| Common Name: | MAXXLIFE HT 220 HT MULTIPURPOSE GREASE NLGI 2 |
| Manufacturer: | RENEWABLE LUBRICANTS |
| SDS Revision Date: | 5/15/2015 |
| SDS Format: | GHS-US |
| Item Number(s): | 21A494, 21A495 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
SAFETY DATA SHEET
ISSUE DATE: 15 MAY 2015
REVISION DATE: 15 MAY 2015
VERSION: 1
| SECTION 1. IDENTIFICATION |  |
GHS PRODUCT IDENTIFIER: MAXXLIFE HT 220 HT MULTIPURPOSE GREASE NLGI #2
OTHER MEANS OF IDENTIFICATION: LUBRICATING GREASE.
PRODUCT TYPE: SOLID. LUBRICATING GREASE
PRODUCT CODE: 89001,89002, 89003, 89004, 89005, 89006
RELEVANT IDENTIFIED USES OF THE SUBSTANCE OR MIXTURE AND USES ADVISED
AGAINST:
PRODUCT USE: FOR PROFESSIONAL USE ONLY.
INDUSTRIAL APPLICATIONS: LUBRICANTS; GREASE
SUPPLIER'S DETAILS:
RENEWABLE LUBRICANTS, INC.
476 GRIGGY RD NE
P.O. BOX 474
HARTVILLE, OH 44632
PHONE: (330) 877-9982
FAX: (330) 877-2266
WWW.RENEWABLELUBE.COM
WWW.RENEWABLELUBRICANTS.COM
EMERGENCY TELEPHONE NUMBER:
(CHEMTREC): 1-800-424-9300.
OUTSIDE THE U.S.: (703) 527-3887
| SECTION 2. HAZARDS IDENTIFICATION | |
OSHA/HCS STATUS:
THIS MATERIAL IS NOT HAZARDOUS ACCORDING TO REGULATORY GUIDELINES OSHA
HAZARD COMMUNICATION STANDARD (29 CFR 1910.1200) (SEE SDS SECTION 15).
CLASSIFICATION OF THE SUBSTANCE OR MIXTURE:
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 2A
SKIN SENSITIZATION: CATEGORY 1
GHS LABEL ELEMENTS:
HAZARD PICTOGRAMS: EXCLAMATION MARK
SIGNAL WORD: WARNING
HAZARD STATEMENTS:
CAUSES SERIOUS EYE IRRITATION.
MAY CAUSE AN ALLERGIC SKIN REACTION.
PRECAUTIONARY STATEMENTS:
PREVENTION:
WEAR PROTECTIVE GLOVES. WEAR EYE OR FACE PROTECTION. AVOID BREATHING DUST.
WASH HANDS THOROUGHLY AFTER HANDLING. CONTAMINATED WORK CLOTHING SHOULD NOT
BE ALLOWED OUT OF THE WORKPLACE.
RESPONSE:
IF ON SKIN:
WASH WITH PLENTY OF SOAP AND WATER. WASH CONTAMINATED CLOTHING BEFORE
REUSE.
IF SKIN IRRITATION OR RASH OCCURS: GET MEDICAL ATTENTION.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ATTENTION.
STORAGE: NOT APPLICABLE.
DISPOSAL:
DISPOSE OF CONTENTS AND CONTAINER IN ACCORDANCE WITH ALL LOCAL, REGIONAL,
NATIONAL AND INTERNATIONAL REGULATIONS.
HAZARDS NOT OTHERWISE CLASSIFIED: NONE KNOWN.
| SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
SUBSTANCE/MIXTURE: MIXTURE
OTHER MEANS OF IDENTIFICATION: NOT AVAILABLE.
CAS NUMBER/OTHER IDENTIFIERS:
INGREDIENT NAME % CAS NUMBER
DISTILLATES (PETROLEUM), SOLVENT-DEWAXED 30-60 64742-65-0
HEAVY PARAFFINIC
SULFONIC ACIDS, PETROLEUM, CALCIUM SALTS 7-13 61789-86-4
DIBORON CALCIUM TETRAOXIDE 1-5 13701-64-9
CALCIUM DODECYLBENZENESULPHONATE 1-5 26264-06-2
ANY CONCENTRATION SHOWN AS A RANGE IS TO PROTECT CONFIDENTIALITY OR IS DUE
TO BATCH VARIATION.
THERE ARE NO ADDITIONAL INGREDIENTS PRESENT WHICH, WITHIN THE CURRENT
KNOWLEDGE OF THE SUPPLIER AND IN THE CONCENTRATIONS APPLICABLE, ARE
CLASSIFIED AS HAZARDOUS TO HEALTH OR THE ENVIRONMENT AND HENCE REQUIRE
REPORTING IN THIS SECTION.
OCCUPATIONAL EXPOSURE LIMITS, IF AVAILABLE, ARE LISTED IN SECTION 8.
| SECTION 4. FIRST AID MEASURES | |
DESCRIPTION OF NECESSARY FIRST AID MEASURES:
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER, OCCASIONALLY LIFTING THE UPPER
AND LOWER EYELIDS. CHECK FOR AND REMOVE ANY CONTACT LENSES. CONTINUE TO
RINSE FOR AT LEAST 10 MINUTES. GET MEDICAL ATTENTION.
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. IF NOT BREATHING, IF BREATHING IS IRREGULAR OR IF RESPIRATORY
ARREST OCCURS, PROVIDE ARTIFICIAL RESPIRATION OR OXYGEN BY TRAINED
PERSONNEL. IT MAY BE DANGEROUS TO THE PERSON PROVIDING AID TO GIVE
MOUTH-TO-MOUTH RESUSCITATION. GET MEDICAL ATTENTION IF ADVERSE HEALTH
EFFECTS PERSIST OR ARE SEVERE. IF UNCONSCIOUS, PLACE IN RECOVERY POSITION
AND GET MEDICAL ATTENTION IMMEDIATELY. MAINTAIN AN OPEN AIRWAY. LOOSEN
TIGHT CLOTHING SUCH AS A COLLAR, TIE, BELT OR WAISTBAND.
SKIN CONTACT:
WASH WITH PLENTY OF SOAP AND WATER. REMOVE CONTAMINATED CLOTHING AND SHOES.
WASH CONTAMINATED CLOTHING THOROUGHLY WITH WATER BEFORE REMOVING IT, OR
WEAR GLOVES. CONTINUE TO RINSE FOR AT LEAST 10 MINUTES. GET MEDICAL
ATTENTION. IN THE EVENT OF ANY COMPLAINTS OR SYMPTOMS, AVOID FURTHER
EXPOSURE. WASH CLOTHING BEFORE REUSE. CLEAN SHOES THOROUGHLY BEFORE REUSE.
INGESTION:
WASH OUT MOUTH WITH WATER. REMOVE DENTURES IF ANY. REMOVE VICTIM TO FRESH
AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR BREATHING. IF MATERIAL
HAS BEEN SWALLOWED AND THE EXPOSED PERSON IS CONSCIOUS, GIVE SMALL
QUANTITIES OF WATER TO DRINK. STOP IF THE EXPOSED PERSON FEELS SICK AS
VOMITING MAY BE DANGEROUS. DO NOT INDUCE VOMITING UNLESS DIRECTED TO DO SO
BY MEDICAL PERSONNEL. IF VOMITING OCCURS, THE HEAD SHOULD BE KEPT LOW SO
THAT VOMIT DOES NOT ENTER THE LUNGS. GET MEDICAL ATTENTION IF ADVERSE
HEALTH EFFECTS PERSIST OR ARE SEVERE. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. IF UNCONSCIOUS, PLACE IN RECOVERY POSITION AND GET
MEDICAL ATTENTION IMMEDIATELY. MAINTAIN AN OPEN AIRWAY. LOOSEN TIGHT
CLOTHING SUCH AS A COLLAR, TIE, BELT OR WAISTBAND.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
POTENTIAL ACUTE HEALTH EFFECTS:
EYE CONTACT: CAUSES SERIOUS EYE IRRITATION.
INHALATION: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
SKIN CONTACT: MAY CAUSE AN ALLERGIC SKIN REACTION.
INGESTION: IRRITATING TO MOUTH, THROAT AND STOMACH.
OVER-EXPOSURE SIGNS/SYMPTOMS:
EYE CONTACT:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
PAIN OR IRRITATION
WATERING
REDNESS
INHALATION: NO SPECIFIC DATA.
SKIN CONTACT:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
IRRITATION
REDNESS
INGESTION: NO SPECIFIC DATA.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED,
IF NECESSARY:
NOTES TO PHYSICIAN:
TREAT SYMPTOMATICALLY. CONTACT POISON TREATMENT SPECIALIST IMMEDIATELY IF
LARGE QUANTITIES HAVE BEEN INGESTED OR INHALED.
SPECIFIC TREATMENTS: NO SPECIFIC TREATMENT.
PROTECTION OF FIRST-AIDERS:
NO ACTION SHALL BE TAKEN INVOLVING ANY PERSONAL RISK OR WITHOUT SUITABLE
TRAINING. IT MAY BE DANGEROUS TO THE PERSON PROVIDING AID TO GIVE
MOUTH-TO-MOUTH RESUSCITATION. WASH CONTAMINATED CLOTHING THOROUGHLY WITH
WATER BEFORE REMOVING IT, OR WEAR GLOVES.
SEE TOXICOLOGICAL INFORMATION (SECTION 11)
| SECTION 5. FIRE-FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
SUITABLE EXTINGUISHING MEDIA:
USE AN EXTINGUISHING AGENT SUITABLE FOR THE SURROUNDING FIRE.
UNSUITABLE EXTINGUISHING MEDIA: NONE KNOWN.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
NO SPECIFIC FIRE OR EXPLOSION HAZARD.
HAZARDOUS THERMAL DECOMPOSITION PRODUCTS:
DECOMPOSITION PRODUCTS MAY INCLUDE THE FOLLOWING MATERIALS:
CARBON DIOXIDE
CARBON MONOXIDE
SULFUR OXIDES
METAL OXIDE/OXIDES
SPECIAL PROTECTIVE ACTIONS FOR FIRE-FIGHTERS:
PROMPTLY ISOLATE THE SCENE BY REMOVING ALL PERSONS FROM THE VICINITY OF
THE INCIDENT IF THERE IS A FIRE. NO ACTION SHALL BE TAKEN INVOLVING ANY
PERSONAL RISK OR WITHOUT SUITABLE TRAINING.
SPECIAL PROTECTIVE EQUIPMENT FOR FIRE-FIGHTERS:
FIRE-FIGHTERS SHOULD WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND
SELF-CONTAINED BREATHING APPARATUS (SCBA) WITH A FULL FACE-PIECE OPERATED
IN POSITIVE PRESSURE MODE.
| SECTION 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
FOR NON-EMERGENCY PERSONNEL:
NO ACTION SHALL BE TAKEN INVOLVING ANY PERSONAL RISK OR WITHOUT SUITABLE
TRAINING. EVACUATE SURROUNDING AREAS. KEEP UNNECESSARY AND UNPROTECTED
PERSONNEL FROM ENTERING. DO NOT TOUCH OR WALK THROUGH SPILLED MATERIAL.
PROVIDE ADEQUATE VENTILATION.
FOR EMERGENCY RESPONDERS:
IF SPECIALIZED CLOTHING IS REQUIRED TO DEAL WITH THE SPILLAGE, TAKE NOTE
OF ANY INFORMATION IN SECTION 8 ON SUITABLE AND UNSUITABLE MATERIALS. SEE
ALSO THE INFORMATION IN "FOR NON-EMERGENCY PERSONNEL".
ENVIRONMENTAL PRECAUTIONS:
AVOID DISPERSAL OF SPILLED MATERIAL AND RUNOFF AND CONTACT WITH SOIL,
WATERWAYS, DRAINS AND SEWERS. INFORM THE RELEVANT AUTHORITIES IF THE
PRODUCT HAS CAUSED ENVIRONMENTAL POLLUTION (SEWERS, WATERWAYS, SOIL
OR AIR).
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
SMALL SPILL:
MOVE CONTAINERS FROM SPILL AREA. AVOID DUST GENERATION. USING A VACUUM
WITH HEPA FILTER WILL REDUCE DUST DISPERSAL. PLACE SPILLED MATERIAL IN A
DESIGNATED, LABELED WASTE CONTAINER. DISPOSE OF VIA A LICENSED WASTE
DISPOSAL CONTRACTOR.
LARGE SPILL:
MOVE CONTAINERS FROM SPILL AREA. APPROACH RELEASE FROM UPWIND. PREVENT
ENTRY INTO SEWERS, WATER COURSES, BASEMENTS OR CONFINED AREAS. AVOID DUST
GENERATION. DO NOT DRY SWEEP. VACUUM DUST WITH EQUIPMENT FITTED WITH A HEPA
FILTER AND PLACE IN A CLOSED, LABELED WASTE CONTAINER. DISPOSE OF VIA A
LICENSED WASTE DISPOSAL CONTRACTOR.
NOTE:
SEE SECTION 1 FOR EMERGENCY CONTACT INFORMATION AND SECTION 13 FOR WASTE
DISPOSAL.
| SECTION 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
PROTECTIVE MEASURES:
PUT ON APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT (SEE SECTION 8). PERSONS
WITH A HISTORY OF SKIN SENSITIZATION PROBLEMS SHOULD NOT BE EMPLOYED IN
ANY PROCESS IN WHICH THIS PRODUCT IS USED. DO NOT GET IN EYES OR ON SKIN
OR CLOTHING. DO NOT INGEST. KEEP IN THE ORIGINAL CONTAINER OR AN APPROVED
ALTERNATIVE MADE FROM A COMPATIBLE MATERIAL, KEPT TIGHTLY CLOSED WHEN NOT
IN USE. EMPTY CONTAINERS RETAIN PRODUCT RESIDUE AND CAN BE HAZARDOUS. DO
NOT REUSE CONTAINER.
ADVICE ON GENERAL OCCUPATIONAL HYGIENE:
EATING, DRINKING AND SMOKING SHOULD BE PROHIBITED IN AREAS WHERE THIS
MATERIAL IS HANDLED, STORED AND PROCESSED. WORKERS SHOULD WASH HANDS AND
FACE BEFORE EATING, DRINKING AND SMOKING. REMOVE CONTAMINATED CLOTHING AND
PROTECTIVE EQUIPMENT BEFORE ENTERING EATING AREAS. SEE ALSO SECTION 8 FOR
ADDITIONAL INFORMATION ON HYGIENE MEASURES.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
STORE IN ACCORDANCE WITH LOCAL REGULATIONS. STORE IN ORIGINAL CONTAINER
PROTECTED FROM DIRECT SUNLIGHT IN A DRY, COOL AND WELL-VENTILATED AREA,
AWAY FROM INCOMPATIBLE MATERIALS (SEE SECTION 10) AND FOOD AND DRINK. KEEP
CONTAINER TIGHTLY CLOSED AND SEALED UNTIL READY FOR USE. CONTAINERS THAT
HAVE BEEN OPENED MUST BE CAREFULLY RESEALED AND KEPT UPRIGHT TO PREVENT
LEAKAGE. DO NOT STORE IN UNLABELED CONTAINERS. USE APPROPRIATE CONTAINMENT
TO AVOID ENVIRONMENTAL CONTAMINATION.
| SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
CONTROL PARAMETERS:
OCCUPATIONAL EXPOSURE LIMITS:
INGREDIENT NAME EXPOSURE LIMITS
DISTILLATES (PETROLEUM), ACGIH TLV (UNITED STATES, 6/2013).
SOLVENT-DEWAXED HEAVY PARAFFINIC TWA: 5 MG/M3 8 HOURS.
FORM: INHALABLE FRACTION
NIOSH REL (UNITED STATES, 10/2013).
TWA: 5 MG/M3 10 HOURS.
FORM: MIST
STEL: 10 MG/M3 15 MINUTES.
FORM: MIST
OSHA PEL (UNITED STATES, 2/2013).
TWA: 5 MG/M3 8 HOURS.
APPROPRIATE ENGINEERING CONTROLS:
GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT TO CONTROL WORKER EXPOSURE
TO AIRBORNE CONTAMINANTS.
ENVIRONMENTAL EXPOSURE CONTROLS:
EMISSIONS FROM VENTILATION OR WORK PROCESS EQUIPMENT SHOULD BE CHECKED
TO ENSURE THEY COMPLY WITH THE REQUIREMENTS OF ENVIRONMENTAL PROTECTION
LEGISLATION. IN SOME CASES, FUME SCRUBBERS, FILTERS OR ENGINEERING
MODIFICATIONS TO THE PROCESS EQUIPMENT WILL BE NECESSARY TO REDUCE
EMISSIONS TO ACCEPTABLE LEVELS.
INDIVIDUAL PROTECTION MEASURES:
HYGIENE MEASURES:
WASH HANDS, FOREARMS AND FACE THOROUGHLY AFTER HANDLING CHEMICAL PRODUCTS,
BEFORE EATING, SMOKING AND USING THE LAVATORY AND AT THE END OF THE WORKING
PERIOD. APPROPRIATE TECHNIQUES SHOULD BE USED TO REMOVE POTENTIALLY
CONTAMINATED CLOTHING. CONTAMINATED WORK CLOTHING SHOULD NOT BE ALLOWED OUT
OF THE WORKPLACE. WASH CONTAMINATED CLOTHING BEFORE REUSING. ENSURE THAT
EYEWASH STATIONS AND SAFETY SHOWERS ARE CLOSE TO THE WORKSTATION LOCATION.
EYE/FACE PROTECTION:
SAFETY EYEWEAR COMPLYING WITH AN APPROVED STANDARD SHOULD BE USED WHEN A
RISK ASSESSMENT INDICATES THIS IS NECESSARY TO AVOID EXPOSURE TO LIQUID
SPLASHES, MISTS, GASES OR DUSTS. IF CONTACT IS POSSIBLE, THE FOLLOWING
PROTECTION SHOULD BE WORN, UNLESS THE ASSESSMENT INDICATES A HIGHER DEGREE
OF PROTECTION: CHEMICAL SPLASH GOGGLES.
SKIN PROTECTION:
HAND PROTECTION:
CHEMICAL-RESISTANT, IMPERVIOUS GLOVES COMPLYING WITH AN APPROVED STANDARD
SHOULD BE WORN AT ALL TIMES WHEN HANDLING CHEMICAL PRODUCTS IF A RISK
ASSESSMENT INDICATES THIS IS NECESSARY. CONSIDERING THE PARAMETERS
SPECIFIED BY THE GLOVE MANUFACTURER, CHECK DURING USE THAT THE GLOVES ARE
STILL RETAINING THEIR PROTECTIVE PROPERTIES. IT SHOULD BE NOTED THAT THE
TIME TO BREAKTHROUGH FOR ANY GLOVE MATERIAL MAY BE DIFFERENT FOR DIFFERENT
GLOVE MANUFACTURERS. IN THE CASE OF MIXTURES, CONSISTING OF SEVERAL
SUBSTANCES, THE PROTECTION TIME OF THE GLOVES CANNOT BE ACCURATELY
ESTIMATED.
BODY PROTECTION:
PERSONAL PROTECTIVE EQUIPMENT FOR THE BODY SHOULD BE SELECTED BASED ON THE
TASK BEING PERFORMED AND THE RISKS INVOLVED AND SHOULD BE APPROVED BY A
SPECIALIST BEFORE HANDLING THIS PRODUCT.
OTHER SKIN PROTECTION:
APPROPRIATE FOOTWEAR AND ANY ADDITIONAL SKIN PROTECTION MEASURES SHOULD
BE SELECTED BASED ON THE TASK BEING PERFORMED AND THE RISKS INVOLVED AND
SHOULD BE APPROVED BY A SPECIALIST BEFORE HANDLING THIS PRODUCT.
RESPIRATORY PROTECTION:
USE A PROPERLY FITTED, PARTICULATE FILTER RESPIRATOR COMPLYING WITH AN
APPROVED STANDARD IF A RISK ASSESSMENT INDICATES THIS IS NECESSARY.
RESPIRATOR SELECTION MUST BE BASED ON KNOWN OR ANTICIPATED EXPOSURE LEVELS,
THE HAZARDS OF THE PRODUCT AND THE SAFE WORKING LIMITS OF THE SELECTED
RESPIRATOR.
| SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: SOLID. [GREASE]
COLOR: TAN.
ODOR: MILD. PETROLEUM OIL
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT APPLICABLE.
MELTING POINT: NOT AVAILABLE.
BOILING POINT: NOT AVAILABLE.
FLASH POINT: NOT AVAILABLE.
EVAPORATION RATE: NOT AVAILABLE.
FLAMMABILITY (SOLID, GAS):
FLAMMABLE IN THE PRESENCE OF THE FOLLOWING MATERIALS OR CONDITIONS:
OPEN FLAMES, SPARKS AND STATIC DISCHARGE AND HEAT.
LOWER AND UPPER EXPLOSIVE (FLAMMABLE) LIMITS: NOT AVAILABLE.
VAPOR PRESSURE: NOT AVAILABLE.
VAPOR DENSITY: NOT AVAILABLE.
RELATIVE DENSITY: 0.96 G/CM3
SOLUBILITY:
INSOLUBLE IN THE FOLLOWING MATERIALS: COLD WATER.
PARTITION COEFFICIENT N-OCTANOL/WATER: NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
VISCOSITY:
KINEMATIC (40 DEG. C (104 DEG. F)): >0.21 CM2/S (>21 CST)
| SECTION 10. STABILITY AND REACTIVITY | |
REACTIVITY:
NO SPECIFIC TEST DATA RELATED TO REACTIVITY AVAILABLE FOR THIS PRODUCT OR
ITS INGREDIENTS.
CHEMICAL STABILITY: THE PRODUCT IS STABLE.
POSSIBILITY OF HAZARDOUS REACTIONS:
UNDER NORMAL CONDITIONS OF STORAGE AND USE, HAZARDOUS REACTIONS WILL NOT
OCCUR.
CONDITIONS TO AVOID: NO SPECIFIC DATA.
INCOMPATIBLE MATERIALS: NO SPECIFIC DATA.
HAZARDOUS DECOMPOSITION PRODUCTS:
UNDER NORMAL CONDITIONS OF STORAGE AND USE, HAZARDOUS DECOMPOSITION
PRODUCTS SHOULD NOT BE PRODUCED.
| SECTION 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY:
PRODUCT/INGREDIENT NAME RESULT SPECIES DOSE EXPOSURE
DISTILLATES (PETROLEUM), LD50 DERMAL RABBIT >5000 MG/KG
SOLVENT-DEWAXED HEAVY LD50 ORAL RAT >5000 MG/KG
PARAFFINIC
SULFONIC ACIDS, PETROLEUM, LD50 DERMAL RABBIT >5 G/KG
CALCIUM SALTS LD50 ORAL RAT >5 G/KG
CALCIUM LD50 ORAL RAT 1300 MG/KG
DODECYLBENZENESULPHONATE
CONCLUSION/SUMMARY: MAY BE HARMFUL IF SWALLOWED.
IRRITATION/CORROSION:
CONCLUSION/SUMMARY:
SKIN: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
EYES: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
RESPIRATORY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
SENSITIZATION:
CONCLUSION/SUMMARY:
SKIN:
NO SPECIFIC INFORMATION IS AVAILABLE IN OUR DATABASE REGARDING THE SKIN
SENSITIZING PROPERTIES OF THIS PRODUCT. SENSITIZATION NOT SUSPECTED FOR
HUMANS.
RESPIRATORY: SENSITIZATION NOT SUSPECTED FOR HUMANS.
MUTAGENICITY:
CONCLUSION/SUMMARY:
THERE ARE NO DATA AVAILABLE ON THE MIXTURE ITSELF. MUTAGENICITY NOT
SUSPECTED FOR HUMANS.
CARCINOGENICITY:
CONCLUSION/SUMMARY:
THERE ARE NO DATA AVAILABLE ON THE MIXTURE ITSELF. CARCINOGENICITY NOT
SUSPECTED FOR HUMANS.
REPRODUCTIVE TOXICITY:
CONCLUSION/SUMMARY:
THERE ARE NO DATA AVAILABLE ON THE MIXTURE ITSELF. NOT CONSIDERED TO BE
DANGEROUS TO HUMANS, ACCORDING TO OUR DATABASE.
CONCLUSION/SUMMARY:
THERE ARE NO DATA AVAILABLE ON THE MIXTURE ITSELF. TERATOGENICITY NOT
SUSPECTED FOR HUMANS.
SPECIFIC TARGET ORGAN TOXICITY (SINGLE EXPOSURE): NOT AVAILABLE.
SPECIFIC TARGET ORGAN TOXICITY (REPEATED EXPOSURE): NOT AVAILABLE.
ASPIRATION HAZARD:
NAME RESULT
DISTILLATES (PETROLEUM), SOLVENT-DEWAXED ASPIRATION HAZARD - CATEGORY 1
HEAVYPARAFFINIC
INFORMATION ON THE LIKELY ROUTES OF EXPOSURE:
ROUTES OF ENTRY ANTICIPATED: ORAL, DERMAL, INHALATION.
POTENTIAL ACUTE HEALTH EFFECTS:
EYE CONTACT: CAUSES SERIOUS EYE IRRITATION.
INHALATION: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
SKIN CONTACT: MAY CAUSE AN ALLERGIC SKIN REACTION.
INGESTION: IRRITATING TO MOUTH, THROAT AND STOMACH.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
EYE CONTACT:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
PAIN OR IRRITATION
WATERING
REDNESS
INHALATION: NO SPECIFIC DATA.
SKIN CONTACT:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
IRRITATION
REDNESS
INGESTION: NO SPECIFIC DATA.
DELAYED AND IMMEDIATE EFFECTS AND ALSO CHRONIC EFFECTS FROM SHORT AND
LONG TERM EXPOSURE:
SHORT TERM EXPOSURE:
POTENTIAL IMMEDIATE EFFECTS: NOT AVAILABLE.
POTENTIAL DELAYED EFFECTS: NOT AVAILABLE.
LONG TERM EXPOSURE:
POTENTIAL IMMEDIATE EFFECTS: NOT AVAILABLE.
POTENTIAL DELAYED EFFECTS: NOT AVAILABLE.
POTENTIAL CHRONIC HEALTH EFFECTS:
CONCLUSION/SUMMARY:
CONTAINS MATERIAL THAT MAY CAUSE TARGET ORGAN DAMAGE, BASED ON ANIMAL DATA.
GENERAL:
ONCE SENSITIZED, A SEVERE ALLERGIC REACTION MAY OCCUR WHEN SUBSEQUENTLY
EXPOSED TO VERY LOW LEVELS.
CARCINOGENICITY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
MUTAGENICITY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
TERATOGENICITY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
DEVELOPMENTAL EFFECTS: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
FERTILITY EFFECTS: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
NUMERICAL MEASURES OF TOXICITY:
ACUTE TOXICITY ESTIMATES:
ROUTE ATE VALUE
ORAL 65000 MG/KG
| SECTION 12. ECOLOGICAL INFORMATION | |
TOXICITY:
CONCLUSION/SUMMARY: THERE ARE NO DATA AVAILABLE ON THE MIXTURE ITSELF.
PERSISTENCE AND DEGRADABILITY:
CONCLUSION/SUMMARY:
NOT READILY BIODEGRADABLE. THIS PRODUCT IS NOT EXPECTED TO BIOACCUMULATE
THROUGH FOOD CHAINS IN THE ENVIRONMENT.
PRODUCT/INGREDIENT NAME AQUATIC HALF-LIFE PHOTOLYSIS BIODEGRADABILITY
MAXXLIFE HT 220 HT NOT READILY
MULTIPURPOSE GREASE
NLGI #2
BIOACCUMULATIVE POTENTIAL: NOT AVAILABLE.
MOBILITY IN SOIL:
SOIL/WATER PARTITION COEFFICIENT (KOC): NOT AVAILABLE.
OTHER ADVERSE EFFECTS: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
| SECTION 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL METHODS:
THE GENERATION OF WASTE SHOULD BE AVOIDED OR MINIMIZED WHEREVER POSSIBLE.
DISPOSAL OF THIS PRODUCT, SOLUTIONS AND ANY BY-PRODUCTS SHOULD AT ALL TIMES
COMPLY WITH THE REQUIREMENTS OF ENVIRONMENTAL PROTECTION AND WASTE DISPOSAL
LEGISLATION AND ANY REGIONAL LOCAL AUTHORITY REQUIREMENTS. DISPOSE OF
SURPLUS AND NON-RECYCLABLE PRODUCTS VIA A LICENSED WASTE DISPOSAL
CONTRACTOR. WASTE SHOULD NOT BE DISPOSED OF UNTREATED TO THE SEWER UNLESS
FULLY COMPLIANT WITH THE REQUIREMENTS OF ALL AUTHORITIES WITH JURISDICTION.
WASTE PACKAGING SHOULD BE RECYCLED. INCINERATION OR LANDFILL SHOULD ONLY BE
CONSIDERED WHEN RECYCLING IS NOT FEASIBLE. THIS MATERIAL AND ITS CONTAINER
MUST BE DISPOSED OF IN A SAFE WAY. CARE SHOULD BE TAKEN WHEN HANDLING
EMPTIED CONTAINERS THAT HAVE NOT BEEN CLEANED OR RINSED OUT. EMPTY
CONTAINERS OR LINERS MAY RETAIN SOME PRODUCT RESIDUES. AVOID DISPERSAL OF
SPILLED MATERIAL AND RUNOFF AND CONTACT WITH SOIL, WATERWAYS, DRAINS AND
SEWERS.
| SECTION 14. TRANSPORT INFORMATION | |
DOT TDG MEXICO
CLASSIFICATION CLASSIFICATION CLASSIFICATION
UN NUMBER NOT REGULATED. NOT REGULATED. NOT REGULATED.
UN PROPER SHIPPING NAME
TRANSPORT HAZARD
CLASS(ES)
PACKING GROUP
ENVIRONMENTAL HAZARDS NO. NO. NO.
ADDITIONAL INFORMATION
ADR/RID IMDG IATA
UN NUMBER NOT REGULATED. NOT REGULATED. NOT REGULATED.
UN PROPER SHIPPING NAME
TRANSPORT HAZARD CLASS(ES)
PACKING GROUP
ENVIRONMENTAL HAZARDS NO. NO. NO.
ADDITIONAL INFORMATION
SPECIAL PRECAUTIONS FOR USER:
TRANSPORT WITHIN USER'S PREMISES:
ALWAYS TRANSPORT IN CLOSED CONTAINERS THAT ARE UPRIGHT AND SECURE. ENSURE
THAT PERSONS TRANSPORTING THE PRODUCT KNOW WHAT TO DO IN THE EVENT OF AN
ACCIDENT OR SPILLAGE.
TRANSPORT IN BULK ACCORDING TO ANNEX II OF MARPOL 73/78 AND THE IBC CODE:
NOT AVAILABLE.
| SECTION 15. REGULATORY INFORMATION | |
U.S. FEDERAL REGULATIONS:
TSCA 8(A) CDR EXEMPT/PARTIAL EXEMPTION: NOT DETERMINED
UNITED STATES INVENTORY (TSCA 8B): ALL COMPONENTS ARE LISTED OR EXEMPTED.
CLEAN WATER ACT (CWA) 311: CALCIUM DODECYLBENZENESULPHONATE
CLEAN AIR ACT SECTION 112 (B) HAZARDOUS AIR POLLUTANTS (HAPS): NOT LISTED
CLEAN AIR ACT SECTION 602 CLASS I SUBSTANCES: NOT LISTED
CLEAN AIR ACT SECTION 602 CLASS II SUBSTANCES: NOT LISTED
DEA LIST I CHEMICALS (PRECURSOR CHEMICALS): NOT LISTED
DEA LIST II CHEMICALS (ESSENTIAL CHEMICALS): NOT LISTED
SARA 302/304:
COMPOSITION/INFORMATION ON INGREDIENTS: NO PRODUCTS WERE FOUND.
SARA 304 RQ: NOT APPLICABLE.
SARA 311/312:
CLASSIFICATION: IMMEDIATE (ACUTE) HEALTH HAZARD
COMPOSITION/INFORMATION ON INGREDIENTS:
NAME % FIRE SUDDEN REACTIVE IMMEDIATE DELAYED
HAZARD RELEASE OF (ACUTE) (CHRONIC)
PRESSURE HEALTH HEALTH
HAZARD HAZARD
SULFONIC ACIDS, 7-13 NO. NO. NO. YES. NO.
PETROLEUM,
CALCIUM SALTS
DIBORON CALCIUM 1-5 NO. NO. NO. YES. NO.
TETRAOXIDE
CALCIUM 1-5 NO. NO. NO. YES. NO.
DODECYLBENZENE-
SULPHONATE
SARA 313:
PRODUCT NAME CAS NUMBER %
FORM R - REPORTING REQUIREMENTS:
NO LISTED SUBSTANCE
SUPPLIER NOTIFICATION:
NO LISTED SUBSTANCE
SARA 313 NOTIFICATIONS MUST NOT BE DETACHED FROM THE SDS AND ANY COPYING
AND REDISTRIBUTION OF THE SDS SHALL INCLUDE COPYING AND REDISTRIBUTION OF
THE NOTICE ATTACHED TO COPIES OF THE SDS SUBSEQUENTLY REDISTRIBUTED.
STATE REGULATIONS:
CONNECTICUT CARCINOGEN REPORTING: NONE OF THE COMPONENTS ARE LISTED.
CONNECTICUT HAZARDOUS MATERIAL SURVEY: NONE OF THE COMPONENTS ARE LISTED.
FLORIDA SUBSTANCES: NONE OF THE COMPONENTS ARE LISTED.
ILLINOIS CHEMICAL SAFETY ACT: NONE OF THE COMPONENTS ARE LISTED.
ILLINOIS TOXIC SUBSTANCES DISCLOSURE TO EMPLOYEE ACT:
NONE OF THE COMPONENTS ARE LISTED.
LOUISIANA REPORTING: NONE OF THE COMPONENTS ARE LISTED.
LOUISIANA SPILL: NONE OF THE COMPONENTS ARE LISTED.
MASSACHUSETTS SPILL: NONE OF THE COMPONENTS ARE LISTED.
MASSACHUSETTS SUBSTANCES:
THE FOLLOWING COMPONENTS ARE LISTED: CALCIUM DODECYLBENZENE SULFONATE
MICHIGAN CRITICAL MATERIAL: NONE OF THE COMPONENTS ARE LISTED.
MINNESOTA HAZARDOUS SUBSTANCES: NONE OF THE COMPONENTS ARE LISTED.
NEW JERSEY SPILL: NONE OF THE COMPONENTS ARE LISTED.
NEW JERSEY TOXIC CATASTROPHE PREVENTION ACT:
NONE OF THE COMPONENTS ARE LISTED.
NEW JERSEY HAZARDOUS SUBSTANCES:
THE FOLLOWING COMPONENTS ARE LISTED:
CALCIUM DODECYLBENZENE SULFONATE; BENZENESULFONIC ACID, DODECYL-, CALCIUM
SALT
NEW YORK ACUTELY HAZARDOUS SUBSTANCES:
THE FOLLOWING COMPONENTS ARE LISTED: CALCIUM DODECYLBENZENE SULFONATE
NEW YORK TOXIC CHEMICAL RELEASE REPORTING:
NONE OF THE COMPONENTS ARE LISTED.
PENNSYLVANIA RTK HAZARDOUS SUBSTANCES:
THE FOLLOWING COMPONENTS ARE LISTED:
BENZENESULFONIC ACID, DODECYL-, CALCIUM SALT
RHODE ISLAND HAZARDOUS SUBSTANCES: NONE OF THE COMPONENTS ARE LISTED.
CALIFORNIA PROP. 65: NONE OF THE COMPONENTS ARE LISTED.
INTERNATIONAL REGULATIONS
CHEMICAL WEAPON CONVENTION LIST SCHEDULES I, II & III CHEMICALS:
NOT LISTED.
MONTREAL PROTOCOL (ANNEXES A, B, C, E): NOT LISTED.
INTERNATIONAL LISTS:
NATIONAL INVENTORY:
AUSTRALIA: ALL COMPONENTS ARE LISTED OR EXEMPTED.
CHINA: ALL COMPONENTS ARE LISTED OR EXEMPTED.
EUROPE: ALL COMPONENTS ARE LISTED OR EXEMPTED.
JAPAN: NOT DETERMINED.
MALAYSIA: NOT DETERMINED.
NEW ZEALAND: ALL COMPONENTS ARE LISTED OR EXEMPTED.
PHILIPPINES: NOT DETERMINED.
REPUBLIC OF KOREA: ALL COMPONENTS ARE LISTED OR EXEMPTED.
TAIWAN: NOT DETERMINED.
CANADA:
WHMIS (CANADA):
CLASS D-2B: MATERIAL CAUSING OTHER TOXIC EFFECTS (TOXIC).
CANADIAN LISTS:
CANADIAN NPRI: NONE OF THE COMPONENTS ARE LISTED.
CEPA TOXIC SUBSTANCES: NONE OF THE COMPONENTS ARE LISTED.
CANADA INVENTORY; DSL/NDSL: ALL COMPONENTS ARE LISTED OR EXEMPTED.
THIS PRODUCT HAS BEEN CLASSIFIED IN ACCORDANCE WITH THE HAZARD CRITERIA
OF THE CONTROLLED PRODUCTS REGULATIONS AND THE MSDS CONTAINS ALL THE
INFORMATION REQUIRED BY THE CONTROLLED PRODUCTS REGULATIONS.
| SECTION 16. OTHER INFORMATION | |
HAZARDOUS MATERIAL INFORMATION SYSTEM (U.S.A.):
HEALTH 1*
FLAMMABILITY 1
PHYSICAL HAZARDS 0
ALTHOUGH HMIS(R*) RATINGS ARE NOT REQUIRED ON SDSS UNDER 29 CFR 1910.1200,
THE PREPARER MAY CHOOSE TO PROVIDE THEM.
THE CUSTOMER IS RESPONSIBLE FOR DETERMINING THE PPE CODE FOR THIS MATERIAL.
NATIONAL FIRE PROTECTION ASSOCIATION (U.S.A.):
HEALTH 1
FLAMMABILITY 1
INSTABILITY/REACTIVITY 0
SPECIAL
THIS WARNING SYSTEM IS INTENDED TO BE INTERPRETED AND APPLIED ONLY BY
PROPERLY TRAINED INDIVIDUALS TO IDENTIFY FIRE, HEALTH AND REACTIVITY
HAZARDS OF CHEMICALS. THE USER IS REFERRED TO CERTAIN LIMITED NUMBER OF
CHEMICALS WITH RECOMMENDED CLASSIFICATIONS IN NFPA 49 AND NFPA 325, WHICH
WOULD BE USED AS A GUIDELINE ONLY. WHETHER THE CHEMICALS ARE CLASSIFIED BY
NFPA OR NOT, ANYONE USING THE 704 SYSTEMS TO CLASSIFY CHEMICALS DOES SO AT
THEIR OWN RISK.
HISTORY:
REVISION:
DATE REVISED SECTION
15 MAY 2015 NEW
THE INFORMATION PRESENTED HEREIN HAS BEEN COMPILED FROM SOURCES CONSIDERED
TO BE DEPENDABLE AND IS ACCURATE TO THE BEST OF RENEWABLE LUBRICANTS, INC.
KNOWLEDGE; HOWEVER, RENEWABLE LUBRICANTS, INC. MAKES NO WARRANTY
WHATSOEVER, EXPRESSED OR IMPLIED, OF MERCHANTABILITY OF FITNESS FOR THE
PARTICULAR PURPOSE, REGARDING THE ACCURACY OF SUCH DATA OR THE RESULTS TO
BE OBTAINED FROM THE USE THEREOF. RENEWABLE LUBRICANTS INC. ASSUMES NO
RESPONSIBILITY FOR INJURY TO RECIPIENT OR TO THIRD PERSONS OR FOR ANY
DAMAGE TO ANY PROPERTY AND RECIPIENT ASSUMES ALL SUCH RISKS.
MATERIAL NAME: MAXXLIFE HT 220 HT MULTIPURPOSE GREASE NLGI #2