| Common Name: | PVC HEAVY DUTY CLEAR OR GRAY CEMENT |
| Manufacturer: | OATEY |
| SDS Revision Date: | 7/1/2022 |
| SDS Format: | No Format Specified |
| Item Number(s): | 29FH97, 29FJ04, 39AN94, 39AP12, 49K210, 58NG04, 58NG05, 807W31, 807W32, 807W39, 807W40, 807W44 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
OATEY(R*)
SAFETY DATA SHEET
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFIER: OATEY PVC HEAVY DUTY CLEAR OR GRAY CEMENT
OTHER MEANS OF IDENTIFICATION:
SDS NUMBER: 1102EV
SYNONYMS:
PART NUMBERS:
30850,30850V, 30863 30863V, 30876, 30876V, 30882, 31008, 31008V, 31011,
31011R, 31011V, 31950, 31951, 31952, 31953, 31953R, 30349, 31093, 31093V,
31094, 31094V, 31095,31095V, 31105, 31105V, 31118, 31118V, 31978, 31979,
31980, 31981, 32050, 32051, 32052, 32210, 32211
RECOMMENDED USE: JOINING PVC PIPES
RECOMMENDED RESTRICTIONS: NONE KNOWN.
MANUFACTURER/IMPORTER/SUPPLIER/DISTRIBUTOR INFORMATION:
COMPANY NAME: OATEY CO.
ADDRESS:
4700 WEST 160TH ST.
CLEVELAND, OH 44135
TELEPHONE: 216-267-7100
E-MAIL: INFO@OATEY.COM
TRANSPORT EMERGENCY:
CHEMTREC: 1-800-424-9300 (OUTSIDE THE US 1-703-527-3887)
EMERGENCY FIRST AID: 1-877-740-5015
CONTACT PERSON: MSDS COORDINATOR
| 2. HAZARD(S) IDENTIFICATION | |
PHYSICAL HAZARDS:
FLAMMABLE LIQUIDS: CATEGORY 2
HEALTH HAZARDS:
ACUTE TOXICITY, ORAL: CATEGORY 4
SKIN CORROSION/IRRITATION: CATEGORY 2
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 2A
SPECIFIC TARGET ORGAN TOXICITY, SINGLE EXPOSURE:
CATEGORY 3 RESPIRATORY TRACT IRRITATION
SPECIFIC TARGET ORGAN TOXICITY, SINGLE EXPOSURE:
CATEGORY 3 NARCOTIC EFFECTS
ASPIRATION HAZARD: CATEGORY 1
OSHA DEFINED HAZARDS: NOT CLASSIFIED.
LABEL ELEMENTS:
FLAME
HEALTH HAZARD
EXCLAMATION MARK
SIGNAL WORD: DANGER
HAZARD STATEMENT:
HIGHLY FLAMMABLE LIQUID AND VAPOR. HARMFUL IF SWALLOWED. MAY BE FATAL IF
SWALLOWED AND ENTERS AIRWAYS. CAUSES SKIN IRRITATION. CAUSES SERIOUS EYE
IRRITATION. MAY CAUSE RESPIRATORY IRRITATION. MAY CAUSE DROWSINESS OR
DIZZINESS.
PRECAUTIONARY STATEMENT:
PREVENTION:
KEEP AWAY FROM HEAT/SPARKS/OPEN FLAMES/HOT SURFACES. - NO SMOKING. USE
ONLY OUTDOORS OR IN A WELL-VENTILATED AREA. KEEP CONTAINER TIGHTLY
CLOSED. GROUND/BOND CONTAINER AND RECEIVING EQUIPMENT. USE EXPLOSION-PROOF
ELECTRICAL/VENTILATING/LIGHTING EQUIPMENT. USE ONLY NON-SPARKING TOOLS.
TAKE PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGE. AVOID BREATHING
MIST OR VAPOR. WASH THOROUGHLY AFTER HANDLING. DO NOT EAT, DRINK OR SMOKE
WHEN USING THIS PRODUCT. WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE
PROTECTION/FACE PROTECTION.
RESPONSE:
RINSE MOUTH. DO NOT INDUCE VOMITING.
IF SKIN IRRITATION OCCURS: GET MEDICAL ADVICE/ATTENTION.
IF EYE IRRITATION PERSISTS:
GET MEDICAL ADVICE/ATTENTION. TAKE OFF CONTAMINATED CLOTHING AND WASH
BEFORE REUSE.
IN CASE OF FIRE: USE APPROPRIATE MEDIA TO EXTINGUISH.
STORAGE:
STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED. KEEP
COOL. STORE LOCKED UP.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH LOCAL/REGIONAL/NATIONAL/
INTERNATIONAL REGULATIONS.
HAZARD(S) NOT OTHERWISE CLASSIFIED (HNOC):
FREQUENT OR PROLONGED CONTACT MAY DEFAT AND DRY THE SKIN, LEADING TO
DISCOMFORT AND DERMATITIS. MAY FORM EXPLOSIVE PEROXIDES. CONTAINS A
CHEMICAL CLASSIFIED BY THE US EPA AS A SUSPECTED POSSIBLE CARCINOGEN.
SUPPLEMENTAL INFORMATION: NOT APPLICABLE.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
MIXTURES:
CHEMICAL NAME CAS NUMBER %
FURAN, TETRAHYDRO- 109-99-9 30-60
2-PROPANONE 67-64-1 10-30
CYCLOHEXANONE 108-94-1 10-30
POLYVINYL CHLORIDE 9002-86-2 10-30
METHYL ETHYL KETONE 78-93-3 5-10
COLLOIDAL SILICON DIOXIDE 112945-52-5 1-5
*DESIGNATES THAT A SPECIFIC CHEMICAL IDENTITY AND/OR PERCENTAGE OF
COMPOSITION HAS BEEN WITHHELD AS A TRADE SECRET.
| 4. FIRST-AID MEASURES | |
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
SKIN CONTACT:
TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. WASH WITH PLENTY OF SOAP
AND WATER.
IF SKIN IRRITATION OCCURS:
GET MEDICAL ADVICE/ATTENTION. TAKE OFF CONTAMINATED CLOTHING AND WASH
BEFORE REUSE.
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.
REMOVE CONTACT LENSES, IF PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
INGESTION:
CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY. DO NOT INDUCE
VOMITING. IF VOMITING OCCURS, KEEP HEAD LOW SO THAT STOMACH CONTENT
DOESN'T GET INTO THE LUNGS. ASPIRATION MAY CAUSE PULMONARY EDEMA AND
PNEUMONITIS.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
SYMPTOMS MAY INCLUDE STINGING, TEARING, REDNESS, SWELLING, AND BLURRED
VISION. SKIN IRRITATION. VAPORS HAVE A NARCOTIC EFFECT AND MAY CAUSE
HEADACHE, FATIGUE, DIZZINESS AND NAUSEA. MAY CAUSE REDNESS AND PAIN.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
PROVIDE GENERAL SUPPORTIVE MEASURES AND TREAT SYMPTOMATICALLY.
THERMAL BURNS:
FLUSH WITH WATER IMMEDIATELY. WHILE FLUSHING, REMOVE CLOTHES WHICH DO
NOT ADHERE TO AFFECTED AREA. CALL AN AMBULANCE. CONTINUE FLUSHING DURING
TRANSPORT TO HOSPITAL. IN CASE OF SHORTNESS OF BREATH, GIVE OXYGEN. KEEP
VICTIM WARM. KEEP VICTIM UNDER OBSERVATION. SYMPTOMS MAY BE DELAYED.
GENERAL INFORMATION:
TAKE OFF ALL CONTAMINATED CLOTHING IMMEDIATELY.
IF EXPOSED OR CONCERNED:
GET MEDICAL ADVICE/ATTENTION. ENSURE THAT MEDICAL PERSONNEL ARE AWARE OF
THE MATERIAL(S) INVOLVED, AND TAKE PRECAUTIONS TO PROTECT THEMSELVES. WASH
CONTAMINATED CLOTHING BEFORE REUSE.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
ALCOHOL RESISTANT FOAM. WATER FOG. DRY CHEMICAL POWDER. CARBON DIOXIDE
(CO2).
UNSUITABLE EXTINGUISHING MEDIA:
DO NOT USE WATER JET AS AN EXTINGUISHER, AS THIS WILL SPREAD THE FIRE.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
VAPORS MAY FORM EXPLOSIVE MIXTURES WITH AIR. VAPORS MAY TRAVEL
CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK.
DURING FIRE, GASES HAZARDOUS TO HEALTH MAY BE FORMED.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING MUST BE
WORN IN CASE OF FIRE.
FIRE FIGHTING EQUIPMENT/INSTRUCTIONS:
IN CASE OF FIRE AND/OR EXPLOSION DO NOT BREATHE FUMES. MOVE CONTAINERS
FROM FIRE AREA IF YOU CAN DO SO WITHOUT RISK.
SPECIFIC METHODS:
USE STANDARD FIREFIGHTING PROCEDURES AND CONSIDER THE HAZARDS OF OTHER
INVOLVED MATERIALS.
GENERAL FIRE HAZARDS:
HIGHLY FLAMMABLE LIQUID AND VAPOR. THIS PRODUCT CONTAINS TETRAHYDROFURAN
THAT MAY FORM EXPLOSIVE ORGANIC PEROXIDE WHEN EXPOSED TO AIR OR LIGHT OR
WITH AGE.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
KEEP UNNECESSARY PERSONNEL AWAY. KEEP PEOPLE AWAY FROM AND UPWIND OF
SPILL/LEAK. KEEP OUT OF LOW AREAS. ELIMINATE ALL IGNITION SOURCES
(NO SMOKING, FLARES, SPARKS, OR FLAMES IN IMMEDIATE AREA). WEAR
APPROPRIATE PROTECTIVE EQUIPMENT AND CLOTHING DURING CLEAN-UP. AVOID
INHALATION OF VAPORS OR MISTS. DO NOT TOUCH DAMAGED CONTAINERS OR
SPILLED MATERIAL UNLESS WEARING APPROPRIATE PROTECTIVE CLOTHING.
VENTILATE CLOSED SPACES BEFORE ENTERING THEM. LOCAL AUTHORITIES SHOULD
BE ADVISED IF SIGNIFICANT SPILLAGES CANNOT BE CONTAINED. FOR PERSONAL
PROTECTION, SEE SECTION 8 OF THE SDS.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
ELIMINATE ALL IGNITION SOURCES (NO SMOKING, FLARES, SPARKS, OR FLAMES IN
IMMEDIATE AREA). TAKE PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGE. USE
ONLY NON-SPARKING TOOLS. KEEP COMBUSTIBLES (WOOD, PAPER, OIL, ETC.) AWAY
FROM SPILLED MATERIAL.
LARGE SPILLS:
STOP THE FLOW OF MATERIAL, IF THIS IS WITHOUT RISK. DIKE THE SPILLED
MATERIAL, WHERE THIS IS POSSIBLE. COVER WITH PLASTIC SHEET TO PREVENT
SPREADING. USE A NON-COMBUSTIBLE MATERIAL LIKE VERMICULITE, SAND OR EARTH
TO SOAK UP THE PRODUCT AND PLACE INTO A CONTAINER FOR LATER DISPOSAL. USE
WATER SPRAY TO REDUCE VAPORS OR DIVERT VAPOR CLOUD DRIFT. PREVENT ENTRY
INTO WATERWAYS, SEWER, BASEMENTS OR CONFINED AREAS. FOLLOWING PRODUCT
RECOVERY, FLUSH AREA WITH WATER.
SMALL SPILLS:
WIPE UP WITH ABSORBENT MATERIAL (E.G. CLOTH, FLEECE). CLEAN SURFACE
THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
NEVER RETURN SPILLS TO ORIGINAL CONTAINERS FOR RE-USE. FOR WASTE DISPOSAL,
SEE SECTION 13 OF THE SDS.
ENVIRONMENTAL PRECAUTIONS:
AVOID DISCHARGE INTO DRAINS, WATER COURSES OR ONTO THE GROUND.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
VAPORS MAY FORM EXPLOSIVE MIXTURES WITH AIR. DO NOT HANDLE, STORE OR
OPEN NEAR AN OPEN FLAME, SOURCES OF HEAT OR SOURCES OF IGNITION. PROTECT
MATERIAL FROM DIRECT SUNLIGHT. TAKE PRECAUTIONARY MEASURES AGAINST STATIC
DISCHARGES. ALL EQUIPMENT USED WHEN HANDLING THE PRODUCT MUST BE GROUNDED.
USE NON-SPARKING TOOLS AND EXPLOSION-PROOF EQUIPMENT. DO NOT TASTE OR
SWALLOW. AVOID BREATHING MIST OR VAPOR. AVOID CONTACT WITH SKIN. AVOID
CONTACT WITH EYES. AVOID PROLONGED EXPOSURE. AVOID CONTACT WITH CLOTHING.
PROVIDE ADEQUATE VENTILATION. WEAR APPROPRIATE PERSONAL PROTECTIVE
EQUIPMENT. OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES. WHEN USING, DO NOT
EAT, DRINK OR SMOKE. WASH HANDS THOROUGHLY AFTER HANDLING.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
STORE LOCKED UP. KEEP AWAY FROM HEAT, SPARKS AND OPEN FLAME. PREVENT
ELECTROSTATIC CHARGE BUILD-UP BY USING COMMON BONDING AND GROUNDING
TECHNIQUES. STORE IN ORIGINAL TIGHTLY CLOSED CONTAINER. STORE IN A COOL,
DRY PLACE OUT OF DIRECT SUNLIGHT. STORE IN A WELL-VENTILATED PLACE. STORE
AWAY FROM INCOMPATIBLE MATERIALS (SEE SECTION 10 OF THE SDS). KEEP IN AN
AREA EQUIPPED WITH SPRINKLERS.
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
OCCUPATIONAL EXPOSURE LIMITS:
U.S. - OSHA:
COMPONENTS TYPE VALUE FORM
COLLOIDAL SILICON DIOXIDE TWA 0.8 MG/M3 UNSPECIFIED.
(CAS 112945-52-5) 20 MPPCF UNSPECIFIED.
US. OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1050):
COMPONENTS TYPE VALUE
POLYVINYL CHLORIDE STEL 5 PPM
(CAS 9002-86-2)
TWA 1 PPM
US. OSHA TABLE Z-1 LIMITS FOR AIR CONTAMINANTS (29 CFR 1910.1000):
COMPONENTS TYPE VALUE FORM
2-PROPANONE PEL 2400 MG/M3
(CAS 67-64-1) 1000 PPM
CYCLOHEXANONE PEL 200 MG/M3
(CAS 108-94-1) 50 PPM
FURAN, TETRAHYDRO- PEL 590 MG/M3
(CAS 109-99-9) 200 PPM
METHYL ETHYL KETONE PEL 590 MG/M3
(CAS 78-93-3) 200 PPM
POLYVINYL CHLORIDE PEL 5 MG/M3 RESPIRABLE FRACTION.
(CAS 9002-86-2) 15 MG/M3 TOTAL DUST.
US. OSHA TABLE Z-3 (29 CFR 1910.1000):
COMPONENTS TYPE VALUE
COLLOIDAL SILICON DIOXIDE TWA 0.8 MG/M3
(CAS 112945-52-5) 20 MPPCF
US. ACGIH THRESHOLD LIMIT VALUES:
COMPONENTS TYPE VALUE FORM
2-PROPANONE STEL 750 PPM
(CAS 67-64-1)
TWA 500 PPM
CYCLOHEXANONE STEL 50 PPM
(CAS 108-94-1)
TWA 20 PPM
FURAN, TETRAHYDRO- STEL 100 PPM
(CAS 109-99-9)
TWA 50 PPM
METHYL ETHYL KETONE STEL 300 PPM
(CAS 78-93-3)
TWA 200 PPM
POLYVINYL CHLORIDE TWA 1 MG/M3 RESPIRABLE FRACTION.
(CAS 9002-86-2)
U.S. - NIOSH:
COMPONENTS TYPE VALUE FORM
COLLOIDAL SILICON DIOXIDE REL 6 MG/M3 UNSPECIFIED.
(CAS 112945-52-5)
US. NIOSH POCKET GUIDE TO CHEMICAL HAZARDS:
COMPONENTS TYPE VALUE
2-PROPANONE TWA 590 MG/M3
(CAS 67-64-1) 250 PPM
COLLOIDAL SILICON DIOXIDE TWA 6 MG/M3
(CAS 112945-52-5)
CYCLOHEXANONE TWA 100 MG/M3
(CAS 108-94-1)
FURAN, TETRAHYDRO- STEL 735 MG/M3
(CAS 109-99-9) 250 PPM
TWA 590 MG/M3
200 PPM
METHYL ETHYL KETONE STEL 885 MG/M3
(CAS 78-93-3) 300 PPM
TWA 590 MG/M3
200 PPM
BIOLOGICAL LIMIT VALUES:
ACGIH BIOLOGICAL EXPOSURE INDICES:
COMPONENTS VALUE DETERMINANT SPECIMEN SAMPLING TIME
2-PROPANONE 50 MG/L ACETONE URINE *
(CAS 67-64-1)
CYCLOHEXANONE 80 MG/L 1,2-CYCLOHEXAN URINE *
(CAS 108-94-1) EDIOL, WITH
HYDROLYSIS
8 MG/L CYCLOHEXANOL, URINE *
WITH HYDROLYSIS
FURAN, TETRAHYDRO- 2 MG/L TETRAHYDROFURAN URINE *
(CAS 109-99-9)
METHYL ETHYL KETONE 2 MG/L MEK URINE *
(CAS 78-93-3)
* - FOR SAMPLING DETAILS, PLEASE SEE THE SOURCE DOCUMENT.
EXPOSURE GUIDELINES:
US - CALIFORNIA OELS SKIN DESIGNATION
CYCLOHEXANONE (CAS 108-94-1) CAN BE ABSORBED THROUGH THE SKIN.
US - MINNESOTA HAZ SUBS SKIN DESIGNATION APPLIES
CYCLOHEXANONE (CAS 108-94-1) SKIN DESIGNATION APPLIES.
US - TENNESSEE OELS SKIN DESIGNATION
CYCLOHEXANONE (CAS 108-94-1) CAN BE ABSORBED THROUGH THE SKIN.
US ACGIH THRESHOLD LIMIT VALUES SKIN DESIGNATION
CYCLOHEXANONE (CAS 108-94-1) CAN BE ABSORBED THROUGH THE SKIN.
FURAN, TETRAHYDRO- (CAS 109-99-9) CAN BE ABSORBED THROUGH THE SKIN.
US. NIOSH POCKET GUIDE TO CHEMICAL HAZARDS:
CYCLOHEXANONE (CAS 108-94-1) CAN BE ABSORBED THROUGH THE SKIN.
APPROPRIATE ENGINEERING CONTROLS:
EXPLOSION-PROOF GENERAL AND LOCAL EXHAUST VENTILATION. GOOD GENERAL
VENTILATION (TYPICALLY 10 AIR CHANGES PER HOUR) SHOULD BE USED.
VENTILATION RATES SHOULD BE MATCHED TO CONDITIONS. IF APPLICABLE, USE
PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING
CONTROLS TO MAINTAIN AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS.
IF EXPOSURE LIMITS HAVE NOT BEEN ESTABLISHED, MAINTAIN AIRBORNE LEVELS
TO AN ACCEPTABLE LEVEL. EYE WASH FACILITIES AND EMERGENCY SHOWER MUST BE
AVAILABLE WHEN HANDLING THIS PRODUCT.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION: WEAR SAFETY GLASSES WITH SIDE SHIELDS (OR GOGGLES).
SKIN PROTECTION:
HAND PROTECTION: WEAR APPROPRIATE CHEMICAL RESISTANT GLOVES.
OTHER: WEAR APPROPRIATE CHEMICAL RESISTANT CLOTHING.
RESPIRATORY PROTECTION:
IF ENGINEERING CONTROLS DO NOT MAINTAIN AIRBORNE CONCENTRATIONS BELOW
RECOMMENDED EXPOSURE LIMITS (WHERE APPLICABLE) OR TO AN ACCEPTABLE LEVEL
(IN COUNTRIES WHERE EXPOSURE LIMITS HAVE NOT BEEN ESTABLISHED), AN APPROVED
RESPIRATOR MUST BE WORN.
THERMAL HAZARDS:
WEAR APPROPRIATE THERMAL PROTECTIVE CLOTHING, WHEN NECESSARY.
GENERAL HYGIENE CONSIDERATIONS:
WHEN USING, DO NOT EAT, DRINK OR SMOKE. WASH HANDS AFTER HANDLING AND
BEFORE EATING.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: OPAQUE.OR TRANSLUCENT.
PHYSICAL STATE: LIQUID.
FORM: LIQUID.
COLOR: GRAY OR CLEAR.
ODOR: SOLVENT.
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
MELTING POINT/FREEZING POINT: NOT AVAILABLE.
INITIAL BOILING POINT AND BOILING RANGE: 151 DEG. F (66.11 DEG. C)
FLASH POINT: 14.0 - 23.0 DEG. F (-10.0 - -5.0 DEG. C)
EVAPORATION RATE: 5.5 - 8
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS:
FLAMMABILITY LIMIT - LOWER (%): NOT AVAILABLE.
FLAMMABILITY LIMIT - UPPER (%): NOT AVAILABLE.
EXPLOSIVE LIMIT - LOWER (%): NOT AVAILABLE.
EXPLOSIVE LIMIT - UPPER (%): NOT AVAILABLE.
VAPOR PRESSURE: 145 MM Hg @ 20 C
VAPOR DENSITY: 2.5
RELATIVE DENSITY: 0.88 - 0.92
SOLUBILITY(IES):
SOLUBILITY (WATER): NEGLIGIBLE
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
VISCOSITY: 1200 - 2500 CP
OTHER INFORMATION:
BULK DENSITY: 7.5 LB/GAL
VOC (WEIGHT %): SEE CAN LABEL
| 10. STABILITY AND REACTIVITY | |
REACTIVITY:
THE PRODUCT IS STABLE AND NON-REACTIVE UNDER NORMAL CONDITIONS OF USE,
STORAGE AND TRANSPORT.
CHEMICAL STABILITY: MATERIAL IS STABLE UNDER NORMAL CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS:
NO DANGEROUS REACTION KNOWN UNDER CONDITIONS OF NORMAL USE.
CONDITIONS TO AVOID:
AVOID HEAT, SPARKS, OPEN FLAMES AND OTHER IGNITION SOURCES. AVOID
TEMPERATURES EXCEEDING THE FLASH POINT. CONTACT WITH INCOMPATIBLE
MATERIALS.
INCOMPATIBLE MATERIALS:
ACIDS. STRONG OXIDIZING AGENTS. AMMONIA. AMINES. ISOCYANATES. CAUSTICS.
HAZARDOUS DECOMPOSITION PRODUCTS:
NO HAZARDOUS DECOMPOSITION PRODUCTS ARE KNOWN.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INHALATION:
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. VAPORS HAVE A NARCOTIC
EFFECT AND MAY CAUSE HEADACHE, FATIGUE, DIZZINESS AND NAUSEA. PROLONGED
INHALATION MAY BE HARMFUL. MAY CAUSE IRRITATION TO THE RESPIRATORY SYSTEM.
SKIN CONTACT: CAUSES SKIN IRRITATION.
EYE CONTACT: CAUSES SERIOUS EYE IRRITATION.
INGESTION:
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. HARMFUL IF SWALLOWED.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
SYMPTOMS MAY INCLUDE STINGING, TEARING, REDNESS, SWELLING, AND BLURRED
VISION. SKIN IRRITATION. MAY CAUSE REDNESS AND PAIN. SYMPTOMS OF
OVEREXPOSURE MAY BE HEADACHE, DIZZINESS, TIREDNESS, NAUSEA AND VOMITING.
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY:
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS. NARCOTIC EFFECTS. MAY CAUSE
RESPIRATORY IRRITATION.
COMPONENTS SPECIES TEST RESULTS
CYCLOHEXANONE (CAS 108-94-1):
ACUTE:
DERMAL:
LD50 RABBIT 948 MG/KG
INHALATION:
LC50 RAT 8000 PPM, 4 HOURS
ORAL:
LD50 RAT 1540 MG/KG
* ESTIMATES FOR PRODUCT MAY BE BASED ON ADDITIONAL COMPONENT DATA NOT
SHOWN.
SKIN CORROSION/IRRITATION: CAUSES SKIN IRRITATION.
SERIOUS EYE DAMAGE/EYE IRRITATION: CAUSES SERIOUS EYE IRRITATION.
RESPIRATORY OR SKIN SENSITIZATION:
RESPIRATORY SENSITIZATION: NOT AVAILABLE.
SKIN SENSITIZATION:
THIS PRODUCT IS NOT EXPECTED TO CAUSE SKIN SENSITIZATION.
GERM CELL MUTAGENICITY:
NO DATA AVAILABLE TO INDICATE PRODUCT OR ANY COMPONENTS PRESENT AT GREATER
THAN 0.1% ARE MUTAGENIC OR GENOTOXIC.
CARCINOGENICITY:
SUSPECTED OF CAUSING CANCER. IN 2012 USEPA INTEGRATED RISK INFORMATION
SYSTEM (IRIS) REVIEWED A TWO SPECIES INHALATION LIFETIME STUDY ON THF
CONDUCTED BY NTP (1998). MALE RATS DEVELOPED RENAL TUMORS AND FEMALE MICE
DEVELOPED LIVER TUMORS WHILE NEITHER THE FEMALE RATS NOR THE MALE MICE
SHOWED SIMILAR RESULTS. BECAUSE THE CARCINOGENIC MECHANISMS COULD NOT BE
IDENTIFIED CLEARLY IN EITHER SPECIES FOR EITHER TUMOR, THE EPA DETERMINED
THAT THE MALE RAT AND FEMALE MOUSE FINDINGS ARE RELEVANT TO THE ASSESSMENT
OF CARCINOGENIC POTENTIAL IN HUMANS. THEREFORE, THE IRIS REVIEW CONCLUDES
THAT THESE DATA IN AGGREGATE INDICATE THAT THERE IS "SUGGESTIVE EVIDENCE
OF CARCINOGENIC POTENTIAL" FOLLOWING EXPOSURE TO THF BY ALL ROUTES OF
EXPOSURE. THIS PRODUCT CONTAINS POLYVINYL CHLORIDE (PVC) THAT IS NOT A
FABRICATED PRODUCT, AND IS THEREFORE, DEFINED AND REGULATED AS A TOXIC
AND HAZARDOUS SUBSTANCE UNDER 29 C.F.R. SUBSECTION 1910.1017 DUE TO THE
PRESUMED PRESENCE OF RESIDUAL VINYL CHLORIDE MONOMER. THE CONCENTRATIONS
OF RESIDUAL VINYL CHLORIDE CALCULATED TO BE CONTAINED IN THIS PRODUCT ARE
WELL BELOW THE THRESHOLD FOR CLASSIFICATION IN ACCORDANCE WITH 29 C.F.R.
SUBSECTION 1910.1200.
IARC MONOGRAPHS. OVERALL EVALUATION OF CARCINOGENICITY:
COLLOIDAL SILICON DIOXIDE (CAS 112945-52-5) 3 NOT CLASSIFIABLE AS TO
CARCINOGENICITY TO HUMANS.
CYCLOHEXANONE (CAS 108-94-1) 3 NOT CLASSIFIABLE AS TO
CARCINOGENICITY TO HUMANS.
POLYVINYL CHLORIDE (CAS 9002-86-2) 3 NOT CLASSIFIABLE AS TO
CARCINOGENICITY TO HUMANS.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1050):
POLYVINYL CHLORIDE (CAS 9002-86-2) CANCER
REPRODUCTIVE TOXICITY:
THIS PRODUCT IS NOT EXPECTED TO CAUSE REPRODUCTIVE OR DEVELOPMENTAL
EFFECTS.
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE:
RESPIRATORY TRACT IRRITATION. NARCOTIC EFFECTS.
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE: NOT CLASSIFIED.
ASPIRATION HAZARD: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
CHRONIC EFFECTS: PROLONGED INHALATION MAY BE HARMFUL.
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY:
THE PRODUCT IS NOT CLASSIFIED AS ENVIRONMENTALLY HAZARDOUS. HOWEVER, THIS
DOES NOT EXCLUDE THE POSSIBILITY THAT LARGE OR FREQUENT SPILLS CAN HAVE A
HARMFUL OR DAMAGING EFFECT ON THE ENVIRONMENT.
COMPONENTS SPECIES TEST RESULTS
CYCLOHEXANONE (CAS 108-94-1):
AQUATIC:
FISH LC50 FATHEAD MINNOW 481 - 578 MG/L, 96 HOURS
(PIMEPHALES PROMELAS)
* ESTIMATES FOR PRODUCT MAY BE BASED ON ADDITIONAL COMPONENT DATA NOT
SHOWN.
PERSISTENCE AND DEGRADABILITY:
NO DATA IS AVAILABLE ON THE DEGRADABILITY OF THIS PRODUCT.
BIOACCUMULATIVE POTENTIAL: NO DATA AVAILABLE.
PARTITION COEFFICIENT N-OCTANOL / WATER (LOG KOW):
2-PROPANONE (CAS 67-64-1) -0.24
CYCLOHEXANONE (CAS 108-94-1) 0.81
FURAN, TETRAHYDRO- (CAS 109-99-9) 0.46
METHYL ETHYL KETONE (CAS 78-93-3) 0.29
MOBILITY IN SOIL: NO DATA AVAILABLE.
OTHER ADVERSE EFFECTS:
NO OTHER ADVERSE ENVIRONMENTAL EFFECTS (E.G. OZONE DEPLETION,
PHOTOCHEMICAL OZONE CREATION POTENTIAL, ENDOCRINE DISRUPTION,
GLOBAL WARMING POTENTIAL) ARE EXPECTED FROM THIS COMPONENT.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL INSTRUCTIONS:
COLLECT AND RECLAIM OR DISPOSE IN SEALED CONTAINERS AT LICENSED WASTE
DISPOSAL SITE. THIS MATERIAL AND ITS CONTAINER MUST BE DISPOSED OF AS
HAZARDOUS WASTE. DO NOT ALLOW THIS MATERIAL TO DRAIN INTO SEWERS/WATER
SUPPLIES. DO NOT CONTAMINATE PONDS, WATERWAYS OR DITCHES WITH CHEMICAL
OR USED CONTAINER. DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
LOCAL DISPOSAL REGULATIONS:
DISPOSE IN ACCORDANCE WITH ALL APPLICABLE REGULATIONS.
HAZARDOUS WASTE CODE:
THE WASTE CODE SHOULD BE ASSIGNED IN DISCUSSION BETWEEN THE USER, THE
PRODUCER AND THE WASTE DISPOSAL COMPANY.
WASTE FROM RESIDUES / UNUSED PRODUCTS:
DISPOSE OF IN ACCORDANCE WITH LOCAL REGULATIONS. EMPTY CONTAINERS OR
LINERS MAY RETAIN SOME PRODUCT RESIDUES. THIS MATERIAL AND ITS CONTAINER
MUST BE DISPOSED OF IN A SAFE MANNER (SEE: DISPOSAL INSTRUCTIONS).
CONTAMINATED PACKAGING:
EMPTY CONTAINERS SHOULD BE TAKEN TO AN APPROVED WASTE HANDLING SITE FOR
RECYCLING OR DISPOSAL. SINCE EMPTIED CONTAINERS MAY RETAIN PRODUCT RESIDUE,
FOLLOW LABEL WARNINGS EVEN AFTER CONTAINER IS EMPTIED.
| 14. TRANSPORT INFORMATION | |
DOT:
UN NUMBER: UN1133
UN PROPER SHIPPING NAME: ADHESIVES
TRANSPORT HAZARD CLASS(ES):
CLASS: 3
SUBSIDIARY RISK:
LABEL(S): 3
PACKING GROUP: II
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
SPECIAL PROVISIONS: T11, TP1, TP8, TP27
PACKAGING EXCEPTIONS: 150
PACKAGING NON BULK: 201
PACKAGING BULK: 243
IATA:
UN NUMBER: UN1133
UN PROPER SHIPPING NAME: ADHESIVES
TRANSPORT HAZARD CLASS(ES):
CLASS: 3
SUBSIDIARY RISK:
PACKING GROUP: II
ENVIRONMENTAL HAZARDS: NO.
ERG CODE: 3L
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
IMDG:
UN NUMBER: UN1133
UN PROPER SHIPPING NAME: ADHESIVES
TRANSPORT HAZARD CLASS(ES):
CLASS: 3
SUBSIDIARY RISK:
PACKING GROUP: II
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: NO.
EMS: F-E, S-D
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
TRANSPORT IN BULK ACCORDING TO ANNEX II OF MARPOL 73/78 AND THE IBC CODE:
NOT AVAILABLE.
| 15. REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
ALL COMPONENTS ARE ON THE U.S. EPA TSCA INVENTORY LIST.
TSCA SECTION 12(B) EXPORT NOTIFICATION (40 CFR 707, SUBPT. D):
NOT REGULATED.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1050):
POLYVINYL CHLORIDE (CAS 9002-86-2):
CANCER
CENTRAL NERVOUS SYSTEM
LIVER
BLOOD
FLAMMABILITY
CERCLA HAZARDOUS SUBSTANCE LIST (40 CFR 302.4):
2-PROPANONE (CAS 67-64-1) LISTED
CYCLOHEXANONE (CAS 108-94-1) LISTED
FURAN, TETRAHYDRO- (CAS 109-99-9) LISTED
METHYL ETHYL KETONE (CAS 78-93-3) LISTED
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA):
HAZARD CATEGORIES:
IMMEDIATE HAZARD: YES
DELAYED HAZARD: NO
FIRE HAZARD: YES
PRESSURE HAZARD: NO
REACTIVITY HAZARD: NO
SARA 302 EXTREMELY HAZARDOUS SUBSTANCE: NOT LISTED.
SARA 311/312 HAZARDOUS CHEMICAL: NO
SARA 313 (TRI REPORTING): NOT REGULATED.
OTHER FEDERAL REGULATIONS:
CLEAN AIR ACT (CAA) SECTION 112 HAZARDOUS AIR POLLUTANTS (HAPS) LIST:
NOT REGULATED.
CLEAN AIR ACT (CAA) SECTION 112(R) ACCIDENTAL RELEASE PREVENTION
(40 CFR 68.130): NOT REGULATED.
SAFE DRINKING WATER ACT (SDWA): NOT REGULATED.
DRUG ENFORCEMENT ADMINISTRATION (DEA). LIST 2, ESSENTIAL CHEMICALS
(21 CFR 1310.02(B) AND 1310.04(F)(2) AND CHEMICAL CODE NUMBER:
2-PROPANONE (CAS 67-64-1) 6532
METHYL ETHYL KETONE (CAS 78-93-3) 6714
DRUG ENFORCEMENT ADMINISTRATION (DEA). LIST 1 & 2 EXEMPT CHEMICAL MIXTURES
(21 CFR 1310.12(C)):
2-PROPANONE (CAS 67-64-1) 35 %WV
METHYL ETHYL KETONE (CAS 78-93-3) 35 %WV
DEA EXEMPT CHEMICAL MIXTURES CODE NUMBER:
2-PROPANONE (CAS 67-64-1) 6532
METHYL ETHYL KETONE (CAS 78-93-3) 6714
US STATE REGULATIONS:
US. MASSACHUSETTS RTK - SUBSTANCE LIST:
2-PROPANONE (CAS 67-64-1)
COLLOIDAL SILICON DIOXIDE (CAS 112945-52-5)
CYCLOHEXANONE (CAS 108-94-1)
FURAN, TETRAHYDRO- (CAS 109-99-9)
METHYL ETHYL KETONE (CAS 78-93-3)
US. NEW JERSEY WORKER AND COMMUNITY RIGHT-TO-KNOW ACT:
2-PROPANONE (CAS 67-64-1)
CYCLOHEXANONE (CAS 108-94-1)
FURAN, TETRAHYDRO- (CAS 109-99-9)
METHYL ETHYL KETONE (CAS 78-93-3)
POLYVINYL CHLORIDE (CAS 9002-86-2)
US. PENNSYLVANIA WORKER AND COMMUNITY RIGHT-TO-KNOW LAW:
2-PROPANONE (CAS 67-64-1)
COLLOIDAL SILICON DIOXIDE (CAS 112945-52-5)
CYCLOHEXANONE (CAS 108-94-1)
FURAN, TETRAHYDRO- (CAS 109-99-9)
METHYL ETHYL KETONE (CAS 78-93-3)
US. RHODE ISLAND RTK:
2-PROPANONE (CAS 67-64-1)
CYCLOHEXANONE (CAS 108-94-1)
FURAN, TETRAHYDRO- (CAS 109-99-9)
METHYL ETHYL KETONE (CAS 78-93-3)
US. CALIFORNIA PROPOSITION 65:
WARNING:
THIS PRODUCT CAN EXPOSE YOU TO CHEMICALS INCLUDING TETRAHYDROFURAN, WHICH
IS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER. FOR MORE INFORMATION
GO TO WWW.P65WARNINGS.CA.GOV.
SEE SECTION 11 FOR ADDITIONAL INFORMATION.
INTERNATIONAL INVENTORIES:
COUNTRY(S) OR REGION INVENTORY NAME ON INVENTORY (YES/NO)*
AUSTRALIA AUSTRALIAN INVENTORY OF YES
CHEMICAL SUBSTANCES
(AICS)
CANADA DOMESTIC SUBSTANCES YES
LIST (DSL)
CANADA NON-DOMESTIC SUBSTANCES NO
LIST (NDSL)
CHINA INVENTORY OF EXISTING YES
CHEMICAL SUBSTANCES IN
CHINA (IECSC)
EUROPE EUROPEAN INVENTORY OF NO
EXISTING COMMERCIAL
CHEMICAL SUBSTANCES
(EINECS)
EUROPE EUROPEAN LIST OF NO
NOTIFIED CHEMICAL
SUBSTANCES (ELINCS)
JAPAN INVENTORY OF EXISTING AND YES
NEW CHEMICAL SUBSTANCES
(ENCS)
KOREA EXISTING CHEMICALS LIST YES
(ECL)
NEW ZEALAND NEW ZEALAND INVENTORY YES
PHILIPPINES PHILIPPINE INVENTORY OF YES
CHEMICALS AND CHEMICAL
SUBSTANCES (PICCS)
UNITED STATES & TOXIC SUBSTANCES CONTROL YES
PUERTO RICO ACT (TSCA) INVENTORY
*A "YES" INDICATES THIS PRODUCT COMPLIES WITH THE INVENTORY REQUIREMENTS
ADMINISTERED BY THE GOVERNING COUNTRY(S).
A "NO" INDICATES THAT ONE OR MORE COMPONENTS OF THE PRODUCT ARE NOT LISTED
OR EXEMPT FROM LISTING ON THE INVENTORY ADMINISTERED BY THE GOVERNING
COUNTRY(S).
| 16. OTHER INFORMATION, INCLUDING DATE OF PREPARATION | |
OR LAST REVISION
ISSUE DATE: 04-AUGUST-2014
REVISION DATE: 07-01-2022
VERSION #: 03
HMIS(R*) RATINGS:
HEALTH 2
FLAMMABILITY 3
PHYSICAL HAZARD 0
DISCLAIMER:
THE INFORMATION IN THE SHEET WAS WRITTEN BASED ON THE BEST KNOWLEDGE AND
EXPERIENCE CURRENTLY AVAILABLE.
920700
SDS US