| Common Name: | LPS PRESOLVE |
| Manufacturer: | ITW PRO BRANDS |
| SDS Revision Date: | 3/22/2016 |
| SDS Format: | GHS-US |
| Item Number(s): | 2JFD8, 36FL96, 49CT11 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
LPS(R*)
SAFETY DATA SHEET
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFIER: LPS(R*) PRESOLVE
OTHER MEANS OF IDENTIFICATION:
PART NUMBER: 01422, 01428, 01405, 01455
RECOMMENDED USE:
A SOLVENT DEGREASING AGENT DESIGNED FOR REMOVING TAR, ADHESIVES, GREASE,
OIL AND OTHER RESIDUES FROM METAL AND OTHER HARD SURFACES.
RECOMMENDED RESTRICTIONS: NONE KNOWN.
MANUFACTURER/IMPORTER/SUPPLIER/DISTRIBUTOR INFORMATION:
MANUFACTURER:
COMPANY NAME: ITW PRO BRANDS
ADDRESS:
4647 HUGH HOWELL RD.
TUCKER, GA 30084
COUNTRY: (USA.)
TEL: +1 770-243-8800
IN CASE OF EMERGENCY:
1-800-424-9300 (INSIDE U.S.)
+001 703-527-3887 (OUTSIDE U.S.)
WEBSITE: WWW.LPSLABS.COM
E-MAIL: LPSSDS@ITWPROBRANDS.COM
| 2. HAZARD(S) IDENTIFICATION | |
PHYSICAL HAZARDS:
FLAMMABLE LIQUIDS: CATEGORY 3
HEALTH HAZARDS:
SKIN CORROSION/IRRITATION: CATEGORY 2
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 2A
SENSITIZATION, SKIN: CATEGORY 1
SPECIFIC TARGET ORGAN TOXICITY, SINGLE EXPOSURE:
CATEGORY 3 NARCOTIC EFFECTS
ASPIRATION HAZARD: CATEGORY 1
ENVIRONMENTAL HAZARDS: NOT CLASSIFIED.
OSHA DEFINED HAZARDS: NOT CLASSIFIED.
LABEL ELEMENTS:
FLAME
HEALTH HAZARD
EXCLAMATION MARK
SIGNAL WORD: DANGER
HAZARD STATEMENT:
FLAMMABLE LIQUID AND VAPOR. CAUSES SKIN IRRITATION. CAUSES SERIOUS EYE
IRRITATION. MAY CAUSE AN ALLERGIC SKIN REACTION. MAY CAUSE DROWSINESS OR
DIZZINESS. MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
PRECAUTIONARY STATEMENT:
PREVENTION:
KEEP AWAY FROM HEAT/SPARKS/OPEN FLAMES/HOT SURFACES. NO SMOKING. KEEP
CONTAINER TIGHTLY CLOSED. GROUND/BOND CONTAINER AND RECEIVING EQUIPMENT.
USE EXPLOSION-PROOF ELECTRICAL/VENTILATING/LIGHTING EQUIPMENT. USE ONLY
NON-SPARKING TOOLS. TAKE PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGE.
AVOID BREATHING DUST/FUME/GAS/MIST/VAPORS/SPRAY. WASH THOROUGHLY AFTER
HANDLING. USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA. CONTAMINATED WORK
CLOTHING SHOULD NOT BE ALLOWED OUT OF THE WORKPLACE. WEAR PROTECTIVE
GLOVES/EYE PROTECTION/FACE PROTECTION.
RESPONSE:
IN CASE OF FIRE: USE APPROPRIATE MEDIA TO EXTINGUISH.
IF SWALLOWED:
IMMEDIATELY CALL A POISON CENTER/DOCTOR. DO NOT INDUCE VOMITING.
IF ON SKIN (OR HAIR):
TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. RINSE SKIN WITH
WATER/SHOWER.
IF SKIN IRRITATION OR RASH OCCURS:
GET MEDICAL ADVICE/ATTENTION. SPECIFIC TREATMENT (SEE THIS LABEL). TAKE OFF
CONTAMINATED CLOTHING AND WASH IT BEFORE REUSE.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
IF INHALED:
REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING. CALL A
POISON CENTER/DOCTOR IF YOU FEEL UNWELL.
STORAGE:
KEEP COOL. STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED.
STORE LOCKED UP.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
HAZARD(S) NOT OTHERWISE CLASSIFIED (HNOC): NONE KNOWN.
SUPPLEMENTAL INFORMATION: NOT APPLICABLE.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
MIXTURES:
CHEMICAL NAME COMMON NAME AND SYNONYMS CAS NUMBER %
DISTILLATES PETROLEUM 64742-47-8 60 - 70
HYDROTREATED LIGHT
3-METHOXY-3-METHYL- 56539-66-3 10 - 20
1-BUTANOL (MMB)
D-LIMONENE 5989-27-5 10 - 20
ALL CONCENTRATIONS ARE IN PERCENT BY WEIGHT UNLESS INGREDIENT IS A GAS.
GAS CONCENTRATIONS ARE IN PERCENT BY VOLUME.
| 4. FIRST-AID MEASURES | |
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. OXYGEN OR ARTIFICIAL RESPIRATION IF NEEDED. DO NOT USE
MOUTH-TO-MOUTH METHOD IF VICTIM INHALED THE SUBSTANCE. INDUCE ARTIFICIAL
RESPIRATION WITH THE AID OF A POCKET MASK EQUIPPED WITH A ONE-WAY VALVE OR
OTHER PROPER RESPIRATORY MEDICAL DEVICE. CALL A POISON CENTER OR
DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
SKIN CONTACT:
IN CASE OF CONTACT, IMMEDIATELY FLUSH SKIN WITH PLENTY OF WATER FOR AT
LEAST 15 MINUTES WHILE REMOVING CONTAMINATED CLOTHING AND SHOES. GET
MEDICAL ATTENTION IF IRRITATION DEVELOPS AND PERSISTS.
EYE CONTACT:
IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. IF EASY TO
DO, REMOVE CONTACT LENSES. GET MEDICAL ATTENTION IF IRRITATION DEVELOPS AND
PERSISTS.
INGESTION:
CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY. ONLY INDUCE VOMITING
AT THE INSTRUCTION OF MEDICAL PERSONNEL. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. IF VOMITING OCCURS, KEEP HEAD LOW SO THAT STOMACH
CONTENT DOESN'T GET INTO THE LUNGS.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
IRRITANT EFFECTS. SYMPTOMS MAY INCLUDE STINGING, TEARING, REDNESS,
SWELLING, AND BLURRED VISION. DEFATTING OF THE SKIN. RASH. SYMPTOMS OF
OVEREXPOSURE CAN INCLUDE SHORTNESS OF BREATH, DROWSINESS, HEADACHES,
CONFUSION, DECREASED COORDINATION, VISUAL DISTURBANCES AND VOMITING, AND
ARE REVERSIBLE IF EXPOSURE IS STOPPED.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
PROVIDE GENERAL SUPPORTIVE MEASURES AND TREAT SYMPTOMATICALLY. IN CASE OF
SHORTNESS OF BREATH, GIVE OXYGEN. KEEP VICTIM UNDER OBSERVATION. SYMPTOMS
MAY BE DELAYED.
GENERAL INFORMATION:
IN THE CASE OF ACCIDENT OR IF YOU FEEL UNWELL, SEEK MEDICAL ADVICE
IMMEDIATELY (SHOW THE LABEL WHERE POSSIBLE). ENSURE THAT MEDICAL PERSONNEL
ARE AWARE OF THE MATERIAL(S) INVOLVED, AND TAKE PRECAUTIONS TO PROTECT
THEMSELVES.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
ALCOHOL RESISTANT FOAM. WATER FOG. DRY CHEMICAL POWDER. CARBON DIOXIDE
(CO2).
UNSUITABLE EXTINGUISHING MEDIA:
DO NOT USE WATER JET AS AN EXTINGUISHER, AS THIS WILL SPREAD THE FIRE.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
BY HEATING AND FIRE, HARMFUL VAPORS/GASES MAY BE FORMED. VAPORS MAY FORM
EXPLOSIVE MIXTURES WITH AIR. VAPORS MAY TRAVEL CONSIDERABLE DISTANCE TO A
SOURCE OF IGNITION AND FLASH BACK.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
FIREFIGHTERS MUST USE STANDARD PROTECTIVE EQUIPMENT INCLUDING FLAME
RETARDANT COAT, HELMET WITH FACE SHIELD, GLOVES, RUBBER BOOTS, AND IN
ENCLOSED SPACES, SCBA. STRUCTURAL FIREFIGHTERS PROTECTIVE CLOTHING WILL
ONLY PROVIDE LIMITED PROTECTION.
FIRE FIGHTING EQUIPMENT/INSTRUCTIONS:
IN CASE OF FIRE AND/OR EXPLOSION DO NOT BREATHE FUMES. USE STANDARD
FIREFIGHTING PROCEDURES AND CONSIDER THE HAZARDS OF OTHER INVOLVED
MATERIALS. MOVE CONTAINERS FROM FIRE AREA IF YOU CAN DO SO WITHOUT RISK.
WATER RUNOFF CAN CAUSE ENVIRONMENTAL DAMAGE.
SPECIFIC METHODS:
USE STANDARD FIREFIGHTING PROCEDURES AND CONSIDER THE HAZARDS OF OTHER
INVOLVED MATERIALS. MOVE CONTAINER FROM FIRE AREA IF IT CAN BE DONE WITHOUT
RISK. IN THE EVENT OF FIRE AND/OR EXPLOSION DO NOT BREATHE FUMES.
GENERAL FIRE HAZARDS: FLAMMABLE LIQUID AND VAPOR.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
KEEP PEOPLE AWAY FROM AND UPWIND OF SPILL/LEAK. KEEP OUT OF LOW AREAS.
ELIMINATE ALL IGNITION SOURCES (NO SMOKING, FLARES, SPARKS, OR FLAMES IN
IMMEDIATE AREA). WEAR APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT. DO NOT
TOUCH DAMAGED CONTAINERS OR SPILLED MATERIAL UNLESS WEARING APPROPRIATE
PROTECTIVE CLOTHING. AVOID INHALATION OF VAPORS OR MISTS. VENTILATE CLOSED
SPACES BEFORE ENTERING THEM. LOCAL AUTHORITIES SHOULD BE ADVISED IF
SIGNIFICANT SPILLAGES CANNOT BE CONTAINED. USE PERSONAL PROTECTION
RECOMMENDED IN SECTION 8 OF THE SDS.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
ELIMINATE ALL IGNITION SOURCES (NO SMOKING, FLARES, SPARKS, OR FLAMES IN
IMMEDIATE AREA). TAKE PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGE. USE
ONLY NON-SPARKING TOOLS. KEEP COMBUSTIBLES (WOOD, PAPER, OIL, ETC.) AWAY
FROM SPILLED MATERIAL. THIS MATERIAL IS CLASSIFIED AS A WATER POLLUTANT
UNDER THE CLEAN WATER ACT AND SHOULD BE PREVENTED FROM CONTAMINATING SOIL
OR FROM ENTERING SEWAGE AND DRAINAGE SYSTEMS WHICH LEAD TO WATERWAYS.
LARGE SPILLS:
STOP THE FLOW OF MATERIAL, IF THIS IS WITHOUT RISK. DIKE THE SPILLED
MATERIAL, WHERE THIS IS POSSIBLE. COVER WITH PLASTIC SHEET TO PREVENT
SPREADING. USE A NON-COMBUSTIBLE MATERIAL LIKE VERMICULITE, SAND OR EARTH
TO SOAK UP THE PRODUCT AND PLACE INTO A CONTAINER FOR LATER DISPOSAL. USE
WATER SPRAY TO REDUCE VAPORS OR DIVERT VAPOR CLOUD DRIFT. FOLLOWING PRODUCT
RECOVERY, FLUSH AREA WITH WATER.
SMALL SPILLS:
WIPE UP WITH ABSORBENT MATERIAL (E.G. CLOTH, FLEECE). CLEAN SURFACE
THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
NEVER RETURN SPILLS IN ORIGINAL CONTAINERS FOR RE-USE. FOR WASTE DISPOSAL,
SEE SECTION 13 OF THE SDS.
ENVIRONMENTAL PRECAUTIONS:
AVOID RELEASE TO THE ENVIRONMENT. CONTACT LOCAL AUTHORITIES IN CASE OF
SPILLAGE TO DRAIN/AQUATIC ENVIRONMENT. PREVENT FURTHER LEAKAGE OR SPILLAGE
IF SAFE TO DO SO. AVOID DISCHARGE INTO DRAINS, WATER COURSES OR ONTO THE
GROUND.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
DO NOT HANDLE, STORE OR OPEN NEAR AN OPEN FLAME, SOURCES OF HEAT OR SOURCES
OF IGNITION. PROTECT MATERIAL FROM DIRECT SUNLIGHT. DO NOT SMOKE. TAKE
PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGES. ALL EQUIPMENT USED WHEN
HANDLING THE PRODUCT MUST BE GROUNDED. USE NON-SPARKING TOOLS AND
EXPLOSION-PROOF EQUIPMENT. AVOID BREATHING MIST OR VAPOR. AVOID CONTACT
WITH SKIN. AVOID CONTACT WITH EYES. AVOID PROLONGED EXPOSURE. PROVIDE
ADEQUATE VENTILATION. WEAR APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT.
OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES. WASH HANDS THOROUGHLY AFTER
HANDLING. AVOID RELEASE TO THE ENVIRONMENT. DO NOT EMPTY INTO DRAINS.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
KEEP AWAY FROM HEAT, SPARKS AND OPEN FLAME. KEEP CONTAINER TIGHTLY CLOSED.
STORE IN A COOL, DRY PLACE OUT OF DIRECT SUNLIGHT. STORE IN A
WELL-VENTILATED PLACE. KEEP IN AN AREA EQUIPPED WITH SPRINKLERS.
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
OCCUPATIONAL EXPOSURE LIMITS: NO EXPOSURE LIMITS NOTED FOR INGREDIENT(S).
BIOLOGICAL LIMIT VALUES:
NO BIOLOGICAL EXPOSURE LIMITS NOTED FOR THE INGREDIENT(S).
APPROPRIATE ENGINEERING CONTROLS:
GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER HOUR) SHOULD BE
USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS. IF APPLICABLE, USE
PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING
CONTROLS TO MAINTAIN AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS. IF
EXPOSURE LIMITS HAVE NOT BEEN ESTABLISHED, MAINTAIN AIRBORNE LEVELS TO AN
ACCEPTABLE LEVEL.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION:
WEAR SAFETY GLASSES WITH SIDE SHIELDS (OR GOGGLES). EYE WASH FOUNTAIN IS
RECOMMENDED.
SKIN PROTECTION:
HAND PROTECTION: CHEMICAL RESISTANT GLOVES ARE RECOMMENDED.
OTHER: WEAR SUITABLE PROTECTIVE CLOTHING.
RESPIRATORY PROTECTION:
NO PERSONAL RESPIRATORY PROTECTIVE EQUIPMENT NORMALLY REQUIRED. USE A
POSITIVE-PRESSURE AIR-SUPPLIED RESPIRATOR IF THERE IS ANY POTENTIAL FOR AN
UNCONTROLLED RELEASE, EXPOSURE LEVELS ARE NOT KNOWN, OR ANY OTHER
CIRCUMSTANCES WHERE AIR-PURIFYING RESPIRATORS MAY NOT PROVIDE ADEQUATE
PROTECTION.
THERMAL HAZARDS: NOT APPLICABLE.
GENERAL HYGIENE CONSIDERATIONS:
WHEN USING, DO NOT EAT, DRINK OR SMOKE. ALWAYS OBSERVE GOOD PERSONAL
HYGIENE MEASURES, SUCH AS WASHING AFTER HANDLING THE MATERIAL AND BEFORE
EATING, DRINKING, AND/OR SMOKING. ROUTINELY WASH WORK CLOTHING AND
PROTECTIVE EQUIPMENT TO REMOVE CONTAMINANTS.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: LIQUID.
FORM: LIQUID.
COLOR: CLEAR, OFF-WHITE.
ODOR: ORANGE
ODOR THRESHOLD: NOT ESTABLISHED
PH: NOT APPLICABLE
MELTING POINT/FREEZING POINT: NOT ESTABLISHED
INITIAL BOILING POINT AND BOILING RANGE:
>302 DEG. F (>150 DEG. C)
FLASH POINT: 104.0 DEG. F (40.0 DEG. C) TAG CLOSED CUP
EVAPORATION RATE: >0.1 BUAC
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS:
FLAMMABILITY LIMIT - LOWER (%): 0.7 %
FLAMMABILITY LIMIT - UPPER (%): 6 %
EXPLOSIVE LIMIT - LOWER (%): NOT AVAILABLE.
EXPLOSIVE LIMIT - UPPER (%): NOT AVAILABLE.
VAPOR PRESSURE: <5 MMHg @ 20 DEG. C
VAPOR DENSITY: >1 (AIR = 1)
RELATIVE DENSITY: NOT AVAILABLE.
SOLUBILITY(IES):
SOLUBILITY (WATER): <15%
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT ESTABLISHED
AUTO-IGNITION TEMPERATURE: >392 DEG. F (>200 DEG. C)
DECOMPOSITION TEMPERATURE: NOT ESTABLISHED
VISCOSITY: <3 CST @ 25 DEG. C
OTHER INFORMATION:
HEAT OF COMBUSTION: >30 KJ/G
PERCENT VOLATILE: 100%
SPECIFIC GRAVITY: 0.82 - 0.86 @ 20 DEG. C
VOC (WEIGHT %):
100% PER U.S. STATE AND FEDERAL CONSUMER PRODUCT REGULATIONS CARB
| 10. STABILITY AND REACTIVITY | |
REACTIVITY:
THE PRODUCT IS STABLE AND NON-REACTIVE UNDER NORMAL CONDITIONS OF USE,
STORAGE AND TRANSPORT.
CHEMICAL STABILITY:
MATERIAL IS STABLE UNDER NORMAL CONDITIONS. RISK OF IGNITION.
POSSIBILITY OF HAZARDOUS REACTIONS:
HAZARDOUS POLYMERIZATION DOES NOT OCCUR.
CONDITIONS TO AVOID:
HEAT, FLAMES AND SPARKS. AVOID TEMPERATURES EXCEEDING THE FLASH POINT.
INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS: CARBON OXIDES.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INHALATION: MAY CAUSE DROWSINESS AND DIZZINESS.
SKIN CONTACT:
CAUSES SKIN IRRITATION. MAY CAUSE SENSITIZATION BY SKIN CONTACT.
EYE CONTACT: CAUSES EYE IRRITATION.
INGESTION:
HARMFUL IF SWALLOWED. MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
IRRITANT EFFECTS. SYMPTOMS MAY INCLUDE STINGING, TEARING, REDNESS,
SWELLING, AND BLURRED VISION. DEFATTING OF THE SKIN. VAPORS HAVE A NARCOTIC
EFFECT AND MAY CAUSE HEADACHE, FATIGUE, DIZZINESS AND NAUSEA. SYMPTOMS OF
OVEREXPOSURE MAY BE HEADACHE, DIZZINESS, TIREDNESS, NAUSEA AND VOMITING.
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY: NOT EXPECTED TO BE ACUTELY TOXIC.
COMPONENTS SPECIES TEST RESULTS
3-METHOXY-3-METHYL-1-BUTANOL (MMB) (CAS 56539-66-3):
ACUTE:
DERMAL:
LD50 RAT >2000 MG/KG, 24 HOURS
ORAL:
LD50 MOUSE 5830 MG/KG
RAT >2000 MG/KG
DISTILLATES PETROLEUM HYDROTREATED LIGHT (CAS 64742-47-8):
ACUTE:
DERMAL:
LD50 RABBIT >2000 MG/KG
>2000 MG/KG, 24 HOURS
INHALATION:
AEROSOL:
LC50 CAT >6.4 MG/L, 6 HOURS
RAT >7.5 MG/L, 6 HOURS
>4.3 MG/L, 4 HOURS
VAPOR:
LC50 RAT >0.1 MG/L, 8 HOURS
ORAL:
LD50 RAT >5000 MG/KG
D-LIMONENE (CAS 5989-27-5):
ACUTE:
ORAL:
LD50 MOUSE 5600 - 6600 MG/KG
RAT >2000 MG/KG
SKIN CORROSION/IRRITATION: CAUSES SKIN IRRITATION.
SERIOUS EYE DAMAGE/EYE IRRITATION: CAUSES SERIOUS EYE IRRITATION.
RESPIRATORY OR SKIN SENSITIZATION:
RESPIRATORY SENSITIZATION: NOT A RESPIRATORY SENSITIZER.
SKIN SENSITIZATION: MAY CAUSE SENSITIZATION BY SKIN CONTACT.
GERM CELL MUTAGENICITY:
NO DATA AVAILABLE TO INDICATE PRODUCT OR ANY COMPONENTS PRESENT AT GREATER
THAN 0.1% ARE MUTAGENIC OR GENOTOXIC.
CARCINOGENICITY:
THIS PRODUCT IS NOT CONSIDERED TO BE A CARCINOGEN BY IARC, ACGIH, NTP, OR
OSHA.
IARC MONOGRAPHS. OVERALL EVALUATION OF CARCINOGENICITY:
D-LIMONENE (CAS 5989-27-5):
3: NOT CLASSIFIABLE AS TO CARCINOGENICITY TO HUMANS.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1050):
NOT REGULATED.
US. NATIONAL TOXICOLOGY PROGRAM (NTP) REPORT ON CARCINOGENS: NOT LISTED.
REPRODUCTIVE TOXICITY:
THIS PRODUCT IS NOT EXPECTED TO CAUSE REPRODUCTIVE OR DEVELOPMENTAL
EFFECTS.
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE: NARCOTIC EFFECTS.
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE: NOT CLASSIFIED.
ASPIRATION HAZARD:
MAY BE HARMFUL IF SWALLOWED AND ENTERS AIRWAYS. IF ASPIRATED INTO LUNGS
DURING SWALLOWING OR VOMITING, MAY CAUSE CHEMICAL PNEUMONIA, PULMONARY
INJURY OR DEATH.
CHRONIC EFFECTS: PROLONGED EXPOSURE MAY CAUSE CHRONIC EFFECTS.
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY: TOXIC TO AQUATIC LIFE WITH LONG LASTING EFFECTS.
COMPONENTS SPECIES TEST RESULTS
DISTILLATES PETROLEUM HYDROTREATED LIGHT (CAS 64742-47-8):
AQUATIC:
FISH LC50 RAINBOW TROUT, DONALDSON 2.9 MG/L, 96 HOURS
TROUT (ONCORHYNCHUS
MYKISS)
D-LIMONENE (CAS 5989-27-5):
AQUATIC:
CRUSTACEA EC50 WATER FLEA (DAPHNIA PULEX) 69.6 MG/L, 48 HOURS
FISH LC50 FATHEAD MINNOW (PIMEPHALES 0.619 - 0.796 MG/L,
PROMELAS) 96 HOURS
PERSISTENCE AND DEGRADABILITY: NOT INHERENTLY BIODEGRADABLE.
BIOACCUMULATIVE POTENTIAL: NO DATA AVAILABLE.
PARTITION COEFFICIENT N-OCTANOL / WATER (LOG KOW):
D-LIMONENE: 4.232
MOBILITY IN SOIL: READILY ABSORBED INTO SOIL.
OTHER ADVERSE EFFECTS: NONE KNOWN.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL INSTRUCTIONS:
COLLECT AND RECLAIM OR DISPOSE IN SEALED CONTAINERS AT LICENSED WASTE
DISPOSAL SITE. THIS MATERIAL AND ITS CONTAINER MUST BE DISPOSED OF AS
HAZARDOUS WASTE. DO NOT ALLOW THIS MATERIAL TO DRAIN INTO SEWERS/WATER
SUPPLIES. DO NOT CONTAMINATE PONDS, WATERWAYS OR DITCHES WITH CHEMICAL OR
USED CONTAINER. DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
HAZARDOUS WASTE CODE:
D001: WASTE FLAMMABLE MATERIAL WITH A FLASH POINT <140 F
WASTE FROM RESIDUES / UNUSED PRODUCTS:
DISPOSE OF IN ACCORDANCE WITH LOCAL REGULATIONS. EMPTY CONTAINERS OR LINERS
MAY RETAIN SOME PRODUCT RESIDUES. THIS MATERIAL AND ITS CONTAINER MUST BE
DISPOSED OF IN A SAFE MANNER (SEE: DISPOSAL INSTRUCTIONS).
CONTAMINATED PACKAGING:
EMPTY CONTAINERS SHOULD BE TAKEN TO AN APPROVED WASTE HANDLING SITE FOR
RECYCLING OR DISPOSAL. SINCE EMPTIED CONTAINERS MAY RETAIN PRODUCT RESIDUE,
FOLLOW LABEL WARNINGS EVEN AFTER CONTAINER IS EMPTIED.
| 14. TRANSPORT INFORMATION | |
DOT:
UN NUMBER: UN1993
UN PROPER SHIPPING NAME: FLAMMABLE LIQUIDS, N.O.S. (D-LIMONENE, NAPTHA)
TRANSPORT HAZARD CLASS(ES):
CLASS: 3
SUBSIDIARY RISK:
LABEL(S): 3
PACKING GROUP: III
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
SPECIAL PROVISIONS: B1, B52, IB3, T4, TP1, TP29
PACKAGING EXCEPTIONS: 150
PACKAGING NON BULK: 203
PACKAGING BULK: 242
MAY BE RECLASSIFIED AS COMBUSTIBLE LIQUID FOR DOMESTIC TRANSPORT.
IATA:
UN NUMBER: UN1993
UN PROPER SHIPPING NAME: FLAMMABLE LIQUID, N.O.S. (D-LIMONENE, NAPTHA)
TRANSPORT HAZARD CLASS(ES):
CLASS: 3
SUBSIDIARY RISK:
PACKING GROUP: III
ENVIRONMENTAL HAZARDS: YES
ERG CODE: 3L
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
OTHER INFORMATION:
PASSENGER AND CARGO AIRCRAFT: ALLOWED WITH RESTRICTIONS.
CARGO AIRCRAFT ONLY: ALLOWED WITH RESTRICTIONS.
IMDG:
UN NUMBER: UN1993
UN PROPER SHIPPING NAME:
FLAMMABLE LIQUID, N.O.S. (D-LIMONENE, NAPTHA), MARINE POLLUTANT
TRANSPORT HAZARD CLASS(ES):
CLASS: 3
SUBSIDIARY RISK:
PACKING GROUP: III
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: YES
EMS: F-E, S-E
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
TRANSPORT IN BULK ACCORDING TO ANNEX II OF MARPOL 73/78 AND THE IBC CODE:
NOT AVAILABLE.
DOT:
FLAMMABLE LIQUID, CLASS/DIVISION 3.1, 3.2, 3.3
IATA; IMDG: CLASS 3, FLAMMABLE LIQUIDS
MARINE POLLUTANT: ENVIRONMENT
GENERAL INFORMATION:
DOT REGULATED MARINE POLLUTANT. IMDG REGULATED MARINE POLLUTANT.
| 15. REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
TSCA SECTION 12(B) EXPORT NOTIFICATION (40 CFR 707, SUBPT. D):
NOT REGULATED.
CERCLA HAZARDOUS SUBSTANCE LIST (40 CFR 302.4): NOT LISTED.
SARA 304 EMERGENCY RELEASE NOTIFICATION: NOT REGULATED.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1050):
NOT REGULATED.
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA):
HAZARD CATEGORIES:
IMMEDIATE HAZARD: YES
DELAYED HAZARD: NO
FIRE HAZARD: YES
PRESSURE HAZARD: NO
REACTIVITY HAZARD: NO
SARA 302 EXTREMELY HAZARDOUS SUBSTANCE: NOT LISTED.
SARA 311/312 HAZARDOUS CHEMICAL: YES
SARA 313 (TRI REPORTING): NOT REGULATED.
OTHER FEDERAL REGULATIONS:
CLEAN AIR ACT (CAA) SECTION 112 HAZARDOUS AIR POLLUTANTS (HAPS) LIST:
NOT REGULATED.
CLEAN AIR ACT (CAA) SECTION 112(R) ACCIDENTAL RELEASE PREVENTION (40 CFR
68.130): NOT REGULATED.
SAFE DRINKING WATER ACT (SDWA): NOT REGULATED.
US STATE REGULATIONS:
US. CALIFORNIA CONTROLLED SUBSTANCES. CA DEPARTMENT OF JUSTICE (CALIFORNIA
HEALTH AND SAFETY CODE SECTION 11100): NOT LISTED.
US. MASSACHUSETTS RTK - SUBSTANCE LIST: NOT REGULATED.
US. NEW JERSEY WORKER AND COMMUNITY RIGHT-TO-KNOW ACT: NOT LISTED.
US. PENNSYLVANIA WORKER AND COMMUNITY RIGHT-TO-KNOW LAW: NOT LISTED.
US. RHODE ISLAND RTK: NOT REGULATED.
US. CALIFORNIA PROPOSITION 65:
CALIFORNIA SAFE DRINKING WATER AND TOXIC ENFORCEMENT ACT OF 1986
(PROPOSITION 65):
THIS MATERIAL IS NOT KNOWN TO CONTAIN ANY CHEMICALS CURRENTLY LISTED AS
CARCINOGENS OR REPRODUCTIVE TOXINS.
INTERNATIONAL INVENTORIES:
COUNTRY(S) OR REGION INVENTORY NAME ON INVENTORY
(YES/NO)*
AUSTRALIA AUSTRALIAN INVENTORY OF CHEMICAL YES
SUBSTANCES (AICS)
CANADA DOMESTIC SUBSTANCES LIST (DSL) YES
CANADA NON-DOMESTIC SUBSTANCES LIST (NDSL) NO
CHINA INVENTORY OF EXISTING CHEMICAL YES
SUBSTANCES IN CHINA (IECSC)
EUROPE EUROPEAN INVENTORY OF EXISTING YES
COMMERCIAL CHEMICAL SUBSTANCES
(EINECS)
EUROPE EUROPEAN LIST OF NOTIFIED CHEMICAL NO
SUBSTANCES (ELINCS)
JAPAN INVENTORY OF EXISTING AND NEW CHEMICAL NO
SUBSTANCES (ENCS)
KOREA EXISTING CHEMICALS LIST (ECL) YES
NEW ZEALAND NEW ZEALAND INVENTORY YES
PHILIPPINES PHILIPPINE INVENTORY OF CHEMICALS AND YES
CHEMICAL SUBSTANCES (PICCS)
UNITED STATES & TOXIC SUBSTANCES CONTROL ACT (TSCA) YES
PUERTO RICO INVENTORY
*A "YES" INDICATES THAT ALL COMPONENTS OF THIS PRODUCT COMPLY WITH THE
INVENTORY REQUIREMENTS ADMINISTERED BY THE GOVERNING COUNTRY(S)
A "NO" INDICATES THAT ONE OR MORE COMPONENTS OF THE PRODUCT ARE NOT LISTED
OR EXEMPT FROM LISTING ON THE INVENTORY ADMINISTERED BY THE GOVERNING
COUNTRY(S).
| 16. OTHER INFORMATION, INCLUDING DATE OF PREPARATION | |
OR LAST REVISION
ISSUE DATE: 03-22-2016
VERSION #: 01
DISCLAIMER:
THE INFORMATION PROVIDED IN THIS SAFETY DATA SHEET IS CORRECT TO THE BEST
OF OUR KNOWLEDGE, INFORMATION AND BELIEF AT THE DATE OF ITS PUBLICATION.
THE INFORMATION GIVEN IS DESIGNED ONLY AS A GUIDANCE FOR SAFE HANDLING,
USE, PROCESSING, STORAGE, TRANSPORTATION, DISPOSAL AND RELEASE AND IS NOT
TO BE CONSIDERED A WARRANTY OR QUALITY SPECIFICATION. THE INFORMATION
RELATES ONLY TO THE SPECIFIC MATERIAL DESIGNATED AND MAY NOT BE VALID FOR
SUCH MATERIAL USED IN COMBINATION WITH ANY OTHER MATERIALS OR IN ANY
PROCESS, UNLESS SPECIFIED IN THE TEXT.
REVISION INFORMATION:
PRODUCT AND COMPANY IDENTIFICATION: PRODUCT AND COMPANY IDENTIFICATION
COMPOSITION/INFORMATION ON INGREDIENTS: COMPONENT INFORMATION
FIRE-FIGHTING MEASURES: UNSUITABLE EXTINGUISHING MEDIA
ACCIDENTAL RELEASE MEASURES:
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES
ACCIDENTAL RELEASE MEASURES: ENVIRONMENTAL PRECAUTIONS
HANDLING AND STORAGE:
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES
EXPOSURE CONTROLS/PERSONAL PROTECTION: OTHER
TOXICOLOGICAL INFORMATION: INHALATION
TRANSPORT INFORMATION: MATERIAL TRANSPORTATION INFORMATION
GHS: CLASSIFICATION
MATERIAL NAME: LPS(R*) PRESOLVE
SDS US