| Common Name: | MS-752, VERTREL MCA CLEANING AGENT |
| Manufacturer: | MILLER-STEPHENSON CHEMICAL |
| SDS Revision Date: | 3/1/2015 |
| SDS Format: | GHS-US |
| Item Number(s): | 35RN54, 35RN55, 35RN56, 35RN57 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
MS(TM)
MILLER-STEPHENSON
SDS
SAFETY DATA SHEET
| 1. CHEMICAL PRODUCT/COMPANY IDENTIFICATION |  |
NAME:
MS-752
VERTREL MCA CLEANING AGENT
PRODUCT USE: CLEANING AGENT
MANUFACTURER/DISTRIBUTOR:
MILLER-STEPHENSON CHEMICAL
55 BACKUS AVE
DANBURY, CONN. 06810
USA
(203) 743-4447
EMERGENCY PHONE NUMBER: (800) 424-9300
| 2. HAZARDS IDENTIFICATION | |
HAZARD CLASSIFICATION:
SERIOUS EYE DAMAGE/IRRITATION: CATEGORY 2B.
SPECIFIC TARGET ORGAN TOXICITY (SINGLE EXPOSURE): CATEGORY 3.
LABEL ELEMENTS:
SIGNAL WORD: WARNING
PICTOGRAM: EXCLAMATION MARK
HAZARD STATEMENTS:
CAUSES EYE IRRITATION.
MAY CAUSE RESPIRATORY IRRITATION.
MAY CAUSE DROWSINESS OR DIZZINESS.
PREVENTION STATEMENTS:
AVOID BREATHING DUST/FUME/GAS/MIST/VAPORS/SPRAY.
WASH THOROUGHLY AFTER HANDLING.
USE ONLY IN A WELL-VENTILATED AREA.
IF INHALED:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
CALL A POISON CENTER OR DOCTOR/ PHYSICIAN IF YOU FEEL UNWELL
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ ATTENTION.
STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED.
DISPOSE OF CONTENTS/ CONTAINER TO AN APPROVED WASTE DISPOSAL PLANT.
OTHER HAZARDS:
VAPORS ARE HEAVIER THAN AIR AND CAN CAUSE SUFFOCATION BY REDUCING OXYGEN
AVAILABLE FOR BREATHING. PROLONGED SKIN CONTACT MAY DEFAT THE SKIN AND
PRODUCE DERMATITIS. MAY CAUSE CARDIAC ARRHYTHMIA. MISUSE OR INTENTIONAL
INHALATION ABUSE MAY LEAD TO DEATH WITHOUT WARNING.
| 3. INGREDIENTS | |
MATERIAL (S) CAS NO. APPROXIMATE %
1,1,1,2,2,3,4,5,5,5-DECAFLUOROPENTANE 138495-42-8 61 - 63
(HFC-43-10MEE)
TRANS,1,2-DICHLOROETHYLENE 156-60-5 37 - 39
| 4. FIRST AID MEASURES | |
INHALATION:
REMOVE PATIENT TO FRESH AIR, LIE DOWN. KEEP PATIENT WARM AND AT REST. IF
NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. GIVE OXYGEN AS NECESSARY, IF
QUALIFIED PERSONNEL IS AVAILABLE. GET MEDICAL ATTENTION IF NECESSARY.
EYE:
FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES, LIFTING EYELIDS
UNTIL NO EVIDENCE OF THE CHEMICAL REMAINS. GET MEDICAL ATTENTION. REMOVE
CONTACT LENSES, IF PRESENT AND EASY TO DO. CONTINUE TO RINSE.
SKIN:
WASH SKIN WITH WARM WATER AFTER CONTACT. WASH CONTAMINATED CLOTHING BEFORE
USE. GET MEDICAL ATTENTION IF NECESSARY.
ORAL:
DO NOT INDUCE VOMITING WITHOUT MEDICAL ADVICE. NEVER GIVE ANYTHING BY MOUTH
TO AN UNCONSCIOUS PERSON. GIVE 2 GLASSES OF WATER. IF VOMITING OCCURS, LEAN
VICTIM FORWARD TO REDUCE THE RISK OF ASPIRATION. CALL A PHYSICIAN.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
NO APPLICABLE DATA AVAILABLE.
NOTES TO PHYSICIAN: DO NOT GIVE ADRENALINE OR SIMILAR DRUGS.
| 5. FIRE FIGHTING MEASURES | |
FLAMMABILITY:
THIS PRODUCT IS NOT FLAMMABLE. DOES NOT FLASH USING PENSKY-MARTENS CLOSED
CUP - PMCC.
SUITABLE EXTINGUISHING MEDIA:
WATER SPRAY, WATER MIST, DRY CHEMICAL, CARBON DIOXIDE (CO2)
UNSUITABLE EXTINGUISHING MEDIA: NO APPLICABLE DATA AVAILABLE.
SPECIAL HAZARDS:
FIRE OR INTENSE HEAT MAY CAUSE VIOLENT RUPTURE OF PACKAGES. THE PRODUCT IS
NOT FLAMMABLE. HAZARDOUS COMBUSTION PRODUCTS: HYDROGEN FLUORIDE FLUORINATED
HYDROCARBONS CARBONYL FLUORIDE CARBON OXIDES HYDROGEN CHLORIDE
SPECIAL FIRE FIGHTING INSTRUCTION:
IN THE EVENT OF FIRE, WEAR SELF-CONTAINED BREATHING APPARATUS. USE PERSONAL
PROTECTIVE EQUIPMENT. WEAR NEOPRENE GLOVES DURING CLEANING UP WORK AFTER A
FIRE. EXPOSURE TO DECOMPOSITION PRODUCTS MAY BE A HAZARD TO HEALTH.
FURTHER INFORMATION:
USE EXTINGUISHING MEASURES THAT ARE APPROPRIATE TO LOCAL CIRCUMSTANCES AND
THE SURROUNDING ENVIRONMENT. EVACUATE PERSONNEL TO SAFE AREAS. COOL
CONTAINERS/TANKS WITH WATER SPRAY. FIRE RESIDUES AND CONTAMINATED FIRE
EXTINGUISHING WATER MUST BE DISPOSED OF IN ACCORDANCE WITH LOCAL
REGULATIONS.
| 6. ACCIDENTAL RELEASE MEASURES | |
SAFEGUARDS (PERSONNEL):
EVACUATE PERSONNEL TO SAFE AREA. VENTILATE AREA, ESPECIALLY LOW OR ENCLOSED
PLACES WHERE HEAVY VAPORS MIGHT COLLECT. IN CASE OF INSUFFICIENT
VENTILATION, WEAR SUITABLE RESPIRATORY EQUIPMENT.
ENVIRONMENTAL PRECAUTIONS:
IF CONTAINERS RUPTURE, PREVENT MATERIAL FROM ENTERING SEWERS, WATERWAYS,
OR LOW AREAS. SHOULD NOT BE RELEASED INTO THE ENVIRONMENT. DO NOT ALLOW
CONTACT WITH SOIL, SURFACE OR GROUND WATER.
SPILL CLEANUP:
CONTAIN SPILLAGE, AND THEN COLLECT WITH NON-COMBUSTIBLE ABSORBENT MATERIAL,
(E.G. SAND, EARTH, DIATOMACEOUS EARTH, VERMICULITE) AND PLACE IN CONTAINER
FOR DISPOSAL ACCORDING TO LOCAL / NATIONAL REGULATIONS
| 7. HANDLING AND STORAGE | |
HANDLING:
USE IN A WELL-VENTILATED AREA TO AVOID BREATHING VAPORS. VAPORS ARE HEAVIER
THAN AIR AND ACCUMULATE IN LOW AREAS. USE ONLY WITH ADEQUATE VENTILATION.
USE APPROPRIATE RESPIRATORY PROTECTION WHEN VENTILATIONS IS INADEQUATE.
WHEN USING DO NOT EAT, DRINK, OR SMOKE. AVOID CONTACT WITH SKIN, EYES OR
CLOTHING. WASH THOROUGHLY AFTER HANDLING.
STORAGE CONDITIONS:
STORE TIGHTLY SEALED IN A CLEAN, DRY PLACE, AND WELL VENTILATED PLACE. DO
NOT STORE IN TEMPERATURES THAT EXCEED 125 DEG. F/52 DEG. C, BECAUSE THE
CONTAINERS COULD LEAK OR RUPTURE FROM PRESSURE AND EXPANSION. PROTECT FROM
FREEZING TEMPERATURES. IF SOLVENT IS STORED BELOW -10 DEG. C (14 DEG. F),
MIX PRIOR TO USE.
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
EXPOSURE LIMITS:
TLV (ACGIH) PEL (OSHA) AEL (DUPONT)
1,1,1,2,2,3,4,5,5,5- NOT NOT 200 PPM, 8 & 12 HR. TWA
DECAFLUOROPENTANE ESTABLISHED ESTABLISHED 400 PPM, CEILING
TRANS,1,2- 200 PPM, 200 PPM, 200 PPM, 8 & 12 HR. TWA
DICHLOROETHYLENE TWA 8 HR. TWA
* AEL IS DUPONT'S ACCEPTABLE EXPOSURE LIMIT. WHERE GOVERNMENTALLY IMPOSED
OCCUPATIONAL EXPOSURE LIMITS WHICH IS LOWER THAN THE AEL ARE IN EFFECT,
SUCH LIMITS SHALL TAKE PRECEDENCE.
RESPIRATORY PROTECTION:
AVOID BREATHING VAPORS, MISTS OR SPRAY. USE WITH SUFFICIENT VENTILATION
ESPECIALLY FOR ENCLOSED OR LOW PLACES. VAPORS ARE HEAVIER THAN AIR AND CAN
CAUSE SUFFOCATION BY REDUCING OXYGEN. IN POORLY VENTILATED AREAS, USE AN
APPROVED SELF-CONTAINED BREATHING APPARATUS.
EYE PROTECTION:
AVOID EYE CONTACT. USE CHEMICAL GOGGLES OR SAFETY GLASSES WITH SIDE
SHIELDS.
SKIN PROTECTION:
AVOID CONTACT WITH SKIN. USE GLOVES IMPERVIOUS TO THIS MATERIAL WHEN
PROLONGED OR FREQUENTLY REPEATED CONTACT OCCURS.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
BOILING POINT: 102 DEG. F/39 DEG. C
PERCENT VOLATILE BY VOLUME: 100
DENSITY: 1.41 G/CC @ 77 DEG. F/25 DEG. C
VAPOR PRESSURE: 464 MMHg @ 77 DEG. F/25 DEG. C
VAPOR DENSITY (AIR=1): 5.4
SOLUBILITY IN H2O: 15 G/L @ 77 DEG. F/25 DEG. C
PH INFORMATION: NEUTRAL
EVAPORATION RATE (CC14=1): N.A.
FORM: LIQUID
APPEARANCE: CLEAR & COLORLESS
COLOR: COLORLESS
ODOR: ETHER-LIKE
| 10. STABILITY AND REACTIVITY | |
STABILITY: STABLE AT NORMAL TEMPERATURES AND STORAGE CONDITIONS.
CHEMICAL STABILITY: NO DECOMPOSITION IF STORED AND APPLIED AS DIRECTED.
POSSIBILITY OF HAZARDOUS REACTIONS: NO APPLICABLE DATE AVAILABLE.
MATERIAL AND CONDITIONS TO AVOID:
OPEN FLAMES AND HIGH TEMPERATURES. ALKALI OR ALKALINE EARTH METALS, POWDER
METALS, POWDERED METAL SALTS, STRONG BASES
DECOMPOSITION:
THIS PRODUCT CAN BE DECOMPOSED BY HIGH TEMPERATURES (FLAME, GLOWING METAL
SURFACES, ETC.) FORMING FLUORINATED HYDROCARBONS, HYDROGEN FLUORIDE, CARBON
DIOXIDE, CARBON MONOXIDE, CARBONYL FLUORIDE.
| 11. TOXICOLOGICAL INFORMATION | |
ANIMAL DATA:
1,1,1,2,2,3,4,5,5,5-DECAFLUOROPENTANE (HFC-43-10MEE):
INHALATION:
4 HOUR LC50: 114 MG/L IN RATS, CENTRAL NERVOUS SYSTEM EFFECTS, CONVULSIONS
ORAL:
LD50: >5,000 MG/KG IN RATS
DERMAL:
LD50: >5,000 MG/KG IN RABBITS
SKIN IRRITATION: NO SKIN IRRITATION, RABBIT
EYE IRRITATION: NO EYE IRRITATION, RABBIT
SKIN SENSITIZATION:
DID NOT CAUSE SENSITIZATION ON LABORATORY ANIMALS., GUINEA PIG
REPEATED DOSE TOXICITY: INHALATION, RAT
NO TOXICOLOGICALLY SIGNIFICANT EFFECTS WERE FOUND.
MUTAGENICITY: ANIMAL TESTING SHOWED NO MUTAGENIC EFFECTS.
REPRODUCTIVE TOXICITY: ANIMAL TESTING SHOWED NO REPRODUCTIVE TOXICITY.
TERATOGENICITY: ANIMAL TESTING SHOWED NO DEVELOPMENTAL TOXICITY.
TRANS-1,2-DICHLOROETHYLENE:
ORAL:
LD50: 7902 MG/KG IN RATS
DERMAL:
LD50: >5,000 MG/KG IN RABBITS
INHALATION:
4 HOUR LC50: 95.4 MG/L IN RATS
TARGET ORGANS: CENTRAL NERVOUS SYSTEM, NARCOSIS
SKIN IRRITATION: MILD SKIN IRRITATION IN RABBITS
EYE IRRITATION: MILD EYE IRRITATION IN RABBITS
REPEATED DOSE TOXICITY:
INHALATION, 90 DAYS IN RATS:
NO TOXICOLOGICALLY SIGNIFICANT EFFECTS WERE FOUND.
ORAL, 90 DAYS IN RATS: NO TOXICOLOGICALLY SIGNIFICANT EFFECTS WERE FOUND.
MUTAGENICITY: DID NOT CAUSE GENETIC DAMAGE IN ANIMALS.
TEST ON BACTERIAL OR MAMMALIAN CELL CULTURES DID NOT SHOW MUTAGENIC
EFFECTS.
REPRODUCTIVE TOXICITY: ANIMAL TESTING SHOWED NO REPRODUCTIVE TOXICITY.
TERATOGENICITY: ANIMAL TESTING SHOWED NO DEVELOPMENTAL TOXICITY.
| 12. ECOLOGICAL INFORMATION | |
AQUATIC TOXICITY:
HFC-43-10MEE:
96 HOUR LC50 IN FATHEAD MINNOWS: 27.2 MG/L
96 HOUR LC50 IN RAINBOW TROUT: 13.9 MG/L
48 HOUR LC50 IN DAPHNIA MAGNA: 11.7 MG/L
72 HOUR EC50 IN GREEN ALGAE: >120 MG/L
TRANS-1,2-DICHLOROETHYLENE:
96 HOUR LC50 IN BLUEGILL SUNFISH: 74 MG/L
48 HOUR LC50 IN DAPHNIA MAGNA: 79 MG/L
96 HOUR EC50 IN GREEN ALGAE: 798 MG/L
| 13. DISPOSAL CONSIDERATIONS | |
IF RECYCLING IS NOT PRACTICABLE, DISPOSE OF IN COMPLIANCE WITH LOCAL
REGULATIONS. REMOVE TO A PERMITTED WASTE DISPOSAL FACILITY. THE PRODUCT
SHOULD NOT BE ALLOWED TO ENTER DRAINS, WATER COURSES OR THE SOIL.
| 14. TRANSPORT INFORMATION | |
U.S. DOT: NOT REGULATED
IATA: NOT REGULATED
IMDG: NOT REGULATED
| 15. REGULATORY INFORMATION | |
U.S. FEDERAL REGULATIONS
TSCA: ALL INGREDIENTS ARE LISTED IN TSCA INVENTORY.
1,1,1,2,2,3,4,5,5,5-DECAFLUOROPENTANE (CAS# 138495-42-8) IS CONTROLLED BY
TSCA SECTION 5, SIGNIFICANT NEW USE RULE (SNUR; 40 CFR 721.5645) THE
APPROVED USES ARE: PRECISION AND GENERAL CLEANING, CARRIER FLUID,
DISPLACEMENT DRYING, PRINTED CIRCUIT BOARD CLEANING, PARTICULATE REMOVAL,
FILM CLEANING, PROCESS MEDIUM, HEAT TRANSFER FLUID (DIELECTRIC AND
NON-DIELECTRIC), AND TEST FLUID. PROCESSORS AND USERS OF THIS SUBSTANCE
MUST ALSO COMPLY WITH THE APPLICABLE GENERAL SNUR REQUIREMENTS SET FORTH
IN 40 CFR 721 SUBPART A, INCLUDING EXPORT NOTIFICATION REQUIREMENTS IF
APPLICABLE (40 CFR 721.20), AND THE APPLICABLE RECORD KEEPING REQUIREMENTS
SET FORTH AT 40 CFR 721.125.
SARA 313 REGULATED CHEMICALS: TRANS-DICHLOROETHYLENE
| 16. OTHER INFORMATION | |
NPCA-HMIS RATINGS:
HEALTH 1
FLAMMABILITY 0
REACTIVITY 1
PERSONAL PROTECTIVE RATING TO BE SUPPLIED BY USER DEPENDING ON THE
CONDITIONS.
FOR INDUSTRIAL USE ONLY
REVISION DATE: MARCH 2015
THE INFORMATION PROVIDED IN THIS SAFETY DATA SHEET IS CORRECT TO THE BEST
OF OUR KNOWLEDGE, INFORMATION AND BELIEF AT THE DATE OF ITS PUBLICATION.
THE INFORMATION GIVEN IS DESIGNED ONLY AS A GUIDANCE FOR SAFE HANDLING,
USE, PROCESSING, STORAGE, TRANSPORTATION, DISPOSAL AND RELEASE AND IS NOT
TO BE CONSIDERED A WARRANTY OR QUALITY SPECIFICATION. THE INFORMATION
RELATES ONLY TO THE SPECIFIC MATERIAL DESIGNATED AND MAY NOT BE VALID FOR
SUCH MATERIAL USED IN COMBINATION WITH ANY OTHER MATERIALS OR IN ANY
PROCESS, UNLESS SPECIFIED IN THE TEXT. FINAL DETERMINATION OF SUITABILITY
OF ANY MATERIAL IS THE SOLE RESPONSIBILITY OF THE USER.