| Common Name: | 14D THREAD SEALANT WITH PTFE 16 FL.OZ., 80633 |
| Manufacturer: | ITW PERMATEX |
| SDS Revision Date: | 4/24/2015 |
| SDS Format: | GHS-US |
| Item Number(s): | 2GXY8 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
PERMATEX(R*)
SAFETY DATA SHEET
REVISION DATE: 24-APR-2015
VERSION: 1
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFIER:
PRODUCT NAME: 14D THREAD SEALANT WITH PTFE 16 FL.OZ.
OTHER MEANS OF IDENTIFICATION:
PRODUCT CODE: 80633
SYNONYMS: NONE
RECOMMENDED USE OF THE CHEMICAL AND RESTRICTIONS ON USE:
RECOMMENDED USE: SEALANT
USES ADVISED AGAINST: NO INFORMATION AVAILABLE
DETAILS OF THE SUPPLIER OF THE SAFETY DATA SHEET:
MANUFACTURER ADDRESS:
ITW PERMATEX
10 COLUMBUS BLVD.
HARTFORD, CT 06106
USA
DISTRIBUTOR:
ITW PERMATEX CANADA
35 BROWNRIDGE ROAD, UNIT 1
HALTON HILLS, ON L7G 0C6
CANADA
TELEPHONE: (800) 924-6994
COMPANY PHONE NUMBER:
1-87-PERMATEX
(877) 376-2839
24 HOUR EMERGENCY PHONE NUMBER:
CHEM-TEL: 800-255-3924
INTERNATIONAL EMERGENCY: 00+1+ 813-248-0585
CONTRACT NUMBER: MIS0003453
E-MAIL ADDRESS: MAIL@PERMATEX.COM
| 2. HAZARDS IDENTIFICATION | |
CLASSIFICATION:
OSHA REGULATORY STATUS:
THIS CHEMICAL IS CONSIDERED HAZARDOUS BY THE 2012 OSHA HAZARD COMMUNICATION
STANDARD (29 CFR 1910.1200)
ACUTE TOXICITY - ORAL: CATEGORY 4
CARCINOGENICITY: CATEGORY 2
SPECIFIC TARGET ORGAN TOXICITY (SINGLE EXPOSURE): CATEGORY 1
FLAMMABLE LIQUIDS: CATEGORY 3
LABEL ELEMENTS:
EMERGENCY OVERVIEW:
DANGER:
HARMFUL IF SWALLOWED
MAY CAUSE CANCER
CAUSES DAMAGE TO ORGANS
FLAMMABLE LIQUID
EXCLAMATION MARK
HEALTH HAZARD
FLAME
APPEARANCE: WHITE
PHYSICAL STATE: PASTE
ODOR: ALCOHOLIC
PRECAUTIONARY STATEMENTS - PREVENTION:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE
DO NOT HANDLE UNTIL ALL SAFETY PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD
USE PERSONAL PROTECTIVE EQUIPMENT AS REQUIRED
WASH FACE, HANDS AND ANY EXPOSED SKIN THOROUGHLY AFTER HANDLING
DO NOT EAT, DRINK OR SMOKE WHEN USING THIS PRODUCT
DO NOT BREATHE DUST/FUME/GAS/MIST/VAPORS/SPRAY
KEEP AWAY FROM HEAT/SPARKS/OPEN FLAMES/HOT SURFACES. - NO SMOKING
KEEP CONTAINER TIGHTLY CLOSED
TAKE PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGE
PRECAUTIONARY STATEMENTS - RESPONSE:
IF EXPOSED: CALL A POISON CENTER OR DOCTOR/PHYSICIAN
SPECIFIC TREATMENT (SEE SUPPLEMENTAL FIRST AID INSTRUCTIONS ON THIS LABEL)
IF ON SKIN (OR HAIR):
REMOVE/TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. RINSE SKIN WITH
WATER/SHOWER
IF SWALLOWED: CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL
RINSE MOUTH
IN CASE OF FIRE: USE WATER SPRAY, FOG OR REGULAR FOAM FOR EXTINCTION
PRECAUTIONARY STATEMENTS - STORAGE: STORE LOCKED UP
PRECAUTIONARY STATEMENTS - DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER TO AN APPROVED WASTE DISPOSAL PLANT
HAZARDS NOT OTHERWISE CLASSIFIED (HNOC): NOT APPLICABLE
OTHER INFORMATION: HARMFUL TO AQUATIC LIFE WITH LONG LASTING EFFECTS.
UNKNOWN ACUTE TOXICITY:
65.99515% OF THE MIXTURE CONSISTS OF INGREDIENT(S) OF UNKNOWN TOXICITY
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
SUBSTANCE(S):
CHEMICAL NAME CAS NO WEIGHT-% TRADE SECRET
TALC 14807-96-6 15 - 40 *
ETHANOL 64-17-5 10 - 30 *
CASTOR OIL 8001-79-4 10 - 30 *
POLYVINYL RESIN 63148-65-2 5 - 10 *
2-PROPANOL 67-63-0 1 - 5 *
TITANIUM DIOXIDE 13463-67-7 1 - 5 *
METHANOL 67-56-1 1 - 5 *
POLYTETRAFLUOROETHYLENE 9002-84-0 1 - 5 *
*THE EXACT PERCENTAGE (CONCENTRATION) OF COMPOSITION HAS BEEN WITHHELD AS A
TRADE SECRET.
| 4. FIRST AID MEASURES | |
DESCRIPTION OF FIRST AID MEASURES:
GENERAL ADVICE: GET MEDICAL ADVICE/ATTENTION IF YOU FEEL UNWELL.
EYE CONTACT:
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
SKIN CONTACT:
IF ON SKIN (OR HAIR):
REMOVE/TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. RINSE SKIN WITH
WATER/SHOWER. WASH WITH SOAP AND WATER. IF SYMPTOMS PERSIST, CALL A
PHYSICIAN.
INHALATION:
IF INHALED:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. IF SYMPTOMS PERSIST, CALL A PHYSICIAN.
INGESTION:
IF SWALLOWED:
DO NOT INDUCE VOMITING. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON. CALL A PHYSICIAN.
SELF-PROTECTION OF THE FIRST AIDER:
USE PERSONAL PROTECTIVE EQUIPMENT AS REQUIRED. AVOID CONTACT WITH SKIN,
EYES OR CLOTHING.
MOST IMPORTANT SYMPTOMS AND EFFECTS, BOTH ACUTE AND DELAYED:
SYMPTOMS: SEE SECTION 2 FOR MORE INFORMATION.
INDICATION OF ANY IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
NOTE TO PHYSICIANS: TREAT SYMPTOMATICALLY.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA: CARBON DIOXIDE (CO2), DRY CHEMICAL, FOAM
UNSUITABLE EXTINGUISHING MEDIA: NONE.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
FLAMMABLE. KEEP PRODUCT AND EMPTY CONTAINER AWAY FROM HEAT AND SOURCES OF
IGNITION.
EXPLOSION DATA:
SENSITIVITY TO MECHANICAL IMPACT: NONE.
SENSITIVITY TO STATIC DISCHARGE: NONE.
PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
AS IN ANY FIRE, WEAR SELF-CONTAINED BREATHING APPARATUS PRESSURE-DEMAND,
MSHA/NIOSH (APPROVED OR EQUIVALENT) AND FULL PROTECTIVE GEAR.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
PERSONAL PRECAUTIONS:
REMOVE ALL SOURCES OF IGNITION. USE PERSONAL PROTECTIVE EQUIPMENT AS
REQUIRED. ENSURE ADEQUATE VENTILATION, ESPECIALLY IN CONFINED AREAS. AVOID
CONTACT WITH SKIN, EYES OR CLOTHING. WASH THOROUGHLY AFTER HANDLING.
ENVIRONMENTAL PRECAUTIONS:
ENVIRONMENTAL PRECAUTIONS:
DO NOT FLUSH INTO SURFACE WATER OR SANITARY SEWER SYSTEM. SEE SECTION 12
FOR ADDITIONAL ECOLOGICAL INFORMATION.
METHODS AND MATERIAL FOR CONTAINMENT AND CLEANING UP:
METHODS FOR CONTAINMENT:
PREVENT FURTHER LEAKAGE OR SPILLAGE IF SAFE TO DO SO.
METHODS FOR CLEANING UP:
ELIMINATE ALL IGNITION SOURCES IF SAFE TO DO SO. ENSURE ADEQUATE
VENTILATION. SOAK UP WITH INERT ABSORBENT MATERIAL. SWEEP UP AND SHOVEL
INTO SUITABLE CONTAINERS FOR DISPOSAL.
PREVENTION OF SECONDARY HAZARDS:
CLEAN CONTAMINATED OBJECTS AND AREAS THOROUGHLY OBSERVING ENVIRONMENTAL
REGULATIONS.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
ADVICE ON SAFE HANDLING:
HANDLE IN ACCORDANCE WITH GOOD INDUSTRIAL HYGIENE AND SAFETY PRACTICE.
AVOID BREATHING VAPORS OR MISTS. AVOID CONTACT WITH SKIN, EYES OR CLOTHING.
WASH THOROUGHLY AFTER HANDLING. WASH CONTAMINATED CLOTHING BEFORE REUSE.
USE PERSONAL PROTECTIVE EQUIPMENT AS REQUIRED. KEEP AWAY FROM
HEAT/SPARKS/OPEN FLAMES/HOT SURFACES. - NO SMOKING.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
STORAGE CONDITIONS:
KEEP AWAY FROM HEAT, SPARKS, FLAME AND OTHER SOURCES OF IGNITION (I.E.,
PILOT LIGHTS, ELECTRIC MOTORS AND STATIC ELECTRICITY). STORE LOCKED UP.
INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
CONTROL PARAMETERS:
EXPOSURE GUIDELINES:
CHEMICAL NAME ACGIH TLV OSHA PEL NIOSH IDLH
TALC TWA: (VACATED) TWA: IDLH: 1000 MG/M3
14807-96-6 2 MG/M3 2 MG/M3 RESPIRABLE DUST
PARTICULATE <1% CRYSTALLINE SILICA, TWA:
MATTER CONTAINING NO ASBESTOS 2 MG/M3
CONTAINING CONTAINING NO
NO ASBESTOS TWA: ASBESTOS AND <1%
AND <1% 20 MPPCF IF 1% QUARTZ QUARTZ
CRYSTALLINE OR MORE, USE QUARTZ RESPIRABLE DUST
SILICA, LIMIT
RESPIRABLE
FRACTION
ETHANOL STEL: TWA: 1000 PPM IDLH: 3300 PPM
64-17-5 1000 PPM TWA: 1900 MG/M3 TWA: 1000 PPM
(VACATED) TWA: 1000 PPM TWA: 1900 MG/M3
(VACATED) TWA: 1900 MG/M3
2-PROPANOL STEL: 400 PPM TWA: 400 PPM IDLH: 2000 PPM
67-63-0 TWA: 200 PPM TWA: 980 MG/M3 TWA: 400 PPM
(VACATED) TWA: 400 PPM TWA: 980 MG/M3
(VACATED) TWA: 980 MG/M3 STEL: 500 PPM
(VACATED) STEL: 500 PPM STEL: 1225 MG/M3
(VACATED) STEL:
1225 MG/M3
TITANIUM TWA: 10 MG/M3 TWA: 15 MG/M3 TOTAL DUST IDLH: 5000 MG/M3
DIOXIDE
13463-67-7 (VACATED) TWA:
10 MG/M3 TOTAL DUST
METHANOL STEL: 250 PPM TWA: 200 PPM IDLH: 6000 PPM
67-56-1 TWA: 200 PPM TWA: 260 MG/M3 TWA: 200 PPM
S* (VACATED) TWA: 200 PPM TWA: 260 MG/M3
(VACATED) TWA: 260 MG/M3 STEL: 250 PPM
(VACATED) STEL: 250 PPM STEL: 325 MG/M3
(VACATED) STEL: 325 MG/M3
(VACATED) S*
NIOSH IDLH: IMMEDIATELY DANGEROUS TO LIFE OR HEALTH
OTHER INFORMATION:
VACATED LIMITS REVOKED BY THE COURT OF APPEALS DECISION IN AFL-CIO V. OSHA,
965 F.2D 962 (11TH CIR., 1992).
APPROPRIATE ENGINEERING CONTROLS:
ENGINEERING CONTROLS:
SHOWERS
EYEWASH STATIONS
VENTILATION SYSTEMS
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION: WEAR SAFETY GLASSES WITH SIDE SHIELDS (OR GOGGLES).
SKIN AND BODY PROTECTION: WEAR PROTECTIVE GLOVES AND PROTECTIVE CLOTHING.
RESPIRATORY PROTECTION:
USE NIOSH-APPROVED AIR-PURIFYING RESPIRATOR WITH ORGANIC VAPOR CARTRIDGE OR
CANISTER, AS APPROPRIATE.
GENERAL HYGIENE CONSIDERATIONS:
HANDLE IN ACCORDANCE WITH GOOD INDUSTRIAL HYGIENE AND SAFETY PRACTICE.
REGULAR CLEANING OF EQUIPMENT, WORK AREA AND CLOTHING IS RECOMMENDED.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
INFORMATION ON BASIC PHYSICAL AND CHEMICAL PROPERTIES:
PHYSICAL STATE: PASTE
APPEARANCE: WHITE
ODOR: ALCOHOLIC
ODOR THRESHOLD: NO INFORMATION AVAILABLE
PROPERTY VALUES REMARKS - METHOD
PH NO INFORMATION AVAILABLE
MELTING POINT / FREEZING POINT NO INFORMATION AVAILABLE
BOILING POINT / BOILING RANGE 82 DEG. C / 180 DEG. F
FLASH POINT 23 DEG. C / 74 DEG. F TAG CLOSED CUP
EVAPORATION RATE <1 BUTYL
ACETATE = 1
FLAMMABILITY (SOLID, GAS) NO INFORMATION AVAILABLE
FLAMMABILITY LIMIT IN AIR:
UPPER FLAMMABILITY LIMIT 12.7%
LOWER FLAMMABILITY LIMIT 2.3%
VAPOR PRESSURE 33 MMHg @ 68 DEG. F
VAPOR DENSITY >1 AIR = 1
RELATIVE DENSITY 1.06-1.10
WATER SOLUBILITY PARTIALLY SOLUBLE
SOLUBILITY IN OTHER SOLVENTS NO INFORMATION AVAILABLE
PARTITION COEFFICIENT NO INFORMATION AVAILABLE
AUTOIGNITION TEMPERATURE NO INFORMATION AVAILABLE
DECOMPOSITION TEMPERATURE NO INFORMATION AVAILABLE
KINEMATIC VISCOSITY NO INFORMATION AVAILABLE
DYNAMIC VISCOSITY NO INFORMATION AVAILABLE
EXPLOSIVE PROPERTIES NO INFORMATION AVAILABLE
OXIDIZING PROPERTIES NO INFORMATION AVAILABLE
OTHER INFORMATION:
SOFTENING POINT NO INFORMATION AVAILABLE
MOLECULAR WEIGHT NO INFORMATION AVAILABLE
VOC CONTENT (%) 36.7%
DENSITY NO INFORMATION AVAILABLE
BULK DENSITY NO INFORMATION AVAILABLE
| 10. STABILITY AND REACTIVITY | |
REACTIVITY: NO DATA AVAILABLE
CHEMICAL STABILITY: STABLE UNDER RECOMMENDED STORAGE CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS: NONE UNDER NORMAL PROCESSING.
CONDITIONS TO AVOID: HEAT, FLAMES AND SPARKS.
INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS
HAZARDOUS DECOMPOSITION PRODUCTS: CARBON OXIDES FLUORIDES
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INHALATION: HARMFUL BY INHALATION.
EYE CONTACT:
CONTACT WITH EYES MAY CAUSE IRRITATION. MAY CAUSE REDNESS AND TEARING OF
THE EYES.
SKIN CONTACT: MAY CAUSE SKIN IRRITATION AND/OR DERMATITIS.
INGESTION: MAY BE HARMFUL IF SWALLOWED.
CHEMICAL NAME ORAL LD50 DERMAL LD50 INHALATION LC50
ETHANOL =7060 MG/KG (RAT) =124.7 MG/L (RAT)
64-17-5 4 H
2-PROPANOL =1870 MG/KG (RAT) =4059 MG/KG =72600 MG/M3 (RAT)
67-63-0 (RABBIT) 4 H
TITANIUM >10000 MG/KG
DIOXIDE (RAT)
13463-67-7
METHANOL =6200 MG/KG (RAT) =15800 MG/KG =22500 PPM (RAT)
67-56-1 (RABBIT) 8 H
=64000 PPM (RAT)
4 H
INFORMATION ON TOXICOLOGICAL EFFECTS:
SYMPTOMS: NO INFORMATION AVAILABLE.
DELAYED AND IMMEDIATE EFFECTS AS WELL AS CHRONIC EFFECTS FROM SHORT AND
LONG-TERM EXPOSURE:
SENSITIZATION: NO INFORMATION AVAILABLE.
GERM CELL MUTAGENICITY: NO INFORMATION AVAILABLE.
CARCINOGENICITY:
THE TABLE BELOW INDICATES WHETHER EACH AGENCY HAS LISTED ANY INGREDIENT AS
A CARCINOGEN.
CHEMICAL NAME ACGIH IARC NTP OSHA
TALC GROUP 3
14807-96-6
ETHANOL A3 GROUP 1 KNOWN X
64-17-5
2-PROPANOL GROUP 1 X
67-63-0
TITANIUM DIOXIDE GROUP 2B X
13463-67-7
POLYTETRA- GROUP 3
FLUOROETHYLENE
9002-84-0
ACGIH (AMERICAN CONFERENCE OF GOVERNMENTAL INDUSTRIAL HYGIENISTS):
A3 - ANIMAL CARCINOGEN
IARC (INTERNATIONAL AGENCY FOR RESEARCH ON CANCER):
GROUP 1 - CARCINOGENIC TO HUMANS
GROUP 2B - POSSIBLY CARCINOGENIC TO HUMANS
NOT CLASSIFIABLE AS A HUMAN CARCINOGEN
NTP (NATIONAL TOXICOLOGY PROGRAM):
KNOWN - KNOWN CARCINOGEN
OSHA (OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION OF THE US DEPARTMENT OF
LABOR):
X - PRESENT
CHRONIC TOXICITY:
MAY CAUSE ADVERSE EFFECTS ON THE BONE MARROW AND BLOOD-FORMING SYSTEM. MAY
CAUSE ADVERSE LIVER EFFECTS. CONTAINS A KNOWN OR SUSPECTED REPRODUCTIVE
TOXIN.
TARGET ORGAN EFFECTS:
BLOOD, CENTRAL NERVOUS SYSTEM, CENTRAL VASCULAR SYSTEM (CVS), EYES,
GASTROINTESTINAL TRACT (GI), LIVER, LUNGS, REPRODUCTIVE SYSTEM, RESPIRATORY
SYSTEM, SKIN.
THE FOLLOWING VALUES ARE CALCULATED BASED ON CHAPTER 3.1 OF THE GHS
DOCUMENT:
ATEMIX (ORAL): 1811 MG/KG
ATEMIX (DERMAL): 6521 MG/KG
ATEMIX (INHALATION-DUST/MIST): 11.7 MG/L
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY:
35.44605% OF THE MIXTURE CONSISTS OF COMPONENTS(S) OF UNKNOWN HAZARDS TO
THE AQUATIC ENVIRONMENT
CHEMICAL NAME ALGAE/AQUATIC FISH CRUSTACEA
PLANTS
TALC 100:
14807-96-6 96 H BRACHYDANIO
RERIO G/L LC50
SEMI-STATIC
ETHANOL 12.0 - 16.0: 9268 - 14221:
64-17-5 96 H ONCORHYNCHUS 48 H DAPHNIA
MYKISS ML/L LC50 MAGNA MG/L LC50
STATIC
2:
100: 48 H DAPHNIA
96 H PIMEPHALES MAGNA MG/L EC50
PROMELAS MG/L LC50 STATIC
STATIC
10800:
13400 - 15100: 24 H DAPHNIA
96 H PIMEPHALES MAGNA MG/L EC50
PROMELAS MG/L LC50
FLOW-THROUGH
2-PROPANOL 1000: 11130: 13299:
67-63-0 96 H DESMODESMUS 96 H PIMEPHALES 48 H DAPHNIA
SUBSPICATUS MG/L PROMELAS MG/L LC50 MAGNA MG/L EC50
EC50 STATIC
1000: 9640:
72 H DESMODESMUS 96 H PIMEPHALES
SUBSPICATUS MG/L PROMELAS MG/L LC50
EC50 FLOW-THROUGH
1400000:
96 H LEPOMIS
MACROCHIRUS
(MICRO)G/L LC50
METHANOL 28200:
67-56-1 96 H PIMEPHALES
PROMELAS MG/L LC50
FLOW-THROUGH
100:
96 H PIMEPHALES
PROMELAS MG/L LC50
STATIC
19500 - 20700:
96 H ONCORHYNCHUS
MYKISS MG/L LC50
FLOW-THROUGH
13500 - 17600:
96 H LEPOMIS
MACROCHIRUS MG/L
LC50 FLOW-THROUGH
18 - 20:
96 H ONCORHYNCHUS
MYKISS ML/L LC50
STATIC
PERSISTENCE AND DEGRADABILITY: NO INFORMATION AVAILABLE.
BIOACCUMULATION: NO INFORMATION AVAILABLE.
MOBILITY: NO INFORMATION AVAILABLE.
CHEMICAL NAME PARTITION COEFFICIENT
ETHANOL -0.32
64-17-5
2-PROPANOL 0.05
67-63-0
METHANOL -0.77
67-56-1
OTHER ADVERSE EFFECTS: NO INFORMATION AVAILABLE
| 13. DISPOSAL CONSIDERATIONS | |
WASTE TREATMENT METHODS:
DISPOSAL OF WASTES:
THIS MATERIAL, AS SUPPLIED, IS A HAZARDOUS WASTE ACCORDING TO FEDERAL
REGULATIONS (40 CFR 261).
CONTAMINATED PACKAGING: DO NOT REUSE CONTAINER.
US EPA WASTE NUMBER: D001
CHEMICAL NAME RCRA RCRA - BASIS RCRA - D RCRA - U
FOR LISTING SERIES WASTES SERIES WASTES
METHANOL INCLUDED IN U154
67-56-1 WASTE STREAM:
F039
THIS PRODUCT CONTAINS ONE OR MORE SUBSTANCES THAT ARE LISTED WITH THE STATE
OF CALIFORNIA AS A HAZARDOUS WASTE.
CHEMICAL NAME CALIFORNIA HAZARDOUS WASTE STATUS
ETHANOL TOXIC
64-17-5 IGNITABLE
2-PROPANOL TOXIC
67-63-0 IGNITABLE
METHANOL TOXIC
67-56-1 IGNITABLE
| 14. TRANSPORT INFORMATION | |
DOT:
UN/ID NO: 1133
PROPER SHIPPING NAME: ADHESIVES, LIMITED QUANTITY (LQ)
HAZARD CLASS: 3
PACKING GROUP: III
EMERGENCY RESPONSE GUIDE NUMBER: 128
IATA:
UN/ID NO: ID 8000
PROPER SHIPPING NAME: CONSUMER COMMODITY
HAZARD CLASS: 9
ERG CODE: 9L
IMDG:
UN/ID NO: 1133
PROPER SHIPPING NAME: ADHESIVES, LIMITED QUANTITY (LQ)
HAZARD CLASS: 3
PACKING GROUP: III
EMS-NO: F-E, S-D
| 15. REGULATORY INFORMATION | |
INTERNATIONAL INVENTORIES:
TSCA: COMPLIES
DSL/NDSL: COMPLIES
EINECS/ELINCS: NOT LISTED.
ENCS: NOT LISTED.
IECSC: COMPLIES
KECL: COMPLIES
PICCS: COMPLIES
AICS: COMPLIES
LEGEND:
TSCA: UNITED STATES TOXIC SUBSTANCES CONTROL ACT SECTION 8(B) INVENTORY
DSL/NDSL: CANADIAN DOMESTIC SUBSTANCES LIST/NON-DOMESTIC SUBSTANCES LIST
EINECS/ELINCS:
EUROPEAN INVENTORY OF EXISTING CHEMICAL SUBSTANCES/EUROPEAN LIST OF
NOTIFIED CHEMICAL SUBSTANCES
ENCS: JAPAN EXISTING AND NEW CHEMICAL SUBSTANCES
IECSC: CHINA INVENTORY OF EXISTING CHEMICAL SUBSTANCES
KECL: KOREAN EXISTING AND EVALUATED CHEMICAL SUBSTANCES
PICCS: PHILIPPINES INVENTORY OF CHEMICALS AND CHEMICAL SUBSTANCES
AICS: AUSTRALIAN INVENTORY OF CHEMICAL SUBSTANCES
US FEDERAL REGULATIONS:
SARA 313:
SECTION 313 OF TITLE III OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION
ACT OF 1986 (SARA). THIS PRODUCT CONTAINS A CHEMICAL OR CHEMICALS WHICH
ARE SUBJECT TO THE REPORTING REQUIREMENTS OF THE ACT AND TITLE 40 OF THE
CODE OF FEDERAL REGULATIONS, PART 372
CHEMICAL NAME SARA 313 - THRESHOLD VALUES %
2-PROPANOL - 67-63-0 1.0
METHANOL - 67-56-1 1.0
SARA 311/312 HAZARD CATEGORIES:
ACUTE HEALTH HAZARD: YES
CHRONIC HEALTH HAZARD: NO
FIRE HAZARD: YES
SUDDEN RELEASE OF PRESSURE HAZARD: NO
REACTIVE HAZARD: NO
CWA (CLEAN WATER ACT):
THIS PRODUCT DOES NOT CONTAIN ANY SUBSTANCES REGULATED AS POLLUTANTS
PURSUANT TO THE CLEAN WATER ACT (40 CFR 122.21 AND 40 CFR 122.42)
CERCLA:
THIS MATERIAL, AS SUPPLIED, CONTAINS ONE OR MORE SUBSTANCES REGULATED AS A
HAZARDOUS SUBSTANCE UNDER THE COMPREHENSIVE ENVIRONMENTAL RESPONSE
COMPENSATION AND LIABILITY ACT (CERCLA) (40 CFR 302)
CHEMICAL NAME HAZARDOUS SUBSTANCES CERCLA/SARA REPORTABLE QUANTITY
RQS RQ (RQ)
METHANOL 5000 LB RQ: 5000 LB FINAL RQ
67-56-1 RQ: 2270 KG FINAL RQ
US STATE REGULATIONS:
CALIFORNIA PROPOSITION 65:
THIS PRODUCT CONTAINS THE FOLLOWING PROPOSITION 65 CHEMICALS
CHEMICAL NAME CALIFORNIA PROPOSITION 65
ETHANOL - 64-17-5 CARCINOGEN
DEVELOPMENTAL
TITANIUM DIOXIDE - 13463-67-7 CARCINOGEN
METHANOL - 67-56-1 DEVELOPMENTAL
METHYL ISOBUTYL KETONE - 108-10-1 CARCINOGEN
DEVELOPMENTAL
U.S. STATE RIGHT-TO-KNOW REGULATIONS:
CHEMICAL NAME NEW JERSEY MASSACHUSETTS PENNSYLVANIA
TALC X X X
14807-96-6
ETHANOL X X X
64-17-5
2-PROPANOL X X X
67-63-0
TITANIUM DIOXIDE X X X
13463-67-7
WATER X
7732-18-5
METHANOL X X X
67-56-1
POLYTETRAFLUOROETHYLENE X
9002-84-0
METHYL ISOBUTYL KETONE X X X
108-10-1
U.S. EPA LABEL INFORMATION:
EPA PESTICIDE REGISTRATION NUMBER: NOT APPLICABLE
| 16. OTHER INFORMATION, INCLUDING DATE OF PREPARATION | |
OF THE LAST REVISION
NFPA:
HEALTH HAZARDS 2
FLAMMABILITY 3
INSTABILITY 0
HMIS:
HEALTH HAZARDS 2
FLAMMABILITY 3
PHYSICAL HAZARDS 0
PERSONAL PROTECTION B
NFPA (NATIONAL FIRE PROTECTION ASSOCIATION)
HMIS (HAZARDOUS MATERIAL INFORMATION SYSTEM)
REVISION DATE: 24-APR-2015
DISCLAIMER:
THE INFORMATION PROVIDED IN THIS MATERIAL SAFETY DATA SHEET IS CORRECT TO
THE BEST OF OUR KNOWLEDGE, INFORMATION AND BELIEF AT THE DATE OF ITS
PUBLICATION. THE INFORMATION GIVEN IS DESIGNED ONLY AS A GUIDANCE FOR SAFE
HANDLING, USE, PROCESSING, STORAGE, TRANSPORTATION, DISPOSAL AND RELEASE
AND IS NOT TO BE CONSIDERED A WARRANTY OR QUALITY SPECIFICATION. THE
INFORMATION RELATES ONLY TO THE SPECIFIC MATERIAL DESIGNATED AND MAY NOT BE
VALID FOR SUCH MATERIAL USED IN COMBINATION WITH ANY OTHER MATERIALS OR IN
ANY PROCESS, UNLESS SPECIFIED IN THE TEXT.