| Common Name: | LOCTITE SF 7452 ACCELERATOR KNOWN AS LOCTITE 7452 ACCELERATOR TAK, 18580 |
| Manufacturer: | HENKEL |
| SDS Revision Date: | 11/8/2017 |
| SDS Format: | GHS-US |
| Item Number(s): | 2VFK1 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
HENKEL
SAFETY DATA SHEET
REVISION NUMBER: 007.0
ISSUE DATE: 11/08/2017
| 1. PRODUCT AND COMPANY IDENTIFICATION |  |
PRODUCT NAME:
LOCTITE SF 7452 ACCELERATOR KNOWN AS LOCTITE(R*) 7452(TM) ACCELERATOR TAK
PRODUCT TYPE: ACCELERATOR
RESTRICTION OF USE: NONE IDENTIFIED
IDH NUMBER: 229769
ITEM NUMBER: 18580
REGION: UNITED STATES
COMPANY ADDRESS:
HENKEL CORPORATION
ONE HENKEL WAY
ROCKY HILL, CONNECTICUT 06067
CONTACT INFORMATION:
TELEPHONE: +1 (860) 571-5100
MEDICAL EMERGENCY PHONE:
POISON CONTROL CENTER: 1-877-671-4608 (TOLL FREE) OR 1-303-592-1711
TRANSPORT EMERGENCY PHONE:
CHEMTREC: 1-800-424-9300 (TOLL FREE) OR 1-703-527-3887
INTERNET: WWW.HENKELNA.COM
| 2. HAZARDS IDENTIFICATION | |
EMERGENCY OVERVIEW:
DANGER:
HIGHLY FLAMMABLE LIQUID AND VAPOR.
CAUSES SERIOUS EYE IRRITATION.
MAY CAUSE DROWSINESS OR DIZZINESS.
HAZARD CLASS HAZARD CATEGORY
FLAMMABLE LIQUID 2
EYE IRRITATION 2A
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE 3
PICTOGRAM(S):
FLAME
HEALTH HAZARD
PRECAUTIONARY STATEMENTS:
PREVENTION:
KEEP AWAY FROM HEAT, SPARKS, OPEN FLAMES, HOT SURFACES - NO SMOKING. KEEP
CONTAINER TIGHTLY CLOSED. NO RELEASE INTO WATER. USE EXPLOSION-PROOF
EQUIPMENT. USE NON-SPARKING TOOLS. TAKE ACTION TO PREVENT STATIC
DISCHARGES. AVOID BREATHING VAPORS, MIST, OR SPRAY. WASH AFFECTED AREA
THOROUGHLY AFTER HANDLING. USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA.
WEAR PROTECTIVE GLOVES, EYE PROTECTION, AND FACE PROTECTION.
RESPONSE:
IF ON SKIN (OR HAIR): TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING.
IF INHALED:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. CALL A POISON CENTER OR PHYSICIAN IF YOU FEEL UNWELL.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES,
IF PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ATTENTION.
IN CASE OF FIRE: USE FOAM, DRY CHEMICAL OR CARBON DIOXIDE TO EXTINGUISH.
STORAGE:
STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED. STORE IN
A WELL-VENTILATED PLACE. KEEP COOL. STORE LOCKED UP.
DISPOSAL:
DISPOSE OF CONTENTS AND/OR CONTAINER ACCORDING TO FEDERAL, STATE/PROVINCIAL
AND LOCAL GOVERNMENTAL REGULATIONS.
CLASSIFICATION COMPLIES WITH OSHA HAZARD COMMUNICATION STANDARD
(29 CFR 1910.1200) AND IS CONSISTENT WITH THE PROVISIONS OF THE UNITED
NATIONS GLOBALLY HARMONIZED SYSTEM OF CLASSIFICATION AND LABELING OF
CHEMICALS (GHS).
SEE SECTION 11 FOR ADDITIONAL TOXICOLOGICAL INFORMATION.
| 3. COMPOSITION / INFORMATION ON INGREDIENTS | |
HAZARDOUS COMPONENT(S) CAS NUMBER PERCENTAGE*
ACETONE 67-64-1 90 - 100
* EXACT PERCENTAGES MAY VARY OR ARE TRADE SECRET. CONCENTRATION RANGE
IS PROVIDED TO ASSIST USERS IN PROVIDING APPROPRIATE PROTECTIONS.
| 4. FIRST AID MEASURES | |
INHALATION:
MOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. IF SYMPTOMS DEVELOP AND PERSIST,
GET MEDICAL ATTENTION.
SKIN CONTACT:
REMOVE CONTAMINATED CLOTHING AND FOOTWEAR. IMMEDIATELY FLUSH SKIN WITH
PLENTY OF WATER (USING SOAP, IF AVAILABLE). WASH CLOTHING BEFORE REUSE.
IF SYMPTOMS DEVELOP AND PERSIST, GET MEDICAL ATTENTION.
EYE CONTACT:
RINSE IMMEDIATELY WITH PLENTY OF WATER, ALSO UNDER THE EYELIDS, FOR AT
LEAST 15 MINUTES. GET MEDICAL ATTENTION.
INGESTION:
DO NOT INDUCE VOMITING UNLESS DIRECTED TO DO SO BY MEDICAL PERSONNEL.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. GET IMMEDIATE
MEDICAL ATTENTION.
SYMPTOMS: SEE SECTION 11.
| 5. FIRE FIGHTING MEASURES | |
EXTINGUISHING MEDIA: FOAM, DRY CHEMICAL OR CARBON DIOXIDE.
SPECIAL FIREFIGHTING PROCEDURES:
WEAR SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING,
SUCH AS TURN-OUT GEAR.
UNUSUAL FIRE OR EXPLOSION HAZARDS:
VAPORS MAY ACCUMULATE IN LOW OR CONFINED AREAS, TRAVEL CONSIDERABLE
DISTANCE TO SOURCE OF IGNITION, AND FLASH BACK. CLOSED CONTAINERS MAY
RUPTURE (DUE TO BUILD UP OF PRESSURE) WHEN EXPOSED TO EXTREME HEAT.
HAZARDOUS COMBUSTION PRODUCTS: OXIDES OF CARBON. OXIDES OF NITROGEN.
| 6. ACCIDENTAL RELEASE MEASURES | |
USE PERSONAL PROTECTION RECOMMENDED IN SECTION 8, ISOLATE THE HAZARD AREA
AND DENY ENTRY TO UNNECESSARY AND UNPROTECTED PERSONNEL.
ENVIRONMENTAL PRECAUTIONS:
DO NOT ALLOW PRODUCT TO ENTER SEWER OR WATERWAYS.
CLEAN-UP METHODS:
REMOVE ALL SOURCES OF IGNITION. ENSURE ADEQUATE VENTILATION. WEAR
APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT. REFER TO SECTION 8 "EXPOSURE
CONTROLS / PERSONAL PROTECTION" PRIOR TO CLEAN UP. SOAK UP WITH INERT
ABSORBENT MATERIAL (E.G. SAND, SILICA GEL, ACID BINDER, UNIVERSAL BINDER,
SAWDUST). STORE IN A PARTLY FILLED, CLOSED CONTAINER UNTIL DISPOSAL.
| 7. HANDLING AND STORAGE | |
HANDLING:
PREVENT CONTACT WITH EYES, SKIN AND CLOTHING. DO NOT BREATHE VAPOR AND
MIST. WASH THOROUGHLY AFTER HANDLING. KEEP CONTAINER CLOSED.
STORAGE:
KEEP IN A COOL, WELL VENTILATED AREA AWAY FROM HEAT, SPARKS AND OPEN
FLAME. KEEP CONTAINER TIGHTLY CLOSED UNTIL READY FOR USE.
| 8. EXPOSURE CONTROLS / PERSONAL PROTECTION | |
EMPLOYERS SHOULD COMPLETE AN ASSESSMENT OF ALL WORKPLACES TO DETERMINE
THE NEED FOR, AND SELECTION OF, PROPER EXPOSURE CONTROLS AND PROTECTIVE
EQUIPMENT FOR EACH TASK PERFORMED.
HAZARDOUS COMPONENT(S) ACGIH TLV OSHA PEL
ACETONE 250 PPM TWA 1,000 PPM
500 PPM STEL (2,400 MG/M3) PEL
HAZARDOUS COMPONENT(S) AIHA WEEL OTHER
ACETONE NONE NONE
ENGINEERING CONTROLS:
USE LOCAL VENTILATION IF GENERAL VENTILATION IS INSUFFICIENT TO MAINTAIN
VAPOR CONCENTRATION BELOW ESTABLISHED EXPOSURE LIMITS.
RESPIRATORY PROTECTION:
USE NIOSH APPROVED RESPIRATOR IF THERE IS POTENTIAL TO EXCEED EXPOSURE
LIMIT(S). OBSERVE OSHA REGULATIONS FOR RESPIRATOR USE (29 CFR 1910.134).
EYE/FACE PROTECTION:
SAFETY GOGGLES OR SAFETY GLASSES WITH SIDE SHIELDS. FULL FACE PROTECTION
SHOULD BE USED IF THE POTENTIAL FOR SPLASHING OR SPRAYING OF PRODUCT
EXISTS.
SKIN PROTECTION:
USE IMPERMEABLE GLOVES AND PROTECTIVE CLOTHING AS NECESSARY TO PREVENT
SKIN CONTACT. BUTYL RUBBER GLOVES. NEOPRENE GLOVES. NATURAL RUBBER GLOVES.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
PHYSICAL STATE: LIQUID
COLOR: CLEAR, TO, AMBER
ODOR: ACETONE
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT APPLICABLE
VAPOR PRESSURE: 185 MMHg (20 DEG. C (68 DEG. F)) APPROXIMATELY
BOILING POINT/RANGE: 57 DEG. C (134.6 DEG. F)
MELTING POINT/RANGE: NOT AVAILABLE.
SPECIFIC GRAVITY: 0.7926
VAPOR DENSITY: 2 APPROXIMATELY
FLASH POINT: -17 DEG. C (1.4 DEG. F) TAGLIABUE CLOSED CUP
FLAMMABLE/EXPLOSIVE LIMITS - LOWER: 2.8%
FLAMMABLE/EXPLOSIVE LIMITS - UPPER: 12.8%
AUTOIGNITION TEMPERATURE: NOT AVAILABLE.
FLAMMABILITY: NOT APPLICABLE
EVAPORATION RATE: 1.9 (ETHER = 1)
SOLUBILITY IN WATER: SOLUBLE
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
VOC CONTENT: 1.02%; 80 G/L
VISCOSITY: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
| 10. STABILITY AND REACTIVITY | |
STABILITY: STABLE AT NORMAL CONDITIONS.
HAZARDOUS REACTIONS: WILL NOT OCCUR.
HAZARDOUS DECOMPOSITION PRODUCTS: NOT AVAILABLE.
INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS.
REACTIVITY: NOT AVAILABLE.
CONDITIONS TO AVOID:
SEE "HANDLING AND STORAGE" (SECTION 7) AND "INCOMPATIBILITY" (SECTION 10).
| 11. TOXICOLOGICAL INFORMATION | |
RELEVANT ROUTES OF EXPOSURE: SKIN, INHALATION, EYES
POTENTIAL HEALTH EFFECTS/SYMPTOMS:
INHALATION:
VAPOURS MAY CAUSE DROWSINESS AND DIZZINESS. CENTRAL NERVOUS SYSTEM
DEPRESSION, INCLUDING DIZZINESS, DROWSINESS, FATIGUE, NAUSEA, HEADACHE,
UNCONSCIOUSNESS.
SKIN CONTACT:
MAY CAUSE AN ALLERGIC SKIN REACTION. SKIN ABSORPTION IS POSSIBLE, BUT
HARMFUL EFFECTS ARE NOT EXPECTED FROM THIS ROUTE OF EXPOSURE UNDER NORMAL
CONDITIONS OF HANDLING AND USE.
EYE CONTACT:
CAUSES SERIOUS EYE IRRITATION. EXPOSURE TO VAPOR MAY CAUSE TEARING OF THE
EYES, IRRITATION AND BURNING SENSATION.
INGESTION:
INGESTION MAY CAUSE GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING AND
DIARRHEA.
HAZARDOUS COMPONENT(S) LD50S AND LC50S IMMEDIATE AND DELAYED
HEALTH EFFECTS
ACETONE ORAL LD50 (MOUSE): CENTRAL NERVOUS
5.2 G/KG SYSTEM, IRRITANT
ORAL LD50 (MOUSE):
3,000 MG/KG
ORAL LD50 (RABBIT):
5,340 MG/KG
ORAL LD50 (RAT):
5,800 MG/KG
ORAL LD50 (RAT):
9,800 MG/KG
DERMAL LD50 (RABBIT):
20,000 MG/KG
INHALATION LC50
(RAT, 4 H): 76 MG/L
HAZARDOUS COMPONENT(S) NTP IARC OSHA CARCINOGEN
CARCINOGEN CARCINOGEN (SPECIFICALLY REGULATED)
ACETONE NO NO NO
| 12. ECOLOGICAL INFORMATION | |
ECOLOGICAL INFORMATION: NOT AVAILABLE.
| 13. DISPOSAL CONSIDERATIONS | |
INFORMATION PROVIDED IS FOR UNUSED PRODUCT ONLY.
RECOMMENDED METHOD OF DISPOSAL:
FOLLOW ALL LOCAL, STATE, FEDERAL AND PROVINCIAL REGULATIONS FOR DISPOSAL.
HAZARDOUS WASTE NUMBER:
D001: IGNITABLE.
| 14. TRANSPORT INFORMATION | |
THE TRANSPORT INFORMATION PROVIDED IN THIS SECTION ONLY APPLIES
TO THE MATERIAL/FORMULATION ITSELF, AND IS NOT SPECIFIC TO ANY
PACKAGE/CONFIGURATION.
U.S. DEPARTMENT OF TRANSPORTATION GROUND (49 CFR):
PROPER SHIPPING NAME: ACETONE
HAZARD CLASS OR DIVISION: 3
IDENTIFICATION NUMBER: UN 1090
PACKING GROUP: II
DOT HAZARDOUS SUBSTANCE(S): ACETONE
INTERNATIONAL AIR TRANSPORTATION (ICAO/IATA):
PROPER SHIPPING NAME: ACETONE
HAZARD CLASS OR DIVISION: 3
IDENTIFICATION NUMBER: UN 1090
PACKING GROUP: II
EXCEPTIONS:
(NOT MORE THAN 500 ML), MAY QUALIFY AS CONSUMER COMMODITY, ID8000
WATER TRANSPORTATION (IMO/IMDG):
PROPER SHIPPING NAME: ACETONE
HAZARD CLASS OR DIVISION: 3
IDENTIFICATION NUMBER: UN 1090
PACKING GROUP: II
EXCEPTIONS: LIMITED QUANTITY (NOT MORE THAN 1 L).
| 15. REGULATORY INFORMATION | |
UNITED STATES REGULATORY INFORMATION:
TSCA 8 (B) INVENTORY STATUS:
ALL COMPONENTS ARE LISTED OR ARE EXEMPT FROM LISTING ON THE TOXIC
SUBSTANCES CONTROL ACT INVENTORY.
TSCA 12 (B) EXPORT NOTIFICATION: NONE ABOVE REPORTING DE MINIMIS
CERCLA/SARA SECTION 302 EHS: NONE ABOVE REPORTING DE MINIMIS.
CERCLA/SARA SECTION 311/312: FIRE, IMMEDIATE HEALTH, DELAYED HEALTH
CERCLA/SARA SECTION 313: NONE ABOVE REPORTING DE MINIMIS.
CERCLA REPORTABLE QUANTITY: ACETONE (CAS# 67-64-1) 5,000 LBS. (2,270 KG)
CALIFORNIA PROPOSITION 65:
THIS PRODUCT CONTAINS A CHEMICAL KNOWN IN THE STATE OF CALIFORNIA TO CAUSE
CANCER. THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA
TO CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
CANADA REGULATORY INFORMATION:
CEPA DSL/NDSL STATUS:
CONTAINS ONE OR MORE COMPONENTS LISTED ON THE NON-DOMESTIC SUBSTANCES
LIST. ALL OTHER COMPONENTS ARE LISTED ON OR ARE EXEMPT FROM LISTING ON THE
DOMESTIC SUBSTANCES LIST. COMPONENTS LISTED ON THE NDSL MUST BE TRACKED
BY ALL CANADIAN IMPORTERS OF RECORD AS REQUIRED BY ENVIRONMENT CANADA.
THEY MAY BE IMPORTED INTO CANADA IN LIMITED QUANTITIES. PLEASE CONTACT
REGULATORY AFFAIRS FOR ADDITIONAL DETAILS.
| 16. OTHER INFORMATION | |
THIS SAFETY DATA SHEET CONTAINS CHANGES FROM THE PREVIOUS VERSION IN
SECTIONS: NEW SAFETY DATA SHEET FORMAT.
PREPARED BY: PRODUCT SAFETY AND REGULATORY AFFAIRS
ISSUE DATE: 11/08/2017
DISCLAIMER:
THE DATA CONTAINED HEREIN ARE FURNISHED FOR INFORMATION ONLY AND ARE
BELIEVED TO BE RELIABLE. HOWEVER, HENKEL CORPORATION AND ITS AFFILIATES
("HENKEL") DOES NOT ASSUME RESPONSIBILITY FOR ANY RESULTS OBTAINED BY
PERSONS OVER WHOSE METHODS HENKEL HAS NO CONTROL. IT IS THE USER'S
RESPONSIBILITY TO DETERMINE THE SUITABILITY OF HENKEL'S PRODUCTS OR ANY
PRODUCTION METHODS MENTIONED HEREIN FOR A PARTICULAR PURPOSE, AND TO ADOPT
SUCH PRECAUTIONS AS MAY BE ADVISABLE FOR THE PROTECTION OF PROPERTY AND
PERSONS AGAINST ANY HAZARDS THAT MAY BE INVOLVED IN THE HANDLING AND USE
OF ANY HENKEL'S PRODUCTS. IN LIGHT OF THE FOREGOING, HENKEL SPECIFICALLY
DISCLAIMS ALL WARRANTIES, EXPRESS OR IMPLIED, INCLUDING WARRANTIES OF
MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE, ARISING FROM SALE
OR USE OF HENKEL'S PRODUCTS. HENKEL FURTHER DISCLAIMS ANY LIABILITY FOR
CONSEQUENTIAL OR INCIDENTAL DAMAGES OF ANY KIND, INCLUDING LOST PROFITS.