL PROTECTIVE EQUIPMENT.
REMOVE ALL SOURCES OF IGNITION.
ENSURE ADEQUATE VENTILATION.
AVOID BREATHING DUST.
BEWARE OF VAPOURS ACCUMULATING TO FORM EXPLOSIVE CONCENTRATIONS. VAPOURS
CAN ACCUMULATE IN LOW AREAS.
EVACUATE PERSONNEL TO SAFE AREAS.
PERSONS NOT WEARING PROTECTIVE EQUIPMENT SHOULD BE EXCLUDED FROM AREA OF
SPILL UNTIL CLEAN-UP HAS BEEN COMPLETED.
ENVIRONMENTAL PRECAUTIONS:
PREVENT FURTHER LEAKAGE OR SPILLAGE IF SAFE TO DO SO.
PREVENT PRODUCT FROM ENTERING DRAINS.
DO NOT FLUSH INTO SURFACE WATER OR SANITARY SEWER SYSTEM.
IF THE PRODUCT CONTAMINATES RIVERS AND LAKES OR DRAINS INFORM RESPECTIVE
AUTHORITIES.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
CONTAIN SPILLAGE, AND THEN COLLECT WITH NON-COMBUSTIBLE ABSORBENT MATERIAL,
(E.G. SAND, EARTH, DIATOMACEOUS EARTH, VERMICULITE) AND PLACE IN CONTAINER
FOR DISPOSAL ACCORDING TO LOCAL / NATIONAL REGULATIONS (SEE SECTION 13).
| SECTION 7. HANDLING AND STORAGE | |
ADVICE ON PROTECTION AGAINST FIRE AND EXPLOSION:
TAKE NECESSARY ACTION TO AVOID STATIC ELECTRICITY DISCHARGE (WHICH MIGHT
CAUSE IGNITION OF ORGANIC VAPOURS).
ELECTRICALLY BOND AND GROUND ALL CONTAINERS, PERSONNEL AND EQUIPMENT BEFORE
TRANSFER OR USE OF MATERIAL. SPECIAL PRECAUTIONS MAY BE NECESSARY TO
DISSIPATE STATIC ELECTRICITY FOR NON-CONDUCTIVE CONTAINERS. USE PROPER
BONDING AND GROUNDING DURING PRODUCT TRANSFER AS DESCRIBED IN NATIONAL FIRE
PROTECTION ASSOCIATION DOCUMENT NFPA 77.
KEEP AWAY FROM OPEN FLAMES, HOT SURFACES AND SOURCES OF IGNITION.
USE ONLY EXPLOSION-PROOF EQUIPMENT.
DO NOT SPRAY ON A NAKED FLAME OR ANY INCANDESCENT MATERIAL.
ADVICE ON SAFE HANDLING:
OPEN DRUM CAREFULLY AS CONTENT MAY BE UNDER PRESSURE.
AVOID FORMATION OF AEROSOL.
PROVIDE SUFFICIENT AIR EXCHANGE AND/OR EXHAUST IN WORK ROOMS.
DO NOT BREATHE VAPOURS/DUST.
DO NOT SMOKE.
TAKE PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGES.
DISPOSE OF RINSE WATER IN ACCORDANCE WITH LOCAL AND NATIONAL REGULATIONS.
CONTAINER HAZARDOUS WHEN EMPTY.
SMOKING, EATING AND DRINKING SHOULD BE PROHIBITED IN THE APPLICATION AREA.
FOR PERSONAL PROTECTION SEE SECTION 8.
CONDITIONS FOR SAFE STORAGE:
KEEP CONTAINER TIGHTLY CLOSED IN A DRY AND WELL-VENTILATED PLACE.
CONTAINERS WHICH ARE OPENED MUST BE CAREFULLY RESEALED AND KEPT UPRIGHT
TO PREVENT LEAKAGE.
OBSERVE LABEL PRECAUTIONS.
NO SMOKING.
FURTHER INFORMATION ON STORAGE STABILITY:
NO DECOMPOSITION IF STORED AND APPLIED AS DIRECTED.
| SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
COMPONENTS WITH WORKPLACE CONTROL PARAMETERS:
COMPONENTS CAS-NO. VALUE TYPE CONTROL BASIS
(FORM OF PARAMETERS /
EXPOSURE) PERMISSIBLE
CONCENTRATION
METHANOL 67-56-1 TWA 200 PPM ACGIH
STEL 250 PPM ACGIH
TWA 200 PPM NIOSH REL
260 MG/M3
ST 250 PPM NIOSH REL
325 MG/M3
TWA 200 PPM OSHA Z-1
260 MG/M3
STEL 250 PPM OSHA P0
325 MG/M3
TWA 200 PPM OSHA P0
260 MG/M3
BIOLOGICAL OCCUPATIONAL EXPOSURE LIMITS:
COMPONENTS CAS-NO. CONTROL BIOLOGICAL SAMPLING PERMISSIBLE BASIS
PARAMETERS SPECIMEN TIME CONCENTRATION
METHANOL 67-56-1 METHANOL URINE END OF 15 MG/L ACGIH
SHIFT BEI
(AS SOON
AS
POSSIBLE
AFTER
EXPOSURE
CEASES)
ENGINEERING MEASURES:
PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL EXHAUST) VENTILATION
TO MAINTAIN EXPOSURE BELOW EXPOSURE GUIDELINES (IF APPLICABLE) OR BELOW
LEVELS THAT CAUSE KNOWN, SUSPECTED OR APPARENT ADVERSE EFFECTS.
PERSONAL PROTECTIVE EQUIPMENT:
HAND PROTECTION:
REMARKS:
WEAR RESISTANT GLOVES (CONSULT YOUR SAFETY EQUIPMENT SUPPLIER). THE
SUITABILITY FOR A SPECIFIC WORKPLACE SHOULD BE DISCUSSED WITH THE PRODUCERS
OF THE PROTECTIVE GLOVES. DISCARD GLOVES THAT SHOW TEARS, PINHOLES, OR
SIGNS OF WEAR.
EYE PROTECTION:
NOT REQUIRED UNDER NORMAL CONDITIONS OF USE. WEAR SPLASH-PROOF SAFETY
GOGGLES IF MATERIAL COULD BE MISTED OR SPLASHED INTO EYES.
SKIN AND BODY PROTECTION:
CHOOSE BODY PROTECTION ACCORDING TO THE AMOUNT AND CONCENTRATION OF THE
DANGEROUS SUBSTANCE AT THE WORK PLACE.
WEAR AS APPROPRIATE:
IMPERVIOUS CLOTHING
FLAME-RESISTANT CLOTHING
SAFETY SHOES
REMOVE AND WASH CONTAMINATED CLOTHING BEFORE RE-USE.
HYGIENE MEASURES:
HANDLE IN ACCORDANCE WITH GOOD INDUSTRIAL HYGIENE AND SAFETY PRACTICE.
AVOID CONTACT WITH SKIN, EYES AND CLOTHING.
WASH HANDS BEFORE BREAKS AND IMMEDIATELY AFTER HANDLING THE PRODUCT.
| SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: LIQUID
ODOUR: ALCOHOL-LIKE
ODOUR THRESHOLD: NO DATA AVAILABLE
PH: NO DATA AVAILABLE
MELTING POINT/FREEZING POINT: -118 DEG. C
BOILING POINT/BOILING RANGE: 67 DEG. C
FLASH POINT: 11 DEG. C
METHOD: CLOSED CUP
EVAPORATION RATE: NO DATA AVAILABLE
SELF-IGNITION: NO DATA AVAILABLE
UPPER EXPLOSION LIMIT / UPPER FLAMMABILITY LIMIT: NO DATA AVAILABLE
LOWER EXPLOSION LIMIT / LOWER FLAMMABILITY LIMIT: NO DATA AVAILABLE
VAPOUR PRESSURE: 169.27 HPA (25 DEG. C)
RELATIVE VAPOUR DENSITY: >1 (AIR = 1.0)
DENSITY: 0.822 G/CM3 (15.6 DEG. C)
SOLUBILITY(IES):
WATER SOLUBILITY: COMPLETELY MISCIBLE
PARTITION COEFFICIENT N-OCTANOL/WATER: NO DATA AVAILABLE
VOC % BY WEIGHT: 99.6 %
| SECTION 10. STABILITY AND REACTIVITY | |
REACTIVITY: NO DECOMPOSITION IF STORED AND APPLIED AS DIRECTED.
CHEMICAL STABILITY: NO DECOMPOSITION IF STORED AND APPLIED AS DIRECTED.
POSSIBILITY OF HAZARDOUS REACTIONS:
NO DECOMPOSITION IF STORED AND APPLIED AS DIRECTED.
VAPOURS MAY FORM EXPLOSIVE MIXTURE WITH AIR.
CONDITIONS TO AVOID: HEAT, FLAMES AND SPARKS.
INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS
HAZARDOUS DECOMPOSITION PRODUCTS: CARBON OXIDES
| SECTION 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INHALATION
EYE CONTACT
SKIN CONTACT
INGESTION
ACUTE TOXICITY:
TOXIC IF SWALLOWED, IN CONTACT WITH SKIN OR IF INHALED.
PRODUCT:
ACUTE ORAL TOXICITY:
ACUTE TOXICITY ESTIMATE: 101.01 MG/KG
METHOD: CALCULATION METHOD
ACUTE INHALATION TOXICITY:
ACUTE TOXICITY ESTIMATE: 3.03 MG/L
EXPOSURE TIME: 4 H
TEST ATMOSPHERE: VAPOUR
METHOD: CALCULATION METHOD
ACUTE DERMAL TOXICITY:
ACUTE TOXICITY ESTIMATE: 303.03 MG/KG
METHOD: CALCULATION METHOD
COMPONENTS:
METHANOL:
ACUTE ORAL TOXICITY:
LDLO (HUMANS): 300 MG/KG
ASSESSMENT: THE COMPONENT/MIXTURE IS TOXIC AFTER SINGLE INGESTION.
ACUTE INHALATION TOXICITY:
TEST ATMOSPHERE: DUST/MIST
ASSESSMENT: THE COMPONENT/MIXTURE IS TOXIC AFTER SHORT TERM INHALATION.
ACUTE DERMAL TOXICITY:
LD50 (RABBIT): 12,800 MG/KG
ASSESSMENT: THE COMPONENT/MIXTURE IS TOXIC AFTER SINGLE CONTACT WITH SKIN.
SKIN CORROSION/IRRITATION: NOT CLASSIFIED BASED ON AVAILABLE INFORMATION.
COMPONENTS:
METHANOL:
SPECIES: RABBIT
RESULT: NO SKIN IRRITATION
SERIOUS EYE DAMAGE/EYE IRRITATION:
NOT CLASSIFIED BASED ON AVAILABLE INFORMATION.
COMPONENTS:
METHANOL:
SPECIES: RABBIT
RESULT: POSSIBLY IRRITATING TO EYES
RESPIRATORY OR SKIN SENSITISATION:
SKIN SENSITISATION: NOT CLASSIFIED BASED ON AVAILABLE INFORMATION.
RESPIRATORY SENSITISATION: NOT CLASSIFIED BASED ON AVAILABLE INFORMATION.
COMPONENTS:
METHANOL:
TEST TYPE: MAXIMISATION TEST
SPECIES: GUINEA PIG
ASSESSMENT: DOES NOT CAUSE SKIN SENSITISATION.
METHOD: OECD TEST GUIDELINE 406
GERM CELL MUTAGENICITY: NOT CLASSIFIED BASED ON AVAILABLE INFORMATION.
CARCINOGENICITY: NOT CLASSIFIED BASED ON AVAILABLE INFORMATION.
IARC:
NO COMPONENT OF THIS PRODUCT PRESENT AT LEVELS GREATER THAN OR EQUAL TO
0.1% IS IDENTIFIED AS PROBABLE, POSSIBLE OR CONFIRMED HUMAN CARCINOGEN
BY IARC.
OSHA:
NO COMPONENT OF THIS PRODUCT PRESENT AT LEVELS GREATER THAN OR EQUAL TO
0.1% IS ON OSHA'S LIST OF REGULATED CARCINOGENS.
NTP:
NO COMPONENT OF THIS PRODUCT PRESENT AT LEVELS GREATER THAN OR EQUAL TO
0.1% IS IDENTIFIED AS A KNOWN OR ANTICIPATED CARCINOGEN BY NTP.
REPRODUCTIVE TOXICITY: NOT CLASSIFIED BASED ON AVAILABLE INFORMATION.
STOT - SINGLE EXPOSURE:
CAUSES DAMAGE TO ORGANS (CENTRAL NERVOUS SYSTEM, EYES).
COMPONENTS:
METHANOL:
TARGET ORGANS: CENTRAL NERVOUS SYSTEM, EYES
ASSESSMENT:
THE SUBSTANCE OR MIXTURE IS CLASSIFIED AS SPECIFIC TARGET ORGAN TOXICANT,
SINGLE EXPOSURE, CATEGORY 1.
STOT - REPEATED EXPOSURE: NOT CLASSIFIED BASED ON AVAILABLE INFORMATION.
ASPIRATION TOXICITY: NOT CLASSIFIED BASED ON AVAILABLE INFORMATION.
FURTHER INFORMATION:
PRODUCT:
REMARKS: NO DATA AVAILABLE
| SECTION 12. ECOLOGICAL INFORMATION | |
| SECTION 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL METHODS:
WASTE FROM RESIDUES:
DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE LOCAL, STATE AND FEDERAL
REGULATIONS.
CONTAMINATED PACKAGING:
EMPTY REMAINING CONTENTS.
DISPOSE OF AS UNUSED PRODUCT.
DO NOT RE-USE EMPTY CONTAINERS.
DO NOT BURN, OR USE A CUTTING TORCH ON, THE EMPTY DRUM.
| SECTION 14. TRANSPORT INFORMATION | |
DANGEROUS GOODS DESCRIPTIONS (IF INDICATED BELOW) MAY NOT REFLECT
QUANTITY, END-USE, OR REGION-SPECIFIC EXCEPTIONS THAT CAN BE APPLIED.
CONSULT SHIPPING DOCUMENTS FOR DESCRIPTIONS THAT ARE SPECIFIC TO THE
SHIPMENT.
INTERNATIONAL REGULATIONS:
IATA-DGR:
UN/ID NO.: UN 1230
PROPER SHIPPING NAME: METHANOL
CLASS: 3
SUBSIDIARY RISK: 6.1
PACKING GROUP: II
LABELS: 3 (6.1)
PACKING INSTRUCTION (CARGO AIRCRAFT): 364
IMDG-CODE:
UN NUMBER: UN 1230
PROPER SHIPPING NAME: METHANOL
CLASS: 3
SUBSIDIARY RISK: 6.1
PACKING GROUP: II
LABELS: 3 (6.1)
EMS CODE: F-E, S-D
MARINE POLLUTANT: NO
TRANSPORT IN BULK ACCORDING TO ANNEX II OF MARPOL 73/78 AND THE IBC CODE:
NOT APPLICABLE FOR PRODUCT AS SUPPLIED.
NATIONAL REGULATIONS:
49 CFR:
UN/ID/NA NUMBER: UN 1230
PROPER SHIPPING NAME: METHANOL
CLASS: 3
PACKING GROUP: II
LABELS: 3
ERG CODE: 131
MARINE POLLUTANT: NO
| SECTION 15. REGULATORY INFORMATION | |
EPCRA - EMERGENCY PLANNING AND COMMUNITY RIGHT-TO-KNOW ACT:
CERCLA REPORTABLE QUANTITY:
COMPONENTS CAS-NO. COMPONENT RQ (LBS) CALCULATED PRODUCT RQ (LBS)
METHANOL 67-56-1 100 100 (F003)
METHANOL 67-56-1 5000 *
*: CALCULATED RQ EXCEEDS REASONABLY ATTAINABLE UPPER LIMIT.
SARA 304 EXTREMELY HAZARDOUS SUBSTANCES REPORTABLE QUANTITY:
THIS MATERIAL DOES NOT CONTAIN ANY COMPONENTS WITH A SECTION 304 EHS RQ.
SARA 302 EXTREMELY HAZARDOUS SUBSTANCES THRESHOLD PLANNING QUANTITY:
THIS MATERIAL DOES NOT CONTAIN ANY COMPONENTS WITH A SECTION 302 EHS TPQ.
SARA 311/312 HAZARDS:
FLAMMABLE (GASES, AEROSOLS, LIQUIDS, OR SOLIDS)
ACUTE TOXICITY (ANY ROUTE OF EXPOSURE)
SPECIFIC TARGET ORGAN TOXICITY (SINGLE OR REPEATED EXPOSURE)
SARA 313:
THE FOLLOWING COMPONENTS ARE SUBJECT TO REPORTING LEVELS ESTABLISHED BY
SARA TITLE III, SECTION 313:
METHANOL 67-56-1 >=90 - <=100 %
CALIFORNIA PROP. 65:
WARNING:
THIS PRODUCT CAN EXPOSE YOU TO CHEMICALS INCLUDING METHANOL, WHICH
IS/ARE KNOWN TO THE STATE OF CALIFORNIA TO CAUSE BIRTH DEFECTS OR
OTHER REPRODUCTIVE HARM. FOR MORE INFORMATION GO TO
WWW.P65WARNINGS.CA.GOV.
| SECTION 16. OTHER INFORMATION | |
FURTHER INFORMATION:
NFPA:
HEALTH 2
FLAMMABILITY 3
INSTABILITY 0
SPECIAL HAZARD.
REVISION DATE: 09/05/2018
THE INFORMATION PROVIDED IN THIS SAFETY DATA SHEET IS CORRECT TO THE BEST
OF OUR KNOWLEDGE, INFORMATION AND BELIEF AT THE DATE OF ITS PUBLICATION.
THE INFORMATION GIVEN IS DESIGNED ONLY AS A GUIDANCE FOR SAFE HANDLING,
USE, PROCESSING, STORAGE, TRANSPORTATION, DISPOSAL AND RELEASE AND IS NOT
TO BE CONSIDERED A WARRANTY OR QUALITY SPECIFICATION. THE INFORMATION
RELATES ONLY TO THE SPECIFIC MATERIAL DESIGNATED AND MAY NOT BE VALID
FOR SUCH MATERIAL USED IN COMBINATION WITH ANY OTHER MATERIALS OR IN
ANY PROCESS, UNLESS SPECIFIED IN THE TEXT.
US / EN