| Common Name: | INDUSTRIAL SILICONE 03032 |
| Manufacturer: | CRC |
| SDS Revision Date: | 5/14/2015 |
| SDS Format: | GHS-US |
| Item Number(s): | 36GG84 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
CRC(R*)
SAFETY DATA SHEET
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFIER: INDUSTRIAL SILICONE
OTHER MEANS OF IDENTIFICATION:
PRODUCT CODE: 03032
RECOMMENDED USE: SILICONE-BASED MULTI-PURPOSE LUBRICANT
RECOMMENDED RESTRICTIONS: NONE KNOWN.
MANUFACTURER/IMPORTER/SUPPLIER/DISTRIBUTOR INFORMATION:
MANUFACTURED OR SOLD BY:
COMPANY NAME: CRC INDUSTRIES, INC.
ADDRESS:
885 LOUIS DR.
WARMINSTER, PA 18974
US
TELEPHONE:
GENERAL INFORMATION: 215-674-4300
TECHNICAL ASSISTANCE: 800-521-3168
CUSTOMER SERVICE: 800-272-4620
24-HOUR EMERGENCY (CHEMTREC):
800-424-9300 (US)
703-527-3887 (INTERNATIONAL)
WEBSITE: WWW.CRCINDUSTRIES.COM
| 2. HAZARD(S) IDENTIFICATION | |
PHYSICAL HAZARDS:
FLAMMABLE AEROSOLS: CATEGORY 1
GASES UNDER PRESSURE: LIQUEFIED GAS
HEALTH HAZARDS:
REPRODUCTIVE TOXICITY (FERTILITY): CATEGORY 2
SPECIFIC TARGET ORGAN TOXICITY, SINGLE EXPOSURE:
CATEGORY 3 NARCOTIC EFFECTS
SPECIFIC TARGET ORGAN TOXICITY, REPEATED EXPOSURE: CATEGORY 2
ASPIRATION HAZARD: CATEGORY 1
ENVIRONMENTAL HAZARDS:
HAZARDOUS TO THE AQUATIC ENVIRONMENT, ACUTE HAZARD: CATEGORY 3
HAZARDOUS TO THE AQUATIC ENVIRONMENT, LONG-TERM HAZARD: CATEGORY 3
OSHA DEFINED HAZARDS: NOT CLASSIFIED.
LABEL ELEMENTS:
FLAME
GAS CYLINDER
HEALTH HAZARD
EXCLAMATION MARK
SIGNAL WORD: DANGER
HAZARD STATEMENT:
EXTREMELY FLAMMABLE AEROSOL. CONTAINS GAS UNDER PRESSURE; MAY EXPLODE IF
HEATED. MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. MAY CAUSE DROWSINESS
OR DIZZINESS. SUSPECTED OF DAMAGING FERTILITY. MAY CAUSE DAMAGE TO ORGANS
(NERVOUS SYSTEM, UPPER RESPIRATORY TRACT, SKIN, EYES) THROUGH PROLONGED OR
REPEATED EXPOSURE. HARMFUL TO AQUATIC LIFE. HARMFUL TO AQUATIC LIFE WITH
LONG LASTING EFFECTS.
PRECAUTIONARY STATEMENT:
PREVENTION:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. KEEP AWAY FROM HEAT/SPARKS/OPEN
FLAMES/HOT SURFACES. - NO SMOKING. DO NOT SPRAY ON AN OPEN FLAME OR OTHER
IGNITION SOURCE. DO NOT APPLY WHILE EQUIPMENT IS ENERGIZED.
PRESSURIZED CONTAINER:
DO NOT PIERCE OR BURN, EVEN AFTER USE. EXTINGUISH ALL FLAMES, PILOT LIGHTS
AND HEATERS. VAPORS WILL ACCUMULATE READILY AND MAY IGNITE. USE ONLY WITH
ADEQUATE VENTILATION; MAINTAIN VENTILATION DURING USE AND UNTIL ALL VAPORS
ARE GONE. OPEN DOORS AND WINDOWS OR USE OTHER MEANS TO ENSURE A FRESH AIR
SUPPLY DURING USE AND WHILE PRODUCT IS DRYING. IF YOU EXPERIENCE ANY
SYMPTOMS LISTED ON THIS LABEL, INCREASE VENTILATION OR LEAVE THE AREA. DO
NOT BREATHE GAS. DO NOT BREATHE MIST OR VAPOR. WEAR PROTECTIVE
GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION. AVOID RELEASE
TO THE ENVIRONMENT.
RESPONSE:
IF SWALLOWED:
IMMEDIATELY CALL A POISON CENTER/DOCTOR. DO NOT INDUCE VOMITING.
IF INHALED:
REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING. CALL A
POISON CENTER/DOCTOR IF YOU FEEL UNWELL.
IF EXPOSED OR CONCERNED: GET MEDICAL ATTENTION.
STORAGE:
STORE IN A WELL-VENTILATED PLACE. STORE LOCKED UP. PROTECT FROM SUNLIGHT.
DO NOT EXPOSE TO TEMPERATURES EXCEEDING 50 DEG. C/122 DEG. F. EXPOSURE TO
HIGH TEMPERATURE MAY CAUSE CAN TO BURST.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH LOCAL/REGIONAL/NATIONAL
REGULATIONS.
HAZARD(S) NOT OTHERWISE CLASSIFIED (HNOC):
STATIC ACCUMULATING FLAMMABLE LIQUID CAN BECOME ELECTROSTATICALLY CHARGED
EVEN IN BONDED AND GROUNDED EQUIPMENT. SPARKS MAY IGNITE LIQUID AND VAPOR.
MAY CAUSE FLASH FIRE OR EXPLOSION.
SUPPLEMENTAL INFORMATION:
94.58% OF THE MIXTURE CONSISTS OF COMPONENT(S) OF UNKNOWN ACUTE HAZARDS TO
THE AQUATIC ENVIRONMENT. 82.47% OF THE MIXTURE CONSISTS OF COMPONENT(S) OF
UNKNOWN LONG-TERM HAZARDS TO THE AQUATIC ENVIRONMENT.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
MIXTURES:
CHEMICAL NAME COMMON NAME AND SYNONYMS CAS NUMBER %
NAPHTHA (PETROLEUM), 64742-49-0 40 - 50
HYDROTREATED LIGHT
1,1-DIFLUOROETHANE HFC-152A 75-37-6 30 - 40
2-METHYLPENTANE 107-83-5 10 - 20
POLYDIMETHYLSILOXANE 63148-62-9 3 - 5
N-HEXANE 110-54-3 1 - 3
SPECIFIC CHEMICAL IDENTITY AND/OR PERCENTAGE OF COMPOSITION HAS BEEN
WITHHELD AS A TRADE SECRET.
| 4. FIRST-AID MEASURES | |
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
SKIN CONTACT:
WASH OFF WITH SOAP AND PLENTY OF WATER. GET MEDICAL ATTENTION IF
IRRITATION DEVELOPS AND PERSISTS. TAKE OFF CONTAMINATED CLOTHING AND WASH
BEFORE REUSE.
EYE CONTACT:
RINSE WITH WATER. GET MEDICAL ATTENTION IF IRRITATION DEVELOPS AND
PERSISTS.
INGESTION:
CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY. DO NOT INDUCE
VOMITING. IF VOMITING OCCURS, KEEP HEAD LOW SO THAT STOMACH CONTENT
DOESN'T GET INTO THE LUNGS. ASPIRATION MAY CAUSE PULMONARY EDEMA AND
PNEUMONITIS.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
VAPORS HAVE A NARCOTIC EFFECT AND MAY CAUSE HEADACHE, FATIGUE, DIZZINESS
AND NAUSEA. MAY CAUSE DROWSINESS OR DIZZINESS. PROLONGED EXPOSURE MAY
CAUSE CHRONIC EFFECTS.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
PROVIDE GENERAL SUPPORTIVE MEASURES AND TREAT SYMPTOMATICALLY.
GENERAL INFORMATION:
IF EXPOSED OR CONCERNED:
GET MEDICAL ADVICE/ATTENTION. ENSURE THAT MEDICAL PERSONNEL ARE AWARE OF
THE MATERIAL(S) INVOLVED, AND TAKE PRECAUTIONS TO PROTECT THEMSELVES.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
WATER SPRAY. WATER FOG. FOAM. DRY CHEMICAL POWDER, CARBON DIOXIDE, SAND OR
EARTH MAY BE USED FOR SMALL FIRES ONLY.
UNSUITABLE EXTINGUISHING MEDIA:
DO NOT USE WATER JET AS AN EXTINGUISHER, AS THIS WILL SPREAD THE FIRE.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
CONTENTS UNDER PRESSURE. PRESSURIZED CONTAINER MAY EXPLODE WHEN EXPOSED TO
HEAT OR FLAME. THIS PRODUCT IS A POOR CONDUCTOR OF ELECTRICITY AND CAN
BECOME ELECTROSTATICALLY CHARGED. IF SUFFICIENT CHARGE IS ACCUMULATED,
IGNITION OF FLAMMABLE MIXTURES CAN OCCUR. STATIC ELECTRICITY ACCUMULATION
MAY BE SIGNIFICANTLY INCREASED BY THE PRESENCE OF SMALL QUANTITIES OF
WATER OR OTHER CONTAMINANTS. MATERIAL WILL FLOAT AND MAY IGNITE ON SURFACE
OF WATER.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
FIREFIGHTERS MUST USE STANDARD PROTECTIVE EQUIPMENT INCLUDING FLAME
RETARDANT COAT, HELMET WITH FACE SHIELD, GLOVES, RUBBER BOOTS, AND IN
ENCLOSED SPACES, SCBA.
FIRE-FIGHTING EQUIPMENT/INSTRUCTIONS:
IN CASE OF FIRE:
STOP LEAK IF SAFE TO DO SO. MOVE CONTAINERS FROM FIRE AREA IF YOU CAN DO
SO WITHOUT RISK. CONTAINERS SHOULD BE COOLED WITH WATER TO PREVENT VAPOR
PRESSURE BUILD UP. IN THE EVENT OF FIRE, COOL TANKS WITH WATER SPRAY.
GENERAL FIRE HAZARDS: EXTREMELY FLAMMABLE AEROSOL.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
KEEP UNNECESSARY PERSONNEL AWAY. KEEP PEOPLE AWAY FROM AND UPWIND OF
SPILL/LEAK. KEEP OUT OF LOW AREAS. REMOVE ALL POSSIBLE SOURCES OF IGNITION
IN THE SURROUNDING AREA. WEAR APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT.
DO NOT BREATHE GAS. DO NOT BREATHE MIST OR VAPOR. DO NOT TOUCH DAMAGED
CONTAINERS OR SPILLED MATERIAL UNLESS WEARING APPROPRIATE PROTECTIVE
CLOTHING. VENTILATE CLOSED SPACES BEFORE ENTERING THEM. USE APPROPRIATE
CONTAINMENT TO AVOID ENVIRONMENTAL CONTAMINATION. LOCAL AUTHORITIES SHOULD
BE ADVISED IF SIGNIFICANT SPILLAGES CANNOT BE CONTAINED. FOR PERSONAL
PROTECTION, SEE SECTION 8 OF THE SDS.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
ELIMINATE ALL IGNITION SOURCES (NO SMOKING, FLARES, SPARKS, OR FLAMES IN
IMMEDIATE AREA). KEEP COMBUSTIBLES (WOOD, PAPER, OIL, ETC.) AWAY FROM
SPILLED MATERIAL. THIS PRODUCT IS MISCIBLE IN WATER. STOP THE FLOW OF
MATERIAL, IF THIS IS WITHOUT RISK. COLLECT SPILLAGE. DIKE FAR AHEAD OF
SPILL FOR LATER DISPOSAL. WIPE UP WITH ABSORBENT MATERIAL (E.G. CLOTH,
FLEECE). CLEAN SURFACE THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
PREVENT ENTRY INTO WATERWAYS, SEWER, BASEMENTS OR CONFINED AREAS. FOR
WASTE DISPOSAL, SEE SECTION 13 OF THE SDS.
ENVIRONMENTAL PRECAUTIONS:
AVOID RELEASE TO THE ENVIRONMENT. CONTACT LOCAL AUTHORITIES IN CASE OF
SPILLAGE TO DRAIN/AQUATIC ENVIRONMENT. PREVENT FURTHER LEAKAGE OR SPILLAGE
IF SAFE TO DO SO. DO NOT CONTAMINATE WATER. AVOID DISCHARGE INTO DRAINS,
WATER COURSES OR ONTO THE GROUND. USE APPROPRIATE CONTAINMENT TO AVOID
ENVIRONMENTAL CONTAMINATION.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. MINIMIZE FIRE RISKS FROM
FLAMMABLE AND COMBUSTIBLE MATERIALS (INCLUDING COMBUSTIBLE DUST AND STATIC
ACCUMULATING LIQUIDS) OR DANGEROUS REACTIONS WITH INCOMPATIBLE MATERIALS.
HANDLING OPERATIONS THAT CAN PROMOTE ACCUMULATION OF STATIC CHARGES
INCLUDE BUT ARE NOT LIMITED TO:
MIXING, FILTERING, PUMPING AT HIGH FLOW RATES, SPLASH FILLING, CREATING
MISTS OR SPRAYS, TANK AND CONTAINER FILLING, TANK CLEANING, SAMPLING,
GAUGING, SWITCH LOADING, VACUUM TRUCK OPERATIONS.
PRESSURIZED CONTAINER:
DO NOT PIERCE OR BURN, EVEN AFTER USE. DO NOT USE IF SPRAY BUTTON IS
MISSING OR DEFECTIVE. DO NOT SPRAY ON A NAKED FLAME OR ANY OTHER
INCANDESCENT MATERIAL. DO NOT SMOKE WHILE USING OR UNTIL SPRAYED SURFACE
IS THOROUGHLY DRY. DO NOT CUT, WELD, SOLDER, DRILL, GRIND, OR EXPOSE
CONTAINERS TO HEAT, FLAME, SPARKS, OR OTHER SOURCES OF IGNITION. USE
CAUTION AROUND ENERGIZED EQUIPMENT. THE METAL CONTAINER WILL CONDUCT
ELECTRICITY IF IT CONTACTS A LIVE SOURCE. THIS MAY RESULT IN INJURY TO THE
USER FROM ELECTRICAL SHOCK AND/OR FLASH FIRE. DO NOT BREATHE MIST OR
VAPOR. DO NOT BREATHE GAS. AVOID CONTACT DURING PREGNANCY/WHILE NURSING.
AVOID PROLONGED EXPOSURE. USE ONLY IN WELL-VENTILATED AREAS. WEAR
APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT. WHEN USING, DO NOT EAT, DRINK
OR SMOKE. WASH HANDS THOROUGHLY AFTER HANDLING. OBSERVE GOOD INDUSTRIAL
HYGIENE PRACTICES. AVOID RELEASE TO THE ENVIRONMENT. DO NOT EMPTY INTO
DRAINS. FOR PRODUCT USAGE INSTRUCTIONS, PLEASE SEE THE PRODUCT LABEL.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
LEVEL 3 AEROSOL.
PRESSURIZED CONTAINER. PROTECT FROM SUNLIGHT AND DO NOT EXPOSE TO
TEMPERATURES EXCEEDING 50 DEG. C/122 DEG. F. DO NOT PUNCTURE, INCINERATE
OR CRUSH. DO NOT HANDLE OR STORE NEAR AN OPEN FLAME, HEAT OR OTHER SOURCES
OF IGNITION. THIS MATERIAL CAN ACCUMULATE STATIC CHARGE WHICH MAY CAUSE
SPARK AND BECOME AN IGNITION SOURCE. AVOID SPARK PROMOTERS. THESE ALONE
MAY BE INSUFFICIENT TO REMOVE STATIC ELECTRICITY. STORE IN A
WELL-VENTILATED PLACE. STORE AWAY FROM INCOMPATIBLE MATERIALS (SEE SECTION
10 OF THE SDS). KEEP OUT OF THE REACH OF CHILDREN.
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
OCCUPATIONAL EXPOSURE LIMITS:
US. OSHA TABLE Z-1 LIMITS FOR AIR CONTAMINANTS (29 CFR 1910.1000):
COMPONENTS TYPE VALUE
N-HEXANE PEL 1800 MG/M3
(CAS 110-54-3) 500 PPM
US. ACGIH THRESHOLD LIMIT VALUES:
COMPONENTS TYPE VALUE
2-METHYLPENTANE STEL 1000 PPM
(CAS 107-83-5) TWA 500 PPM
N-HEXANE TWA 50 PPM
(CAS 110-54-3)
US. NIOSH: POCKET GUIDE TO CHEMICAL HAZARDS
COMPONENTS TYPE VALUE
2-METHYLPENTANE CEILING 1800 MG/M3
(CAS 107-83-5) 510 PPM
TWA 350 MG/M3
100 PPM
N-HEXANE TWA 180 MG/M3
(CAS 110-54-3) 50 PPM
US. AIHA WORKPLACE ENVIRONMENTAL EXPOSURE LEVEL (WEEL) GUIDES:
COMPONENTS TYPE VALUE
1,1-DIFLUOROETHANE TWA 2700 MG/M3
(CAS 75-37-6) 1000 PPM
BIOLOGICAL LIMIT VALUES:
ACGIH BIOLOGICAL EXPOSURE INDICES:
COMPONENTS VALUE DETERMINANT SPECIMEN SAMPLING TIME
N-HEXANE 0.4 MG/L 2,5-HEXANEDIO URINE *
(CAS 110-54-3) N, WITHOUT
HYDROLYSIS
* - FOR SAMPLING DETAILS, PLEASE SEE THE SOURCE DOCUMENT.
EXPOSURE GUIDELINES:
US - CALIFORNIA OELS SKIN DESIGNATION
N-HEXANE (CAS 110-54-3) CAN BE ABSORBED THROUGH THE SKIN.
US ACGIH THRESHOLD LIMIT VALUES SKIN DESIGNATION
N-HEXANE (CAS 110-54-3) CAN BE ABSORBED THROUGH THE SKIN.
APPROPRIATE ENGINEERING CONTROLS:
GOOD GENERAL VENTILATION (TYPICALLY 10 AIR CHANGES PER HOUR) SHOULD BE
USED. VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS. IF APPLICABLE,
USE PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING
CONTROLS TO MAINTAIN AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS. IF
EXPOSURE LIMITS HAVE NOT BEEN ESTABLISHED, MAINTAIN AIRBORNE LEVELS TO AN
ACCEPTABLE LEVEL.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION: WEAR SAFETY GLASSES WITH SIDE SHIELDS (OR GOGGLES).
SKIN PROTECTION:
HAND PROTECTION:
WEAR PROTECTIVE GLOVES SUCH AS:
NITRILE. POLYVINYL CHLORIDE (PVC). VITON(R*).
OTHER: WEAR APPROPRIATE CHEMICAL RESISTANT CLOTHING.
RESPIRATORY PROTECTION:
WEAR POSITIVE PRESSURE SELF-CONTAINED BREATHING APPARATUS (SCBA). AIR
MONITORING IS NEEDED TO DETERMINE ACTUAL EMPLOYEE EXPOSURE LEVELS.
THERMAL HAZARDS:
WEAR APPROPRIATE THERMAL PROTECTIVE CLOTHING, WHEN NECESSARY.
GENERAL HYGIENE CONSIDERATIONS:
WHEN USING, DO NOT EAT, DRINK OR SMOKE. ALWAYS OBSERVE GOOD PERSONAL
HYGIENE MEASURES, SUCH AS WASHING AFTER HANDLING THE MATERIAL AND BEFORE
EATING, DRINKING, AND/OR SMOKING. ROUTINELY WASH WORK CLOTHING AND
PROTECTIVE EQUIPMENT TO REMOVE CONTAMINANTS.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: LIQUID.
FORM: AEROSOL.
COLOR: CLEAR WATER-WHITE.
ODOR: MILD SOLVENT.
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
MELTING POINT/FREEZING POINT: NOT AVAILABLE.
INITIAL BOILING POINT AND BOILING RANGE:
118.4 DEG. F (48 DEG. C) ESTIMATED
FLASH POINT: <0 DEG. F (<-17.8 DEG. C) TAG CLOSED CUP
EVAPORATION RATE: FAST.
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS:
FLAMMABILITY LIMIT - LOWER (%): 1% ESTIMATED
FLAMMABILITY LIMIT - UPPER (%): 8% ESTIMATED
VAPOR PRESSURE: 3083.3 HPA ESTIMATED
VAPOR DENSITY: >1 (AIR = 1)
RELATIVE DENSITY: 0.81 ESTIMATED
SOLUBILITY (WATER): NEGLIGIBLE.
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: 437 DEG. F (225 DEG. C) ESTIMATED
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
VISCOSITY (KINEMATIC): NOT AVAILABLE.
PERCENT VOLATILE: 97% ESTIMATED
| 10. STABILITY AND REACTIVITY | |
REACTIVITY:
THE PRODUCT IS STABLE AND NON-REACTIVE UNDER NORMAL CONDITIONS OF USE,
STORAGE AND TRANSPORT.
CHEMICAL STABILITY: MATERIAL IS STABLE UNDER NORMAL CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS:
NO DANGEROUS REACTION KNOWN UNDER CONDITIONS OF NORMAL USE.
CONDITIONS TO AVOID:
HEAT, FLAMES AND SPARKS. CONTACT WITH INCOMPATIBLE MATERIALS.
INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS. CHLORINE.
HAZARDOUS DECOMPOSITION PRODUCTS: CARBON OXIDES.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INGESTION: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
INHALATION:
VAPORS HAVE A NARCOTIC EFFECT AND MAY CAUSE HEADACHE, FATIGUE, DIZZINESS
AND NAUSEA.
PROLONGED INHALATION MAY BE HARMFUL. MAY CAUSE DAMAGE TO ORGANS BY
INHALATION.
SKIN CONTACT:
PROLONGED SKIN CONTACT MAY CAUSE TEMPORARY IRRITATION. FREQUENT OR
PROLONGED CONTACT MAY DEFAT AND DRY THE SKIN, LEADING TO DISCOMFORT AND
DERMATITIS.
EYE CONTACT: DIRECT CONTACT WITH EYES MAY CAUSE TEMPORARY IRRITATION.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
SYMPTOMS OF OVEREXPOSURE MAY BE HEADACHE, DIZZINESS, TIREDNESS, NAUSEA AND
VOMITING.
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY:
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. NARCOTIC EFFECTS.
PRODUCT SPECIES TEST RESULTS
INDUSTRIAL SILICONE:
ACUTE:
DERMAL:
LD50 RABBIT 3663.2004 MG/KG ESTIMATED
INHALATION:
LC50 RAT 984.9073 MG/L, 4 HOURS ESTIMATED
ORAL:
LD50 RAT 22253.0469 MG/KG ESTIMATED
* ESTIMATES FOR PRODUCT MAY BE BASED ON ADDITIONAL COMPONENT DATA NOT
SHOWN.
SKIN CORROSION/IRRITATION:
PROLONGED SKIN CONTACT MAY CAUSE TEMPORARY IRRITATION.
SERIOUS EYE DAMAGE/EYE IRRITATION:
DIRECT CONTACT WITH EYES MAY CAUSE TEMPORARY IRRITATION.
RESPIRATORY SENSITIZATION: NOT AVAILABLE.
SKIN SENSITIZATION:
THIS PRODUCT IS NOT EXPECTED TO CAUSE SKIN SENSITIZATION.
GERM CELL MUTAGENICITY:
NO DATA AVAILABLE TO INDICATE PRODUCT OR ANY COMPONENTS PRESENT AT GREATER
THAN 0.1% ARE MUTAGENIC OR GENOTOXIC.
CARCINOGENICITY:
THIS PRODUCT IS NOT CONSIDERED TO BE A CARCINOGEN BY IARC, ACGIH, NTP, OR
OSHA.
REPRODUCTIVE TOXICITY: SUSPECTED OF DAMAGING FERTILITY.
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE: NARCOTIC EFFECTS.
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE:
MAY CAUSE DAMAGE TO ORGANS (NERVOUS SYSTEM, UPPER RESPIRATORY TRACT, SKIN,
EYES) THROUGH PROLONGED OR REPEATED EXPOSURE.
ASPIRATION HAZARD: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
CHRONIC EFFECTS:
PROLONGED INHALATION MAY BE HARMFUL. MAY CAUSE DAMAGE TO ORGANS THROUGH
PROLONGED OR REPEATED EXPOSURE.
OVEREXPOSURE TO N-HEXANE MAY CAUSE PROGRESSIVE AND POTENTIALLY
IRREVERSIBLE DAMAGE TO THE PERIPHERAL NERVOUS SYSTEM, PARTICULARLY IN THE
ARMS AND LEGS.
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY:
HARMFUL TO AQUATIC LIFE WITH LONG LASTING EFFECTS. ACCUMULATION IN AQUATIC
ORGANISMS IS EXPECTED.
PRODUCT SPECIES TEST RESULTS
INDUSTRIAL SILICONE:
AQUATIC:
FISH LC50 FISH 372.3494 MG/L, 96 HOURS ESTIMATED
COMPONENTS SPECIES TEST RESULTS
N-HEXANE (CAS 110-54-3):
AQUATIC:
FISH LC50 FATHEAD MINNOW 2.101 - 2.981 MG/L, 96 HOURS
(PIMEPHALES PROMELAS)
POLYDIMETHYLSILOXANE (CAS 63148-62-9):
AQUATIC:
FISH LC50 CHANNEL CATFISH 2.36 - 4.15 MG/L, 96 HOURS
(ICTALURUS PUNCTATUS)
* ESTIMATES FOR PRODUCT MAY BE BASED ON ADDITIONAL COMPONENT DATA NOT
SHOWN.
PERSISTENCE AND DEGRADABILITY:
NO DATA IS AVAILABLE ON THE DEGRADABILITY OF THIS PRODUCT.
BIOACCUMULATIVE POTENTIAL: NO DATA AVAILABLE.
PARTITION COEFFICIENT N-OCTANOL / WATER (LOG KOW):
1,1-DIFLUOROETHANE: 0.75
2-METHYLPENTANE: 3.74
N-HEXANE: 3.9
MOBILITY IN SOIL: NO DATA AVAILABLE.
OTHER ADVERSE EFFECTS:
NO OTHER ADVERSE ENVIRONMENTAL EFFECTS (E.G. OZONE DEPLETION,
PHOTOCHEMICAL OZONE CREATION POTENTIAL, ENDOCRINE DISRUPTION, GLOBAL
WARMING POTENTIAL) ARE EXPECTED FROM THIS COMPONENT.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL OF WASTE FROM RESIDUES / UNUSED PRODUCTS:
THIS MATERIAL AND ITS CONTAINER MUST BE DISPOSED OF AS HAZARDOUS WASTE.
IF DISCARDED, THIS PRODUCT IS CONSIDERED A RCRA IGNITABLE WASTE, D001.
CONSULT AUTHORITIES BEFORE DISPOSAL. CONTENTS UNDER PRESSURE. DO NOT
PUNCTURE, INCINERATE OR CRUSH. DO NOT ALLOW THIS MATERIAL TO DRAIN INTO
SEWERS/WATER SUPPLIES. DO NOT CONTAMINATE PONDS, WATERWAYS OR DITCHES WITH
CHEMICAL OR USED CONTAINER. DISPOSE IN ACCORDANCE WITH ALL APPLICABLE
REGULATIONS.
HAZARDOUS WASTE CODE:
D001: WASTE FLAMMABLE MATERIAL WITH A FLASH POINT <140 F
CONTAMINATED PACKAGING:
EMPTY CONTAINERS SHOULD BE TAKEN TO AN APPROVED WASTE HANDLING SITE FOR
RECYCLING OR DISPOSAL. SINCE EMPTIED CONTAINERS MAY RETAIN PRODUCT
RESIDUE, FOLLOW LABEL WARNINGS EVEN AFTER CONTAINER IS EMPTIED.
| 14. TRANSPORT INFORMATION | |
DOT:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, FLAMMABLE, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
LABEL(S): 2.1
PACKING GROUP: NOT APPLICABLE.
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
SPECIAL PROVISIONS: N82
PACKAGING EXCEPTIONS: 306
PACKAGING NON BULK: NONE
PACKAGING BULK: NONE
IATA:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, FLAMMABLE, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
SUBSIDIARY RISK:
PACKING GROUP: NOT APPLICABLE.
ENVIRONMENTAL HAZARDS: NO.
ERG CODE: 10L
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
OTHER INFORMATION:
PASSENGER AND CARGO AIRCRAFT: ALLOWED.
CARGO AIRCRAFT ONLY: ALLOWED.
IMDG:
UN NUMBER: UN1950
UN PROPER SHIPPING NAME: AEROSOLS, LIMITED QUANTITY
TRANSPORT HAZARD CLASS(ES):
CLASS: 2
SUBSIDIARY RISK:
PACKING GROUP: NOT APPLICABLE.
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: NO.
EMS: F-D, S-U
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
| 15. REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
ALL COMPONENTS ARE ON THE U.S. EPA TSCA INVENTORY LIST.
TSCA SECTION 12(B) EXPORT NOTIFICATION (40 CFR 707, SUBPT. D):
NOT REGULATED.
SARA 304 EMERGENCY RELEASE NOTIFICATION: NOT REGULATED.
US. OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1050):
NOT LISTED.
US EPCRA (SARA TITLE III) SECTION 313 - TOXIC CHEMICAL LISTED SUBSTANCE
N-HEXANE (CAS 110-54-3)
CERCLA HAZARDOUS SUBSTANCE LIST (40 CFR 302.4): N-HEXANE (CAS 110-54-3)
CERCLA HAZARDOUS SUBSTANCES REPORTABLE QUANTITY
N-HEXANE (CAS 110-54-3) 5000 LBS
SPILLS OR RELEASES RESULTING IN THE LOSS OF ANY INGREDIENT AT OR ABOVE ITS
RQ REQUIRE IMMEDIATE NOTIFICATION TO THE NATIONAL RESPONSE CENTER
(800-424-8802) AND TO YOUR LOCAL EMERGENCY PLANNING COMMITTEE.
CLEAN AIR ACT (CAA) SECTION 112 HAZARDOUS AIR POLLUTANTS (HAPS) LIST:
N-HEXANE (CAS 110-54-3)
CLEAN AIR ACT (CAA) SECTION 112(R) ACCIDENTAL RELEASE PREVENTION
(40 CFR 68.130): 1,1-DIFLUOROETHANE (CAS 75-37-6)
SAFE DRINKING WATER ACT (SDWA): NOT REGULATED.
FOOD AND DRUG ADMINISTRATION (FDA): NOT REGULATED.
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA):
SECTION 311/312 HAZARD CATEGORIES:
IMMEDIATE HAZARD: YES
DELAYED HAZARD: YES
FIRE HAZARD: YES
PRESSURE HAZARD: YES
REACTIVITY HAZARD: NO
SARA 302 EXTREMELY HAZARDOUS SUBSTANCE: NO
US STATE REGULATIONS:
US. NEW JERSEY WORKER AND COMMUNITY RIGHT-TO-KNOW ACT:
1,1-DIFLUOROETHANE (CAS 75-37-6)
2-METHYLPENTANE (CAS 107-83-5)
N-HEXANE (CAS 110-54-3)
US. MASSACHUSETTS RTK - SUBSTANCE LIST:
1,1-DIFLUOROETHANE (CAS 75-37-6)
2-METHYLPENTANE (CAS 107-83-5)
N-HEXANE (CAS 110-54-3)
US. PENNSYLVANIA WORKER AND COMMUNITY RIGHT-TO-KNOW LAW:
2-METHYLPENTANE (CAS 107-83-5)
N-HEXANE (CAS 110-54-3)
US. RHODE ISLAND RTK:
1,1-DIFLUOROETHANE (CAS 75-37-6)
N-HEXANE (CAS 110-54-3)
US. CALIFORNIA PROPOSITION 65:
CALIFORNIA SAFE DRINKING WATER AND TOXIC ENFORCEMENT ACT OF 1986
(PROPOSITION 65):
THIS MATERIAL IS NOT KNOWN TO CONTAIN ANY CHEMICALS CURRENTLY LISTED AS
CARCINOGENS OR REPRODUCTIVE TOXINS.
VOLATILE ORGANIC COMPOUNDS (VOC) REGULATIONS:
EPA:
VOC CONTENT (40 CFR 51.100(S)): 60%
CONSUMER PRODUCTS (40 CFR 59, SUBPT. C): NOT REGULATED
STATE:
CONSUMER PRODUCTS:
THIS PRODUCT IS REGULATED AS A SILICONE BASED MULTI-PURPOSE LUBRICANT.
THIS PRODUCT IS COMPLIANT FOR USE IN ALL 50 STATES.
VOC CONTENT (CA): 60%
VOC CONTENT (OTC): 60%
INTERNATIONAL INVENTORIES:
COUNTRY(S) OR REGION INVENTORY NAME ON INVENTORY
(YES/NO)*
AUSTRALIA AUSTRALIAN INVENTORY OF CHEMICAL YES
SUBSTANCES (AICS)
CANADA DOMESTIC SUBSTANCES LIST (DSL) YES
CANADA NON-DOMESTIC SUBSTANCES LIST (NDSL) NO
CHINA INVENTORY OF EXISTING CHEMICAL YES
SUBSTANCES IN CHINA (IECSC)
EUROPE EUROPEAN INVENTORY OF EXISTING NO
COMMERCIAL CHEMICAL SUBSTANCES
(EINECS)
EUROPE EUROPEAN LIST OF NOTIFIED CHEMICAL NO
SUBSTANCES (ELINCS)
JAPAN INVENTORY OF EXISTING AND NEW NO
CHEMICAL SUBSTANCES (ENCS)
KOREA EXISTING CHEMICALS LIST (ECL) YES
NEW ZEALAND NEW ZEALAND INVENTORY YES
PHILIPPINES PHILIPPINE INVENTORY OF CHEMICALS YES
AND CHEMICAL SUBSTANCES (PICCS)
UNITED STATES & TOXIC SUBSTANCES CONTROL ACT (TSCA) YES
PUERTO RICO INVENTORY
*A "YES" INDICATES THAT ALL COMPONENTS OF THIS PRODUCT COMPLY WITH THE
INVENTORY REQUIREMENTS ADMINISTERED BY THE GOVERNING COUNTRY(S)
A "NO" INDICATES THAT ONE OR MORE COMPONENTS OF THE PRODUCT ARE NOT LISTED
OR EXEMPT FROM LISTING ON THE INVENTORY ADMINISTERED BY THE GOVERNING
COUNTRY(S).
| 16. OTHER INFORMATION | |
INCLUDING DATE OF PREPARATION OR LAST REVISION
ISSUE DATE: 05-14-2014
PREPARED BY: ALLISON CHO
VERSION #: 01
FURTHER INFORMATION: CRC # 519E-F
HMIS(R*) RATINGS:
HEALTH 2*
FLAMMABILITY 4
PHYSICAL HAZARD 0
PERSONAL PROTECTION B
NFPA RATINGS:
HEALTH 2
FLAMMABILITY 4
INSTABILITY 0
DISCLAIMER:
THE INFORMATION CONTAINED IN THIS DOCUMENT APPLIES TO THIS SPECIFIC
MATERIAL AS SUPPLIED. IT MAY NOT BE VALID FOR THIS MATERIAL IF IT IS USED
IN COMBINATION WITH ANY OTHER MATERIALS. THIS INFORMATION IS ACCURATE TO
THE BEST OF CRC INDUSTRIES' KNOWLEDGE OR OBTAINED FROM SOURCES BELIEVED BY
CRC TO BE ACCURATE. BEFORE USING ANY PRODUCT, READ ALL WARNINGS AND
DIRECTIONS ON THE LABEL. FOR FURTHER CLARIFICATION OF ANY INFORMATION
CONTAINED ON THIS (M)SDS CONSULT YOUR SUPERVISOR, A HEALTH & SAFETY
PROFESSIONAL, OR CRC INDUSTRIES.
MATERIAL NAME: INDUSTRIAL SILICONE
2620
SDS: US