| Common Name: | DYMON OVEN CLEANER - NATURAL CITRUS, 34420 |
| Manufacturer: | ITW PRO BRANDS |
| SDS Revision Date: | 7/26/2018 |
| SDS Format: | GHS-US |
| Item Number(s): | 20PG68, 2DBX5 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
ITW PRO BRANDS
SAFETY DATA SHEET
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFIER: DYMON(R*) OVEN CLEANER - NATURAL CITRUS
OTHER MEANS OF IDENTIFICATION:
PART NUMBER: 34420
RECOMMENDED USE: OVEN CLEANER
RECOMMENDED RESTRICTIONS: NONE KNOWN.
MANUFACTURER/IMPORTER/SUPPLIER/DISTRIBUTOR INFORMATION:
MANUFACTURER:
COMPANY NAME: ITW PRO BRANDS
ADDRESS:
805 E. OLD 56 HIGHWAY
OLATHE, KS 66061
COUNTRY: (U.S.A.)
TEL: +1 800-443-9536
IN CASE OF EMERGENCY: 1-800-535-5053 (INFOTRAC)
| 2. HAZARD(S) IDENTIFICATION | |
PHYSICAL HAZARDS:
GASES UNDER PRESSURE: LIQUEFIED GAS
HEALTH HAZARDS:
SKIN CORROSION/IRRITATION: CATEGORY 1
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 1
SENSITIZATION, SKIN: CATEGORY 1
ENVIRONMENTAL HAZARDS: NOT CLASSIFIED.
OSHA DEFINED HAZARDS: NOT CLASSIFIED.
LABEL ELEMENTS:
GAS CYLINDER
CORROSION
EXCLAMATION MARK
SIGNAL WORD: DANGER
HAZARD STATEMENT:
CONTAINS GAS UNDER PRESSURE; MAY EXPLODE IF HEATED. CAUSES SEVERE SKIN
BURNS AND EYE DAMAGE. MAY CAUSE AN ALLERGIC SKIN REACTION.
PRECAUTIONARY STATEMENT:
PREVENTION:
AVOID BREATHING GAS. WASH THOROUGHLY AFTER HANDLING. CONTAMINATED WORK
CLOTHING MUST NOT BE ALLOWED OUT OF THE WORKPLACE. WEAR PROTECTIVE
GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION.
RESPONSE:
IF SWALLOWED: RINSE MOUTH. DO NOT INDUCE VOMITING.
IF ON SKIN (OR HAIR):
TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. RINSE SKIN WITH
WATER/SHOWER.
IF INHALED: REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING.
IF IN EYES: RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES.
REMOVE CONTACT LENSES, IF PRESENT AND EASY TO DO. CONTINUE RINSING.
IMMEDIATELY CALL A POISON CENTER/DOCTOR.
IF SKIN IRRITATION OR RASH OCCURS:
GET MEDICAL ADVICE/ATTENTION. WASH CONTAMINATED CLOTHING BEFORE REUSE.
STORAGE:
STORE LOCKED UP. PROTECT FROM SUNLIGHT. STORE IN A WELL-VENTILATED PLACE.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
HAZARD(S) NOT OTHERWISE CLASSIFIED (HNOC): NONE KNOWN.
SUPPLEMENTAL INFORMATION: NONE.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
MIXTURES:
CHEMICAL NAME COMMON NAME CAS NUMBER %
AND SYNONYMS
DIETHYLENE GLYCOL 112-34-5 1 - 5
MONOBUTYL ETHER
D-LIMONENE 5989-27-5 1 - 5
ISOBUTANE 75-28-5 1 - 5
POTASSIUM HYDROXIDE 1310-58-3 1 - 5
PROPANE 74-98-6 1 - 5
ALCOHOL ETHOXYLATE PROPRIETARY 0.1 - 1
HEXYLENE GLYCOL 107-41-5 0.1 - 1
MONOETHANOLAMIN 141-43-5 0.1 - 1
MORPHOLINE 110-91-8 0.1 - 1
SMECTITE CLAY 12199-37-0 0.1 - 1
XANTHAN GUM 11138-66-2 0.1 - 1
| 4. FIRST-AID MEASURES | |
INHALATION:
MOVE TO FRESH AIR. CALL A PHYSICIAN IF SYMPTOMS DEVELOP OR PERSIST.
SKIN CONTACT:
REMOVE CONTAMINATED CLOTHING IMMEDIATELY AND WASH SKIN WITH SOAP AND WATER.
CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY. CHEMICAL BURNS MUST
BE TREATED BY A PHYSICIAN. WASH CONTAMINATED CLOTHING BEFORE REUSE.
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. REMOVE
CONTACT LENSES, IF PRESENT AND EASY TO DO. CONTINUE RINSING. CALL A
PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY.
INGESTION:
NOT LIKELY, DUE TO THE FORM OF THE PRODUCT. CALL A PHYSICIAN OR POISON
CONTROL CENTER IMMEDIATELY. RINSE MOUTH. DO NOT INDUCE VOMITING. IF
VOMITING OCCURS, KEEP HEAD LOW SO THAT STOMACH CONTENT DOESN'T GET INTO
THE LUNGS.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
BURNING PAIN AND SEVERE CORROSIVE SKIN DAMAGE. CAUSES SERIOUS EYE DAMAGE.
SYMPTOMS MAY INCLUDE STINGING, TEARING, REDNESS, SWELLING, AND BLURRED
VISION. PERMANENT EYE DAMAGE INCLUDING BLINDNESS COULD RESULT.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
PROVIDE GENERAL SUPPORTIVE MEASURES AND TREAT SYMPTOMATICALLY. CHEMICAL
BURNS:
FLUSH WITH WATER IMMEDIATELY. WHILE FLUSHING, REMOVE CLOTHES WHICH DO NOT
ADHERE TO AFFECTED AREA. CALL AN AMBULANCE. CONTINUE FLUSHING DURING
TRANSPORT TO HOSPITAL. KEEP VICTIM UNDER OBSERVATION. SYMPTOMS MAY BE
DELAYED.
GENERAL INFORMATION:
ENSURE THAT MEDICAL PERSONNEL ARE AWARE OF THE MATERIAL(S) INVOLVED, AND
TAKE PRECAUTIONS TO PROTECT THEMSELVES. WASH CONTAMINATED CLOTHING BEFORE
REUSE.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
WATER FOG. FOAM. DRY CHEMICAL POWDER. CARBON DIOXIDE (CO2).
UNSUITABLE EXTINGUISHING MEDIA:
DO NOT USE WATER JET AS AN EXTINGUISHER, AS THIS WILL SPREAD THE FIRE.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
DURING FIRE, GASES HAZARDOUS TO HEALTH MAY BE FORMED.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING MUST BE
WORN IN CASE OF FIRE.
FIRE FIGHTING EQUIPMENT/INSTRUCTIONS:
IN CASE OF FIRE: STOP LEAK IF SAFE TO DO SO. DO NOT MOVE CARGO OR VEHICLE
IF CARGO HAS BEEN EXPOSED TO HEAT. ALWAYS STAY AWAY FROM TANKS ENGULFED IN
FLAME. MOVE CONTAINERS FROM FIRE AREA IF YOU CAN DO SO WITHOUT RISK. USE
WATER SPRAY TO COOL UNOPENED CONTAINERS. FOR MASSIVE FIRE IN CARGO AREA,
USE UNMANNED HOSE HOLDER OR MONITOR NOZZLES, IF POSSIBLE. IF NOT, WITHDRAW
AND LET FIRE BURN OUT.
SPECIFIC METHODS:
COOL CONTAINERS EXPOSED TO FLAMES WITH WATER UNTIL WELL AFTER THE FIRE IS
OUT.
GENERAL FIRE HAZARDS:
CONTENTS UNDER PRESSURE. PRESSURIZED CONTAINER MAY EXPLODE WHEN EXPOSED TO
HEAT OR FLAME.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
KEEP UNNECESSARY PERSONNEL AWAY. KEEP PEOPLE AWAY FROM AND UPWIND OF
SPILL/LEAK. KEEP OUT OF LOW AREAS. MANY GASES ARE HEAVIER THAN AIR AND
WILL SPREAD ALONG GROUND AND COLLECT IN LOW OR CONFINED AREAS (SEWERS,
BASEMENTS, TANKS). WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND CLOTHING
DURING CLEAN-UP. AVOID BREATHING GAS. EMERGENCY PERSONNEL NEED
SELF-CONTAINED BREATHING EQUIPMENT. DO NOT TOUCH DAMAGED CONTAINERS OR
SPILLED MATERIAL UNLESS WEARING APPROPRIATE PROTECTIVE CLOTHING. VENTILATE
CLOSED SPACES BEFORE ENTERING THEM. LOCAL AUTHORITIES SHOULD BE ADVISED IF
SIGNIFICANT SPILLAGES CANNOT BE CONTAINED. FOR PERSONAL PROTECTION, SEE
SECTION 8 OF THE SDS.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
ISOLATE AREA UNTIL GAS HAS DISPERSED.
LARGE SPILLS:
STOP THE FLOW OF MATERIAL, IF THIS IS WITHOUT RISK. DIKE THE SPILLED
MATERIAL, WHERE THIS IS POSSIBLE. ABSORB IN VERMICULITE, DRY SAND OR EARTH
AND PLACE INTO CONTAINERS. FOLLOWING PRODUCT RECOVERY, FLUSH AREA WITH
WATER.
SMALL SPILLS:
WIPE UP WITH ABSORBENT MATERIAL (E.G. CLOTH, FLEECE). CLEAN SURFACE
THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
NEVER RETURN SPILLS TO ORIGINAL CONTAINERS FOR RE-USE. FOR WASTE DISPOSAL,
SEE SECTION 13 OF THE SDS.
ENVIRONMENTAL PRECAUTIONS:
AVOID DISCHARGE INTO DRAINS, WATER COURSES OR ONTO THE GROUND.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
KEEP AWAY FROM HEAT/SPARKS/OPEN FLAMES/HOT SURFACES. - NO SMOKING. DO NOT
GET IN EYES, ON SKIN, OR ON CLOTHING. AVOID BREATHING GAS. AVOID PROLONGED
EXPOSURE. PROVIDE ADEQUATE VENTILATION. WEAR APPROPRIATE PERSONAL
PROTECTIVE EQUIPMENT. OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
STORE LOCKED UP. STORE IN A COOL, DRY PLACE OUT OF DIRECT SUNLIGHT. STORE
IN TIGHTLY CLOSED CONTAINER. STORE IN A WELL-VENTILATED PLACE. STORED
CONTAINERS SHOULD BE PERIODICALLY CHECKED FOR GENERAL CONDITION AND
LEAKAGE. STORE AWAY FROM INCOMPATIBLE MATERIALS (SEE SECTION 10 OF THE
SDS).
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
OCCUPATIONAL EXPOSURE LIMITS:
THE FOLLOWING CONSTITUENTS ARE THE ONLY CONSTITUENTS OF THE PRODUCT WHICH
HAVE A PEL, TLV OR OTHER RECOMMENDED EXPOSURE LIMIT. AT THIS TIME, THE
OTHER CONSTITUENTS HAVE NO KNOWN EXPOSURE LIMITS.
US. OSHA TABLE Z-1 LIMITS FOR AIR CONTAMINANTS (29 CFR 1910.1000):
COMPONENTS TYPE VALUE
MONOETHANOLAMIN (CAS 141-43-5) PEL 6 MG/M3
3 PPM
MORPHOLINE (CAS 110-91-8) PEL 70 MG/M3
20 PPM
PROPANE (CAS 74-98-6) PEL 1800 MG/M3
1000 PPM
US. ACGIH THRESHOLD LIMIT VALUES:
COMPONENTS TYPE VALUE FORM
DIETHYLENE GLYCOL MONOBUTYL ETHER TWA 10 PPM INHALABLE FRACTION
(CAS 112-34-5) AND VAPOR.
HEXYLENE GLYCOL (CAS 107-41-5) STEL 10 MG/M3 AEROSOL, INHALABLE.
50 PPM VAPOR FRACTION
TWA 25 PPM VAPOR FRACTION
ISOBUTANE (CAS 75-28-5) STEL 1000 PPM
MONOETHANOLAMIN (CAS 141-43-5) STEL 6 PPM
TWA 3 PPM
MORPHOLINE (CAS 110-91-8) TWA 20 PPM
POTASSIUM HYDROXIDE CEILING 2 MG/M3
(CAS 1310-58-3)
US. NIOSH: POCKET GUIDE TO CHEMICAL HAZARDS
COMPONENTS TYPE VALUE
HEXYLENE GLYCOL (CAS 107-41-5) CEILING 125 MG/M3
25 PPM
ISOBUTANE (CAS 75-28-5) TWA 1900 MG/M3
800 PPM
MONOETHANOLAMIN (CAS 141-43-5) STEL 15 MG/M3
6 PPM
TWA 8 MG/M3
3 PPM
MORPHOLINE (CAS 110-91-8) STEL 105 MG/M3
30 PPM
TWA 70 MG/M3
20 PPM
POTASSIUM HYDROXIDE CEILING 2 MG/M3
(CAS 1310-58-3)
PROPANE (CAS 74-98-6) TWA 1800 MG/M3
1000 PPM
BIOLOGICAL LIMIT VALUES:
NO BIOLOGICAL EXPOSURE LIMITS NOTED FOR THE INGREDIENT(S).
EXPOSURE GUIDELINES:
US - CALIFORNIA OELS SKIN DESIGNATION
MORPHOLINE (CAS 110-91-8) CAN BE ABSORBED THROUGH THE SKIN.
US - MINNESOTA HAZ SUBS SKIN DESIGNATION APPLIES
MORPHOLINE (CAS 110-91-8) SKIN DESIGNATION APPLIES.
US - TENNESSEE OELS SKIN DESIGNATION
MORPHOLINE (CAS 110-91-8) CAN BE ABSORBED THROUGH THE SKIN.
US ACGIH THRESHOLD LIMIT VALUES SKIN DESIGNATION
MORPHOLINE (CAS 110-91-8) CAN BE ABSORBED THROUGH THE SKIN.
US NIOSH POCKET GUIDE TO CHEMICAL SKIN DESIGNATION
HAZARDS
MORPHOLINE (CAS 110-91-8) CAN BE ABSORBED THROUGH THE SKIN.
US. OSHA TABLE Z-1 LIMITS FOR AIR CONTAMINANTS (29 CFR 1910.1000):
MORPHOLINE (CAS 110-91-8): CAN BE ABSORBED THROUGH THE SKIN.
APPROPRIATE ENGINEERING CONTROLS:
GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER HOUR) SHOULD BE
USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS. IF APPLICABLE,
USE PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING
CONTROLS TO MAINTAIN AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS. IF
EXPOSURE LIMITS HAVE NOT BEEN ESTABLISHED, MAINTAIN AIRBORNE LEVELS TO AN
ACCEPTABLE LEVEL. EYE WASH FACILITIES AND EMERGENCY SHOWER MUST BE
AVAILABLE WHEN HANDLING THIS PRODUCT.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION:
WEAR SAFETY GLASSES WITH SIDE SHIELDS (OR GOGGLES) AND A FACE SHIELD. FACE
SHIELD IS RECOMMENDED.
SKIN PROTECTION:
HAND PROTECTION: WEAR APPROPRIATE CHEMICAL RESISTANT GLOVES.
OTHER:
WEAR APPROPRIATE CHEMICAL RESISTANT CLOTHING. USE OF AN IMPERVIOUS APRON IS
RECOMMENDED.
RESPIRATORY PROTECTION:
IN CASE OF INSUFFICIENT VENTILATION, WEAR SUITABLE RESPIRATORY EQUIPMENT.
THERMAL HAZARDS:
WEAR APPROPRIATE THERMAL PROTECTIVE CLOTHING, WHEN NECESSARY.
GENERAL HYGIENE CONSIDERATIONS:
ALWAYS OBSERVE GOOD PERSONAL HYGIENE MEASURES, SUCH AS WASHING AFTER
HANDLING THE MATERIAL AND BEFORE EATING, DRINKING, AND/OR SMOKING.
ROUTINELY WASH WORK CLOTHING AND PROTECTIVE EQUIPMENT TO REMOVE
CONTAMINANTS. CONTAMINATED WORK CLOTHING SHOULD NOT BE ALLOWED OUT OF THE
WORKPLACE.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: GAS.
FORM: AEROSOL.
COLOR: WHITE.
ODOR: CITRUS.
ODOR THRESHOLD: NOT AVAILABLE.
PH: 13.5
MELTING POINT/FREEZING POINT: NOT AVAILABLE.
INITIAL BOILING POINT AND BOILING RANGE: 212 DEG. F (100 DEG. C)
FLASH POINT: NONE.
EVAPORATION RATE: NOT AVAILABLE.
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS:
FLAMMABILITY LIMIT - LOWER (%): NOT AVAILABLE.
FLAMMABILITY LIMIT - UPPER (%): NOT AVAILABLE.
EXPLOSIVE LIMIT - LOWER (%): NOT AVAILABLE.
EXPLOSIVE LIMIT - UPPER (%): NOT AVAILABLE.
VAPOR PRESSURE: NOT AVAILABLE.
VAPOR DENSITY: NOT AVAILABLE.
RELATIVE DENSITY: NOT AVAILABLE.
SOLUBILITY(IES):
SOLUBILITY (WATER): COMPLETE
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
VISCOSITY: 500 CP
OTHER INFORMATION:
EXPLOSIVE PROPERTIES: NOT EXPLOSIVE.
OXIDIZING PROPERTIES: NOT OXIDIZING.
SPECIFIC GRAVITY: 1.04 @ 70 DEG. F
VOC: 7.89% PER US STATE AND FEDERAL CONSUMER PRODUCT REGULATIONS
| 10. STABILITY AND REACTIVITY | |
REACTIVITY:
REACTS VIOLENTLY WITH STRONG ACIDS. THIS PRODUCT MAY REACT WITH OXIDIZING
AGENTS.
CHEMICAL STABILITY: MATERIAL IS STABLE UNDER NORMAL CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS:
NO DANGEROUS REACTION KNOWN UNDER CONDITIONS OF NORMAL USE.
CONDITIONS TO AVOID:
KEEP AWAY FROM HEAT, HOT SURFACES, SPARKS, OPEN FLAMES AND OTHER IGNITION
SOURCES. CONTACT WITH INCOMPATIBLE MATERIALS. DO NOT MIX WITH OTHER
CHEMICALS.
INCOMPATIBLE MATERIALS: ACIDS. OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS: CARBON OXIDES.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INHALATION:
MAY CAUSE IRRITATION TO THE RESPIRATORY SYSTEM. PROLONGED INHALATION MAY BE
HARMFUL.
SKIN CONTACT:
CAUSES SEVERE SKIN BURNS. MAY CAUSE AN ALLERGIC SKIN REACTION.
EYE CONTACT: CAUSES SERIOUS EYE DAMAGE.
INGESTION: CAUSES DIGESTIVE TRACT BURNS.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
BURNING PAIN AND SEVERE CORROSIVE SKIN DAMAGE. CAUSES SERIOUS EYE DAMAGE.
SYMPTOMS MAY INCLUDE STINGING, TEARING, REDNESS, SWELLING, AND BLURRED
VISION. PERMANENT EYE DAMAGE INCLUDING BLINDNESS COULD RESULT.
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY: NOT EXPECTED TO BE ACUTELY TOXIC.
COMPONENTS SPECIES TEST RESULTS
DIETHYLENE GLYCOL MONOBUTYL ETHER (CAS 112-34-5):
ACUTE:
DERMAL:
LD50 RABBIT 2700 MG/KG
ORAL:
LD50 RAT 3300 MG/KG
D-LIMONENE (CAS 5989-27-5):
ACUTE:
ORAL:
LD50 RAT >2000 MG/KG
MONOETHANOLAMIN (CAS 141-43-5):
ACUTE:
INHALATION:
VAPOR:
LC50 RAT >1.3 MG/L, 6 HOURS
SKIN CORROSION/IRRITATION: CAUSES SEVERE SKIN BURNS AND EYE DAMAGE.
SERIOUS EYE DAMAGE/EYE IRRITATION: CAUSES SERIOUS EYE DAMAGE.
RESPIRATORY OR SKIN SENSITIZATION:
RESPIRATORY SENSITIZATION: NOT A RESPIRATORY SENSITIZER.
SKIN SENSITIZATION: MAY CAUSE AN ALLERGIC SKIN REACTION.
GERM CELL MUTAGENICITY:
NO DATA AVAILABLE TO INDICATE PRODUCT OR ANY COMPONENTS PRESENT AT GREATER
THAN 0.1% ARE MUTAGENIC OR GENOTOXIC.
CARCINOGENICITY: NOT CLASSIFIABLE AS TO CARCINOGENICITY TO HUMANS.
ACGIH CARCINOGENS:
MORPHOLINE (CAS 110-91-8):
A4: NOT CLASSIFIABLE AS A HUMAN CARCINOGEN.
IARC MONOGRAPHS. OVERALL EVALUATION OF CARCINOGENICITY:
D-LIMONENE (CAS 5989-27-5):
3: NOT CLASSIFIABLE AS TO CARCINOGENICITY TO HUMANS.
MORPHOLINE (CAS 110-91-8):
3: NOT CLASSIFIABLE AS TO CARCINOGENICITY TO HUMANS.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1052):
NOT REGULATED.
US. NATIONAL TOXICOLOGY PROGRAM (NTP) REPORT ON CARCINOGENS: NOT LISTED.
REPRODUCTIVE TOXICITY:
THIS PRODUCT IS NOT EXPECTED TO CAUSE REPRODUCTIVE OR DEVELOPMENTAL
EFFECTS.
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE: NOT CLASSIFIED.
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE: NOT CLASSIFIED.
ASPIRATION HAZARD: NOT LIKELY, DUE TO THE FORM OF THE PRODUCT.
CHRONIC EFFECTS: PROLONGED INHALATION MAY BE HARMFUL.
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY:
THE PRODUCT IS NOT CLASSIFIED AS ENVIRONMENTALLY HAZARDOUS. HOWEVER, THIS
DOES NOT EXCLUDE THE POSSIBILITY THAT LARGE OR FREQUENT SPILLS CAN HAVE A
HARMFUL OR DAMAGING EFFECT ON THE ENVIRONMENT.
COMPONENTS SPECIES TEST RESULTS
DIETHYLENE GLYCOL MONOBUTYL ETHER (CAS 112-34-5):
AQUATIC:
FISH LC50 BLUEGILL (LEPOMIS MACROCHIRUS) 1300 MG/L, 96 HOURS
D-LIMONENE (CAS 5989-27-5):
AQUATIC:
CRUSTACEA EC50 WATER FLEA (DAPHNIA PULEX) 69.6 MG/L, 48 HOURS
FISH LC50 FATHEAD MINNOW (PIMEPHALES PROMELAS) 0.619 - 0.796 MG/L,
96 HOURS
HEXYLENE GLYCOL (CAS 107-41-5):
AQUATIC:
CRUSTACEA EC50 WATER FLEA (CERIODAPHNIA RETICULATA) 2400 - 3200 MG/L,
48 HOURS
FISH LC50 BLEAK (ALBURNUS ALBURNUS) 7000 - 9100 MG/L,
96 HOURS
MONOETHANOLAMIN (CAS 141-43-5):
AQUATIC:
FISH LC50 RAINBOW TROUT,DONALDSON TROUT 114 - 196 MG/L,
(ONCORHYNCHUS MYKISS) 96 HOURS
MORPHOLINE (CAS 110-91-8):
AQUATIC:
FISH LC50 ZEBRA DANIO (DANIO RERIO) >1 MG/L, 96 HOURS
POTASSIUM HYDROXIDE (CAS 1310-58-3):
AQUATIC:
FISH LC50 WESTERN MOSQUITOFISH 80 MG/L, 96 HOURS
(GAMBUSIA AFFINIS)
XANTHAN GUM (CAS 11138-66-2):
AQUATIC:
FISH LC50 RAINBOW TROUT,DONALDSON TROUT 320 - 560 MG/L,
(ONCORHYNCHUS MYKISS) 96 HOURS
PERSISTENCE AND DEGRADABILITY:
NO DATA IS AVAILABLE ON THE DEGRADABILITY OF ANY INGREDIENTS IN THE
MIXTURE.
BIOACCUMULATIVE POTENTIAL:
PARTITION COEFFICIENT N-OCTANOL / WATER (LOG KOW):
DIETHYLENE GLYCOL MONOBUTYL ETHER: 0.56
D-LIMONENE: 4.232
ISOBUTANE: 2.76
MONOETHANOLAMIN: -1.31
MORPHOLINE: -0.86
PROPANE: 2.36
MOBILITY IN SOIL: NO DATA AVAILABLE.
OTHER ADVERSE EFFECTS: NONE KNOWN.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL INSTRUCTIONS:
COLLECT AND RECLAIM OR DISPOSE IN SEALED CONTAINERS AT LICENSED WASTE
DISPOSAL SITE. INCINERATE THE MATERIAL UNDER CONTROLLED CONDITIONS IN AN
APPROVED INCINERATOR. DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
LOCAL DISPOSAL REGULATIONS:
DISPOSE IN ACCORDANCE WITH ALL APPLICABLE REGULATIONS.
HAZARDOUS WASTE CODE:
THE WASTE CODE SHOULD BE ASSIGNED IN DISCUSSION BETWEEN THE USER, THE
PRODUCER AND THE WASTE DISPOSAL COMPANY.
D002: WASTE CORROSIVE MATERIAL [PH <=2 OR =>12.5, OR CORROSIVE TO STEEL]
D003: WASTE REACTIVE MATERIAL
WASTE FROM RESIDUES / UNUSED PRODUCTS:
DISPOSE OF IN ACCORDANCE WITH LOCAL REGULATIONS. EMPTY CONTAINERS OR LINERS
MAY RETAIN SOME PRODUCT RESIDUES. THIS MATERIAL AND ITS CONTAINER MUST BE
DISPOSED OF IN A SAFE MANNER (SEE: DISPOSAL INSTRUCTIONS).
CONTAMINATED PACKAGING:
SINCE EMPTIED CONTAINERS MAY RETAIN PRODUCT RESIDUE, FOLLOW LABEL WARNINGS
EVEN AFTER CONTAINER IS EMPTIED. EMPTY CONTAINERS SHOULD BE TAKEN TO AN
APPROVED WASTE HANDLING SITE FOR RECYCLING OR DISPOSAL.
| 14. TRANSPORT INFORMATION | |
DOT:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME:
AEROSOLS, NON-FLAMMABLE, (EACH NOT EXCEEDING 1 L CAPACITY)
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.2
SUBSIDIARY RISK:
LABEL(S): 2.2
PACKING GROUP: NOT AVAILABLE.
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
PACKAGING EXCEPTIONS: 306
PACKAGING NON BULK: NONE
PACKAGING BULK: NONE
IATA:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, NON-FLAMMABLE
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.2
SUBSIDIARY RISK:
PACKING GROUP: NOT AVAILABLE.
ENVIRONMENTAL HAZARDS: NO.
ERG CODE: 2L
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
OTHER INFORMATION:
PASSENGER AND CARGO AIRCRAFT: ALLOWED WITH RESTRICTIONS.
CARGO AIRCRAFT ONLY: ALLOWED WITH RESTRICTIONS.
IMDG:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, NON-FLAMMABLE
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.2
SUBSIDIARY RISK:
PACKING GROUP: NOT AVAILABLE.
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: NO.
EMS: F-D, S-U
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
TRANSPORT IN BULK ACCORDING TO ANNEX II OF MARPOL 73/78 AND THE IBC CODE:
NOT APPLICABLE.
DOT: NON-FLAMMABLE GAS, CLASS/DIVISION 2.2
IATA; IMDG: CLASS 2.2 - NON-FLAMMABLE GASES
| 15. REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
TSCA SECTION 12(B) EXPORT NOTIFICATION (40 CFR 707, SUBPT. D):
NOT REGULATED.
CERCLA HAZARDOUS SUBSTANCE LIST (40 CFR 302.4):
POTASSIUM HYDROXIDE (CAS 1310-58-3): LISTED.
SARA 304 EMERGENCY RELEASE NOTIFICATION: NOT REGULATED.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1052):
NOT REGULATED.
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA):
SARA 302 EXTREMELY HAZARDOUS SUBSTANCE: NOT LISTED.
CLASSIFIED HAZARD CATEGORIES:
GAS UNDER PRESSURE
SKIN CORROSION OR IRRITATION
SERIOUS EYE DAMAGE OR EYE IRRITATION
RESPIRATORY OR SKIN SENSITIZATION
SARA 313 (TRI REPORTING): NOT REGULATED.
OTHER FEDERAL REGULATIONS:
CLEAN AIR ACT (CAA) SECTION 112 HAZARDOUS AIR POLLUTANTS (HAPS) LIST:
NOT REGULATED.
CLEAN AIR ACT (CAA) SECTION 112(R) ACCIDENTAL RELEASE PREVENTION
(40 CFR 68.130):
ISOBUTANE (CAS 75-28-5)
PROPANE (CAS 74-98-6)
SAFE DRINKING WATER ACT (SDWA): NOT REGULATED.
US STATE REGULATIONS:
US. NEW JERSEY WORKER AND COMMUNITY RIGHT-TO-KNOW ACT:
HEXYLENE GLYCOL (CAS 107-41-5)
ISOBUTANE (CAS 75-28-5)
MONOETHANOLAMIN (CAS 141-43-5)
MORPHOLINE (CAS 110-91-8)
POTASSIUM HYDROXIDE (CAS 1310-58-3)
PROPANE (CAS 74-98-6)
CALIFORNIA PROPOSITION 65:
CALIFORNIA SAFE DRINKING WATER AND TOXIC ENFORCEMENT ACT OF 2016
(PROPOSITION 65):
THIS MATERIAL IS NOT KNOWN TO CONTAIN ANY CHEMICALS CURRENTLY LISTED AS
CARCINOGENS OR REPRODUCTIVE TOXINS. FOR MORE INFORMATION GO TO
WWW.P65WARNINGS.CA.GOV.
US. CALIFORNIA. CANDIDATE CHEMICALS LIST. SAFER CONSUMER PRODUCTS
REGULATIONS (CAL. CODE REGS, TIT. 22, 69502.3, SUBD. (A)):
ISOBUTANE (CAS 75-28-5)
INTERNATIONAL INVENTORIES:
COUNTRY(S) INVENTORY NAME ON INVENTORY (YES/NO)*
OR REGION
AUSTRALIA AUSTRALIAN INVENTORY OF CHEMICAL SUBSTANCES YES
(AICS)
CANADA DOMESTIC SUBSTANCES LIST (DSL) YES
CANADA NON-DOMESTIC SUBSTANCES LIST (NDSL) NO
CHINA INVENTORY OF EXISTING CHEMICAL SUBSTANCES IN NO
CHINA (IECSC)
EUROPE EUROPEAN INVENTORY OF EXISTING COMMERCIAL YES
CHEMICAL SUBSTANCES (EINECS)
EUROPE EUROPEAN LIST OF NOTIFIED CHEMICAL SUBSTANCES NO
(ELINCS)
JAPAN INVENTORY OF EXISTING AND NEW CHEMICAL NO
SUBSTANCES (ENCS)
KOREA EXISTING CHEMICALS LIST (ECL) YES
NEW ZEALAND NEW ZEALAND INVENTORY NO
PHILIPPINES PHILIPPINE INVENTORY OF CHEMICALS AND CHEMICAL YES
SUBSTANCES (PICCS)
TAIWAN TAIWAN CHEMICAL SUBSTANCE INVENTORY (TCSI) NO
UNITED STATES & TOXIC SUBSTANCES CONTROL ACT (TSCA) INVENTORY YES
PUERTO RICO
*A "YES" INDICATES THAT ALL COMPONENTS OF THIS PRODUCT COMPLY WITH THE
INVENTORY REQUIREMENTS ADMINISTERED BY THE GOVERNING COUNTRY(S)
A "NO" INDICATES THAT ONE OR MORE COMPONENTS OF THE PRODUCT ARE NOT LISTED
OR EXEMPT FROM LISTING ON THE INVENTORY ADMINISTERED BY THE GOVERNING
COUNTRY(S).
| 16. OTHER INFORMATION, INCLUDING DATE OF PREPARATION | |
OR LAST REVISION
ISSUE DATE: 07-26-2018
VERSION #: 01
DISCLAIMER:
ITW PRO BRANDS CANNOT ANTICIPATE ALL CONDITIONS UNDER WHICH THIS
INFORMATION AND ITS PRODUCT, OR THE PRODUCTS OF OTHER MANUFACTURERS
IN COMBINATION WITH ITS PRODUCT, MAY BE USED. IT IS THE USER'S
RESPONSIBILITY TO ENSURE SAFE CONDITIONS FOR HANDLING, STORAGE AND
DISPOSAL OF THE PRODUCT, AND TO ASSUME LIABILITY FOR LOSS, INJURY,
DAMAGE OR EXPENSE DUE TO IMPROPER USE. THE INFORMATION IN THE
SHEET WAS WRITTEN BASED ON THE BEST KNOWLEDGE AND EXPERIENCE
CURRENTLY AVAILABLE.
MATERIAL NAME: DYMON(R*) OVEN CLEANER - NATURAL CITRUS
SDS US