| Common Name: | INTERMEDIATE - LITHIUM MANGANESE DIOXIDE D CELL BATTERY INTERMEDIATE |
| Manufacturer: | 3M |
| SDS Revision Date: | 12/21/2016 |
| SDS Format: | OTHER INFORMATION SHEET |
| Item Number(s): | 1UKG9 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
INTERMEDIATE - LITHIUM MANGANESE DIOXIDE D CELL BATTERY
INTERNAL USE ONLY
12/21/16
3M
ARTICLE INFORMATION SHEET
COPYRIGHT, 2016, 3M COMPANY.
ALL RIGHTS RESERVED. COPYING AND/OR DOWNLOADING OF THIS INFORMATION FOR
THE PURPOSE OF PROPERLY UTILIZING 3M PRODUCTS IS ALLOWED PROVIDED THAT:
(1) THE INFORMATION IS COPIED IN FULL WITH NO CHANGES UNLESS
PRIOR WRITTEN AGREEMENT IS OBTAINED FROM 3M, AND
(2) NEITHER THE COPY NOR THE ORIGINAL IS RESOLD OR OTHERWISE DISTRIBUTED
WITH THE INTENTION OF EARNING A PROFIT THEREON.
THIS ARTICLE INFORMATION SHEET IS PROVIDED AS A COURTESY IN RESPONSE TO
A CUSTOMER REQUEST A SAFETY DATA SHEET (SDS) HAS NOT BEEN PREPARED FOR
THESE PRODUCT(S) BECAUSE THEY ARE ARTICLES. ARTICLES ARE NOT SUBJECT TO
THE OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION'S HAZARD COMMUNICATION
STANDARD (29 CFR 1910.1200(B)(6)(V)). AS DEFINED IN THIS STANDARD:
"ARTICLE" MEANS A MANUFACTURED ITEM OTHER THAN A FLUID OR PARTICLE:
(I) WHICH IS FORMED TO A SPECIFIC SHAPE OR DESIGN DURING MANUFACTURE;
(II) WHICH HAS END USE FUNCTION(S) DEPENDENT IN WHOLE OR IN PART UPON ITS
SHAPE OR DESIGN DURING END USE; AND (III) WHICH UNDER NORMAL CONDITIONS
OF USE DOES NOT RELEASE MORE THAN VERY SMALL QUANTITIES, E.G., MINUTE
OR TRACE AMOUNTS OF A HAZARDOUS CHEMICAL, AND DOES NOT POSE A PHYSICAL
HAZARD OR HEALTH RISK TO EMPLOYEES.
DOCUMENT GROUP: 17-0401-4
VERSION NUMBER: 1.01
ISSUE DATE: 12/21/16
SUPERCEDES DATE: 05/29/14
| SECTION 1: IDENTIFICATION |  |
1.1. PRODUCT IDENTIFIER:
INTERMEDIATE - LITHIUM MANGANESE DIOXIDE D CELL BATTERY INTERMEDIATE
PRODUCT IDENTIFICATION NUMBERS:
70-0708-8718-0, 78-8124-0062-6, 78-8124-0106-1, 78-8124-0565-8
1.2. RECOMMENDED USE AND RESTRICTIONS ON USE:
RECOMMENDED USE: BATTERY
1.3. SUPPLIER'S DETAILS:
MANUFACTURER: 3M
DIVISION: PERSONAL SAFETY DIVISION
ADDRESS:
3M CENTER
ST. PAUL, MN 55144-1000
USA
TELEPHONE: 1-888-3M HELPS (1-888-364-3577)
1.4. EMERGENCY TELEPHONE NUMBER:
1-800-364-3577 OR (651) 737-6501 (24 HOURS)
| SECTION 2: HAZARD IDENTIFICATION | |
THIS PRODUCT IS EXEMPT FROM HAZARD CLASSIFICATION ACCORDING TO OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
| SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS | |
INGREDIENT C.A.S. NO. % BY WT
LITHIUM METAL NONE 3.4
LITHIUM PERCHLORATE NONE 1.9
MANGANESE DIOXIDE NONE 38.5
ORGANIC SOLVENT MIXTURE NONE 17.3
| SECTION 4: FIRST AID MEASURES | |
4.1. DESCRIPTION OF FIRST AID MEASURES:
INHALATION: NO NEED FOR FIRST AID IS ANTICIPATED.
SKIN CONTACT: NO NEED FOR FIRST AID IS ANTICIPATED.
EYE CONTACT: NO NEED FOR FIRST AID IS ANTICIPATED.
IF SWALLOWED: NO NEED FOR FIRST AID IS ANTICIPATED.
| SECTION 5: FIRE-FIGHTING MEASURES | |
IN CASE OF FIRE:
USE A FIRE FIGHTING AGENT SUITABLE FOR ORDINARY COMBUSTIBLE MATERIAL
SUCH AS WATER OR FOAM.
| SECTION 6: ACCIDENTAL RELEASE MEASURES | |
6.1. PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
NOT APPLICABLE.
6.2. ENVIRONMENTAL PRECAUTIONS: NOT APPLICABLE.
6.3. METHODS AND MATERIAL FOR CONTAINMENT AND CLEANING UP: NOT APPLICABLE.
| SECTION 7: HANDLING AND STORAGE | |
7.1. PRECAUTIONS FOR SAFE HANDLING:
THIS PRODUCT IS CONSIDERED TO BE AN ARTICLE WHICH DOES NOT RELEASE
OR OTHERWISE RESULT IN EXPOSURE TO A HAZARDOUS CHEMICAL UNDER NORMAL
USE CONDITIONS.
7.2. CONDITIONS FOR SAFE STORAGE INCLUDING ANY INCOMPATIBILITIES:
NO SPECIAL STORAGE REQUIREMENTS.
| SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION | |
THIS PRODUCT IS CONSIDERED TO BE AN ARTICLE WHICH DOES NOT RELEASE
OR OTHERWISE RESULT IN EXPOSURE TO A HAZARDOUS CHEMICAL UNDER NORMAL
USE CONDITIONS. NO ENGINEERING CONTROLS OR PERSONAL PROTECTIVE
EQUIPMENT(PPE) ARE NECESSARY.
| SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES | |
9.1. INFORMATION ON BASIC PHYSICAL AND CHEMICAL PROPERTIES:
GENERAL PHYSICAL FORM: SOLID
SPECIFIC PHYSICAL FORM: BATTERY PACK
ODOR, COLOR, GRADE:
ODORLESS, POLYPROPYLENE SEALED CASE WHICH CONTAINS SEALED
LITHIUM MANGANESE DIOXIDE BATTERIES.
ODOR THRESHOLD: NOT APPLICABLE
PH: NOT APPLICABLE
MELTING POINT: NOT APPLICABLE
BOILING POINT: NO DATA AVAILABLE
FLASH POINT: NOT APPLICABLE
EVAPORATION RATE: NOT APPLICABLE
FLAMMABILITY (SOLID, GAS): NOT CLASSIFIED
FLAMMABLE LIMITS(LEL): NOT APPLICABLE
FLAMMABLE LIMITS(UEL): NOT APPLICABLE
VAPOR PRESSURE: NOT APPLICABLE
VAPOR DENSITY: NOT APPLICABLE
DENSITY: NO DATA AVAILABLE
SPECIFIC GRAVITY: NOT APPLICABLE
SOLUBILITY IN WATER: NOT APPLICABLE
SOLUBILITY-NON-WATER: NOT APPLICABLE
PARTITION COEFFICIENT N-OCTANOL/WATER: NO DATA AVAILABLE
AUTOIGNITION TEMPERATURE: NOT APPLICABLE
DECOMPOSITION TEMPERATURE: NOT APPLICABLE
VISCOSITY: NOT APPLICABLE
VOLATILE ORGANIC COMPOUNDS: NOT APPLICABLE
PERCENT VOLATILE: NOT APPLICABLE
VOC LESS H2O & EXEMPT SOLVENTS: NOT APPLICABLE
| SECTION 10: STABILITY AND REACTIVITY | |
THIS MATERIAL IS CONSIDERED TO BE NON REACTIVE UNDER NORMAL USE CONDITIONS.
| SECTION 11: TOXICOLOGICAL INFORMATION | |
INHALATION: NO HEALTH EFFECTS ARE EXPECTED
SKIN CONTACT: NO HEALTH EFFECTS ARE EXPECTED
EYE CONTACT: NO HEALTH EFFECTS ARE EXPECTED
INGESTION: NO HEALTH EFFECTS ARE EXPECTED
ADDITIONAL INFORMATION:
THIS PRODUCT, WHEN USED UNDER REASONABLE CONDITIONS AND IN ACCORDANCE
WITH THE DIRECTIONS FOR USE, SHOULD NOT PRESENT A HEALTH HAZARD. HOWEVER,
USE OR PROCESSING OF THE PRODUCT IN A MANNER NOT IN ACCORDANCE WITH THE
PRODUCT'S DIRECTIONS FOR USE MAY AFFECT THE PERFORMANCE OF THE PRODUCT
AND MAY PRESENT POTENTIAL HEALTH AND SAFETY HAZARDS.
| SECTION 12: ECOLOGICAL INFORMATION | |
THIS ARTICLE IS EXPECTED TO PRESENT A LOW ENVIRONMENTAL RISK EITHER
BECAUSE USE AND DISPOSAL ARE UNLIKELY TO RESULT IN A SIGNIFICANT
RELEASE OF COMPONENTS TO THE ENVIRONMENT OR BECAUSE THOSE COMPONENTS
THAT MAY BE RELEASED ARE EXPECTED TO HAVE INSIGNIFICANT ENVIRONMENTAL
IMPACT.
| SECTION 13: DISPOSAL CONSIDERATIONS | |
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH THE
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
| SECTION 14: TRANSPORT INFORMATION | |
FOR TRANSPORT INFORMATION, PLEASE VISIT:
HTTP://3M.COM/TRANSPORT INFO OR CALL 1-800-364-3577 OR 651-737-6501.
| SECTION 15: REGULATORY INFORMATION | |
CHEMICAL INVENTORIES:
THIS PRODUCT IS AN ARTICLE AS DEFINED BY TSCA REGULATIONS, AND IS EXEMPT
FROM TSCA INVENTORY REQUIREMENTS.
| SECTION 16: OTHER INFORMATION | |
NFPA HAZARD CLASSIFICATION:
HEALTH 1
FLAMMABILITY 3
INSTABILITY 2
SPECIAL HAZARDS REACTS WITH WATER
NATIONAL FIRE PROTECTION ASSOCIATION(NFPA) HAZARD RATINGS ARE
DESIGNED FOR USE BY EMERGENCY RESPONSE PERSONNEL TO ADDRESS THE
HAZARDS THAT ARE PRESENTED BY SHORT-TERM, ACUTE EXPOSURE TO A MATERIAL
UNDER CONDITIONS OF FIRE, SPILL, OR SIMILAR EMERGENCIES. HAZARD RATINGS
ARE PRIMARILY BASED ON THE INHERENT PHYSICAL AND TOXIC PROPERTIES OF
THE MATERIAL BUT ALSO INCLUDE THE TOXIC PROPERTIES OF COMBUSTION OR
DECOMPOSITION PRODUCTS THAT ARE KNOWN TO BE GENERATED IN SIGNIFICANT
QUANTITIES.
HMIS HAZARD CLASSIFICATION:
HEALTH 1
FLAMMABILITY 3
PHYSICAL HAZARD 2
PERSONAL PROTECTION X - SEE PPE SECTION.
HAZARDOUS MATERIAL IDENTIFICATION SYSTEM(HMIS(R*)IV) HAZARD RATINGS
ARE DESIGNED TO INFORM EMPLOYEES OF CHEMICAL HAZARDS IN THE WORKPLACE.
THESE RATINGS ARE BASED ON THE INHERENT PROPERTIES OF THE MATERIAL
UNDER EXPECTED CONDITIONS OF NORMAL USE AND ARE NOT INTENDED FOR USE
IN EMERGENCY SITUATIONS. HMIS(R*) IV RATINGS ARE TO BE USED WITH A FULLY
IMPLEMENTED HMIS(R*) IV PROGRAM. HMIS(*) IS A REGISTERED MARK OF THE
AMERICAN COATINGS ASSOCIATION(ACA).
DOCUMENT GROUP: 17-0401-4
VERSION NUMBER: 1.01
ISSUE DATE: 12/21/16
SUPERCEDES DATE: 05/29/14
DISCLAIMER:
THE INFORMATION IN THIS ARTICLE INFORMATION SHEET (AIS) IS BELIEVED
TO BE CORRECT AS OF THE DATE ISSUED. 3M MAKES NO WARRANTIES, EXPRESSED
OR IMPLIED, INCLUDING, BUT NOT LIMITED TO, ANY IMPLIED WARRANTY OF
MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE OR COURSE OF
PERFORMANCE OR USAGE OF TRADE. USER IS RESPONSIBLE FOR DETERMINING
WHETHER THE 3M PRODUCT IS FIT FOR A PARTICULAR PURPOSE AND SUITABLE
FOR USER'S METHOD OF USE OR APPLICATION. GIVEN THE VARIETY OF FACTORS
THAT CAN AFFECT THE USE AND APPLICATION OF A 3M PRODUCT, SOME OF WHICH
ARE UNIQUELY WITH IN THE USER'S KNOWLEDGE AND CONTROL, IT IS ESSENTIAL
THAT THE USER EVALUATE THE 3M PRODUCT TO DETERMINE WHETHER IT IS
FIT FOR A PARTICULAR PURPOSE AND SUITABLE FOR USER'S METHOD OF USE OR
APPLICATION.
3M PROVIDES INFORMATION IN ELECTRONIC FORM AS A SERVICE TO ITS CUSTOMERS.
DUE TO THE REMOTE POSSIBILITY THAT ELECTRONIC TRANSFER MAY HAVE RESULTED
IN ERRORS, OMISSIONS OR ALTERATIONS IN THIS INFORMATION, 3M MAKES NO
REPRESENTATIONS AS TO ITS COMPLETENESS OR ACCURACY. IN ADDITION,
INFORMATION OBTAINED FROM A DATABASE MAY NOT BE AS CURRENT AS THE
INFORMATION IN THE AIS AVAILABLE DIRECTLY FROM 3M.