| Common Name: | THROTTLE BODY & AIR-INTAKE CLEANER 05078, 05678 |
| Manufacturer: | CRC |
| SDS Revision Date: | 5/7/2015 |
| SDS Format: | GHS-US |
| Item Number(s): | 19MX76, 1YHN9 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
CRC(R*)
SAFETY DATA SHEET
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFIER: THROTTLE BODY & AIR-INTAKE CLEANER
OTHER MEANS OF IDENTIFICATION:
PRODUCT CODE: 05078, 05678
RECOMMENDED USE: FUEL-INJECTION AIR INTAKE CLEANER
RECOMMENDED RESTRICTIONS: NONE KNOWN.
MANUFACTURER/IMPORTER/SUPPLIER/DISTRIBUTOR INFORMATION:
MANUFACTURED OR SOLD BY:
COMPANY NAME: CRC INDUSTRIES, INC.
ADDRESS:
885 LOUIS DR.
WARMINSTER, PA 18974
US
TELEPHONE:
GENERAL INFORMATION: 215-674-4300
TECHNICAL ASSISTANCE: 800-521-3168
CUSTOMER SERVICE: 800-272-4620
24-HOUR EMERGENCY (CHEMTREC):
800-424-9300 (US)
703-527-3887 (INTERNATIONAL)
WEBSITE: WWW.CRCINDUSTRIES.COM
| 2. HAZARD(S) IDENTIFICATION | |
PHYSICAL HAZARDS:
FLAMMABLE AEROSOLS: CATEGORY 1
GASES UNDER PRESSURE: COMPRESSED GAS
HEALTH HAZARDS:
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 2
REPRODUCTIVE TOXICITY (THE UNBORN CHILD): CATEGORY 2
SPECIFIC TARGET ORGAN TOXICITY, SINGLE EXPOSURE:
CATEGORY 3 NARCOTIC EFFECTS
SPECIFIC TARGET ORGAN TOXICITY, REPEATED EXPOSURE: CATEGORY 2
ENVIRONMENTAL HAZARDS:
HAZARDOUS TO THE AQUATIC ENVIRONMENT, ACUTE HAZARD: CATEGORY 2
HAZARDOUS TO THE AQUATIC ENVIRONMENT, LONG-TERM HAZARD: CATEGORY 2
OSHA DEFINED HAZARDS: NOT CLASSIFIED.
LABEL ELEMENTS:
FLAME
GAS CYLINDER
HEALTH HAZARD
EXCLAMATION MARK
SIGNAL WORD: DANGER
HAZARD STATEMENT:
EXTREMELY FLAMMABLE AEROSOL. CONTAINS GAS UNDER PRESSURE; MAY EXPLODE IF
HEATED. CAUSES SERIOUS EYE IRRITATION. MAY CAUSE DROWSINESS OR DIZZINESS.
SUSPECTED OF DAMAGING THE UNBORN CHILD. MAY CAUSE DAMAGE TO ORGANS (LIVER,
KIDNEYS, BRAIN, LUNGS) THROUGH PROLONGED OR REPEATED EXPOSURE. TOXIC TO
AQUATIC LIFE. TOXIC TO AQUATIC LIFE WITH LONG LASTING EFFECTS.
PRECAUTIONARY STATEMENT:
PREVENTION:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. KEEP AWAY FROM HEAT/SPARKS/OPEN
FLAMES/HOT SURFACES. - NO SMOKING. DO NOT SPRAY ON AN OPEN FLAME OR OTHER
IGNITION SOURCE. DO NOT APPLY WHILE EQUIPMENT IS ENERGIZED.
PRESSURIZED CONTAINER:
DO NOT PIERCE OR BURN, EVEN AFTER USE. EXTINGUISH ALL FLAMES, PILOT LIGHTS
AND HEATERS. VAPORS WILL ACCUMULATE READILY AND MAY IGNITE. USE ONLY WITH
ADEQUATE VENTILATION; MAINTAIN VENTILATION DURING USE AND UNTIL ALL VAPORS
ARE GONE. OPEN DOORS AND WINDOWS OR USE OTHER MEANS TO ENSURE A FRESH AIR
SUPPLY DURING USE AND WHILE PRODUCT IS DRYING. IF YOU EXPERIENCE ANY
SYMPTOMS LISTED ON THIS LABEL, INCREASE VENTILATION OR LEAVE THE AREA.
DO NOT BREATHE MIST OR VAPOR. WASH THOROUGHLY AFTER HANDLING. WEAR
PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION. AVOID
RELEASE TO THE ENVIRONMENT.
RESPONSE:
IF INHALED:
REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING. CALL A
POISON CENTER/DOCTOR IF YOU FEEL UNWELL.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ATTENTION.
IF EXPOSED OR CONCERNED: GET MEDICAL ADVICE/ATTENTION. COLLECT SPILLAGE.
STORAGE:
STORE IN A WELL-VENTILATED PLACE. STORE LOCKED UP. PROTECT FROM SUNLIGHT.
DO NOT EXPOSE TO TEMPERATURES EXCEEDING 50 DEG. C/122 DEG. F. EXPOSURE TO
HIGH TEMPERATURE MAY CAUSE CAN TO BURST.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH LOCAL/REGIONAL/NATIONAL
REGULATIONS.
HAZARD(S) NOT OTHERWISE CLASSIFIED (HNOC):
STATIC ACCUMULATING FLAMMABLE LIQUID CAN BECOME ELECTROSTATICALLY CHARGED
EVEN IN BONDED AND GROUNDED EQUIPMENT. SPARKS MAY IGNITE LIQUID AND VAPOR.
MAY CAUSE FLASH FIRE OR EXPLOSION.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
MIXTURES:
CHEMICAL NAME COMMON NAME CAS NUMBER %
AND SYNONYMS
ACETONE 67-64-1 80 - 90
CARBON DIOXIDE 124-38-9 5 - 10
3-METHYLHEXANE 589-34-4 1 - 3
METHYLCYCLOHEXANE 108-87-2 1 - 3
NAPHTHA (PETROLEUM), 64742-49-0 1 - 3
HYDROTREATED LIGHT
N-HEPTANE 142-82-5 1 - 3
TOLUENE 108-88-3 1 - 3
CYCLOHEXANE 110-82-7 <1
SPECIFIC CHEMICAL IDENTITY AND/OR PERCENTAGE OF COMPOSITION HAS BEEN
WITHHELD AS A TRADE SECRET.
| 4. FIRST-AID MEASURES | |
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
SKIN CONTACT:
RINSE SKIN WITH WATER/SHOWER. GET MEDICAL ATTENTION IF IRRITATION DEVELOPS
AND PERSISTS.
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. REMOVE
CONTACT LENSES, IF PRESENT AND EASY TO DO. CONTINUE RINSING. GET MEDICAL
ATTENTION IF IRRITATION DEVELOPS AND PERSISTS.
INGESTION:
IF SWALLOWED:
IMMEDIATELY CALL A POISON CENTER OR DOCTOR/PHYSICIAN. RINSE MOUTH. DO NOT
INDUCE VOMITING WITHOUT ADVICE FROM POISON CONTROL CENTER.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
MAY CAUSE DROWSINESS AND DIZZINESS. HEADACHE. NAUSEA, VOMITING. SEVERE EYE
IRRITATION. SYMPTOMS MAY INCLUDE STINGING, TEARING, REDNESS, SWELLING, AND
BLURRED VISION. PROLONGED EXPOSURE MAY CAUSE CHRONIC EFFECTS.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
PROVIDE GENERAL SUPPORTIVE MEASURES AND TREAT SYMPTOMATICALLY. KEEP VICTIM
UNDER OBSERVATION. SYMPTOMS MAY BE DELAYED.
GENERAL INFORMATION:
IF EXPOSED OR CONCERNED:
GET MEDICAL ADVICE/ATTENTION. ENSURE THAT MEDICAL PERSONNEL ARE AWARE OF
THE MATERIAL(S) INVOLVED, AND TAKE PRECAUTIONS TO PROTECT THEMSELVES. SHOW
THIS SAFETY DATA SHEET TO THE DOCTOR IN ATTENDANCE.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
ALCOHOL RESISTANT FOAM. WATER FOG. CARBON DIOXIDE (CO2). DRY CHEMICAL
POWDER, CARBON DIOXIDE, SAND OR EARTH MAY BE USED FOR SMALL FIRES ONLY.
UNSUITABLE EXTINGUISHING MEDIA:
DO NOT USE WATER JET AS AN EXTINGUISHER, AS THIS WILL SPREAD THE FIRE.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
CONTENTS UNDER PRESSURE. PRESSURIZED CONTAINER MAY RUPTURE WHEN EXPOSED TO
HEAT OR FLAME. THIS PRODUCT IS A POOR CONDUCTOR OF ELECTRICITY AND CAN
BECOME ELECTROSTATICALLY CHARGED. IF SUFFICIENT CHARGE IS ACCUMULATED,
IGNITION OF FLAMMABLE MIXTURES CAN OCCUR. STATIC ELECTRICITY ACCUMULATION
MAY BE SIGNIFICANTLY INCREASED BY THE PRESENCE OF SMALL QUANTITIES OF WATER
OR OTHER CONTAMINANTS. MATERIAL WILL FLOAT AND MAY IGNITE ON SURFACE OF
WATER. DURING FIRE, GASES HAZARDOUS TO HEALTH MAY BE FORMED.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
FIREFIGHTERS MUST USE STANDARD PROTECTIVE EQUIPMENT INCLUDING FLAME
RETARDANT COAT, HELMET WITH FACE SHIELD, GLOVES, RUBBER BOOTS, AND IN
ENCLOSED SPACES, SCBA.
FIRE-FIGHTING EQUIPMENT/INSTRUCTIONS:
IN CASE OF FIRE:
STOP LEAK IF SAFE TO DO SO. MOVE CONTAINERS FROM FIRE AREA IF YOU CAN DO SO
WITHOUT RISK. CONTAINERS SHOULD BE COOLED WITH WATER TO PREVENT VAPOR
PRESSURE BUILD UP.
GENERAL FIRE HAZARDS:
EXTREMELY FLAMMABLE AEROSOL. CONTENTS UNDER PRESSURE. PRESSURIZED CONTAINER
MAY RUPTURE WHEN EXPOSED TO HEAT OR FLAME.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
KEEP UNNECESSARY PERSONNEL AWAY. KEEP PEOPLE AWAY FROM AND UPWIND OF
SPILL/LEAK. KEEP OUT OF LOW AREAS. REMOVE ALL POSSIBLE SOURCES OF IGNITION
IN THE SURROUNDING AREA. MANY VAPORS ARE HEAVIER THAN AIR AND WILL SPREAD
ALONG GROUND AND COLLECT IN LOW OR CONFINED AREAS (SEWERS, BASEMENTS,
TANKS). WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND CLOTHING DURING CLEAN-UP.
DO NOT BREATHE MIST OR VAPOR. EMERGENCY PERSONNEL NEED SELF-CONTAINED
BREATHING EQUIPMENT. DO NOT TOUCH DAMAGED CONTAINERS OR SPILLED MATERIAL
UNLESS WEARING APPROPRIATE PROTECTIVE CLOTHING. VENTILATE CLOSED SPACES
BEFORE ENTERING THEM. USE APPROPRIATE CONTAINMENT TO AVOID ENVIRONMENTAL
CONTAMINATION. LOCAL AUTHORITIES SHOULD BE ADVISED IF SIGNIFICANT SPILLAGES
CANNOT BE CONTAINED. FOR PERSONAL PROTECTION, SEE SECTION 8 OF THE SDS.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
ELIMINATE ALL IGNITION SOURCES (NO SMOKING, FLARES, SPARKS, OR FLAMES IN
IMMEDIATE AREA). KEEP COMBUSTIBLES (WOOD, PAPER, OIL, ETC.) AWAY FROM
SPILLED MATERIAL. THIS MATERIAL IS CLASSIFIED AS A WATER POLLUTANT UNDER
THE CLEAN WATER ACT AND SHOULD BE PREVENTED FROM CONTAMINATING SOIL OR FROM
ENTERING SEWAGE AND DRAINAGE SYSTEMS WHICH LEAD TO WATERWAYS. STOP THE FLOW
OF MATERIAL, IF THIS IS WITHOUT RISK. WIPE UP WITH ABSORBENT MATERIAL (E.G.
CLOTH, FLEECE). CLEAN SURFACE THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
FOR WASTE DISPOSAL, SEE SECTION 13 OF THE SDS.
ENVIRONMENTAL PRECAUTIONS:
AVOID RELEASE TO THE ENVIRONMENT. PREVENT FURTHER LEAKAGE OR SPILLAGE IF
SAFE TO DO SO. AVOID DISCHARGE INTO DRAINS, WATER COURSES OR ONTO THE
GROUND. INFORM APPROPRIATE MANAGERIAL OR SUPERVISORY PERSONNEL OF ALL
ENVIRONMENTAL RELEASES. USE APPROPRIATE CONTAINMENT TO AVOID ENVIRONMENTAL
CONTAMINATION.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. MINIMIZE FIRE RISKS FROM
FLAMMABLE AND COMBUSTIBLE MATERIALS (INCLUDING COMBUSTIBLE DUST AND STATIC
ACCUMULATING LIQUIDS) OR DANGEROUS REACTIONS WITH INCOMPATIBLE MATERIALS.
PRESSURIZED CONTAINER:
DO NOT PIERCE OR BURN, EVEN AFTER USE. DO NOT USE IF SPRAY BUTTON IS
MISSING OR DEFECTIVE. DO NOT SPRAY ON A NAKED FLAME OR ANY OTHER
INCANDESCENT MATERIAL. DO NOT SMOKE WHILE USING OR UNTIL SPRAYED SURFACE IS
THOROUGHLY DRY. DO NOT CUT, WELD, SOLDER, DRILL, GRIND, OR EXPOSE
CONTAINERS TO HEAT, FLAME, SPARKS, OR OTHER SOURCES OF IGNITION. USE
CAUTION AROUND ENERGIZED EQUIPMENT. THE METAL CONTAINER WILL CONDUCT
ELECTRICITY IF IT CONTACTS A LIVE SOURCE. THIS MAY RESULT IN INJURY TO THE
USER FROM ELECTRICAL SHOCK AND/OR FLASH FIRE. DO NOT BREATHE MIST OR VAPOR.
AVOID CONTACT WITH EYES. AVOID PROLONGED EXPOSURE. PREGNANT OR
BREASTFEEDING WOMEN MUST NOT HANDLE THIS PRODUCT. SHOULD BE HANDLED IN
CLOSED SYSTEMS, IF POSSIBLE. USE ONLY IN WELL-VENTILATED AREAS. WEAR
APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT. OBSERVE GOOD INDUSTRIAL HYGIENE
PRACTICES. AVOID RELEASE TO THE ENVIRONMENT. FOR PRODUCT USAGE
INSTRUCTIONS, PLEASE SEE THE PRODUCT LABEL.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
LEVEL 3 AEROSOL.
PRESSURIZED CONTAINER. PROTECT FROM SUNLIGHT AND DO NOT EXPOSE TO
TEMPERATURES EXCEEDING 50 DEG. C/122 DEG. F. DO NOT PUNCTURE, INCINERATE OR
CRUSH. DO NOT HANDLE OR STORE NEAR AN OPEN FLAME, HEAT OR OTHER SOURCES OF
IGNITION. THIS MATERIAL CAN ACCUMULATE STATIC CHARGE WHICH MAY CAUSE SPARK
AND BECOME AN IGNITION SOURCE. AVOID SPARK PROMOTERS. THESE ALONE MAY BE
INSUFFICIENT TO REMOVE STATIC ELECTRICITY. STORE IN A WELL-VENTILATED
PLACE. STORE AWAY FROM INCOMPATIBLE MATERIALS (SEE SECTION 10 OF THE SDS).
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
OCCUPATIONAL EXPOSURE LIMITS:
US. OSHA TABLE Z-1 LIMITS FOR AIR CONTAMINANTS (29 CFR 1910.1000):
COMPONENTS TYPE VALUE
ACETONE PEL 2400 MG/M3
(CAS 67-64-1) 1000 PPM
CARBON DIOXIDE PEL 9000 MG/M3
(CAS 124-38-9) 5000 PPM
CYCLOHEXANE PEL 1050 MG/M3
(CAS 110-82-7) 300 PPM
METHYLCYCLOHEXANE PEL 2000 MG/M3
(CAS 108-87-2) 500 PPM
N-HEPTANE PEL 2000 MG/M3
(CAS 142-82-5) 500 PPM
US. OSHA TABLE Z-2 (29 CFR 1910.1000):
COMPONENTS TYPE VALUE
TOLUENE CEILING 300 PPM
(CAS 108-88-3) TWA 200 PPM
US. ACGIH THRESHOLD LIMIT VALUES:
COMPONENTS TYPE VALUE
3-METHYLHEXANE STEL 500 PPM
(CAS 589-34-4) TWA 400 PPM
ACETONE STEL 750 PPM
(CAS 67-64-1) TWA 500 PPM
CARBON DIOXIDE STEL 30000 PPM
(CAS 124-38-9) TWA 5000 PPM
CYCLOHEXANE TWA 100 PPM
(CAS 110-82-7)
METHYLCYCLOHEXANE STEL 500 PPM
(CAS 108-87-2) TWA 400 PPM
N-HEPTANE STEL 500 PPM
(CAS 142-82-5) TWA 400 PPM
TOLUENE TWA 20 PPM
(CAS 108-88-3)
US. NIOSH: POCKET GUIDE TO CHEMICAL HAZARDS
COMPONENTS TYPE VALUE
ACETONE TWA 590 MG/M3
(CAS 67-64-1) 250 PPM
CARBON DIOXIDE STEL 54000 MG/M3
(CAS 124-38-9) 30000 PPM
TWA 9000 MG/M3
5000 PPM
CYCLOHEXANE TWA 1050 MG/M3
(CAS 110-82-7) 300 PPM
METHYLCYCLOHEXANE TWA 1600 MG/M3
(CAS 108-87-2) 400 PPM
N-HEPTANE CEILING 1800 MG/M3
(CAS 142-82-5) 440 PPM
TWA 350 MG/M3
85 PPM
TOLUENE STEL 560 MG/M3
(CAS 108-88-3) 150 PPM
TWA 375 MG/M3
100 PPM
BIOLOGICAL LIMIT VALUES:
ACGIH BIOLOGICAL EXPOSURE INDICES:
COMPONENTS VALUE DETERMINANT SPECIMEN SAMPLING TIME
ACETONE 50 MG/L ACETONE URINE *
(CAS 67-64-1)
TOLUENE 0.3 MG/G O-CRESOL, WITH CREATININE IN *
(CAS 108-88-3) HYDROLYSIS URINE
0.03 MG/L TOLUENE URINE *
0.02 MG/L TOLUENE BLOOD *
* - FOR SAMPLING DETAILS, PLEASE SEE THE SOURCE DOCUMENT.
EXPOSURE GUIDELINES:
US - CALIFORNIA OELS SKIN DESIGNATION
TOLUENE (CAS 108-88-3) CAN BE ABSORBED THROUGH THE SKIN.
US - MINNESOTA HAZ SUBS SKIN DESIGNATION APPLIES
TOLUENE (CAS 108-88-3) SKIN DESIGNATION APPLIES.
APPROPRIATE ENGINEERING CONTROLS:
GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER HOUR) SHOULD BE
USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS. IF APPLICABLE, USE
PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING
CONTROLS TO MAINTAIN AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS. IF
EXPOSURE LIMITS HAVE NOT BEEN ESTABLISHED, MAINTAIN AIRBORNE LEVELS TO AN
ACCEPTABLE LEVEL. PROVIDE EYEWASH STATION.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION: WEAR SAFETY GLASSES WITH SIDE SHIELDS (OR GOGGLES).
SKIN PROTECTION:
HAND PROTECTION:
WEAR PROTECTIVE GLOVES SUCH AS: NITRILE. NEOPRENE. POLYVINYL ALCOHOL (PVA).
OTHER: WEAR SUITABLE PROTECTIVE CLOTHING.
RESPIRATORY PROTECTION:
IF ENGINEERING CONTROLS ARE NOT FEASIBLE OR IF EXPOSURE EXCEEDS THE
APPLICABLE EXPOSURE LIMITS, USE A NIOSH-APPROVED CARTRIDGE RESPIRATOR WITH
AN ORGANIC VAPOR CARTRIDGE. USE A SELF-CONTAINED BREATHING APPARATUS IN
CONFINED SPACES AND FOR EMERGENCIES. AIR MONITORING IS NEEDED TO DETERMINE
ACTUAL EMPLOYEE EXPOSURE LEVELS.
THERMAL HAZARDS:
WEAR APPROPRIATE THERMAL PROTECTIVE CLOTHING, WHEN NECESSARY.
GENERAL HYGIENE CONSIDERATIONS:
WHEN USING DO NOT SMOKE. ALWAYS OBSERVE GOOD PERSONAL HYGIENE MEASURES,
SUCH AS WASHING AFTER HANDLING THE MATERIAL AND BEFORE EATING, DRINKING,
AND/OR SMOKING. ROUTINELY WASH WORK CLOTHING AND PROTECTIVE EQUIPMENT TO
REMOVE CONTAMINANTS.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: LIQUID.
FORM: AEROSOL.
COLOR: CLEAR. COLORLESS.
ODOR: KETONE.
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
MELTING POINT/FREEZING POINT: -195.9 DEG. F (-126.6 DEG. C) ESTIMATED
INITIAL BOILING POINT AND BOILING RANGE:
132.9 DEG. F (56.1 DEG. C) ESTIMATED
FLASH POINT: <0 DEG. F (<-17.8 DEG. C) TAG CLOSED CUP
EVAPORATION RATE: FAST.
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS:
FLAMMABILITY LIMIT - LOWER (%): 1.1% ESTIMATED
FLAMMABILITY LIMIT - UPPER (%): 12.8% ESTIMATED
VAPOR PRESSURE: 5856.8 HPA ESTIMATED
VAPOR DENSITY: 2 (AIR = 1)
RELATIVE DENSITY: 0.86 ESTIMATED
SOLUBILITY (WATER): SLIGHTLY SOLUBLE.
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: 539.6 DEG. F (282 DEG. C) ESTIMATED
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
VISCOSITY (KINEMATIC): NOT AVAILABLE.
PERCENT VOLATILE: 90.1% ESTIMATED
| 10. STABILITY AND REACTIVITY | |
REACTIVITY:
THE PRODUCT IS STABLE AND NON-REACTIVE UNDER NORMAL CONDITIONS OF USE,
STORAGE AND TRANSPORT.
CHEMICAL STABILITY: MATERIAL IS STABLE UNDER NORMAL CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS:
NO DANGEROUS REACTION KNOWN UNDER CONDITIONS OF NORMAL USE.
CONDITIONS TO AVOID:
HEAT, FLAMES AND SPARKS. CONTACT WITH INCOMPATIBLE MATERIALS.
INCOMPATIBLE MATERIALS: ACIDS. ALUMINUM. STRONG OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS: CARBON OXIDES.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INHALATION:
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE BY
INHALATION. MAY CAUSE DROWSINESS AND DIZZINESS. HEADACHE. NAUSEA, VOMITING.
SKIN CONTACT: PROLONGED SKIN CONTACT MAY CAUSE TEMPORARY IRRITATION.
EYE CONTACT: CAUSES SERIOUS EYE IRRITATION.
INGESTION:
SINGLE DOSE ORAL TOXICITY IS CONSIDERED TO BE LOW. SWALLOWING LARGE AMOUNTS
MAY CAUSE SERIOUS INJURY, EVEN DEATH. IF ASPIRATED INTO LUNGS, DURING
SWALLOWING OR VOMITING, LIQUID MAY BE RAPIDLY ABSORBED THROUGH THE LUNGS
AND RESULT IN INJURY TO OTHER BODY SYSTEMS.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
HEADACHE. MAY CAUSE DROWSINESS AND DIZZINESS. NAUSEA, VOMITING. SEVERE EYE
IRRITATION. SYMPTOMS MAY INCLUDE STINGING, TEARING, REDNESS, SWELLING, AND
BLURRED VISION.
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY: NARCOTIC EFFECTS.
PRODUCT SPECIES TEST RESULTS
THROTTLE BODY & AIR-INTAKE CLEANER:
ACUTE:
DERMAL:
LD50 RABBIT 13960 MG/KG ESTIMATED
INHALATION:
LC50 RAT 80 MG/L, 4 HOURS ESTIMATED
ORAL:
LD50 RAT 6330 MG/KG ESTIMATED
* ESTIMATES FOR PRODUCT MAY BE BASED ON ADDITIONAL COMPONENT DATA NOT
SHOWN.
SKIN CORROSION/IRRITATION:
PROLONGED SKIN CONTACT MAY CAUSE TEMPORARY IRRITATION.
SERIOUS EYE DAMAGE/EYE IRRITATION: CAUSES SERIOUS EYE IRRITATION.
RESPIRATORY SENSITIZATION: NOT A RESPIRATORY SENSITIZER.
SKIN SENSITIZATION:
THIS PRODUCT IS NOT EXPECTED TO CAUSE SKIN SENSITIZATION.
GERM CELL MUTAGENICITY:
NO DATA AVAILABLE TO INDICATE PRODUCT OR ANY COMPONENTS PRESENT AT GREATER
THAN 0.1% ARE MUTAGENIC OR GENOTOXIC.
CARCINOGENICITY:
THIS PRODUCT IS NOT CONSIDERED TO BE A CARCINOGEN BY IARC, ACGIH, NTP, OR
OSHA.
IARC MONOGRAPHS. OVERALL EVALUATION OF CARCINOGENICITY:
TOLUENE (CAS 108-88-3): 3 NOT CLASSIFIABLE AS TO CARCINOGENICITY TO HUMANS.
REPRODUCTIVE TOXICITY: SUSPECTED OF DAMAGING THE UNBORN CHILD.
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE:
MAY CAUSE DROWSINESS AND DIZZINESS.
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE:
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE:
LIVER. KIDNEYS. BRAIN. LUNGS.
ASPIRATION HAZARD:
BASED ON AVAILABLE DATA, THE CLASSIFICATION CRITERIA ARE NOT MET.
CHRONIC EFFECTS:
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
PROLONGED INHALATION MAY BE HARMFUL.
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY: TOXIC TO AQUATIC LIFE WITH LONG LASTING EFFECTS.
PRODUCT SPECIES TEST RESULTS
THROTTLE BODY & AIR-INTAKE CLEANER:
AQUATIC:
ACUTE:
FISH LC50 FISH 119.4553 MG/L, 96 HOURS ESTIMATED
COMPONENTS SPECIES TEST RESULTS
ACETONE (CAS 67-64-1):
AQUATIC:
CRUSTACEA EC50 WATER FLEA 10294 - 17704 MG/L, 48 HOURS
(DAPHNIA MAGNA)
FISH LC50 RAINBOW TROUT, 4740 - 6330 MG/L, 96 HOURS
DONALDSON TROUT
(ONCORHYNCHUS MYKISS)
CYCLOHEXANE (CAS 110-82-7):
AQUATIC:
FISH LC50 FATHEAD MINNOW 23.03 - 42.07 MG/L, 96 HOURS
(PIMEPHALES PROMELAS)
METHYLCYCLOHEXANE (CAS 108-87-2):
AQUATIC:
FISH LC50 STRIPED BASS 5.8 MG/L, 96 HOURS
(MORONE SAXATILIS)
N-HEPTANE (CAS 142-82-5):
AQUATIC:
ACUTE:
FISH LC50 FATHEAD MINNOW 2.1 - 2.98 MG/L, 96 HOURS
(PIMEPHALES PROMELAS)
TOLUENE (CAS 108-88-3):
AQUATIC:
CRUSTACEA EC50 WATER FLEA 5.46 - 9.83 MG/L, 48 HOURS
(DAPHNIA MAGNA)
FISH LC50 COHO SALMON, 8.11 MG/L, 96 HOURS
SILVER SALMON
(ONCORHYNCHUS KISUTCH)
* ESTIMATES FOR PRODUCT MAY BE BASED ON ADDITIONAL COMPONENT DATA NOT
SHOWN.
PERSISTENCE AND DEGRADABILITY:
NO DATA IS AVAILABLE ON THE DEGRADABILITY OF THIS PRODUCT.
BIOACCUMULATIVE POTENTIAL:
PARTITION COEFFICIENT N-OCTANOL / WATER (LOG KOW):
ACETONE: -0.24
CYCLOHEXANE: 3.44
METHYLCYCLOHEXANE: 3.61
N-HEPTANE: 4.66
TOLUENE: 2.73
MOBILITY IN SOIL: NO DATA AVAILABLE.
OTHER ADVERSE EFFECTS:
NO OTHER ADVERSE ENVIRONMENTAL EFFECTS (E.G. OZONE DEPLETION, PHOTOCHEMICAL
OZONE CREATION POTENTIAL, ENDOCRINE DISRUPTION, GLOBAL WARMING POTENTIAL)
ARE EXPECTED FROM THIS COMPONENT.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL OF WASTE FROM RESIDUES / UNUSED PRODUCTS:
IF DISCARDED, THIS PRODUCT IS CONSIDERED A RCRA IGNITABLE WASTE, D001.
COLLECT AND RECLAIM OR DISPOSE IN SEALED CONTAINERS AT LICENSED WASTE
DISPOSAL SITE. CONTENTS UNDER PRESSURE. DO NOT PUNCTURE, INCINERATE OR
CRUSH. DISPOSE IN ACCORDANCE WITH ALL APPLICABLE REGULATIONS.
HAZARDOUS WASTE CODE:
D001: WASTE FLAMMABLE MATERIAL WITH A FLASH POINT <140 F
CONTAMINATED PACKAGING:
EMPTY CONTAINERS SHOULD BE TAKEN TO AN APPROVED WASTE HANDLING SITE FOR
RECYCLING OR DISPOSAL.
SINCE EMPTIED CONTAINERS MAY RETAIN PRODUCT RESIDUE, FOLLOW LABEL WARNINGS
EVEN AFTER CONTAINER IS EMPTIED.
| 14. TRANSPORT INFORMATION | |
DOT:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, FLAMMABLE, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
LABEL(S): 2.1
PACKING GROUP: NOT APPLICABLE.
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
SPECIAL PROVISIONS: N82
PACKAGING EXCEPTIONS: 306
PACKAGING NON BULK: NONE
PACKAGING BULK: NONE
IATA:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, FLAMMABLE, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
PACKING GROUP: NOT APPLICABLE.
ENVIRONMENTAL HAZARDS: NO.
ERG CODE: 10L
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
OTHER INFORMATION:
PASSENGER AND CARGO AIRCRAFT: ALLOWED.
CARGO AIRCRAFT ONLY: ALLOWED.
IMDG:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, LIMITED QUANTITY, MARINE POLLUTANT
TRANSPORT HAZARD CLASS(ES):
CLASS: 2
SUBSIDIARY RISK:
PACKING GROUP: NOT APPLICABLE.
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: YES
EMS: F-D, S-U
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
| 15. REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
TSCA SECTION 12(B) EXPORT NOTIFICATION (40 CFR 707, SUBPT. D):
NOT REGULATED.
US. OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1050):
NOT LISTED.
SARA 304 EMERGENCY RELEASE NOTIFICATION: NOT REGULATED.
US EPCRA (SARA TITLE III) SECTION 313 - TOXIC CHEMICAL LISTED SUBSTANCE
TOLUENE (CAS 108-88-3)
CERCLA HAZARDOUS SUBSTANCE LIST (40 CFR 302.4):
ACETONE (CAS 67-64-1): LISTED.
TOLUENE (CAS 108-88-3): LISTED.
CERCLA HAZARDOUS SUBSTANCES REPORTABLE QUANTITY
ACETONE (CAS 67-64-1) 5000 LBS
TOLUENE (CAS 108-88-3) 1000 LBS
SPILLS OR RELEASES RESULTING IN THE LOSS OF ANY INGREDIENT AT OR ABOVE ITS
RQ REQUIRE IMMEDIATE NOTIFICATION TO THE NATIONAL RESPONSE CENTER
(800-424-8802) AND TO YOUR LOCAL EMERGENCY PLANNING COMMITTEE.
CLEAN AIR ACT (CAA) SECTION 112 HAZARDOUS AIR POLLUTANTS (HAPS) LIST:
TOLUENE (CAS 108-88-3)
CLEAN AIR ACT (CAA) SECTION 112(R) ACCIDENTAL RELEASE PREVENTION
(40 CFR 68.130): NOT REGULATED.
SAFE DRINKING WATER ACT (SDWA): NOT REGULATED.
DRUG ENFORCEMENT ADMINISTRATION (DEA). LIST 2, ESSENTIAL CHEMICALS
(21 CFR 1310.02(B) AND 1310.04(F)(2) AND CHEMICAL CODE NUMBER:
ACETONE (CAS 67-64-1): 6532
TOLUENE (CAS 108-88-3): 6594
DRUG ENFORCEMENT ADMINISTRATION (DEA). LIST 1 & 2 EXEMPT CHEMICAL MIXTURES
(21 CFR 1310.12(C)):
ACETONE (CAS 67-64-1): 35 %WV
TOLUENE (CAS 108-88-3): 35 %WV
DEA EXEMPT CHEMICAL MIXTURES CODE NUMBER:
ACETONE (CAS 67-64-1): 6532
TOLUENE (CAS 108-88-3): 594
FOOD AND DRUG ADMINISTRATION (FDA): NOT REGULATED.
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA):
SECTION 311/312 HAZARD CATEGORIES:
IMMEDIATE HAZARD: YES
DELAYED HAZARD: YES
FIRE HAZARD: YES
PRESSURE HAZARD: YES
REACTIVITY HAZARD: NO
SARA 302 EXTREMELY HAZARDOUS SUBSTANCE: NO
US STATE REGULATIONS:
US. CALIFORNIA. CANDIDATE CHEMICALS LIST. SAFER CONSUMER PRODUCTS
REGULATIONS (CAL. CODE REGS, TIT. 22, 69502.3, SUBD. (A)):
ACETONE (CAS 67-64-1)
NAPHTHA (PETROLEUM), HYDROTREATED LIGHT (CAS 64742-49-0)
TOLUENE (CAS 108-88-3)
US. CALIFORNIA CONTROLLED SUBSTANCES. CA DEPARTMENT OF JUSTICE (CALIFORNIA
HEALTH AND SAFETY CODE SECTION 11100): NOT LISTED.
US. NEW JERSEY WORKER AND COMMUNITY RIGHT-TO-KNOW ACT:
3-METHYLHEXANE (CAS 589-34-4)
ACETONE (CAS 67-64-1)
CARBON DIOXIDE (CAS 124-38-9)
METHYLCYCLOHEXANE (CAS 108-87-2)
N-HEPTANE (CAS 142-82-5)
TOLUENE (CAS 108-88-3)
US. MASSACHUSETTS RTK - SUBSTANCE LIST:
3-METHYLHEXANE (CAS 589-34-4)
ACETONE (CAS 67-64-1)
CARBON DIOXIDE (CAS 124-38-9)
METHYLCYCLOHEXANE (CAS 108-87-2)
N-HEPTANE (CAS 142-82-5)
TOLUENE (CAS 108-88-3)
US. PENNSYLVANIA WORKER AND COMMUNITY RIGHT-TO-KNOW LAW:
ACETONE (CAS 67-64-1)
TOLUENE (CAS 108-88-3)
CYCLOHEXANE (CAS 110-82-7)
3-METHYLHEXANE (CAS 589-34-4)
CARBON DIOXIDE (CAS 124-38-9)
METHYLCYCLOHEXANE (CAS 108-87-2)
N-HEPTANE (CAS 142-82-5)
US. RHODE ISLAND RTK:
ACETONE (CAS 67-64-1)
TOLUENE (CAS 108-88-3)
US. CALIFORNIA PROPOSITION 65:
WARNING:
THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER AND BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
US - CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/CARCINOGENIC SUBSTANCE
BENZENE (CAS 71-43-2) LISTED: FEBRUARY 27, 1987
CUMENE (CAS 98-82-8) LISTED: APRIL 6, 2010
ETHANAL (CAS 75-07-0) LISTED: APRIL 1, 1988
ETHYLBENZENE (CAS 100-41-4) LISTED: JUNE 11, 2004
NAPHTHALENE (CAS 91-20-3) LISTED: APRIL 19, 2002
US - CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/DEVELOPMENTAL TOXIN
BENZENE (CAS 71-43-2) LISTED: DECEMBER 26, 1997
TOLUENE (CAS 108-88-3) LISTED: JANUARY 1, 1991
US - CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/FEMALE REPRODUCTIVE TOXIN
TOLUENE (CAS 108-88-3) LISTED: AUGUST 7, 2009
US - CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/MALE REPRODUCTIVE TOXIN
BENZENE (CAS 71-43-2) LISTED: DECEMBER 26, 1997
VOLATILE ORGANIC COMPOUNDS (VOC) REGULATIONS:
EPA:
VOC CONTENT (40 CFR 51.100(S)): 9.1%
CONSUMER PRODUCTS (40 CFR 59, SUBPT. C): COMPLIANT
STATE:
CONSUMER PRODUCTS:
THIS PRODUCT IS REGULATED AS A FUEL INJECTION AIR INTAKE CLEANER. THIS
PRODUCT IS COMPLIANT FOR USE IN ALL 50 STATES.
VOC CONTENT (CA): 9.1%
VOC CONTENT (OTC): 9.1%
INTERNATIONAL INVENTORIES:
COUNTRY(S) OR REGION INVENTORY NAME ON INVENTORY
(YES/NO)*
AUSTRALIA AUSTRALIAN INVENTORY OF CHEMICAL NO
SUBSTANCES (AICS)
CANADA DOMESTIC SUBSTANCES LIST (DSL) NO
CANADA NON-DOMESTIC SUBSTANCES LIST (NDSL) YES
CHINA INVENTORY OF EXISTING CHEMICAL YES
SUBSTANCES IN CHINA (IECSC)
EUROPE EUROPEAN INVENTORY OF EXISTING YES
COMMERCIAL CHEMICAL SUBSTANCES
(EINECS)
EUROPE EUROPEAN LIST OF NOTIFIED CHEMICAL NO
SUBSTANCES (ELINCS)
JAPAN INVENTORY OF EXISTING AND NEW YES
CHEMICAL SUBSTANCES (ENCS)
KOREA EXISTING CHEMICALS LIST (ECL) YES
NEW ZEALAND NEW ZEALAND INVENTORY YES
PHILIPPINES PHILIPPINE INVENTORY OF CHEMICALS YES
AND CHEMICAL SUBSTANCES (PICCS)
UNITED STATES & TOXIC SUBSTANCES CONTROL ACT YES
PUERTO RICO (TSCA) INVENTORY
*A "YES" INDICATES THAT ALL COMPONENTS OF THIS PRODUCT COMPLY WITH THE
INVENTORY REQUIREMENTS ADMINISTERED BY THE GOVERNING COUNTRY(S)
A "NO" INDICATES THAT ONE OR MORE COMPONENTS OF THE PRODUCT ARE NOT LISTED
OR EXEMPT FROM LISTING ON THE INVENTORY ADMINISTERED BY THE GOVERNING
COUNTRY(S).
| 16. OTHER INFORMATION, INCLUDING DATE OF PREPARATION | |
OR LAST REVISION
ISSUE DATE: 05-07-2015
PREPARED BY: ALLISON CHO
VERSION #: 01
FURTHER INFORMATION: CRC # 464K
HMIS(R*) RATINGS:
HEALTH 2*
FLAMMABILITY 4
PHYSICAL HAZARD 0
PERSONAL PROTECTION B
NFPA RATINGS:
HEALTH 2
FLAMMABILITY 4
INSTABILITY 0
NFPA RATINGS:
2
4
0
DISCLAIMER:
THE INFORMATION CONTAINED IN THIS DOCUMENT APPLIES TO THIS SPECIFIC
MATERIAL AS SUPPLIED. IT MAY NOT BE VALID FOR THIS MATERIAL IF IT IS USED
IN COMBINATION WITH ANY OTHER MATERIALS. THIS INFORMATION IS ACCURATE TO
THE BEST OF CRC INDUSTRIES' KNOWLEDGE OR OBTAINED FROM SOURCES BELIEVED BY
CRC TO BE ACCURATE. BEFORE USING ANY PRODUCT, READ ALL WARNINGS AND
DIRECTIONS ON THE LABEL. FOR FURTHER CLARIFICATION OF ANY INFORMATION
CONTAINED ON THIS (M)SDS CONSULT YOUR SUPERVISOR, A HEALTH & SAFETY
PROFESSIONAL, OR CRC INDUSTRIES.
MATERIAL NAME: THROTTLE BODY & AIR-INTAKE CLEANER
SDS: US