| Common Name: | MARINE STRIP |
| Manufacturer: | DUMOND CHEMICALS |
| SDS Revision Date: | 3/3/2018 |
| SDS Format: | GHS-US |
| Item Number(s): | 39C320, 39C321 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
DUMOND(TM)
SAFETY DATA SHEET
ISSUE DATE: 01-JAN-2008
REVISION DATE: 3-MAR-2018
VERSION: 1
| 1. PRODUCT AND COMPANY IDENTIFICATION |  |
PRODUCT IDENTIFIER:
PRODUCT NAME: MARINE STRIP
OTHER MEANS OF IDENTIFICATION:
SDS #: DCI-071
UN/ID NO: UN1823
RECOMMENDED USE OF THE CHEMICAL AND RESTRICTIONS ON USE:
RECOMMENDED USE: PAINT REMOVER.
DETAILS OF THE SUPPLIER OF THE SAFETY DATA SHEET:
SUPPLIER ADDRESS:
DUMOND CHEMICALS, INC.
1475 PHOENIXVILLE RD. SUITE 18
WEST CHESTER, PA 19380
EMERGENCY TELEPHONE NUMBER:
COMPANY PHONE NUMBER: 1-609-655-7700
EMERGENCY TELEPHONE:
INFOTRAC:
1-352-323-3500 (INTERNATIONAL)
1-800-535-5053 (NORTH AMERICA)
| 2. HAZARDS IDENTIFICATION | |
CLASSIFICATION:
SKIN CORROSION/IRRITATION: CATEGORY 1 SUB-CATEGORY B
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 1
SPECIFIC TARGET ORGAN TOXICITY (SINGLE EXPOSURE): CATEGORY 3
SIGNAL WORD: DANGER
HAZARD STATEMENTS:
CAUSES SEVERE SKIN BURNS AND EYE DAMAGE
MAY CAUSE RESPIRATORY IRRITATION. MAY CAUSE DROWSINESS OR DIZZINESS
EXCLAMATION MARK
CORROSION
APPEARANCE: WHITE PASTE
PHYSICAL STATE: PASTE
ODOR: NONE
PRECAUTIONARY STATEMENTS - PREVENTION:
DO NOT BREATHE DUST/FUME/GAS/MIST/VAPORS/SPRAY
WASH FACE, HANDS AND ANY EXPOSED SKIN THOROUGHLY AFTER HANDLING
WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION
USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA
PRECAUTIONARY STATEMENTS - RESPONSE:
IMMEDIATELY CALL A POISON CENTER OR DOCTOR/PHYSICIAN
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES,
IF PRESENT AND EASY TO DO. CONTINUE RINSING
IMMEDIATELY CALL A POISON CENTER OR DOCTOR/PHYSICIAN
IF ON SKIN (OR HAIR):
REMOVE/TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. RINSE SKIN WITH
WATER/SHOWER
WASH CONTAMINATED CLOTHING BEFORE REUSE
IF INHALED:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING
IMMEDIATELY CALL A POISON CENTER OR DOCTOR/PHYSICIAN
CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL
IF SWALLOWED: RINSE MOUTH. DO NOT INDUCE VOMITING
PRECAUTIONARY STATEMENTS - STORAGE:
STORE LOCKED UP
STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED
PRECAUTIONARY STATEMENTS - DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER TO AN APPROVED WASTE DISPOSAL PLANT
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
CHEMICAL FAMILY: ALKALINE.
CHEMICAL NAME CAS NO WEIGHT-%
CALCIUM HYDROXIDE 1305-62-0 21
MAGNESIUM HYDROXIDE 1309-42-8 16
SODIUM HYDROXIDE 1310-73-2 9
| 4. FIRST AID MEASURES | |
FIRST AID MEASURES:
INHALATION: REMOVE TO FRESH AIR. IMMEDIATE MEDICAL ATTENTION IS REQUIRED.
EYE CONTACT:
IMMEDIATELY FLUSH WITH PLENTY OF WATER. AFTER INITIAL FLUSHING, REMOVE ANY
CONTACT LENSES AND CONTINUE FLUSHING FOR AT LEAST 15 MINUTES. CALL A
PHYSICIAN IMMEDIATELY.
INGESTION:
IF CONSCIOUS, GIVE WATER OR MILK. DO NOT INDUCE VOMITING. GET MEDICAL
ATTENTION IF NECESSARY.
SKIN CONTACT:
WASH OFF IMMEDIATELY WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES. REMOVE
CONTAMINATED CLOTHING AND SHOES. GET MEDICAL ATTENTION IF IRRITATION
OCCURS.
MOST IMPORTANT SYMPTOMS AND EFFECTS, BOTH ACUTE AND DELAYED:
SYMPTOMS:
MAY CAUSE DERMATITIS OR IRRITATION IN SOME INDIVIDUALS UPON PROLONGED
CONTACT. MAY CAUSE SEVERE CHEMICAL BURNS WITH REDDENING AND PAIN. CAUSES
EYE IRRITATION. CAUSES SKIN IRRITATION. MAY CAUSE IRRITATION TO THE MUCOUS
MEMBRANES AND UPPER RESPIRATORY TRACT. INGESTION MAY CAUSE SEVERE BURNS TO
MOUTH, THROAT OR STOMACH.
INDICATION OF ANY IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
NOTE TO PHYSICIANS:
TREAT SYMPTOMATICALLY. INDIVIDUALS WITH CHRONIC RESPIRATORY OR SKIN
DISEASES MAY BE AT RISK FROM EXPOSURE.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
USE EXTINGUISHING MEASURES THAT ARE APPROPRIATE TO LOCAL CIRCUMSTANCES AND
THE SURROUNDING ENVIRONMENT.
UNSUITABLE EXTINGUISHING MEDIA: NOT DETERMINED.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
AT ELEVATED TEMPERATURES, CONTAINERS MAY RUPTURE. CONTENTS ARE CORROSIVE
AND ALL PERSONAL CONTACT MUST BE AVOIDED.
PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
AS IN ANY FIRE, WEAR SELF-CONTAINED BREATHING APPARATUS PRESSURE-DEMAND,
MSHA/NIOSH (APPROVED OR EQUIVALENT) AND FULL PROTECTIVE GEAR. COOL
CONTAINERS WITH FLOODING QUANTITIES OF WATER UNTIL WELL AFTER FIRE IS OUT.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
PERSONAL PRECAUTIONS: USE PERSONAL PROTECTIVE EQUIPMENT AS REQUIRED.
ENVIRONMENTAL PRECAUTIONS:
DO NOT ALLOW INTO ANY SEWER, ON THE GROUND OR INTO ANY BODY OF WATER.
METHODS AND MATERIAL FOR CONTAINMENT AND CLEANING UP:
METHODS FOR CONTAINMENT:
PREVENT FURTHER LEAKAGE OR SPILLAGE IF SAFE TO DO SO.
METHODS FOR CLEANING UP:
KEEP IN SUITABLE, CLOSED CONTAINERS FOR DISPOSAL. WASH SPILL AREA WITH
PLENTY OF WATER. SPILLS AND RELEASES MAY HAVE TO BE REPORTED TO FEDERAL
AND/OR LOCAL AUTHORITIES. SEE SECTION 15.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
ADVICE ON SAFE HANDLING:
HANDLE IN ACCORDANCE WITH GOOD INDUSTRIAL HYGIENE AND SAFETY PRACTICE.
WASH FACE, HANDS, AND ANY EXPOSED SKIN THOROUGHLY AFTER HANDLING. DO NOT
BREATHE DUST/FUME/GAS/MIST/VAPORS/SPRAY. USE ONLY IN WELL-VENTILATED AREAS.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
STORAGE CONDITIONS:
STORE IN A COOL, WELL VENTILATED AREA AWAY FROM ACIDS AND OTHER
INCOMPATIBLE SUBSTANCES. STORE LOCKED UP.
INCOMPATIBLE MATERIALS:
ACIDS. ORGANIC HALOGEN COMPOUNDS. NITROMETHANE. FLAMMABLE LIQUID. METALS
SUCH AS ALUMINUM, TIN, AND ZINC.
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
EXPOSURE GUIDELINES:
CHEMICAL NAME ACGIH TLV OSHA PEL NIOSH IDLH
CALCIUM HYDROXIDE TWA: 5 MG/M3 TWA: 15 MG/M3 TOTAL TWA: 5 MG/M3
1305-62-0 DUST TWA: 5 MG/M3
RESPIRABLE
FRACTION (VACATED)
TWA: 5 MG/M3 NOT
IN EFFECT AS A
RESULT OF
RECONSIDERATION
SODIUM HYDROXIDE CEILING: TWA: 2 MG/M3 IDLH: 10 MG/M3
1310-73-2 2 MG/M3 (VACATED) CEILING: CEILING:
2 MG/M3 2 MG/M3
APPROPRIATE ENGINEERING CONTROLS:
ENGINEERING CONTROLS:
APPLY TECHNICAL MEASURES TO COMPLY WITH THE OCCUPATIONAL EXPOSURE LIMITS.
USE IN A WELL-VENTILATED LOCATION (EG. LOCAL EXHAUST VENTILATION, FANS).
SHOWERS. EYEWASH STATIONS.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION: CHEMICAL SAFETY GOGGLES/FACESHIELD.
SKIN AND BODY PROTECTION:
WEAR SUITABLE PROTECTIVE CLOTHING. RUBBER, NEOPRENE, OR OTHER IMPERVIOUS
GLOVES ARE RECOMMENDED TO PREVENT SKIN CONTACT. SELECTION OF SPECIFIC
ITEMS SUCH AS FACE SHIELD, BOOTS, APRON, OR FULL BODY SUIT WILL DEPEND
ON THE TASK.
RESPIRATORY PROTECTION:
ENSURE ADEQUATE VENTILATION, ESPECIALLY IN CONFINED AREAS. FOR SPRAY
APPLICATION, A NIOSH APPROVED DUST RESPIRATOR AND EYE PROTECTION.
GENERAL HYGIENE CONSIDERATIONS:
HANDLE IN ACCORDANCE WITH GOOD INDUSTRIAL HYGIENE AND SAFETY PRACTICE.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
INFORMATION ON BASIC PHYSICAL AND CHEMICAL PROPERTIES:
PHYSICAL STATE: PASTE
APPEARANCE: WHITE PASTE
ODOR: NONE
COLOR: WHITE
ODOR THRESHOLD: NOT DETERMINED
PROPERTY VALUES REMARKS - METHOD
PH 12
MELTING POINT/FREEZING POINT NOT DETERMINED
BOILING POINT/BOILING RANGE >100 DEG. C /
>212 DEG. F
FLASH POINT NONE
EVAPORATION RATE SAME AS WATER
FLAMMABILITY (SOLID, GAS) NOT DETERMINED
FLAMMABILITY LIMITS IN AIR:
UPPER FLAMMABILITY LIMITS NOT APPLICABLE
LOWER FLAMMABILITY LIMIT NOT APPLICABLE
VAPOR PRESSURE SAME AS WATER @ 20 C
VAPOR DENSITY SAME AS WATER
SPECIFIC GRAVITY 1.33
WATER SOLUBILITY COMPLETELY SOLUBLE
SOLUBILITY IN OTHER SOLVENTS NOT DETERMINED
PARTITION COEFFICIENT NOT DETERMINED
AUTOIGNITION TEMPERATURE NONE
DECOMPOSITION TEMPERATURE NOT DETERMINED
KINEMATIC VISCOSITY NOT DETERMINED
DYNAMIC VISCOSITY NOT DETERMINED
EXPLOSIVE PROPERTIES NOT DETERMINED
OXIDIZING PROPERTIES NOT DETERMINED
OTHER INFORMATION:
VOC CONTENT (%) 0%
VOC CONTENT 0 LBS/GAL
| 10. STABILITY AND REACTIVITY | |
REACTIVITY: NOT REACTIVE UNDER NORMAL CONDITIONS
CHEMICAL STABILITY: STABLE UNDER RECOMMENDED STORAGE CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS: NONE UNDER NORMAL PROCESSING.
CONDITIONS TO AVOID: KEEP OUT OF REACH OF CHILDREN.
INCOMPATIBLE MATERIALS:
ACIDS. ORGANIC HALOGEN COMPOUNDS. NITROMETHANE. FLAMMABLE LIQUID.
METALS SUCH AS ALUMINUM, TIN, AND ZINC.
HAZARDOUS DECOMPOSITION PRODUCTS: NONE KNOWN BASED ON INFORMATION SUPPLIED.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
PRODUCT INFORMATION:
INHALATION: AVOID BREATHING VAPORS OR MISTS.
EYE CONTACT: CAUSES SEVERE EYE DAMAGE.
SKIN CONTACT: CAUSES SEVERE SKIN BURNS.
INGESTION: DO NOT TASTE OR SWALLOW.
COMPONENT INFORMATION:
CHEMICAL NAME ORAL LD50 DERMAL LD50 INHALATION
LC50
WATER >90 ML/KG (RAT)
7732-18-5
CALCIUM HYDROXIDE =7340 MG/KG (RAT)
1305-62-0
MAGNESIUM HYDROXIDE =8500 MG/KG (RAT)
1309-42-8
SODIUM HYDROXIDE =1350 MG/KG (RABBIT)
1310-73-2
INFORMATION ON PHYSICAL, CHEMICAL AND TOXICOLOGICAL EFFECTS:
SYMPTOMS:
MAY CAUSE DERMATITIS OR IRRITATION IN SOME INDIVIDUALS UPON PROLONGED
CONTACT. MAY CAUSE SEVERE CHEMICAL BURNS WITH REDDENING AND PAIN. MAY
CAUSE SKIN AND EYE IRRITATION. MAY CAUSE IRRITATION TO THE MUCOUS
MEMBRANES AND UPPER RESPIRATORY TRACT. MAY CAUSE BURNS TO MOUTH AND
GASTROINTESTINAL CORROSION.
DELAYED AND IMMEDIATE EFFECTS AS WELL AS CHRONIC EFFECTS FROM SHORT
AND LONG-TERM EXPOSURE:
CARCINOGENICITY:
THIS PRODUCT DOES NOT CONTAIN ANY CARCINOGENS OR POTENTIAL CARCINOGENS
AS LISTED BY OSHA, IARC OR NTP.
STOT - SINGLE EXPOSURE:
MAY CAUSE RESPIRATORY IRRITATION. MAY CAUSE DROWSINESS OR DIZZINESS.
NUMERICAL MEASURES OF TOXICITY- PRODUCT: NOT DETERMINED
THE FOLLOWING VALUES ARE CALCULATED BASED ON CHAPTER 3.1 OF THE GHS
DOCUMENT:
ATEMIX (ORAL): 21097 MG/KG
ATEMIX (DERMAL): 9445 MG/KG
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY:
AN ENVIRONMENTAL HAZARD CANNOT BE EXCLUDED IN THE EVENT OF UNPROFESSIONAL
HANDLING OR DISPOSAL
CHEMICAL NAME ALGAE/ FISH TOXICITY TO CRUSTACEA
AQUATIC MICROORGANISMS
PLANTS
CALCIUM HYDROXIDE 160: 96 H
1305-62-0 GAMBUSIA AFFINIS
MG/L LC50 STATIC
SODIUM HYDROXIDE 45.4: 96 H
1310-73-2 ONCORHYNCHUS
MYKISS MG/L LC50
STATIC
PERSISTENCE AND DEGRADABILITY: NOT DETERMINED.
BIOACCUMULATION: NOT DETERMINED.
MOBILITY: NOT DETERMINED.
OTHER ADVERSE EFFECTS: NOT DETERMINED
| 13. DISPOSAL CONSIDERATIONS | |
WASTE TREATMENT METHODS:
DISPOSAL OF WASTES:
DISPOSAL SHOULD BE IN ACCORDANCE WITH APPLICABLE REGIONAL, NATIONAL AND
LOCAL LAWS AND REGULATIONS.
CONTAMINATED PACKAGING:
DISPOSAL SHOULD BE IN ACCORDANCE WITH APPLICABLE REGIONAL, NATIONAL AND
LOCAL LAWS AND REGULATIONS.
CHEMICAL NAME CALIFORNIA HAZARDOUS WASTE STATUS
CALCIUM HYDROXIDE CORROSIVE
1305-62-0
SODIUM HYDROXIDE TOXIC
1310-73-2 CORROSIVE
| 14. TRANSPORT INFORMATION | |
NOTE:
BASED ON PACKAGE SIZE, PRODUCT MAY BE ELIGIBLE FOR LIMITED QUANTITY
EXCEPTION
DOT:
UN/ID NO: UN1823
PROPER SHIPPING NAME: SODIUM HYDROXIDE, SOLID, MIXTURE
HAZARD CLASS: 8
PACKING GROUP: II
IATA:
UN/ID NO: UN1823
PROPER SHIPPING NAME: SODIUM HYDROXIDE, SOLID, MIXTURE
HAZARD CLASS: 8
PACKING GROUP: II
IMDG:
UN/ID NO: UN1823
PROPER SHIPPING NAME: SODIUM HYDROXIDE, SOLID, MIXTURE
HAZARD CLASS: 8
PACKING GROUP: II
| 15. REGULATORY INFORMATION | |
INTERNATIONAL INVENTORIES:
LEGEND:
TSCA: UNITED STATES TOXIC SUBSTANCES CONTROL ACT SECTION 8(B) INVENTORY
DSL/NDSL: CANADIAN DOMESTIC SUBSTANCES LIST/NON-DOMESTIC SUBSTANCES LIST
EINECS/ELINCS:
EUROPEAN INVENTORY OF EXISTING CHEMICAL SUBSTANCES/EUROPEAN LIST OF
NOTIFIED CHEMICAL SUBSTANCES
ENCS: JAPAN EXISTING AND NEW CHEMICAL SUBSTANCES
IECSC: CHINA INVENTORY OF EXISTING CHEMICAL SUBSTANCES
KECL: KOREAN EXISTING AND EVALUATED CHEMICAL SUBSTANCES
PICCS: PHILIPPINES INVENTORY OF CHEMICALS AND CHEMICAL SUBSTANCES
US FEDERAL REGULATIONS:
SARA 311/312 HAZARD CATEGORIES:
CHEMICAL NAME CWA - CWA - CWA - CWA -
REPORTABLE TOXIC PRIORITY HAZARDOUS
QUANTITIES POLLUTANTS POLLUTANTS SUBSTANCES
SODIUM HYDROXIDE 1000 LB X
1310-73-2
CHEMICAL NAME HAZARDOUS CERCLA/SARA RQ REPORTABLE QUANTITY (RQ)
SUBSTANCES
RQS
SODIUM HYDROXIDE 1000 LB RQ 1000 LB FINAL RQ
1310-73-2 RQ 454 KG FINAL RQ
US STATE REGULATIONS:
U.S. STATE RIGHT-TO-KNOW REGULATIONS:
CHEMICAL NAME NEW JERSEY MASSACHUSETTS PENNSYLVANIA
CALCIUM HYDROXIDE X X X
1305-62-0
SODIUM HYDROXIDE X X X
1310-73-2
U.S. EPA LABEL INFORMATION:
| 16. OTHER INFORMATION | |
NFPA:
HEALTH HAZARDS NOT DETERMINED
FLAMMABILITY NOT DETERMINED
INSTABILITY NOT DETERMINED
SPECIAL HAZARDS NOT DETERMINED
HMIS:
HEALTH HAZARDS 3
FLAMMABILITY 0
PHYSICAL HAZARDS 0
PERSONAL PROTECTION NOT DETERMINED
ISSUE DATE: 01-JAN-2008
REVISION DATE: 3-MAR-2018
REVISION NOTE: NEW FORMAT
DISCLAIMER:
THE INFORMATION PROVIDED IN THIS SAFETY DATA SHEET IS CORRECT TO THE BEST
OF OUR KNOWLEDGE, INFORMATION AND BELIEF AT THE DATE OF ITS PUBLICATION.
THE INFORMATION GIVEN IS DESIGNED ONLY AS A GUIDANCE FOR SAFE HANDLING,
USE, PROCESSING, STORAGE, TRANSPORTATION, DISPOSAL AND RELEASE AND IS NOT
TO BE CONSIDERED A WARRANTY OR QUALITY SPECIFICATION. THE INFORMATION
RELATES ONLY TO THE SPECIFIC MATERIAL DESIGNATED AND MAY NOT BE VALID FOR
SUCH MATERIAL USED IN COMBINATION WITH ANY OTHER MATERIALS OR IN ANY
PROCESS, UNLESS SPECIFIED IN THE TEXT.