| Common Name: | WDCARE 1-GL 2PK VARA FLR OIL BS SATIN, 130231 |
| Manufacturer: | RUST-OLEUM |
| SDS Revision Date: | 1/6/2016 |
| SDS Format: | GHS-US |
| Item Number(s): | 1TBN6 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
DATE PRINTED: 1/6/2016
SAFETY DATA SHEET
RUST-OLEUM CORPORATION
TRUSTED QUALITY SINCE 1921
WWW.RUSTOLEUM.COM
| 1. IDENTIFICATION |  |
PRODUCT NAME: WDCARE 1-GL 2PK VARA FLR OIL BS SATIN
PRODUCT IDENTIFIER: 130231
PRODUCT USE/CLASS: WOODCOATING/OILBASED VARATHANE
REVISION DATE: 1/6/2016
SUPERCEDES DATE: 5/20/2015
SUPPLIER:
RUST-OLEUM CORPORATION
11 HAWTHORN PARKWAY
VERNON HILLS, IL 60061
USA
MANUFACTURER:
RUST-OLEUM CORPORATION
11 HAWTHORN PARKWAY
VERNON HILLS, IL 60061
USA
PREPARER: REGULATOR DEPARTMENT
EMERGENCY TELEPHONE:
24 HOUR HOTLINE: 847-367-7700
| 2. HAZARD IDENTIFICATION | |
CLASSIFICATION:
SYMBOL(S) OF PRODUCT:
FLAME
EXCLAMATION MARK
HEALTH HAZARD
SIGNAL WORD: DANGER
GHS HAZARD STATEMENTS:
FLAMMABLE LIQUID, CATEGORY 3:
H226: FLAMMABLE LIQUID AND VAPOR.
SKIN SENSITIZER, CATEGORY 1:
H317: MAY CAUSE AN ALLERGIC SKIN REACTION.
GERM CELL MUTAGENICITY, CATEGORY 1B:
H340: MAY CAUSE GENETIC DEFECTS.
CARCINOGENICITY, CATEGORY 1B:
H350: MAY CAUSE CANCER.
STOT, REPEATED EXPOSURE, CATEGORY 1:
H372: CAUSES DAMAGE TO ORGANS.
GHS LABEL PRECAUTIONARY STATEMENTS:
P201: OBTAIN SPECIAL INSTRUCTIONS BEFORE USE.
P210:
KEEP AWAY FROM HEAT, HOT SURFACES, SPARKS, OPEN FLAMES AND OTHER IGNITION
SOURCES. NO SMOKING.
P260: DO NOT BREATHE DUST, FUMES, GASES, MISTS, VAPORS, OR SPRAY.
P280:
WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION.
P281: USE PERSONAL PROTECTIVE EQUIPMENT AS REQUIRED.
P302+P352:
IF ON SKIN: WASH WITH PLENTY OF SOAP AND WATER.
P308+P313:
IF EXPOSED OR CONCERNED: GET MEDICAL ADVICE/ATTENTION.
P314: GET MEDICAL ADVICE/ATTENTION IF YOU FEEL UNWELL.
P333+P313:
IF SKIN IRRITATION OR RASH OCCURS: GET MEDICAL ADVICE/ATTENTION.
GHS SDS PRECAUTIONARY STATEMENTS:
P240: GROUND/BOND CONTAINER AND RECEIVING EQUIPMENT.
P241: USE EXPLOSION-PROOF ELECTRICAL/VENTILATING/LIGHTING/EQUIPMENT.
P242: USE ONLY NON-SPARKING TOOLS.
P243: TAKE PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGE.
P270: DO NOT EAT, DRINK OR SMOKE WHEN USING THIS PRODUCT.
P363: WASH CONTAMINATED CLOTHING BEFORE REUSE.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
HAZARDOUS SUBSTANCES:
CHEMICAL NAME CAS-NO. WT.% GHS SYMBOLS GHS STATEMENTS
RANGE
MINERAL SPIRITS 64742-88-7 25-50 GHS08 H304-372
NAPHTHA, PETROLEUM, 64742-49-0 2.5-10 GHS08 H304-340-350
HYDROTREATED LIGHT
STODDARD SOLVENT 8052-41-3 0.1-1.0 GHS08 H304-372
METHYL ETHYL 96-29-7 0.1-1.0 GHS05-GHS06 H302-312-
KETOXIME 317-318-331
ETHYLBENZENE 100-41-4 0.1-1.0 GHS02-GHS07- H225-304-332-373
GHS08
| 4. FIRST-AID MEASURES | |
FIRST AID - EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES HOLDING
EYELIDS OPEN. GET MEDICAL ATTENTION. DO NOT ALLOW RUBBING OF EYES OR
KEEPING EYES CLOSED.
FIRST AID - SKIN CONTACT:
WASH SKIN WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. GET MEDICAL
ATTENTION IF IRRITATION DEVELOPS OR PERSISTS.
FIRST AID - INHALATION:
REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. GET IMMEDIATE MEDICAL ATTENTION. DO
NOT USE MOUTH-TO-MOUTH RESUSCITATION. IF YOU EXPERIENCE DIFFICULTY IN
BREATHING, LEAVE THE AREA TO OBTAIN FRESH AIR. IF CONTINUED DIFFICULTY IS
EXPERIENCED, GET MEDICAL ASSISTANCE IMMEDIATELY.
FIRST AID - INGESTION:
ASPIRATION HAZARD:
DO NOT INDUCE VOMITING OR GIVE ANYTHING BY MOUTH BECAUSE THIS MATERIAL
CAN ENTER THE LUNGS AND CAUSE SEVERE LUNG DAMAGE. GET IMMEDIATE MEDICAL
ATTENTION. IF SWALLOWED, GET MEDICAL ATTENTION.
| 5. FIRE-FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
ALCOHOL FILM FORMING FOAM, CARBON DIOXIDE, DRY CHEMICAL, DRY SAND, WATER
FOG
UNUSUAL FIRE AND EXPLOSION HAZARDS:
CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT DUE TO BUILDUP
OF STEAM. KEEP CONTAINERS TIGHTLY CLOSED. COMBUSTIBLE LIQUID AND VAPOR. NO
UNUSUAL FIRE OR EXPLOSION HAZARDS NOTED.
SPECIAL FIREFIGHTING PROCEDURES:
WATER MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT PRESSURE BUILDUP
AND POSSIBLE AUTOIGNITION OR EXPLOSION. EVACUATE AREA AND FIGHT FIRE FROM
A SAFE DISTANCE. USE WATER SPRAY TO KEEP FIRE-EXPOSED CONTAINERS COOL.
CONTAINERS MAY EXPLODE WHEN HEATED.
| 6. ACCIDENTAL RELEASE MEASURES | |
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED:
CONTAIN SPILLED LIQUID WITH SAND OR EARTH. DO NOT USE COMBUSTIBLE MATERIALS
SUCH AS SAWDUST. REMOVE ALL SOURCES OF IGNITION, VENTILATE AREA AND REMOVE
WITH INERT ABSORBENT AND NON-SPARKING TOOLS. DISPOSE OF ACCORDING TO LOCAL,
STATE (PROVINCIAL) AND FEDERAL REGULATIONS. DO NOT INCINERATE CLOSED
CONTAINERS.
| 7. HANDLING AND STORAGE | |
HANDLING:
WASH THOROUGHLY AFTER HANDLING. WASH HANDS BEFORE EATING. REMOVE
CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE. USE ONLY WITH ADEQUATE
VENTILATION. FOLLOW ALL MSDS/LABEL PRECAUTIONS EVEN AFTER CONTAINER IS
EMPTIED BECAUSE IT MAY RETAIN PRODUCT RESIDUES. AVOID BREATHING FUMES,
VAPORS, OR MIST. AVOID CONTACT WITH EYES, SKIN AND CLOTHING. AVOID CONTACT
WITH EYES.
STORAGE:
STORE IN A DRY, WELL VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED WHEN
NOT IN USE. KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE FROM HEAT, ELECTRICAL
EQUIPMENT, SPARKS AND OPEN FLAME. DO NOT STORE ABOVE 120 DEG. F. STORE
LARGE QUANTITIES IN BUILDINGS DESIGNED AND PROTECTED FOR STORAGE OF NFPA
CLASS II COMBUSTIBLE LIQUIDS. KEEP AWAY FROM HEAT, SPARKS, FLAME AND
SOURCES OF IGNITION. KEEP CONTAINER CLOSED WHEN NOT IN USE. AVOID EXCESS
HEAT.
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
CHEMICAL NAME CAS-NO. WEIGHT % LESS THAN
MINERAL SPIRITS 64742-88-7 40.0
NAPHTHA, PETROLEUM, 64742-49-0 10.0
HYDROTREATED LIGHT
STODDARD SOLVENT 8052-41-3 1.0
METHYL ETHYL KETOXIME 96-29-7 1.0
ETHYLBENZENE 100-41-4 1.0
CHEMICAL NAME ACGIH ACGIH OSHA OSHA
TLV-TWA TLV-STEL PEL-TWA PEL-CEILING
MINERAL SPIRITS N.E. N.E. N.E. N.E.
NAPHTHA, PETROLEUM, N.E. N.E. N.E. N.E.
HYDROTREATED LIGHT
STODDARD SOLVENT 100 PPM N.E. 500 PPM N.E.
METHYL ETHYL KETOXIME 10 PPM N.E. N.E. N.E.
ETHYLBENZENE 20 PPM N.E. 100 PPM N.E.
PERSONAL PROTECTION:
ENGINEERING CONTROLS:
USE PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING
CONTROLS TO CONTROL AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS.
PREVENT BUILD-UP OF VAPORS BY OPENING ALL DOORS AND WINDOWS TO ACHIEVE
CROSS-VENTILATION.
RESPIRATORY PROTECTION:
A RESPIRATORY PROTECTION PROGRAM THAT MEETS OSHA 1910.134 AND ANSI Z88.2
REQUIREMENTS MUST BE FOLLOWED WHENEVER WORKPLACE CONDITIONS WARRANT A
RESPIRATOR'S USE. A NIOSH/MSHA APPROVED AIR PURIFYING RESPIRATOR WITH AN
ORGANIC VAPOR CARTRIDGE OR CANISTER MAY BE PERMISSIBLE UNDER CERTAIN
CIRCUMSTANCES WHERE AIRBORNE CONCENTRATIONS ARE EXPECTED TO EXCEED EXPOSURE
LIMITS.
PROTECTION PROVIDED BY AIR PURIFYING RESPIRATORS IS LIMITED. USE A POSITIVE
PRESSURE AIR SUPPLIED RESPIRATOR IF THERE IS ANY POTENTIAL FOR AN
UNCONTROLLED RELEASE, EXPOSURE LEVELS ARE NOT KNOWN, OR IN ANY OTHER
CIRCUMSTANCES WHERE AIR PURIFYING RESPIRATORS MAY NOT PROVIDE ADEQUATE
PROTECTION.
SKIN PROTECTION:
USE GLOVES TO PREVENT PROLONGED SKIN CONTACT. USE IMPERVIOUS GLOVES TO
PREVENT SKIN CONTACT AND ABSORPTION OF THIS MATERIAL THROUGH THE SKIN.
NITRILE OR NEOPRENE GLOVES MAY AFFORD ADEQUATE SKIN PROTECTION.
EYE PROTECTION:
USE SAFETY EYEWEAR DESIGNED TO PROTECT AGAINST SPLASH OF LIQUIDS.
OTHER PROTECTIVE EQUIPMENT:
REFER TO SAFETY SUPERVISOR OR INDUSTRIAL HYGIENIST FOR FURTHER GUIDANCE
REGARDING TYPES OF PERSONAL PROTECTIVE EQUIPMENT AND THEIR APPLICATIONS.
REFER TO SAFETY SUPERVISOR OR INDUSTRIAL HYGIENIST FOR FURTHER INFORMATION
REGARDING PERSONAL PROTECTIVE EQUIPMENT AND ITS APPLICATION.
HYGIENIC PRACTICES:
WASH THOROUGHLY WITH SOAP AND WATER BEFORE EATING, DRINKING OR SMOKING.
REMOVE CONTAMINATED CLOTHING IMMEDIATELY AND LAUNDER BEFORE REUSE.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: LIQUID
PHYSICAL STATE: LIQUID
ODOR: SOLVENT LIKE
ODOR THRESHOLD: N.E.
RELATIVE DENSITY: 0.908
PH: N.D.
FREEZE POINT, DEG. C: N.D.
VISCOSITY: N.D.
SOLUBILITY IN WATER: NONE
PARTITION COEFFICIENT, N-OCTANOL/WATER: N.D.
DECOMPOSITION TEMP., DEG. C: N.D.
BOILING RANGE, DEG. C: 136 - 537
EXPLOSIVE LIMITS, VOL%: 1.0 - 6.0
FLAMMABILITY: SUPPORTS COMBUSTION
FLASH POINT, DEG. C: 41
EVAPORATION RATE: SLOWER THAN ETHER
AUTO-IGNITION TEMP., DEG. C: N.D.
VAPOR DENSITY: HEAVIER THAN AIR
VAPOR PRESSURE: N.D.
(SEE "OTHER INFORMATION" SECTION FOR ABBREVIATION LEGEND)
| 10. STABILITY AND REACTIVITY | |
CONDITIONS TO AVOID:
AVOID TEMPERATURES ABOVE 120 DEG. F (49 DEG. C). AVOID CONTACT WITH STRONG
ACID AND STRONG BASES. AVOID ALL POSSIBLE SOURCES OF IGNITION.
INCOMPATIBILITY:
INCOMPATIBLE WITH STRONG OXIDIZING AGENTS, STRONG ACIDS AND STRONG
ALKALIES.
HAZARDOUS DECOMPOSITION:
BY OPEN FLAME, CARBON MONOXIDE AND CARBON DIOXIDE.WHEN HEATED TO
DECOMPOSITION, IT EMITS ACRID SMOKE AND IRRITATING FUMES. CONTAINS
SOLVENTS WHICH MAY FORM CARBON MONOXIDE, CARBON DIOXIDE, AND FORMALDEHYDE.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR UNDER NORMAL CONDITIONS.
STABILITY: THIS PRODUCT IS STABLE UNDER NORMAL STORAGE CONDITIONS.
| 11. TOXICOLOGICAL INFORMATION | |
EFFECTS OF OVEREXPOSURE - EYE CONTACT:
CAUSES EYE IRRITATION. SUBSTANCE CAUSES MODERATE EYE IRRITATION.
EFFECTS OF OVEREXPOSURE - SKIN CONTACT:
SUBSTANCE MAY CAUSE SLIGHT SKIN IRRITATION. MAY CAUSE SKIN IRRITATION.
EFFECTS OF OVEREXPOSURE - INHALATION:
HARMFUL IF INHALED. HIGH GAS, VAPOR, MIST OR DUST CONCENTRATIONS MAY BE
HARMFUL IF INHALED. AVOID BREATHING FUMES, SPRAY, VAPORS, OR MIST. MAY
CAUSE HEADACHES AND DIZZINESS. HIGH VAPOR CONCENTRATIONS ARE IRRITATING TO
THE EYES, NOSE, THROAT AND LUNGS. PROLONGED OR EXCESSIVE INHALATION MAY
CAUSE RESPIRATORY TRACT IRRITATION.
EFFECTS OF OVEREXPOSURE - INGESTION:
IRRITATING TO THE NOSE, THROAT AND RESPIRATORY TRACT. HARMFUL IF
SWALLOWED. ASPIRATION HAZARD IF SWALLOWED; CAN ENTER LUNGS AND CAUSE
DAMAGE.
EFFECTS OF OVEREXPOSURE - CHRONIC HAZARDS:
REPORTS HAVE ASSOCIATED REPEATED AND PROLONGED OCCUPATIONAL OVEREXPOSURE TO
SOLVENTS WITH PERMANENT BRAIN AND NERVOUS SYSTEM DAMAGE. IARC LISTS
ETHYLBENZENE AS A POSSIBLE HUMAN CARCINOGEN (GROUP 2B).
PRIMARY ROUTE(S) OF ENTRY:
EYE CONTACT, INGESTION, INHALATION, SKIN ABSORPTION, SKIN CONTACT
ACUTE TOXICITY VALUES:
THE ACUTE EFFECTS OF THIS PRODUCT HAVE NOT BEEN TESTED. DATA ON INDIVIDUAL
COMPONENTS ARE TABULATED BELOW:
CAS-NO. CHEMICAL NAME ORAL LD50 DERMAL LD50 VAPOR LC50
64742-88-7 MINERAL SPIRITS >5000 MG/KG 3000 MG/KG 4951 MG/L RAT
RAT RABBIT
64742-49-0 NAPHTHA, >5000 MG/KG >3160 MG/KG >4951 MG/L RAT
PETROLEUM, RAT RABBIT
HYDROTREATED
LIGHT
96-29-7 METHYL ETHYL 930 MG/KG 1100 MG/KG >4.8 MG/L RAT
KETOXIME RAT RABBIT
100-41-4 ETHYLBENZENE 3500 MG/KG 15400 MG/KG 17.2 MG/L RAT
RAT RABBIT
N.I. - NO INFORMATION
| 12. ECOLOGICAL INFORMATION | |
ECOLOGICAL INFORMATION:
PRODUCT IS A MIXTURE OF LISTED COMPONENTS. PRODUCT IS A MIXTURE OF LISTED
COMPONENTS.
| 13. DISPOSAL INFORMATION | |
DISPOSAL INFORMATION:
DISPOSE OF MATERIAL IN ACCORDANCE TO LOCAL, STATE, AND FEDERAL REGULATIONS
AND ORDINANCES. DO NOT ALLOW TO ENTER WATERWAYS, WASTEWATER, SOIL, STORM
DRAINS OR SEWER SYSTEMS.
| 14. TRANSPORT INFORMATION | |
DOMESTIC INTERNATIONAL AIR (IATA) TDG (CANADA)
(USDOT) (IMDG)
UN NUMBER N.A. 1263 1263 N.A.
PROPER SHIPPING NOT PAINT PAINT NOT
NAME REGULATED REGULATED
HAZARD CLASS N.A. 3 3 N.A.
PACKING GROUP N.A. III III N.A.
LIMITED QUANTITY NO YES, >5L NO YES, >5L NO NO
| 15. REGULATORY INFORMATION | |
U.S. FEDERAL REGULATIONS:
CERCLA - SARA HAZARD CATEGORY:
THIS PRODUCT HAS BEEN REVIEWED ACCORDING TO THE EPA 'HAZARD CATEGORIES'
PROMULGATED UNDER SECTIONS 311 AND 312 OF THE SUPERFUND AMENDMENT AND
REAUTHORIZATION ACT OF 1986 (SARA TITLE III) AND IS CONSIDERED, UNDER
APPLICABLE DEFINITIONS, TO MEET THE FOLLOWING CATEGORIES:
FIRE HAZARD, ACUTE HEALTH HAZARD, CHRONIC HEALTH HAZARD
SARA SECTION 313:
THIS PRODUCT CONTAINS THE FOLLOWING SUBSTANCES SUBJECT TO THE REPORTING
REQUIREMENTS OF SECTION 313 OF TITLE III OF THE SUPERFUND AMENDMENT AND
REAUTHORIZATION ACT OF 1986 AND 40 CFR PART 372:
CHEMICAL NAME CAS-NO.
ETHYLBENZENE 100-41-4
TOXIC SUBSTANCES CONTROL ACT:
THIS PRODUCT CONTAINS THE FOLLOWING CHEMICAL SUBSTANCES SUBJECT TO THE
REPORTING REQUIREMENTS OF TSCA 12(B) IF EXPORTED FROM THE UNITED STATES:
CHEMICAL NAME CAS-NO.
N-NONANE 111-84-2
ETHYLENE GLYCOL METHYL ETHER 109-86-4
| 16. OTHER INFORMATION | |
HMIS RATINGS:
HEALTH 2*
FLAMMABILITY 2
PHYSICAL HAZARD 0
PERSONAL PROTECTION X
NFPA RATINGS:
HEALTH 2
FLAMMABILITY 2
INSTABILITY 0
VOLATILE ORGANIC COMPOUNDS, G/L: 449
SDS REVISION DATE: 1/6/2016
REASON FOR REVISION:
PRODUCT COMPOSITION CHANGED
SUBSTANCE AND/OR PRODUCT PROPERTIES CHANGED IN SECTION(S):
01 - IDENTIFICATION
02 - HAZARD IDENTIFICATION
05 - FIRE-FIGHTING MEASURES
09 - PHYSICAL & CHEMICAL PROPERTIES
15 - REGULATORY INFORMATION
16 - OTHER INFORMATION
STATEMENT(S) CHANGED
LEGEND:
N.A. - NOT APPLICABLE
N.E. - NOT ESTABLISHED
N.D. - NOT DETERMINED
RUST-OLEUM CORPORATION BELIEVES, TO THE BEST OF ITS KNOWLEDGE, INFORMATION
AND BELIEF, THE INFORMATION CONTAINED HEREIN TO BE ACCURATE AND RELIABLE AS
OF THE DATE OF THIS SAFETY DATA SHEET. HOWEVER, BECAUSE THE CONDITIONS OF
HANDLING, USE, AND STORAGE OF THESE MATERIALS ARE BEYOND OUR CONTROL, WE
ASSUME NO RESPONSIBILITY OR LIABILITY FOR PERSONAL INJURY OR PROPERTY
DAMAGE INCURRED BY THE USE OF THESE MATERIALS. RUST-OLEUM CORPORATION MAKES
NO WARRANTY, EXPRESSED OR IMPLIED, REGARDING THE ACCURACY OR RELIABILITY OF
THE DATA OR RESULTS OBTAINED FROM THEIR USE. ALL MATERIALS MAY PRESENT
UNKNOWN HAZARDS AND SHOULD BE USED WITH CAUTION. THE INFORMATION AND
RECOMMENDATIONS IN THIS MATERIAL SAFETY DATA SHEET ARE OFFERED FOR THE
USERS' CONSIDERATION AND EXAMINATION. IT IS THE RESPONSIBILITY OF THE USER
TO DETERMINE THE FINAL SUITABILITY OF THIS INFORMATION AND TO COMPLY WITH
ALL APPLICABLE INTERNATIONAL, FEDERAL, STATE, AND LOCAL LAWS AND
REGULATIONS.