| Common Name: | S-T DRAIN OPENER |
| Manufacturer: | SANTEEN PRODUCTS |
| SDS Revision Date: | 7/3/2015 |
| SDS Format: | No Format Specified |
| Item Number(s): | 32UU97, 32UU98, 793JY0 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
SAFETY DATA SHEET
ISSUE DATE: 30-DEC-2009
REVISION DATE: 03-JUL-2015
VERSION: 2
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFIER:
PRODUCT NAME: S-T DRAIN OPENER
OTHER MEANS OF IDENTIFICATION:
SDS #: SAPC-001
UN/ID NO: UN1830
RECOMMENDED USE OF THE CHEMICAL AND RESTRICTIONS ON USE:
RECOMMENDED USE: ACID CLEANER.
DETAILS OF THE SUPPLIER OF THE SAFETY DATA SHEET:
SUPPLIER ADDRESS:
SANTEEN PRODUCTS COMPANY
10509 MILLER DRIVE
GALESBURG, MI 49053
EMERGENCY TELEPHONE NUMBER:
COMPANY PHONE NUMBER: 616-502-4928
EMERGENCY TELEPHONE (24 HR):
INFOTRAC:
1-352-323-3500 (INTERNATIONAL)
1-800-535-5053 (NORTH AMERICA)
| 2. HAZARDS IDENTIFICATION | |
APPEARANCE: BROWN LIQUID
PHYSICAL STATE: LIQUID
ODOR: DISTINCT ODOR
CLASSIFICATION:
SKIN CORROSION/IRRITATION: CATEGORY 1 SUB-CATEGORY B
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 1
CORROSIVE TO METALS: CATEGORY 1
HAZARDS NOT OTHERWISE CLASSIFIED (HNOC): MAY BE HARMFUL IF SWALLOWED
SIGNAL WORD: DANGER
HAZARD STATEMENTS:
CAUSES SEVERE SKIN BURNS AND EYE DAMAGE
MAY BE CORROSIVE TO METALS
CORROSION
PRECAUTIONARY STATEMENTS - PREVENTION:
DO NOT BREATHE DUST/FUME/GAS/MIST/VAPORS/SPRAY
WASH FACE, HANDS AND ANY EXPOSED SKIN THOROUGHLY AFTER HANDLING
WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION
KEEP ONLY IN ORIGINAL CONTAINER
PRECAUTIONARY STATEMENTS - RESPONSE:
IMMEDIATELY CALL A POISON CENTER OR DOCTOR/PHYSICIAN
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING
IMMEDIATELY CALL A POISON CENTER OR DOCTOR/PHYSICIAN
IF ON SKIN (OR HAIR):
REMOVE/TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. RINSE SKIN WITH
WATER/SHOWER
WASH CONTAMINATED CLOTHING BEFORE REUSE
IF INHALED:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING IMMEDIATELY CALL A POISON CENTER OR DOCTOR/PHYSICIAN
IF SWALLOWED: RINSE MOUTH. DO NOT INDUCE VOMITING
IN CASE OF SPILL: ABSORB SPILLAGE TO PREVENT MATERIAL DAMAGE
PRECAUTIONARY STATEMENTS - STORAGE:
STORE LOCKED UP
STORE IN CORROSIVE RESISTANT CONTAINER WITH A RESISTANT INNER LINER
PRECAUTIONARY STATEMENTS - DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER TO AN APPROVED WASTE DISPOSAL PLANT
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
CHEMICAL NAME CAS NO WEIGHT-%
SULFURIC ACID 7664-93-9 85-87
IF CHEMICAL NAME/CAS NO IS "PROPRIETARY" AND/OR WEIGHT-% IS LISTED AS A
RANGE, THE SPECIFIC CHEMICAL IDENTITY AND/OR PERCENTAGE OF COMPOSITION
HAS BEEN WITHHELD AS A TRADE SECRET.
| 4. FIRST-AID MEASURES | |
FIRST AID MEASURES:
GENERAL ADVICE: PROVIDE THIS SDS TO MEDICAL PERSONNEL FOR TREATMENT.
EYE CONTA:
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES,
IF PRESENT AND EASY TO DO. CONTINUE RINSING. IMMEDIATELY CALL A POISON
CENTER OR DOCTOR/PHYSICIAN.
SKIN CONTACT:
IF ON SKIN (OR HAIR):
REMOVE/TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. RINSE SKIN WITH
WATER/SHOWER. IMMEDIATELY CALL A POISON CENTER OR DOCTOR/PHYSICIAN. WASH
CONTAMINATED CLOTHING BEFORE REUSE.
INHALATION:
IF INHALED:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. IMMEDIATELY CALL A POISON CENTER OR DOCTOR/PHYSICIAN.
INGESTION:
IF SWALLOWED:
RINSE MOUTH. DO NOT INDUCE VOMITING. IMMEDIATELY CALL A POISON CENTER OR
DOCTOR/PHYSICIAN.
MOST IMPORTANT SYMPTOMS AND EFFECTS:
SYMPTOMS:
MAY BE HARMFUL IF SWALLOWED. CAUSES SEVERE SKIN BURNS AND EYE DAMAGE.
INDICATION OF ANY IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT
NEEDED:
NOTES TO PHYSICIAN: TREAT SYMPTOMATICALLY.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
USE EXTINGUISHING MEASURES THAT ARE APPROPRIATE TO LOCAL CIRCUMSTANCES AND
THE SURROUNDING ENVIRONMENT.
UNSUITABLE EXTINGUISHING MEDIA: NOT DETERMINED.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL: NOT DETERMINED.
HAZARDOUS COMBUSTION PRODUCTS:
CONTACT WITH SOFT METALS MAY EVOLVE FLAMMABLE HYDROGEN GAS.
PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
AS IN ANY FIRE, WEAR SELF-CONTAINED BREATHING APPARATUS PRESSURE-DEMAND,
MSHA/NIOSH (APPROVED OR EQUIVALENT) AND FULL PROTECTIVE GEAR.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
PERSONAL PRECAUTIONS: USE PERSONAL PROTECTIVE EQUIPMENT AS REQUIRED.
ENVIRONMENTAL PRECAUTIONS:
SEE SECTION 12 FOR ADDITIONAL ECOLOGICAL INFORMATION.
METHODS AND MATERIAL FOR CONTAINMENT AND CLEANING UP:
METHODS FOR CONTAINMENT:
PREVENT FURTHER LEAKAGE OR SPILLAGE IF SAFE TO DO SO.
METHODS FOR CLEAN-UP:
SOAK UP WITH ABSORBENT MATERIAL. NEUTRALIZE WITH AN ALKALINE MATERIAL.
COLLECT SPILLAGE. DISPOSE OF CONTENTS/CONTAINER TO AN APPROVED WASTE
DISPOSAL PLANT.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
ADVICE ON SAFE HANDLING:
HANDLE IN ACCORDANCE WITH GOOD INDUSTRIAL HYGIENE AND SAFETY PRACTICE.
WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING AND EYE/FACE PROTECTION. DO
NOT BREATHE DUST/FUME/GAS/MIST/VAPORS/SPRAY. WASH FACE, HANDS, AND ANY
EXPOSED SKIN THOROUGHLY AFTER HANDLING. KEEP ONLY IN ORIGINAL CONTAINER.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
STORAGE CONDITIONS:
KEEP CONTAINER TIGHTLY CLOSED AND STORE IN A COOL, DRY AND
WELL-VENTILATED PLACE. STORE LOCKED UP. STORE IN CORROSIVE
RESISTANT CONTAINER WITH A RESISTANT INNER LINER.
INCOMPATIBLE MATERIALS: METALS. WATER. CHLORINE BLEACH. OXIDIZING AGENTS.
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
EXPOSURE GUIDELINES:
CHEMICAL NAME ACGIH TLV OSHA PEL NIOSH IDLH
SULFURIC ACID TWA: 0.2 MG/M3 TWA: 1 MG/M3 (VACATED) IDLH: 15 MG/M3
7664-93-9 THORACIC FRACTION TWA: 1 MG/M3 TWA: 1 MG/M3
APPROPRIATE ENGINEERING CONTROLS:
ENGINEERING CONTROLS:
APPLY TECHNICAL MEASURES TO COMPLY WITH THE OCCUPATIONAL EXPOSURE LIMITS.
SHOWERS. EYEWASH STATIONS. VENTILATION SYSTEMS.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION:
GOGGLES. FACE PROTECTION SHIELD. REFER TO 29 CFR 1910.133 FOR EYE AND FACE
PROTECTION REGULATIONS.
SKIN AND BODY PROTECTION:
CHEMICAL RESISTANT GLOVES. IMPERVIOUS FOOTWEAR. REFER TO 29 CFR 1910.138
FOR APPROPRIATE SKIN AND BODY PROTECTION.
RESPIRATORY PROTECTION:
NO PROTECTIVE EQUIPMENT IS NEEDED UNDER NORMAL USE CONDITIONS. IN CASE
OF INSUFFICIENT VENTILATION, WEAR SUITABLE RESPIRATORY EQUIPMENT. REFER
TO 29 CFR 1910.134 FOR RESPIRATORY PROTECTION REQUIREMENTS.
GENERAL HYGIENE CONSIDERATIONS:
HANDLE IN ACCORDANCE WITH GOOD INDUSTRIAL HYGIENE AND SAFETY PRACTICE.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
INFORMATION ON BASIC PHYSICAL AND CHEMICAL PROPERTIES:
PHYSICAL STATE: LIQUID
APPEARANCE: BROWN LIQUID
ODOR: DISTINCT ODOR
COLOR: BROWN
ODOR THRESHOLD: NOT DETERMINED
PROPERTY VALUES REMARKS - METHOD
PH <1
MELTING POINT/FREEZING POINT NOT DETERMINED
BOILING POINT/BOILING RANGE 276.1 DEG. C / (APPROXIMATE)
529 DEG. F
FLASH POINT NOT DETERMINED
EVAPORATION RATE NOT DETERMINED
FLAMMABILITY (SOLID, GAS) LIQUID- NOT APPLICABLE
UPPER FLAMMABILITY LIMITS NOT DETERMINED
LOWER FLAMMABILITY LIMIT NOT DETERMINED
VAPOR PRESSURE 1.7 MM @ 121 DEG. C
VAPOR DENSITY >1 (AIR=1)
SPECIFIC GRAVITY 1.793 (WATER = 1)
WATER SOLUBILITY MISCIBLE IN WATER
SOLUBILITY IN OTHER SOLVENTS NOT DETERMINED
PARTITION COEFFICIENT NOT DETERMINED
AUTO-IGNITION TEMPERATURE NOT DETERMINED
DECOMPOSITION TEMPERATURE NOT DETERMINED
KINEMATIC VISCOSITY NOT DETERMINED
DYNAMIC VISCOSITY NOT DETERMINED
EXPLOSIVE PROPERTIES NOT DETERMINED
OXIDIZING PROPERTIES NOT DETERMINED
| 10. STABILITY AND REACTIVITY | |
REACTIVITY: NOT REACTIVE UNDER NORMAL CONDITIONS.
CHEMICAL STABILITY: STABLE UNDER RECOMMENDED STORAGE CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS: NONE UNDER NORMAL PROCESSING.
HAZARDOUS POLYMERIZATION: HAZARDOUS POLYMERIZATION DOES NOT OCCUR.
CONDITIONS TO AVOID: KEEP OUT OF REACH OF CHILDREN.
INCOMPATIBLE MATERIALS: METALS. WATER. CHLORINE BLEACH. OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS:
FLAMMABLE HYDROGEN GAS GENERATED IN CONTACT WITH SOFT METALS.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
PRODUCT INFORMATION:
EYE CONTACT: CAUSES SEVERE EYE DAMAGE.
SKIN CONTACT: CAUSES SEVERE SKIN BURNS.
INHALATION: DO NOT INHALE.
INGESTION: MAY BE HARMFUL IF SWALLOWED.
COMPONENT INFORMATION:
CHEMICAL NAME ORAL LD50 DERMAL LD50 INHALATION LC50
SULFURIC ACID = 2140 MG/KG (RAT) = 510 MG/M3 (RAT) 2 H
7664-93-9
INFORMATION ON PHYSICAL, CHEMICAL AND TOXICOLOGICAL EFFECTS:
SYMPTOMS: PLEASE SEE SECTION 4 OF THIS SDS FOR SYMPTOMS.
DELAYED AND IMMEDIATE EFFECTS AS WELL AS CHRONIC EFFECTS FROM SHORT AND
LONG-TERM EXPOSURE:
CARCINOGENICITY:
IARC HAS CLASSIFIED "STRONG INORGANIC ACID MIST CONTAINING SULFURIC ACID"
AS A CATEGORY 1 CARCINOGEN, SUBSTANCE THAT IS CARCINOGENIC TO HUMANS. THIS
CLASSIFICATION DOES NOT APPLY TO LIQUID FORMS OF SULFURIC ACID. INORGANIC
MIST IS NOT GENERATED UNDER NORMAL USE OF THIS PRODUCT.
CHEMICAL NAME ACGIH IARC NTP OSHA
SULFURIC ACID A2 GROUP 1 KNOWN X
7664-93-9
LEGEND:
ACGIH (AMERICAN CONFERENCE OF GOVERNMENTAL INDUSTRIAL HYGIENISTS):
A2 - SUSPECTED HUMAN CARCINOGEN
IARC (INTERNATIONAL AGENCY FOR RESEARCH ON CANCER):
GROUP 1 - CARCINOGENIC TO HUMANS
NTP (NATIONAL TOXICOLOGY PROGRAM):
KNOWN - KNOWN CARCINOGEN
OSHA (OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION OF THE US DEPARTMENT
OF LABOR): X - PRESENT
NUMERICAL MEASURES OF TOXICITY: NOT DETERMINED
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY:
THE PRODUCT IS NOT CLASSIFIED AS ENVIRONMENTALLY HAZARDOUS. HOWEVER, THIS
DOES NOT EXCLUDE THE POSSIBILITY THAT LARGE OR FREQUENT SPILLS CAN HAVE A
HARMFUL OR DAMAGING EFFECT ON THE ENVIRONMENT.
COMPONENT INFORMATION:
CHEMICAL NAME ALGAE/AQUATIC FISH TOXICITY TO CRUSTACEA
PLANTS MICROORGANISMS
SULFURIC ACID 500: 29:
7664-93-9 96 H 24 H DAPHNIA
BRACHYDANIO MAGNA MG/L
RERIO MG/L EC50
LC50 STATIC
PERSISTENCE/DEGRADABILITY: NOT DETERMINED.
BIOACCUMULATION: NOT DETERMINED.
MOBILITY: NOT DETERMINED
OTHER ADVERSE EFFECTS: NOT DETERMINED
| 13. DISPOSAL CONSIDERATIONS | |
WASTE TREATMENT METHODS:
DISPOSAL OF WASTES:
DISPOSAL SHOULD BE IN ACCORDANCE WITH APPLICABLE REGIONAL, NATIONAL AND
LOCAL LAWS AND REGULATIONS.
CONTAMINATED PACKAGING:
DISPOSAL SHOULD BE IN ACCORDANCE WITH APPLICABLE REGIONAL, NATIONAL AND
LOCAL LAWS AND REGULATIONS.
CALIFORNIA HAZARDOUS WASTE STATUS:
CHEMICAL NAME CALIFORNIA HAZARDOUS WASTE STATUS
SULFURIC ACID TOXIC
7664-93-9 CORROSIVE
| 14. TRANSPORT INFORMATION | |
NOTE:
PLEASE SEE CURRENT SHIPPING PAPER FOR MOST UP TO DATE SHIPPING
INFORMATION, INCLUDING EXEMPTIONS AND SPECIAL CIRCUMSTANCES.
DOT:
UN/ID NO: UN1830
PROPER SHIPPING NAME: SULFURIC ACID
HAZARD CLASS: 8
PACKING GROUP: II
IATA:
UN/ID NO: UN1830
PROPER SHIPPING NAME: SULFURIC ACID
HAZARD CLASS: 8
PACKING GROUP: II
IMDG:
UN/ID NO: UN1830
PROPER SHIPPING NAME: SULFURIC ACID
HAZARD CLASS: 8
PACKING GROUP: II
| 15. REGULATORY INFORMATION | |
INTERNATIONAL INVENTORIES:
CHEMICAL NAME TSCA DSL NDSL EINECS ELINCS
SULFURIC ACID PRESENT X PRESENT
CHEMICAL NAME ENCS IECSC KECL PICCS AICS
SULFURIC ACID PRESENT X PRESENT X X
LEGEND:
TSCA: UNITED STATES TOXIC SUBSTANCES CONTROL ACT SECTION 8(B) INVENTORY
DSL/NDSL: CANADIAN DOMESTIC SUBSTANCES LIST/NON-DOMESTIC SUBSTANCES LIST
EINECS/ELINCS:
EUROPEAN INVENTORY OF EXISTING CHEMICAL SUBSTANCES/EUROPEAN LIST OF
NOTIFIED CHEMICAL SUBSTANCES
ENCS: JAPAN EXISTING AND NEW CHEMICAL SUBSTANCES
IECSC: CHINA INVENTORY OF EXISTING CHEMICAL SUBSTANCES
KECL: KOREAN EXISTING AND EVALUATED CHEMICAL SUBSTANCES
PICCS: PHILIPPINES INVENTORY OF CHEMICALS AND CHEMICAL SUBSTANCES
AICS: AUSTRALIAN INVENTORY OF CHEMICAL SUBSTANCES
US FEDERAL REGULATIONS:
CERCLA:
THIS MATERIAL, AS SUPPLIED, CONTAINS ONE OR MORE SUBSTANCES REGULATED
AS A HAZARDOUS SUBSTANCE UNDER THE COMPREHENSIVE ENVIRONMENTAL RESPONSE
COMPENSATION AND LIABILITY ACT (CERCLA) (40 CFR 302)
CHEMICAL NAME HAZARDOUS SUBSTANCES CERCLA/SARA REPORTABLE QUANTITY
RQS RQ (RQ)
SULFURIC ACID 1000 LB 1000 LB RQ 1000 LB FINAL RQ
7664-93-9 RQ 454 KG FINAL RQ
SARA 313:
SECTION 313 OF TITLE III OF THE SUPERFUND AMENDMENTS AND REAUTHORIZATION
ACT OF 1986 (SARA). THIS PRODUCT CONTAINS A CHEMICAL OR CHEMICALS WHICH
ARE SUBJECT TO THE REPORTING REQUIREMENTS OF THE ACT AND TITLE 40 OF THE
CODE OF FEDERAL REGULATIONS, PART 372
CHEMICAL NAME CAS NO WEIGHT-% SARA 313 - THRESHOLD VALUES %
SULFURIC ACID 7664-93-9 85-87 1.0
7664-93-9
CWA (CLEAN WATER ACT):
THIS PRODUCT CONTAINS THE FOLLOWING SUBSTANCES WHICH ARE REGULATED
POLLUTANTS PURSUANT TO THE CLEAN WATER ACT (40 CFR 122.21 AND
40 CFR 122.42)
CHEMICAL NAME CWA - REPORTABLE CWA - TOXIC CWA - PRIORITY CWA -
QUANTITIES POLLUTANTS POLLUTANTS HAZARDOUS
SUBSTANCES
SULFURIC ACID 1000 LB X
US STATE REGULATIONS:
CALIFORNIA PROPOSITION 65:
THIS PRODUCT CONTAINS THE FOLLOWING PROPOSITION 65 CHEMICALS.
CHEMICAL NAME CALIFORNIA PROPOSITION 65
SULFURIC ACID CARCINOGEN
7664-93-9
U.S. STATE RIGHT-TO-KNOW REGULATIONS:
CHEMICAL NAME NEW JERSEY MASSACHUSETTS PENNSYLVANIA
SULFURIC ACID X X X
7664-93-9
| 16. OTHER INFORMATION | |
NFPA:
HEALTH HAZARDS 3
FLAMMABILITY 0
INSTABILITY 2
SPECIAL HAZARDS NOT DETERMINED
HMIS:
HEALTH HAZARDS NOT DETERMINED
FLAMMABILITY NOT DETERMINED
PHYSICAL HAZARDS NOT DETERMINED
PERSONAL PROTECTION NOT DETERMINED
ISSUE DATE: 30-DEC-2009
REVISION DATE: 03-JUL-2015
REVISION NOTE: NEW FORMAT
DISCLAIMER:
THE INFORMATION PROVIDED IN THIS SAFETY DATA SHEET IS CORRECT TO THE BEST
OF OUR KNOWLEDGE, INFORMATION AND BELIEF AT THE DATE OF ITS PUBLICATION.
THE INFORMATION GIVEN IS DESIGNED ONLY AS A GUIDANCE FOR SAFE HANDLING,
USE, PROCESSING, STORAGE, TRANSPORTATION, DISPOSAL AND RELEASE AND IS
NOT TO BE CONSIDERED A WARRANTY OR QUALITY SPECIFICATION. THE INFORMATION
RELATES ONLY TO THE SPECIFIC MATERIAL DESIGNATED AND MAY NOT BE VALID FOR
SUCH MATERIAL USED IN COMBINATION WITH ANY OTHER MATERIALS OR IN ANY
PROCESS, UNLESS SPECIFIED IN THE TEXT.