| Common Name: | RAPID RELEASE |
| Manufacturer: | STONER |
| SDS Revision Date: | 4/17/2015 |
| SDS Format: | GHS-US |
| Item Number(s): | 35HY51 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
STONER
SAFETY DATA SHEET
A324
RAPID RELEASE(TM)
COPYING AND/OR DOWNLOADING OF THIS INFORMATION FOR THE PURPOSE OF PROPERLY
UTILIZING STONER INC. PRODUCT IS ALLOWED PROVIDED THAT:
(1) THE INFORMATION IS COPIED IN FULL WITH NO CHANGES UNLESS PRIOR
AGREEMENT IS OBTAINED FROM STONER INC., &
(2) NEITHER THE COPY NOR THE ORIGINAL IS RESOLD OR OTHERWISE DISTRIBUTED
WITH INTENTION OF EARNING PROFIT THEREON.
| 1. IDENTIFICATION |  |
STONER INCORPORATED
1070 ROBERT FULTON HWY.
QUARRYVILLE, PA 17566
1-800-227-5538
PRODUCT NAME: RAPID RELEASE(TM)
PRODUCT CODE: A324
PRODUCT USE: MOLD RELEASE
24-HOUR EMERGENCY PHONE: 1-800-424-9300 [CHEMTREC]
| 2. HAZARD IDENTIFICATION | |
POTENTIAL HEALTH EFFECTS:
CLASSIFICATION OF THE CHEMICAL IN ACCORDANCE WITH PARAGRAPH (D)
OF SUBSECTION 1910.1200;
GHS HAZARD SYMBOLS:
FLAME
GAS CYLINDER
EXCLAMATION MARK
GHS CLASSIFICATION:
FLAMMABLE AEROSOL CATEGORY 1
GASES UNDER PRESSURE - LIQUIFIED GAS
SKIN CORROSION/IRRITATION CATEGORY 2
SERIOUS EYE DAMAGE/EYE IRRITATION CATEGORY 2A
SPECIFIC TARGET ORGAN SYSTEMIC TOXICITY (STOT) - SINGLE EXPOSURE CATEGORY 3
SIGNAL WORD: DANGER
HAZARD STATEMENTS:
EXTREMELY FLAMMABLE AEROSOL.
CONTAINS GAS UNDER PRESSURE; MAY EXPLODE IF HEATED.
CAUSES SKIN IRRITATION.
CAUSES SERIOUS EYE IRRITATION.
MAY CAUSE RESPIRATORY IRRITATION.
PRECAUTIONARY STATEMENTS:
PREVENTION:
KEEP AWAY FROM HEAT/SPARKS/OPEN FLAMES/HOT SURFACES. - NO SMOKING.
DO NOT SPRAY ON AN OPEN FLAME OR OTHER IGNITION SOURCE.
PRESSURIZED CONTAINER: DO NOT PIERCE OR BURN, EVEN AFTER USE.
AVOID BREATHING DUST/FUME/GAS/MIST/VAPOURS/SPRAY.
WASH THOROUGHLY AFTER HANDLING.
USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA.
WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION.
RESPONSE:
IF ON SKIN: WASH WITH PLENTY OF SOAP AND WATER.
IF INHALED:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO.
CONTINUE RINSING.
CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
SPECIFIC TREATMENT (SEE ... ON THIS LABEL).
IF SKIN IRRITATION OCCURS: GET MEDICAL ADVICE/ATTENTION.
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
TAKE OFF CONTAMINATED CLOTHING AND WASH BEFORE REUSE.
STORAGE STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED.
STORE LOCKED UP.
PROTECT FROM SUNLIGHT. STORE IN A WELL-VENTILATED PLACE.
PROTECT FROM SUNLIGHT. DO NO EXPOSE TO TEMPERATURES EXCEEDING
50 DEG. C / 122 DEG. F.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH LOCAL/REGIONAL/NATIONAL/
INTERNATIONAL REGULATION FOR HAZARDOUS WASTES.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
COMPONENT CAS # PERCENT
HYDROCARBON PROPELLANT 106-97-8 70-90
NJ TRADE SECRET REGISTRY #80100382-5096P 1-20
ALIPHATIC HYDROCARBON 64741-66-8 1-20
PETROLEUM DISTILLATES 8052-41-3 1-20
HMIS(R*) III* HAZARDOUS WARNINGS:
HEALTH 1
FLAMMABILITY 4
PHYSICAL 0
PERSONAL PROTECTIVE EQUIPMENT SEE SECTION 8
* SEE WWW.PAINT.ORG/HMIS OR CALL THE NPCA AT 1 (202) 462-6272 FOR MORE
INFORMATION ON THIS CURRENT RATING SYSTEM.
| 4. FIRST AID MEASURES | |
EYES:
IMMEDIATELY FLUSH EYES GENTLY WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES
WHILE HOLDING EYELIDS APART. IF SYMPTOMS PERSIST OR THERE IS VISUAL
DIFFICULTY, SEEK MEDICAL ATTENTION.
SKIN CONTACT:
IN CASE OF CONTACT, IMMEDIATELY WASH CONTAMINATED AREA WITH PLENTY OF WATER
FOR AT LEAST 15 MINUTES. SEEK MEDICAL ATTENTION IF SYMPTOMS PERSIST. SEEK
MEDICAL ATTENTION IF SYMPTOMS PERSIST. WASH CLOTHING BEFORE REUSE.
INGESTION:
DO NOT INDUCE VOMITING. ASPIRATION INTO THE LUNGS CAN CAUSE SERIOUS DAMAGE.
IF VOMITING OCCURS SPONTANEOUSLY, KEEP HEAD BELOW HIPS TO PREVENT
ASPIRATION OF LIQUID INTO LUNGS. CONTACT A PHYSICIAN, MEDICAL FACILITY, OR
POISON CONTROL CENTER IMMEDIATELY.
INHALATION:
REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. SEEK IMMEDIATE MEDICAL ATTENTION.
NOTES TO PHYSICIAN:
THIS MATERIAL IS AN ASPIRATION HAZARD. POTENTIAL DANGER FROM ASPIRATION
MUST BE WEIGHED AGAINST POSSIBLE ORAL TOXICITY WHEN DECIDING WHETHER TO
INDUCE VOMITING. BECAUSE OF POSSIBLE DISTURBANCES OF CARDIAC RHYTHM,
CATECHOLAMINE DRUGS, SUCH AS EPINEPHRINE, SHOULD BE USED ONLY IN
SITUATIONS OF EMERGENCY LIFE SUPPORT.
THIS MATERIAL IS AN ASPIRATION HAZARD. PREEXISTING DISORDERS OF THE
FOLLOWING ORGANS (OR ORGAN SYSTEMS) MAY BE AGGRAVATED BY EXPOSURE TO THIS
MATERIAL: SKIN; LUNG (FOR EXAMPLE, ASTHMA-LIKE CONDITIONS)
| 5. FIRE FIGHTING MEASURES | |
FIRE AND/OR EXPLOSION HAZARDS:
THIS PRODUCT CONTAINS A COMPONENT(S) THAT IS CONSIDERED AN EXTREMELY
FLAMMABLE GAS(ES), WHICH HAS VAPORS THAT ARE HEAVIER THAN AIR AND MAY
TRAVEL ALONG THE GROUND OR BE MOVED BY VENTILATION AND IGNITED BY HEAT,
PILOT LIGHTS, OR OTHER FLAMES AND IGNITION SOURCES AT LOCATIONS DISTANT
FROM THE MATERIAL'S HANDLING POINT. THIS PRODUCT CONTAINS A COMPONENT(S)
THAT IS CONSIDERED A FLAMMABLE LIQUID, WHICH HAS VAPORS THAT ARE HEAVIER
THAN AIR AND MAY TRAVEL ALONG THE GROUND OR BE MOVED BY VENTILATION AND
IGNITED BY HEAT, PILOT LIGHTS, OR OTHER FLAMES AND IGNITION SOURCES AT
LOCATIONS DISTANT FROM THE MATERIAL'S HANDLING POINT.
FIRE FIGHTING INSTRUCTIONS:
USE CO2, FOAM OR DRY CHEMICAL. FIRE FIGHTERS SHOULD WEAR NORMAL PROTECTIVE
EQUIPMENT AND POSITIVE-PRESSURE SELF-CONTAINED BREATHING APPARATUS.
| 6. ACCIDENTAL RELEASE MEASURES | |
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED:
REMOVE ALL SOURCES OF IGNITION. WEAR APPROPRIATE PERSONAL PROTECTIVE
EQUIPMENT (PPE). STOP OR REDUCE DISCHARGE IF IT CAN BE DONE SAFELY.
VENTILATE CONTAMINATED AREA. AVOID RUN-OFF INTO STORM SEWERS AND DITCHES
WHICH MAY LEAD TO NATURAL WATERWAYS. IF RUNOFF OCCURS, NOTIFY AUTHORITIES
AS REQUIRED. CLEAN UP WITH ABSORBENT MATERIAL. PLACE ABSORBENT MATERIALS
INTO CONTAINER AND CLOSE IT TIGHTLY. DISPOSE OF CONTAINER PROPERLY.
| 7. HANDLING AND STORAGE | |
HANDLING:
THIS MATERIAL CAN BE HARMFUL OR IRRITATING. USE WITH ADEQUATE VENTILATION.
NORMAL PRECAUTIONS COMMON TO SAFE MANUFACTURING PRACTICE SHOULD BE FOLLOWED
IN HANDLING AND STORAGE. AVOID PROLONGED OR REPEATED BREATHING OF VAPOR.
AVOID PROLONGED OR REPEATED CONTACT WITH SKIN. DO NOT USE NEAR IGNITION
SOURCES.
STORAGE:
DO NOT STORE AT TEMPERATURES ABOVE 120 DEGREES F. STORE AWAY FROM
INCOMPATIBLE MATERIALS SUCH AS MATERIALS THAT SUPPORT COMBUSTION (OXIDIZING
MATERIALS) AND CORROSIVE MATERIALS (STRONG ACIDS OR BASES). STORE IN A
COOL, DRY, WELL VENTILATED AREA AWAY FROM ALL SOURCES OF IGNITION. EMPTY
CONTAINER MAY CONTAIN RESIDUES WHICH ARE HAZARDOUS. NORMAL PRECAUTIONS
COMMON TO SAFE MANUFACTURING PRACTICE SHOULD BE FOLLOWED IN HANDLING AND
STORAGE.
| 8. EXPOSURE CONTROLS / PERSONAL PROTECTION | |
ENGINEERING CONTROLS:
VENTILATION IS REQUIRED TO MAINTAIN OPERATOR EXPOSURE BELOW PUBLISHED
EXPOSURE LIMITS. VENTILATION SHOULD BE ADEQUATE TO PREVENT EXPOSURES ABOVE
THE LIMITS INDICATED IN "SECTION 2" OF THIS MSDS (FROM KNOWN, SUSPECTED OR
APPARENT ADVERSE EFFECTS).
EYE PROTECTION:
WEAR CHEMICALLY RESISTANT SAFETY GLASSES WITH SIDE SHIELDS WHEN HANDLING
THIS PRODUCT. WEAR ADDITIONAL EYE PROTECTION SUCH AS CHEMICAL SPLASH
GOGGLES AND/OR FACE SHIELD WHEN THE POSSIBILITY EXISTS FOR EYE CONTACT WITH
SPLASHING OR SPRAYING LIQUID OR AIRBORNE MATERIAL. DO NOT WEAR CONTACT
LENSES. HAVE AN EYE WASH STATION AVAILABLE.
SKIN PROTECTION:
THE USE OF CHEMICALLY RESISTANT GLOVES IS RECOMMENDED IF THERE IS ANY
POSSIBILITY OF PROLONGED OR REPEATED LIQUID CONTACT WITH SKIN.
RESPIRATORY PROTECTION:
A SUPPLIED AIR RESPIRATOR SHOULD BE USED IF VENTILATION IS NOT SUFFICIENT
TO MAINTAIN EXPOSURE LIMITS. USE NIOSH APPROVED RESPIRATOR WHERE THERE IS
LIKELIHOOD OF INHALATION OF THE PRODUCT MIST, SPRAY OR AEROSOL.
COMPONENT CAS # ACGIH TLV OSHA PEL OTHER
HYDROCARBON PROPELLANT 106-97-8 NOT NOT NOT
ESTABLISHED ESTABLISHED ESTABLISHED
NJ TRADE SECRET REGISTRY #80100382- NOT NOT NOT
5096P ESTABLISHED ESTABLISHED ESTABLISHED
ALIPHATIC HYDROCARBON 64741-66-8 NOT 500 PPM TWA 300 PPM
ESTABLISHED TWA-MFR.
RECOMMENDED
PETROLEUM DISTILLATES 8052-41-3 100 PPM TWA 500 PPM NOT
ESTABLISHED
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
PHYSICAL STATE: AEROSOL CAN
LOWER FLAMMABILITY LIMIT (%): NOT APPLICABLE
UPPER FLAMMABILITY LIMIT (%): NOT APPLICABLE
APPEARANCE: CLOUDY WHITE
ODOR: PETROLEUM SOLVENT
VAPOR PRESSURE (PSIG @ 70 DEG. F): 56.00
ODOR THRESHOLD: MILD
VAPOR DENSITY [AIR = 1]: 4.40
PH: NOT APPLICABLE
RELATIVE DENSITY (H2O=1): 0.54
MELTING/FREEZING POINT (DEG. F): NO DATA AVAILABLE
SOLUBILITY IN WATER: NEGLIGIBLE; 0-1%
BOILING POINT (DEG. F): NO DATA AVAILABLE
PARTIAL COEFFICIENT N-OCTANOL/WATER: NO DATA AVAILABLE
FLASH POINT (DEG. F PMCC): NOT APPLICABLE
AUTOIGNITION TEMPERATURE (DEG. F): NOT APPLICABLE
EVAPORATION RATE: 0.1-0.5 (N-BUTYL ACETATE = 1)
DECOMPOSITION TEMPERATURE (DEG. F): NO DATA AVAILABLE
FLAMMABILITY (SOLID, GAS): NO DATA AVAILABLE
VISCOSITY, DYNAMIC (CST): NO DATA AVAILABLE
PERCENT VOCS (%): 1-20
| 10. STABILITY AND REACTION | |
CHEMICAL STABILITY: STABLE.
CONDITIONS TO AVOID:
AVOID CONTACT WITH:
STRONG OXIDIZING AGENTS. IGNITION SOURCES SUCH AS OPEN FLAMES, SPARKS,
STATIC DISCHARGES OR GLOWING METAL SURFACES.
DECOMPOSITION PRODUCTS:
BURNING CAN PRODUCE THE FOLLOWING COMBUSTION PRODUCTS:
CARBON DIOXIDE AND CARBON MONOXIDE. VARIOUS HYDROCARBONS.
| 11. TOXICOLOGICAL INFORMATION | |
REPRODUCTIVE & DEVELOPMENTAL TOXICITY: NO DATA AVAILABLE.
INGREDIENT CAS # TOXICOLOGICAL DATA
ALIPHATIC HYDROCARBON 64741-66-8 DERMAL LD50 RABBIT: >3160 ML/KG
DERMAL LD50 RABBIT: >10000 ML/KG
PETROLEUM DISTILLATES 8052-41-3 DERMAL LD50 RABBIT: >3 G/KG
ORAL LD50 RAT: >5 G/KG
| 12. ECOLOGICAL INFORMATION | |
ECOLOGICAL TOXICITY:
MAY CAUSE LONG-TERM ADVERSE EFFECTS IN THE AQUATIC ENVIRONMENT.
MOBILITY: NO DATA AVAILABLE
INGREDIENT CAS # TOXICOLOGICAL DATA
NO DATA AVAILABLE
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL: DISPOSE ACCORDING TO FEDERAL, STATE AND LOCAL REGULATIONS.
| 14. TRANSPORTATION INFORMATION | |
AGENCY UN NUMBER PROPER SHIPPING NAME HAZARD CLASS PACKING GROUP
DOT UN1950 AEROSOLS, FLAMMABLE+ 2.1 NOT APPLICABLE
IATA ID8000 CONSUMER COMMODITY+ 9 NOT APPLICABLE
IMDG UN1950 AEROSOLS, FLAMMABLE+ 2.1 NOT APPLICABLE
+ "LIMITED QUANTITIES" MAY BE APPLICABLE FOR THIS TRANSPORTATION MODE.
| 15. REGULATORY INFORMATION | |
WARNING:
THIS PRODUCT CONTAINS THE FOLLOWING CHEMICALS THAT ARE SUBJECT TO REPORTING
REQUIREMENTS FOR THE FOLLOWING REGULATORY BODIES LISTED BELOW:
COMPONENT CAS # % BY WEIGHT REGULATORY BODY
NO COMPONENTS LISTED IN THIS SECTION. SARA SECTION 313
WARNING:
THIS PRODUCT MAY CONTAIN CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO
CAUSE CANCER. SEE LIST BELOW.
NO COMPONENTS LISTED IN THIS SECTION. PROP65 CANCER
WARNING:
THIS PRODUCT MAY CONTAIN CHEMICALS KNOWN TO THE STATE OF CALIFORNIA TO
CAUSE BIRTH DEFECTS. SEE LIST BELOW.
NO COMPONENTS LISTED IN THIS SECTION. PROP65 BIRTH DEFECTS
ALL COMPONENTS OF THIS PRODUCT ARE LISTED ON THE TSCA INVENTORY.
| 16. OTHER INFORMATION | |
OTHER INFORMATION: MSDS PREPARED BY L. DEAN SWARTZ, MSDS COORDINATOR
VERSION DATE: 04/17/15
THIS INFORMATION CONTAINED IN THIS MSDS IS BELIEVED TO BE ACCURATE AS
OF THE VERSION DATE, BUT IS NOT WARRANTED TO BE. SINCE THE USE OF THIS
INFORMATION AND THE CONDITIONS OF USE OF THIS PRODUCT ARE NOT WITHIN
THE CONTROL OF STONER INC, IT IS THE USER'S OBLIGATION TO DETERMINE THE
CONDITIONS OF SAFE USE.