| Common Name: | HIGH HEAT MORTAR |
| Manufacturer: | DAP |
| SDS Revision Date: | 6/19/2015 |
| SDS Format: | GHS-US |
| Item Number(s): | 2KVH9 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
SDS NUMBER: 00077370004
REVISION DATE: 6/19/2015
DAP(R*)
SAFETY DATA SHEET
24 HOUR EMERGENCY PHONE NUMBERS:
MEDICAL/POISON CONTROL:
IN U.S.:
CALL: 1-800-222-1222
OUTSIDE U.S.: CALL YOUR LOCAL POISON CONTROL CENTER
TRANSPORTATION/NATIONAL RESPONSE CENTER:
1-800-535-5053
1-352-323-3500
NOTE:
THE NATIONAL RESPONSE CENTER EMERGENCY NUMBERS TO BE USED ONLY IN THE EVENT
OF CHEMICAL EMERGENCIES INVOLVING A SPILL, LEAK, FIRE, EXPOSURE OR ACCIDENT
INVOLVING CHEMICALS.
IMPORTANT:
PROVIDE THIS INFORMATION TO EMPLOYEES, CUSTOMERS, AND USERS OF THIS
PRODUCT. READ THIS SDS BEFORE HANDLING OR DISPOSING OF THIS PRODUCT.
THIS PRODUCT IS COVERED BY THE OSHA HAZARD COMMUNICATION STANDARD AND
THIS DOCUMENT HAS BEEN PREPARED IN ACCORDANCE WITH REQUIREMENTS OF THIS
STANDARD. ALL ABBREVIATED TERMS USED IN THIS MSDS ARE FURTHER DESCRIBED
IN SECTION 16.
| 1. IDENTIFICATION |  |
THIS MATERIAL SAFETY DATA SHEET IS AVAILABLE IN AMERICAN SPANISH UPON
REQUEST.
PRODUCT NAME: HIGH HEAT MORTAR
PRODUCT UPC NUMBER: 18854
PRODUCT USE/CLASS: CAULKING COMPOUND
MANUFACTURER:
DAP PRODUCTS INC.
2400 BOSTON STREET
SUITE 200
BALTIMORE, MD 21224-4723
888-327-8477 (NON - EMERGENCY MATTERS)
PREPARER: REGULATORY DEPARTMENT
REVISION DATE: 6/19/2015
SUPERCEDES DATE: 3/14/2013
SDS NO: 00077370004
| 2. HAZARDS IDENTIFICATION | |
EMERGENCY OVERVIEW:
UNDER NORMAL USE CONDITIONS, THIS PRODUCT IS NOT EXPECTED TO CAUSE ADVERSE
HEALTH EFFECTS.
GHS CLASSIFICATION: ACUTE TOX. 4 INHALATION, EYE IRRIT. 2, SKIN IRRIT. 2
SYMBOL(S) OF PRODUCT: EXCLAMATION MARK
SIGNAL WORD: WARNING
POSSIBLE HAZARDS:
70% OF THE MIXTURE CONSISTS OF INGREDIENTS OF UNKNOWN ACUTE TOXICITY
GHS HAZARD STATEMENTS:
SKIN IRRITATION, CATEGORY 2:
H315: CAUSES SKIN IRRITATION.
EYE IRRITATION, CATEGORY 2:
H319: CAUSES SERIOUS EYE IRRITATION.
ACUTE TOXICITY, INHALATION, CATEGORY 4:
H332: HARMFUL IF INHALED.
GHS LABEL PRECAUTIONARY STATEMENTS:
P261: AVOID BREATHING DUST/FUME/GAS/MIST/VAPOURS/SPRAY.
P280:
WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION.
P302+P352:
IF ON SKIN: WASH WITH PLENTY OF SOAP AND WATER.
P305+P351+P338:
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
P312: CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
P337+P313:
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
P362: TAKE OFF CONTAMINATED CLOTHING.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
CHEMICAL NAME CAS-NO. WT. % GHS SYMBOLS GHS STATEMENTS
CLAY 1332-58-7 50-75 GHS03 H270
SODIUM SILICATE GLASS 1344-09-8 25-50 GHS03-GHS07 H270-302-332
CALCIUM META SILICATE 13983-17-0 2.5-10 GHS03 H270
SODIUM HYDROXIDE 1310-73-2 1.0-2.5 GHS03-GHS05- H270-302-
GHS07 312-314
QUARTZ 14808-60-7 0.1-1.0 GHS03-GHS07 H270-302
THE TEXT FOR GHS HAZARD STATEMENTS SHOWN ABOVE (IF ANY) IS GIVEN IN THE
"OTHER INFORMATION" SECTION.
| 4. FIRST-AID MEASURES | |
FIRST AID - INHALATION:
MATERIAL IS NOT LIKELY TO PRESENT AN INHALATION HAZARD AT AMBIENT
CONDITIONS. IF YOU EXPERIENCE DIFFICULTY IN BREATHING, LEAVE THE AREA TO
OBTAIN FRESH AIR. IF CONTINUED DIFFICULTY IS EXPERIENCED, GET MEDICAL
ATTENTION IMMEDIATELY.
FIRST AID - SKIN CONTACT:
NO HEALTH HAZARDS ARE KNOWN TO EXIST. IN CASE OF CONTACT, WASH SKIN
IMMEDIATELY WITH SOAP AND WATER.
FIRST AID - EYE CONTACT:
IN CASE OF CONTACT, IMMEDIATELY FLUSH EYES WITH LARGE QUANTITIES OF WATER
FOR AT LEAST 15 MINUTES UNTIL IRRITATION SUBSIDES. GET MEDICAL ATTENTION
IMMEDIATELY.
FIRST AID - INGESTION:
IF SWALLOWED, DO NOT INDUCE VOMITING. GET MEDICAL ATTENTION IMMEDIATELY.
| 5. FIRE-FIGHTING MEASURES | |
UNUSUAL FIRE AND EXPLOSION HAZARDS: NONE KNOWN.
SPECIAL FIREFIGHTING PROCEDURES:
WEAR SELF-CONTAINED BREATHING APPARATUS PRESSURE-DEMAND (NIOSH APPROVED OR
EQUIVALENT) AND FULL PROTECTIVE GEAR. USE WATER SPRAY TO COOL EXPOSED
SURFACES.
EXTINGUISHING MEDIA: CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG
| 6. ACCIDENTAL RELEASE MEASURES | |
ENVIRONMENTAL MEASURES: NO INFORMATION
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED:
CONTAIN SPILLED MATERIAL AND REMOVE WITH INERT ABSORBENT. DISPOSE OF
CONTAMINATED ABSORBENT, CONTAINER AND UNUSED CONTENTS IN ACCORDANCE WITH
LOCAL, STATE AND FEDERAL REGULATIONS. SCRAPE UP DRIED MATERIAL AND PLACE
INTO CONTAINERS. USE PERSONAL PROTECTIVE EQUIPMENT AS NECESSARY. IN CASE
OF SPILLAGE, ABSORB WITH INERT MATERIAL AND DISPOSE OF IN ACCORDANCE WITH
APPLICABLE REGULATIONS.
| 7. HANDLING AND STORAGE | |
HANDLING:
KEEP OUT OF REACH OF CHILDREN!
DO NOT TAKE INTERNALLY. USE ONLY WITH ADEQUATE VENTILATION. ENSURE
FRESH AIR ENTRY DURING APPLICATION AND DRYING. WASH THOROUGHLY AFTER
HANDLING.
STORAGE:
AVOID EXCESSIVE HEAT AND FREEZING. DO NOT STORE AT TEMPERATURES ABOVE
120 DEGREES F. STORE AWAY FROM CAUSTICS AND OXIDIZERS.
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
INGREDIENTS WITH OCCUPATIONAL EXPOSURE LIMITS:
CHEMICAL NAME ACGIH ACGIH- OSHA OSHA
TLV-TWA TLV STEL PEL-TWA PEL-CEILING
CLAY 2 MG/M3 TWA N.E. 15 MG/M3 TWA N.E.
PARTICULATE TOTAL DUST
MATTER
CONTAINING NO 5 MG/M3 TWA
ASBESTOS AND <1% RESPIRABLE
CRYSTALLINE FRACTION
SILICA,
RESPIRABLE
FRACTION
SODIUM SILICATE N.E. N.E. N.E. N.E.
GLASS
CALCIUM META N.E. N.E. N.E. N.E.
SILICATE
SODIUM HYDROXIDE N.E. N.E. 2 MG/M3 TWA N.E.
QUARTZ 0.025 MG/M3 TWA N.E. N.E. N.E.
RESPIRABLE
FRACTION
FURTHER ADVICE:
MEL = MAXIMUM EXPOSURE LIMIT
OES = OCCUPATIONAL EXPOSURE STANDARD
SUP = SUPPLIER'S RECOMMENDATION
SK = SKIN SENSITIZER
N.E. = NOT ESTABLISHED
PERSONAL PROTECTION:
RESPIRATORY PROTECTION:
NO PERSONAL RESPIRATORY PROTECTIVE EQUIPMENT NORMALLY REQUIRED. NATIONAL
INSTITUTE FOR OCCUPATIONAL SAFETY AND HEALTH (NIOSH) HAS RECOMMENDED THAT
THE PERMISSIBLE EXPOSURE LIMIT BE CHANGED TO 50 MICROGRAMS RESPIRABLE FREE
SILICA PER CUBIC METER OF AIR (0.05 MG/M3) AS DETERMINED BY A FULL SHIFT
SAMPLE UP TO 10-HOUR WORK SHIFT.
SKIN PROTECTION: RUBBER GLOVES.
EYE PROTECTION: GOGGLES OR SAFETY GLASSES WITH SIDE SHIELDS.
OTHER PROTECTIVE EQUIPMENT: NOT REQUIRED UNDER NORMAL USE.
HYGIENIC PRACTICES:
WASH HANDS BEFORE BREAKS AND AT THE END OF WORKDAY. REMOVE AND WASH
CONTAMINATED CLOTHING BEFORE RE-USE.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: COLORED
PHYSICAL STATE: PASTE
ODOR: SLIGHT
ODOR THRESHOLD: NOT ESTABLISHED
DENSITY, G/CM3: 1.80 - 1.80
PH: BETWEEN 7.0 AND 12.0
FREEZE POINT, DEG. C: NOT ESTABLISHED
VISCOSITY (MPA.S): NOT ESTABLISHED
SOLUBILITY IN WATER: NOT ESTABLISHED
PARTITION COEFF., N-OCTANOL/WATER: NOT ESTABLISHED
DECOMPOSITION TEMPERATURE, DEG. C: NOT ESTABLISHED
EXPLOSIVE LIMITS, %: N.I. - N.I.
BOILING RANGE, DEG. C: N.I. - N.I.
AUTO-IGNITION TEMPERATURE, DEG. C: NOT ESTABLISHED
MINIMUM FLASH POINT, DEG. C: 93.3
VAPOR PRESSURE, MMHg: NO INFORMATION
EVAPORATION RATE: SLOWER THAN N-BUTYL ACETATE
FLASH METHOD: SETA CLOSED CUP
VAPOR DENSITY: HEAVIER THAN AIR
COMBUSTIBILITY: DOES NOT SUPPORT COMBUSTION
(SEE "OTHER INFORMATION" SECTION FOR ABBREVIATION LEGEND)
(IF PRODUCT IS AN AEROSOL, THE FLASH POINT STATED ABOVE IS THAT OF THE
PROPELLANT.)
| 10. STABILITY AND REACTIVITY | |
STABILITY: STABLE UNDER RECOMMENDED STORAGE CONDITIONS.
CONDITIONS TO AVOID: EXCESSIVE HEAT AND FREEZING.
INCOMPATIBILITY: INCOMPATIBLE WITH STRONG BASES AND OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS:
NORMAL DECOMPOSITION PRODUCTS, I.E., COX, NOX.
| 11. TOXICOLOGICAL INFORMATION | |
EFFECT OF OVEREXPOSURE - INHALATION:
UNDER NORMAL USE CONDITIONS, THIS PRODUCT IS NOT EXPECTED TO CAUSE ADVERSE
HEALTH EFFECTS. INHALATION OF VAPORS IN HIGH CONCENTRATION MAY CAUSE MILD
IRRITATION OF RESPIRATORY SYSTEM (NOSE, MOUTH, MUCOUS MEMBRANES).
EFFECT OF OVEREXPOSURE - SKIN CONTACT:
UNDER NORMAL USE CONDITIONS, THIS PRODUCT IS NOT EXPECTED TO CAUSE ADVERSE
HEALTH EFFECTS. PROLONGED OR REPEATED CONTACT WITH SKIN MAY CAUSE MILD
IRRITATION.
EFFECT OF OVEREXPOSURE - EYE CONTACT:
UNDER NORMAL USE CONDITIONS, THIS PRODUCT IS NOT EXPECTED TO CAUSE ADVERSE
HEALTH EFFECTS. DIRECT EYE CONTACT MAY CAUSE IRRITATION.
EFFECT OF OVEREXPOSURE - INGESTION:
UNDER NORMAL USE CONDITIONS, THIS PRODUCT IS NOT EXPECTED TO CAUSE ADVERSE
HEALTH EFFECTS. SINGLE DOSE ORAL TOXICITY IS VERY LOW. AMOUNTS INGESTED
INCIDENTAL TO INDUSTRIAL HANDLING ARE NOT LIKELY TO CAUSE INJURY; HOWEVER,
INGESTION OF LARGE AMOUNTS MAY CAUSE INJURY.
CARCINOGENICITY: NO INFORMATION
PRIMARY ROUTE(S) OF ENTRY: EYE CONTACT, SKIN CONTACT
ACUTE TOXICITY VALUES:
THE ACUTE EFFECTS OF THIS PRODUCT HAVE NOT BEEN TESTED. DATA ON INDIVIDUAL
COMPONENTS ARE TABULATED BELOW
CAS-NO. CHEMICAL NAME ORAL LD50 DERMAL LD50 VAPOR LC50
1332-58-7 CLAY >5000 MG/KG RAT >5000 MG/KG RAT >20 MG/L
1344-09-8 SODIUM SILICATE 1153 MG/KG RAT 5000 MG/KG RAT N.I.
GLASS
13983-17-0 CALCIUM META N.I. N.I. N.I.
SILICATE
1310-73-2 SODIUM HYDROXIDE 325 MG/KG RABBIT 1350 MG/KG N.I.
RABBIT
14808-60-7 QUARTZ 500 MG/KG RAT >2000 MG/KG >20 MG/L
N.I. = NO INFORMATION
| 12. ECOLOGICAL INFORMATION | |
ECOLOGICAL INFORMATION:
ECOLOGICAL INJURIES ARE NOT KNOWN OR EXPECTED UNDER NORMAL USE.
| 13. DISPOSAL INFORMATION | |
DISPOSAL INFORMATION:
THIS PRODUCT DOES NOT MEET THE DEFINITION OF A HAZARDOUS WASTE ACCORDING TO
U.S. EPA HAZARDOUS WASTE MANAGEMENT REGULATION, 40 CFR SECTION 261. DISPOSE
AS HAZARDOUS WASTE ACCORDING TO ALL LOCAL, STATE, FEDERAL AND PROVINCIAL
REGULATIONS. STATE AND LOCAL REGULATIONS/RESTRICTIONS ARE COMPLEX AND MAY
DIFFER FROM FEDERAL REGULATIONS. RESPONSIBILITY FOR PROPER WASTE DISPOSAL
IS WITH THE OWNER OF THE WASTE.
| 14. TRANSPORT INFORMATION | |
SPECIAL TRANSPORT PRECAUTIONS: NO INFORMATION
DOT UN/NA NUMBER: N.A.
DOT PROPER SHIPPING NAME: NOT REGULATED.
DOT TECHNICAL NAME: N.A.
DOT HAZARD CLASS: N.A.
HAZARD SUBCLASS: N.A.
PACKING GROUP: N.A.
| 15. REGULATORY INFORMATION | |
U.S. FEDERAL REGULATIONS:
CERCLA - SARA HAZARD CATEGORY:
THIS PRODUCT HAS BEEN REVIEWED ACCORDING TO THE EPA 'HAZARD CATEGORIES'
PROMULGATED UNDER SECTIONS 311 AND 312 OF THE SUPERFUND AMENDMENT AND
REAUTHORIZATION ACT OF 1986 (SARA TITLE III) AND IS CONSIDERED, UNDER
APPLICABLE DEFINITIONS, TO MEET THE FOLLOWING CATEGORIES:
ACUTE HEALTH HAZARD, CHRONIC HEALTH HAZARD
SARA SECTION 313:
THIS PRODUCT CONTAINS THE FOLLOWING SUBSTANCES SUBJECT TO THE REPORTING
REQUIREMENTS OF SECTION 313 OF TITLE III OF THE SUPERFUND AMENDMENT AND
REAUTHORIZATION ACT OF 1986 AND 40 CFR PART 372:
NO SARA 313 COMPONENTS EXIST IN THIS PRODUCT.
TOXIC SUBSTANCES CONTROL ACT:
ALL INGREDIENTS IN THIS PRODUCT ARE EITHER ON TSCA INVENTORY LIST, OR
OTHERWISE EXEMPT.
THIS PRODUCT CONTAINS THE FOLLOWING CHEMICAL SUBSTANCES SUBJECT TO THE
REPORTING REQUIREMENTS OF TSCA 12(B) IF EXPORTED FROM THE UNITED STATES:
NO TSCA 12(B) COMPONENTS EXIST IN THIS PRODUCT.
CALIFORNIA PROPOSITION 65 CARCINOGENS:
WARNING:
THIS PRODUCT CONTAINS CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER.
CALIFORNIA PROPOSITION 65 REPRODUCTIVE TOXINS:
THIS PRODUCT DOES NOT CONTAIN ANY CHEMICALS KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
INTERNATIONAL REGULATIONS: AS FOLLOWS
CANADIAN WHMIS:
THIS MSDS HAS BEEN PREPARED IN COMPLIANCE WITH CONTROLLED PRODUCT
REGULATIONS EXCEPT FOR THE USE OF THE 16 HEADINGS.
WHMIS CLASS: CONSUMER COMMODITY
| 16. OTHER INFORMATION | |
REVISION DATE: 6/19/2015
SUPERSEDES DATE: 3/14/2013
REASON FOR REVISION: HAZCOM2012/GHS CONVERSION
DATASHEET PRODUCED BY: REGULATORY DEPARTMENT
HMIS RATINGS:
HEALTH 2
FLAMMABILITY 0
REACTIVITY 0
PERSONAL PROTECTION X
VOC LESS WATER LESS EXEMPT SOLVENT, G/L: 0.0
VOC MATERIAL, G/L: 0
VOC AS DEFINED BY CALIFORNIA CONSUMER PRODUCT REGULATION, WT/WT%: 0.0
TEXT FOR GHS HAZARD STATEMENTS SHOWN IN SECTION 3 DESCRIBING EACH
INGREDIENT:
H270: MAY CAUSE OR INTENSIFY FIRE; OXIDISER.
H302: HARMFUL IF SWALLOWED.
H312: HARMFUL IN CONTACT WITH SKIN.
H314: CAUSES SEVERE SKIN BURNS AND EYE DAMAGE.
H332: HARMFUL IF INHALED.
ICONS FOR GHS PICTOGRAMS SHOWN IN SECTION 3 DESCRIBING EACH INGREDIENT:
GHS03: FLAME OVER CIRCLE
GHS05: CORROSION
GHS07: EXCLAMATION MARK
LEGEND:
N.A. - NOT APPLICABLE
N.E. - NOT ESTABLISHED
N.D. - NOT DETERMINED
DAP BELIEVES THE DATA AND STATEMENTS CONTAINED HEREIN ARE ACCURATE AS OF
THE DATE HEREOF. THEY ARE OFFERED IN GOOD FAITH AS TYPICAL VALUES AND NOT
AS A PRODUCT SPECIFICATION. NO WARRANTY OF MERCHANTABILITY, WARRANTY OF
FITNESS FOR ANY PARTICULAR PURPOSE OR ANY OTHER WARRANTY, EXPRESS OR
IMPLIED, IS MADE WITH REGARD TO THE INFORMATION HEREIN PROVIDED OR THE
PRODUCT TO WHICH THE INFORMATION REFERS. SINCE THIS DOCUMENT IS INTENDED
ONLY AS A GUIDE TO THE APPROPRIATE USE AND PRECAUTIONARY HANDLING OF THE
REFERENCED PRODUCT BY A PROPERLY TRAINED PERSON, IT IS THEREFORE THE
RESPONSIBILITY OF THE USER TO (I) REVIEW THE RECOMMENDATIONS WITH DUE
CONSIDERATION FOR THE SPECIFIC CONTEXT OF THE INTENDED USE AND (II)
DETERMINE IF THEY ARE APPROPRIATE.