| Common Name: | BRAKLEEN BRAKE PARTS CLEANER WITH TRIGGER - 19 OZ NO. 05089T (ITEM 1003711) |
| Manufacturer: | CRC INDUSTRIES |
| SDS Revision Date: | 4/3/2019 |
| SDS Format: | GHS-US |
| Item Number(s): | 35WT63 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
CRC(R*)
SAFETY DATA SHEET
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFIER: BRAKLEEN(R*) BRAKE PARTS CLEANER WITH TRIGGER - 19 OZ
OTHER MEANS OF IDENTIFICATION:
PRODUCT CODE: NO. 05089T (ITEM# 1003711)
RECOMMENDED USE: BRAKE PARTS CLEANER
RECOMMENDED RESTRICTIONS: NONE KNOWN.
MANUFACTURER/IMPORTER/SUPPLIER/DISTRIBUTOR INFORMATION:
MANUFACTURED OR SOLD BY:
COMPANY NAME: CRC INDUSTRIES, INC.
ADDRESS:
885 LOUIS DR.
WARMINSTER, PA 18974
US
TELEPHONE:
GENERAL INFORMATION: 215-674-4300
TECHNICAL ASSISTANCE: 800-521-3168
CUSTOMER SERVICE: 800-272-4620
24-HOUR EMERGENCY (CHEMTREC): 800-424-9300 (US)
WEBSITE: WWW.CRCINDUSTRIES.COM
| 2. HAZARD(S) IDENTIFICATION | |
PHYSICAL HAZARDS:
GASES UNDER PRESSURE: COMPRESSED GAS
HEALTH HAZARDS:
SKIN CORROSION/IRRITATION: CATEGORY 2
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 2B
SENSITIZATION, SKIN: CATEGORY 1B
CARCINOGENICITY: CATEGORY 1B
SPECIFIC TARGET ORGAN TOXICITY, SINGLE EXPOSURE:
CATEGORY 3 NARCOTIC EFFECTS
ENVIRONMENTAL HAZARDS:
HAZARDOUS TO THE AQUATIC ENVIRONMENT, LONG-TERM HAZARD: CATEGORY 2
OSHA DEFINED HAZARDS: NOT CLASSIFIED.
LABEL ELEMENTS:
GAS CYLINDER
HEALTH HAZARD
EXCLAMATION MARK
SIGNAL WORD: DANGER
HAZARD STATEMENT:
CONTAINS GAS UNDER PRESSURE; MAY EXPLODE IF HEATED. CAUSES SKIN IRRITATION.
MAY CAUSE AN ALLERGIC SKIN REACTION. CAUSES EYE IRRITATION. MAY CAUSE
DROWSINESS OR DIZZINESS. MAY CAUSE CANCER. TOXIC TO AQUATIC LIFE WITH LONG
LASTING EFFECTS.
PRECAUTIONARY STATEMENT:
PREVENTION:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. DO NOT PUNCTURE OR INCINERATE
CONTAINER. DO NOT EXPOSE TO HEAT OR STORE AT TEMPERATURES ABOVE
49 DEG. C/120 DEG. F. USE WITH ADEQUATE VENTILATION. OPEN DOORS AND WINDOWS
OR USE OTHER MEANS TO ENSURE A FRESH AIR SUPPLY DURING USE AND WHILE
PRODUCT IS DRYING. IF YOU EXPERIENCE ANY SYMPTOMS LISTED ON THIS LABEL,
INCREASE VENTILATION OR LEAVE THE AREA. WASH THOROUGHLY AFTER HANDLING.
CONTAMINATED WORK CLOTHING MUST NOT BE ALLOWED OUT OF THE WORKPLACE. AVOID
RELEASE TO THE ENVIRONMENT. WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE
PROTECTION/FACE PROTECTION.
RESPONSE:
IF ON SKIN: WASH WITH PLENTY OF WATER.
IF SKIN IRRITATION OR RASH OCCURS:
GET MEDICAL ADVICE/ATTENTION. TAKE OFF CONTAMINATED CLOTHING AND WASH
BEFORE REUSE.
IF INHALED: REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE
FOR BREATHING.
IF IN EYES: RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES.
REMOVE CONTACT LENSES, IF PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
IF EXPOSED OR CONCERNED:
GET MEDICAL ADVICE/ATTENTION. COLLECT SPILLAGE.
STORAGE:
STORE LOCKED UP. PROTECT FROM SUNLIGHT. STORE IN A WELL-VENTILATED PLACE.
EXPOSURE TO HIGH TEMPERATURE MAY CAUSE CAN TO BURST.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH LOCAL/REGIONAL/NATIONAL
REGULATIONS.
HAZARD(S) NOT OTHERWISE CLASSIFIED (HNOC): NONE KNOWN.
SUPPLEMENTAL INFORMATION:
WHEN EXPOSED TO EXTREME HEAT OR HOT SURFACES, VAPORS MAY DECOMPOSE TO
HARMFUL OR FATAL CORROSIVE GASES SUCH AS HYDROGEN CHLORIDE AND POSSIBLY
PHOSGENE.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
MIXTURES:
CHEMICAL NAME COMMON NAME AND SYNONYMS CAS NUMBER %
TETRACHLOROETHYLENE PERCHLOROETHYLENE 127-18-4 90 - 100
CARBON DIOXIDE 124-38-9 1 - 5
SPECIFIC CHEMICAL IDENTITY AND/OR PERCENTAGE OF COMPOSITION HAS BEEN
WITHHELD AS A TRADE SECRET.
| 4. FIRST-AID MEASURES | |
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
SKIN CONTACT:
REMOVE CONTAMINATED CLOTHING IMMEDIATELY AND WASH SKIN WITH SOAP AND WATER.
IN CASE OF ECZEMA OR OTHER SKIN DISORDERS:
SEEK MEDICAL ATTENTION AND TAKE ALONG THESE INSTRUCTIONS.
IF SKIN IRRITATION OR RASH OCCURS: GET MEDICAL ADVICE/ATTENTION.
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.
REMOVE CONTACT LENSES, IF PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
INGESTION:
IN THE UNLIKELY EVENT OF SWALLOWING CONTACT A PHYSICIAN OR POISON CONTROL
CENTER. RINSE MOUTH. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
MAY CAUSE DROWSINESS AND DIZZINESS. HEADACHE. NAUSEA, VOMITING. IRRITATION
OF EYES AND MUCOUS MEMBRANES. EXPOSED INDIVIDUALS MAY EXPERIENCE EYE
TEARING, REDNESS, AND DISCOMFORT. IRRITATION OF NOSE AND THROAT. SKIN
IRRITATION. MAY CAUSE REDNESS AND PAIN. MAY CAUSE AN ALLERGIC SKIN
REACTION. DERMATITIS. RASH.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
PROVIDE GENERAL SUPPORTIVE MEASURES AND TREAT SYMPTOMATICALLY. KEEP VICTIM
UNDER OBSERVATION. SYMPTOMS MAY BE DELAYED.
GENERAL INFORMATION:
IF EXPOSED OR CONCERNED: GET MEDICAL ADVICE/ATTENTION.
ENSURE THAT MEDICAL PERSONNEL ARE AWARE OF THE MATERIAL(S) INVOLVED, AND
TAKE PRECAUTIONS TO PROTECT THEMSELVES. WASH CONTAMINATED CLOTHING BEFORE
REUSE.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
WATER FOG. FOAM. DRY CHEMICAL POWDER. CARBON DIOXIDE (CO2), OR WATER SPRAY.
UNSUITABLE EXTINGUISHING MEDIA:
DO NOT USE WATER JET AS AN EXTINGUISHER, AS THIS WILL SPREAD THE FIRE.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
CONTENTS UNDER PRESSURE. PRESSURIZED CONTAINER MAY RUPTURE WHEN EXPOSED
TO HEAT OR FLAME. DURING FIRE, GASES HAZARDOUS TO HEALTH MAY BE FORMED.
WHEN EXPOSED TO EXTREME HEAT OR HOT SURFACES, VAPORS MAY DECOMPOSE TO
HARMFUL OR FATAL CORROSIVE GASES SUCH AS HYDROGEN CHLORIDE AND POSSIBLY
PHOSGENE.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIRE-FIGHTERS:
FIREFIGHTERS MUST USE STANDARD PROTECTIVE EQUIPMENT INCLUDING FLAME
RETARDANT COAT, HELMET WITH FACE SHIELD, GLOVES, RUBBER BOOTS, AND IN
ENCLOSED SPACES, SCBA.
FIRE-FIGHTING EQUIPMENT/INSTRUCTIONS:
IN CASE OF FIRE:
STOP LEAK IF SAFE TO DO SO. MOVE CONTAINERS FROM FIRE AREA IF YOU CAN DO
SO WITHOUT RISK. CONTAINERS SHOULD BE COOLED WITH WATER TO PREVENT VAPOR
PRESSURE BUILD UP.
GENERAL FIRE HAZARDS:
CONTENTS UNDER PRESSURE. PRESSURIZED CONTAINER MAY RUPTURE WHEN EXPOSED TO
HEAT OR FLAME.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
KEEP UNNECESSARY PERSONNEL AWAY. KEEP PEOPLE AWAY FROM AND UPWIND OF
SPILL/LEAK. KEEP OUT OF LOW AREAS. MANY GASES ARE HEAVIER THAN AIR AND
WILL SPREAD ALONG GROUND AND COLLECT IN LOW OR CONFINED AREAS
(SEWERS, BASEMENTS, TANKS). WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND
CLOTHING DURING CLEAN-UP. AVOID BREATHING MIST OR VAPOR. EMERGENCY
PERSONNEL NEED SELF-CONTAINED BREATHING EQUIPMENT. DO NOT TOUCH DAMAGED
CONTAINERS OR SPILLED MATERIAL UNLESS WEARING APPROPRIATE PROTECTIVE
CLOTHING. VENTILATE CLOSED SPACES BEFORE ENTERING THEM. LOCAL AUTHORITIES
SHOULD BE ADVISED IF SIGNIFICANT SPILLAGES CANNOT BE CONTAINED.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
ELIMINATE ALL IGNITION SOURCES (NO SMOKING, FLARES, SPARKS, OR FLAMES IN
IMMEDIATE AREA). KEEP COMBUSTIBLES (WOOD, PAPER, OIL, ETC.) AWAY FROM
SPILLED MATERIAL. COLLECT SPILLAGE. THIS MATERIAL IS CLASSIFIED AS A WATER
POLLUTANT UNDER THE CLEAN WATER ACT AND SHOULD BE PREVENTED FROM
CONTAMINATING SOIL OR FROM ENTERING SEWAGE AND DRAINAGE SYSTEMS WHICH LEAD
TO WATERWAYS. STOP THE FLOW OF MATERIAL, IF THIS IS WITHOUT RISK. WIPE UP
WITH ABSORBENT MATERIAL (E.G. CLOTH, FLEECE). CLEAN SURFACE THOROUGHLY TO
REMOVE RESIDUAL CONTAMINATION. PUT MATERIAL IN SUITABLE, COVERED,
LABELED CONTAINERS. FOR WASTE DISPOSAL, SEE SECTION 13 OF THE SDS.
ENVIRONMENTAL PRECAUTIONS:
AVOID RELEASE TO THE ENVIRONMENT. INFORM APPROPRIATE MANAGERIAL OR
SUPERVISORY PERSONNEL OF ALL ENVIRONMENTAL RELEASES. PREVENT FURTHER
LEAKAGE OR SPILLAGE IF SAFE TO DO SO. DO NOT CONTAMINATE WATER. AVOID
DISCHARGE INTO DRAINS, WATER COURSES OR ONTO THE GROUND.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD.
PRESSURIZED CONTAINER:
DO NOT PIERCE OR BURN, EVEN AFTER USE. USE WITH ADEQUATE VENTILATION. OPEN
DOORS AND WINDOWS OR USE OTHER MEANS TO ENSURE A FRESH AIR SUPPLY DURING
USE AND WHILE PRODUCT IS DRYING. IF YOU EXPERIENCE ANY SYMPTOMS LISTED ON
THIS LABEL, INCREASE VENTILATION OR LEAVE THE AREA. DO NOT USE IF SPRAY
BUTTON IS MISSING OR DEFECTIVE. DO NOT SPRAY ON A NAKED FLAME OR ANY OTHER
INCANDESCENT MATERIAL. DO NOT SMOKE WHILE USING OR UNTIL SPRAYED SURFACE IS
THOROUGHLY DRY. DO NOT CUT, WELD, SOLDER, DRILL, GRIND, OR EXPOSE
CONTAINERS TO HEAT, FLAME, SPARKS, OR OTHER SOURCES OF IGNITION. USE
CAUTION AROUND ENERGIZED EQUIPMENT. THE METAL CONTAINER WILL CONDUCT
ELECTRICITY IF IT CONTACTS A LIVE SOURCE. THIS MAY RESULT IN INJURY TO THE
USER FROM ELECTRICAL SHOCK AND/OR FLASH FIRE. AVOID BREATHING MIST OR
VAPOR. AVOID CONTACT WITH EYES, SKIN, AND CLOTHING. AVOID PROLONGED
EXPOSURE. SHOULD BE HANDLED IN CLOSED SYSTEMS, IF POSSIBLE. USE ONLY IN
WELL-VENTILATED AREAS. WEAR APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT.
AVOID RELEASE TO THE ENVIRONMENT. DO NOT EMPTY INTO DRAINS. OBSERVE GOOD
INDUSTRIAL HYGIENE PRACTICES. FOR PRODUCT USAGE INSTRUCTIONS, SEE THE
PRODUCT LABEL.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
LEVEL 1 AEROSOL.
CONTENTS UNDER PRESSURE. DO NOT HANDLE OR STORE NEAR AN OPEN FLAME, HEAT OR
OTHER SOURCES OF IGNITION. DO NOT PUNCTURE OR INCINERATE CONTAINER. DO NOT
EXPOSE TO HEAT OR STORE AT TEMPERATURES ABOVE 49 DEG. C/120 DEG. F. PROTECT
FROM SUNLIGHT. STORE IN A WELL-VENTILATED PLACE. STORE IN COOL PLACE.
EXPOSURE TO HIGH TEMPERATURE MAY CAUSE CAN TO BURST. STORE AWAY FROM
INCOMPATIBLE MATERIALS (SEE SECTION 10 OF THE SDS).
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
OCCUPATIONAL EXPOSURE LIMITS:
THE FOLLOWING CONSTITUENTS ARE THE ONLY CONSTITUENTS OF THE PRODUCT WHICH
HAVE A PEL, TLV OR OTHER RECOMMENDED EXPOSURE LIMIT. AT THIS TIME, THE
OTHER CONSTITUENTS HAVE NO KNOWN EXPOSURE LIMITS.
US. OSEA TABLE Z-1 LIMITS FOR AIR CONTAMINANTS (29 CFR 1910.1000):
COMPONENTS TYPE VALUE
CARBON DIOXIDE PEL 9000 MG/M3
(CAS 124-38-9)
5000 PPM
US. OSEA TABLE Z-2 (29 CFR 1910.1000):
COMPONENTS TYPE VALUE
TETRACHLOROETHYLENE CEILING 200 PPM
(CAS 127-18-4)
TWA 100 PPM
US. ACGIE THRESHOLD LIMIT VALUES COMPONENTS:
COMPONENTS TYPE VALUE
CARBON DIOXIDE STEL 30000 PPM
(CAS 124-38-9)
TWA 5000 PPM
TETRACHLOROETHYLENE STEL 100 PPM
(CAS 127-18-4)
TWA 25 PPM
US. NIOSH: POCKET GUIDE TO CHEMICAL HAZARDS.
COMPONENTS TYPE VALUE
CARBON DIOXIDE STEL 54000 MG/M3
(CAS 124-38-9)
TWA 30000 PPM
9000 MG/M3
5000 PPM
BIOLOGICAL LIMIT VALUES:
ACGIH BIOLOGICAL EXPOSURE INDICES:
COMPONENTS VALUE DETERMINANT SPECIMEN SAMPLING TIME
TETRACHLOROETHYLENE 0.5 MG/L TETRACHLOROETHY BLOOD *
(CAS 127-18-4) LENE
3 PPM TETRACHLOROETHY END-EXHALED *
LENE AIR
* - FOR SAMPLING DETAILS, PLEASE SEE THE SOURCE DOCUMENT.
EXPOSURE GUIDELINES:
US - MINNESOTA HAZ SUBS:
SKIN DESIGNATION APPLIES:
TETRACHLOROETHYLENE (CAS 127-18-4) SKIN DESIGNATION APPLIES.
APPROPRIATE ENGINEERING CONTROLS:
GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER HOUR) SHOULD BE
USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS. IF APPLICABLE,
USE PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING
CONTROLS TO MAINTAIN AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS.
IF EXPOSURE LIMITS HAVE NOT BEEN ESTABLISHED, MAINTAIN AIRBORNE LEVELS
TO AN ACCEPTABLE LEVEL. EYE WASH FACILITIES AND EMERGENCY SHOWER SHOULD
BE AVAILABLE WHEN HANDLING THIS PRODUCT. PROVIDE EYEWASH STATION.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION: WEAR SAFETY GLASSES WITH SIDE SHIELDS (OR GOGGLES).
SKIN PROTECTION:
HAND PROTECTION:
WEAR PROTECTIVE GLOVES SUCH AS:
NITRILE. VITON/BUTYL. POLYVINYL ALCOHOL (PVA). SILVER SHIELD(R*).
OTHER: WEAR APPROPRIATE CHEMICAL RESISTANT CLOTHING.
RESPIRATORY PROTECTION:
IF ENGINEERING CONTROLS ARE NOT FEASIBLE OR IF EXPOSURE EXCEEDS THE
APPLICABLE EXPOSURE LIMITS, USE A NIOSH-APPROVED CARTRIDGE RESPIRATOR WITH
AN ORGANIC VAPOR CARTRIDGE. USE A SELF-CONTAINED BREATHING APPARATUS IN
CONFINED SPACES AND FOR EMERGENCIES. AIR MONITORING IS NEEDED TO DETERMINE
ACTUAL EMPLOYEE EXPOSURE LEVELS.
THERMAL HAZARDS:
WEAR APPROPRIATE THERMAL PROTECTIVE CLOTHING, WHEN NECESSARY.
GENERAL HYGIENE CONSIDERATIONS:
OBSERVE ANY MEDICAL SURVEILLANCE REQUIREMENTS. WHEN USING DO NOT SMOKE.
ALWAYS OBSERVE GOOD PERSONAL HYGIENE MEASURES, SUCH AS WASHING AFTER
HANDLING THE MATERIAL AND BEFORE EATING, DRINKING, AND/OR SMOKING.
ROUTINELY WASH WORK CLOTHING AND PROTECTIVE EQUIPMENT TO REMOVE
CONTAMINANTS. CONTAMINATED WORK CLOTHING SHOULD NOT BE ALLOWED OUT OF
THE WORKPLACE.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: LIQUID.
FORM: AEROSOL.
COLOR: COLORLESS.
ODOR: IRRITATING.
ODOR THRESHOLD: 50 PPM
PH: NOT AVAILABLE.
MELTING POINT/FREEZING POINT: -8.1 DEG. F (-22.3 DEG. C) ESTIMATED
INITIAL BOILING POINT AND BOILING RANGE:
250.3 DEG. F (121.3 DEG. C) ESTIMATED
FLASH POINT: NONE
EVAPORATION RATE: VERY FAST.
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS:
FLAMMABILITY LIMIT - LOWER (%): NOT AVAILABLE.
FLAMMABILITY LIMIT - UPPER (%): NOT AVAILABLE.
VAPOR PRESSURE: 1264.5 HPA ESTIMATED
VAPOR DENSITY: 5.76 (AIR = 1)
RELATIVE DENSITY: 1.62
SOLUBILITY(IES) SOLUBILITY (WATER): 0.02% (77 DEG. F (25 DEG. C))
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
VISCOSITY: NOT AVAILABLE.
PERCENT VOLATILE: 97.8% ESTIMATED
OTHER INFORMATION:
PARTITION COEFFICIENT (OIL/WATER): 2.88
| 10. STABILITY AND REACTIVITY | |
REACTIVITY:
THE PRODUCT IS STABLE AND NON-REACTIVE UNDER NORMAL CONDITIONS OF USE,
STORAGE AND TRANSPORT.
CHEMICAL STABILITY: MATERIAL IS STABLE UNDER NORMAL CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS:
NO DANGEROUS REACTION KNOWN UNDER CONDITIONS OF NORMAL USE.
CONDITIONS TO AVOID:
HEAT, FLAMES AND SPARKS. CONTACT WITH INCOMPATIBLE MATERIALS. WHEN EXPOSED
TO EXTREME HEAT OR HOT SURFACES, VAPORS MAY DECOMPOSE TO HARMFUL OR FATAL
CORROSIVE GASES SUCH AS HYDROGEN CHLORIDE AND POSSIBLY PHOSGENE.
INCOMPATIBLE MATERIALS:
STRONG OXIDIZING AGENTS. STRONG ACIDS. STRONG BASES.
HAZARDOUS DECOMPOSITION PRODUCTS:
HYDROGEN CHLORIDE. TRACE AMOUNTS OF CHLORINE AND PHOSGENE. CARBON OXIDES.
HALOGENATED MATERIALS. CARBONYL HALIDES.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INHALATION: PROLONGED INHALATION MAY BE HARMFUL. MAY CAUSE DROWSINESS AND
DIZZINESS. HEADACHE. NAUSEA, VOMITING.
SKIN CONTACT: CAUSES SKIN IRRITATION. MAY CAUSE AN ALLERGIC SKIN REACTION.
EYE CONTACT: CAUSES EYE IRRITATION.
INGESTION:
INGESTION OF LARGE AMOUNTS MAY PRODUCE GASTROINTESTINAL DISTURBANCES
INCLUDING IRRITATION, NAUSEA, AND DIARRHEA.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
MAY CAUSE DROWSINESS AND DIZZINESS. HEADACHE. NAUSEA, VOMITING. IRRITATION
OF EYES AND MUCOUS MEMBRANES. EXPOSED INDIVIDUALS MAY EXPERIENCE EYE
TEARING, REDNESS, AND DISCOMFORT. IRRITATION OF NOSE AND THROAT.
SKIN IRRITATION. MAY CAUSE REDNESS AND PAIN. MAY CAUSE AN ALLERGIC SKIN
REACTION. DERMATITIS. RASH.
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY: NONE KNOWN.
COMPONENTS SPECIES TEST RESULTS
CARBON DIOXIDE (CAS 124-38-9):
ACUTE:
INHALATION:
GAS:
LC50 RAT 470000 PPM, 30 MINUTES
* ESTIMATES FOR PRODUCT MAY BE BASED ON ADDITIONAL COMPONENT DATA NOT
SHOWN.
SKIN CORROSION/IRRITATION: CAUSES SKIN IRRITATION.
SERIOUS EYE DAMAGE/EYE IRRITATION:
CAUSES EYE IRRITATION.
RESPIRATORY OR SKIN SENSITIZATION:
RESPIRATORY SENSITIZATION: NOT A RESPIRATORY SENSITIZER.
SKIN SENSITIZATION: MAY CAUSE AN ALLERGIC SKIN REACTION.
GERM CELL MUTAGENICITY:
NO DATA AVAILABLE TO INDICATE PRODUCT OR ANY COMPONENTS PRESENT AT GREATER
THAN 0.1% ARE MUTAGENIC OR GENOTOXIC.
CARCINOGENICITY: MAY CAUSE CANCER.
IARC MONOGRAPHS. OVERALL EVALUATION OF CARCINOGENICITY:
TETRACHLOROETHYLENE (CAS 127-18-4): 2A PROBABLY CARCINOGENIC TO HUMANS.
OSEA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1052):
NOT REGULATED.
US. NATIONAL TOXICOLOGY PROGRAM (NTP) REPORT ON CARCINOGENS:
TETRACHLOROETHYLENE (CAS 127-18-4):
REASONABLY ANTICIPATED TO BE A HUMAN CARCINOGEN.
REPRODUCTIVE TOXICITY:
THIS PRODUCT IS NOT EXPECTED TO CAUSE REPRODUCTIVE OR DEVELOPMENTAL
EFFECTS.
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE:
MAY CAUSE DROWSINESS AND DIZZINESS.
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE: NOT CLASSIFIED.
ASPIRATION HAZARD: NOT AN ASPIRATION HAZARD.
CHRONIC EFFECTS:
PROLONGED INHALATION MAY BE HARMFUL. PROLONGED EXPOSURE MAY CAUSE CHRONIC
EFFECTS.
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY: TOXIC TO AQUATIC LIFE WITH LONG LASTING EFFECTS.
ACCUMULATION IN AQUATIC ORGANISMS IS EXPECTED.
COMPONENTS SPECIES TEST RESULTS
TETRACHLOROETHYLENE (CAS 127-18-4):
AQUATIC:
CRUSTACEA EC50 WATER FLEA (DAPHNIA MAGNA) 6.1 - 9 MG/L, 48 HOURS
FISH LC50 RAINBOW TROUT, 4.82 MG/L, 96 HOURS
DONALDSON TROUT
(ONCORHYNCHUS
MYKISS)
* ESTIMATES FOR PRODUCT MAY BE BASED ON ADDITIONAL COMPONENT DATA NOT
SHOWN.
PERSISTENCE AND DEGRADABILITY:
NO DATA IS AVAILABLE ON THE DEGRADABILITY OF THIS PRODUCT.
BIOACCUMULATIVE POTENTIAL:
PARTITION COEFFICIENT N-OCTANOL / WATER (LOG KOW):
TETRACHLOROETHYLENE: 3.4
MOBILITY IN SOIL: NO DATA AVAILABLE.
OTHER ADVERSE EFFECTS:
NO OTHER ADVERSE ENVIRONMENTAL EFFECTS (E.G. OZONE DEPLETION, PHOTOCHEMICAL
OZONE CREATION POTENTIAL, ENDOCRINE DISRUPTION, GLOBAL WARMING POTENTIAL)
ARE EXPECTED FROM THIS COMPONENT.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL INSTRUCTIONS:
THIS MATERIAL AND ITS CONTAINER MUST BE DISPOSED OF AS HAZARDOUS WASTE.
CONSULT AUTHORITIES BEFORE DISPOSAL. CONTENTS UNDER PRESSURE. DO NOT
PUNCTURE, INCINERATE OR CRUSH. DO NOT ALLOW THIS MATERIAL TO DRAIN INTO
SEWERS/WATER SUPPLIES. DO NOT CONTAMINATE PONDS, WATERWAYS OR DITCHES WITH
CHEMICAL OR USED CONTAINER. DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
REGULATIONS.
HAZARDOUS WASTE CODE:
D039: WASTE TETRACHLOROETHYLENE
F001:
WASTE HALOGENATED SOLVENT - SPENT HALOGENATED SOLVENT USED IN DEGREASING
F002: WASTE HALOGENATED SOLVENT - SPENT HALOGENATED SOLVENT
US RCRA HAZARDOUS WASTE U LIST:
REFERENCE:
TETRACHLOROETHYLENE (CAS 127-18-4) U210
CONTAMINATED PACKAGING:
SINCE EMPTIED CONTAINERS MAY RETAIN PRODUCT RESIDUE, FOLLOW LABEL WARNINGS
EVEN AFTER CONTAINER IS EMPTIED. EMPTY CONTAINERS SHOULD BE TAKEN TO AN
APPROVED WASTE HANDLING SITE FOR RECYCLING OR DISPOSAL.
| 14. TRANSPORT INFORMATION | |
DOT:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, POISON, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.2
SUBSIDIARY RISK: 6.1(PGIII)
LABEL(S): 2.2, 6.1
PACKING GROUP: NOT APPLICABLE.
SPECIAL PRECAUTIONS FOR USER: FORBIDDEN FROM TRANSPORTATION BY AIR.
PACKAGING EXCEPTIONS: 306
PACKAGING NON BULK: NONE
PACKAGING BULK: NONE
IATA:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME:
AEROSOLS, NON-FLAMMABLE, CONTAINING SUBSTANCES IN DIVISION 6.1, PACKING
GROUP III
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.2
SUBSIDIARY RISK: 6.1(PGIII)
PACKING GROUP: NOT APPLICABLE.
ERG CODE: 2P
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
OTHER INFORMATION:
PASSENGER AND CARGO AIRCRAFT: ALLOWED WITH RESTRICTIONS.
CARGO AIRCRAFT ONLY: ALLOWED WITH RESTRICTIONS.
IMDG:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.2
SUBSIDIARY RISK: 6.1(PGIII)
PACKING GROUP: NOT APPLICABLE.
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: YES, BUT EXEMPT FROM THE REGULATIONS.
EMS: NOT AVAILABLE.
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
DOT: LIMITED QUANTITY FOR PACKAGES NOT PREPARED FOR AIR TRANSPORT
IATA; IMDG:
CLASS 2.2, NON-FLAMMABLE AND NON-TOXIC GASES
CLASS 6.1, TOXIC
| 15. REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
TSCA SECTION 12(B) EXPORT NOTIFICATION (40 CFR 707, SUBPT. D):
NOT REGULATED.
SARA 304 EMERGENCY RELEASE NOTIFICATION: NOT REGULATED.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1052):
NOT REGULATED.
US EPCRA (SARA TITLE III) SECTION 313 - TOXIC CHEMICAL:
LISTED SUBSTANCE: TETRACHLOROETHYLENE (CAS 127-18-4)
CERCLA HAZARDOUS SUBSTANCE LIST (40 CFR 302.4):
TETRACHLOROETHYLENE (CAS 127-18-4)
CERCLA HAZARDOUS SUBSTANCES:
REPORTABLE QUANTITY:
TETRACHLOROETHYLENE (CAS 127-18-4) 100 LBS
SPILLS OR RELEASES RESULTING IN THE LOSS OF ANY INGREDIENT AT OR ABOVE
ITS RQ REQUIRE IMMEDIATE NOTIFICATION TO THE NATIONAL RESPONSE CENTER
(800-424-8802) AND TO YOUR LOCAL EMERGENCY PLANNING COMMITTEE.
OTHER FEDERAL REGULATIONS:
CLEAN AIR ACT (CAA) SECTION 112 HAZARDOUS AIR POLLUTANTS (HAPS) LIST:
TETRACHLOROETHYLENE (CAS 127-18-4)
CLEAN AIR ACT (CAA) SECTION 112(R) ACCIDENTAL RELEASE PREVENTION (40 CFR
68.130): NOT REGULATED.
SAFE DRINKING WATER ACT (SDWA): NOT REGULATED.
FOOD AND DRUG ADMINISTRATION (FDA): NOT REGULATED.
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA):
CLASSIFIED HAZARD CATEGORIES:
GAS UNDER PRESSURE
SKIN CORROSION OR IRRITATION
SERIOUS EYE DAMAGE OR EYE IRRITATION
RESPIRATORY OR SKIN SENSITIZATION
CARCINOGENICITY
SPECIFIC TARGET ORGAN TOXICITY (SINGLE OR REPEATED EXPOSURE)
SARA 302 EXTREMELY HAZARDOUS SUBSTANCE: NOT LISTED.
SARA 311/312 EAZARDOUS CHEMICAL: YES
SARA 313 (TRI REPORTING):
CHEMICAL NAME CAS NUMBER % BY WT.
TETRACHLOROETHYLENE 127-18-4 90 - 100
US STATE REGULATIONS:
US. NEW JERSEY WORKER AND COMMUNITY RIGHT-TO-KNOW ACT:
CARBON DIOXIDE (CAS 124-38-9)
TETRACHLOROETHYLENE (CAS 127-18-4)
US. MASSACHUSETTS RTK - SUBSTANCE LIST:
CARBON DIOXIDE (CAS 124-38-9)
TETRACHLOROETHYLENE (CAS 127-18-4)
US. PENNSYLVANIA WORKER AND COMMUNITY RIGHT-TO-KNOW LAW:
CARBON DIOXIDE (CAS 124-38-9)
TETRACHLOROETHYLENE (CAS 127-18-4)
US. RHODE ISLAND RTK:
CARBON DIOXIDE (CAS 124-38-9)
TETRACHLOROETHYLENE (CAS 127-18-4)
CALIFORNIA PROPOSITION 65:
WARNING: CANCER - WWW.P65WARNINGS.CA.GOV
US - CALIFORNIA PROPOSITION 65 - CRT:
LISTED DATE/CARCINOGENIC SUBSTANCE:
TETRACHLOROETHYLENE (CAS 127-18-4) LISTED: APRIL 1, 1988
US. CALIFORNIA. CANDIDATE CHEMICALS LIST. SAFER CONSUMER PRODUCTS
REGULATIONS (CAL. CODE REGS, TIT. 22, 69502.3, SUBD. (A)):
TETRACHLOROETHYLENE (CAS 127-18-4)
VOLATILE ORGANIC COMPOUNDS (VOC) REGULATIONS:
EPA:
VOC CONTENT (40 CFR 51.100(S)): 0%
CONSUMER PRODUCTS (40 CFR 59, SUBPT. C): NOT REGULATED
STATE:
CONSUMER PRODUCTS:
THIS PRODUCT IS REGULATED AS A BRAKE CLEANER. THIS PRODUCT IS NOT COMPLIANT
TO BE SOLD FOR USE IN CALIFORNIA AND NEW JERSEY. THIS PRODUCT IS COMPLIANT
IN ALL OTHER STATES.
VOC CONTENT (CA): 0%
VOC CONTENT (OTC): 0%
INTERNATIONAL INVENTORIES:
COUNTRY(S) OR REGION INVENTORY NAME ON INVENTORY
(YES/NO)*
AUSTRALIA AUSTRALIAN INVENTORY OF CHEMICAL YES
SUBSTANCES (AICS)
CANADA DOMESTIC SUBSTANCES LIST (DSL) YES
CANADA NON-DOMESTIC SUBSTANCES LIST (NDSL) NO
CHINA INVENTORY OF EXISTING CHEMICAL YES
SUBSTANCES IN CHINA (IECSC)
EUROPE EUROPEAN INVENTORY OF EXISTING YES
COMMERCIAL CHEMICAL SUBSTANCES
(EINECS)
EUROPE EUROPEAN LIST OF NOTIFIED CHEMICAL NO
SUBSTANCES (ELINCS)
JAPAN INVENTORY OF EXISTING AND NEW YES
CHEMICAL SUBSTANCES (ENCS)
KOREA EXISTING CHEMICALS LIST (ECL) YES
NEW ZEALAND NEW ZEALAND INVENTORY YES
PHILIPPINES PHILIPPINE INVENTORY OF CHEMICALS YES
AND CHEMICAL SUBSTANCES (PICCS)
TAIWAN TAIWAN CHEMICAL SUBSTANCE YES
INVENTORY (TCSI)
UNITED STATES & TOXIC SUBSTANCES CONTROL ACT YES
PUERTO RICO (TSCA) INVENTORY
*A "YES" INDICATES THAT ALL COMPONENTS OF THIS PRODUCT COMPLY WITH
THE INVENTORY REQUIREMENTS ADMINISTERED BY THE GOVERNING COUNTRY(S)
A "NO" INDICATES THAT ONE OR MORE COMPONENTS OF THE PRODUCT ARE NOT LISTED
OR EXEMPT FROM LISTING ON THE INVENTORY ADMINISTERED BY THE GOVERNING
COUNTRY(S).
| 16. OTHER INFORMATION INCLUDING DATE OF PREPARATION | |
OR LAST REVISION
ISSUE DATE: 03-12-2019
REVISION DATE: 04-03-2019
PREPARED BY: ALLISON YOON
VERSION #: 02
FURTHER INFORMATION: CRC # 491G/1002481
DISCLAIMER:
THE INFORMATION CONTAINED IN THIS DOCUMENT APPLIES TO THIS SPECIFIC
MATERIAL AS SUPPLIED. IT MAY NOT BE VALID FOR THIS MATERIAL IF IT IS USED
IN COMBINATION WITH ANY OTHER MATERIALS. THIS INFORMATION IS ACCURATE TO
THE BEST OF CRC'S KNOWLEDGE OR OBTAINED FROM SOURCES BELIEVED BY CRC TO BE
ACCURATE. BEFORE USING ANY PRODUCT, READ ALL WARNINGS AND DIRECTIONS ON
THE LABEL. FOR FURTHER CLARIFICATION OF ANY INFORMATION CONTAINED ON THIS
(M)SDS CONSULT YOUR SUPERVISOR, A HEALTH & SAFETY PROFESSIONAL, OR CRC
INDUSTRIES, INC.
REVISION INFORMATION:
COMPOSITION / INFORMATION ON INGREDIENTS: COMPONENT SUMMARY
PHYSICAL & CHEMICAL PROPERTIES: MULTIPLE PROPERTIES
ECOLOGICAL INFORMATION: ECOTOXICITY
TRANSPORT INFORMATION: MATERIAL TRANSPORTATION INFORMATION
GHS: CLASSIFICATION
MATERIAL NAME: BRAKLEEN(R*) BRAKE PARTS CLEANER WITH TRIGGER - 19 OZ
SDS US