| Common Name: | TS-2 TISSUE AND GEL SOLUBILIZER |
| Manufacturer: | RESEARCH PRODUCTS INTERNATIONAL |
| SDS Revision Date: | 11/10/2015 |
| SDS Format: | No Format Specified |
| Item Number(s): | 31FV49 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
PRODUCT SAFETY DATA SHEET
RESEARCH PRODUCTS INTERNATIONAL
ISSUE DATE: 12/15/14
REV.: 1
REV DATE: 11/10/15
DOCUMENT #: F/RPI/QC 7.7.3-02
PRODUCT NAME: TS-2 TISSUE AND GEL SOLUBILIZER
RPI ITEM NO: 112001
| SECTION 1 - CHEMICAL IDENTIFICATION |  |
PRODUCT NAME: TS-2 TISSUE AND GEL SOLUBILIZER
RPI CATALOG #: 112001
SUPPLIER'S NAME: RESEARCH PRODUCTS INTERNATIONAL CORP.
SUPPLIERS ADDRESS:
410 N BUSINESS CENTER DRIVE MOUNT PROSPECT,
IL 60056
EMERGENCY CONTACT: 1-800-424-9300
OTHER INFORMATION: 847-635-7330
| SECTION 2 - HAZARDS IDENTIFICATION | |
2.1 CLASSIFICATION OF THE SUBSTANCE OR MIXTURE:
GHS CLASSIFICATION IN ACCORDANCE WITH 29 CFR 1910 (OSHA HCS):
H224:
FLAMMABLE LIQUIDS: CATEGORY 1
H302:
ACUTE TOXICITY, ORAL: CATEGORY 4
H314:
SKIN CORROSION: CATEGORY 1B
H336:
SPECIFIC TARGET ORGAN TOXICITY, SINGLE: CATEGORY 3B
2.2 GHS LABEL ELEMENTS, INCLUDING HAZARD AND PRECAUTIONARY STATEMENT(S):
PICTOGRAM:
CORROSION
EXCLAMATION MARK
FLAME
SIGNAL WORD: DANGER
HAZARD STATEMENT(S):
H224: EXTREMELY FLAMMABLE LIQUID AND VAPOUR
H302: HARMFUL IF SWALLOWED
H314: CAUSES SEVERE SKIN BURNS AND EYE DAMAGE.
H336: MAY CAUSE DROWSINESS OR DIZZINESS
PREVENTION, RESPONSE, STORAGE AND DISPOSAL PRECAUTIONARY STATEMENT(S):
P210: KEEP AWAY FROM HEAT/SPARKS/OPEN FLAMES/HOT SURFACES. NO SMOKING.
P233: KEEP CONTAINER TIGHTLY CLOSED.
P240: GROUND/BOND CONTAINER AND RECEIVING EQUIPMENT.
P241: USE EXPLOSION-PROOF ELECTRICAL/VENTILATING/LIGHTING/EQUIPMENT
P242: USE ONLY NON-SPARKING TOOLS.
P243: TAKE PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGE
P261: AVOID BREATHING DUST/FUME/GAS/MIST/VAPORS/SPRAY.
P264: WASH SKIN THOROUGHLY AFTER HANDLING
P270: DO NOT EAT, DRINK OR SMOKE WHEN USING THIS PRODUCT.
P271: USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA.
P280:
WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION.
P301 + P312:
IF SWALLOWED: CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
P301+ P330+ P331:
IF SWALLOWED: RINSE MOUTH. DO NOT INDUCE VOMITING.
P303+ P61+ P353:
IF ON SKIN (OR HAIR):
REMOVE/ TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. RINSE SKIN WITH
WATER/ SHOWER.
P304 + P340:
IF INHALED:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE
FOR BREATHING.
P305+ P351+ P338:
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES,
IF PRESENT AND EASY TO DO. CONTINUE RINSING.
P310: IMMEDIATELY CALL A POISON CENTER OR DOCTOR/ PHYSICIAN.
P321: SPECIFIC TREATMENT (SEE. ON THIS LABEL).
P330: RINSE MOUTH.
P363: WASH CONTAMINATED CLOTHING BEFORE REUSE
P370 + P378:
IN CASE OF FIRE:
USE DRY SAND, DRY CHEMICAL OR ALCOHOL-RESISTANT FOAM FOR EXTINCTION
P403 + P233:
STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED.
P403 + P235: STORE IN A WELL-VENTILATED PLACE. KEEP COOL.
P405: STORE LOCKED UP.
P501: DISPOSE OF CONTENTS/ CONTAINER TO AN APPROVED WASTE DISPOSAL PLANT.
| SECTION 3 - COMPOSITION/INFORMATION ON INGREDIENTS | |
COMPONENT CAS NUMBER COMPOSITION
%AGE
PROPAN-2-OL 67-63-0 70.0 - 80.0
N,N-DIALKYL-N,N-DIMETHYLAMMONIUM HYDROXIDE N/A (MIXTURE) 15.0 - 30.0
WATER 7732-18-5 15.0 - 25.0
| SECTION 4 - FIRST-AID MEASURES | |
4.1 DESCRIPTION OF FIRST AID MEASURES:
GENERAL ADVICE: CONSULT A DOCTOR AND SHOW THIS SAFETY DATA SHEET.
I. IF INHALED:
REMOVE TO FRESH AIR AND MONITOR BREATHING. IF BREATHING BECOMES DIFFICULT,
GIVE OXYGEN. IF BREATHING STOPS, GIVE ARTIFICIAL RESPIRATION. CONSULT A
DOCTOR.
II. IN CASE OF SKIN CONTACT:
IMMEDIATELY WASH SKIN WITH COPIOUS AMOUNTS OF SOAP AND WATER FOR AT LEAST
15 MINUTES. REMOVE CONTAMINATED CLOTHING AND SHOES AND WASH BEFORE REUSE.
CONSULT A DOCTOR.
III. IN CASE OF EYE CONTACT:
FLUSH WITH COPIOUS AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. CONSULT A
DOCTOR.
IV. IF SWALLOWED:
RINSE MOUTH WITH WATER. DO NOT INDUCE VOMITING UNLESS DIRECTED TO DO SO
BY MEDICAL PERSONNEL. NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS
PERSON. CONSULT A DOCTOR.
4.2 MOST IMPORTANT SYMPTOMS AND EFFECTS, BOTH ACUTE AND DELAYED:
TO THE BEST OF OUR KNOWLEDGE, THE CHEMICAL, PHYSICAL AND TOXICOLOGICAL
PROPERTIES HAVE NOT BEEN THOROUGHLY INVESTIGATED.
4.3 INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
SHOW THIS SAFETY DATA SHEET TO THE DOCTOR IN ATTENDANCE. IMMEDIATE MEDICAL
ATTENTION IS REQUIRED.
| SECTION 5 - FIRE FIGHTING MEASURES | |
5.1 EXTINGUISHING MEDIA:
SUITABLE EXTINGUISHING MEDIA:
USE WATER SPRAY, ALCOHOL-RESISTANT FOAM, DRY CHEMICAL OR CARBON DIOXIDE
5.2 SPECIAL HAZARDS ARISING FROM THE SUBSTANCE OR MIXTURE:
NO DATA AVAILABLE.
5.3 PRECAUTIONS FOR FIRE-FIGHTERS:
WEAR SUITABLE PROTECTIVE CLOTHING TO PREVENT CONTACT WITH SKIN AND EYES
AND SELF-CONTAINED BREATHING APPARATUS.
5.4 FURTHER INFORMATION: NO DATA AVAILABLE
| SECTION 6 - ACCIDENTAL RELEASE MEASURES | |
6.1 PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
DO NOT TAKE ACTION WITHOUT SUITABLE PROTECTIVE CLOTHING - SEE SECTION 8 OF
SDS. EVACUATE PERSONNEL TO SAFE AREAS. ENSURE ADEQUATE VENTILATION. AVOID
BREATHING VAPORS, MIST, DUST OR GAS.
6.2 ENVIRONMENTAL PRECAUTIONS: DO NOT LET PRODUCT ENTER DRAINS.
6.3 METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
COVER SPILLAGE WITH SUITABLE ABSORBENT MATERIAL. USING NON-SPARK TOOLS,
SWEEP UP MATERIAL AND PLACE IN AN APPROPRIATE CONTAINER. DECONTAMINATE
SPILL SITE WITH 10% CAUSTIC SOLUTION AND VENTILATE AREA UNTIL AFTER
DISPOSAL IS COMPLETE. HOLD ALL MATERIAL FOR APPROPRIATE DISPOSAL AS
DESCRIBED UNDER SECTION 13 OF SDS.
6.4 REFERENCE TO OTHER SECTIONS:
FOR REQUIRED PPE SEE SECTION 8. FOR DISPOSAL SEE SECTION 13.
| SECTION 7 - HANDLING AND STORAGE | |
7.1 PRECAUTIONS FOR SAFE HANDLING:
USE IN A CHEMICAL FUME HOOD, WITH AIR SUPPLIED BY AN INDEPENDENT SYSTEM.
AVOID INHALATION, CONTACT WITH EYES, SKIN AND CLOTHING. AVOID THE FORMATION
OF DUST AND AEROSOLS. USE IN A WELL-VENTILATED AREA. KEEP AWAY FROM SOURCES
OF IGNITION. AVOID PROLONGED OR REPEATED EXPOSURE.
7.2 CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
STORE IN COOL, WELL-VENTILATED AREA. KEEP AWAY FROM DIRECT SUNLIGHT. KEEP
CONTAINER TIGHTLY SEALED UNTIL READY FOR USE. KEEP IN A DRY PLACE. KEEP
AWAY FROM DIRECT SUNLIGHT. KEEP AWAY FROM SOURCES OF IGNITION. FLAMMABLE
LIQUIDS.
7.3 SPECIFIC END USE(S):
USE IN A LABORATORY FUME HOOD WHERE POSSIBLE. REFER TO EMPLOYER'S COSHH
RISK ASSESSMENT.
| SECTION 8 - EXPOSURE CONTROLS/PERSONAL PROTECTION | |
8.1 CONTROL PARAMETERS: COMPONENTS WITH WORKPLACE CONTROL PARAMETERS
COMPONENT ACGIH TLV OSHA PEL NIOSH IDLH
ISOPROPYL ALCOHOL TWA: 200 PPM (VACATED) TWA: 400 PPM IDLH: 2000 PPM
STEL: 400 PPM (VACATED) TWA: TWA: 400 PPM
980 MG/M3 TWA: 980 MG/M3
(VACATED) STEL: MG/M3 STEL: 500 PPM
(VACATED) STEL: STEL:
1225 MG/M3 1225 MG/M3
TWA: 400 PPM
TWA: 980 MG/M3
COMPONENT QUEBEC MEXICO OEL (TWA) ONTARIO TWAEV
ISOPROPYL ALCOHOL TWA: 400 PPM TWA:400 PPM TWA: 200 PPM
TWA: 985 MG/M3 TWA: 980 MG/M3 STEL: 400 PPM
STEL: 500 PPM STEL: 500 PPM
STEL: 1230 MG/M3 STEL: 1225 MG/M3
ACGIH: AMERICAN CONFERENCE OF GOVERNMENTAL INDUSTRIAL HYGIENISTS
OSHA: OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION
NIOSH IDLH:
THE NATIONAL INSTITUTE FOR OCCUPATIONAL SAFETY AND HEALTH IMMEDIATELY
DANGEROUS TO LIFE OR HEALTH
8.2 EXPOSURE CONTROLS:
I. APPROPRIATE ENGINEERING CONTROLS:
USE IN A FUME HOOD WHERE APPLICABLE. ENSURE ALL ENGINEERING MEASURES
DESCRIBED UNDER SECTION 7 OF SDS ARE IN PLACE. ENSURE LABORATORY IS
EQUIPPED WITH A SAFETY SHOWER AND EYE WASH STATION.
8.3 PERSONAL PROTECTIVE EQUIPMENT:
I. EYE/FACE PROTECTION:
FACE SHIELD AND SAFETY GLASSES USE EQUIPMENT FOR EYE PROTECTION TESTED
AND APPROVED UNDER APPROPRIATE GOVERNMENT STANDARDS SUCH AS NIOSH (US)
OR EN 166(EU).
II. SKIN PROTECTION:
WEAR APPROPRIATE PROTECTIVE EYEGLASSES OR CHEMICAL SAFETY GOGGLES AS
DESCRIBED BY OSHA'S EYE AND FACE PROTECTION REGULATIONS IN 29 CFR
1910.133 OR EUROPEAN STANDARD EN166
III. BODY PROTECTION:
WEAR APPROPRIATE PROTECTIVE CLOTHING. COMPLETE SUIT PROTECTING AGAINST
CHEMICALS, THE TYPE OF PROTECTIVE EQUIPMENT MUST BE SELECTED ACCORDING
TO THE CONCENTRATION AND AMOUNT OF THE DANGEROUS SUBSTANCE AT THE
SPECIFIC WORKPLACE.
IV. RESPIRATORY PROTECTION:
FOLLOW THE OSHA RESPIRATOR REGULATIONS FOUND IN 29 CFR 1910.134 OR
EUROPEAN STANDARD EN 149. USE A NIOSH/MSHA OR EUROPEAN STANDARD EN149
APPROVED RESPIRATOR IF EXPOSURE LIMITS ARE EXCEEDED OR IF IRRITATION
OR OTHER SYMPTOMS ARE EXPERIENCED.
V. CONTROL OF ENVIRONMENTAL EXPOSURE: DO NOT LET PRODUCT ENTER DRAINS
| SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES | |
INFORMATION ON BASIC PHYSICAL AND CHEMICAL PROPERTIES:
APPEARANCE: COLORLESS LIQUID
ODOR: NO DATA AVAILABLE
ODOR THRESHOLD: NO DATA AVAILABLE
PH: NO DATA AVAILABLE
MELTING / FREEZING POINT: NO DATA AVAILABLE
INITIAL BOILING POINT RANGE: 82 DEG. C
FLASH POINT: 12 DEG. C
EVAPORATION RATE: NO DATA AVAILABLE
FLAMMABILITY (SOLID, GAS): NO DATA AVAILABLE
UPPER / LOWER FLAMMABILITY OR EXPLOSIVE LIMITS: NO DATA AVAILABLE
VAPOR PRESSURE @ 20.0 DEG. C: 35MM HG
VAPOR DENSITY: NO DATA AVAILABLE
RELATIVE DENSITY: 0.83
WATER SOLUBILITY: NO DATA AVAILABLE
PARTITION COEFFICIENT: NO DATA AVAILABLE
AUTO-IGNITION TEMPERATURE: 399.0 DEG. C
DECOMPOSITION TEMPERATURE: NO DATA AVAILABLE
VISCOSITY: NO DATA AVAILABLE
EXPLOSIVE PROPERTIES: NO DATA AVAILABLE
OXIDIZING PROPERTIES: NO DATA AVAILABLE
| SECTION 10 - STABILITY AND REACTIVITY | |
STABILITY: STABLE UNDER RECOMMENDED STORAGE CONDITIONS.
CONDITIONS TO AVOID: MOIST, AIR, HEAT, SOURCES OF IGNITION, LIGHT.
INCOMPATIBILITIES MATERIALS:
ACIDS, BASES, AMMONIA, ETHYLENE OXIDE, ISOCYANATES, ACETALDEHYDE,
CHLORIDE, PHOSGENE.
| SECTION 11 - TOXICOLOGICAL INFORMATION | |
ACUTE TOXICITY:
LD50 ORAL: > 2000 MG/KG (RAT)
LD50DERMAL: >2000 MG/KG (RABBIT)
LD50 VAPOUR TOXICITY: >20MG/L (RAT)
| SECTION 12 - ECOLOGICAL INFORMATION | |
ECO TOXICITY:
LC50 -DAPHNIA: 4600 MG/L - 24H
LC50 -FISH: 9600MG/L- 96H
PERSISTENCE AND DEGRADABILITY/ BIOACCUMLATIVE POTENTIAL: NO DATA AVAILABLE
MOBILITY / RESULTS OF PBT AND VPVB ASSESSMENT: NO DATA AVAILABLE
OTHER ADVERSE EFFECTS: NO DATA AVAILABLE
CHRONIC TOXICITY:
THERE ARE NO KNOWN CARCINOGENIC CHEMICALS IN THIS PRODUCT
| SECTION 13 - DISPOSAL CONSIDERATIONS | |
WHATEVER CANNOT BE SAVED FOR RECOVERY OR RECYCLING SHOULD BE MANAGED IN
AN APPROPRIATE AND APPROVED WASTE DISPOSAL FACILITY. PROCESSING, USE OR
CONTAMINATION OF THIS PRODUCT MAY CHANGE THE WASTE MANAGEMENT OPTIONS.
STATE AND LOCAL DISPOSAL REGULATIONS MAY DIFFER FROM FEDERAL DISPOSAL
REGULATIONS. DISPOSE OF CONTAINER AND UNUSED CONTENTS IN ACCORDANCE WITH
FEDERAL, STATE AND LOCAL REQUIREMENTS.
| SECTION 14 - TRANSPORT INFORMATION | |
UN# PROPER SHIPPING TRANSPORT SUB CLASS PACKAGING
NAME HAZARD CLASS GROUP
DOT 2920 CORROSIVE LIQUID, 8 3 II
FLAMMABLE, N.O.S.
(GOLDISOL)
TDG 2920 CORROSIVE LIQUID, 8 3 II
FLAMMABLE, N.O.S.
(GOLDISOL)
IATA 2920 CORROSIVE LIQUID, 8 3 II
FLAMMABLE, N.O.S.
(GOLDISOL)
IMDG/IMO 2920 CORROSIVE LIQUID, 8 3 II
FLAMMABLE, N.O.S.
(GOLDISOL)
| SECTION 15 - REGULATORY INFORMATION | |
INTERNATIONAL INVENTORIES:
REDIENT: WATER
CAS #:7732-18-5
EINECS: 231-791-2
TSCA DSL NDSL ELINCS NLP PICCS ENCS AICS CHINA KECL
LISTED LISTED LISTED LISTED LISTED LISTED
INGREDIENT: ISOPROPYL ALCOHOL
CAS #: 67-63-0
EINECS: 200-661-7
TSCA DSL NDSL ELINCS NLP PICCS ENCS AICS CHINA KECL
LISTED LISTED LISTED LISTED LISTED LISTED LISTED
USA FEDERAL REGULATION:
SARA 311/312 HAZARDOUS CATEGORIZATION:
ACUTE HEALTH CHRONIC HEALTH FIRE HAZARD SUDDEN RELEASE REACTIVE
HAZARD HAZARD OF PRESSURE HAZARD
HAZARD
YES YES YES NO NO
SARA 313 HAZARDOUS CATEGORIZATION: NO HAZARD CLASS
CLEAN WATER ACT/ CLEAN AIR ACT/ TSCA 12(B)/ OSHA/ CERCLA: NOT APPLICABLE
CALIFORNIA PROPOSITION 65:
THIS PRODUCT DOES NOT CONTAIN ANY PROPOSITION 65 CHEMICALS.
HMIS RATING:
HEALTH HAZARD 2
CHRONIC HEALTH HAZARD *
FLAMMABILITY 3
PHYSICAL HAZARD 0
NFPA RATING
HEALTH HAZARD 2
FIRE HAZARD 3
REACTIVITY HAZARD 0
STATE RIGHT TO KNOW:
COMPONENT MASSACHUSETTS NEW JERSEY PENNSYLVANIA ILLINOIS RHODE
ISLAND
TOLUENE LISTED LISTED LISTED LISTED
US DEPARTMENT OF TRANSPORTATION:
REPORTABLE QUANTITY (RQ) DOT MARINE POLLUTANT DOT SEVER MARINE
POLLUTANT
YES NO NO
U.S. DEPARTMENT OF HOMELAND SECURITY:
THIS PRODUCT DOES NOT CONTAIN ANY DHS CHEMICALS.
CANADA:
THIS PRODUCT HAS BEEN CLASSIFIED IN ACCORDANCE WITH THE HAZARD CRITERIA
OF THE CONTROLLED PRODUCTS REGULATIONS (CPR) AND THE SDS CONTAINS ALL
THE INFORMATION REQUIRED BY THE CPR.
THIS SDS COMPLIES WITH THE REQUIREMENTS OF REGULATION (EC).
| SECTION 16 - OTHER INFORMATION | |
THE ABOVE INFORMATION IS BELIEVED TO BE CORRECT BUT DOES NOT PURPORT TO BE
ALL INCLUSIVE AND SHALL BE USED ONLY AS A GUIDE. RESEARCH PRODUCTS
INTERNATIONAL CORP. SHALL NOT BE HELD LIABLE FOR ANY DAMAGE RESULTING FROM
HANDLING OR FROM CONTACT WITH THE ABOVE PRODUCT. SEE REVERSE SIDE OF
INVOICE OR PACKING SLIP FOR ADDITIONAL TERMS AND CONDITIONS OF SALE. THIS
PRODUCT IS SOLD FOR LABORATORY RESEARCH AND DEVELOPMENT PURPOSES USE ONLY.