| Common Name: | HERCULES SIZZLE |
| Manufacturer: | HCC HOLDINGS |
| SDS Revision Date: | 12/20/2021 |
| SDS Format: | No Format Specified |
| Item Number(s): | 20CM17, 20CM21 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
HERCULES(R*)
HERCULES SIZZLE
HCC HOLDINGS, INC. AN OATEY AFFILIATE
VERSION NO: 2.5
SAFETY DATA SHEET ACCORDING TO OSHA HAZCOM STANDARD (2012) REQUIREMENTS
ISSUE DATE: 12/20/2021
PRINT DATE: 12/20/2021
S.GHS.USA.EN
| SECTION 1 IDENTIFICATION |  |
PRODUCT IDENTIFIER:
PRODUCT NAME: HERCULES SIZZLE
SYNONYMS: NOT AVAILABLE
PROPER SHIPPING NAME: HYDROCHLORIC ACID
OTHER MEANS OF IDENTIFICATION: 20305 AND 20310
RECOMMENDED USE OF THE CHEMICAL AND RESTRICTIONS ON USE:
RELEVANT IDENTIFIED USES:
DRAIN OPENER AND HARD SURFACE DESCALER. RECOMMENDED RESTRICTIONS DO NOT
MIX WITH CAUSTIC MATERIALS OR BLEACH
NAME, ADDRESS, AND TELEPHONE NUMBER OF THE CHEMICAL MANUFACTURER, IMPORTER,
OR OTHER RESPONSIBLE PARTY:
REGISTERED COMPANY NAME: HCC HOLDINGS, INC. AN OATEY AFFILIATE
ADDRESS:
4700 WEST 160TH STREET
CLEVELAND, OH 44135
UNITED STATES
TELEPHONE: 216-267-7100
FAX: NOT AVAILABLE
WEBSITE: NOT AVAILABLE
EMAIL: INFO@OATEY.COM
EMERGENCY PHONE NUMBER:
ASSOCIATION / ORGANISATION: CHEMTREC
EMERGENCY TELEPHONE NUMBERS:
1-800-424-9300 (OUTSIDE THE US 1-703-527-3887)
OTHER EMERGENCY TELEPHONE NUMBERS:
EMERGENCY FIRST AID: 1-877-740-5015
| SECTION 2 HAZARD(S) IDENTIFICATION | |
CLASSIFICATION OF THE SUBSTANCE OR MIXTURE:
CLASSIFICATION:
SKIN CORROSION/IRRITATION CATEGORY 1B, CORROSIVE TO METALS CATEGORY 1,
SERIOUS EYE DAMAGE/EYE IRRITATION CATEGORY 1, SPECIFIC TARGET ORGAN
TOXICITY - SINGLE EXPOSURE (RESPIRATORY TRACT IRRITATION) CATEGORY 3
LABEL ELEMENTS:
HAZARD PICTOGRAM(S):
CORROSION
EXCLAMATION MARK
SIGNAL WORD: DANGER
HAZARD STATEMENT(S):
CAUSES SEVERE SKIN BURNS AND EYE DAMAGE.
MAY BE CORROSIVE TO METALS.
MAY CAUSE RESPIRATORY IRRITATION.
HAZARD(S) NOT OTHERWISE CLASSIFIED: NOT APPLICABLE
PRECAUTIONARY STATEMENT(S) PREVENTION:
DO NOT BREATHE MIST/VAPOURS/SPRAY.
WASH ALL EXPOSED EXTERNAL BODY AREAS THOROUGHLY AFTER HANDLING.
USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA.
WEAR PROTECTIVE GLOVES, PROTECTIVE CLOTHING, EYE PROTECTION AND FACE
PROTECTION.
KEEP ONLY IN ORIGINAL CONTAINER.
AVOID BREATHING MIST/VAPOURS/SPRAY.
PRECAUTIONARY STATEMENT(S) RESPONSE:
IF SWALLOWED: RINSE MOUTH. DO NOT INDUCE VOMITING.
IF ON SKIN (OR HAIR):
TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. RINSE SKIN WITH
WATER/SHOWER.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
IMMEDIATELY CALL A POISON CENTER/DOCTOR/PHYSICIAN/FIRST AIDER.
WASH CONTAMINATED CLOTHING BEFORE REUSE.
ABSORB SPILLAGE TO PREVENT MATERIAL DAMAGE.
IF INHALED: REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING.
PRECAUTIONARY STATEMENT(S) STORAGE:
STORE LOCKED UP.
STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED.
STORE IN CORROSIVE RESISTANT/ CONTAINER WITH A RESISTANT INNER LINER.
PRECAUTIONARY STATEMENT(S) DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER TO AUTHORISED HAZARDOUS OR SPECIAL WASTE
COLLECTION POINT IN ACCORDANCE WITH ANY LOCAL REGULATION.
| SECTION 3 COMPOSITION / INFORMATION ON INGREDIENTS | |
SUBSTANCES: SEE SECTION BELOW FOR COMPOSITION OF MIXTURES
MIXTURES:
CAS NO %[WEIGHT] NAME
7647-01-0* 20-25 HYDROCHLORIC ACID
THE SPECIFIC CHEMICAL IDENTITY AND/OR EXACT PERCENTAGE (CONCENTRATION)
OF COMPOSITION HAS BEEN WITHHELD AS A TRADE SECRET.
| SECTION 4 FIRST-AID MEASURES | |
DESCRIPTION OF FIRST AID MEASURES:
EYE CONTACT:
IF THIS PRODUCT COMES IN CONTACT WITH THE EYES:
IMMEDIATELY HOLD EYELIDS APART AND FLUSH THE EYE CONTINUOUSLY WITH RUNNING
WATER.
ENSURE COMPLETE IRRIGATION OF THE EYE BY KEEPING EYELIDS APART AND AWAY
FROM EYE AND MOVING THE EYELIDS BY OCCASIONALLY LIFTING THE UPPER AND
LOWER LIDS.
CONTINUE FLUSHING UNTIL ADVISED TO STOP BY THE POISONS INFORMATION CENTRE
OR A DOCTOR, OR FOR AT LEAST 15 MINUTES.
TRANSPORT TO HOSPITAL OR DOCTOR WITHOUT DELAY.
REMOVAL OF CONTACT LENSES AFTER AN EYE INJURY SHOULD ONLY BE UNDERTAKEN
BY SKILLED PERSONNEL.
SKIN CONTACT:
IF SKIN OR HAIR CONTACT OCCURS:
IMMEDIATELY FLUSH BODY AND CLOTHES WITH LARGE AMOUNTS OF WATER, USING
SAFETY SHOWER IF AVAILABLE.
QUICKLY REMOVE ALL CONTAMINATED CLOTHING, INCLUDING FOOTWEAR.
WASH SKIN AND HAIR WITH RUNNING WATER. CONTINUE FLUSHING WITH WATER UNTIL
ADVISED TO STOP BY THE POISONS INFORMATION CENTRE.
TRANSPORT TO HOSPITAL, OR DOCTOR.
INHALATION:
IF FUMES OR COMBUSTION PRODUCTS ARE INHALED REMOVE FROM CONTAMINATED AREA.
LAY PATIENT DOWN. KEEP WARM AND RESTED.
PROSTHESES SUCH AS FALSE TEETH, WHICH MAY BLOCK AIRWAY, SHOULD BE REMOVED,
WHERE POSSIBLE, PRIOR TO INITIATING FIRST AID PROCEDURES.
APPLY ARTIFICIAL RESPIRATION IF NOT BREATHING, PREFERABLY WITH A DEMAND
VALVE RESUSCITATOR, BAG-VALVE MASK DEVICE, OR POCKET MASK AS TRAINED.
PERFORM CPR IF NECESSARY.
TRANSPORT TO HOSPITAL, OR DOCTOR, WITHOUT DELAY.
INHALATION OF VAPOURS OR AEROSOLS (MISTS, FUMES) MAY CAUSE LUNG OEDEMA.
CORROSIVE SUBSTANCES MAY CAUSE LUNG DAMAGE (E.G. LUNG OEDEMA, FLUID IN THE
LUNGS).
AS THIS REACTION MAY BE DELAYED UP TO 24 HOURS AFTER EXPOSURE, AFFECTED
INDIVIDUALS NEED COMPLETE REST (PREFERABLY IN SEMI-RECUMBENT POSTURE) AND
MUST BE KEPT UNDER MEDICAL OBSERVATION EVEN IF NO SYMPTOMS ARE (YET)
MANIFESTED.
BEFORE ANY SUCH MANIFESTATION, THE ADMINISTRATION OF A SPRAY CONTAINING A
DEXAMETHASONE DERIVATIVE OR BECLOMETHASONE DERIVATIVE MAY BE CONSIDERED.
THIS MUST DEFINITELY BE LEFT TO A DOCTOR OR PERSON AUTHORISED BY HIM/HER.
(ICSC13719)
INGESTION:
FOR ADVICE, CONTACT A POISONS INFORMATION CENTRE OR A DOCTOR AT ONCE.
URGENT HOSPITAL TREATMENT IS LIKELY TO BE NEEDED.
IF SWALLOWED DO NOT INDUCE VOMITING.
IF VOMITING OCCURS, LEAN PATIENT FORWARD OR PLACE ON LEFT SIDE (HEAD-DOWN
POSITION, IF POSSIBLE) TO MAINTAIN OPEN AIRWAY AND PREVENT ASPIRATION.
OBSERVE THE PATIENT CAREFULLY.
NEVER GIVE LIQUID TO A PERSON SHOWING SIGNS OF BEING SLEEPY OR WITH REDUCED
AWARENESS; I.E. BECOMING UNCONSCIOUS.
GIVE WATER TO RINSE OUT MOUTH, THEN PROVIDE LIQUID SLOWLY AND AS MUCH AS
CASUALTY CAN COMFORTABLY DRINK.
TRANSPORT TO HOSPITAL OR DOCTOR WITHOUT DELAY.
MOST IMPORTANT SYMPTOMS AND EFFECTS, BOTH ACUTE AND DELAYED:
SEE SECTION 11
INDICATION OF ANY IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
TREAT SYMPTOMATICALLY.
FOR CORROSIVES:
BASIC TREATMENT:
ESTABLISH A PATENT AIRWAY WITH SUCTION WHERE NECESSARY.
WATCH FOR SIGNS OF RESPIRATORY INSUFFICIENCY AND ASSIST VENTILATION AS
NECESSARY.
ADMINISTER OXYGEN BY NON-REBREATHER MASK AT 10 TO 15 L/MIN.
MONITOR AND TREAT, WHERE NECESSARY, FOR PULMONARY OEDEMA.
MONITOR AND TREAT, WHERE NECESSARY, FOR SHOCK.
ANTICIPATE SEIZURES.
WHERE EYES HAVE BEEN EXPOSED, FLUSH IMMEDIATELY WITH WATER AND CONTINUE
TO IRRIGATE WITH NORMAL SALINE DURING TRANSPORT TO HOSPITAL.
DO NOT USE EMETICS. WHERE INGESTION IS SUSPECTED RINSE MOUTH AND GIVE UP
TO 200 ML WATER (5 ML/KG RECOMMENDED) FOR DILUTION WHERE PATIENT IS ABLE
TO SWALLOW, HAS A STRONG GAG REFLEX AND DOES NOT DROOL.
SKIN BURNS SHOULD BE COVERED WITH DRY, STERILE BANDAGES, FOLLOWING
DECONTAMINATION.
DO NOT ATTEMPT NEUTRALISATION AS EXOTHERMIC REACTION MAY OCCUR.
ADVANCED TREATMENT:
CONSIDER OROTRACHEAL OR NASOTRACHEAL INTUBATION FOR AIRWAY CONTROL IN
UNCONSCIOUS PATIENT OR WHERE RESPIRATORY ARREST HAS OCCURRED.
POSITIVE-PRESSURE VENTILATION USING A BAG-VALVE MASK MIGHT BE OF USE.
MONITOR AND TREAT, WHERE NECESSARY, FOR ARRHYTHMIAS.
START AN IV D5W TKO. IF SIGNS OF HYPOVOLAEMIA ARE PRESENT USE LACTATED
RINGERS SOLUTION. FLUID OVERLOAD MIGHT CREATE COMPLICATIONS.
DRUG THERAPY SHOULD BE CONSIDERED FOR PULMONARY OEDEMA.
HYPOTENSION WITH SIGNS OF HYPOVOLAEMIA REQUIRES THE CAUTIOUS ADMINISTRATION
OF FLUIDS. FLUID OVERLOAD MIGHT CREATE COMPLICATIONS.
TREAT SEIZURES WITH DIAZEPAM.
PROPARACAINE HYDROCHLORIDE SHOULD BE USED TO ASSIST EYE IRRIGATION.
EMERGENCY DEPARTMENT:
LABORATORY ANALYSIS OF COMPLETE BLOOD COUNT, SERUM ELECTROLYTES, BUN,
CREATININE, GLUCOSE, URINALYSIS, BASELINE FOR SERUM AMINOTRANSFERASES
(ALT AND AST), CALCIUM, PHOSPHORUS AND MAGNESIUM, MAY ASSIST IN
ESTABLISHING A TREATMENT REGIME.
POSITIVE END-EXPIRATORY PRESSURE (PEEP)-ASSISTED VENTILATION MAY BE
REQUIRED FOR ACUTE PARENCHYMAL INJURY OR ADULT RESPIRATORY DISTRESS
SYNDROME.
CONSIDER ENDOSCOPY TO EVALUATE ORAL INJURY.
CONSULT A TOXICOLOGIST AS NECESSARY.
BRONSTEIN, A.C. AND CURRANCE, PL. EMERGENCY CARE FOR HAZARDOUS MATERIALS
EXPOSURE: 2ND ED. 1994
| SECTION 5 FIRE-FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
WATER SPRAY OR FOG.
FOAM.
DRY CHEMICAL POWDER.
BCF (WHERE REGULATIONS PERMIT).
CARBON DIOXIDE.
SPECIAL HAZARDS ARISING FROM THE SUBSTRATE OR MIXTURE:
FIRE INCOMPATIBILITY: NONE KNOWN.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIRE-FIGHTERS:
FIRE FIGHTING:
ALERT FIRE DEPARTMENT AND TELL THEM LOCATION AND NATURE OF HAZARD.
WEAR FULL BODY PROTECTIVE CLOTHING WITH BREATHING APPARATUS.
PREVENT, BY ANY MEANS AVAILABLE, SPILLAGE FROM ENTERING DRAINS OR WATER
COURSE.
USE FIRE FIGHTING PROCEDURES SUITABLE FOR SURROUNDING AREA.
DO NOT APPROACH CONTAINERS SUSPECTED TO BE HOT.
COOL FIRE EXPOSED CONTAINERS WITH WATER SPRAY FROM A PROTECTED LOCATION.
IF SAFE TO DO SO, REMOVE CONTAINERS FROM PATH OF FIRE.
EQUIPMENT SHOULD BE THOROUGHLY DECONTAMINATED AFTER USE.
FIRE/EXPLOSION HAZARD:
NON COMBUSTIBLE.
NOT CONSIDERED A SIGNIFICANT FIRE RISK, HOWEVER CONTAINERS MAY BURN.
MAY EMIT CORROSIVE FUMES.
| SECTION 6 ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
SEE SECTION 8
ENVIRONMENTAL PRECAUTIONS: SEE SECTION 12
METHODS AND MATERIAL FOR CONTAINMENT AND CLEANING UP:
MINOR SPILLS:
DRAINS FOR STORAGE OR USE AREAS SHOULD HAVE RETENTION BASINS FOR PH
ADJUSTMENTS AND DILUTION OF SPILLS BEFORE DISCHARGE OR DISPOSAL OF
MATERIAL.
CHECK REGULARLY FOR SPILLS AND LEAKS.
CLEAN UP ALL SPILLS IMMEDIATELY.
AVOID BREATHING VAPOURS AND CONTACT WITH SKIN AND EYES.
CONTROL PERSONAL CONTACT WITH THE SUBSTANCE, BY USING PROTECTIVE EQUIPMENT.
CONTAIN AND ABSORB SPILL WITH SAND, EARTH, INERT MATERIAL OR VERMICULITE.
WIPE UP.
PLACE IN A SUITABLE, LABELLED CONTAINER FOR WASTE DISPOSAL.
MAJOR SPILLS:
CLEAR AREA OF PERSONNEL AND MOVE UPWIND.
ALERT FIRE DEPARTMENT AND TELL THEM LOCATION AND NATURE OF HAZARD.
WEAR FULL BODY PROTECTIVE CLOTHING WITH BREATHING APPARATUS.
PREVENT, BY ANY MEANS AVAILABLE, SPILLAGE FROM ENTERING DRAINS OR WATER
COURSE.
STOP LEAK IF SAFE TO DO SO.
CONTAIN SPILL WITH SAND, EARTH OR VERMICULITE.
COLLECT RECOVERABLE PRODUCT INTO LABELLED CONTAINERS FOR RECYCLING.
NEUTRALISE/DECONTAMINATE RESIDUE (SEE SECTION 13 FOR SPECIFIC AGENT).
COLLECT SOLID RESIDUES AND SEAL IN LABELLED DRUMS FOR DISPOSAL.
WASH AREA AND PREVENT RUNOFF INTO DRAINS.
AFTER CLEAN UP OPERATIONS, DECONTAMINATE AND LAUNDER ALL PROTECTIVE
CLOTHING AND EQUIPMENT BEFORE STORING AND RE-USING.
IF CONTAMINATION OF DRAINS OR WATERWAYS OCCURS, ADVISE EMERGENCY SERVICES.
PERSONAL PROTECTIVE EQUIPMENT ADVICE IS CONTAINED IN SECTION 8 OF THE SDS.
| SECTION 7 HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
SAFE HANDLING:
AVOID ALL PERSONAL CONTACT, INCLUDING INHALATION.
WEAR PROTECTIVE CLOTHING WHEN RISK OF EXPOSURE OCCURS.
USE IN A WELL-VENTILATED AREA.
WARNING:
TO AVOID VIOLENT REACTION, ALWAYS ADD MATERIAL TO WATER AND NEVER WATER TO
MATERIAL.
AVOID SMOKING, NAKED LIGHTS OR IGNITION SOURCES.
AVOID CONTACT WITH INCOMPATIBLE MATERIALS.
WHEN HANDLING, DO NOT EAT, DRINK OR SMOKE.
KEEP CONTAINERS SECURELY SEALED WHEN NOT IN USE.
AVOID PHYSICAL DAMAGE TO CONTAINERS.
ALWAYS WASH HANDS WITH SOAP AND WATER AFTER HANDLING.
WORK CLOTHES SHOULD BE LAUNDERED SEPARATELY. LAUNDER CONTAMINATED CLOTHING
BEFORE RE-USE.
USE GOOD OCCUPATIONAL WORK PRACTICE.
OBSERVE MANUFACTURER'S STORAGE AND HANDLING RECOMMENDATIONS CONTAINED
WITHIN THIS SDS.
ATMOSPHERE SHOULD BE REGULARLY CHECKED AGAINST ESTABLISHED EXPOSURE
STANDARDS TO ENSURE SAFE WORKING CONDITIONS ARE MAINTAINED.
DO NOT ALLOW CLOTHING WET WITH MATERIAL TO STAY IN CONTACT WITH SKIN
OTHER INFORMATION:
STORE IN ORIGINAL CONTAINERS.
KEEP CONTAINERS SECURELY SEALED.
STORE IN A COOL, DRY, WELL-VENTILATED AREA.
STORE AWAY FROM INCOMPATIBLE MATERIALS AND FOODSTUFF CONTAINERS.
PROTECT CONTAINERS AGAINST PHYSICAL DAMAGE AND CHECK REGULARLY FOR LEAKS.
OBSERVE MANUFACTURER'S STORAGE AND HANDLING RECOMMENDATIONS CONTAINED
WITHIN THIS SDS.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
SUITABLE CONTAINER:
LINED METAL CAN, LINED METAL PAIL/CAN.
PLASTIC PAIL.
POLYLINER DRUM
PACKING AS RECOMMENDED BY MANUFACTURER.
CHECK ALL CONTAINERS ARE CLEARLY LABELLED AND FREE FROM LEAKS.
STORAGE INCOMPATIBILITY: DANGEROUS GOODS OF OTHER CLASSES.
| SECTION 8 EXPOSURE CONTROLS / PERSONAL PROTECTION | |
CONTROL PARAMETERS:
OCCUPATIONAL EXPOSURE LIMITS (OEL):
INGREDIENT DATA:
SOURCE INGREDIENT MATERIAL TWA STEL PEAK NOTES
NAME
US OSHA HYDROCHLORIC HYDROGEN NOT NOT 5 PPM / NOT
PERMISSIBLE ACID CHLORIDE AVAIL- AVAIL- 7 MG/M3 AVAIL-
EXPOSURE ABLE ABLE ABLE
LIMITS
(PELS)
TABLE Z-1
US NIOSH HYDROCHLORIC HYDROGEN NOT NOT 5 PPM / NOT
RECOMMENDED ACID CHLORIDE AVAIL- AVAIL- 7 MG/M3 AVAIL-
EXPOSURE ABLE ABLE ABLE
LIMITS
(RELS)
US ACGIH HYDROCHLORIC HYDROGEN NOT NOT 2 PPM A4
THRESHOLD ACID CHLORIDE AVAIL- AVAIL-
LIMIT ABLE ABLE
VALUES
(TLV)
EXPOSURE CONTROLS:
APPROPRIATE ENGINEERING CONTROLS:
ENGINEERING CONTROLS ARE USED TO REMOVE A HAZARD OR PLACE A BARRIER BETWEEN
THE WORKER AND THE HAZARD. WELL-DESIGNED ENGINEERING CONTROLS CAN BE HIGHLY
EFFECTIVE IN PROTECTING WORKERS AND WILL TYPICALLY BE INDEPENDENT OF WORKER
INTERACTIONS TO PROVIDE THIS HIGH LEVEL OF PROTECTION.
THE BASIC TYPES OF ENGINEERING CONTROLS ARE:
PROCESS CONTROLS WHICH INVOLVE CHANGING THE WAY A JOB ACTIVITY OR PROCESS
IS DONE TO REDUCE THE RISK.
ENCLOSURE AND/OR ISOLATION OF EMISSION SOURCE WHICH KEEPS A SELECTED HAZARD
'PHYSICALLY' AWAY FROM THE WORKER AND VENTILATION THAT STRATEGICALLY 'ADDS'
AND 'REMOVES' AIR IN THE WORK ENVIRONMENT. VENTILATION CAN REMOVE OR DILUTE
AN AIR CONTAMINANT IF DESIGNED PROPERLY. THE DESIGN OF A VENTILATION SYSTEM
MUST MATCH THE PARTICULAR PROCESS AND CHEMICAL OR CONTAMINANT IN USE.
EMPLOYERS MAY NEED TO USE MULTIPLE TYPES OF CONTROLS TO PREVENT EMPLOYEE
OVEREXPOSURE.
LOCAL EXHAUST VENTILATION USUALLY REQUIRED. IF RISK OF OVEREXPOSURE EXISTS,
WEAR APPROVED RESPIRATOR. CORRECT FIT IS ESSENTIAL TO OBTAIN ADEQUATE
PROTECTION. SUPPLIED-AIR TYPE RESPIRATOR MAY BE REQUIRED IN SPECIAL
CIRCUMSTANCES. CORRECT FIT IS ESSENTIAL TO ENSURE ADEQUATE PROTECTION.
AN APPROVED SELF CONTAINED BREATHING APPARATUS (SCBA) MAY BE REQUIRED IN
SOME SITUATIONS.
PROVIDE ADEQUATE VENTILATION IN WAREHOUSE OR CLOSED STORAGE AREA. AIR
CONTAMINANTS GENERATED IN THE WORKPLACE POSSESS VARYING 'ESCAPE' VELOCITIES
WHICH, IN TURN, DETERMINE THE 'CAPTURE VELOCITIES' OF FRESH CIRCULATING AIR
REQUIRED TO EFFECTIVELY REMOVE THE CONTAMINANT.
TYPE OF CONTAMINANT AIR SPEED
SOLVENT, VAPOURS, DEGREASING ETC., 0.25-0.5 M/S
EVAPORATING FROM TANK (IN STILL AIR). (50 100 F/MIN)
AEROSOLS, FUMES FROM POURING OPERATIONS, 0.5-1 M/S
INTERMITTENT CONTAINER FILLING, LOW SPEED (100-200 F/MIN.)
CONVEYER TRANSFERS, WELDING, SPRAY DRIFT,
PLATING ACID FUMES, PICKLING (RELEASED AT
LOW VELOCITY INTO ZONE OF ACTIVE GENERATION)
DIRECT SPRAY, SPRAY PAINTING IN SHALLOW BOOTHS, 1-2.5 M/S
DRUM FILLING, CONVEYER LOADING, CRUSHER DUSTS, (200-500 F/MIN.)
GAS DISCHARGE (ACTIVE GENERATION INTO ZONE OF
RAPID AIR MOTION)
GRINDING, ABRASIVE BLASTING, TUMBLING, HIGH 2.5-10 M/S
SPEED WHEEL GENERATED DUSTS (RELEASED AT HIGH (500-2000 F/MIN.)
INITIAL VELOCITY INTO ZONE OF VERY HIGH RAPID
AIR MOTION).
WITHIN EACH RANGE THE APPROPRIATE VALUE DEPENDS ON:
LOWER END OF THE RANGE UPPER END OF THE RANGE
1: 1:
ROOM AIR CURRENTS MINIMAL OR FAVOURABLE DISTURBING ROOM AIR CURRENTS
TO CAPTURE
2: 2:
CONTAMINANTS OF LOW TOXICITY OR OF NUISANCE CONTAMINANTS OF HIGH TOXICITY
VALUE ONLY.
3: INTERMITTENT, LOW PRODUCTION. 3: HIGH PRODUCTION, HEAVY USE
4: 4:
LARGE HOOD OR LARGE AIR MASS IN MOTION SMALL HOOD-LOCAL CONTROL ONLY
SIMPLE THEORY SHOWS THAT AIR VELOCITY FALLS RAPIDLY WITH DISTANCE AWAY
FROM THE OPENING OF A SIMPLE EXTRACTION PIPE. VELOCITY GENERALLY DECREASES
WITH THE SQUARE OF DISTANCE FROM THE EXTRACTION POINT (IN SIMPLE CASES).
THEREFORE THE AIR SPEED AT THE EXTRACTION POINT SHOULD BE ADJUSTED,
ACCORDINGLY, AFTER REFERENCE TO DISTANCE FROM THE CONTAMINATING SOURCE.
THE AIR VELOCITY AT THE EXTRACTION FAN, FOR EXAMPLE, SHOULD BE A MINIMUM
OF 1-2 M/S (200-400 F/MIN) FOR EXTRACTION OF SOLVENTS GENERATED IN A TANK
2 METERS DISTANT FROM THE EXTRACTION POINT. OTHER MECHANICAL
CONSIDERATIONS, PRODUCING PERFORMANCE DEFICITS WITHIN THE EXTRACTION
APPARATUS, MAKE IT ESSENTIAL THAT THEORETICAL AIR VELOCITIES ARE MULTIPLIED
BY FACTORS OF 10 OR MORE WHEN EXTRACTION SYSTEMS ARE INSTALLED OR USED.
PERSONAL PROTECTION:
GLOVES
FULL SUIT
BOOTS
FULL-FACE RESPIRATOR
EYE AND FACE PROTECTION:
SAFETY GLASSES WITH UNPERFORATED SIDE SHIELDS MAY BE USED WHERE CONTINUOUS
EYE PROTECTION IS DESIRABLE, AS IN LABORATORIES; SPECTACLES ARE NOT
SUFFICIENT WHERE COMPLETE EYE PROTECTION IS NEEDED SUCH AS WHEN HANDLING
BULK-QUANTITIES, WHERE THERE IS A DANGER OF SPLASHING, OR IF THE MATERIAL
MAY BE UNDER PRESSURE.
CHEMICAL GOGGLES. WHENEVER THERE IS A DANGER OF THE MATERIAL COMING IN
CONTACT WITH THE EYES; GOGGLES MUST BE PROPERLY FITTED.
FULL FACE SHIELD (20 CM, 8 IN MINIMUM) MAY BE REQUIRED FOR SUPPLEMENTARY
BUT NEVER FOR PRIMARY PROTECTION OF EYES; THESE AFFORD FACE PROTECTION.
ALTERNATIVELY A GAS MASK MAY REPLACE SPLASH GOGGLES AND FACE SHIELDS.
CONTACT LENSES MAY POSE A SPECIAL HAZARD; SOFT CONTACT LENSES MAY ABSORB
AND CONCENTRATE IRRITANTS. A WRITTEN POLICY DOCUMENT, DESCRIBING THE
WEARING OF LENSES OR RESTRICTIONS ON USE, SHOULD BE CREATED FOR EACH
WORKPLACE OR TASK. THIS SHOULD INCLUDE A REVIEW OF LENS ABSORPTION AND
ADSORPTION FOR THE CLASS OF CHEMICALS IN USE AND AN ACCOUNT OF INJURY
EXPERIENCE.
MEDICAL AND FIRST-AID PERSONNEL SHOULD BE TRAINED IN THEIR REMOVAL AND
SUITABLE EQUIPMENT SHOULD BE READILY AVAILABLE. IN THE EVENT OF CHEMICAL
EXPOSURE, BEGIN EYE IRRIGATION IMMEDIATELY AND REMOVE CONTACT LENS AS
SOON AS PRACTICABLE. LENS SHOULD BE REMOVED AT THE FIRST SIGNS OF EYE
REDNESS OR IRRITATION - LENS SHOULD BE REMOVED IN A CLEAN ENVIRONMENT ONLY
AFTER WORKERS HAVE WASHED HANDS THOROUGHLY. [CDC NIOSH CURRENT INTELLIGENCE
BULLETIN 59], [AS/NZS 1336 OR NATIONAL EQUIVALENT]
SKIN PROTECTION: SEE HAND PROTECTION BELOW
HANDS/FEET PROTECTION:
ELBOW LENGTH PVC GLOVES
WHEN HANDLING CORROSIVE LIQUIDS, WEAR TROUSERS OR OVERALLS OUTSIDE OF
BOOTS, TO AVOID SPILLS ENTERING BOOTS.
BODY PROTECTION: SEE OTHER PROTECTION BELOW
OTHER PROTECTION:
OVERALLS.
PVC APRON.
PVC PROTECTIVE SUIT MAY BE REQUIRED IF EXPOSURE SEVERE.
EYEWASH UNIT.
ENSURE THERE IS READY ACCESS TO A SAFETY SHOWER.
| SECTION 9 PHYSICAL AND CHEMICAL PROPERTIES | |
INFORMATION ON BASIC PHYSICAL AND CHEMICAL PROPERTIES:
APPEARANCE: YELLOW TO LIGHT AMBER LIQUID
PHYSICAL STATE: LIQUID
ODOUR: PUDGENT
ODOUR THRESHOLD: NOT AVAILABLE
PH (AS SUPPLIED): <1
MELTING POINT / FREEZING POINT (DEG. C): <-40
INITIAL BOILING POINT AND BOILING RANGE (DEG. C): 90.56
FLASH POINT (DEG. C): NOT AVAILABLE
EVAPORATION RATE: NOT AVAILABLE
FLAMMABILITY: NOT AVAILABLE
UPPER EXPLOSIVE LIMIT (%): NOT AVAILABLE
LOWER EXPLOSIVE LIMIT (%): NOT AVAILABLE
VAPOUR PRESSURE (KPA): NOT AVAILABLE
SOLUBILITY IN WATER: MISCIBLE
VAPOUR DENSITY (AIR = 1): 1.12
RELATIVE DENSITY (WATER = 1): NOT AVAILABLE
PARTITION COEFFICIENT N-OCTANOL / WATER: NOT AVAILABLE
AUTO-IGNITION TEMPERATURE (DEG. C): NOT AVAILABLE
DECOMPOSITION TEMPERATURE: NOT AVAILABLE
VISCOSITY (CST): NOT AVAILABLE
MOLECULAR WEIGHT (G/MOL): NOT AVAILABLE
TASTE: NOT AVAILABLE
EXPLOSIVE PROPERTIES: NOT AVAILABLE
OXIDISING PROPERTIES: NOT AVAILABLE
SURFACE TENSION (DYN/CM OR MN/M): NOT AVAILABLE
VOLATILE COMPONENT (%VOL): NOT AVAILABLE
GAS GROUP: NOT AVAILABLE
PH AS A SOLUTION (%): NOT AVAILABLE
VOC G/L: <1
| SECTION 10 STABILITY AND REACTIVITY | |
REACTIVITY: NOT REACTIVE UNDER NORMAL CONDITIONS OF USE.
CHEMICAL STABILITY:
UNSTABLE IN THE PRESENCE OF INCOMPATIBLE MATERIALS.
PRODUCT IS CONSIDERED STABLE.
HAZARDOUS POLYMERISATION WILL NOT OCCUR.
POSSIBILITY OF HAZARDOUS REACTIONS:
NO DANGEROUS REACTION KNOWN UNDER CONDITIONS OF NORMAL USE.
CONDITIONS TO AVOID: CONTACT WITH INCOMPATIBLE MATERIALS.
INCOMPATIBLE MATERIALS:
MIXING WITH BLEACH, ALKALI, OR OXIDIZERS MAY GENERATE TOXIC GASES.
HAZARDOUS DECOMPOSITION PRODUCTS: HYDROGEN CHLORIDE
| SECTION 11 TOXICOLOGICAL INFORMATION | |
INFORMATION ON TOXICOLOGICAL EFFECTS:
INHALED:
NOT NORMALLY A HAZARD DUE TO NON-VOLATILE NATURE OF PRODUCT
THE MATERIAL HAS NOT BEEN CLASSIFIED AS 'HARMFUL BY INHALATION'. THIS
IS BECAUSE OF THE LACK OF CORROBORATING ANIMAL OR HUMAN EVIDENCE.
INGESTION:
THE MATERIAL CAN PRODUCE SEVERE CHEMICAL BURNS WITHIN THE ORAL CAVITY AND
GASTROINTESTINAL TRACT FOLLOWING INGESTION.
SKIN CONTACT:
THE MATERIAL CAN PRODUCE SEVERE CHEMICAL BURNS FOLLOWING DIRECT CONTACT
WITH THE SKIN.
EYE:
THE MATERIAL CAN PRODUCE SEVERE CHEMICAL BURNS TO THE EYE FOLLOWING DIRECT
CONTACT. VAPOURS OR MISTS MAY BE EXTREMELY IRRITATING. IF APPLIED TO THE
EYES, THIS MATERIAL CAUSES SEVERE EYE DAMAGE.
CHRONIC:
REPEATED OR PROLONGED EXPOSURE TO CORROSIVES MAY RESULT IN THE EROSION OF
TEETH, INFLAMMATORY AND ULCERATIVE CHANGES IN THE MOUTH AND NECROSIS
(RARELY) OF THE JAW. BRONCHIAL IRRITATION, WITH COUGH, AND FREQUENT
ATTACKS OF BRONCHIAL PNEUMONIA MAY ENSUE. LONG-TERM EXPOSURE TO RESPIRATORY
IRRITANTS MAY RESULT IN AIRWAYS DISEASE, INVOLVING DIFFICULTY BREATHING AND
RELATED WHOLE-BODY PROBLEMS.
SUBSTANCE ACCUMULATION, IN THE HUMAN BODY, MAY OCCUR AND MAY CAUSE SOME
CONCERN FOLLOWING REPEATED OR LONG-TERM OCCUPATIONAL EXPOSURE.
ACUTE TOXICITY (X)
SKIN IRRITATION/CORROSION ( )
SERIOUS EYE DAMAGE/IRRITATION ( )
RESPIRATORY OR SKIN SENSITISATION (X)
MUTAGENICITY (X)
CARCINOGENICITY (X)
REPRODUCTIVITY (X)
STOT - SINGLE EXPOSURE ( )
STOT - REPEATED EXPOSURE (X)
ASPIRATION HAZARD (X)
LEGEND:
(X):
DATA EITHER NOT AVAILABLE OR DOES NOT FILL THE CRITERIA FOR CLASSIFICATION
( ): DATA AVAILABLE TO MAKE CLASSIFICATION
| SECTION 12 ECOLOGICAL INFORMATION | |
TOXICITY:
HERCULES SIZZLE:
ENDPOINT TEST DURATION (HR) SPECIES VALUE SOURCE
NOT NOT NOT NOT NOT
AVAILABLE AVAILABLE AVAILABLE AVAILABLE AVAILABLE
HYDROCHLORIC ACID:
ENDPOINT TEST DURATION (HR) SPECIES VALUE SOURCE
NOT NOT NOT NOT NOT
AVAILABLE AVAILABLE AVAILABLE AVAILABLE AVAILABLE
LEGEND:
EXTRACTED FROM 1. IUCLID TOXICITY DATA 2. EUROPE ECHA REGISTERED
SUBSTANCES - ECOTOXICOLOGICAL INFORMATION - AQUATIC TOXICITY 3. EPIWIN
SUITE V3.12 (QSAR) - AQUATIC TOXICITY DATA (ESTIMATED) 4. US EPA, ECOTOX
DATABASE - AQUATIC TOXICITY DATA 5. ECETOC AQUATIC HAZARD ASSESSMENT DATA
6. NITE (JAPAN) - BIOCONCENTRATION DATA 7. METI (JAPAN) - BIOCONCENTRATION
DATA 8. VENDOR DATA
PREVENT, BY ANY MEANS AVAILABLE, SPILLAGE FROM ENTERING DRAINS OR WATER
COURSES.
DO NOTDISCHARGE INTO SEWER OR WATERWAYS.
PERSISTENCE AND DEGRADABILITY:
INGREDIENT PERSISTENCE WATER/SOIL PERSISTENCE: AIR
HYDROCHLORIC ACID LOW LOW
BIOACCUMULATIVE POTENTIAL:
INGREDIENT BIOACCUMULATION
HYDROCHLORIC ACID LOW (LOGKOW = 0.5392)
MOBILITY IN SOIL:
INGREDIENT MOBILITY
HYDROCHLORIC ACID LOW (KOC = 14.3)
| SECTION 13 DISPOSAL CONSIDERATIONS | |
WASTE TREATMENT METHODS:
PRODUCT / PACKAGING DISPOSAL:
LEGISLATION ADDRESSING WASTE DISPOSAL REQUIREMENTS MAY DIFFER BY COUNTRY,
STATE AND/ OR TERRITORY. EACH USER MUST REFER TO LAWS OPERATING IN THEIR
AREA. IN SOME AREAS, CERTAIN WASTES MUST BE TRACKED.
A HIERARCHY OF CONTROLS SEEMS TO BE COMMON - THE USER SHOULD INVESTIGATE:
REDUCTION
REUSE
RECYCLING
DISPOSAL (IF ALL ELSE FAILS)
THIS MATERIAL MAY BE RECYCLED IF UNUSED, OR IF IT HAS NOT BEEN CONTAMINATED
SO AS TO MAKE IT UNSUITABLE FOR ITS INTENDED USE. IF IT HAS BEEN
CONTAMINATED, IT MAY BE POSSIBLE TO RECLAIM THE PRODUCT BY FILTRATION,
DISTILLATION OR SOME OTHER MEANS. SHELF LIFE CONSIDERATIONS SHOULD ALSO BE
APPLIED IN MAKING DECISIONS OF THIS TYPE. NOTE THAT PROPERTIES OF A
MATERIAL MAY CHANGE IN USE, AND RECYCLING OR REUSE MAY NOT ALWAYS BE
APPROPRIATE.
DO NOT ALLOW WASH WATER FROM CLEANING OR PROCESS EQUIPMENT TO ENTER DRAINS.
IT MAY BE NECESSARY TO COLLECT ALL WASH WATER FOR TREATMENT BEFORE
DISPOSAL.
IN ALL CASES DISPOSAL TO SEWER MAY BE SUBJECT TO LOCAL LAWS AND REGULATIONS
AND THESE SHOULD BE CONSIDERED FIRST.
WHERE IN DOUBT CONTACT THE RESPONSIBLE AUTHORITY.
RECYCLE WHEREVER POSSIBLE.
CONSULT MANUFACTURER FOR RECYCLING OPTIONS OR CONSULT LOCAL OR REGIONAL
WASTE MANAGEMENT AUTHORITY FOR DISPOSAL IF NO SUITABLE TREATMENT OR
DISPOSAL FACILITY CAN BE IDENTIFIED.
TREAT AND NEUTRALISE AT AN APPROVED TREATMENT PLANT. TREATMENT SHOULD
INVOLVE:
NEUTRALISATION FOLLOWED BY:
BURIAL IN A LAND-FILL SPECIFICALLY LICENSED TO ACCEPT CHEMICAL AND / OR
PHARMACEUTICAL WASTES OR INCINERATION IN A LICENSED APPARATUS (AFTER
ADMIXTURE WITH SUITABLE COMBUSTIBLE MATERIAL)
DECONTAMINATE EMPTY CONTAINERS. OBSERVE ALL LABEL SAFEGUARDS UNTIL
CONTAINERS ARE CLEANED AND DESTROYED.
| SECTION 14 TRANSPORT INFORMATION | |
LABELS REQUIRED: CLASS 8, CORROSIVES
MARINE POLLUTANT: NO
LAND TRANSPORT (DOT):
UN NUMBER: 1789
UN PROPER SHIPPING NAME: HYDROCHLORIC ACID
TRANSPORT HAZARD CLASS(ES):
CLASS: 8
SUBRISK: NOT APPLICABLE
PACKING GROUP: II
ENVIRONMENTAL HAZARD: NOT APPLICABLE
SPECIAL PRECAUTIONS FOR USER:
HAZARD LABEL: 8
SPECIAL PROVISIONS: 386, A3, B3, B15, B133, IB2, N41, T8, TP2
AIR TRANSPORT (ICAO-IATA / DGR):
UN NUMBER: 1789
UN PROPER SHIPPING NAME: HYDROCHLORIC ACID
TRANSPORT HAZARD CLASS(ES):
ICAO/IATA CLASS: 8
ICAO / IATA SUBRISK: NOT APPLICABLE
ERG CODE: 8L
PACKING GROUP: II
ENVIRONMENTAL HAZARD: NOT APPLICABLE
SPECIAL PRECAUTIONS FOR USER:
SPECIAL PROVISIONS: A3 A803
CARGO ONLY PACKING INSTRUCTIONS: 855
CARGO ONLY MAXIMUM QTY / PACK: 30 L
PASSENGER AND CARGO PACKING INSTRUCTIONS: 851
PASSENGER AND CARGO MAXIMUM QTY / PACK: 1 L
PASSENGER AND CARGO LIMITED QUANTITY PACKING INSTRUCTIONS: Y840
PASSENGER AND CARGO LIMITED MAXIMUM QTY / PACK: 0.5 L
SEA TRANSPORT (IMDG-CODE / GGVSEE):
UN NUMBER: 1789
UN PROPER SHIPPING NAME: HYDROCHLORIC ACID
TRANSPORT HAZARD CLASS(ES):
IMDG CLASS: 8
IMDG SUBRISK: NOT APPLICABLE
PACKING GROUP: II
ENVIRONMENTAL HAZARD: NOT APPLICABLE
SPECIAL PRECAUTIONS FOR USER:
EMS NUMBER F-A, S-B
SPECIAL PROVISIONS: NOT APPLICABLE
LIMITED QUANTITIES: 1 L
TRANSPORT IN BULK ACCORDING TO ANNEX II OF MARPOL AND THE IBC CODE:
NOT APPLICABLE
TRANSPORT IN BULK IN ACCORDANCE WITH MARPOL ANNEX V AND THE IMSBC CODE:
PRODUCT NAME GROUP
HYDROCHLORIC ACID NOT AVAILABLE
TRANSPORT IN BULK IN ACCORDANCE WITH THE ICG CODE:
PRODUCT NAME SHIP TYPE
HYDROCHLORIC ACID NOT AVAILABLE
| SECTION 15 REGULATORY INFORMATION | |
SAFETY, HEALTH AND ENVIRONMENTAL REGULATIONS / LEGISLATION SPECIFIC FOR
THE SUBSTANCE OR MIXTURE:
HYDROCHLORIC ACID IS FOUND ON THE FOLLOWING REGULATORY LISTS:
INTERNATIONAL AGENCY FOR RESEARCH ON CANCER (IARC) - AGENTS CLASSIFIED BY
THE IARC MONOGRAPHS
US - CALIFORNIA HAZARDOUS AIR POLLUTANTS IDENTIFIED AS TOXIC AIR
CONTAMINANTS
US - MASSACHUSETTS - RIGHT TO KNOW LISTED CHEMICALS
US ACGIH THRESHOLD LIMIT VALUES (TLV)
US ACGIH THRESHOLD LIMIT VALUES (TLV) - CARCINOGENS
US CLEAN AIR ACT - HAZARDOUS AIR POLLUTANTS
US CWA (CLEAN WATER ACT) - LIST OF HAZARDOUS SUBSTANCES
US DEPARTMENT OF HOMELAND SECURITY (DHS) - CHEMICAL FACILITY
ANTI-TERRORISM STANDARDS (CFATS) - CHEMICALS OF INTEREST
US DOE TEMPORARY EMERGENCY EXPOSURE LIMITS (TEELS)
US DRUG ENFORCEMENT ADMINISTRATION (DEA) LIST I AND II REGULATED CHEMICALS
US EPA INTEGRATED RISK INFORMATION SYSTEM (IRIS)
US EPCRA SECTION 313 CHEMICAL LIST
US NIOSH RECOMMENDED EXPOSURE LIMITS (RELS)
US OSHA PERMISSIBLE EXPOSURE LIMITS (PELS) TABLE Z-1
US SARA SECTION 302 EXTREMELY HAZARDOUS SUBSTANCES
US TOXIC SUBSTANCES CONTROL ACT (TSCA) - CHEMICAL SUBSTANCE INVENTORY
US TSCA CHEMICAL SUBSTANCE INVENTORY - INTERIM LIST OF ACTIVE SUBSTANCES
FEDERAL REGULATIONS:
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA):
SECTION 311/312 HAZARD CATEGORIES:
FLAMMABLE (GASES, AEROSOLS, LIQUIDS, OR SOLIDS): NO
GAS UNDER PRESSURE: NO
EXPLOSIVE: NO
SELF-HEATING: NO
PYROPHORIC (LIQUID OR SOLID): NO
PYROPHORIC GAS: NO
CORROSIVE TO METAL: YES
OXIDIZER (LIQUID, SOLID OR GAS): NO
ORGANIC PEROXIDE: NO
SELF-REACTIVE: NO
IN CONTACT WITH WATER EMITS FLAMMABLE GAS: NO
COMBUSTIBLE DUST: NO
CARCINOGENICITY: NO
ACUTE TOXICITY (ANY ROUTE OF EXPOSURE): NO
REPRODUCTIVE TOXICITY: NO
SKIN CORROSION OR IRRITATION: YES
RESPIRATORY OR SKIN SENSITIZATION: NO
SERIOUS EYE DAMAGE OR EYE IRRITATION: YES
SPECIFIC TARGET ORGAN TOXICITY (SINGLE OR REPEATED EXPOSURE): NO
ASPIRATION HAZARD: NO
GERM CELL MUTAGENICITY: NO
SIMPLE ASPHYXIANT: NO
HAZARDS NOT OTHERWISE CLASSIFIED: NO
US. EPA CERCLA HAZARDOUS SUBSTANCES AND REPORTABLE QUANTITIES
(40 CFR 302.4):
NAME REPORTABLE QUANTITY REPORTABLE QUANTITY
IN POUNDS (LB) IN KG
HYDROCHLORIC ACID 5000 2270
STATE REGULATIONS:
US. CALIFORNIA PROPOSITION 65: NONE REPORTED
NATIONAL INVENTORY STATUS:
NATIONAL INVENTORY STATUS
USA - TSCA YES
YES:
ALL CAS DECLARED INGREDIENTS ARE ON THE
INVENTORY
LEGEND NO:
ONE OR MORE OF THE CAS LISTED INGREDIENTS
ARE NOT ON THE INVENTORY. THESE INGREDIENTS
MAY BE EXEMPT OR WILL REQUIRE REGISTRATION.
| SECTION 16 OTHER INFORMATION | |
REVISION DATE: 12/20/2021
INITIAL DATE: 11/18/2020
OTHER INFORMATION:
THE SDS IS A HAZARD COMMUNICATION TOOL AND SHOULD BE USED TO ASSIST IN THE
RISK ASSESSMENT. MANY FACTORS DETERMINE WHETHER THE REPORTED HAZARDS ARE
RISKS IN THE WORKPLACE OR OTHER SETTINGS. RISKS MAY BE DETERMINED BY
REFERENCE TO EXPOSURES SCENARIOS. SCALE OF USE, FREQUENCY OF USE AND
CURRENT OR AVAILABLE ENGINEERING CONTROLS MUST BE CONSIDERED.
DEFINITIONS AND ABBREVIATIONS:
PC-TWA: PERMISSIBLE CONCENTRATION-TIME WEIGHTED AVERAGE
PC-STEL: PERMISSIBLE CONCENTRATION-SHORT TERM EXPOSURE LIMIT
IARC: INTERNATIONAL AGENCY FOR RESEARCH ON CANCER
ACGIH: AMERICAN CONFERENCE OF GOVERNMENTAL INDUSTRIAL HYGIENISTS
STEL: SHORT TERM EXPOSURE LIMIT
TEEL: TEMPORARY EMERGENCY EXPOSURE LIMIT
IDLH: IMMEDIATELY DANGEROUS TO LIFE OR HEALTH CONCENTRATIONS
ES: EXPOSURE STANDARD
OSF: ODOUR SAFETY FACTOR
NOAEL: NO OBSERVED ADVERSE EFFECT LEVEL
LOAEL: LOWEST OBSERVED ADVERSE EFFECT LEVEL
TLV: THRESHOLD LIMIT VALUE
LOD: LIMIT OF DETECTION
OTV: ODOUR THRESHOLD VALUE
BCF: BIOCONCENTRATION FACTORS
BEI: BIOLOGICAL EXPOSURE INDEX
AIIC: AUSTRALIAN INVENTORY OF INDUSTRIAL CHEMICALS
DSL: DOMESTIC SUBSTANCES LIST
NDSL: NON-DOMESTIC SUBSTANCES LIST
IECSC: INVENTORY OF EXISTING CHEMICAL SUBSTANCE IN CHINA
EINECS: EUROPEAN INVENTORY OF EXISTING COMMERCIAL CHEMICAL SUBSTANCES
ELINCS: EUROPEAN LIST OF NOTIFIED CHEMICAL SUBSTANCES
NLP: NO-LONGER POLYMERS
ENCS: EXISTING AND NEW CHEMICAL SUBSTANCES INVENTORY
KECI: KOREA EXISTING CHEMICALS INVENTORY
NZIOC: NEW ZEALAND INVENTORY OF CHEMICALS
PICCS: PHILIPPINE INVENTORY OF CHEMICALS AND CHEMICAL SUBSTANCES
TSCA: TOXIC SUBSTANCES CONTROL ACT
TCSI: TAIWAN CHEMICAL SUBSTANCE INVENTORY
INSQ: INVENTARIO NACIONAL DE SUSTANCIAS QUFMICAS
NCI: NATIONAL CHEMICAL INVENTORY
FBEPH:
RUSSIAN REGISTER OF POTENTIALLY HAZARDOUS CHEMICAL AND BIOLOGICAL
SUBSTANCES