| Common Name: | NONFLAMMABLE GAS MIXTURE, 002218 |
| Manufacturer: | AIRGAS |
| SDS Revision Date: | 6/24/2016 |
| SDS Format: | No Format Specified |
| Item Number(s): | 32UU75, 32UU76 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
AIRGAS(R*)
AN AIR LIQUIDE COMPANY
SAFETY DATA SHEET
NONFLAMMABLE GAS MIXTURE: NITROGEN 99% / SULFUR DIOXIDE 1PPB-9999PPM
| SECTION 1. IDENTIFICATION |  |
GHS PRODUCT IDENTIFIER:
NONFLAMMABLE GAS MIXTURE: NITROGEN 99% / SULFUR DIOXIDE 1PPB-9999PPM
OTHER MEANS OF IDENTIFICATION: NOT AVAILABLE.
PRODUCT USE: SYNTHETIC/ANALYTICAL CHEMISTRY.
SDS #: 002218
SUPPLIER'S DETAILS:
AIRGAS USA, LLC AND ITS AFFILIATES
259 NORTH RADNOR-CHESTER ROAD
SUITE 100
RADNOR, PA 19087-5283
1-610-687-5253
24-HOUR TELEPHONE: 1-866-734-3438
| SECTION 2. HAZARDS IDENTIFICATION | |
OSHA/HCS STATUS:
THIS MATERIAL IS CONSIDERED HAZARDOUS BY THE OSHA HAZARD COMMUNICATION
STANDARD (29 CFR 1910.1200).
CLASSIFICATION OF THE SUBSTANCE OR MIXTURE:
GASES UNDER PRESSURE - COMPRESSED GAS
GHS LABEL ELEMENTS:
HAZARD PICTOGRAMS: GAS CYLINDER
SIGNAL WORD: WARNING
HAZARD STATEMENTS:
CONTAINS GAS UNDER PRESSURE; MAY EXPLODE IF HEATED.
MAY DISPLACE OXYGEN AND CAUSE RAPID SUFFOCATION.
PRECAUTIONARY STATEMENTS:
GENERAL:
READ AND FOLLOW ALL SAFETY DATA SHEETS (SDS'S) BEFORE USE. READ LABEL
BEFORE USE. KEEP OUT OF REACH OF CHILDREN. IF MEDICAL ADVICE IS NEEDED,
HAVE PRODUCT CONTAINER OR LABEL AT HAND. CLOSE VALVE AFTER EACH USE AND
WHEN EMPTY. USE EQUIPMENT RATED FOR CYLINDER PRESSURE. DO NOT OPEN VALVE
UNTIL CONNECTED TO EQUIPMENT PREPARED FOR USE. USE A BACK FLOW PREVENTATIVE
DEVICE IN THE PIPING. USE ONLY EQUIPMENT OF COMPATIBLE MATERIALS OF
CONSTRUCTION.
PREVENTION: NOT APPLICABLE.
RESPONSE: NOT APPLICABLE.
STORAGE:
PROTECT FROM SUNLIGHT WHEN AMBIENT TEMPERATURE EXCEEDS 52 DEG. C/125 DEG.
F. STORE IN A WELL-VENTILATED PLACE.
DISPOSAL: NOT APPLICABLE.
HAZARDS NOT OTHERWISE CLASSIFIED:
IN ADDITION TO ANY OTHER IMPORTANT HEALTH OR PHYSICAL HAZARDS, THIS PRODUCT
MAY DISPLACE OXYGEN AND CAUSE RAPID SUFFOCATION.
| SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
SUBSTANCE/MIXTURE: MIXTURE
OTHER MEANS OF IDENTIFICATION: NOT AVAILABLE.
CAS NUMBER/OTHER IDENTIFIERS:
CAS NUMBER: NOT APPLICABLE.
PRODUCT CODE: 002218
INGREDIENT NAME % CAS NUMBER
NITROGEN 99 7727-37-9
SULPHUR DIOXIDE 0.0000001 - 0.9999 7446-09-5
ANY CONCENTRATION SHOWN AS A RANGE IS TO PROTECT CONFIDENTIALITY OR IS DUE
TO BATCH VARIATION.
THERE ARE NO ADDITIONAL INGREDIENTS PRESENT WHICH, WITHIN THE CURRENT
KNOWLEDGE OF THE SUPPLIER AND IN THE CONCENTRATIONS APPLICABLE, ARE
CLASSIFIED AS HAZARDOUS TO HEALTH OR THE ENVIRONMENT AND HENCE REQUIRE
REPORTING IN THIS SECTION.
OCCUPATIONAL EXPOSURE LIMITS, IF AVAILABLE, ARE LISTED IN SECTION 8.
| SECTION 4. FIRST AID MEASURES | |
DESCRIPTION OF NECESSARY FIRST AID MEASURES:
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER, OCCASIONALLY LIFTING THE UPPER
AND LOWER EYELIDS. CHECK FOR AND REMOVE ANY CONTACT LENSES. CONTINUE TO
RINSE FOR AT LEAST 10 MINUTES. GET MEDICAL ATTENTION IF IRRITATION OCCURS.
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. IF NOT BREATHING, IF BREATHING IS IRREGULAR OR IF RESPIRATORY
ARREST OCCURS, PROVIDE ARTIFICIAL RESPIRATION OR OXYGEN BY TRAINED
PERSONNEL. IT MAY BE DANGEROUS TO THE PERSON PROVIDING AID TO GIVE
MOUTH-TO-MOUTH RESUSCITATION. GET MEDICAL ATTENTION IF ADVERSE HEALTH
EFFECTS PERSIST OR ARE SEVERE. IF UNCONSCIOUS, PLACE IN RECOVERY POSITION
AND GET MEDICAL ATTENTION IMMEDIATELY. MAINTAIN AN OPEN AIRWAY. LOOSEN
TIGHT CLOTHING SUCH AS A COLLAR, TIE, BELT OR WAISTBAND. IN CASE OF
INHALATION OF DECOMPOSITION PRODUCTS IN A FIRE, SYMPTOMS MAY BE DELAYED.
THE EXPOSED PERSON MAY NEED TO BE KEPT UNDER MEDICAL SURVEILLANCE FOR 48
HOURS.
SKIN CONTACT:
FLUSH CONTAMINATED SKIN WITH PLENTY OF WATER. REMOVE CONTAMINATED CLOTHING
AND SHOES. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. WASH CLOTHING BEFORE
REUSE. CLEAN SHOES THOROUGHLY BEFORE REUSE.
INGESTION: AS THIS PRODUCT IS A GAS, REFER TO THE INHALATION SECTION.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
POTENTIAL ACUTE HEALTH EFFECTS:
EYE CONTACT:
CONTACT WITH RAPIDLY EXPANDING GAS MAY CAUSE BURNS OR FROSTBITE.
INHALATION: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
SKIN CONTACT:
CONTACT WITH RAPIDLY EXPANDING GAS MAY CAUSE BURNS OR FROSTBITE.
FROSTBITE: TRY TO WARM UP THE FROZEN TISSUES AND SEEK MEDICAL ATTENTION.
INGESTION: AS THIS PRODUCT IS A GAS, REFER TO THE INHALATION SECTION.
OVER-EXPOSURE SIGNS/SYMPTOMS:
EYE CONTACT: NO SPECIFIC DATA.
INHALATION: NO SPECIFIC DATA.
SKIN CONTACT: NO SPECIFIC DATA.
INGESTION: NO SPECIFIC DATA.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED, IF
NECESSARY:
NOTES TO PHYSICIAN:
IN CASE OF INHALATION OF DECOMPOSITION PRODUCTS IN A FIRE, SYMPTOMS MAY BE
DELAYED. THE EXPOSED PERSON MAY NEED TO BE KEPT UNDER MEDICAL SURVEILLANCE
FOR 48 HOURS.
SPECIFIC TREATMENTS: NO SPECIFIC TREATMENT.
PROTECTION OF FIRST-AIDERS:
NO ACTION SHALL BE TAKEN INVOLVING ANY PERSONAL RISK OR WITHOUT SUITABLE
TRAINING. IT MAY BE DANGEROUS TO THE PERSON PROVIDING AID TO GIVE
MOUTH-TO-MOUTH RESUSCITATION.
SEE TOXICOLOGICAL INFORMATION (SECTION 11)
| SECTION 5. FIRE-FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
SUITABLE EXTINGUISHING MEDIA:
USE AN EXTINGUISHING AGENT SUITABLE FOR THE SURROUNDING FIRE.
UNSUITABLE EXTINGUISHING MEDIA: NONE KNOWN.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
CONTAINS GAS UNDER PRESSURE. IN A FIRE OR IF HEATED, A PRESSURE INCREASE
WILL OCCUR AND THE CONTAINER MAY BURST OR EXPLODE.
HAZARDOUS THERMAL DECOMPOSITION PRODUCTS:
DECOMPOSITION PRODUCTS MAY INCLUDE THE FOLLOWING MATERIALS:
NITROGEN OXIDES
SPECIAL PROTECTIVE ACTIONS FOR FIRE-FIGHTERS:
PROMPTLY ISOLATE THE SCENE BY REMOVING ALL PERSONS FROM THE VICINITY OF THE
INCIDENT IF THERE IS A FIRE. NO ACTION SHALL BE TAKEN INVOLVING ANY
PERSONAL RISK OR WITHOUT SUITABLE TRAINING. CONTACT SUPPLIER IMMEDIATELY
FOR SPECIALIST ADVICE. MOVE CONTAINERS FROM FIRE AREA IF THIS CAN BE DONE
WITHOUT RISK. USE WATER SPRAY TO KEEP FIRE-EXPOSED CONTAINERS COOL.
SPECIAL PROTECTIVE EQUIPMENT FOR FIRE-FIGHTERS:
FIRE-FIGHTERS SHOULD WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND
SELF-CONTAINED BREATHING APPARATUS (SCBA) WITH A FULL FACE-PIECE OPERATED
IN POSITIVE PRESSURE MODE.
| SECTION 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
FOR NON-EMERGENCY PERSONNEL:
NO ACTION SHALL BE TAKEN INVOLVING ANY PERSONAL RISK OR WITHOUT SUITABLE
TRAINING. EVACUATE SURROUNDING AREAS. KEEP UNNECESSARY AND UNPROTECTED
PERSONNEL FROM ENTERING. AVOID BREATHING GAS. PROVIDE ADEQUATE VENTILATION.
WEAR APPROPRIATE RESPIRATOR WHEN VENTILATION IS INADEQUATE. PUT ON
APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT.
FOR EMERGENCY RESPONDERS:
IF SPECIALIZED CLOTHING IS REQUIRED TO DEAL WITH THE SPILLAGE, TAKE NOTE OF
ANY INFORMATION IN SECTION 8 ON SUITABLE AND UNSUITABLE MATERIALS. SEE ALSO
THE INFORMATION IN "FOR NON-EMERGENCY PERSONNEL".
ENVIRONMENTAL PRECAUTIONS:
ENSURE EMERGENCY PROCEDURES TO DEAL WITH ACCIDENTAL GAS RELEASES ARE IN
PLACE TO AVOID CONTAMINATION OF THE ENVIRONMENT. INFORM THE RELEVANT
AUTHORITIES IF THE PRODUCT HAS CAUSED ENVIRONMENTAL POLLUTION (SEWERS,
WATERWAYS, SOIL OR AIR).
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
SMALL SPILL:
IMMEDIATELY CONTACT EMERGENCY PERSONNEL. STOP LEAK IF WITHOUT RISK.
LARGE SPILL:
IMMEDIATELY CONTACT EMERGENCY PERSONNEL. STOP LEAK IF WITHOUT RISK.
NOTE:
SEE SECTION 1 FOR EMERGENCY CONTACT INFORMATION AND SECTION 13 FOR WASTE
DISPOSAL.
| SECTION 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
PROTECTIVE MEASURES:
PUT ON APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT (SEE SECTION 8). CONTAINS
GAS UNDER PRESSURE. AVOID CONTACT WITH EYES, SKIN AND CLOTHING. AVOID
BREATHING GAS. EMPTY CONTAINERS RETAIN PRODUCT RESIDUE AND CAN BE
HAZARDOUS. DO NOT PUNCTURE OR INCINERATE CONTAINER. USE EQUIPMENT RATED FOR
CYLINDER PRESSURE. CLOSE VALVE AFTER EACH USE AND WHEN EMPTY. PROTECT
CYLINDERS FROM PHYSICAL DAMAGE; DO NOT DRAG, ROLL, SLIDE, OR DROP. USE A
SUITABLE HAND TRUCK FOR CYLINDER MOVEMENT.
ADVICE ON GENERAL OCCUPATIONAL HYGIENE:
EATING, DRINKING AND SMOKING SHOULD BE PROHIBITED IN AREAS WHERE THIS
MATERIAL IS HANDLED, STORED AND PROCESSED. WORKERS SHOULD WASH HANDS AND
FACE BEFORE EATING, DRINKING AND SMOKING. REMOVE CONTAMINATED CLOTHING AND
PROTECTIVE EQUIPMENT BEFORE ENTERING EATING AREAS. SEE ALSO SECTION 8 FOR
ADDITIONAL INFORMATION ON HYGIENE MEASURES.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
STORE IN ACCORDANCE WITH LOCAL REGULATIONS. STORE IN A SEGREGATED AND
APPROVED AREA. STORE AWAY FROM DIRECT SUNLIGHT IN A DRY, COOL AND
WELL-VENTILATED AREA, AWAY FROM INCOMPATIBLE MATERIALS (SEE SECTION 10).
KEEP CONTAINER TIGHTLY CLOSED AND SEALED UNTIL READY FOR USE. CYLINDERS
SHOULD BE STORED UPRIGHT, WITH VALVE PROTECTION CAP IN PLACE, AND FIRMLY
SECURED TO PREVENT FALLING OR BEING KNOCKED OVER. CYLINDER TEMPERATURES
SHOULD NOT EXCEED 52 DEG. C (125 DEG. F).
| SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
CONTROL PARAMETERS:
OCCUPATIONAL EXPOSURE LIMITS:
NITROGEN OXYGEN DEPLETION [ASPHYXIANT]
SULPHUR DIOXIDE ACGIH TLV (UNITED STATES, 3/2015).
STEL: 0.25 PPM 15 MINUTES.
OSHA PEL 1989 (UNITED STATES, 3/1989).
TWA: 2 PPM 8 HOURS.
TWA: 5 MG/M3 8 HOURS.
STEL: 5 PPM 15 MINUTES.
STEL: 10 MG/M3 15 MINUTES.
NIOSH REL (UNITED STATES, 10/2013).
TWA: 2 PPM 10 HOURS.
TWA: 5 MG/M3 10 HOURS.
STEL: 5 PPM 15 MINUTES.
STEL: 13 MG/M3 15 MINUTES.
OSHA PEL (UNITED STATES, 2/2013).
TWA: 5 PPM 8 HOURS.
TWA: 13 MG/M3 8 HOURS.
APPROPRIATE ENGINEERING CONTROLS:
GOOD GENERAL VENTILATION SHOULD BE SUFFICIENT TO CONTROL WORKER EXPOSURE TO
AIRBORNE CONTAMINANTS.
ENVIRONMENTAL EXPOSURE CONTROLS:
EMISSIONS FROM VENTILATION OR WORK PROCESS EQUIPMENT SHOULD BE CHECKED TO
ENSURE THEY COMPLY WITH THE REQUIREMENTS OF ENVIRONMENTAL PROTECTION
LEGISLATION. IN SOME CASES, FUME SCRUBBERS, FILTERS OR ENGINEERING
MODIFICATIONS TO THE PROCESS EQUIPMENT WILL BE NECESSARY TO REDUCE
EMISSIONS TO ACCEPTABLE LEVELS.
INDIVIDUAL PROTECTION MEASURES:
HYGIENE MEASURES:
WASH HANDS, FOREARMS AND FACE THOROUGHLY AFTER HANDLING CHEMICAL PRODUCTS,
BEFORE EATING, SMOKING AND USING THE LAVATORY AND AT THE END OF THE WORKING
PERIOD. APPROPRIATE TECHNIQUES SHOULD BE USED TO REMOVE POTENTIALLY
CONTAMINATED CLOTHING. WASH CONTAMINATED CLOTHING BEFORE REUSING. ENSURE
THAT EYEWASH STATIONS AND SAFETY SHOWERS ARE CLOSE TO THE WORKSTATION
LOCATION.
EYE/FACE PROTECTION:
SAFETY EYEWEAR COMPLYING WITH AN APPROVED STANDARD SHOULD BE USED WHEN A
RISK ASSESSMENT INDICATES THIS IS NECESSARY TO AVOID EXPOSURE TO LIQUID
SPLASHES, MISTS, GASES OR DUSTS. IF CONTACT IS POSSIBLE, THE FOLLOWING
PROTECTION SHOULD BE WORN, UNLESS THE ASSESSMENT INDICATES A HIGHER DEGREE
OF PROTECTION: SAFETY GLASSES WITH SIDE- SHIELDS.
SKIN PROTECTION:
HAND PROTECTION:
CHEMICAL-RESISTANT, IMPERVIOUS GLOVES COMPLYING WITH AN APPROVED STANDARD
SHOULD BE WORN AT ALL TIMES WHEN HANDLING CHEMICAL PRODUCTS IF A RISK
ASSESSMENT INDICATES THIS IS NECESSARY. CONSIDERING THE PARAMETERS
SPECIFIED BY THE GLOVE MANUFACTURER, CHECK DURING USE THAT THE GLOVES ARE
STILL RETAINING THEIR PROTECTIVE PROPERTIES. IT SHOULD BE NOTED THAT THE
TIME TO BREAKTHROUGH FOR ANY GLOVE MATERIAL MAY BE DIFFERENT FOR DIFFERENT
GLOVE MANUFACTURERS. IN THE CASE OF MIXTURES, CONSISTING OF SEVERAL
SUBSTANCES, THE PROTECTION TIME OF THE GLOVES CANNOT BE ACCURATELY
ESTIMATED.
BODY PROTECTION:
PERSONAL PROTECTIVE EQUIPMENT FOR THE BODY SHOULD BE SELECTED BASED ON THE
TASK BEING PERFORMED AND THE RISKS INVOLVED AND SHOULD BE APPROVED BY A
SPECIALIST BEFORE HANDLING THIS PRODUCT.
OTHER SKIN PROTECTION:
APPROPRIATE FOOTWEAR AND ANY ADDITIONAL SKIN PROTECTION MEASURES SHOULD BE
SELECTED BASED ON THE TASK BEING PERFORMED AND THE RISKS INVOLVED AND
SHOULD BE APPROVED BY A SPECIALIST BEFORE HANDLING THIS PRODUCT.
RESPIRATORY PROTECTION:
USE A PROPERLY FITTED, AIR-PURIFYING OR AIR-FED RESPIRATOR COMPLYING WITH
AN APPROVED STANDARD IF A RISK ASSESSMENT INDICATES THIS IS NECESSARY.
RESPIRATOR SELECTION MUST BE BASED ON KNOWN OR ANTICIPATED EXPOSURE LEVELS,
THE HAZARDS OF THE PRODUCT AND THE SAFE WORKING LIMITS OF THE SELECTED
RESPIRATOR.
| SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: GAS.
COLOR: NOT AVAILABLE.
MELTING/FREEZING POINT:
-210.01 DEG. C (-346 DEG. F) THIS IS BASED ON DATA FOR THE FOLLOWING
INGREDIENT: NITROGEN.
CRITICAL TEMPERATURE:
LOWEST KNOWN VALUE: -146.95 DEG. C (-232.5 DEG. F) (NITROGEN).
ODOR: NOT AVAILABLE.
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
FLASH POINT: NOT AVAILABLE.
BURNING TIME: NOT APPLICABLE.
BURNING RATE: NOT APPLICABLE.
EVAPORATION RATE: NOT AVAILABLE.
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
LOWER AND UPPER EXPLOSIVE (FLAMMABLE) LIMITS: NOT AVAILABLE.
VAPOR PRESSURE: NOT AVAILABLE.
VAPOR DENSITY:
HIGHEST KNOWN VALUE: 0.97 (AIR = 1) (NITROGEN).
GAS DENSITY (LB/FT 3):
ONLY KNOWN VALUE: 0.072 (NITROGEN).
RELATIVE DENSITY: NOT APPLICABLE.
SOLUBILITY: NOT AVAILABLE.
SOLUBILITY IN WATER: NOT AVAILABLE.
PARTITION COEFFICIENT N-OCTANOL/WATER: NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
SADT: NOT AVAILABLE.
VISCOSITY: NOT APPLICABLE.
| SECTION 10. STABILITY AND REACTIVITY | |
REACTIVITY:
NO SPECIFIC TEST DATA RELATED TO REACTIVITY AVAILABLE FOR THIS PRODUCT OR
ITS INGREDIENTS.
CHEMICAL STABILITY: THE PRODUCT IS STABLE.
POSSIBILITY OF HAZARDOUS REACTIONS:
UNDER NORMAL CONDITIONS OF STORAGE AND USE, HAZARDOUS REACTIONS WILL NOT
OCCUR.
CONDITIONS TO AVOID: NO SPECIFIC DATA.
INCOMPATIBLE MATERIALS: NO SPECIFIC DATA.
HAZARDOUS DECOMPOSITION PRODUCTS:
UNDER NORMAL CONDITIONS OF STORAGE AND USE, HAZARDOUS DECOMPOSITION
PRODUCTS SHOULD NOT BE PRODUCED.
HAZARDOUS POLYMERIZATION:
UNDER NORMAL CONDITIONS OF STORAGE AND USE, HAZARDOUS POLYMERIZATION WILL
NOT OCCUR.
| SECTION 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY:
PRODUCT/INGREDIENT NAME RESULT SPECIES DOSE EXPOSURE
SULPHUR DIOXIDE LC50 INHALATION GAS. RAT 2520 PPM 1 HOURS
IRRITATION/CORROSION:
PRODUCT/INGREDIENT RESULT SPECIES SCORE EXPOSURE OBSERVATION
NAME
SULPHUR DIOXIDE EYES - MILD RABBIT 768 HOURS 6
IRRITANT PARTS PER
MILLION
SENSITIZATION: NOT AVAILABLE.
MUTAGENICITY: NOT AVAILABLE.
CARCINOGENICITY: NOT AVAILABLE.
CLASSIFICATION:
PRODUCT/INGREDIENT NAME OSHA IARC NTP
SULPHUR DIOXIDE 3
REPRODUCTIVE TOXICITY: NOT AVAILABLE.
TERATOGENICITY: NOT AVAILABLE.
SPECIFIC TARGET ORGAN TOXICITY (SINGLE EXPOSURE): NOT AVAILABLE.
SPECIFIC TARGET ORGAN TOXICITY (REPEATED EXPOSURE): NOT AVAILABLE.
ASPIRATION HAZARD: NOT AVAILABLE.
INFORMATION ON THE LIKELY ROUTES OF EXPOSURE: NOT AVAILABLE.
POTENTIAL ACUTE HEALTH EFFECTS:
EYE CONTACT:
CONTACT WITH RAPIDLY EXPANDING GAS MAY CAUSE BURNS OR FROSTBITE.
INHALATION: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
SKIN CONTACT:
CONTACT WITH RAPIDLY EXPANDING GAS MAY CAUSE BURNS OR FROSTBITE.
INGESTION: AS THIS PRODUCT IS A GAS, REFER TO THE INHALATION SECTION.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
EYE CONTACT: NO SPECIFIC DATA.
INHALATION: NO SPECIFIC DATA.
SKIN CONTACT: NO SPECIFIC DATA.
INGESTION: NO SPECIFIC DATA.
DELAYED AND IMMEDIATE EFFECTS AND ALSO CHRONIC EFFECTS FROM SHORT AND LONG
TERM EXPOSURE:
SHORT TERM EXPOSURE:
POTENTIAL IMMEDIATE EFFECTS: NOT AVAILABLE.
POTENTIAL DELAYED EFFECTS: NOT AVAILABLE.
LONG TERM EXPOSURE:
POTENTIAL IMMEDIATE EFFECTS: NOT AVAILABLE.
POTENTIAL DELAYED EFFECTS: NOT AVAILABLE.
POTENTIAL CHRONIC HEALTH EFFECTS: NOT AVAILABLE.
GENERAL: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
CARCINOGENICITY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
MUTAGENICITY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
TERATOGENICITY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
DEVELOPMENTAL EFFECTS: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
FERTILITY EFFECTS: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
NUMERICAL MEASURES OF TOXICITY:
ACUTE TOXICITY ESTIMATES: NOT AVAILABLE.
| SECTION 12. ECOLOGICAL INFORMATION | |
TOXICITY: NOT AVAILABLE.
PERSISTENCE AND DEGRADABILITY: NOT AVAILABLE.
BIOACCUMULATIVE POTENTIAL:
PRODUCT/INGREDIENT NAME LOGPOW BCF POTENTIAL
NITROGEN 0.67 LOW
MOBILITY IN SOIL:
SOIL/WATER PARTITION COEFFICIENT (KOC): NOT AVAILABLE.
OTHER ADVERSE EFFECTS: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
| SECTION 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL METHODS:
THE GENERATION OF WASTE SHOULD BE AVOIDED OR MINIMIZED WHEREVER POSSIBLE.
DISPOSAL OF THIS PRODUCT, SOLUTIONS AND ANY BY-PRODUCTS SHOULD AT ALL TIMES
COMPLY WITH THE REQUIREMENTS OF ENVIRONMENTAL PROTECTION AND WASTE DISPOSAL
LEGISLATION AND ANY REGIONAL LOCAL AUTHORITY REQUIREMENTS. DISPOSE OF
SURPLUS AND NON-RECYCLABLE PRODUCTS VIA A LICENSED WASTE DISPOSAL
CONTRACTOR. WASTE SHOULD NOT BE DISPOSED OF UNTREATED TO THE SEWER UNLESS
FULLY COMPLIANT WITH THE REQUIREMENTS OF ALL AUTHORITIES WITH JURISDICTION.
EMPTY AIRGAS-OWNED PRESSURE VESSELS SHOULD BE RETURNED TO AIRGAS. WASTE
PACKAGING SHOULD BE RECYCLED. INCINERATION OR LANDFILL SHOULD ONLY BE
CONSIDERED WHEN RECYCLING IS NOT FEASIBLE. THIS MATERIAL AND ITS CONTAINER
MUST BE DISPOSED OF IN A SAFE WAY. EMPTY CONTAINERS OR LINERS MAY RETAIN
SOME PRODUCT RESIDUES. DO NOT PUNCTURE OR INCINERATE CONTAINER.
| SECTION 14. TRANSPORT INFORMATION | |
DOT TDG MEXICO
UN NUMBER UN1956 UN1956 UN1956
UN PROPER COMPRESSED GAS, COMPRESSED GAS, COMPRESSED GAS,
SHIPPING NAME N.O.S. (NITROGEN, N.O.S. (NITROGEN, N.O.S. (NITROGEN,
SULFUR DIOXIDE) SULFUR DIOXIDE) SULFUR DIOXIDE)
TRANSPORT 2.2 2.2 2.2
HAZARD CLASS(ES)
NON-FLAMMABLE CLASS 2.2, NON- CLASS 2.2, NON-
GAS, CLASS/ FLAMMABLE AND FLAMMABLE AND
DIVISION 2.2 NON-TOXIC GASES NON-TOXIC GASES
PACKING GROUP
ENVIRONMENT NO. NO. NO.
ADDITIONAL PRODUCT CLASSIFIED
INFORMATION AS PER THE
FOLLOWING SECTIONS
OF THE
TRANSPORTATION OF
DANGEROUS GOODS
REGULATIONS:
2.13-2.17
(CLASS 2).
EXPLOSIVE LIMIT
AND LIMITED
QUANTITY INDEX:
0.125
PASSENGER CARRYING
ROAD OR RAIL INDEX:
75
IMDG IATA
UN NUMBER UN1956 UN1956
UN PROPER COMPRESSED GAS, COMPRESSED GAS,
SHIPPING NAME N.O.S. (NITROGEN, N.O.S. (NITROGEN,
SULFUR DIOXIDE) SULFUR DIOXIDE)
TRANSPORT 2.2 2.2
HAZARD CLASS(ES)
CLASS 2.2 - NON- CLASS 2.2, NON-FLAMMABLE
FLAMMABLE GASES AND NON-TOXIC GASES
PACKING GROUP
ENVIRONMENT NO. NO.
ADDITIONAL
INFORMATION
"REFER TO CFR 49 (OR AUTHORITY HAVING JURISDICTION) TO DETERMINE THE
INFORMATION REQUIRED FOR SHIPMENT OF THE PRODUCT."
SPECIAL PRECAUTIONS FOR USER:
TRANSPORT WITHIN USER'S PREMISES:
ALWAYS TRANSPORT IN CLOSED CONTAINERS THAT ARE UPRIGHT AND SECURE. ENSURE
THAT PERSONS TRANSPORTING THE PRODUCT KNOW WHAT TO DO IN THE EVENT OF AN
ACCIDENT OR SPILLAGE.
TRANSPORT IN BULK ACCORDING TO ANNEX II OF MARPOL 73/78 AND THE IBC CODE:
NOT AVAILABLE.
| SECTION 15. REGULATORY INFORMATION | |
U.S. FEDERAL REGULATIONS:
TSCA 8(A) CDR EXEMPT/PARTIAL EXEMPTION: NOT DETERMINED
UNITED STATES INVENTORY (TSCA 8B): ALL COMPONENTS ARE LISTED OR EXEMPTED.
CLEAN AIR ACT SECTION 112 (B) HAZARDOUS AIR POLLUTANTS (HAPS): NOT LISTED
CLEAN AIR ACT SECTION 602 CLASS I SUBSTANCES: NOT LISTED
CLEAN AIR ACT SECTION 602 CLASS II SUBSTANCES: NOT LISTED
DEA LIST I CHEMICALS (PRECURSOR CHEMICALS): NOT LISTED
DEA LIST II CHEMICALS (ESSENTIAL CHEMICALS): NOT LISTED
SARA 302/304:
COMPOSITION/INFORMATION ON INGREDIENTS:
NAME % EHS SARA 302 TPQ SARA 304 RQ
(LBS) (GALLONS) (LBS) (GALLONS)
SULPHUR DIOXIDE 0.0000001 - YES. 500 500
0.9999
SARA 304 RQ: 50005 LBS / 22702.3 KG
SARA 311/312:
CLASSIFICATION: SUDDEN RELEASE OF PRESSURE
COMPOSITION/INFORMATION ON INGREDIENTS:
NAME % FIRE SUDDEN REACTIVE IMMEDIATE DELAYED
HAZARD RELEASE OF (ACUTE) (CHRONIC)
PRESSURE HEALTH HAZARD
HEALTH HAZARD
NITROGEN 99 NO. YES. NO. NO. NO.
SULPHUR 0.0000001 - NO. YES. NO. YES. NO.
DIOXIDE 0.9999
STATE REGULATIONS:
MASSACHUSETTS:
THE FOLLOWING COMPONENTS ARE LISTED: NITROGEN
NEW YORK: NONE OF THE COMPONENTS ARE LISTED.
NEW JERSEY:
THE FOLLOWING COMPONENTS ARE LISTED: NITROGEN
PENNSYLVANIA:
THE FOLLOWING COMPONENTS ARE LISTED: NITROGEN
CALIFORNIA PROP. 65:
WARNING:
THIS PRODUCT CONTAINS LESS THAN 1% OF A CHEMICAL KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
INGREDIENT NAME CANCER REPRODUCTIVE NO SIGNIFICANT MAXIMUM ACCEPTABLE
RISK LEVEL DOSAGE LEVEL
SULPHUR DIOXIDE NO. YES. NO. YES.
INTERNATIONAL REGULATIONS:
INTERNATIONAL LISTS:
NATIONAL INVENTORY:
AUSTRALIA: ALL COMPONENTS ARE LISTED OR EXEMPTED.
CANADA: ALL COMPONENTS ARE LISTED OR EXEMPTED.
CHINA: ALL COMPONENTS ARE LISTED OR EXEMPTED.
EUROPE: ALL COMPONENTS ARE LISTED OR EXEMPTED.
JAPAN: NOT DETERMINED.
MALAYSIA: NOT DETERMINED.
NEW ZEALAND: ALL COMPONENTS ARE LISTED OR EXEMPTED.
PHILIPPINES: ALL COMPONENTS ARE LISTED OR EXEMPTED.
REPUBLIC OF KOREA: ALL COMPONENTS ARE LISTED OR EXEMPTED.
TAIWAN: ALL COMPONENTS ARE LISTED OR EXEMPTED.
CANADA:
WHMIS (CANADA):
CLASS A: COMPRESSED GAS.
CEPA TOXIC SUBSTANCES: NONE OF THE COMPONENTS ARE LISTED.
CANADIAN ARET: NONE OF THE COMPONENTS ARE LISTED.
CANADIAN NPRI: NONE OF THE COMPONENTS ARE LISTED.
ALBERTA DESIGNATED SUBSTANCES: NONE OF THE COMPONENTS ARE LISTED.
ONTARIO DESIGNATED SUBSTANCES: NONE OF THE COMPONENTS ARE LISTED.
QUEBEC DESIGNATED SUBSTANCES: NONE OF THE COMPONENTS ARE LISTED.
| SECTION 16. OTHER INFORMATION | |
CANADA LABEL REQUIREMENTS:
CLASS A: COMPRESSED GAS.
HAZARDOUS MATERIAL INFORMATION SYSTEM (U.S.A.):
HEALTH 1
FLAMMABILITY 0
PHYSICAL HAZARDS 3
CAUTION:
HMIS(R*) RATINGS ARE BASED ON A 0-4 RATING SCALE, WITH 0 REPRESENTING
MINIMAL HAZARDS OR RISKS, AND 4 REPRESENTING SIGNIFICANT HAZARDS OR RISKS
ALTHOUGH HMIS(R*) RATINGS ARE NOT REQUIRED ON SDSS UNDER 29 CFR 1910.
1200, THE PREPARER MAY CHOOSE TO PROVIDE THEM. HMIS(R*) RATINGS ARE TO BE
USED WITH A FULLY IMPLEMENTED HMIS(R*) PROGRAM. HMIS(R*) IS A REGISTERED
MARK OF THE NATIONAL PAINT & COATINGS ASSOCIATION (NPCA). HMIS(R*)
MATERIALS MAY BE PURCHASED EXCLUSIVELY FROM J. J. KELLER (800) 327-6868.
THE CUSTOMER IS RESPONSIBLE FOR DETERMINING THE PPE CODE FOR THIS MATERIAL.
NATIONAL FIRE PROTECTION ASSOCIATION (U.S.A.):
HEALTH 1
FLAMMABILITY 0
INSTABILITY/REACTIVITY 0
SPECIAL
REPRINTED WITH PERMISSION FROM NFPA 704-2001, IDENTIFICATION OF THE HAZARDS
OF MATERIALS FOR EMERGENCY RESPONSE COPYRIGHT (C)1997, NATIONAL FIRE
PROTECTION ASSOCIATION, QUINCY, MA 02269. THIS REPRINTED MATERIAL IS NOT
THE COMPLETE AND OFFICIAL POSITION OF THE NATIONAL FIRE PROTECTION
ASSOCIATION, ON THE REFERENCED SUBJECT WHICH IS REPRESENTED ONLY BY THE
STANDARD IN ITS ENTIRETY.
COPYRIGHT (C)2001, NATIONAL FIRE PROTECTION ASSOCIATION, QUINCY, MA 02269.
THIS WARNING SYSTEM IS INTENDED TO BE INTERPRETED AND APPLIED ONLY BY
PROPERLY TRAINED INDIVIDUALS TO IDENTIFY FIRE, HEALTH AND REACTIVITY
HAZARDS OF CHEMICALS. THE USER IS REFERRED TO CERTAIN LIMITED NUMBER OF
CHEMICALS WITH RECOMMENDED CLASSIFICATIONS IN NFPA 49 AND NFPA 325, WHICH
WOULD BE USED AS A GUIDELINE ONLY. WHETHER THE CHEMICALS ARE CLASSIFIED BY
NFPA OR NOT, ANYONE USING THE 704 SYSTEMS TO CLASSIFY CHEMICALS DOES SO AT
THEIR OWN RISK.
PROCEDURE USED TO DERIVE THE CLASSIFICATION:
CLASSIFICATION JUSTIFICATION
PRESS. GAS COMP. GAS, H280 ON BASIS OF TEST DATA
HISTORY:
DATE OF PRINTING: 6/24/2016
DATE OF ISSUE/DATE OF REVISION: 6/24/2016
DATE OF PREVIOUS ISSUE: NO PREVIOUS VALIDATION
VERSION: 0.01
KEY TO ABBREVIATIONS:
ATE: ACUTE TOXICITY ESTIMATE
BCF: BIOCONCENTRATION FACTOR
GHS: GLOBALLY HARMONIZED SYSTEM OF CLASSIFICATION AND LABELING OF CHEMICALS
IATA: INTERNATIONAL AIR TRANSPORT ASSOCIATION
IBC: INTERMEDIATE BULK CONTAINER
IMDG: INTERNATIONAL MARITIME DANGEROUS GOODS
LOGPOW: LOGARITHM OF THE OCTANOL/WATER PARTITION COEFFICIENT
MARPOL 73/78:
INTERNATIONAL CONVENTION FOR THE PREVENTION OF POLLUTION FROM SHIPS, 1973
AS MODIFIED BY THE PROTOCOL OF 1978. ("MARPOL" = MARINE POLLUTION)
UN: UNITED NATIONS
REFERENCES: NOT AVAILABLE.
| INDICATES INFORMATION THAT HAS CHANGED FROM PREVIOUSLY ISSUED VERSION.
NOTICE TO READER:
TO THE BEST OF OUR KNOWLEDGE, THE INFORMATION CONTAINED HEREIN IS ACCURATE.
HOWEVER, NEITHER THE ABOVE-NAMED SUPPLIER, NOR ANY OF ITS SUBSIDIARIES,
ASSUMES ANY LIABILITY WHATSOEVER FOR THE ACCURACY OR COMPLETENESS OF THE
INFORMATION CONTAINED HEREIN.
FINAL DETERMINATION OF SUITABILITY OF ANY MATERIAL IS THE SOLE
RESPONSIBILITY OF THE USER. ALL MATERIALS MAY PRESENT UNKNOWN HAZARDS AND
SHOULD BE USED WITH CAUTION. ALTHOUGH CERTAIN HAZARDS ARE DESCRIBED HEREIN,
WE CANNOT GUARANTEE THAT THESE ARE THE ONLY HAZARDS THAT EXIST.