| Common Name: | BRAKLEEN BRAKE PARTS CLEANER - 55 GAL NO. 05087 (ITEM 1003702) |
| Manufacturer: | CRC INDUSTRIES |
| SDS Revision Date: | 12/20/2021 |
| SDS Format: | No Format Specified |
| Item Number(s): | 3APL5, 802LJ9 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
CRC(R*)
SAFETY DATA SHEET
| 1. IDENTIFICATION |  |
PRODUCT IDENTIFIER: BRAKLEEN(R*) BRAKE PARTS CLEANER - 55 GAL
OTHER MEANS OF IDENTIFICATION:
PRODUCT CODE: NO. 05087 (ITEM# 1003702)
RECOMMENDED USE: BRAKE PARTS CLEANER
RECOMMENDED RESTRICTIONS: NONE KNOWN.
MANUFACTURER/IMPORTER/SUPPLIER/DISTRIBUTOR INFORMATION:
MANUFACTURED OR SOLD BY:
COMPANY NAME: CRC INDUSTRIES, INC.
ADDRESS:
885 LOUIS DR.
WARMINSTER, PA 18974
US
TELEPHONE:
GENERAL INFORMATION: 215-674-4300
TECHNICAL ASSISTANCE: 800-521-3168
CUSTOMER SERVICE: 800-272-4620
24-HOUR EMERGENCY (CHEMTREC): 800-424-9300 (US)
WEBSITE: WWW.CRCINDUSTRIES.COM
| 2. HAZARD(S) IDENTIFICATION | |
PHYSICAL HAZARDS:
FLAMMABLE LIQUIDS: CATEGORY 2
HEALTH HAZARDS:
SKIN CORROSION/IRRITATION: CATEGORY 2
SERIOUS EYE DAMAGE/EYE IRRITATION: CATEGORY 2A
SPECIFIC TARGET ORGAN TOXICITY, SINGLE EXPOSURE:
CATEGORY 3 NARCOTIC EFFECTS
ASPIRATION HAZARD: CATEGORY 1
ENVIRONMENTAL HAZARDS:
HAZARDOUS TO THE AQUATIC ENVIRONMENT, ACUTE HAZARD: CATEGORY 1
HAZARDOUS TO THE AQUATIC ENVIRONMENT, LONG-TERM HAZARD: CATEGORY 1
OSHA DEFINED HAZARDS: NOT CLASSIFIED.
LABEL ELEMENTS:
FLAME
HEALTH HAZARD
EXCLAMATION MARK
SIGNAL WORD: DANGER
HAZARD STATEMENT:
HIGHLY FLAMMABLE LIQUID AND VAPOR. MAY BE FATAL IF SWALLOWED AND ENTERS
AIRWAYS. CAUSES SKIN IRRITATION. CAUSES SERIOUS EYE IRRITATION. MAY CAUSE
DROWSINESS OR DIZZINESS.
PRECAUTIONARY STATEMENT:
PREVENTION:
KEEP AWAY FROM HEAT/SPARKS/OPEN FLAMES/HOT SURFACES. - NO SMOKING. KEEP
CONTAINER TIGHTLY CLOSED. GROUND/BOND CONTAINER AND RECEIVING EQUIPMENT.
USE EXPLOSION-PROOF ELECTRICAL/VENTILATING/LIGHTING EQUIPMENT. USE ONLY
NON-SPARKING TOOLS. TAKE PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGE.
USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA. MAINTAIN VENTILATION DURING
USE AND UNTIL ALL VAPORS ARE GONE. OPEN DOORS AND WINDOWS OR USE OTHER
MEANS TO ENSURE A FRESH AIR SUPPLY DURING USE AND WHILE PRODUCT IS DRYING.
IF YOU EXPERIENCE ANY SYMPTOMS LISTED ON THIS LABEL, INCREASE VENTILATION
OR LEAVE THE AREA. AVOID BREATHING MIST/VAPORS. WASH THOROUGHLY AFTER
HANDLING. WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE
PROTECTION.
RESPONSE:
IF SWALLOWED:
IMMEDIATELY CALL A POISON CENTER/DOCTOR. DO NOT INDUCE VOMITING.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
IF ON SKIN (OR HAIR):
TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. RINSE SKIN WITH
WATER/SHOWER.
IF SKIN IRRITATION OCCURS:
GET MEDICAL ADVICE/ATTENTION. WASH CONTAMINATED CLOTHING BEFORE REUSE.
IF INHALED:
REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING. CALL A
POISON CENTER/DOCTOR IF YOU FEEL UNWELL.
IN CASE OF FIRE: USE APPROPRIATE MEDIA TO EXTINGUISH.
STORAGE:
STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED. KEEP COOL.
STORE LOCKED UP.
DISPOSAL:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
HAZARD(S) NOT OTHERWISE CLASSIFIED (HNOC):
STATIC ACCUMULATING FLAMMABLE LIQUID CAN BECOME ELECTROSTATICALLY CHARGED
EVEN IN BONDED AND GROUNDED EQUIPMENT. SPARKS MAY IGNITE LIQUID AND VAPOR.
MAY CAUSE FLASH FIRE OR EXPLOSION.
SUPPLEMENTAL INFORMATION: NONE.
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
MIXTURES:
CHEMICAL NAME COMMON NAME CAS NUMBER %
AND SYNONYMS
NAPHTHA (PETROLEUM), 64742-49-0 40 - 50
HYDROTREATED LIGHT
N-HEPTANE 142-82-5 20 - 30
HEPTANE, BRANCHED, CYCLIC 426260-76-6 10 - 20
AND LINEAR
ISOPROPYL ALCOHOL 67-63-0 5 - 10
SOLVENT NAPHTHA (PETROLEUM), 64742-89-8 3 - 5
LIGHT ALIPH.
SPECIFIC CHEMICAL IDENTITY AND/OR PERCENTAGE OF COMPOSITION HAS BEEN
WITHHELD AS A TRADE SECRET.
| 4. FIRST-AID MEASURES | |
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
SKIN CONTACT:
TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. RINSE SKIN WITH
WATER/SHOWER.
IF SKIN IRRITATION OCCURS:
GET MEDICAL ADVICE/ATTENTION. WASH CONTAMINATED CLOTHING BEFORE REUSE.
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.
REMOVE CONTACT LENSES, IF PRESENT AND EASY TO DO. CONTINUE RINSING.
GET MEDICAL ATTENTION IF IRRITATION DEVELOPS AND PERSISTS.
INGESTION:
CALL A PHYSICIAN OR POISON CONTROL CENTER IMMEDIATELY. RINSE MOUTH. DO NOT
INDUCE VOMITING. IF VOMITING OCCURS, KEEP HEAD LOW SO THAT STOMACH CONTENT
DOESN'T GET INTO THE LUNGS.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
ASPIRATION MAY CAUSE PULMONARY EDEMA AND PNEUMONITIS. MAY CAUSE DROWSINESS
OR DIZZINESS. HEADACHE. NAUSEA, VOMITING. SEVERE EYE IRRITATION. SYMPTOMS
MAY INCLUDE STINGING, TEARING, REDNESS, SWELLING, AND BLURRED VISION. SKIN
IRRITATION. MAY CAUSE REDNESS AND PAIN.
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
PROVIDE GENERAL SUPPORTIVE MEASURES AND TREAT SYMPTOMATICALLY.
THERMAL BURNS:
FLUSH WITH WATER IMMEDIATELY. WHILE FLUSHING, REMOVE CLOTHES WHICH DO NOT
ADHERE TO AFFECTED AREA. CALL AN AMBULANCE. CONTINUE FLUSHING DURING
TRANSPORT TO HOSPITAL. KEEP VICTIM UNDER OBSERVATION. SYMPTOMS MAY BE
DELAYED.
GENERAL INFORMATION:
TAKE OFF ALL CONTAMINATED CLOTHING IMMEDIATELY. ENSURE THAT MEDICAL
PERSONNEL ARE AWARE OF THE MATERIAL(S) INVOLVED, AND TAKE PRECAUTIONS
TO PROTECT THEMSELVES. WASH CONTAMINATED CLOTHING BEFORE REUSE.
| 5. FIRE-FIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
WATER FOG. FOAM. CARBON DIOXIDE (CO2). DRY CHEMICAL POWDER, CARBON
DIOXIDE, SAND OR EARTH MAY BE USED FOR SMALL FIRES ONLY.
UNSUITABLE EXTINGUISHING MEDIA:
DO NOT USE WATER JET AS AN EXTINGUISHER, AS THIS WILL SPREAD THE FIRE.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
VAPORS MAY FORM EXPLOSIVE MIXTURES WITH AIR. VAPORS MAY TRAVEL CONSIDERABLE
DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK. THIS PRODUCT IS A POOR
CONDUCTOR OF ELECTRICITY AND CAN BECOME ELECTROSTATICALLY CHARGED. IF
SUFFICIENT CHARGE IS ACCUMULATED, IGNITION OF FLAMMABLE MIXTURES CAN OCCUR.
TO REDUCE POTENTIAL FOR STATIC DISCHARGE, USE PROPER BONDING AND GROUNDING
PROCEDURES. THIS LIQUID MAY ACCUMULATE STATIC ELECTRICITY WHEN FILLING
PROPERLY GROUNDED CONTAINERS. STATIC ELECTRICITY ACCUMULATION MAY BE
SIGNIFICANTLY INCREASED BY THE PRESENCE OF SMALL QUANTITIES OF WATER OR
OTHER CONTAMINANTS. MATERIAL WILL FLOAT AND MAY IGNITE ON SURFACE OF WATER.
DURING FIRE, GASES HAZARDOUS TO HEALTH MAY BE FORMED.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIREFIGHTERS:
SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE CLOTHING MUST BE
WORN IN CASE OF FIRE.
FIRE-FIGHTING EQUIPMENT/INSTRUCTIONS:
IN CASE OF FIRE AND/OR EXPLOSION DO NOT BREATHE FUMES. MOVE CONTAINERS
FROM FIRE AREA IF YOU CAN DO SO WITHOUT RISK. USE STANDARD FIREFIGHTING
PROCEDURES AND CONSIDER THE HAZARDS OF OTHER INVOLVED MATERIALS.
GENERAL FIRE HAZARDS: HIGHLY FLAMMABLE LIQUID AND VAPOR.
| 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
KEEP UNNECESSARY PERSONNEL AWAY. KEEP PEOPLE AWAY FROM AND UPWIND OF
SPILL/LEAK. ELIMINATE ALL IGNITION SOURCES (NO SMOKING, FLARES, SPARKS,
OR FLAMES IN IMMEDIATE AREA). WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND
CLOTHING DURING CLEAN-UP. AVOID BREATHING MIST/VAPORS. DO NOT TOUCH DAMAGED
CONTAINERS OR SPILLED MATERIAL UNLESS WEARING APPROPRIATE PROTECTIVE
CLOTHING. VENTILATE CLOSED SPACES BEFORE ENTERING THEM. USE APPROPRIATE
CONTAINMENT TO AVOID ENVIRONMENTAL CONTAMINATION. LOCAL AUTHORITIES SHOULD
BE ADVISED IF SIGNIFICANT SPILLAGES CANNOT BE CONTAINED. FOR PERSONAL
PROTECTION, SEE SECTION 8 OF THE SDS.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
ELIMINATE ALL IGNITION SOURCES (NO SMOKING, FLARES, SPARKS, OR FLAMES IN
IMMEDIATE AREA). KEEP COMBUSTIBLES (WOOD, PAPER, OIL, ETC.) AWAY FROM
SPILLED MATERIAL. TAKE PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGE.
USE ONLY NON-SPARKING TOOLS.
LARGE SPILLS:
STOP THE FLOW OF MATERIAL, IF THIS IS WITHOUT RISK. DIKE THE SPILLED
MATERIAL, WHERE THIS IS POSSIBLE. USE A NON-COMBUSTIBLE MATERIAL LIKE
VERMICULITE, SAND OR EARTH TO SOAK UP THE PRODUCT AND PLACE INTO A
CONTAINER FOR LATER DISPOSAL. FOLLOWING PRODUCT RECOVERY, FLUSH AREA
WITH WATER.
SMALL SPILLS:
ABSORB WITH EARTH, SAND OR OTHER NON-COMBUSTIBLE MATERIAL AND TRANSFER TO
CONTAINERS FOR LATER DISPOSAL. WIPE UP WITH ABSORBENT MATERIAL (E.G. CLOTH,
FLEECE). CLEAN SURFACE THOROUGHLY TO REMOVE RESIDUAL CONTAMINATION.
NEVER RETURN SPILLS TO ORIGINAL CONTAINERS FOR RE-USE. FOR WASTE DISPOSAL,
SEE SECTION 13 OF THE SDS.
ENVIRONMENTAL PRECAUTIONS:
AVOID RELEASE TO THE ENVIRONMENT. INFORM APPROPRIATE MANAGERIAL OR
SUPERVISORY PERSONNEL OF ALL ENVIRONMENTAL RELEASES. PREVENT FURTHER
LEAKAGE OR SPILLAGE IF SAFE TO DO SO. AVOID DISCHARGE INTO DRAINS, WATER
COURSES OR ONTO THE GROUND. USE APPROPRIATE CONTAINMENT TO AVOID
ENVIRONMENTAL CONTAMINATION.
| 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
DO NOT HANDLE, STORE OR OPEN NEAR AN OPEN FLAME, SOURCES OF HEAT OR SOURCES
OF IGNITION. PROTECT MATERIAL FROM DIRECT SUNLIGHT. WHEN USING DO NOT
SMOKE. EXPLOSION-PROOF GENERAL AND LOCAL EXHAUST VENTILATION. MINIMIZE FIRE
RISKS FROM FLAMMABLE AND COMBUSTIBLE MATERIALS (INCLUDING COMBUSTIBLE DUST
AND STATIC ACCUMULATING LIQUIDS) OR DANGEROUS REACTIONS WITH INCOMPATIBLE
MATERIALS. HANDLING OPERATIONS THAT CAN PROMOTE ACCUMULATION OF STATIC
CHARGES INCLUDE BUT ARE NOT LIMITED TO:
MIXING, FILTERING, PUMPING AT HIGH FLOW RATES, SPLASH FILLING, CREATING
MISTS OR SPRAYS, TANK AND CONTAINER FILLING, TANK CLEANING, SAMPLING,
GAUGING, SWITCH LOADING, VACUUM TRUCK OPERATIONS. TAKE PRECAUTIONARY
MEASURES AGAINST STATIC DISCHARGES. ALL EQUIPMENT USED WHEN HANDLING THE
PRODUCT MUST BE GROUNDED. USE NON-SPARKING TOOLS AND EXPLOSION-PROOF
EQUIPMENT. AVOID BREATHING MIST/VAPORS. AVOID CONTACT WITH EYES, SKIN, AND
CLOTHING. AVOID PROLONGED EXPOSURE. WEAR APPROPRIATE PERSONAL PROTECTIVE
EQUIPMENT. WASH HANDS THOROUGHLY AFTER HANDLING. AVOID RELEASE TO THE
ENVIRONMENT. OBSERVE GOOD INDUSTRIAL HYGIENE PRACTICES.
FOR ADDITIONAL INFORMATION ON EQUIPMENT BONDING AND GROUNDING, REFER TO THE
CANADIAN ELECTRICAL CODE IN CANADA, (CSA C22.1), OR THE AMERICAN PETROLEUM
INSTITUTE (API) RECOMMENDED PRACTICE 2003, "PROTECTION AGAINST IGNITIONS
ARISING OUT OF STATIC, LIGHTNING, AND STRAY CURRENTS" OR NATIONAL FIRE
PROTECTION ASSOCIATION (NFPA) 77, "RECOMMENDED PRACTICE ON STATIC
ELECTRICITY" OR NATIONAL FIRE PROTECTION ASSOCIATION (NFPA) 70, "NATIONAL
ELECTRICAL CODE".
FOR PRODUCT USAGE INSTRUCTIONS, SEE THE PRODUCT LABEL.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
KEEP AWAY FROM HEAT, SPARKS AND OPEN FLAME. PREVENT ELECTROSTATIC CHARGE
BUILD-UP BY USING COMMON BONDING AND GROUNDING TECHNIQUES. ELIMINATE
SOURCES OF IGNITION. AVOID SPARK PROMOTERS. GROUND/BOND CONTAINER AND
EQUIPMENT. THESE ALONE MAY BE INSUFFICIENT TO REMOVE STATIC ELECTRICITY.
STORE IN A COOL, DRY PLACE OUT OF DIRECT SUNLIGHT. STORE IN TIGHTLY CLOSED
CONTAINER. STORE IN A WELL-VENTILATED PLACE. KEEP IN AN AREA EQUIPPED WITH
SPRINKLERS. STORE AWAY FROM INCOMPATIBLE MATERIALS (SEE SECTION 10 OF THE
SDS).
| 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
OCCUPATIONAL EXPOSURE LIMITS:
THE FOLLOWING CONSTITUENTS ARE THE ONLY CONSTITUENTS OF THE PRODUCT WHICH
HAVE A PEL, TLV OR OTHER RECOMMENDED EXPOSURE LIMIT. AT THIS TIME, THE
OTHER CONSTITUENTS HAVE NO KNOWN EXPOSURE LIMITS.
US. OSHA TABLE Z-1 LIMITS FOR AIR CONTAMINANTS (29 CFR 1910.1000):
COMPONENTS TYPE VALUE
ISOPROPYL ALCOHOL PEL 980 MG/M3
(CAS 67-63-0) 400 PPM
NAPHTHA (PETROLEUM), HYDROTREATED LIGHT PEL 400 MG/M3
(CAS 64742-49-0) 100 PPM
N-HEPTANE PEL 2000 MG/M3
(CAS 142-82-5) 500 PPM
SOLVENT NAPHTHA (PETROLEUM), LIGHT ALIPH. PEL 400 MG/M3
(CAS 64742-89-8) 100 PPM
US. ACGIH THRESHOLD LIMIT VALUES:
COMPONENTS TYPE VALUE
ISOPROPYL ALCOHOL STEL 400 PPM
(CAS 67-63-0)
TWA 200 PPM
N-HEPTANE STEL 500 PPM
(CAS 142-82-5)
TWA 400 PPM
US. NIOSH: POCKET GUIDE TO CHEMICAL HAZARDS
COMPONENTS TYPE VALUE
ISOPROPYL ALCOHOL STEL 1225 MG/M3
(CAS 67-63-0) 500 PPM
TWA 980 MG/M3
400 PPM
NAPHTHA (PETROLEUM), HYDROTREATED LIGHT TWA 400 MG/M3
(CAS 64742-49-0) 100 PPM
N-HEPTANE CEILING 1800 MG/M3
(CAS 142-82-5) 440 PPM
TWA 350 MG/M3
85 PPM
SOLVENT NAPHTHA (PETROLEUM), LIGHT ALIPH. TWA 400 MG/M3
(CAS 64742-89-8) 100 PPM
BIOLOGICAL LIMIT VALUES:
ACGIH BIOLOGICAL EXPOSURE INDICES:
COMPONENTS VALUE DETERMINANT SPECIMEN SAMPLING TIME
ISOPROPYL ALCOHOL 40 MG/L ACETONE URINE *
(CAS 67-63-0)
* - FOR SAMPLING DETAILS, PLEASE SEE THE SOURCE DOCUMENT.
APPROPRIATE ENGINEERING CONTROLS:
EXPLOSION-PROOF GENERAL AND LOCAL EXHAUST VENTILATION. GOOD GENERAL
VENTILATION SHOULD BE USED. VENTILATION RATES SHOULD BE MATCHED TO
CONDITIONS. IF APPLICABLE, USE PROCESS ENCLOSURES, LOCAL EXHAUST
VENTILATION, OR OTHER ENGINEERING CONTROLS TO MAINTAIN AIRBORNE LEVELS
BELOW RECOMMENDED EXPOSURE LIMITS. IF EXPOSURE LIMITS HAVE NOT BEEN
ESTABLISHED, MAINTAIN AIRBORNE LEVELS TO AN ACCEPTABLE LEVEL. PROVIDE
EYEWASH STATION AND SAFETY SHOWER.
INDIVIDUAL PROTECTION MEASURES, SUCH AS PERSONAL PROTECTIVE EQUIPMENT:
EYE/FACE PROTECTION: WEAR SAFETY GLASSES WITH SIDE SHIELDS (OR GOGGLES).
SKIN PROTECTION:
HAND PROTECTION:
WEAR PROTECTIVE GLOVES SUCH AS: LAMINATE FILM.
OTHER: WEAR APPROPRIATE CHEMICAL RESISTANT CLOTHING.
RESPIRATORY PROTECTION:
IF ENGINEERING CONTROLS ARE NOT FEASIBLE OR IF EXPOSURE EXCEEDS THE
APPLICABLE EXPOSURE LIMITS, USE A NIOSH-APPROVED CARTRIDGE RESPIRATOR WITH
AN ORGANIC VAPOR CARTRIDGE. USE A SELF-CONTAINED BREATHING APPARATUS IN
CONFINED SPACES AND FOR EMERGENCIES. AIR MONITORING IS NEEDED TO DETERMINE
ACTUAL EMPLOYEE EXPOSURE LEVELS.
THERMAL HAZARDS:
WEAR APPROPRIATE THERMAL PROTECTIVE CLOTHING, WHEN NECESSARY.
GENERAL HYGIENE CONSIDERATIONS:
WHEN USING DO NOT SMOKE. ALWAYS OBSERVE GOOD PERSONAL HYGIENE MEASURES,
SUCH AS WASHING AFTER HANDLING THE MATERIAL AND BEFORE EATING, DRINKING,
AND/OR SMOKING. ROUTINELY WASH WORK CLOTHING AND PROTECTIVE EQUIPMENT TO
REMOVE CONTAMINANTS.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: LIQUID.
FORM: LIQUID.
COLOR: COLORLESS.
ODOR: PLEASANT.
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
MELTING POINT/FREEZING POINT: -132 DEG. F (-91.1 DEG. C) ESTIMATED
INITIAL BOILING POINT AND BOILING RANGE: 190 DEG. F (87.8 DEG. C) ESTIMATED
FLASH POINT: 15.8 DEG. F (-9.0 DEG. C) ESTIMATED
EVAPORATION RATE: FAST.
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS:
FLAMMABILITY LIMIT - LOWER (%): 1% ESTIMATED
FLAMMABILITY LIMIT - UPPER (%): 13% ESTIMATED
VAPOR PRESSURE: 80.1 HPA ESTIMATED
VAPOR DENSITY: >1 (AIR = 1)
RELATIVE DENSITY: 0.7
SOLUBILITY(IES):
SOLUBILITY (WATER): SLIGHTLY SOLUBLE.
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: 433 DEG. F (222.8 DEG. C) ESTIMATED
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
VISCOSITY: NOT AVAILABLE.
PERCENT VOLATILE: NOT AVAILABLE.
| 10. STABILITY AND REACTIVITY | |
REACTIVITY:
THE PRODUCT IS STABLE AND NON-REACTIVE UNDER NORMAL CONDITIONS OF USE,
STORAGE AND TRANSPORT.
CHEMICAL STABILITY: MATERIAL IS STABLE UNDER NORMAL CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS:
NO DANGEROUS REACTION KNOWN UNDER CONDITIONS OF NORMAL USE.
CONDITIONS TO AVOID:
AVOID HEAT, SPARKS, OPEN FLAMES AND OTHER IGNITION SOURCES. CONTACT WITH
INCOMPATIBLE MATERIALS.
INCOMPATIBLE MATERIALS:
ACIDS. STRONG OXIDIZING AGENTS. CHLORINE. ISOCYANATES.
HAZARDOUS DECOMPOSITION PRODUCTS: CARBON OXIDES. SULFUR OXIDES.
| 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INHALATION:
MAY CAUSE DROWSINESS OR DIZZINESS. HEADACHE. NAUSEA, VOMITING. PROLONGED
INHALATION MAY BE HARMFUL.
SKIN CONTACT: CAUSES SKIN IRRITATION.
EYE CONTACT: CAUSES SERIOUS EYE IRRITATION.
INGESTION:
DROPLETS OF THE PRODUCT ASPIRATED INTO THE LUNGS THROUGH INGESTION OR
VOMITING MAY CAUSE A SERIOUS CHEMICAL PNEUMONIA.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
ASPIRATION MAY CAUSE PULMONARY EDEMA AND PNEUMONITIS. MAY CAUSE DROWSINESS
OR DIZZINESS. HEADACHE. NAUSEA, VOMITING. SEVERE EYE IRRITATION. SYMPTOMS
MAY INCLUDE STINGING, TEARING, REDNESS, SWELLING, AND BLURRED VISION. SKIN
IRRITATION. MAY CAUSE REDNESS AND PAIN.
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
COMPONENTS SPECIES TEST RESULTS
HEPTANE, BRANCHED, CYCLIC AND LINEAR (CAS 426260-76-6):
ACUTE:
DERMAL:
LD50 RABBIT >2000 MG/KG
INHALATION:
LC50 RAT >60 MG/L, 4 HOURS
ORAL:
LD50 RAT >5000 MG/KG
NAPHTHA (PETROLEUM), HYDROTREATED LIGHT (CAS 64742-49-0):
ACUTE:
DERMAL:
LD50 RAT >2000 MG/KG
INHALATION:
VAPOR:
LC50 RAT >5.2 MG/L, 4 HOURS
ORAL:
LD50 RAT >5000 MG/KG
N-HEPTANE (CAS 142-82-5):
ACUTE:
DERMAL:
LD50 RABBIT >2000 MG/KG
INHALATION:
VAPOR:
LC50 RAT >73.5 MG/L, 4 HOURS
ORAL:
LD50 RAT >5000 MG/KG
SKIN CORROSION/IRRITATION: CAUSES SKIN IRRITATION.
SERIOUS EYE DAMAGE/EYE IRRITATION: CAUSES SERIOUS EYE IRRITATION.
RESPIRATORY OR SKIN SENSITIZATION:
RESPIRATORY SENSITIZATION: NOT A RESPIRATORY SENSITIZER.
SKIN SENSITIZATION:
THIS PRODUCT IS NOT EXPECTED TO CAUSE SKIN SENSITIZATION.
GERM CELL MUTAGENICITY:
NO DATA AVAILABLE TO INDICATE PRODUCT OR ANY COMPONENTS PRESENT AT GREATER
THAN 0.1% ARE MUTAGENIC OR GENOTOXIC.
CARCINOGENICITY: NOT CLASSIFIABLE AS TO CARCINOGENICITY TO HUMANS.
IARC MONOGRAPHS. OVERALL EVALUATION OF CARCINOGENICITY: NOT LISTED.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1053): NOT LISTED.
US. NATIONAL TOXICOLOGY PROGRAM (NTP) REPORT ON CARCINOGENS: NOT LISTED.
REPRODUCTIVE TOXICITY:
THIS PRODUCT IS NOT EXPECTED TO CAUSE REPRODUCTIVE OR DEVELOPMENTAL
EFFECTS.
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE:
MAY CAUSE DROWSINESS OR DIZZINESS.
SPECIFIC TARGET ORGAN TOXICITY - REPEATED EXPOSURE: NOT CLASSIFIED.
ASPIRATION HAZARD: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
CHRONIC EFFECTS: PROLONGED INHALATION MAY BE HARMFUL.
| 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY: VERY TOXIC TO AQUATIC LIFE WITH LONG LASTING EFFECTS.
COMPONENTS SPECIES TEST RESULTS
N-HEPTANE (CAS 142-82-5):
AQUATIC:
ACUTE:
CRUSTACEA EC50 WATER FLEA (DAPHNIA MAGNA) >10 MG/L, 24 HOURS
1.5 MG/L, 48 HOURS
FISH LC50 FRESHWATER FISH 375 MG/L, 96 HOURS
GOLDFISH (CARASSIUS AURATUS) 4 MG/L, 24 HOURS
PERSISTENCE AND DEGRADABILITY:
NO DATA IS AVAILABLE ON THE DEGRADABILITY OF ANY INGREDIENTS IN THE
MIXTURE.
BIOACCUMULATIVE POTENTIAL: NO DATA AVAILABLE.
PARTITION COEFFICIENT N-OCTANOL / WATER (LOG KOW):
ISOPROPYL ALCOHOL: 0.05
N-HEPTANE: 4.66
BIOCONCENTRATION FACTOR (BCF):
NAPHTHA (PETROLEUM), HYDROTREATED LIGHT: 10 - 2500
MOBILITY IN SOIL: NO DATA AVAILABLE.
OTHER ADVERSE EFFECTS:
NO OTHER ADVERSE ENVIRONMENTAL EFFECTS (E.G. OZONE DEPLETION, PHOTOCHEMICAL
OZONE CREATION POTENTIAL, ENDOCRINE DISRUPTION, GLOBAL WARMING POTENTIAL)
ARE EXPECTED FROM THIS COMPONENT.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL INSTRUCTIONS:
IF DISCARDED, THIS PRODUCT IS CONSIDERED A RCRA IGNITABLE WASTE, D001.
EMPTY CONTAINER CAN BE RECYCLED. COLLECT AND RECLAIM OR DISPOSE IN SEALED
CONTAINERS AT LICENSED WASTE DISPOSAL SITE. DO NOT ALLOW THIS MATERIAL TO
DRAIN INTO SEWERS/WATER SUPPLIES. DO NOT CONTAMINATE PONDS, WATERWAYS OR
DITCHES WITH CHEMICAL OR USED CONTAINER. DISPOSE OF CONTENTS/CONTAINER IN
ACCORDANCE WITH LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
HAZARDOUS WASTE CODE:
D001: WASTE FLAMMABLE MATERIAL WITH A FLASH POINT <140 F
CONTAMINATED PACKAGING:
SINCE EMPTIED CONTAINERS MAY RETAIN PRODUCT RESIDUE, FOLLOW LABEL WARNINGS
EVEN AFTER CONTAINER IS EMPTIED. EMPTY CONTAINERS SHOULD BE TAKEN TO AN
APPROVED WASTE HANDLING SITE FOR RECYCLING OR DISPOSAL.
| 14. TRANSPORT INFORMATION | |
DOT:
UN NUMBER: UN1993
UN PROPER SHIPPING NAME:
FLAMMABLE LIQUIDS, N.O.S. (HEPTANES, ISOPROPYL ALCOHOL), MARINE POLLUTANT
(HEPTANES)
TRANSPORT HAZARD CLASS(ES):
CLASS: 3
SUBSIDIARY RISK:
LABEL(S): 3
PACKING GROUP: II
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: YES
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
SPECIAL PROVISIONS: IB2, T7, TP1, TP8, TP28
PACKAGING EXCEPTIONS: 150
PACKAGING NON BULK: 202
PACKAGING BULK: 242
IATA:
UN NUMBER: UN1993
UN PROPER SHIPPING NAME:
FLAMMABLE LIQUID, N.O.S. (HEPTANES, ISOPROPYL ALCOHOL)
TRANSPORT HAZARD CLASS(ES):
CLASS: 3
SUBSIDIARY RISK:
PACKING GROUP: II
ENVIRONMENTAL HAZARDS: YES
ERG CODE: 3H
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
OTHER INFORMATION:
PASSENGER AND CARGO AIRCRAFT: FORBIDDEN
CARGO AIRCRAFT ONLY: FORBIDDEN
IMDG:
UN NUMBER: UN1993
UN PROPER SHIPPING NAME:
FLAMMABLE LIQUID, N.O.S. (HEPTANES, ISOPROPYL ALCOHOL), MARINE POLLUTANT
(HEPTANES)
TRANSPORT HAZARD CLASS(ES):
CLASS: 3
SUBSIDIARY RISK:
PACKING GROUP: II
ENVIRONMENTAL HAZARDS:
MARINE POLLUTANT: YES
EMS: F-E, S-E
SPECIAL PRECAUTIONS FOR USER:
READ SAFETY INSTRUCTIONS, SDS AND EMERGENCY PROCEDURES BEFORE HANDLING.
DOT: FLAMMABLE LIQUID, CLASS/DIVISION 3.1, 3.2, 3.3
IATA; IMDG: CLASS 3 - FLAMMABLE LIQUIDS
MARINE POLLUTANT: ENVIRONMENT
GENERAL INFORMATION:
IMDG REGULATED MARINE POLLUTANT. DOT REGULATED MARINE POLLUTANT.
| 15. REGULATORY INFORMATION | |
US FEDERAL REGULATIONS:
THIS PRODUCT IS A "HAZARDOUS CHEMICAL" AS DEFINED BY THE OSHA HAZARD
COMMUNICATION STANDARD, 29 CFR 1910.1200.
TSCA SECTION 12(B) EXPORT NOTIFICATION (40 CFR 707, SUBPT. D):
NOT REGULATED.
SARA 304 EMERGENCY RELEASE NOTIFICATION: NOT REGULATED.
OSHA SPECIFICALLY REGULATED SUBSTANCES (29 CFR 1910.1001-1053): NOT LISTED.
CERCLA HAZARDOUS SUBSTANCE LIST (40 CFR 302.4): NOT LISTED.
CERCLA HAZARDOUS SUBSTANCES REPORTABLE QUANTITY
NOT LISTED.
SPILLS OR RELEASES RESULTING IN THE LOSS OF ANY INGREDIENT AT OR ABOVE
ITS RQ REQUIRE IMMEDIATE NOTIFICATION TO THE NATIONAL RESPONSE CENTER
(800-424-8802) AND TO YOUR LOCAL EMERGENCY PLANNING COMMITTEE.
OTHER FEDERAL REGULATIONS:
CLEAN AIR ACT (CAA) SECTION 112 HAZARDOUS AIR POLLUTANTS (HAPS) LIST:
NOT REGULATED.
CLEAN AIR ACT (CAA) SECTION 112(R) ACCIDENTAL RELEASE PREVENTION
(40 CFR 68.130): NOT REGULATED.
SAFE DRINKING WATER ACT (SDWA):
CONTAINS COMPONENT(S) REGULATED UNDER THE SAFE DRINKING WATER ACT.
FEMA PRIORITY SUBSTANCES RESPIRATORY HEALTH AND SAFETY IN THE FLAVOR
MANUFACTURING WORKPLACE:
ISOPROPYL ALCOHOL (CAS 67-63-0): LOW PRIORITY
FOOD AND DRUG ADMINISTRATION (FDA): NOT REGULATED.
SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT OF 1986 (SARA):
CLASSIFIED HAZARD CATEGORIES:
FLAMMABLE (GASES, AEROSOLS, LIQUIDS, OR SOLIDS)
SKIN CORROSION OR IRRITATION
SERIOUS EYE DAMAGE OR EYE IRRITATION
SPECIFIC TARGET ORGAN TOXICITY (SINGLE OR REPEATED EXPOSURE)
ASPIRATION HAZARD
HAZARD NOT OTHERWISE CLASSIFIED (HNOC)
SARA 302 EXTREMELY HAZARDOUS SUBSTANCE: NOT LISTED.
SARA 311/312 HAZARDOUS CHEMICAL: YES
SARA 313 (TRI REPORTING): NOT REGULATED.
US STATE REGULATIONS:
US. CALIFORNIA. CANDIDATE CHEMICALS LIST. SAFER CONSUMER PRODUCTS
REGULATIONS (CAL. CODE REGS, TIT. 22, 69502.3, SUBD. (A)):
ISOPROPYL ALCOHOL (CAS 67-63-0)
NAPHTHA (PETROLEUM), HYDROTREATED LIGHT (CAS 64742-49-0)
N-HEPTANE (CAS 142-82-5)
SOLVENT NAPHTHA (PETROLEUM), LIGHT ALIPH. (CAS 64742-89-8)
US. NEW JERSEY WORKER AND COMMUNITY RIGHT-TO-KNOW ACT:
ISOPROPYL ALCOHOL (CAS 67-63-0)
NAPHTHA (PETROLEUM), HYDROTREATED LIGHT (CAS 64742-49-0)
N-HEPTANE (CAS 142-82-5)
SOLVENT NAPHTHA (PETROLEUM), LIGHT ALIPH. (CAS 64742-89-8)
US. MASSACHUSETTS RTK - SUBSTANCE LIST:
ISOPROPYL ALCOHOL (CAS 67-63-0)
NAPHTHA (PETROLEUM), HYDROTREATED LIGHT (CAS 64742-49-0)
N-HEPTANE (CAS 142-82-5)
SOLVENT NAPHTHA (PETROLEUM), LIGHT ALIPH. (CAS 64742-89-8)
US. PENNSYLVANIA WORKER AND COMMUNITY RIGHT-TO-KNOW LAW:
ISOPROPYL ALCOHOL (CAS 67-63-0)
NAPHTHA (PETROLEUM), HYDROTREATED LIGHT (CAS 64742-49-0)
N-HEPTANE (CAS 142-82-5)
SOLVENT NAPHTHA (PETROLEUM), LIGHT ALIPH. (CAS 64742-89-8)
US. RHODE ISLAND RTK:
ISOPROPYL ALCOHOL (CAS 67-63-0)
NAPHTHA (PETROLEUM), HYDROTREATED LIGHT (CAS 64742-49-0)
N-HEPTANE (CAS 142-82-5)
SOLVENT NAPHTHA (PETROLEUM), LIGHT ALIPH. (CAS 64742-89-8)
CALIFORNIA PROPOSITION 65:
WARNING: CANCER AND REPRODUCTIVE HARM - WWW.P65WARNINGS.CA.GOV
CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/CARCINOGENIC SUBSTANCE
BENZENE (CAS 71-43-2) LISTED: FEBRUARY 27, 1987
CUMENE (CAS 98-82-8) LISTED: APRIL 6, 2010
ETHYLBENZENE (CAS 100-41-4) LISTED: JUNE 11, 2004
METHYL ISOBUTYL KETONE (CAS 108-10-1) LISTED: NOVEMBER 4, 2011
NAPHTHALENE (CAS 91-20-3) LISTED: APRIL 19, 2002
CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/DEVELOPMENTAL TOXIN
BENZENE (CAS 71-43-2) LISTED: DECEMBER 26, 1997
METHANOL (CAS 67-56-1) LISTED: MARCH 16, 2012
METHYL ISOBUTYL KETONE (CAS 108-10-1) LISTED: MARCH 28, 2014
TOLUENE (CAS 108-88-3) LISTED: JANUARY 1, 1991
CALIFORNIA PROPOSITION 65 - CRT LISTED DATE/MALE REPRODUCTIVE TOXIN
BENZENE (CAS 71-43-2) LISTED: DECEMBER 26, 1997
N-HEXANE (CAS 110-54-3) LISTED: DECEMBER 15, 2017
VOLATILE ORGANIC COMPOUNDS (VOC) REGULATIONS:
EPA:
VOC CONTENT (40 CFR 51.100(S)): 100%
CONSUMER PRODUCTS (40 CFR 59, SUBPT. C): NOT REGULATED
STATE:
CONSUMER PRODUCTS:
THIS PRODUCT IS REGULATED AS A BRAKE CLEANER. THIS PRODUCT IS NOT COMPLIANT
TO BE SOLD FOR USE IN CALIFORNIA, COLORADO, CONNECTICUT, DELAWARE, THE
DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, MAINE, MARYLAND, MASSACHUSETTS,
MICHIGAN, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE
ISLAND AND PARTS OF UTAH AND VIRGINIA. THIS PRODUCT IS COMPLIANT IN ALL
OTHER STATES.
VOC CONTENT (CA): 100%
VOC CONTENT (OTC): 100%
INTERNATIONAL INVENTORIES:
COUNTRY(S) OR REGION INVENTORY NAME ON INVENTORY
(YES/NO)*
AUSTRALIA AUSTRALIAN INVENTORY OF INDUSTRIAL NO
CHEMICALS (AICIS)
CANADA DOMESTIC SUBSTANCES LIST (DSL) YES
CANADA NON-DOMESTIC SUBSTANCES LIST (NDSL) NO
CHINA INVENTORY OF EXISTING CHEMICAL NO
SUBSTANCES IN CHINA (IECSC)
EUROPE EUROPEAN INVENTORY OF EXISTING NO
COMMERCIAL CHEMICAL SUBSTANCES
(EINECS)
EUROPE EUROPEAN LIST OF NOTIFIED CHEMICAL NO
SUBSTANCES (ELINCS)
JAPAN INVENTORY OF EXISTING AND NEW NO
CHEMICAL SUBSTANCES (ENCS)
KOREA EXISTING CHEMICALS LIST (ECL) YES
NEW ZEALAND NEW ZEALAND INVENTORY NO
PHILIPPINES PHILIPPINE INVENTORY OF CHEMICALS YES
AND CHEMICAL SUBSTANCES (PICCS)
TAIWAN TAIWAN CHEMICAL SUBSTANCE INVENTORY YES
(TCSI)
UNITED STATES & TOXIC SUBSTANCES CONTROL ACT (TSCA) YES
PUERTO RICO INVENTORY
*A "YES" INDICATES THAT ALL COMPONENTS OF THIS PRODUCT COMPLY WITH
THE INVENTORY REQUIREMENTS ADMINISTERED BY THE GOVERNING COUNTRY(S)
A "NO" INDICATES THAT ONE OR MORE COMPONENTS OF THE PRODUCT ARE NOT LISTED
OR EXEMPT FROM LISTING ON THE INVENTORY ADMINISTERED BY THE GOVERNING
COUNTRY(S).
| 16. OTHER INFORMATION, INCLUDING DATE OF PREPARATION | |
OR LAST REVISION
ISSUE DATE: 12-20-2021
PREPARED BY: DANICA FULMER
VERSION #: 01
FURTHER INFORMATION: CRC # 937A/1002953
DISCLAIMER:
THE INFORMATION CONTAINED IN THIS DOCUMENT APPLIES TO THIS SPECIFIC
MATERIAL AS SUPPLIED. IT MAY NOT BE VALID FOR THIS MATERIAL IF IT IS USED
IN COMBINATION WITH ANY OTHER MATERIALS. THIS INFORMATION IS ACCURATE TO
THE BEST OF CRC'S KNOWLEDGE OR OBTAINED FROM SOURCES BELIEVED BY CRC TO
BE ACCURATE. BEFORE USING ANY PRODUCT, READ ALL WARNINGS AND DIRECTIONS ON
THE LABEL. FOR FURTHER CLARIFICATION OF ANY INFORMATION CONTAINED ON THIS
(M)SDS CONSULT YOUR SUPERVISOR, A HEALTH & SAFETY PROFESSIONAL, OR CRC
INDUSTRIES, INC.
MATERIAL NAME: BRAKLEEN(R*) BRAKE PARTS CLEANER - 55 GAL
SDS US