| Common Name: | MULTI-USE PRODUCT 25% VOC BULK LIQUID |
| Manufacturer: | WD-40 |
| SDS Revision Date: | 3/5/2019 |
| SDS Format: | GHS-US |
| Item Number(s): | 20JY66, 20JY67, 20JY68 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
WD-40(R*)
MULTI-USE PRODUCT
WD-40 COMPANY
SAFETY DATA SHEET
CALIFORNIA CARB COMPLIANT
| 1 - CHEMICAL PRODUCT AND COMPANY IDENTIFICATION |  |
TRADE NAME: WD-40 MULTI-USE PRODUCT 25% VOC BULK LIQUID
PRODUCT USE:
LUBRICANT, PENETRANT, DRIVES OUT MOISTURE, REMOVES AND PROTECTS SURFACES
FROM CORROSION
RESTRICTIONS ON USE: NONE IDENTIFIED
SDS DATE OF PREPARATION: MARCH 5, 2019
MANUFACTURER: WD-40 COMPANY
ADDRESS:
9715 BUSINESSPARK AVENUE
SAN DIEGO, CALIFORNIA 92131
USA
TELEPHONE:
EMERGENCY: 1-888-324-7596
INFORMATION: 1-888-324-7596
CHEMICAL SPILLS:
1-800-424-9300 (CHEMTREC)
1-703-527-3887 (INTERNATIONAL CALLS)
| 2 - HAZARDS IDENTIFICATION | |
HAZCOM 2012/GHS CLASSIFICATION:
FLAMMABLE LIQUID: CATEGORY 3
ASPIRATION TOXICITY: CATEGORY 1
SPECIFIC TARGET ORGAN TOXICITY SINGLE EXPOSURE:
CATEGORY 3 (NERVOUS SYSTEM EFFECTS)
NOTE:
THE 1 GALLON SIZE PRODUCT IS A CONSUMER PRODUCT AND IS LABELED IN
ACCORDANCE WITH THE US CONSUMER PRODUCT SAFETY COMMISSION REGULATIONS WHICH
TAKE PRECEDENCE OVER OSHA HAZARD COMMUNICATION LABELING. THE ACTUAL
CONTAINER LABEL WILL NOT INCLUDE THE LABEL ELEMENTS BELOW. THE LABELING
BELOW APPLIES TO LARGER CONTAINERS SOLD FOR INDUSTRIAL/PROFESSIONAL USE.
LABEL ELEMENTS:
FLAME
HEALTH HAZARD
EXCLAMATION MARK
DANGER!
FLAMMABLE LIQUID AND VAPOR.
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
MAY CAUSE DROWSINESS OR DIZZINESS.
PREVENTION:
KEEP AWAY FROM HEAT, SPARKS, OPEN FLAMES, HOT SURFACES. - NO SMOKING.
KEEP CONTAINER TIGHTLY CLOSED.
GROUND AND BOND CONTAINERS AND RECEIVING EQUIPMENT.
USE EXPLOSION-PROOF ELECTRICAL EQUIPMENT.
USE ONLY NON-SPARKING TOOLS.
TAKE PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGE.
AVOID BREATHING MISTS OR VAPORS.
USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA.
WEAR EYE PROTECTION.
RESPONSE:
IF SWALLOWED:
IMMEDIATELY CALL A POISON CENTER OR PHYSICIAN. DO NOT INDUCE VOMITING.
IF ON SKIN (OR HAIR):
TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. RINSE SKIN WITH WATER.
IF INHALED:
REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING. CALL A
POISON CENTER OR PHYSICIAN IF YOU FEEL UNWELL.
IN CASE OF FIRE:
USE WATER FOG, DRY CHEMICAL, CARBON DIOXIDE OR FOAM TO EXTINGUISH.
STORAGE:
STORE LOCKED UP.
STORE IN A WELL-VENTILATED PLACE. KEEP COOL. KEEP CONTAINER TIGHTLY CLOSED.
DISPOSAL:
DISPOSE OF CONTENTS AND CONTAINER IN ACCORDANCE WITH LOCAL AND NATIONAL
REGULATIONS.
| 3 - COMPOSITION/INFORMATION ON INGREDIENTS | |
INGREDIENT CAS # WEIGHT GHS CLASSIFICATION
PERCENT
LVP ALIPHATIC HYDROCARBON 64742-47-8 40-50% ASPIRATION TOXICITY
CATEGORY 1
PETROLEUM BASE OIL 64742-56-9 <35% NOT HAZARDOUS
64742-65-0
64742-53-6
64742-54-7
64742-71-8
ALIPHATIC HYDROCARBON 64742-47-8 <25% FLAMMABLE LIQUID
CATEGORY 3
ASPIRATION TOXICITY
CATEGORY 1
SPECIFIC TARGET ORGAN
TOXICITY SINGLE EXPOSURE
CATEGORY 3 (NERVOUS
SYSTEM EFFECTS)
NOTE:
THE SPECIFIC CHEMICAL IDENTITY AND EXACT PERCENTAGES ARE A TRADE SECRET.
| 4 - FIRST AID MEASURES | |
INGESTION (SWALLOWED):
ASPIRATION HAZARD. DO NOT INDUCE VOMITING. CALL PHYSICIAN, POISON CONTROL
CENTER OR THE WD-40 SAFETY HOTLINE AT 1-888-324-7596 IMMEDIATELY.
EYE CONTACT:
FLUSH THOROUGHLY WITH WATER. REMOVE CONTACT LENSES IF PRESENT AFTER THE
FIRST 5 MINUTES AND CONTINUE FLUSHING FOR SEVERAL MORE MINUTES. GET MEDICAL
ATTENTION IF IRRITATION PERSISTS.
SKIN CONTACT:
WASH WITH SOAP AND WATER. IF IRRITATION DEVELOPS AND PERSISTS, GET MEDICAL
ATTENTION.
INHALATION (BREATHING):
IF IRRITATION IS EXPERIENCED, MOVE TO FRESH AIR. GET MEDICAL ATTENTION IF
IRRITATION OR OTHER SYMPTOMS DEVELOP AND PERSIST.
SIGNS AND SYMPTOMS OF EXPOSURE:
HARMFUL OR FATAL IF SWALLOWED. ASPIRATION OF LIQUID INTO THE LUNGS DURING
SWALLOWING OR VOMITING MAY CAUSE LUNG DAMAGE. MAY CAUSE EYE AND RESPIRATORY
IRRITATION. INHALATION OF MISTS OR VAPORS MAY CAUSE DROWSINESS, DIZZINESS
AND OTHER NERVOUS SYSTEM EFFECTS. SKIN CONTACT MAY CAUSE DRYING OF THE
SKIN.
INDICATION OF IMMEDIATE MEDICAL ATTENTION/SPECIAL TREATMENT NEEDED:
IMMEDIATE MEDICAL ATTENTION IS NEEDED FOR INGESTION.
| 5 - FIRE FIGHTING MEASURES | |
SUITABLE (AND UNSUITABLE) EXTINGUISHING MEDIA:
USE WATER FOG, DRY CHEMICAL, CARBON DIOXIDE OR FOAM. DO NOT USE WATER JET
OR FLOODING AMOUNTS OF WATER. BURNING PRODUCT WILL FLOAT ON THE SURFACE AND
SPREAD FIRE.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
FLAMMABLE LIQUID AND VAPOR. VAPORS ARE HEAVIER THAN AIR AND MAY TRAVEL
ALONG SURFACES TO REMOTE IGNITION SOURCES AND FLASH BACK. COMBUSTION WILL
PRODUCE OXIDES OF CARBON AND HYDROCARBONS.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIRE-FIGHTERS:
FIREFIGHTERS SHOULD ALWAYS WEAR POSITIVE PRESSURE SELF-CONTAINED BREATHING
APPARATUS AND FULL PROTECTIVE CLOTHING. COOL FIRE-EXPOSED CONTAINERS WITH
WATER.
| 6 - ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
WEAR APPROPRIATE PROTECTIVE CLOTHING (SEE SECTION 8). ELIMINATE ALL SOURCES
OF IGNITION AND VENTILATE AREA.
METHODS AND MATERIALS FOR CONTAINMENT/CLEANUP:
CONTAIN AND COLLECT LIQUID WITH AN INERT ABSORBENT AND PLACE IN A CONTAINER
FOR DISPOSAL. CLEAN SPILL AREA THOROUGHLY. REPORT SPILLS TO AUTHORITIES AS
REQUIRED.
| 7 - HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
AVOID CONTACT WITH EYES. AVOID PROLONGED CONTACT WITH SKIN. AVOID BREATHING
VAPORS OR AEROSOLS. USE WITH ADEQUATE VENTILATION. KEEP AWAY FROM HEAT,
SPARKS, HOT SURFACES AND OPEN FLAMES. WASH THOROUGHLY WITH SOAP AND WATER
AFTER HANDLING. KEEP CONTAINERS CLOSED WHEN NOT IN USE. KEEP OUT OF THE
REACH OF CHILDREN.
CONDITIONS FOR SAFE STORAGE:
STORE IN A COOL, WELL-VENTILATED AREA, AWAY FROM INCOMPATIBLE MATERIALS.
NFPA 30 CLASS II LIQUID.
| 8 - EXPOSURE CONTROLS/PERSONAL PROTECTION | |
CHEMICAL OCCUPATIONAL EXPOSURE LIMITS
LVP ALIPHATIC HYDROCARBON 1200 MG/M3 TWA (MANUFACTURER
RECOMMENDED)
PETROLEUM BASE OIL 5 MG/M3 TWA (INHALABLE)
ACGIH TLV (AS MINERAL OIL)
5 MG/M3 TWA OSHA PEL
(AS OIL MIST, MINERAL)
ALIPHATIC HYDROCARBON 1200 MG/M3 TWA
(MANUFACTURER RECOMMENDED)
THE FOLLOWING CONTROLS ARE RECOMMENDED FOR NORMAL CONSUMER USE OF THIS
PRODUCT:
ENGINEERING CONTROLS: USE IN A WELL-VENTILATED AREA.
PERSONAL PROTECTION:
EYE PROTECTION: AVOID EYE CONTACT. SAFETY GLASSES OR GOGGLES RECOMMENDED.
SKIN PROTECTION:
AVOID PROLONGED SKIN CONTACT. CHEMICAL RESISTANT GLOVES RECOMMENDED FOR
OPERATIONS WHERE SKIN CONTACT IS LIKELY.
RESPIRATORY PROTECTION:
NONE NEEDED FOR NORMAL USE WITH ADEQUATE VENTILATION.
FOR BULK PROCESSING OR WORKPLACE USE THE FOLLOWING CONTROLS ARE
RECOMMENDED:
ENGINEERING CONTROLS:
USE ADEQUATE GENERAL AND LOCAL EXHAUST VENTILATION TO MAINTAIN EXPOSURE
LEVELS BELOW THAT OCCUPATIONAL EXPOSURE LIMITS.
PERSONAL PROTECTION:
EYE PROTECTION: SAFETY GOGGLES RECOMMENDED WHERE EYE CONTACT IS POSSIBLE.
SKIN PROTECTION: WEAR CHEMICAL RESISTANT GLOVES.
RESPIRATORY PROTECTION:
NONE REQUIRED IF VENTILATION IS ADEQUATE. IF THE OCCUPATIONAL EXPOSURE
LIMITS ARE EXCEEDED, WEAR A NIOSH APPROVED RESPIRATOR. RESPIRATOR
SELECTION AND USE SHOULD BE BASED ON CONTAMINANT TYPE, FORM AND
CONCENTRATION. FOLLOW OSHA 1910.134, ANSI Z88.2 AND GOOD INDUSTRIAL
HYGIENE PRACTICE.
WORK/HYGIENE PRACTICES: WASH WITH SOAP AND WATER AFTER HANDLING.
| 9 - PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: LIGHT AMBER LIQUID
FLAMMABLE LIMITS: (SOLVENT PORTION)
LEL: 0.8%
UEL: 5.6%
ODOR: MILD PETROLEUM ODOR
VAPOR PRESSURE: 1 PSI @38 DEG. C (100 DEG. F) ASTM D323
ODOR THRESHOLD: NOT ESTABLISHED
VAPOR DENSITY: GREATER THAN 1 (AIR=1)
PH: NOT APPLICABLE
RELATIVE DENSITY: 0.8 - 0.82 @ 60 DEG. F
MELTING/FREEZING POINT: NOT ESTABLISHED
SOLUBILITIES: INSOLUBLE IN WATER
BOILING POINT/RANGE: 322 - 388 DEG. F (161 - 198 DEG. C)
PARTITION COEFFICIENT; N-OCTANOL/WATER: NOT ESTABLISHED
FLASH POINT: 138 DEG. F (59 DEG. C) TAG CLOSED CUP
AUTOIGNITION TEMPERATURE: NOT ESTABLISHED
EVAPORATION RATE: NOT ESTABLISHED
DECOMPOSITION TEMPERATURE: NOT ESTABLISHED
FLAMMABILITY (SOLID, GAS): NOT APPLICABLE
VISCOSITY: 2.79-2.96 CST @ 100 DEG. F
VOC: 24.9% MIR=0.44 GO3/GVOC (204 GRAMS/LITER)
POUR POINT: -63 DEG. C (-81.4 DEG. F) ASTM D-97
| 10 - STABILITY AND REACTIVITY | |
REACTIVITY: NOT REACTIVE UNDER NORMAL CONDITIONS
CHEMICAL STABILITY: STABLE
POSSIBILITY OF HAZARDOUS REACTIONS:
MAY REACT WITH STRONG OXIDIZERS GENERATING HEAT.
CONDITIONS TO AVOID:
AVOID HEAT, SPARKS, FLAMES AND OTHER SOURCES OF IGNITION.
INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS: CARBON MONOXIDE AND CARBON DIOXIDE.
| 11 - TOXICOLOGICAL INFORMATION | |
SYMPTOMS OF OVEREXPOSURE:
INHALATION:
HIGH CONCENTRATIONS MAY CAUSE NASAL AND RESPIRATORY IRRITATION AND CENTRAL
NERVOUS SYSTEM EFFECTS SUCH AS HEADACHE, DIZZINESS AND NAUSEA. INTENTIONAL
ABUSE MAY BE HARMFUL OR FATAL.
SKIN CONTACT:
PROLONGED AND/OR REPEATED CONTACT MAY PRODUCE MILD IRRITATION AND DEFATTING
WITH POSSIBLE DERMATITIS.
EYE CONTACT:
CONTACT MAY BE IRRITATING TO EYES. MAY CAUSE REDNESS AND TEARING.
INGESTION:
THIS PRODUCT HAS LOW ORAL TOXICITY. SWALLOWING MAY CAUSE GASTROINTESTINAL
IRRITATION, NAUSEA, VOMITING AND DIARRHEA. THIS PRODUCT IS AN ASPIRATION
HAZARD. IF SWALLOWED, CAN ENTER THE LUNGS AND MAY CAUSE CHEMICAL
PNEUMONITIS, SEVERE LUNG DAMAGE AND DEATH.
CHRONIC EFFECTS: NONE EXPECTED.
CARCINOGEN STATUS:
NONE OF THE COMPONENTS ARE LISTED AS A CARCINOGEN OR SUSPECT CARCINOGEN BY
IARC, NTP, ACGIH OR OSHA.
REPRODUCTIVE TOXICITY:
NONE OF THE COMPONENTS IS CONSIDERED A REPRODUCTIVE HAZARD.
NUMERICAL MEASURES OF TOXICITY:
ACUTE TOXICITY ESTIMATES:
ORAL >5,000 MG/KG; DERMAL >2,000 MG/KG BASED ON AN ASSESSMENT OF THE
INGREDIENTS. THIS PRODUCT IS NOT CLASSIFIED AS TOXIC BY ESTABLISHED
CRITERIA. IT IS AN ASPIRATION HAZARD.
| 12 - ECOLOGICAL INFORMATION | |
ECOTOXICITY:
NO SPECIFIC AQUATIC TOXICITY DATA IS CURRENTLY AVAILABLE; HOWEVER
COMPONENTS OF THIS PRODUCT ARE NOT EXPECTED TO BE HARMFUL TO AQUATIC
ORGANISMS
PERSISTENCE AND DEGRADABILITY: COMPONENTS ARE READILY BIODEGRADABLE.
BIOACCUMULATIVE POTENTIAL:
BIOACCUMULATION IS NOT EXPECTED BASED ON AN ASSESSMENT OF THE INGREDIENTS.
MOBILITY IN SOIL: NO DATA AVAILABLE
OTHER ADVERSE EFFECTS: NONE KNOWN
| 13 - DISPOSAL CONSIDERATIONS | |
IF THIS PRODUCT BECOMES A WASTE, IT WOULD BE EXPECTED TO MEET THE CRITERIA
OF A RCRA IGNITABLE HAZARDOUS WASTE (D001). HOWEVER, IT IS THE
RESPONSIBILITY OF THE GENERATOR TO DETERMINE AT THE TIME OF DISPOSAL THE
PROPER CLASSIFICATION AND METHOD OF DISPOSAL. DISPOSE IN ACCORDANCE WITH
FEDERAL, STATE, AND LOCAL REGULATIONS.
| 14 - TRANSPORTATION INFORMATION | |
DOT SURFACE SHIPPING DESCRIPTION:
EXCEPTED FROM HAZMAT (49CFR 173.150 (F)) IN NON-BULK PACKAGING.
BULK PACKAGING:
UN1268, PETROLEUM DISTILLATES, N.O.S., COMBUSTIBLE LIQUID, PG III
IMDG SHIPPING DESCRIPTION: UN1268, PETROLEUM DISTILLATES, N.O.S. 3, PG III
ICAO SHIPPING DESCRIPTION: UN1268, PETROLEUM DISTILLATES, N.O.S. 3, PG III
NOTE:
WD-40 COMPANY DOES NOT TEST CONTAINERS TO ASSURE THAT THEY MEET THE
PRESSURE DIFFERENTIAL AND OTHER REQUIREMENTS FOR TRANSPORT BY AIR. WE
DO NOT RECOMMEND THAT OUR PRODUCTS BE TRANSPORTED BY AIR.
| 15 - REGULATORY INFORMATION | |
U.S. FEDERAL REGULATIONS:
CERCLA 103 REPORTABLE QUANTITY:
THIS PRODUCT IS NOT SUBJECT TO CERCLA REPORTING REQUIREMENTS, HOWEVER, OIL
SPILLS ARE REPORTABLE TO THE NATIONAL RESPONSE CENTER UNDER THE CLEAN WATER
ACT AND MANY STATES HAVE MORE STRINGENT RELEASE REPORTING REQUIREMENTS.
REPORT SPILLS REQUIRED UNDER FEDERAL, STATE AND LOCAL REGULATIONS.
SARA TITLE III:
HAZARD CATEGORY FOR SECTION 311/312: ACUTE HEALTH, FIRE HAZARD
SECTION 313 TOXIC CHEMICALS:
THIS PRODUCT CONTAINS THE FOLLOWING CHEMICALS SUBJECT TO SARA TITLE III
SECTION 313 REPORTING REQUIREMENTS: NONE
SECTION 302 EXTREMELY HAZARDOUS SUBSTANCES (TPQ): NONE
EPA TOXIC SUBSTANCES CONTROL ACT (TSCA) STATUS:
ALL OF THE COMPONENTS OF THIS PRODUCT ARE LISTED ON THE TSCA INVENTORY.
VOC REGULATIONS:
THIS PRODUCT COMPLIES WITH THE CONSUMER PRODUCT VOC LIMITS OF CARB, THE US
EPA AND STATES ADOPTING THE OTC VOC RULES.
CALIFORNIA SAFE DRINKING WATER AND TOXIC ENFORCEMENT ACT (PROPOSITION 65):
THIS PRODUCT DOES NOT REQUIRE A CALIFORNIA PROPOSITION 65 WARNING.
CANADIAN ENVIRONMENTAL PROTECTION ACT:
ALL OF THE INGREDIENTS ARE LISTED ON THE CANADIAN DOMESTIC SUBSTANCES LIST
OR EXEMPT FROM NOTIFICATION
| 16 - OTHER INFORMATION | |
HMIS HAZARD RATING:
HEALTH 1 (SLIGHT HAZARD)
FIRE HAZARD 2 (MODERATE HAZARD)
PHYSICAL HAZARD 0 (MINIMAL HAZARD)
REVISION DATE: MARCH 5, 2019
SUPERSEDES: JULY 19, 2018
REVISION SUMMARY: SECTION 9 - UPDATED VOC DATA.
PREPARED BY: INDUSTRIAL HEALTH & SAFETY CONSULTANTS, INC. SHELTON, CT, USA
REVIEWED BY: I. KOWALSKI
REGULATORY AFFAIRS DEPT.
1022200/NO.0084605