| Common Name: | LOCTITE SI 5900 INSTANT GASKET KNOWN AS INSTANT GASKET 190ML AE, 40479 |
| Manufacturer: | HENKEL |
| SDS Revision Date: | 3/22/2017 |
| SDS Format: | GHS-US |
| Item Number(s): | 1TDX3, 2PAC4 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
HENKEL
SAFETY DATA SHEET
REVISION NUMBER: 012.0
ISSUE DATE: 03/22/2017
| 1. PRODUCT AND COMPANY IDENTIFICATION |  |
PRODUCT NAME:
LOCTITE SI 5900 INSTANT GASKET KNOWN AS INSTANT GASKET 190ML AE
PRODUCT TYPE: SILICONE SEALANT
RESTRICTION OF USE: NONE IDENTIFIED
IDH NUMBER: 743913
ITEM NUMBER: 40479
REGION: UNITED STATES
COMPANY ADDRESS:
HENKEL CORPORATION
ONE HENKEL WAY
ROCKY HILL, CONNECTICUT 06067
CONTACT INFORMATION:
TELEPHONE: +1 (860) 571-5100
MEDICAL EMERGENCY PHONE:
POISON CONTROL CENTER: 1-877-671-4608 (TOLL FREE) OR 1-303-592-1711
TRANSPORT EMERGENCY PHONE:
CHEMTREC: 1-800-424-9300 (TOLL FREE) OR 1-703-527-3887
INTERNET: WWW.HENKELNA.COM
| 2. HAZARDS IDENTIFICATION | |
EMERGENCY OVERVIEW:
WARNING:
CONTAINS GAS UNDER PRESSURE; MAY EXPLODE IF HEATED.
CAUSES SKIN IRRITATION.
MAY CAUSE AN ALLERGIC SKIN REACTION.
CAUSES SERIOUS EYE IRRITATION.
HAZARD CLASS HAZARD CATEGORY
GASES UNDER PRESSURE COMPR. GAS
SKIN IRRITATION 2
EYE IRRITATION 2A
SKIN SENSITIZATION 1
PICTOGRAM(S):
GAS CYLINDER
EXCLAMATION MARK
PRECAUTIONARY STATEMENTS:
PREVENTION:
AVOID BREATHING MIST OR SPRAY. WASH AFFECTED AREA THOROUGHLY AFTER
HANDLING. CONTAMINATED WORK CLOTHING SHOULD NOT BE ALLOWED OUT OF THE
WORKPLACE. WEAR PROTECTIVE GLOVES, EYE PROTECTION, AND FACE PROTECTION.
RESPONSE:
IF ON SKIN:
WASH WITH PLENTY OF WATER. IF IN EYES: RINSE CAUTIOUSLY WITH WATER FOR
SEVERAL MINUTES. REMOVE CONTACT LENSES, IF PRESENT AND EASY TO DO.
CONTINUE RINSING.
IF SKIN IRRITATION OR RASH OCCURS: GET MEDICAL ATTENTION.
IF EYE IRRITATION PERSISTS:
GET MEDICAL ATTENTION. TAKE OFF CONTAMINATED CLOTHING.
STORAGE: PROTECT FROM SUNLIGHT. STORE IN A WELL-VENTILATED PLACE.
DISPOSAL:
DISPOSE OF CONTENTS AND/OR CONTAINER ACCORDING TO FEDERAL, STATE/PROVINCIAL
AND LOCAL GOVERNMENTAL REGULATIONS.
CLASSIFICATION COMPLIES WITH OSHA HAZARD COMMUNICATION STANDARD (29 CFR
1910.1200) AND IS CONSISTENT WITH THE PROVISIONS OF THE UNITED NATIONS
GLOBALLY HARMONIZED SYSTEM OF CLASSIFICATION AND LABELING OF CHEMICALS
(GHS).
SEE SECTION 11 FOR ADDITIONAL TOXICOLOGICAL INFORMATION.
| 3. COMPOSITION / INFORMATION ON INGREDIENTS | |
HAZARDOUS COMPONENT(S) CAS NUMBER PERCENTAGE*
CALCIUM CARBONATE 471-34-1 30 - 40
SILOXANES AND SILICONES, DI-ME 63148-62-9 10 - 20
NORFLURANE 811-97-2 5 - 10
BUTAN-2-ONE O,O',O''- 2224-33-1 1 - 5
(VINYLSILYLIDYNE)TRIOXIME
OCTADECANOIC ACID 57-11-4 1 - 5
CARBON BLACK 1333-86-4 0.1 - 1
ALUMINUM 7429-90-5 0.1 - 1
BUTAN-2-ONE O,O',O'',O'''- 34206-40-1 0.1 - 1
SILANETETRAYLTETRAOXIME
* EXACT PERCENTAGES MAY VARY OR ARE TRADE SECRET. CONCENTRATION RANGE IS
PROVIDED TO ASSIST USERS IN PROVIDING APPROPRIATE PROTECTIONS.
| 4. FIRST AID MEASURES | |
INHALATION:
MOVE TO FRESH AIR. IF BREATHING IS DIFFICULT, GIVE OXYGEN. IF NOT
BREATHING, GIVE ARTIFICIAL RESPIRATION. IF SYMPTOMS DEVELOP AND PERSIST,
GET MEDICAL ATTENTION.
SKIN CONTACT:
WIPE OFF PASTE WITH PAPER TOWEL OR CLOTH. WASH WITH SOAP AND WATER.
IF SYMPTOMS DEVELOP AND PERSIST, GET MEDICAL ATTENTION.
EYE CONTACT:
RINSE IMMEDIATELY WITH PLENTY OF WATER, ALSO UNDER THE EYELIDS, FOR AT
LEAST 15 MINUTES. IF EYE IRRITATION PERSISTS, CONSULT A SPECIALIST.
INGESTION: DO NOT INDUCE VOMITING. SEEK MEDICAL ADVICE.
SYMPTOMS: SEE SECTION 11.
| 5. FIRE FIGHTING MEASURES | |
EXTINGUISHING MEDIA: FOAM, DRY CHEMICAL OR CARBON DIOXIDE.
SPECIAL FIREFIGHTING PROCEDURES:
USE WATER SPRAY TO KEEP FIRE EXPOSED CONTAINERS COOL AND DISPERSE VAPORS.
UNUSUAL FIRE OR EXPLOSION HAZARDS:
CONTENTS UNDER PRESSURE. CLOSED CONTAINERS MAY RUPTURE (DUE TO BUILD UP OF
PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
HAZARDOUS COMBUSTION PRODUCTS:
OXIDES OF SILICON OXIDES OF CARBON. FORMALDEHYDE
| 6. ACCIDENTAL RELEASE MEASURES | |
USE PERSONAL PROTECTION RECOMMENDED IN SECTION 8, ISOLATE THE HAZARD AREA
AND DENY ENTRY TO UNNECESSARY AND UNPROTECTED PERSONNEL.
ENVIRONMENTAL PRECAUTIONS:
DO NOT ALLOW SPILL TO ENTER SEWAGE SYSTEMS OR OPEN BODIES OF WATER.
CLEAN-UP METHODS:
MAINTAIN GOOD VENTILATION FOR LARGE SPILLS. SCRAPE UP AS MUCH MATERIAL AS
POSSIBLE. PLACE SCRAP MATERIAL IN A WELL VENTILATED AREA AND ALLOW TO CURE
TO RUBBER.
| 7. HANDLING AND STORAGE | |
HANDLING:
PREVENT CONTACT WITH EYES, SKIN AND CLOTHING. DO NOT BREATHE VAPOR AND
MIST. WASH THOROUGHLY AFTER HANDLING. DO NOT HANDLE CONTACT LENSES UNTIL
ALL SEALANT HAS BEEN REMOVED FROM HANDS. RESIDUAL SEALANT MAY TRANSFER TO
LENSES AND CAUSE EYE IRRITATION.
STORAGE: STORE IN A COOL, DRY, WELL-VENTILATED AREA.
FOR INFORMATION ON PRODUCT SHELF LIFE, PLEASE REVIEW LABELS ON CONTAINER
OR CHECK THE TECHNICAL DATA SHEET.
| 8. EXPOSURE CONTROLS / PERSONAL PROTECTION | |
EMPLOYERS SHOULD COMPLETE AN ASSESSMENT OF ALL WORKPLACES TO DETERMINE THE
NEED FOR, AND SELECTION OF, PROPER EXPOSURE CONTROLS AND PROTECTIVE
EQUIPMENT FOR EACH TASK PERFORMED.
HAZARDOUS COMPONENT(S) ACGIH TLV OSHA PEL
CALCIUM CARBONATE 10 MG/M3 TWA 5 MG/M3 PEL
TOTAL DUST. RESPIRABLE FRACTION.
15 MG/M3 PEL TOTAL DUST.
SILOXANES AND SILICONES, NONE NONE
DI-ME
NORFLURANE NONE NONE
BUTAN-2-ONE O,O',O''- NONE NONE
(VINYLSILYLIDYNE)
TRIOXIME
OCTADECANOIC ACID 10 MG/M3 TWA NONE
CARBON BLACK 3 MG/M3 TWA 3.5 MG/M3 PEL
INHALABLE
FRACTION.
ALUMINUM 1 MG/M3 TWA 15 MG/M3 PEL (AS Al)
RESPIRABLE TOTAL DUST.
FRACTION.
5 MG/M3 PEL (AS Al)
RESPIRABLE FRACTION.
15 MPPCF TWA
RESPIRABLE FRACTION.
50 MPPCF TWA TOTAL DUST.
5 MG/M3 TWA RESPIRABLE
FRACTION.
15 MG/M3 TWA TOTAL DUST.
BUTAN-2-ONE- NONE NONE
O,O',O'',O'''-
SILANETETRAYL-
TETRAOXIME
HAZARDOUS COMPONENT(S) AIHA WEEL OTHER
CALCIUM CARBONATE NONE NONE
SILOXANES AND SILICONES, DI-ME NONE NONE
NORFLURANE 1,000 PPM (4,240 NONE
MG/M3) TWA
BUTAN-2-ONE O,O',O''- NONE NONE
(VINYLSILYLIDYNE)TRIOXIME
OCTADECANOIC ACID NONE NONE
CARBON BLACK NONE NONE
ALUMINUM NONE NONE
BUTAN-2-ONE O,O',O'',O'''- NONE NONE
SILANETETRAYLTETRAOXIME
ENGINEERING CONTROLS:
PROVIDE ADEQUATE LOCAL EXHAUST VENTILATION TO MAINTAIN WORKER EXPOSURE
BELOW EXPOSURE LIMITS.
RESPIRATORY PROTECTION:
USE A NIOSH APPROVED AIR-PURIFYING RESPIRATOR IF THE POTENTIAL TO EXCEED
ESTABLISHED EXPOSURE LIMITS EXISTS.
EYE/FACE PROTECTION: SAFETY GOGGLES OR SAFETY GLASSES WITH SIDE SHIELDS.
SKIN PROTECTION:
USE IMPERMEABLE GLOVES AND PROTECTIVE CLOTHING AS NECESSARY TO PREVENT
SKIN CONTACT.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
PHYSICAL STATE: AEROSOL
COLOR: BLACK
ODOR: MILD, PETROLEUM
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
VAPOR PRESSURE: NOT AVAILABLE.
BOILING POINT/RANGE: NOT AVAILABLE.
MELTING POINT/RANGE: NOT AVAILABLE.
VAPOR DENSITY: NOT AVAILABLE.
FLASH POINT: >93.00 DEG. C (>199.4 DEG. F)
FLAMMABLE/EXPLOSIVE LIMITS - LOWER: NOT AVAILABLE.
FLAMMABLE/EXPLOSIVE LIMITS - UPPER: NOT AVAILABLE.
AUTOIGNITION TEMPERATURE: NOT AVAILABLE.
FLAMMABILITY: NOT APPLICABLE
EVAPORATION RATE: NOT AVAILABLE.
SOLUBILITY IN WATER: POLYMERIZES ON CONTACT WITH WATER.
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
VOC CONTENT:
3.90%
50.70 G/L
VISCOSITY: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
| 10. STABILITY AND REACTIVITY | |
STABILITY: STABLE UNDER NORMAL CONDITIONS OF STORAGE AND USE.
HAZARDOUS REACTIONS: WILL NOT OCCUR
HAZARDOUS DECOMPOSITION PRODUCTS:
OXIDES OF CARBON. OXIDES OF SILICON. METHYL ETHYL KETOXIME FORMED DURING
CURE. FORMALDEHYDE.
INCOMPATIBLE MATERIALS: POLYMERIZES ON CONTACT WITH WATER.
REACTIVITY: NOT AVAILABLE.
CONDITIONS TO AVOID: MOISTURE.
| 11. TOXICOLOGICAL INFORMATION | |
RELEVANT ROUTES OF EXPOSURE: SKIN, INHALATION, EYES, INGESTION
POTENTIAL HEALTH EFFECTS/SYMPTOMS:
INHALATION:
INHALATION OF MIST OR SPRAY MAY CAUSE IRRITATION OF THE RESPIRATORY TRACT
AND NASAL PASSAGES. WHEN HEATED TO TEMPERATURES EXCEEDING 300 DEG. F
(150 DEG. C) IN THE PRESENCE OF AIR, SILICONES MAY FORM FORMALDEHYDE
VAPORS. FORMALDEHYDE IS A POTENTIAL CANCER HAZARD AND A KNOWN SKIN AND
RESPIRATORY SENSITIZER. VAPORS IRRITATE THE EYES, NOSE AND THROAT. SAFE
HANDLING CONDITIONS MAY BE MAINTAINED BY KEEPING FORMALDEHYDE VAPOR
CONCENTRATIONS BELOW THE OSHA PERMISSIBLE LIMIT.
SKIN CONTACT: CAUSES SKIN IRRITATION. MAY CAUSE ALLERGIC SKIN REACTION.
EYE CONTACT: CAUSES SERIOUS EYE IRRITATION.
INGESTION:
NOT EXPECTED UNDER NORMAL CONDITIONS OF USE. MAY BE HARMFUL IF SWALLOWED.
HAZARDOUS COMPONENT(S) LD50S AND LC50S IMMEDIATE AND DELAYED
HEALTH EFFECTS
CALCIUM CARBONATE ORAL LD50 (RAT): NUISANCE DUST
6,450 MG/KG
ORAL LD50 (MOUSE):
6,450 MG/KG
SILOXANES AND SILICONES, NONE IRRITANT
DI-ME
NORFLURANE NONE CARDIAC, CENTRAL NERVOUS
SYSTEM, IRRITANT,
RESPIRATORY, SKIN
BUTAN-2-ONE O,O',O''- NONE IRRITANT, ALLERGEN
(VINYLSILYLIDYNE)
TRIOXIME
OCTADECANOIC ACID ORAL LD50 (RAT): IRRITANT
4.6 G/KG
CARBON BLACK ORAL LD50 (RAT): RESPIRATORY, SOME EVIDENCE
>8,000 MG/KG OF CARCINOGENICITY
ALUMINUM NONE CENTRAL NERVOUS SYSTEM,
IRRITANT, LUNG
BUTAN-2-ONE- NONE IRRITANT, ALLERGEN
O,O',O'',O'''-
SILANETETRAYL-
TETRAOXIME
HAZARDOUS COMPONENT(S) NTP IARC OSHA CARCINOGEN
CARCINOGEN CARCINOGEN (SPECIFICALLY
REGULATED)
CALCIUM CARBONATE NO NO NO
SILOXANES AND SILICONES, NO NO NO
DI-ME
NORFLURANE NO NO NO
BUTAN-2-ONE O,O',O''- NO NO NO
(VINYLSILYLIDYNE)TRIOXIME
OCTADECANOIC ACID NO NO NO
CARBON BLACK NO GROUP 2B NO
ALUMINUM NO NO NO
BUTAN-2-ONE O,O',O'',O'''- NO NO NO
SILANETETRAYLTETRAOXIME
| 12. ECOLOGICAL INFORMATION | |
ECOLOGICAL INFORMATION: NOT AVAILABLE.
| 13. DISPOSAL CONSIDERATIONS | |
INFORMATION PROVIDED IS FOR UNUSED PRODUCT ONLY.
RECOMMENDED METHOD OF DISPOSAL:
FOLLOW ALL LOCAL, STATE, FEDERAL AND PROVINCIAL REGULATIONS FOR DISPOSAL.
HAZARDOUS WASTE NUMBER: NOT A RCRA HAZARDOUS WASTE.
| 14. TRANSPORT INFORMATION | |
THE TRANSPORT INFORMATION PROVIDED IN THIS SECTION ONLY APPLIES TO THE
MATERIAL/FORMULATION ITSELF, AND IS NOT SPECIFIC TO ANY
PACKAGE/CONFIGURATION.
U.S. DEPARTMENT OF TRANSPORTATION GROUND (49 CFR):
PROPER SHIPPING NAME: AEROSOLS
HAZARD CLASS OR DIVISION: 2.2
IDENTIFICATION NUMBER: UN 1950
PACKING GROUP: NONE
INTERNATIONAL AIR TRANSPORTATION (ICAO/IATA):
PROPER SHIPPING NAME: AEROSOLS, NON-FLAMMABLE
HAZARD CLASS OR DIVISION: 2.2
IDENTIFICATION NUMBER: UN 1950
PACKING GROUP: NONE
WATER TRANSPORTATION (IMO/IMDG):
PROPER SHIPPING NAME: AEROSOLS
HAZARD CLASS OR DIVISION: 2.2
IDENTIFICATION NUMBER: UN 1950
PACKING GROUP: NONE
| 15. REGULATORY INFORMATION | |
UNITED STATES REGULATORY INFORMATION:
TSCA 8 (B) INVENTORY STATUS:
ALL COMPONENTS ARE LISTED OR ARE EXEMPT FROM LISTING ON THE TOXIC
SUBSTANCES CONTROL ACT INVENTORY.
TSCA 12 (B) EXPORT NOTIFICATION: NONE ABOVE REPORTING DE MINIMIS
CERCLA/SARA SECTION 302 EHS: NONE ABOVE REPORTING DE MINIMIS.
CERCLA/SARA SECTION 311/312: IMMEDIATE HEALTH, DELAYED HEALTH
CERCLA/SARA SECTION 313: NONE ABOVE REPORTING DE MINIMIS.
CALIFORNIA PROPOSITION 65:
THIS PRODUCT CONTAINS A CHEMICAL KNOWN IN THE STATE OF CALIFORNIA TO CAUSE
CANCER. THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA
TO CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
CANADA REGULATORY INFORMATION:
CEPA DSL/NDSL STATUS:
ALL COMPONENTS ARE LISTED ON OR ARE EXEMPT FROM LISTING ON THE CANADIAN
DOMESTIC SUBSTANCES LIST.
| 16. OTHER INFORMATION | |
THIS SAFETY DATA SHEET CONTAINS CHANGES FROM THE PREVIOUS VERSION IN
SECTIONS: NEW SAFETY DATA SHEET FORMAT.
PREPARED BY: REGULATORY AFFAIRS
ISSUE DATE: 03/22/2017
DISCLAIMER:
THE DATA CONTAINED HEREIN ARE FURNISHED FOR INFORMATION ONLY AND ARE
BELIEVED TO BE RELIABLE. HOWEVER, HENKEL CORPORATION AND ITS AFFILIATES
("HENKEL") DOES NOT ASSUME RESPONSIBILITY FOR ANY RESULTS OBTAINED BY
PERSONS OVER WHOSE METHODS HENKEL HAS NO CONTROL. IT IS THE USER'S
RESPONSIBILITY TO DETERMINE THE SUITABILITY OF HENKEL'S PRODUCTS OR ANY
PRODUCTION METHODS MENTIONED HEREIN FOR A PARTICULAR PURPOSE, AND TO ADOPT
SUCH PRECAUTIONS AS MAY BE ADVISABLE FOR THE PROTECTION OF PROPERTY AND
PERSONS AGAINST ANY HAZARDS THAT MAY BE INVOLVED IN THE HANDLING AND USE
OF ANY HENKEL'S PRODUCTS. IN LIGHT OF THE FOREGOING, HENKEL SPECIFICALLY
DISCLAIMS ALL WARRANTIES, EXPRESS OR IMPLIED, INCLUDING WARRANTIES OF
MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE, ARISING FROM SALE OR
USE OF HENKEL'S PRODUCTS. HENKEL FURTHER DISCLAIMS ANY LIABILITY FOR
CONSEQUENTIAL OR INCIDENTAL DAMAGES OF ANY KIND, INCLUDING LOST PROFITS.