| Common Name: | SDS, 20% SOLUTION |
| Manufacturer: | RESEARCH PRODUCTS INTERNATIONAL |
| SDS Revision Date: | 11/19/2015 |
| SDS Format: | No Format Specified |
| Item Number(s): | 30TY69 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
PRODUCT SAFETY DATA SHEET
RESEARCH PRODUCTS INTERNATIONAL
ISSUE DATE: 12/15/14
REV.: 1
REV DATE: 11/19/15
DOCUMENT #: F/RPI/QC 7.7.3-02
PRODUCT NAME: SDS, 20% SOLUTION
RPI ITEM NO: L23100
| SECTION 1 - CHEMICAL IDENTIFICATION |  |
PRODUCT NAME: SDS, 20% SOLUTION
RPI CATALOG #: L23100
SUPPLIER'S NAME: RESEARCH PRODUCTS INTERNATIONAL CORP.
SUPPLIERS ADDRESS:
410 N BUSINESS CENTER DRIVE MOUNT PROSPECT
IL 60056
EMERGENCY CONTACT: 1-800-424-9300
OTHER INFORMATION: 847-635-7330
| SECTION 2 - HAZARDS IDENTIFICATION | |
2.1 CLASSIFICATION OF THE SUBSTANCE OR MIXTURE:
GHS CLASSIFICATION IN ACCORDANCE WITH 29 CFR 1910 (OSHA HCS):
H315:
SKIN CORROSION/IRRITATION: CATEGORY 2
H318:
SERIOUS EYE DAMAGE: CATEGORY 1
H335:
SPECIFIC TARGET ORGAN TOXICITY, SINGLE EXPOSURE; RESPIRATORY TRACT
IRRITATION: CATEGORY 3
H402:
ACUTE AQUATIC TOXICITY: CATEGORY 3
2.2 GHS LABEL ELEMENTS, INCLUDING HAZARD AND PRECAUTIONARY STATEMENT(S):
PICTOGRAM:
CORROSION
EXCLAMATION MARK
SIGNAL WORD: DANGER
HAZARD STATEMENT(S):
H315: CAUSES SKIN IRRITATION
H318: CAUSES SERIOUS EYE DAMAGE
H335: MAY CAUSE RESPIRATORY IRRITATION
H402: HARMFUL TO AQUATIC LIFE
PREVENTION, RESPONSE, STORAGE AND DISPOSAL PRECAUTIONARY STATEMENT(S):
P261: AVOID BREATHING DUST/FUME/GAS/MIST/VAPORS/SPRAY.
P264: WASH SKIN THOROUGHLY AFTER HANDLING
P271: USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA.
P273: AVOID RELEASE TO THE ENVIRONMENT
P280:
WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION.
P302 + P352:
IF ON SKIN: WASH WITH PLENTY OF SOAP AND WATER.
P304 + P340:
IF INHALED:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE
FOR BREATHING.
P305 + P351 + P338:
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES,
IF PRESENT AND EASY TO DO. CONTINUE RINSING.
P312: CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
P321: SPECIFIC TREATMENT (SEE. ON THIS LABEL).
P332 + P313:
IF SKIN IRRITATION OCCURS: GET MEDICAL ADVICE/ATTENTION.
P362 + P364: TAKE OFF CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
P403 + P233:
STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED.
P405: STORE LOCKED UP.
P501: DISPOSE OF CONTENTS/ CONTAINER TO AN APPROVED WASTE DISPOSAL PLANT.
| SECTION 3- COMPOSITION/INFORMATION ON INGREDIENTS | |
COMPONENT CAS NUMBER COMPOSITION % AGE
WATER 7732-18-5 Q.S
SDS 151-21-3 20.0
| SECTION 4 - FIRST-AID MEASURES | |
4.1 DESCRIPTION OF FIRST AID MEASURES:
GENERAL ADVICE: CONSULT A DOCTOR AND SHOW THIS SAFETY DATA SHEET.
I. IF INHALED:
REMOVE TO FRESH AIR AND MONITOR BREATHING. IF BREATHING BECOMES DIFFICULT,
GIVE OXYGEN. IF BREATHING STOPS, GIVE ARTIFICIAL RESPIRATION. CONSULT A
DOCTOR.
II. IN CASE OF SKIN CONTACT:
IMMEDIATELY WASH SKIN WITH COPIOUS AMOUNTS OF SOAP AND WATER FOR AT LEAST
15 MINUTES. REMOVE CONTAMINATED CLOTHING AND SHOES AND WASH BEFORE REUSE.
CONSULT A DOCTOR.
III. IN CASE OF EYE CONTACT:
FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. CONSULT
A DOCTOR.
IV. IF SWALLOWED:
RINSE MOUTH WITH WATER. DO NOT INDUCE VOMITING UNLESS DIRECTED TO DO SO
BY MEDICAL PERSONNEL. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON. CONSULT A DOCTOR.
4.2 MOST IMPORTANT SYMPTOMS AND EFFECTS, BOTH ACUTE AND DELAYED:
TO THE BEST OF OUR KNOWLEDGE, THE CHEMICAL, PHYSICAL AND TOXICOLOGICAL
PROPERTIES HAVE NOT BEEN THOROUGHLY INVESTIGATED.
4.3 INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
SHOW THIS SAFETY DATA SHEET TO THE DOCTOR IN ATTENDANCE. IMMEDIATE MEDICAL
ATTENTION IS REQUIRED.
| SECTION 5 - FIRE FIGHTING MEASURES | |
5.1 EXTINGUISHING MEDIA:
SUITABLE EXTINGUISHING MEDIA:
USE WATER SPRAY, ALCOHOL-RESISTANT FOAM, DRY CHEMICAL OR CARBON DIOXIDE
5.2 SPECIAL HAZARDS ARISING FROM THE SUBSTANCE OR MIXTURE:
NO DATA AVAILABLE
5.3 PRECAUTIONS FOR FIRE-FIGHTERS:
WEAR SUITABLE PROTECTIVE CLOTHING TO PREVENT CONTACT WITH SKIN AND EYES
AND SELF-CONTAINED BREATHING APPARATUS.
5.4 FURTHER INFORMATION: NO DATA AVAILABLE
| SECTION 6 - ACCIDENTAL RELEASE MEASURES | |
6.1 PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
DO NOT TAKE ACTION WITHOUT SUITABLE PROTECTIVE CLOTHING - SEE SECTION 8
OF SDS. EVACUATE PERSONNEL TO SAFE AREAS. ENSURE ADEQUATE VENTILATION.
AVOID BREATHING VAPORS, MIST, DUST OR GAS.
6.2 ENVIRONMENTAL PRECAUTIONS: DO NOT LET PRODUCT ENTER DRAINS.
6.3 METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
COVER SPILLAGE WITH SUITABLE ABSORBENT MATERIAL. USING NON-SPARK TOOLS,
SWEEP UP MATERIAL AND PLACE IN AN APPROPRIATE CONTAINER. DECONTAMINATE
SPILL SITE WITH 10% CAUSTIC SOLUTION AND VENTILATE AREA UNTIL AFTER
DISPOSAL IS COMPLETE. HOLD ALL MATERIAL FOR APPROPRIATE DISPOSAL AS
DESCRIBED UNDER SECTION 13 OF SDS.
6.4 REFERENCE TO OTHER SECTIONS:
FOR REQUIRED PPE SEE SECTION 8. FOR DISPOSAL SEE SECTION 13.
| SECTION 7 - HANDLING AND STORAGE | |
7.1 PRECAUTIONS FOR SAFE HANDLING:
USE IN A CHEMICAL FUME HOOD, WITH AIR SUPPLIED BY AN INDEPENDENT SYSTEM.
AVOID INHALATION, CONTACT WITH EYES, SKIN AND CLOTHING. AVOID THE FORMATION
OF DUST AND AEROSOLS. USE IN A WELL-VENTILATED AREA. KEEP AWAY FROM SOURCES
OF IGNITION. AVOID PROLONGED OR REPEATED EXPOSURE.
7.2 CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
STORE IN COOL, WELL-VENTILATED AREA. KEEP AWAY FROM DIRECT SUNLIGHT.
KEEP CONTAINER TIGHTLY SEALED UNTIL READY FOR USE. STORE AT ROOM
TEMPERATURE.
7.3 SPECIFIC END USE(S):
USE IN A LABORATORY FUME HOOD WHERE POSSIBLE. REFER TO EMPLOYER'S COSHH
RISK ASSESSMENT.
| SECTION 8 - EXPOSURE CONTROLS/PERSONAL PROTECTION | |
8.1 CONTROL PARAMETERS:
COMPONENTS WITH WORKPLACE CONTROL PARAMETERS:
CONTAINS NO SUBSTANCES WITH OCCUPATIONAL EXPOSURE LIMIT VALUES.
8.2 EXPOSURE CONTROLS:
I. APPROPRIATE ENGINEERING CONTROLS:
USE IN A FUME HOOD WHERE APPLICABLE. ENSURE ALL ENGINEERING MEASURES
DESCRIBED UNDER SECTION 7 OF SDS ARE IN PLACE. ENSURE LABORATORY IS
EQUIPPED WITH A SAFETY SHOWER AND EYE WASH STATION.
8.3 PERSONAL PROTECTIVE EQUIPMENT:
I. EYE/FACE PROTECTION:
FACE SHIELD AND SAFETY GLASSES USE EQUIPMENT FOR EYE PROTECTION TESTED
AND APPROVED UNDER APPROPRIATE GOVERNMENT STANDARDS SUCH AS NIOSH (US)
OR EN 166(EU).
II. SKIN PROTECTION:
WEAR APPROPRIATE PROTECTIVE EYEGLASSES OR CHEMICAL SAFETY GOGGLES AS
DESCRIBED BY OSHA'S EYE AND FACE PROTECTION REGULATIONS IN 29 CFR
1910.133 OR EUROPEAN STANDARD EN166
III. BODY PROTECTION:
WEAR APPROPRIATE PROTECTIVE CLOTHING. COMPLETE SUIT PROTECTING AGAINST
CHEMICALS, THE TYPE OF PROTECTIVE EQUIPMENT MUST BE SELECTED ACCORDING
TO THE CONCENTRATION AND AMOUNT OF THE DANGEROUS SUBSTANCE AT THE
SPECIFIC WORKPLACE.
IV. RESPIRATORY PROTECTION:
FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN 29 CFR 1910.134 OR
EUROPEAN STANDARD EN 149. USE A NIOSH/MSHA OR EUROPEAN STANDARD EN149
APPROVED RESPIRATOR IF EXPOSURE LIMITS ARE EXCEEDED OR IF IRRITATION
OR OTHER SYMPTOMS ARE EXPERIENCED.
V. CONTROL OF ENVIRONMENTAL EXPOSURE: DO NOT LET PRODUCT ENTER DRAINS
| SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES | |
INFORMATION ON BASIC PHYSICAL AND CHEMICAL PROPERTIES:
APPEARANCE: LIQUID
ODOR: NO DATA AVAILABLE
ODOR THRESHOLD: NO DATA AVAILABLE
PH: NO DATA AVAILABLE
MELTING / FREEZING POINT: NO DATA AVAILABLE
INITIAL BOILING POINT RANGE: NO DATA AVAILABLE
FLASH POINT: NO DATA AVAILABLE
EVAPORATION RATE: NO DATA AVAILABLE
FLAMMABILITY (SOLID, GAS): NO DATA AVAILABLE
UPPER / LOWER FLAMMABILITY OR EXPLOSIVE LIMITS: NO DATA AVAILABLE
VAPOR PRESSURE: NO DATA AVAILABLE
VAPOR DENSITY: NO DATA AVAILABLE
RELATIVE DENSITY: 1.03 G/ML AT 20 DEG. C
WATER SOLUBILITY: NO DATA AVAILABLE
PARTITION COEFFICIENT: NO DATA AVAILABLE
AUTO-IGNITION TEMPERATURE: NO DATA AVAILABLE
DECOMPOSITION TEMPERATURE: NO DATA AVAILABLE
VISCOSITY: NO DATA AVAILABLE
EXPLOSIVE PROPERTIES: NO DATA AVAILABLE
OXIDIZING PROPERTIES: NO DATA AVAILABLE
| SECTION 10 - STABILITY AND REACTIVITY | |
STABILITY: STABLE UNDER RECOMMENDED STORAGE CONDITIONS.
HAZARDOUS DECOMPOSITION PRODUCTS/ HAZARDOUS POLYMERIZATION:
NO DATA AVAILABLE.
INCOMPATIBILITIES: STRONG OXIDIZING AGENTS, BASSES.
| SECTION 11 - TOXICOLOGICAL INFORMATION | |
ACUTE TOXICITY:
COMPONENT LD50 ORAL LD50 DERMAL LD50 INHALATION
SODIUM DODECYL 1288 MG/KG 580 MG/KG 3900 MG/M3 (RAT)-1 H
SULFATE (SOLID) (RAT) (RABBIT)
| SECTION 12 - ECOLOGICAL INFORMATION | |
ECO TOXICITY:
THE ENVIRONMENTAL IMPACT OF THIS PRODUCT HAS NOT BEEN FULLY INVESTIGATED
COMPONENT TOXICITY TO FISH TOXICITY TO ALGAE
SODIUM DODECYL LC50 15-18.9 MG/L EC50 3.59 - 15.6 MG/L 96 H
SULFATE (SOLID) PIMEPHALES PROMELAS EC50 = 117 MG/L 96 H
96 H EC50 = 53 MG/L 72 H
LC50 4.06-5.75 MG/L EC50 30 - 100 MG/L 96 H
LEPOMIS MACROCHIRUS
96 H
LC50 4.2-4.8 MG/L
LEPOMIS MACROCHIRUS
96 H
LC50 6.2-9.6 MG/L
PIMEPHALES PROMELAS
96 H
LC50= 4.2 MG/L
ONCORHYNCHUS MYKISS
96 H
LC50 13.5-18.3 MG/L
POE CILIA RETICULATE
96 H
LC50 5.8-7.5 MG/L
PIMEPHALES PROMELAS
96 H
LC50 9.9-20.1 MG/L
BRACHYDANIO RERIO
96 H
LC50 10.2-22.5 MG/L
PIMEPHALES PROMELAS
96 H
LC50 8-12.5 MG/L
PIMEPHALES PROMELAS
96 H
LC50= 4.5 MG/L
LEPOMIS MACROCHIRUS
96 H
LC50= 4.62 MG/L
ONCORHYNCHUS MYKISS
96 H
LC50 10.8-16.6 MG/L
POE CILIA RETICULATE
96 H
LC50 22.1-22.8 MG/L
PIMEPHALES PROMELAS
96 H
LC50 4.3-8.5 MG/L
ONCORHYNCHUS MYKISS
96 H
LC50= 1.31 MG/L
CYPRINUS CARPIO
96 H
LC50= 7.97 MG/L
BRACHYDANIO RERIO
96 H
PERSISTENCE AND DEGRADABILITY: NO DATA AVAILABLE
BIOACCUMLATIVE POTENTIAL: NO DATA AVAILABLE
MOBILITY IN SOIL: NO DATA AVAILABLE
RESULTS OF PBT AND VPVB ASSESSMENT: NO DATA AVAILABLE
OTHER ADVERSE EFFECTS: NO DATA AVAILABLE
CHRONIC TOXICITY:
THERE ARE NO KNOWN CARCINOGENIC CHEMICALS IN THIS PRODUCT
| SECTION 13 - DISPOSAL CONSIDERATIONS | |
WHATEVER CANNOT BE SAVED FOR RECOVERY OR RECYCLING SHOULD BE MANAGED
IN AN APPROPRIATE AND APPROVED WASTE DISPOSAL FACILITY. PROCESSING,
USE OR CONTAMINATION OF THIS PRODUCT MAY CHANGE THE WASTE MANAGEMENT
OPTIONS. STATE AND LOCAL DISPOSAL REGULATIONS MAY DIFFER FROM FEDERAL
DISPOSAL REGULATIONS. DISPOSE OF CONTAINER AND UNUSED CONTENTS IN
ACCORDANCE WITH FEDERAL, STATE AND LOCAL REQUIREMENTS.
| SECTION 14 - TRANSPORT INFORMATION | |
DOT: NOT REGULATED
TDG: NOT REGULATED
IATA: NOT REGULATED
IMDG/IMO: NOT REGULATED
| SECTION 15 - REGULATORY INFORMATION | |
USA FEDERAL REGULATION:
SARA 311/312 HAZARDOUS CATEGORIZATION:
ACUTE HEALTH CHRONIC HEALTH FIRE HAZARD SUDDEN RELEASE REACTIVE
HAZARD HAZARD OF PRESSURE HAZARD
HAZARD
YES NO NO NO NO
CLEAN WATER ACT/ CLEAN AIR ACT: NOT APPLICABLE
TSCA 12(B)/ OSHA/ SARA 313: NOT APPLICABLE.
CALIFORNIA PROPOSITION 65:
THIS PRODUCT DOES NOT CONTAIN ANY PROPOSITION 65 CHEMICALS
HMIS RATING:
HEALTH HAZARD 2
CHRONIC HEALTH HAZARD 0
FLAMMABILITY 0
PHYSICAL HAZARD 0
NFPA RATING:
HEALTH HAZARD 2
FIRE HAZARD 0
REACTIVITY HAZARD 0
STATE RIGHT TO KNOW:
MASSACHUSETTS NEW JERSEY PENNSYLVANIA ILLINOIS RHODE ISLAND
LISTED LISTED
US DEPARTMENT OF TRANSPORTATION:
REPORTABLE QUANTITY (RQ) DOT MARINE POLLUTANT DOT SEVER MARINE
POLLUTANT
NO NO NO
U.S. DEPARTMENT OF HOMELAND SECURITY:
THIS PRODUCT DOES NOT CONTAIN ANY DHS CHEMICALS.
CANADA:
THIS PRODUCT HAS BEEN CLASSIFIED IN ACCORDANCE WITH THE HAZARD CRITERIA
OF THE CONTROLLED PRODUCTS REGULATIONS (CPR) AND THE SDS CONTAINS ALL
THE INFORMATION REQUIRED BY THE CPR.
THIS SDS COMPLIES WITH THE REQUIREMENTS OF REGULATION (EC).
| SECTION 16 - OTHER INFORMATION | |
THE ABOVE INFORMATION IS BELIEVED TO BE CORRECT BUT DOES NOT PURPORT TO
BE ALL INCLUSIVE AND SHALL BE USED ONLY AS A GUIDE. RESEARCH PRODUCTS
INTERNATIONAL CORP. SHALL NOT BE HELD LIABLE FOR ANY DAMAGE RESULTING
FROM HANDLING OR FROM CONTACT WITH THE ABOVE PRODUCT. SEE REVERSE SIDE
OF INVOICE OR PACKING SLIP FOR ADDITIONAL TERMS AND CONDITIONS OF SALE.
THIS PRODUCT IS SOLD FOR LABORATORY RESEARCH AND DEVELOPMENT PURPOSES
USE ONLY.