| Common Name: | SET-XP |
| Manufacturer: | SIMPSON STRONG-TIE |
| SDS Revision Date: | 9/1/2016 |
| SDS Format: | GHS-US |
| Item Number(s): | 32PK56 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
SIMPSON
STRONG-TIE(R*)
SET-XP(R*) HIGH-STRENGTH EPOXY ADHESIVE
SAFETY DATA SHEET
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFICATION:
PRODUCT IDENTIFIER: SET-XP(R*)
RECOMMENDED USE:
SET-XP(R*) IS A HIGH-STRENGTH, ANCHORING ADHESIVE FOR CRACKED AND
UNCRACKED CONCRETE.
USE RESTRICTIONS:
TO ENSURE PROPER INSTALLATION USE ACCORDING TO PACKAGE DIRECTIONS, COMPLETE
APPLICATION INSTRUCTIONS CAN BE FOUND IN SIMPSON STRONG-TIE CATALOGS OR
ONLINE AT STRONGTIE.COM.
COMPANY IDENTIFICATION:
COMPANY: SIMPSON STRONG-TIE COMPANY INC.
ADDRESS:
5956 W. LAS POSITAS BLVD.
PLEASANTON, CA 94588
PHONE: 1-800-999-5099
WEBSITE: WWW.STRONGTIE.COM
EMERGENCY: 1-800-535-5053 (US/CANADA) / 1-352-323-3500 (INTERNATIONAL)
FOR MOST CURRENT SDS, PLEASE VISIT OUR WEBSITE AT WWW.STRONGTIE.COM/SDS
| 2. HAZARD IDENTIFICATION | |
GENERAL INFORMATION:
SET-XP HIGH-STRENGTH EPOXY ADHESIVE IS FOR ANCHORING DOWELING IN CRACKED
AND UNCRACKED CONCRETE AND MASONRY. IT IS A TWO-PART (1:1) SYSTEM PACKAGED
AS A SINGLE UNIT IN A DUEL CARTRIDGE. THE TWO PARTS OF THIS PRODUCT HAVE
BEEN INDIVIDUALLY ASSESSED ACCORDING TO THE GLOBALLY HARMONIZED SYSTEM
(GHS). EXPOSURE TO THE INDIVIDUAL COMPONENTS WILL ONLY OCCUR WITH IMPROPER
USE. THE RESIN AND HARDENER ARE DISPENSED AND MIXED SIMULTANEOUSLY THROUGH
THE MIXING NOZZLE. THE MIXED PRODUCT CAN BE ASSUMED TO CARRY THE HAZARDS OF
EACH COMPONENT UNTIL THE PRODUCT HAS FULLY HARDENED. THE FINAL CURED
PRODUCT WILL BE UNIFORMLY TEAL IN COLOR AND CAN BE CONSIDERED NONHAZARDOUS.
SOME HAZARDS MAY APPLY UPON GRINDING OR CUTTING THROUGH HARDENED PRODUCT.
THIS SAFETY DATA SHEET COVERS THE HAZARDS AND RESPONSES FOR THE SAFE USE OF
THIS PRODUCT.
RESIN (WHITE SIDE) GHS CLASSIFICATION:
CLASSIFICATION ACCORDING TO HAZCOM2012 (GHS):
PHYSICAL HAZARDS: NOT CLASSIFIED.
HEALTH HAZARDS:
SKIN CORROSION/IRRITATION: CATEGORY 2
H315: CAUSES SKIN IRRITATION
SERIOUS EYE DAMAGE/IRRITATION: CATEGORY 2
H319: CAUSES SERIOUS EYE IRRITATION
SENSITIZATION, SKIN: CATEGORY 1
H317: MAY CAUSE AN ALLERGIC SKIN REACTION
GERM CELL MUTAGENICITY: CATEGORY 2
H341: SUSPECTED OF CAUSING GENETIC DEFECTS
CARCINOGENICITY: CATEGORY 2
H351: SUSPECTED OF CAUSING CANCER
ENVIRONMENTAL HAZARDS:
CHRONIC AQUATIC HAZARD: CATEGORY 2
H411: TOXIC TO AQUATIC LIFE WITH LONG LASTING EFFECTS
MAIN SYMPTOMS:
IRRITATION OF EYES AND SKIN. SYMPTOMS INCLUDE REDNESS, ITCHING, BURNING,
TEARING, SWELLING, AND BLURRED VISION. MAY CAUSE RASH/ALLERGIC REACTION
TO THE SKIN. LONG TERM EXPOSURE MAY CAUSE CHRONIC EFFECTS.
GHS LABEL ELEMENTS:
EXCLAMATION POINT: EXCLAMATION MARK
CHRONIC HEALTH: HEALTH HAZARD
ENVIRONMENTAL HAZARD: ENVIRONMENT
CONTAINS: RESINS, BUTYL GLYCIDYL ETHER, TITANIUM DIOXIDE
SIGNAL WORD: WARNING!
HAZARD STATEMENTS:
H315: CAUSES SKIN IRRITATION.
H319: CAUSES SERIOUS EYE IRRITATION.
H317: MAY CAUSE AN ALLERGIC SKIN REACTION.
H341: SUSPECTED OF CAUSING GENETIC DEFECTS.
H351: SUSPECTED OF CAUSING CANCER.
H411: TOXIC TO AQUATIC LIFE WITH LONG LASTING EFFECTS.
PRECAUTIONARY STATEMENTS:
PREVENTION:
P102: KEEP OUT OF REACH OF CHILDREN.
P103: READ LABEL BEFORE USE.
P202:
DO NOT HANDLE UNTIL ALL SAFETY PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD.
P261: AVOID BREATHING DUST, MIST, OR VAPORS.
P264: WASH THOROUGHLY AFTER HANDLING.
P271: USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA.
P272:
CONTAMINATED WORK CLOTHING SHOULD NOT BE ALLOWED OUT OF THE WORKPLACE.
P273: AVOID RELEASE TO ENVIRONMENT.
P280:
WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION.
RESPONSE:
P302+P352:
IF ON SKIN: WASH WITH PLENTY OF WATER.
P333+P313:
IF SKIN IRRITATION OR RASH OCCURS: GET MEDICAL ADVICE/ATTENTION.
P362+P364: TAKE OFF CONTAMINATED CLOTHING AND WASH BEFORE RE-USE.
P304+P340:
IF INHALED: REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING.
P305+P351+P338:
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES,
IF PRESENT AND EASY TO DO. CONTINUE RINSING.
P337+P313:
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
P308+P313:
IF EXPOSED OR CONCERNED: CALL A POISON CENTER/DOCTOR.
P391: COLLECT SPILLAGE.
STORAGE:
P403: STORE IN A WELL-VENTILATED PLACE.
P405: STORE LOCKED UP.
P411: STORE BETWEEN 45-90 DEG. F (7-32 DEG. C).
DISPOSAL:
P501:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH LOCAL/REGIONAL
REGULATIONS.
SUPPLEMENTAL LABEL INFORMATION: NONE KNOWN.
HARDENER (GREEN SIDE) GHS CLASSIFICATION:
CLASSIFICATION ACCORDING TO HAZCOM2012 (GHS):
PHYSICAL HAZARDS: NOT CLASSIFIED.
HEALTH HAZARDS:
SKIN CORROSION/IRRITATION: CATEGORY 1
H314: CAUSES SEVERE SKIN BURNS
SERIOUS EYE DAMAGE/IRRITATION: CATEGORY 1
H318: CAUSES SERIOUS EYE DAMAGE
SENSITIZATION, SKIN: CATEGORY 1
H317: MAY CAUSE AN ALLERGIC SKIN REACTION
GERM CELL MUTAGENICITY: CATEGORY 2
H341: SUSPECTED OF CAUSING GENETIC DEFECTS
STOT, REPEATED EXPOSURE: CATEGORY 2
H373: MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED AND REPEATED EXPOSURE
ENVIRONMENTAL HAZARDS: NOT CLASSIFIED.
MAIN SYMPTOMS:
DAMAGE TO THE EYES AND SKIN. SYMPTOMS INCLUDE BURNS, REDNESS, ITCHING,
TEARING, SWELLING, AND BLURRED VISION. MAY CAUSE RASH/ALLERGIC REACTION
TO THE SKIN. LONG TERM EXPOSURE MAY CAUSE CHRONIC EFFECTS.
GHS LABEL ELEMENTS:
CORROSIVE: CORROSION
EXCLAMATION POINT: EXCLAMATION MARK
CHRONIC HEALTH: HEALTH HAZARD
CONTAINS: CRYSTALLINE SILICA (QUARTZ), PHENOLS, AMINES
SIGNAL WORD: DANGER!
HAZARD STATEMENTS:
H314: CAUSES SEVERE SKIN BURNS AND EYE DAMAGE.
H318: CAUSES SERIOUS EYE DAMAGE.
H317: MAY CAUSE AN ALLERGIC SKIN REACTION.
H341: SUSPECTED OF CAUSING GENETIC DEFECTS.
H373: MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED AND REPEATED EXPOSURE.
PRECAUTIONARY STATEMENTS:
PREVENTION:
P102: KEEP OUT OF REACH OF CHILDREN.
P103: READ LABEL BEFORE USE.
P202:
DO NOT HANDLE UNTIL ALL SAFETY PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD.
P260: DO NOT BREATHE DUST, MIST, OR VAPOR.
P264: WASH THOROUGHLY AFTER HANDLING.
P270: DO NOT EAT, DRINK OR SMOKE WHEN USING THIS PRODUCT.
P271: USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA.
P272: CONTAMINATED WORK CLOTHING MUST NOT BE ALLOWED OUT OF THE WORKPLACE.
P280:
WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION.
P284: IN CASE OF INADEQUATE VENTILATION WEAR RESPIRATORY PROTECTION.
RESPONSE:
P301+P330+P331:
IF SWALLOWED: RINSE MOUTH. DO NOT INDUCE VOMITING.
P310: IMMEDIATELY CALL A POSION CENTER/DOCTOR.
P303+P361+P353:
IF ON SKIN (OR HAIR):
TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. RINSE SKIN WITH
WATER/SHOWER.
P333+P313:
IF SKIN IRRITATION OR RASH OCCURS: GET MEDICAL ADVICE/ATTENTION.
P363: WASH CONTAMINATED CLOTHING BEFORE REUSE.
P304+P340:
IF INHALED: REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING.
P305+P351+P338:
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES,
IF PRESENT AND EASY TO DO. CONTINUE RINSING.
P315: GET IMMEDIATELY MEDICAL ADVICE/ATTENTION.
P337+P313:
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
P308+P313:
IF EXPOSED OR CONCERNED: GET MEDICAL ADVICE/ATTENTION.
STORAGE:
P403+P233:
STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED.
P405: STORE LOCKED UP.
P411: STORE BETWEEN 45-90 DEG. F (7-32 DEG. C).
DISPOSAL:
P501:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH LOCAL/REGIONAL
REGULATIONS.
SUPPLEMENTAL LABEL INFORMATION: NONE KNOWN.
HAZARDS NOT OTHERWISE CLASSIFIED (HNOC):
THE ABOVE HAZARDS ARE FOR THE UNCURED COMPONENTS OF SET-XP. UPON
COMBINATION OF THE TWO COMPONENTS, AN INNOCUOUS SOLID WHICH DOES NOT
PRESENT ANY IMMEDIATE HAZARDS IS FORMED. UPON GRINDING OR CUTTING THE
CURED PRODUCT, THE FOLLOWING HAZARDS MAY APPLY. ENSURE GOOD WORK PRACTICE
AND USE OF PERSONAL PROTECTIVE EQUIPMENT AS NEEDED TO CONTROL EXPOSURE TO
PROCESSING DUST.
CHRONIC HEALTH: HEALTH HAZARD
HEALTH HAZARD:
CARCINOGENICITY: CATEGORY 1A
OSHA HAZARD:
STOT, REPEATED EXPOSURE: CATEGORY 1
COMBUSTIBLE DUST
HAZARD STATEMENT:
MAY CAUSE CANCER.
MAY CAUSE DAMAGE TO ORGANS (LUNGS) WITH PROLONGED AND REPEATED EXPOSURE.
CAN FORM EXPLOSIVE AIR-DUST MIXTURES, AVOID CREATING DUST.
PRECAUTIONARY STATEMENT:
DO NOT BREATHE DUST.
DO NOT ALLOW DUST TO BUILD UP ON SURFACES.
| 3. COMPOSITION INFORMATION | |
GENERAL INFORMATION:
THIS PRODUCT IS A MIXTURE. HAZARDOUS INGREDIENTS FOR EACH COMPONENT ARE
LISTED BELOW. MAY INCLUDE OTHER NONHAZARDOUS INGREDIENTS. MAY INCLUDE
OTHER TRACE INGREDIENTS, SEE SECTION 15.
LIST OF ABBREVIATIONS AND SYMBOLS:
CLASSIFICATION: GLOBAL HARMONIZED SYSTEM CLASSIFICATIONS
THE FULL TEXT FOR H-PHRASES IS DISPLAYED IN SECTION 16. ALL CONCENTRATIONS
ARE IN PERCENT BY WEIGHT UNLESS OTHERWISE NOTED.
RESIN (WHITE SIDE):
CHEMICAL NAME WEIGHT % CAS NUMBER EC NUMBER
BISPHENOL-A BASED EPOXY RESIN 30 - 50 25068-38-6 500-033-5
CLASSIFICATIONS:
SKIN IRRIT. 2: H315, EYE IRRIT. 2: H319, SKIN SENS. 1: H317,
AQUATIC CHRONIC 2: H411
PHENOLIC NOVOLAC RESIN 40 - 70 28064-14-4 608-164-0
CLASSIFICATIONS:
SKIN IRRIT. 2: H315, EYE IRRIT. 2: H319, SKIN SENS. 1: H317,
AQUATIC CHRONIC 2: H411
BUTYL GLYCIDYL ETHER 1 - 5 2426-08-6 219-376-4
CLASSIFICATIONS:
FLAM. LIQ. 3: H226, ACUTE TOX. 4: H302+H332, SKIN IRRIT. 2: H315,
EYE IRRIT. 2: H319, SKIN SENS. 1: H317, GCM 2: H341, CARC. 2: H351,
STOT SE 3: H335, AQUATIC 3: H402+H412
TITANIUM DIOXIDE 1 - 5 13463-67-7 236-675-5
CLASSIFICATIONS:
CARC. 2: H351
HARDENER (GREEN SIDE):
CHEMICAL NAME WEIGHT % CAS NUMBER EC NUMBER
CRYSTALLINE SILICA, QUARTZ 20 - 40 14808-60-7 238-878-4
CLASSIFICATIONS:
CARC. 1A: H350, STOT RE 1: H372
POLYAMIDO AMINE 10 - 30 68953-36-6 273-201-6
CLASSIFICATIONS:
SKIN IRRIT. 2: H315, EYE IRRIT. 2: H319, SKIN SENS. 1: H317,
STOT SE 3: H335
2,4,6-TRIS-(DIMETHYLAMINOMETHYL) 1 - 5 90-72-2 202-013-9
PHENOL
CLASSIFICATIONS:
ACUTE TOX. 4: H302, SKIN IRRIT. 2: H315, EYE IRRIT. 2: H319
PHENOL 1 - 5 108-95-2 203-632-7
CLASSIFICATIONS:
ACUTE TOX. 3: H301+H311+H331, SKIN CORR. 1: H314, GCM 2: H341,
STOT RE 2: H373
BENZENE-1,3-DIMETHANEAMINE 1 - 5 1477-55-0 216-032-5
CLASSIFICATIONS:
ACUTE TOX. 4: H302+H312+H332, SKIN CORR. 1: H314, AQUATIC 3: H402+H412
TETRAETHYLENEPENTAMINE 1 - 5 112-57-2 203-986-2
CLASSIFICATIONS:
ACUTE TOX. 4: H302+H312, SKIN CORR. 1: H314, SKIN SENS. 1: 317,
AQUATIC CHRONIC 2: H411
CARBON BLACK <1 1333-86-4 215-609-9
CLASSIFICATIONS:
CARC. 2: H351
| 4. FIRST-AID MEASURES | |
GENERAL INFORMATION:
PROVIDE GENERAL SUPPORTIVE MEASURES AND TREAT SYMPTOMATICALLY. SYMPTOMS
MAY BE DELAYED. ENSURE THAT MEDICAL PERSONNEL ARE AWARE OF THE MATERIAL(S)
INVOLVED AND TAKE PRECAUTIONS TO PROTECT THEMSELVES.
IF EXPOSED OR CONCERNED:
GET MEDICAL ADVICE/ATTENTION. WASH CONTAMINATED CLOTHING BEFORE REUSE.
ROUTES OF EXPOSURE:
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF COOL WATER FOR AT LEAST 15 MINUTES
WHILE HOLDING THE EYES OPEN. REMOVE CONTACT LENSES IF PRESENT AND EASY TO
DO. IF REDNESS, BURNING, BLURRED VISION, OR SWELLING PERSISTS, CONSULT A
PHYSICIAN IMMEDIATELY.
SKIN CONTACT:
REMOVE CONTAMINATED CLOTHING AND PRODUCT; IMMEDIATELY WASH AFFECTED AREA
WITH SOAP AND WATER. DO NOT APPLY GREASES OR OINTMENTS. CHEMICAL BURNS
MUST BE TREATED BY A PHYSICIAN.
INGESTION:
RINSE MOUTH IMMEDIATELY. GIVE LARGE AMOUNTS OF MILK OR WATER IF THE PERSON
IS CONSCIOUS. ONLY INDUCE VOMITING AT THE INSTRUCTION OF MEDICAL PERSONNEL.
CONSULT A PHYSICIAN IMMEDIATELY.
INHALATION:
REMOVE PATIENT TO FRESH AIR. GIVE OXYGEN OR ARTIFICIAL RESPIRATION IF
NEEDED. IF PATIENT CONTINUES TO EXPERIENCE DIFFICULTY BREATHING, CONSULT
A PHYSICIAN.
MOST IMPORTANT SYMPTOMS:
DAMAGE TO THE EYES AND SKIN. SYMPTOMS INCLUDE BURNS, REDNESS, ITCHING,
TEARING, SWELLING, AND BLURRED VISION. PERMANENT EYE DAMAGE, INCLUDING
BLINDNESS, COULD RESULT. RASH/DERMATITIS.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
EXTINGUISH WITH FOAM, CARBON DIOXIDE, DRY POWDER, OR WATER FOG.
ADDITIONAL INFORMATION: NONE KNOWN.
HAZARDS DURING FIRE-FIGHTING:
HAZARDOUS DECOMPOSITION PRODUCTS MAY OCCUR WHEN MATERIALS POLYMERIZE
AT TEMPERATURES ABOVE 500 DEG. F (260 DEG. C). IRRITATING AND TOXIC
GASES/FUMES MAY BE RELEASED DURING A FIRE. WATER RUN-OFF CAN CAUSE
ENVIRONMENTAL DAMAGE.
FIRE-FIGHTING PROCEDURES:
USE STANDARD FIRE-FIGHTING PROCEDURES AND CONSIDER THE HAZARDS OF OTHER
INVOLVED MATERIALS. IN CASE OF FIRE AND/OR EXPLOSION, DO NOT BREATHE FUMES.
SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING MUST BE
WORN. MOVE CONTAINERS FROM FIRE AREA IF YOU CAN DO SO WITHOUT RISK. COOL
CONTAINERS BY FLOODING QUANTITIES OF WATER UNTIL WELL AFTER FIRE IS OUT.
PREVENT RUNOFF FROM FIRE CONTROL OR DILUTION FROM ENTERING STREAMS, SEWERS,
OR DRINKING WATER SUPPLY.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS:
NON-EMERGENCY PERSONNEL:
ELIMINATE ALL IGNITION SOURCES (NO SMOKING, FLARES, SPARKS, OR FLAMES IN
IMMEDIATE AREA). KEEP UNNECESSARY PERSONNEL AWAY. WEAR APPROPRIATE PERSONAL
PROTECTIVE EQUIPMENT. DO NOT TOUCH DAMAGED CONTAINERS OR SPILLED MATERIAL
UNLESS WEARING APPROPRIATE PROTECTIVE CLOTHING. AVOID INHALATION OF VAPORS
OR MISTS. ENSURE ADEQUATE VENTILATION. LOCAL AUTHORITIES SHOULD BE ADVISED
IF SIGNIFICANT SPILLAGES CANNOT BE CONTAINED.
EMERGENCY PERSONNEL:
KEEP UNNECESSARY PERSONNEL AWAY. KEEP PEOPLE AWAY FROM AND UPWIND OF
SPILL/LEAK. WEAR APPROPRIATE PERSONAL PROTECTION.
CLEAN-UP METHODS:
SMALL SPILLS (UNCURED):
WIPE UP WITH ABSORBENT MATERIAL (E.G. CLOTH, FLEECE). PLACE IN LEAK-PROOF
CONTAINERS. SEAL TIGHTLY FOR PROPER DISPOSAL. CLEAN SURFACE THOROUGHLY TO
REMOVE RESIDUAL CONTAMINATION. IF DESIRED, APPROVED SOLVENTS, SUCH AS
KETONES (MEK, ACETONE, ETC.), LACQUER THINNER, OR ADHESIVE REMOVER CAN BE
USED. DO NOT USE SOLVENTS TO CLEAN ADHESIVES FROM SKIN. TAKE APPROPRIATE
PRECAUTIONS WHEN HANDLING FLAMMABLE SOLVENTS. SOLVENTS MAY DAMAGE SURFACES
TO WHICH THEY ARE APPLIED.
LARGE SPILLS (UNCURED):
STOP THE FLOW OF MATERIAL, IF THIS IS WITHOUT RISK. DIKE FAR AHEAD OF SPILL
TO CONTAIN MATERIAL. USE A NON-COMBUSTIBLE MATERIAL LIKE VERMICULITE, SAND
OR EARTH TO SOAK UP THE PRODUCT. PLACE IN LEAK-PROOF CONTAINERS. SEAL
TIGHTLY FOR PROPER DISPOSAL. FOLLOWING PRODUCT RECOVERY, FLUSH AREA WITH
WATER.
CURED MATERIAL:
CHIP OR GRIND OFF SURFACE. THE PRODUCT CONTAINS COMPONENTS THAT ARE
CONSIDERED CARCINOGENIC IN RESPIRABLE FORM. IF YOU ARE GRINDING OR
CUTTING CURED PRODUCT, ENSURE GOOD WORK PRACTICE AND USE OF PERSONAL
PROTECTIVE EQUIPMENT AS NEEDED TO CONTROL EXPOSURE TO RESPIRABLE DUST.
ENVIRONMENTAL PRECAUTIONS:
AVOID RELEASE TO THE ENVIRONMENT. CONTACT LOCAL AUTHORITIES IN CASE OF
SPILLAGE TO DRAIN/AQUATIC ENVIRONMENT. PREVENT FURTHER LEAKAGE OR
SPILLAGE IF SAFE TO DO SO.
| 7. HANDLING AND STORAGE | |
HANDLING:
MECHANICAL VENTILATION OR LOCAL EXHAUST VENTILATION IS RECOMMENDED. KEEP
AWAY FROM OPEN FLAMES, HOT SURFACES AND SOURCES OF IGNITION. WEAR
APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT. WHEN USING, DO NOT EAT, DRINK
OR SMOKE. DO NOT INHALED DUST, MIST, OR VAPOR. AVOID CONTACT WITH EYES,
SKIN, AND CLOTHING. PREGNANT WOMEN SHOULD NOT WORK WITH THIS PRODUCT IF
THERE IS RISK OF EXPOSURE. WASH THOROUGHLY AFTER HANDLING. WASH
CONTAMINATED CLOTHING BEFORE REUSE. OBSERVE GOOD INDUSTRIAL HYGIENE
PRACTICES.
STORAGE:
FULL UNUSED CARTRIDGES:
STORE AWAY FROM INCOMPATIBLE MATERIALS (SEE SECTION 10 OF THE SDS). KEEP
IN ORIGINAL CONTAINER. KEEP CONTAINER TIGHTLY CLOSED. STORE IN A DRY,
WELL-VENTILATED PLACE OUT OF DIRECT SUNLIGHT BETWEEN 45-90 DEG. F
(7-32 DEG. C). KEEP AWAY FROM HEAT AND SOURCES OF IGNITION. PROTECT
CONTAINER FROM PHYSICAL DAMAGE. KEEP OUT OF REACH OF CHILDREN.
PARTIALLY USED CARTRIDGES:
TO STORE PARTIALLY USED CARTRIDGE, TEMPORARILY REPLACE CAP OR LEAVE
HARDENED NOZZLE IN PLACE. TO RE-USE, ATTACH NEW NOZZLE. DO NOT TRY TO
DISPENSE AFTER ADHESIVE HARDENS IN NOZZLE. CAUTION: ADHESIVE WILL START
TO GEL IN THE NOZZLE. ADHESIVE WILL GEL FASTER AT HIGHER TEMPERATURES.
MATERIAL UNDER PRESSURE CAN BLOWOUT THE BACK OF THE CARTRIDGE IF THE
ADHESIVE IN THE NOZZLE HARDENS. USE ONLY AN APPROPRIATE SIMPSON
STRONG-TIE(R*) MIXING NOZZLE IN ACCORDANCE WITH SIMPSON STRONG-TIE
INSTRUCTIONS. MODIFICATION OR IMPROPER USE OF MIXING NOZZLE MAY IMPAIR
ADHESIVE PERFORMANCE. KEEP OUT OF REACH OF CHILDREN.
| 8. EXPOSURE CONTROLS / PERSONAL PROTECTION | |
PERSONAL PROTECTIVE EQUIPMENT:
PROTECTIVE MEASURE: WEAR APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT.
EYE PROTECTION:
WEAR CHEMICAL SPLASH GOGGLES OR SAFETY GLASSES WITH SIDE SHIELD.
HAND PROTECTION:
WEAR CHEMICAL-RESISTANT GLOVES SUCH AS: NITRILE, NEOPRENE, BUTYL.
SKIN AND BODY PROTECTION:
WEAR LONG SLEEVE SHIRT/LONG PANTS AND OTHER CLOTHING AS REQUIRED
TO MINIMIZE CONTACT.
RESPIRATOR PROTECTION:
THE USE OF A RESPIRATOR IS NOT REQUIRED DURING NORMAL USE OF THIS PRODUCT.
IF GRINDING OR CUTTING CURED PRODUCT OR IF USING IN AN AREA WITHOUT PROPER
VENTILATION, THE USE OF AN APPROVED RESPIRATOR IS RECOMMENDED.
GENERAL HYGIENE:
ALWAYS OBSERVE GOOD PERSONAL HYGIENE MEASURES SUCH AS WASHING AFTER
HANDLING THE MATERIAL AND BEFORE EATING, DRINKING, AND/OR SMOKING.
ROUTINELY WASH WORK CLOTHING AND PROTECTIVE EQUIPMENT TO REMOVE
CONTAMINANTS.
ENGINEERING CONTROLS:
WHEN USING INDOORS GOOD GENERAL VENTILATION SHOULD BE USED. VENTILATION
RATES SHOULD BE MATCHED TO CONDITIONS. READY ACCESS TO RUNNING WATER IS
REQUIRED. PROVIDE EYEWASH STATION AND EMERGENCY SHOWER.
LIMITS:
COMPONENT OSHA (PEL) ACGIH (TLV) NIOSH POCKET GUIDE
QUARTZ 10/%SiO2+2 0.025 MG/M3 0.05 MG/M3
(CAS 14808-60-7) MG/M3 (RESPIRABLE) (RESPIRABLE)
PHENOL* 19 MG/M3 19 MG/M3 19 MG/M3
(CAS 108-95-2) 5 PPM 5 PPM 5 PPM
BENZENE-1,3- 0.1 MG/M3 0.1 MG/M3 0.1 MG/M3
DIMETHANEAMINE* (CEILING) (CEILING) (CEILING)
(CAS 1477-55-0)
BUTYL GLYCIDYL 270 MG/M3 3 PPM 30 MG/M3 (CEILING)
ETHER 50 PPM 5.6 PPM (CEILING)
(CAS 2426-08-6)
TITANIUM DIOXIDE 5 MG/M3 10 MG/M3 N/E
(CAS 13463-67-7) (RESPIRABLE)
15 MG/M3
(TOTAL DUST)
CARBON BLACK 3.5 MG/M3 3 MG/M3 0.1 MG/M3
(CAS 1333-86-4)
*SKIN DESIGNATION: MATERIAL CAN BE ABSORBED THROUGH SKIN.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
PROPERTY RESIN HARDENER
PHYSICAL STATE LIQUID, PASTE LIQUID, PASTE
COLOR WHITE DARK GREEN
ODOR SWEET AMMONIA
PH 6.9 10.3
FLAMMABILITY LIMIT - LOWER % NO DATA NO DATA
FLAMMABILITY LIMIT - UPPER % NO DATA NO DATA
VAPOR PRESSURE NON-VOLATILE NO DATA
VAPOR DENSITY NO DATA NO DATA
SOLUBILITY INSOLUBLE IN WATER SLIGHTLY SOLUBLE IN
WATER
FREEZING/MELTING POINT NO DATA NO DATA
BOILING POINT > 500 DEG. F NO DATA
(>260 DEG. C)
FLASH POINT 250 DEG. F 262 DEG. F
(121 DEG. C) (128 DEG. C)
OPEN CUP CLOSED CUP
EVAPORATION RATE NO DATA NO DATA
DECOMPOSITION TEMPERATURE NO DATA NO DATA
SPECIFIC GRAVITY 1.21 AT 72 DEG. F 1.59 AT 72 DEG. F
(22 DEG. C) (22 DEG. C)
VOC (AFTER CURE) 3 G/L 3 G/L
KOW NO DATA NO DATA
VISCOSITY NO DATA NO DATA
| 10. STABILITY AND REACTIVITY | |
RESIN (WHITE SIDE):
REACTIVITY:
THIS PRODUCT IS STABLE AND NON-REACTIVE UNDER NORMAL CONDITIONS.
CHEMICAL STABILITY: STABLE UNDER NORMAL STORAGE CONDITIONS.
CONDITION TO AVOID: HIGH HEAT AND OPEN FLAME.
SUBSTANCES TO AVOID: OXIDIZING AGENTS, ACIDS, ORGANIC BASES, AND AMINES
HAZARDOUS REACTIONS: HAZARDOUS POLYMERIZATION DOES NOT OCCUR.
DECOMPOSITION PRODUCTS:
CARBON DIOXIDE, CARBON MONOXIDE, OXIDES OF NITROGEN, AND OTHER ORGANIC
COMPOUNDS.
HARDENER (GREEN SIDE):
REACTIVITY:
THIS PRODUCT IS STABLE AND NON-REACTIVE UNDER NORMAL CONDITIONS.
CHEMICAL STABILITY: STABLE UNDER NORMAL STORAGE CONDITIONS.
CONDITION TO AVOID: HIGH HEAT AND OPEN FLAME.
SUBSTANCES TO AVOID:
STRONG OXIDIZING AGENTS, PEROXIDES, PHENOLS, AND ACIDS.
HAZARDOUS REACTIONS: HAZARDOUS POLYMERIZATION DOES NOT OCCUR.
DECOMPOSITION PRODUCTS:
CARBON DIOXIDE, CARBON MONOXIDE, OXIDES OF NITROGEN, AND OTHER ORGANIC
COMPOUNDS.
| 11. TOXICOLOGICAL INFORMATION | |
LIKELY ROUTES OF EXPOSURE:
INGESTION:
CORROSIVE MATERIAL; CAUSES SEVERE IRRITATION OR BURNS TO THE
GASTROINTESTINAL TRACT AND RESPIRATORY TRACT.
INHALATION:
PROLONGED INHALATION MAY CAUSE TEMPORARY RESPIRATORY IRRITATION.
SKIN CONTACT:
CAUSES SEVERE SKIN BURNS. MAY CAUSE AN ALLERGIC SKIN REACTION.
EYE CONTACT: CAUSES SEVERE EYE DAMAGE.
SYMPTOMS:
BURNS, REDNESS, ITCHING, TEARING, SWELLING, AND BLURRED VISION.
RASH/DERMATITIS. SEVERE IRRITATION OR BURNS TO THE GASTROINTESTINAL
TRACT AND RESPIRATORY SYSTEM.
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE EFFECTS:
TOXICITY: NOT EXPECTED TO BE ACUTELY TOXIC.
COMPONENT SPECIES TEST RESULT
SET-XP RESIN:
ACUTE, ORAL, LD50 RAT >5000
ACUTE, DERMAL, LD50 RABBIT >2000
SET-XP HARDENER:
ACUTE, ORAL, LD50 RAT >5000
ACUTE, DERMAL, LD50 RABBIT >2000
COMPONENT SPECIES TEST RESULT
BISPHENOL-A BASED EPOXY RESIN
(CAS 25068-38-6):
ACUTE, ORAL, LD50 RAT 11400 MG/KG
ACUTE, DERMAL, LD50 RABBIT 2000 MG/KG
BUTYL GLYCIDYL ETHER (CAS 2426-08-6):
ACUTE, ORAL, LD50 RAT 1660 MG/KG
ACUTE, DERMAL, LD50 RAT >2150 MG/KG
ACUTE, INHALATION, LC50 RAT >18.64 MG/L, 4 HOURS
TITANIUM DIOXIDE (CAS 13463-67-7):
ACUTE, ORAL, LD50 RAT >10000 MG/KG
ACUTE, INHALATION, LC50 RAT >6.82 MG/L
CRYSTALLINE SILICA, QUARTZ
(CAS 14808-60-7):
ACUTE, ORAL, LD50 RAT 22500 MG/KG
2,4,6-TRIS-(DIMETHYLAMINOMETHYL)PHENOL
(CAS 90-72-2):
ACUTE, ORAL, LD50 RAT 1200 MG/KG
ACUTE, DERMAL, LD50 RAT 1280 MG/KG
PHENOL (CAS 108-95-2):
ACUTE, ORAL, LD50 RAT 317 MG/KG
ACUTE, DERMAL, LD50 RABBIT 660 MG/KG
BENZENE-1,3-DIMETHANEAMINE
(CAS 1477-55-0):
ACUTE, ORAL, LD50 RAT 980 MG/KG
ACUTE, DERMAL, LD50 RABBIT 2000 MG/KG
ACUTE, INHALATION, LC50 RAT 700 PPM, 1 HOUR
TETRAETHYLENEPENTAMINE (CAS 112-57-2):
ACUTE, ORAL, LD50 RAT 3990 MG/KG
CARBON BLACK (CAS 1333-86-4):
ACUTE, ORAL, LD50 RAT >8000 MG/KG
SKIN CORROSION/IRRITATION: CAUSES SEVERE SKIN IRRITATION AND BURNS.
EYE DAMAGE/EYE IRRITATION: CAUSES SERIOUS EYE IRRITATION AND DAMAGE.
RESPIRATORY SENSITIZATION: NO DATA AVAILABLE.
SKIN SENSITIZATION: MAY CAUSE AN ALLERGIC SKIN REACTION.
ASPIRATION HAZARD:
DUE TO THE NATURE OF THIS PRODUCT, IT IS NOT EXPECTED TO BE AN ASPIRATION
HAZARD.
SPECIFIC TARGET ORGAN TOXICITY:
SINGLE EXPOSURE: NO DATA AVAILABLE.
CHRONIC EFFECTS:
GERM CELL MUTAGENICITY:
THIS PRODUCT CONTAINS COMPONENTS THAT ARE SUSPECTED OF CAUSING GENETIC
DEFECTS.
CARCINOGENICITY:
SUSPECTED OF CAUSING CANCER. THE PRODUCT ALSO CONTAINS COMPONENTS WHICH
ARE CONSIDERED CARCINOGENS ONLY IN THEIR RESPIRABLE FORM. DUE TO THE NATURE
OF THIS PRODUCT, EXPOSURE TO RESPIRABLE PARTICLES IS LIKELY ONLY WHEN
GRINDING OR CUTTING CURED PRODUCT. ENSURE GOOD WORK PRACTICE AND USE OF
PERSONAL PROTECTIVE EQUIPMENT AS NEEDED TO CONTROL EXPOSURE.
REPRODUCTIVE TOXICITY:
THE AVAILABLE DATA DOES NOT INDICATE THAT ANY INGREDIENTS OF THIS PRODUCT
ARE REPRODUCTIVE TOXINS.
SPECIFIC TARGET ORGAN TOXICITY:
REPEATED EXPOSURE:
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
CARCINOGEN / REPRODUCTIVE TOXIN / MUTAGEN INFORMATION:
COMPONENT % IN BLEND IARC NTP ACGIH OTHER
(APPROX.) MONOGRAPHS
QUARTZ 1 KNOWN A2 CA65
(CAS 14808-60-7)
TITANIUM DIOXIDE <5 2B CA65
(CAS 13463-67-7)
CARBON BLACK <1 2B CA65
(CAS 1333-86-4)
PHENOL 1 - 5 3 A4 IN VITRO TESTS
(CAS 108-95-2) SHOW LIMITED
MUTAGENIC
PROPERTIES IN
HUMAN CELLS
IARC:
1 - CARCINOGENIC
2 - POSSIBLY CARCINOGENIC
3 - NOT CLASSIFIABLE AS TO CARCINOGENICITY
4 - PROBABLY NOT CARCINOGENIC
NTP:
KNOWN TO BE HUMAN CARCINOGEN OR REASONABLY ANTICIPATED TO BE A HUMAN
CARCINOGEN
ACGIH:
A1 - CONFIRMED CARCINOGEN
A2 - SUSPECTED CARCINOGEN
A3 - ANIMAL CARCINOGEN
A4 - NOT CLASSIFIED
A5 - NOT SUSPECTED
CA65 - CALIFORNIA PROP 65
FURTHER INFORMATION:
TOXICOLOGICAL, ECOTOXICOLOGICAL, PHYSICAL, AND CHEMICAL PROPERTIES MAY NOT
HAVE BEEN FULLY INVESTIGATED. HAZARD DATA ABOVE IS ESTIMATED BASED ON BEST
AVAILABLE INFORMATION. SOME WORKERS WITH PRE-EXISTING MEDICAL CONDITIONS
SUCH AS:
ASTHMA, ALLERGIES, OR IMPAIRED PULMONARY AND/OR LIVER FUNCTIONS, OR WHO MAY
BE PARTICULARLY SUSCEPTIBLE TO THIS MATERIAL, MAY BE AFFECTED BY EXPOSURE
TO THIS MATERIAL.
| 12. ECOLOGICAL INFORMATION | |
GENERAL INFORMATION:
INFORMATION GIVEN IS BASED ON DATA ON THE COMPONENTS AND THE ECOTOXICOLOGY
OF SIMILAR PRODUCTS. SET-XP RESIN IS CLASSIFIED AS TOXIC TO AQUATIC LIFE
WITH LONG LASTING EFFECTS. SET-XP HARDENER IS NOT CLASSIFIED AS AN
ENVIRONMENTAL HAZARD. AVOID RELEASE TO THE ENVIRONMENT.
SUPPORTING DATA:
COMPONENT SPECIES TEST RESULT
SET-XP RESIN MIXTURE:
AQUATIC ACUTE, ALGAE, EC50 ALGAE >1000 MG/L, 72 HOURS
AQUATIC ACUTE, CRUSTACEA, EC50 DAPHNIA MAGNA 324.87 MG/L, 48 HOURS
AQUATIC ACUTE, FISH, LC50 FISH 707.11 MG/L, 96 HOURS
COMPONENT SPECIES TEST RESULT
BUTYL GLYCIDYL ETHER
(CAS 2426-08-6):
AQUATIC, CRUSTACEA, EC50 DAPHNIA MAGNA 3.9 MG/L, 48 HOURS
BISPHENOL-A BASED EPOXY RESIN
(CAS 25068-38-6):
AQUATIC, FISH, LC50 FISH 1.3 MG/L, 96 HOURS
AQUATIC, CRUSTACEA, EC50 DAPHNIA MAGNA 2.1 MG/L, 48 HOURS
AQUATIC, ALGAE, EC50 ALGAE > 11 MG/L, 72 HOURS
PHENOL (CAS 108-95-2):
AQUATIC, FISH, LC50 ASIATIC 8-8.25 MG/L, 96 HOURS
KNIFEFISH
AQUATIC, CRUSTACEA, EC50 DAPHNIA MAGNA 4.2 MG/L, 48 HOURS
AQUATIC, ALGAE, EC50 MACROALGAE 36 MG/L, 72 HOURS
BENZENE-1,3-DIMETHANEAMINE
(CAS 1477-55-0):
AQUATIC, ALGAE, EC50 ALGAE 12 MG/L, 72 HOURS
TETRAETHYLENEPENTAMINE
(CAS 112-57-2):
AQUATIC, FISH, LC50 POECILIA 420 MG/L, 96 HOURS
RETICULATE
AQUATIC, CRUSTACEA, EC50 DAPHNIA MAGNA 24 MG/L, 48 HOURS
PERSISTENCE AND DEGRADABILITY:
THIS PRODUCT IS NOT EXPECTED TO BE READILY BIODEGRADABLE.
BIOACCUMULATIVE POTENTIAL: NO DATA AVAILABLE FOR THIS PRODUCT.
CHEMICAL LOG KOW BCF BIOACCUMULATION
POTENTIAL
BUTYL GLYCIDYL ETHER (CAS 2426-08-6) 0.63 LOW
BPA EPOXY RESIN (CAS 25068-38-6) 2.64-3.78 3-31 LOW
PHENOLIC NOVOLAC RESIN 3 LOW
(CAS 28064-14-4)
PHENOL (CAS 108-95-2) 29.5 648 HIGH
TETRAETHYLENEPENTAMINE (CAS 112-57-2) 1.503
MOBILITY IN SOIL: THIS PRODUCT IS NON-VOLATILE.
FURTHER INFORMATION:
NO OTHER ADVERSE ENVIRONMENTAL EFFECTS (E.G. OZONE DEPLETION, PHOTOCHEMICAL
OZONE CREATION POTENTIAL, ENDOCRINE DISRUPTION, GLOBAL WARMING POTENTIAL)
ARE EXPECTED FROM THIS PRODUCT.
| 13. DISPOSAL CONSIDERATION | |
WASTE DISPOSAL OF SUBSTANCE:
DO NOT ALLOW THIS MATERIAL TO DRAIN INTO SEWERS/WATER SUPPLIES. DO NOT
CONTAMINATE PONDS, WATERWAYS OR DITCHES WITH CHEMICAL OR USED CONTAINER.
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH LOCAL/REGIONAL/NATIONAL
REGULATIONS.
CONTAINER DISPOSAL:
EMPTY CONTAINERS OR LINERS MAY RETAIN SOME PRODUCT RESIDUES; FOLLOW LABEL
WARNINGS EVEN AFTER CONTAINER IS EMPTIED. EMPTY CONTAINERS SHOULD BE TAKEN
TO AN APPROVED WASTE HANDLING SITE FOR RECYCLING OR DISPOSAL.
DISPOSAL OF CURED PRODUCT:
CHIP OR GRIND OFF SURFACE. SOLID MATERIAL DOES NOT NEED SPECIAL DISPOSAL
CONSIDERATION.
| 14. TRANSPORTATION INFORMATION | |
CHECK LIMITED QUANTITY REGULATIONS PRIOR TO SHIPPING. SET-XP CARTRIDGES MAY
QUALIFY FOR LQ SHIPPING EXEMPTIONS.
RESIN (WHITE SIDE) HARDENER (GREEN SIDE)
UN NUMBER UN3082 UN2735
UN PROPER SHIPPING NAME ENVIRONMENTALLY AMINES, LIQUID,
HAZARDOUS SUBSTANCE, CORROSIVE, N.O.S.
LIQUID, N.O.S. (BENZENE-1,3-
(BISPHENOL-A- DIMETHANEAMINE), 8, II
EPICHLOROHYDRIN), 9,
III, MARINE POLLUTANT
PRECAUTIONS MARINE POLLUTANT CORROSIVE
REQUIRED LABELS 9 8
ERG CODE (IATA) 9L 8L
EMS (IMDG) F-A, S-F F-A, S-B
ADDITIONAL INFORMATION:
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
TRANSPORT IN BULK ACCORDING TO ANNEX II OF MARPOL 73/78 AND THE IBC CODE:
THIS SUBSTANCE/MIXTURE IS NOT INTENDED TO BE TRANSPORTED IN BULK
THIS INFORMATION DOES NOT COVER ALL SPECIFIC REGULATORY OR OPERATIONAL
REQUIREMENTS OF THIS PRODUCT. THE CLASSIFICATIONS FOR TRANSPORTATION MAY
VARY BY CONTAINER VOLUME OR DIFFERENT REGIONAL OR NATIONAL REGULATIONS.
| 15. REGULATORY INFORMATION | |
UNITED STATES:
FEDERAL REGULATIONS:
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
TSCA SECTION 12(B) EXPORT NOTIFICATION (40 CFR 707, SUBPT. D):
NOT REGULATED.
US. OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1050):
NOT LISTED.
CERCLA HAZARDOUS SUBSTANCE LIST (40 CFR 302.4):
1-BUTANOL (CAS 71-36-3) LISTED
PHENOL (CAS 108-95-2) LISTED
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA):
HAZARD CATEGORIES IMMEDIATE DELAYED FIRE PRESSURE REACTIVITY
RESIN YES YES NO NO NO
HARDENER YES YES NO NO NO
SARA 302 EXTREMELY HAZARDOUS SUBSTANCE:
COMPONENT CAS REPORTABLE THRESHOLD PLANNING THRESHOLD PLANNING
QUANT. QUANT. LOWER VALUE QUANT. UPPER VALUE
PHENOL 108-95-2 1000 500 LBS 10000 LBS
SARA 311/312 HAZARDOUS CHEMICAL: YES
SARA 313 (TRI REPORTING):
CHEMICAL NAME CAS NUMBER % IN BLEND (APPROX.)
1-BUTANOL 71-36-3 < 0.1
PHENOL 108-95-2 1-5
ALUMINUM OXIDE 1344-28-1 < 1
US. CALIFORNIA PROPOSITION 65:
WARNING:
THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER, BIRTH DEFECTS, OR REPRODUCTIVE HARM.
CARCINOGEN / REPRODUCTIVE TOXIN / MUTAGEN INFORMATION:
COMPONENT % IN BLEND IARC NTP ACGIH OTHER
(APPROX.) MONOGRAPHS
QUARTZ 20 - 40 1 KNOWN A2 CA65
(CAS 14808-60-7) (CARCINOGENIC)
TITANIUM DIOXIDE <5 2B CA65
(CAS 13463-67-7) (CARCINOGENIC)
CARBON BLACK <1 2B CA65
(CAS 1333-86-4) (CARCINOGENIC)
IARC:
1 - CARCINOGENIC
2 - POSSIBLY CARCINOGENIC
3 - NOT CLASSIFIABLE AS TO CARCINOGENICITY
4 - PROBABLY NOT CARCINOGENIC
NTP:
KNOWN TO BE HUMAN CARCINOGEN OR REASONABLY ANTICIPATED TO BE A HUMAN
CARCINOGEN
ACGIH:
A1 - CONFIRMED CARCINOGEN
A2 - SUSPECTED CARCINOGEN
A3 - ANIMAL CARCINOGEN
A4 - NOT CLASSIFIED
A5 - NOT SUSPECTED
CA65 - CALIFORNIA PROP 65
US STATE RIGHT-TO-KNOW LISTS:
CHEMICAL MASSACHUSETTS NEW JERSEY WORK PENNSYLVANIA
RTK AND COMMUNITY WORKER AND
RTK ACT COMMUNITY RTK
LAW
BUTYL GLYCIDYL ETHER LISTED LISTED LISTED
(CAS 2426-08-6)
TITANIUM DIOXIDE LISTED LISTED LISTED
(CAS 13463-67-7)
CARBON BLACK LISTED LISTED LISTED
(CAS 1333-86-4)
PHENOL LISTED LISTED LISTED
(CAS 108-95-2)
BENZENE-1,3- LISTED LISTED LISTED
DIMETHANEAMINE
(CAS 1477-55-0)
TETRAETHYLENEPENTAMINE LISTED LISTED LISTED
(CAS 112-57-2)
QUARTZ LISTED LISTED LISTED
(CAS 14808-60-7)
CHEMICAL RHODE ISLAND RTK MAINE CHC
BUTYL GLYCIDYL ETHER LISTED
TITANIUM DIOXIDE
CARBON BLACK LISTED
PHENOL LISTED
BENZENE-1,3-DIMETHANEAMINE
TETRAETHYLENEPENTAMINE
QUARTZ LISTED
CANADA:
THIS PRODUCT HAS BEEN CLASSIFIED ACCORDING TO THE HAZARD CRITERIA OF THE
HPR AND THE SDS CONTAINS ALL OF THE INFORMATION REQUIRED BY THE HPR.
INTERNATIONAL:
THE PRODUCT IS CLASSIFIED IN ACCORDANCE WITH EC DIRECTIVES OR RESPECTIVE
NATIONAL LAWS. THIS SAFETY DATA SHEET COMPLIES WITH THE REQUIREMENTS OF
REGULATION (EC) NO 1907/2006.
REACH REGISTERED SUBSTANCES:
CHEMICAL CAS NUMBER EC NUMBER INDEX NUMBER
BISPHENOL-A BASED EPOXY RESIN 25068-38-6 500-033-5 603-074-00-8
BUTYL GLYCIDYL ETHER 2426-08-6 219-376-4 603-039-00-7
PHENOL 108-95-2 203-632-7 604-001-00-2
TETRAETHYLENEPENTAMINE 112-57-2 203-986-2 612-060-00-0
2,4,6-TRIS- 90-72-2 202-013-0-9 603-069-00-0
(DIMETHYLAMINOMETHYL)PHENOL
THIS PRODUCT IS NOT SUBJECT TO OR NOT APPLICABLE FOR ANY OF THE FOLLOWING
INTERNATIONAL REGULATIONS; STOCKHOLM CONVENTION, ROTTERDAM CONVENTION,
KYOTO PROTOCOL, MONTREAL PROTOCOL, BASEL CONVENTION.
INTERNATIONAL INVENTORIES:
AUSTRALIA:
ONE OR MORE COMPONENTS OF THIS PRODUCT ARE NOT LISTED ON THE AUSTRALIAN
INVENTORY OF CHEMICAL SUBSTANCES (AICS).
CANADA:
ALL COMPONENTS OF THIS PRODUCT ARE INCLUDED ON THE DOMESTIC SUBSTANCES
LIST (DSL).
CHINA:
ONE OR MORE COMPONENTS OF THIS PRODUCT ARE NOT LISTED ON THE INVENTORY OF
EXISTING CHEMICAL SUBSTANCES IN CHINA (IECSC).
EUROPE:
ONE OR MORE COMPONENTS OF THIS PRODUCT ARE NOT INCLUDED ON THE EUROPEAN
INVENTORY OF EXISTING COMMERCIAL CHEMICAL SUBSTANCES (EINECS) OR ARE NOT
EXEMPT FROM LISTING.
JAPAN:
ONE OR MORE COMPONENTS OF THIS PRODUCT ARE NOT LISTED ON THE INVENTORY OF
EXISTING AND NEW CHEMICAL SUBSTANCES (ENCS).
KOREA:
ALL COMPONENTS OF THIS PRODUCT ARE INCLUDED ON THE EXISTING CHEMICALS
LIST (ECL).
NEW ZEALAND:
ONE OR MORE COMPONENTS OF THIS PRODUCT HAVE AN UNKNOWN STATUS ON THE NEW
ZEALAND INVENTORY. CONTACT SIMPSON STRONG-TIE ENVIRONMENTAL HEALTH AND
SAFETY IF THE STATUS OF THIS PRODUCT ON THE INVENTORY IS DESIRED.
PHILIPPINES:
ONE OR MORE COMPONENTS IN THIS PRODUCT ARE NOT LISTED IN THE PHILIPPINE
INVENTORY OF CHEMICALS AND CHEMICAL SUBSTANCES (PICCS).
UNITED STATES & PUERTO RICO:
ALL COMPONENTS OF THIS PRODUCT ARE LISTED ON THE TOXIC SUBSTANCES CONTROL
ACT (TSCA) INVENTORY OR ARE NOT REQUIRED TO BE LISTED.
| 16. OTHER INFORMATION | |
DATE PREPARED OR REVISED: SEPTEMBER 2016
SUPERSEDES: DECEMBER 2014
CONTACT SIMPSON STRONG-TIE ENVIRONMENTAL HEALTH AND SAFETY AT
EHS@STRONGTIE.COM
ADDITIONAL RESIN (WHITE SIDE) CLASSIFICATIONS:
NFPA RATINGS:
2
1
0
HMIS RATING:
HEALTH 2
FLAMMABILITY 1
PHYSICAL 0
PPE B
ADDITIONAL HARDENER (GREEN SIDE) CLASSIFICATIONS:
NFPA RATINGS:
3
1
0
HMIS RATING:
HEALTH 3
FLAMMABILITY 1
PHYSICAL 0
PPE B
ABBREVIATIONS:
ACGIH: AMERICAN CONFERENCE OF GOVERNMENTAL INDUSTRIAL HYGIENISTS
CAS NO.: CHEMICAL ABSTRACT SERVICE REGISTRY NUMBER
CERCLA:
COMPREHENSIVE ENVIRONMENTAL RESPONSE, COMPENSATION AND LIABILITY ACT
(U.S. EPA)
HPR: HAZARDOUS PRODUCT REGULATIONS (CANADA)
DOT: DEPARTMENT OF TRANSPORTATION (U.S.)
GHS: GLOBALLY HARMONIZED SYSTEM OF CLASSIFICATION AND LABELING OF CHEMICALS
HMIS: HAZARDOUS MATERIALS IDENTIFICATION SYSTEM
IARC: INTERNATIONAL AGENCY FOR RESEARCH ON CANCER
IATA: INTERNATIONAL AIR TRANSPORT ASSOCIATION
IMDG: INTERNATIONAL MARITIME DANGEROUS GOODS CODE
NIOSH: NATIONAL INSTITUTE OF OCCUPATIONAL SAFETY AND HEALTH (U.S.)
NFPA: NATIONAL FIRE PROTECTION ASSOCIATION (US)
NTP: NATIONAL TOXICOLOGY PROGRAM (US)
OSHA: OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION (U.S.)
PEL: PERMISSIBLE EXPOSURE LIMIT
SARA: SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT (U.S. EPA)
STEL: SHORT TERM EXPOSURE LIMIT (15 MINUTE TIME WEIGHTED AVERAGE)
STOT: SPECIFIC TARGET ORGAN TOXICITY (GHS CLASSIFICATION)
TLV: THRESHOLD LIMIT VALUE
TSCA: TOXIC SUBSTANCES CONTROL ACT (U.S.)
TWA: TIME WEIGHTED AVERAGE (EXPOSURE FOR 8-HOUR WORKDAY)
VOC: VOLATILE ORGANIC COMPOUNDS
WHMIS: CANADIAN WORKPLACE HAZARDOUS MATERIALS INFORMATION SYSTEM
FULL TEXT OF H - PHRASES UNDER SECTION 3:
H226: FLAMMABLE LIQUID AND VAPOR.
H301: TOXIC IF SWALLOWED.
H302: HARMFUL IF SWALLOWED.
H311: TOXIC IN CONTACT WITH SKIN.
H312: HARMFUL IN CONTACT WITH SKIN.
H314: CAUSES SEVERE SKIN BURNS AND EYE DAMAGE.
H315: CAUSES SKIN IRRITATION.
H317: MAY CAUSE AN ALLERGIC SKIN REACTION.
H318: CAUSES SERIOUS EYE DAMAGE.
H319: CAUSES SERIOUS EYE IRRITATION.
H331: TOXIC IF INHALED.
H332: HARMFUL IF INHALED.
H335: MAY CAUSE RESPIRATORY IRRITATION.
H341: SUSPECTED OF CAUSING GENETIC DEFECTS.
H350: MAY CAUSE CANCER.
H351: SUSPECTED OF CAUSING CANCER.
H372: CAUSES DAMAGE TO ORGANS THROUGH PROLONGED AND REPEATED EXPOSURE.
H373: MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED AND REPEATED EXPOSURE.
H402: HARMFUL TO AQUATIC LIFE.
H411: TOXIC TO AQUATIC LIFE WITH LONG LASTING EFFECTS.
H412: HARMFUL TO AQUATIC LIFE WITH LONG LASTING EFFECTS.
DISCLAIMER:
THIS SAFETY DATA SHEET (SDS) IS PREPARED BY SIMPSON STRONG-TIE CO. IN
COMPLIANCE WITH THE REQUIREMENTS OF OSHA 29 CFR PART 1910.1200. THE
INFORMATION IT CONTAINS IS OFFERED IN GOOD FAITH AS ACCURATE AS OF THE
DATE OF THIS SDS. THIS SDS IS PROVIDED SOLELY FOR THE PURPOSE OF CONVEYING
HEALTH, SAFETY, AND ENVIRONMENTAL INFORMATION. NO WARRANTY, EXPRESSED OR
IMPLIED, IS GIVEN. HEALTH AND SAFETY PRECAUTIONS MAY NOT BE ADEQUATE FOR
ALL INDIVIDUALS AND/OR SITUATIONS. IT IS THE USER'S OBLIGATION TO EVALUATE
AND USE THIS PRODUCT SAFELY AND TO COMPLY WITH ALL APPLICABLE LAWS AND
REGULATIONS.
(C) 2016 SIMPSON STRONG-TIE COMPANY INC.
INTERNAL:
FOR INTERNAL USE ONLY:
SET-XP RESIN: XCOM3B - 50% CARTRIDGE
SET-XP HARDENER:
XCOM3B - 50% CARTRIDGE
XCORR - 50% CARTRIDGE