| Common Name: | SILICONE PLUS PREMIUM KITCHEN & BATH SEALANT ALMOND |
| Manufacturer: | DAP |
| SDS Revision Date: | 7/28/2015 |
| SDS Format: | GHS-US |
| Item Number(s): | 29RV07 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
SDS NUMBER: 00008785004
REVISION DATE: 7/28/2015
DAP(R*)
SAFETY DATA SHEET
24 HOUR EMERGENCY PHONE NUMBERS:
MEDICAL/POISON CONTROL:
IN U.S.:
CALL: 1-800-222-1222
OUTSIDE U.S.: CALL YOUR LOCAL POISON CONTROL CENTER
TRANSPORTATION/NATIONAL RESPONSE CENTER:
1-800-535-5053
1-352-323-3500
NOTE:
THE NATIONAL RESPONSE CENTER EMERGENCY NUMBERS TO BE USED ONLY IN THE EVENT
OF CHEMICAL EMERGENCIES INVOLVING A SPILL, LEAK, FIRE, EXPOSURE OR ACCIDENT
INVOLVING CHEMICALS.
IMPORTANT:
PROVIDE THIS INFORMATION TO EMPLOYEES, CUSTOMERS, AND USERS OF THIS
PRODUCT. READ THIS SDS BEFORE HANDLING OR DISPOSING OF THIS PRODUCT. THIS
PRODUCT IS COVERED BY THE OSHA HAZARD COMMUNICATION STANDARD AND THIS
DOCUMENT HAS BEEN PREPARED IN ACCORDANCE WITH REQUIREMENTS OF THIS
STANDARD. ALL ABBREVIATED TERMS USED IN THIS MSDS ARE FURTHER DESCRIBED
IN SECTION 16.
| 1. IDENTIFICATION |  |
THIS SAFETY DATA SHEET IS AVAILABLE IN AMERICAN SPANISH UPON REQUEST.
PRODUCT NAME: SILICONE PLUS PREMIUM KITCHEN & BATH SEALANT ALMOND
PRODUCT UPC NUMBER: 070798087859
PRODUCT USE/CLASS: CAULKING COMPOUND
REVISION DATE: 7/28/2015
SUPERCEDES DATE: NEW SDS
SDS NO: 00008785004
MANUFACTURER:
DAP PRODUCTS INC.
2400 BOSTON STREET
SUITE 200
BALTIMORE, MD 21224-4723
888-327-8477 (NON - EMERGENCY MATTERS)
PREPARER: REGULATORY DEPARTMENT
| 2. HAZARDS IDENTIFICATION | |
EMERGENCY OVERVIEW:
HIGH CONCENTRATION OF VAPORS MAY CAUSE IRRITATION TO EYES AND RESPIRATORY
SYSTEM.
GHS CLASSIFICATION: EYE IRRIT. 2, SKIN SENS. 1, STOT RE 2
SYMBOL(S) OF PRODUCT:
EXCLAMATION MARK
HEALTH HAZARD
SIGNAL WORD: WARNING
GHS HAZARD STATEMENTS:
SKIN SENSITIZER, CATEGORY 1:
H317: MAY CAUSE AN ALLERGIC SKIN REACTION.
EYE IRRITATION, CATEGORY 2:
H319: CAUSES SERIOUS EYE IRRITATION.
STOT, REPEATED EXPOSURE, CATEGORY 2:
H373: MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
GHS LABEL PRECAUTIONARY STATEMENTS:
P261: AVOID BREATHING DUST/FUME/GAS/MIST/VAPOURS/SPRAY.
P280:
WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION.
P302+P352:
IF ON SKIN: WASH WITH PLENTY OF SOAP AND WATER.
P333+P313:
IF SKIN IRRITATION OR RASH OCCURS: GET MEDICAL ADVICE/ATTENTION.
GHS SDS PRECAUTIONARY STATEMENTS:
P363: WASH CONTAMINATED CLOTHING BEFORE REUSE.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
CHEMICAL NAME CAS-NO. WT. % GHS SYMBOLS GHS STATEMENTS
SILICA, AMORPHOUS 7631-86-9 2.5-10 GHS03-GHS07 H270-332
METHYLTRI 22984-54-9 2.5-10 GHS03-GHS07- H270-317-
(ETHYLMETHYL- GHS08 319-373
KETOXIME)SILANE
TITANIUM DIOXIDE 13463-67-7 0.1-1.0 NO INFORMATION NO INFORMATION
CARBON BLACK 1333-86-4 0.1-1.0 NO INFORMATION NO INFORMATION
THE TEXT FOR GHS HAZARD STATEMENTS SHOWN ABOVE (IF ANY) IS GIVEN IN THE
"OTHER INFORMATION" SECTION.
| 4. FIRST-AID MEASURES | |
FIRST AID - INHALATION:
MATERIAL IS NOT LIKELY TO PRESENT AN INHALATION HAZARD AT AMBIENT
CONDITIONS. IF YOU EXPERIENCE DIFFICULTY IN BREATHING, LEAVE THE AREA TO
OBTAIN FRESH AIR. IF CONTINUED DIFFICULTY IS EXPERIENCED, GET MEDICAL
ATTENTION IMMEDIATELY.
FIRST AID - SKIN CONTACT:
WASH SKIN WITH SOAP AND WATER FOR 15 MINUTES. GET MEDICAL AID IF SYMPTOMS
PERSIST.
FIRST AID - EYE CONTACT:
IN CASE OF CONTACT, IMMEDIATELY FLUSH EYES WITH LARGE QUANTITIES OF WATER
FOR AT LEAST 15 MINUTES UNTIL IRRITATION SUBSIDES. GET MEDICAL ATTENTION
IMMEDIATELY.
FIRST AID - INGESTION:
IF SWALLOWED, DO NOT INDUCE VOMITING. GET MEDICAL ATTENTION IMMEDIATELY.
| 5. FIRE-FIGHTING MEASURES | |
UNUSUAL FIRE AND EXPLOSION HAZARDS: 465 <UNDEFINED>
SPECIAL FIREFIGHTING PROCEDURES:
WEAR SELF-CONTAINED BREATHING APPARATUS PRESSURE-DEMAND (NIOSH APPROVED
OR EQUIVALENT) AND FULL PROTECTIVE GEAR. USE WATER SPRAY TO COOL EXPOSED
SURFACES.
EXTINGUISHING MEDIA: CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG
| 6. ACCIDENTAL RELEASE MEASURES | |
ENVIRONMENTAL MEASURES: NO INFORMATION
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED:
CONTAIN SPILLED MATERIAL AND REMOVE WITH INERT ABSORBENT. DISPOSE OF
CONTAMINATED ABSORBENT, CONTAINER AND UNUSED CONTENTS IN ACCORDANCE WITH
LOCAL, STATE AND FEDERAL REGULATIONS. SCRAPE UP DRIED MATERIAL AND PLACE
INTO CONTAINERS. USE PERSONAL PROTECTIVE EQUIPMENT AS NECESSARY. IN CASE
OF SPILLAGE, ABSORB WITH INERT MATERIAL AND DISPOSE OF IN ACCORDANCE WITH
APPLICABLE REGULATIONS.
| 7. HANDLING AND STORAGE | |
HANDLING:
KEEP OUT OF REACH OF CHILDREN!
DO NOT TAKE INTERNALLY. AVOID BREATHING VAPOR AND CONTACT WITH EYES, SKIN
AND CLOTHING. USE ONLY WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER
HANDLING. REMOVE CONTACT LENSES BEFORE USING. DO NOT HANDLE CONTACT LENSES
UNTIL ALL SEALANT HAS BEEN CLEANED FROM FINGERTIPS, NAILS AND CUTICLES.
RESIDUAL SEALANT MAY TRANSFER TO CONTACT LENSES AND CAUSE SEVERE EYE
IRRITATION.
STORAGE:
AVOID EXCESSIVE HEAT AND FREEZING. DO NOT STORE AT TEMPERATURES ABOVE
120 DEGREES F. STORE AWAY FROM CAUSTICS AND OXIDIZERS.
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
INGREDIENTS WITH OCCUPATIONAL EXPOSURE LIMITS:
CHEMICAL NAME ACGIH ACGIH-TLV OSHA OSHA
TLV-TWA STEL PEL-TWA PEL-CEILING
SILICA, AMORPHOUS N.E. N.E. N.E. N.E.
METHYLTRI N.E. N.E. N.E. N.E.
(ETHYLMETHYLKETOXIME)
SILANE
TITANIUM DIOXIDE 10 MG/M3 N.E. 15 MG/M3 N.E.
TWA TWA
TOTAL DUST
CARBON BLACK 3 MG/M3 N.E. 3.5 MG/M3 N.E.
TWA TWA
INHALABLE
FRACTION
FURTHER ADVICE:
MEL = MAXIMUM EXPOSURE LIMIT
OES = OCCUPATIONAL EXPOSURE STANDARD
SUP = SUPPLIER'S RECOMMENDATION
SK = SKIN SENSITIZER
N.E. = NOT ESTABLISHED
PERSONAL PROTECTION:
RESPIRATORY PROTECTION:
NO PERSONAL RESPIRATORY PROTECTIVE EQUIPMENT NORMALLY REQUIRED.
SKIN PROTECTION: WEAR NITRILE OR NEOPRENE GLOVES.
EYE PROTECTION: GOGGLES OR SAFETY GLASSES WITH SIDE SHIELDS.
OTHER PROTECTIVE EQUIPMENT: NOT REQUIRED UNDER NORMAL USE.
HYGIENIC PRACTICES:
WASH HANDS BEFORE BREAKS AND AT THE END OF WORKDAY. REMOVE AND WASH
CONTAMINATED CLOTHING BEFORE RE-USE.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: ALMOND
PHYSICAL STATE: PASTE
ODOR: SLIGHT
ODOR THRESHOLD: NOT ESTABLISHED
DENSITY, G/CM3: 1.04 - 1.04
PH: NOT ESTABLISHED
FREEZE POINT, DEG. C: NOT ESTABLISHED
VISCOSITY (MPA.S): NOT ESTABLISHED
SOLUBILITY IN WATER: NOT ESTABLISHED
PARTITION COEFF., N-OCTANOL/WATER: NOT ESTABLISHED
DECOMPOSITION TEMPERATURE, DEG. C: NOT ESTABLISHED
EXPLOSIVE LIMITS, %: N.I. - N.I.
BOILING RANGE, DEG. C: N.I. - N.I.
AUTO-IGNITION TEMPERATURE, DEG. C: NOT ESTABLISHED
MINIMUM FLASH POINT, DEG. C: 93.3
VAPOR PRESSURE, MMHg: NO INFORMATION
EVAPORATION RATE: SLOWER THAN N-BUTYL ACETATE
FLASH METHOD: SETA CLOSED CUP
VAPOR DENSITY: HEAVIER THAN AIR
FLAMMABILITY: NO INFORMATION
COMBUSTIBILITY: DOES NOT SUPPORT COMBUSTION
(SEE "OTHER INFORMATION" SECTION FOR ABBREVIATION LEGEND)
(IF PRODUCT IS AN AEROSOL, THE FLASH POINT STATED ABOVE IS THAT OF THE
PROPELLANT.)
| 10. STABILITY AND REACTIVITY | |
STABILITY:
THIS PRODUCT IS CONSIDERED STABLE UNDER NORMAL AND ANTICIPATED STORAGE AND
HANDLING CONDITIONS.
CONDITIONS TO AVOID: OXIDIZING AGENTS. EXCESSIVE HEAT AND FREEZING.
INCOMPATIBILITY:
KEEP AWAY FROM STRONG OXIDIZING AGENTS. INCOMPATIBLE WITH STRONG BASES AND
OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS:
NORMAL DECOMPOSITION PRODUCTS, I.E., COX, NOX.
| 11. TOXICOLOGICAL INFORMATION | |
EFFECT OF OVEREXPOSURE - INHALATION:
DURING APPLICATION AND CURE, THIS PRODUCT RELEASES METHANOL. INHALATION MAY
CAUSE IRRITATION TO THE RESPIRATORY TRACT (NOSE, MOUTH, MUCOUS MEMBRANES).
MAY CAUSE ALLERGIC RESPIRATORY REACTION.
EFFECT OF OVEREXPOSURE - SKIN CONTACT:
DIRECT SKIN CONTACT MAY CAUSE IRRITATION. MAY CAUSE ALLERGIC SKIN REACTION.
EFFECT OF OVEREXPOSURE - EYE CONTACT: MAY CAUSE MILD EYE IRRITATION.
EFFECT OF OVEREXPOSURE - INGESTION:
SINGLE DOSE ORAL TOXICITY IS VERY LOW. AMOUNTS INGESTED INCIDENTAL TO
INDUSTRIAL HANDLING ARE NOT LIKELY TO CAUSE INJURY; HOWEVER, INGESTION OF
LARGE AMOUNTS MAY CAUSE INJURY. INGESTION OF LARGE AMOUNTS MAY CAUSE
NAUSEA, GASTROINTESTINAL UPSET, AND PAIN. MAY CAUSE LIVER AND KIDNEY
DAMAGE, AND CENTRAL NERVOUS SYSTEM DEPRESSION. INGESTION MAY RESULT IN
OBSTRUCTION WHEN MATERIAL HARDENS.
CARCINOGENICITY: NO INFORMATION
EFFECT OF OVEREXPOSURE - CHRONIC HAZARDS:
REPEATED OR PROLONGED EXPOSURE MAY CAUSE IRRITATION OF EYES AND SKIN.
REPEATED OR PROLONGED SKIN CONTACT MAY CAUSE ALLERGIC REACTIONS WITH
SUSCEPTIBLE PERSONS.
PRIMARY ROUTE(S) OF ENTRY: EYE CONTACT, INHALATION, SKIN CONTACT
ACUTE TOXICITY VALUES:
THE ACUTE EFFECTS OF THIS PRODUCT HAVE NOT BEEN TESTED. DATA ON INDIVIDUAL
COMPONENTS ARE TABULATED BELOW:
CAS-NO. CHEMICAL NAME ORAL LD50 DERMAL LD50 VAPOR LC50
7631-86-9 SILICA, AMORPHOUS >3300 MG/KG >5000 MG/KG >20 MG/L
RAT RABBIT
22984-54-9 METHYLTRI >2520 MG/KG >2000 MG/KG >50 MG/L
(ETHYLMETHYLKETOXIME) RAT RAT RAT
SILANE
13463-67-7 TITANIUM DIOXIDE >10000 MG/KG >5000 MG/KG >20 MG/L
RAT RABBIT
1333-86-4 CARBON BLACK >8000 MG/KG >3000 MG/KG N.I.
RAT RABBIT
N.I. = NO INFORMATION
| 12. ECOLOGICAL INFORMATION | |
ECOLOGICAL INFORMATION:
ECOLOGICAL INJURIES ARE NOT KNOWN OR EXPECTED UNDER NORMAL USE.
| 13. DISPOSAL INFORMATION | |
DISPOSAL INFORMATION:
THIS PRODUCT DOES NOT MEET THE DEFINITION OF A HAZARDOUS WASTE ACCORDING
TO U.S. EPA HAZARDOUS WASTE MANAGEMENT REGULATION, 40 CFR SECTION 261.
DISPOSE AS HAZARDOUS WASTE ACCORDING TO ALL LOCAL, STATE, FEDERAL AND
PROVINCIAL REGULATIONS. STATE AND LOCAL REGULATIONS/RESTRICTIONS ARE
COMPLEX AND MAY DIFFER FROM FEDERAL REGULATIONS. RESPONSIBILITY FOR PROPER
WASTE DISPOSAL IS WITH THE OWNER OF THE WASTE. DO NOT FLUSH INTO SURFACE
WATER OR SANITARY SEWER SYSTEM.
| 14. TRANSPORT INFORMATION | |
SPECIAL TRANSPORT PRECAUTIONS: NO INFORMATION
DOT UN/NA NUMBER: N.A.
DOT PROPER SHIPPING NAME: NOT REGULATED.
DOT TECHNICAL NAME: N.A.
DOT HAZARD CLASS: N.A.
HAZARD SUBCLASS: N.A.
PACKING GROUP: N.A.
| 15. REGULATORY INFORMATION | |
U.S. FEDERAL REGULATIONS:
CERCLA - SARA HAZARD CATEGORY:
THIS PRODUCT HAS BEEN REVIEWED ACCORDING TO THE EPA 'HAZARD CATEGORIES'
PROMULGATED UNDER SECTIONS 311 AND 312 OF THE SUPERFUND AMENDMENT AND
REAUTHORIZATION ACT OF 1986 (SARA TITLE III) AND IS CONSIDERED, UNDER
APPLICABLE DEFINITIONS, TO MEET THE FOLLOWING CATEGORIES:
ACUTE HEALTH HAZARD, CHRONIC HEALTH HAZARD
SARA SECTION 313:
THIS PRODUCT CONTAINS THE FOLLOWING SUBSTANCES SUBJECT TO THE REPORTING
REQUIREMENTS OF SECTION 313 OF TITLE III OF THE SUPERFUND AMENDMENT AND
REAUTHORIZATION ACT OF 1986 AND 40 CFR PART 372:
NO SARA 313 COMPONENTS EXIST IN THIS PRODUCT.
TOXIC SUBSTANCES CONTROL ACT:
ALL INGREDIENTS IN THIS PRODUCT ARE EITHER ON TSCA INVENTORY LIST, OR
OTHERWISE EXEMPT.
THIS PRODUCT CONTAINS THE FOLLOWING CHEMICAL SUBSTANCES SUBJECT TO THE
REPORTING REQUIREMENTS OF TSCA 12(B) IF EXPORTED FROM THE UNITED STATES:
NO TSCA 12(B) COMPONENTS EXIST IN THIS PRODUCT.
CALIFORNIA PROPOSITION 65 CARCINOGENS AND REPRODUCTIVE TOXINS:
CALIFORNIA PROPOSITION 65:
WARNING:
THIS PRODUCT CONTAINS CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER, BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
INTERNATIONAL REGULATIONS: AS FOLLOWS
CANADIAN WHMIS:
THIS SDS HAS BEEN PREPARED IN COMPLIANCE WITH CONTROLLED PRODUCT
REGULATIONS EXCEPT FOR THE USE OF THE 16 HEADINGS.
WHMIS CLASS: CONSUMER COMMODITY
| 16. OTHER INFORMATION | |
REVISION DATE: 7/28/2015
SUPERSEDES DATE: NEW MSDS
REASON FOR REVISION: HAZCOM2012/GHS CONVERSION
DATASHEET PRODUCED BY: REGULATORY DEPARTMENT
HMIS RATINGS:
HEALTH 2*
FLAMMABILITY 1
REACTIVITY 0
PERSONAL PROTECTION X
VOC LESS WATER LESS EXEMPT SOLVENT, G/L: 30.0
VOC MATERIAL, G/L: 30
VOC AS DEFINED BY CALIFORNIA CONSUMER PRODUCT REGULATION, WT/WT%: 2.9
TEXT FOR GHS HAZARD STATEMENTS SHOWN IN SECTION 3 DESCRIBING EACH
INGREDIENT:
H270: MAY CAUSE OR INTENSIFY FIRE; OXIDISER.
H317: MAY CAUSE AN ALLERGIC SKIN REACTION.
H319: CAUSES SERIOUS EYE IRRITATION.
H332: HARMFUL IF INHALED.
H373: MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
ICONS FOR GHS PICTOGRAMS SHOWN IN SECTION 3 DESCRIBING EACH INGREDIENT:
GHS03: FLAME OVER CIRCLE
GHS07: EXCLAMATION MARK
GHS08: HEALTH HAZARD
LEGEND:
N.A. - NOT APPLICABLE
N.E. - NOT ESTABLISHED
N.D. - NOT DETERMINED
DAP BELIEVES THE DATA AND STATEMENTS CONTAINED HEREIN ARE ACCURATE AS OF
THE DATE HEREOF. THEY ARE OFFERED IN GOOD FAITH AS TYPICAL VALUES AND NOT
AS A PRODUCT SPECIFICATION. NO WARRANTY OF MERCHANTABILITY, WARRANTY OF
FITNESS FOR ANY PARTICULAR PURPOSE OR ANY OTHER WARRANTY, EXPRESS OR
IMPLIED, IS MADE WITH REGARD TO THE INFORMATION HEREIN PROVIDED OR THE
PRODUCT TO WHICH THE INFORMATION REFERS. SINCE THIS DOCUMENT IS INTENDED
ONLY AS A GUIDE TO THE APPROPRIATE USE AND PRECAUTIONARY HANDLING OF THE
REFERENCED PRODUCT BY A PROPERLY TRAINED PERSON, IT IS THEREFORE THE
RESPONSIBILITY OF THE USER TO (I) REVIEW THE RECOMMENDATIONS WITH DUE
CONSIDERATION FOR THE SPECIFIC CONTEXT OF THE INTENDED USE AND (II)
DETERMINE IF THEY ARE APPROPRIATE.