| Common Name: | LOCTITE SI 5920 RTV SILICONE COPPER KNOWN AS LOCTITE CO RTV SIL 70ML EN, 30542 |
| Manufacturer: | HENKEL |
| SDS Revision Date: | 5/19/2022 |
| SDS Format: | No Format Specified |
| Item Number(s): | 2PAC9, 5XB47 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
HENKEL
SAFETY DATA SHEET
REVISION NUMBER: 009.1
ISSUE DATE: 05/19/2022
| 1. PRODUCT AND COMPANY IDENTIFICATION |  |
PRODUCT NAME:
LOCTITE SI 5920 RTV SILICONE COPPER KNOWN AS LOCTITE CO RTV SIL 70ML EN
PRODUCT TYPE/USE: SILICONE
RESTRICTION OF USE: NONE IDENTIFIED
IDH NUMBER: 198818
ITEM NUMBER: 30542
REGION: UNITED STATES
COMPANY ADDRESS:
HENKEL CORPORATION
ONE HENKEL WAY
ROCKY HILL, CONNECTICUT 06067
CONTACT INFORMATION:
TELEPHONE: +1 (860) 571-5100
MEDICAL EMERGENCY PHONE:
POISON CONTROL CENTER 1-877-671-4608 (TOLL FREE) OR 1-303-592-1711
TRANSPORT EMERGENCY PHONE:
CHEMTREC: 1-800-424-9300 (TOLL FREE) OR 1-703-527-3887
INTERNET: WWW.HENKELNA.COM
| 2. HAZARDS IDENTIFICATION | |
EMERGENCY OVERVIEW:
WARNING
MAY CAUSE AN ALLERGIC SKIN REACTION.
CAUSES SERIOUS EYE IRRITATION.
SUSPECTED OF CAUSING CANCER.
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
HAZARD CLASS HAZARD CATEGORY
EYE IRRITATION 2A
SKIN SENSITIZATION 1
CARCINOGENICITY 2
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE 2
PICTOGRAM(S):
HEALTH HAZARD
EXCLAMATION MARK
PRECAUTIONARY STATEMENTS:
PREVENTION:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. DO NOT BREATHE DUST OR FUMES.
WASH AFFECTED AREA THOROUGHLY AFTER HANDLING. CONTAMINATED WORK CLOTHING
SHOULD NOT BE ALLOWED OUT OF THE WORKPLACE. WEAR PROTECTIVE GLOVES,
CLOTHING, EYE AND FACE PROTECTION.
RESPONSE:
IF ON SKIN: WASH WITH PLENTY OF WATER.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES,
IF PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EXPOSED OR CONCERNED: GET MEDICAL ATTENTION.
IF SKIN IRRITATION OR RASH OCCURS: GET MEDICAL ATTENTION.
IF EYE IRRITATION PERSISTS:
GET MEDICAL ATTENTION. WASH CONTAMINATED CLOTHING BEFORE REUSE.
STORAGE: STORE LOCKED UP.
DISPOSAL:
DISPOSE OF CONTENTS AND/OR CONTAINER ACCORDING TO FEDERAL,
STATE/PROVINCIAL AND LOCAL GOVERNMENTAL REGULATIONS.
CLASSIFICATION COMPLIES WITH OSHA HAZARD COMMUNICATION STANDARD
(29 CFR 1910.1200) AND IS CONSISTENT WITH THE PROVISIONS OF THE
UNITED NATIONS GLOBALLY HARMONIZED SYSTEM OF CLASSIFICATION AND
LABELING OF CHEMICALS (GHS).
SEE SECTION 11 FOR ADDITIONAL TOXICOLOGICAL INFORMATION.
| 3. COMPOSITION / INFORMATION ON INGREDIENTS | |
HAZARDOUS COMPONENT(S) CAS NUMBER PERCENTAGE*
SILANE, DICHLORODIMETHYL-, REACTION 68611-44-9 5 - 10
PRODUCTS WITH SILICA
BUTAN-2-ONE O,O',O''- 2224-33-1 1 - 5
(VINYLSILYLIDYNE)TRIOXIME
DIIRON TRIOXIDE 1309-37-1 1 - 5
MICA 12001-26-2 1 - 5
2-BUTANONE OXIME 96-29-7 1 - 5
* EXACT PERCENTAGES MAY VARY OR ARE TRADE SECRET. CONCENTRATION RANGE IS
PROVIDED TO ASSIST USERS IN PROVIDING APPROPRIATE PROTECTIONS.
| 4. FIRST AID MEASURES | |
INHALATION:
MOVE TO FRESH AIR. IF SYMPTOMS DEVELOP AND PERSIST, GET MEDICAL ATTENTION.
SKIN CONTACT:
WIPE OFF PASTE WITH PAPER TOWEL OR CLOTH. WASH WITH SOAP AND WATER. IF
SYMPTOMS DEVELOP AND PERSIST, GET MEDICAL ATTENTION.
EYE CONTACT:
RINSE IMMEDIATELY WITH PLENTY OF WATER, ALSO UNDER THE EYELIDS, FOR AT
LEAST 15 MINUTES. GET MEDICAL ATTENTION.
INGESTION:
DO NOT INDUCE VOMITING. IF SYMPTOMS DEVELOP AND PERSIST, GET MEDICAL
ATTENTION.
SYMPTOMS: SEE SECTION 11.
| 5. FIRE FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
WATER SPRAY (FOG), FOAM, DRY CHEMICAL OR CARBON DIOXIDE. DO NOT USE HIGH
VOLUME WATER JET.
SPECIAL FIREFIGHTING PROCEDURES:
WEAR SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING, SUCH
AS TURN-OUT GEAR.
UNUSUAL FIRE OR EXPLOSION HAZARDS:
IN CASE OF FIRE, KEEP CONTAINERS COOL WITH WATER SPRAY.
HAZARDOUS COMBUSTION PRODUCTS:
OXIDES OF CARBON. OXIDES OF SILICON. OXIDES OF NITROGEN. HYDROCARBONS.
FORMALDEHYDE. IRRITATING ORGANIC VAPOURS.
| 6. ACCIDENTAL RELEASE MEASURES | |
USE PERSONAL PROTECTION RECOMMENDED IN SECTION 8, ISOLATE THE HAZARD AREA
AND DENY ENTRY TO UNNECESSARY AND UNPROTECTED PERSONNEL.
ENVIRONMENTAL PRECAUTIONS:
DO NOT ALLOW PRODUCT TO ENTER SEWER OR WATERWAYS.
CLEAN-UP METHODS:
SCRAPE UP AS MUCH MATERIAL AS POSSIBLE. MAINTAIN GOOD VENTILATION FOR
LARGE SPILLS. PLACE SCRAP MATERIAL IN A WELL VENTILATED AREA AND ALLOW
TO CURE TO RUBBER.
| 7. HANDLING AND STORAGE | |
HANDLING:
PREVENT CONTACT WITH EYES, SKIN AND CLOTHING. DO NOT BREATHE VAPOR AND
MIST. WASH THOROUGHLY AFTER HANDLING. DO NOT HANDLE CONTACT LENSES UNTIL
ALL SEALANT HAS BEEN REMOVED FROM HANDS. RESIDUAL SEALANT MAY TRANSFER TO
LENSES AND CAUSE EYE IRRITATION.
STORAGE:
FOR SAFE STORAGE, STORE BETWEEN 8 DEG. C (46.4 DEG. F) AND 28 DEG. C
(82.4 DEG. F)
STORE IN A DRY AREA BELOW 90 DEG. F. KEEP CONTAINER CLOSED.
| 8. EXPOSURE CONTROLS / PERSONAL PROTECTION | |
EMPLOYERS SHOULD COMPLETE AN ASSESSMENT OF ALL WORKPLACES TO DETERMINE
THE NEED FOR, AND SELECTION OF, PROPER EXPOSURE CONTROLS AND PROTECTIVE
EQUIPMENT FOR EACH TASK PERFORMED.
HAZARDOUS COMPONENT(S) ACGIH TLV OSHA PEL
SILANE, DICHLORODIMETHYL-, 3 MG/M3 TWA 0.8 MG/M3 TWA
REACTION PRODUCTS WITH SILICA RESPIRABLE PARTICLES.
20 MPPCF TWA
10 MG/M3 TWA
INHALABLE PARTICLES. 50 MPPCF TWA
TOTAL DUST.
15 MG/M3 TWA
TOTAL DUST.
5 MG/M3 TWA
RESPIRABLE FRACTION.
15 MPPCF TWA
RESPIRABLE FRACTION.
BUTAN-2-ONE O,O',O''- NONE NONE
(VINYLSILYLIDYNE)TRIOXIME
DIIRON TRIOXIDE 5 MG/M3 TWA 10 MG/M3 PEL FUME.
RESPIRABLE FRACTION.
50 MPPCF TWA
TOTAL DUST.
5 MG/M3 TWA
RESPIRABLE FRACTION.
15 MG/M3 TWA
TOTAL DUST.
15 MPPCF TWA
RESPIRABLE FRACTION.
MICA 0.1 MG/M3 TWA 20 MPPCF TWA
RESPIRABLE FRACTION.
15 MG/M3 PEL
TOTAL DUST.
5 MG/M3 PEL
RESPIRABLE FRACTION.
2-BUTANONE OXIME NONE NONE
HAZARDOUS COMPONENT(S) AIHA WEEL OTHER
SILANE, DICHLORODIMETHYL-, REACTION NONE NONE
PRODUCTS WITH SILICA
BUTAN-2-ONE O,O',O''- NONE NONE
(VINYLSILYLIDYNE)TRIOXIME
DIIRON TRIOXIDE NONE NONE
MICA NONE NONE
2-BUTANONE OXIME 10 PPM NONE
(36 MG/M3) TWA
(SKIN SENSITIZER.)
ENGINEERING CONTROLS:
PROVIDE ADEQUATE LOCAL EXHAUST VENTILATION TO MAINTAIN WORKER EXPOSURE
BELOW EXPOSURE LIMITS.
RESPIRATORY PROTECTION:
USE A NIOSH APPROVED AIR-PURIFYING RESPIRATOR IF THE POTENTIAL TO EXCEED
ESTABLISHED EXPOSURE LIMITS EXISTS.
EYE/FACE PROTECTION:
SAFETY GOGGLES OR SAFETY GLASSES WITH SIDE SHIELDS. SAFETY SHOWERS AND
EYE WASH STATIONS SHOULD BE AVAILABLE.
SKIN PROTECTION:
CHEMICAL RESISTANT, IMPERMEABLE GLOVES. IMPERVIOUS CLOTHING.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
PHYSICAL STATE: PASTE
COLOR: COPPER
ODOR: MILD
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT APPLICABLE
VAPOR PRESSURE: <5 MM Hg (20 DEG. C (68 DEG. F))
BOILING POINT/RANGE: NOT APPLICABLE
MELTING POINT/ RANGE: NOT AVAILABLE.
SPECIFIC GRAVITY: 1.31 AT 20 DEG. C (68 DEG. F)
VAPOR DENSITY: HEAVIER THAN AIR.
FLASH POINT: >93 DEG. C (>199.4 DEG. F) TAGLIABUE CLOSED CUP
FLAMMABLE/EXPLOSIVE LIMITS - LOWER: NOT APPLICABLE NOT APPLICABLE
FLAMMABLE/EXPLOSIVE LIMITS - UPPER: NOT APPLICABLE NOT APPLICABLE
AUTOIGNITION TEMPERATURE: NOT AVAILABLE.
FLAMMABILITY: NOT APPLICABLE
EVAPORATION RATE: NOT AVAILABLE.
SOLUBILITY IN WATER: POLYMERISES IN PRESENCE OF WATER.
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
VOC CONTENT: 0.59 %
VISCOSITY: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
| 10. STABILITY AND REACTIVITY | |
STABILITY: STABLE AT NORMAL CONDITIONS.
HAZARDOUS REACTIONS: NONE UNDER NORMAL PROCESSING.
HAZARDOUS DECOMPOSITION PRODUCTS:
METHYL ETHYL KETOXIME FORMED DURING CURE. OXIDES OF CARBON. OXIDES
OF SILICON. OXIDES OF NITROGEN. IRRITATING VAPORS. HYDROCARBONS.
FORMALDEHYDE.
INCOMPATIBLE MATERIALS:
POLYMERIZES ON CONTACT WITH WATER. OXIDIZING AGENTS. ACIDS AND BASES.
REACTIVITY: NOT AVAILABLE.
CONDITIONS TO AVOID: MOISTURE.
| 11. TOXICOLOGICAL INFORMATION | |
RELEVANT ROUTES OF EXPOSURE: SKIN, INHALATION, EYES, INGESTION
POTENTIAL HEALTH EFFECTS/SYMPTOMS:
INHALATION:
INHALATION OF VAPORS OR MISTS OF THE PRODUCT MAY BE IRRITATING TO THE
RESPIRATORY SYSTEM. WHEN HEATED TO TEMPERATURES EXCEEDING 300 DEG. F
(150 DEG. C) IN THE PRESENCE OF AIR, SILICONES MAY FORM FORMALDEHYDE
VAPORS. FORMALDEHYDE IS A POTENTIAL CANCER HAZARD AND A KNOWN SKIN
AND RESPIRATORY SENSITIZER. VAPORS IRRITATE THE EYES, NOSE AND THROAT.
SAFE HANDLING CONDITIONS MAY BE MAINTAINED BY KEEPING FORMALDEHYDE VAPOR
CONCENTRATIONS BELOW THE OSHA PERMISSIBLE LIMIT.
SKIN CONTACT: MAY CAUSE SKIN IRRITATION. MAY CAUSE ALLERGIC SKIN REACTION.
EYE CONTACT: MAY CAUSE EYE IRRITATION.
INGESTION:
MAY BE HARMFUL IF SWALLOWED. NOT EXPECTED UNDER NORMAL CONDITIONS OF USE.
HAZARDOUS COMPONENT(S) LD50S AND LC50S IMMEDIATE AND DELAYED
HEALTH EFFECTS
SILANE, DICHLORODIMETHYL-, NONE NO DATA
REACTION PRODUCTS WITH
SILICA
BUTAN-2-ONE O,O',O''- NONE IRRITANT, ALLERGEN
(VINYLSILYLIDYNE)TRIOXIME
DIIRON TRIOXIDE NONE ALLERGEN, CARDIAC, CENTRAL
NERVOUS SYSTEM, IRRITANT,
KIDNEY, LIVER, LUNG
MICA NONE LUNG
2-BUTANONE OXIME INHALATION ALLERGEN, BLOOD, CENTRAL
LC50 (RAT, 4 H): NERVOUS SYSTEM, EYES,
>4.83 MG/L IRRITANT, SOME EVIDENCE
OF CARCINOGENICITY
HAZARDOUS COMPONENT(S) NTP IARC OSHA
CARCINOGEN CARCINOGEN CARCINOGEN
(SPECIFICALLY
REGULATED)
SILANE, DICHLORODIMETHYL-, NO NO NO
REACTION PRODUCTS WITH
SILICA
BUTAN-2-ONE O,O',O''- NO NO NO
(VINYLSILYLIDYNE)TRIOXIME
DIIRON TRIOXIDE NO NO NO
MICA NO NO NO
2-BUTANONE OXIME NO NO NO
| 12. ECOLOGICAL INFORMATION | |
ECOLOGICAL INFORMATION: NOT AVAILABLE.
| 13. DISPOSAL CONSIDERATIONS | |
INFORMATION PROVIDED IS FOR UNUSED PRODUCT ONLY.
RECOMMENDED METHOD OF DISPOSAL:
CURED RUBBER CAN BE INCINERATED OR LANDFILLED FOLLOWING EPA AND LOCAL
REGULATIONS. FOLLOW ALL LOCAL, STATE, FEDERAL AND PROVINCIAL REGULATIONS
FOR DISPOSAL.
| 14. TRANSPORT INFORMATION | |
THE TRANSPORT INFORMATION PROVIDED IN THIS SECTION ONLY APPLIES
TO THE MATERIAL/FORMULATION ITSELF, AND IS NOT SPECIFIC TO ANY
PACKAGE/CONFIGURATION.
U.S. DEPARTMENT OF TRANSPORTATION GROUND (49 CFR):
PROPER SHIPPING NAME: NOT REGULATED
HAZARD CLASS OR DIVISION: NONE
IDENTIFICATION NUMBER: NONE
PACKING GROUP: NONE
INTERNATIONAL AIR TRANSPORTATION (ICAO/IATA):
PROPER SHIPPING NAME: NOT REGULATED
HAZARD CLASS OR DIVISION: NONE
IDENTIFICATION NUMBER: NONE
PACKING GROUP: NONE
WATER TRANSPORTATION (IMO/IMDG):
PROPER SHIPPING NAME: NOT REGULATED
HAZARD CLASS OR DIVISION: NONE
IDENTIFICATION NUMBER: NONE
PACKING GROUP: NONE
| 15. REGULATORY INFORMATION | |
UNITED STATES REGULATORY INFORMATION:
TSCA 8 (B) INVENTORY STATUS:
ALL COMPONENTS ARE LISTED AS ACTIVE OR ARE EXEMPT FROM LISTING ON THE
TOXIC SUBSTANCES CONTROL ACT (TSCA) INVENTORY.
TSCA 12 (B) EXPORT NOTIFICATION: NONE ABOVE REPORTING DE MINIMIS
CERCLA/SARA SECTION 302 EHS: NONE ABOVE REPORTING DE MINIMIS.
CERCLA/SARA SECTION 311/312: IMMEDIATE HEALTH, DELAYED HEALTH
CERCLA/SARA SECTION 313: NONE ABOVE REPORTING DE MINIMIS.
CALIFORNIA PROPOSITION 65:
THIS PRODUCT CONTAINS A CHEMICAL KNOWN IN THE STATE OF CALIFORNIA TO CAUSE
CANCER. THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA
TO CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
CANADA REGULATORY INFORMATION:
CEPA DSL/NDSL STATUS:
CONTAINS ONE OR MORE COMPONENTS LISTED ON THE NON-DOMESTIC SUBSTANCES
LIST. ALL OTHER COMPONENTS ARE LISTED ON OR ARE EXEMPT FROM LISTING ON
THE DOMESTIC SUBSTANCES LIST. COMPONENTS LISTED ON THE NDSL MUST BE
TRACKED BY ALL CANADIAN IMPORTERS OF RECORD AS REQUIRED BY ENVIRONMENT
CANADA. THEY MAY BE IMPORTED INTO CANADA IN LIMITED QUANTITIES. PLEASE
CONTACT REGULATORY AFFAIRS FOR ADDITIONAL DETAILS.
| 16. OTHER INFORMATION | |
THIS SAFETY DATA SHEET CONTAINS CHANGES FROM THE PREVIOUS VERSION IN
SECTIONS: 9
PREPARED BY: PRODUCT SAFETY AND REGULATORY AFFAIRS
ISSUE DATE: 05/19/2022
DISCLAIMER:
THE DATA CONTAINED HEREIN ARE FURNISHED FOR INFORMATION ONLY AND ARE
BELIEVED TO BE RELIABLE. HOWEVER, HENKEL CORPORATION AND ITS AFFILIATES
("HENKEL") DOES NOT ASSUME RESPONSIBILITY FOR ANY RESULTS OBTAINED BY
PERSONS OVER WHOSE METHODS HENKEL HAS NO CONTROL. IT IS THE USER'S
RESPONSIBILITY TO DETERMINE THE SUITABILITY OF HENKEL'S PRODUCTS OR ANY
PRODUCTION METHODS MENTIONED HEREIN FOR A PARTICULAR PURPOSE, AND TO
ADOPT SUCH PRECAUTIONS AS MAY BE ADVISABLE FOR THE PROTECTION OF PROPERTY
AND PERSONS AGAINST ANY HAZARDS THAT MAY BE INVOLVED IN THE HANDLING AND
USE OF ANY HENKEL'S PRODUCTS. IN LIGHT OF THE FOREGOING, HENKEL
SPECIFICALLY DISCLAIMS ALL WARRANTIES, EXPRESS OR IMPLIED, INCLUDING
WARRANTIES OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE,
ARISING FROM SALE OR USE OF HENKEL'S PRODUCTS. HENKEL FURTHER DISCLAIMS
ANY LIABILITY FOR CONSEQUENTIAL OR INCIDENTAL DAMAGES OF ANY KIND,
INCLUDING LOST PROFITS.
THIS SAFETY DATA SHEET HAS BEEN GENERATED BASED ON OSHA HAZARD
COMMUNICATION STANDARD (29 CFR 1910.1200) AND PROVIDES INFORMATION
IN ACCORDANCE WITH U.S. FEDERAL LAW ONLY. NO WARRANTY OR REPRESENTATION
OF ANY KIND IS GIVEN WITH RESPECT TO THE SUBSTANTIVE OR EXPORT LAWS OF
ANY OTHER JURISDICTION OR COUNTRY. PLEASE CONFIRM THAT THE INFORMATION
PROVIDED HEREIN CONFORMS TO THE SUBSTANTIVE EXPORT OR OTHER LAW OF ANY
OTHER JURISDICTION PRIOR TO EXPORT. PLEASE CONTACT HENKEL PRODUCT SAFETY
AND REGULATORY AFFAIRS FOR ADDITIONAL ASSISTANCE.