| Common Name: | 3-IN-ONE GARAGE DOOR LUBE |
| Manufacturer: | WD-40 |
| SDS Revision Date: | 7/18/2018 |
| SDS Format: | GHS-US |
| Item Number(s): | 3DVF7 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
3 IN 1
3-IN-ONE(R*)
WD-40 COMPANY
SAFETY DATA SHEET
| 1 - IDENTIFICATION |  |
PRODUCT NAME: 3-IN-ONE(R*) GARAGE DOOR LUBE
PRODUCT USE: AEROSOL LUBRICANT
RESTRICTIONS ON USE: NONE IDENTIFIED
SDS DATE OF PREPARATION: JULY 18, 2018
MANUFACTURER: WD-40 COMPANY
ADDRESS:
9715 BUSINESS PARK AVENUE
SAN DIEGO, CALIFORNIA 92131
USA
TELEPHONE:
EMERGENCY: 1-888-324-7596
INFORMATION: 1-888-324-7596
CHEMICAL SPILLS:
1-800-424-9300 (CHEMTREC)
1-703-527-3887 (INTERNATIONAL CALLS)
| 2 - HAZARDS IDENTIFICATION | |
HAZCOM 2012/GHS CLASSIFICATION:
FLAMMABLE AEROSOL: CATEGORY 1
GAS UNDER PRESSURE: COMPRESSED GAS
ASPIRATION TOXICITY: CATEGORY 1
NOTE:
THIS PRODUCT IS A CONSUMER PRODUCT AND IS LABELED IN ACCORDANCE WITH THE US
CONSUMER PRODUCT SAFETY COMMISSION REGULATIONS WHICH TAKE PRECEDENCE OVER
OSHA HAZARD COMMUNICATION LABELING. THE ACTUAL CONTAINER LABEL WILL NOT
INCLUDE THE LABEL ELEMENTS BELOW. THE LABELING BELOW APPLIES TO
INDUSTRIAL/PROFESSIONAL PRODUCTS.
LABEL ELEMENTS:
FLAME
GAS CYLINDER
HEALTH HAZARD
DANGER!
EXTREMELY FLAMMABLE AEROSOL.
CONTAINS GAS UNDER PRESSURE; MAY EXPLODE IF HEATED.
MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
PREVENTION:
KEEP AWAY FROM HEAT, SPARKS, OPEN FLAMES, HOT SURFACES - NO SMOKING.
DO NOT SPRAY ON AN OPEN FLAME OR OTHER IGNITION SOURCE.
PRESSURIZED CONTAINER: DO NOT PIERCE OR BURN, EVEN AFTER USE.
RESPONSE:
IF SWALLOWED:
IMMEDIATELY CALL A POISON CENTER OR PHYSICIAN. DO NOT INDUCE VOMITING.
STORAGE:
STORE LOCKED UP.
PROTECT FROM SUNLIGHT. DO NOT EXPOSE TO TEMPERATURES EXCEEDING 50 DEG.
C/122 DEG. F. STORE IN A WELL-VENTILATED PLACE.
DISPOSAL:
DISPOSE OF CONTENTS AND CONTAINER IN ACCORDANCE WITH LOCAL AND NATIONAL
REGULATIONS.
| 3 - COMPOSITION/INFORMATION ON INGREDIENTS | |
INGREDIENT CAS # WEIGHT US HAZCOM 2012/
PERCENT GHS CLASSIFICATION
ALIPHATIC PETROLEUM 64742-47-8 50-60 ASPIRATION TOXICITY
DISTILLATES CATEGORY 1
LIQUEFIED PETROLEUM 68476-86-8 35-45 FLAMMABLE GAS CATEGORY 1
GAS (PROPANE, N-BUTANE) GAS UNDER PRESSURE,
COMPRESSED GAS
POLYDIMETHYLSILOXANE 63148-62-9 2-4 NOT HAZARDOUS
WHITE MINERAL OIL 8042-47-5 2-4 ASPIRATION TOXICITY
CATEGORY 1
NOTE: THE EXACT PERCENTAGES ARE A TRADE SECRET.
| 4 - FIRST AID MEASURES | |
INGESTION (SWALLOWED):
ASPIRATION HAZARD. DO NOT INDUCE VOMITING. CALL PHYSICIAN, POISON
CONTROL CENTER OR THE WD-40 SAFETY HOTLINE AT 1-888-324-7596 IMMEDIATELY.
EYE CONTACT:
FLUSH THOROUGHLY WITH WATER FOR 15 MINUTES. REMOVE CONTACT LENSES IF
PRESENT AFTER THE FIRST 5 MINUTES AND CONTINUE FLUSHING. GET MEDICAL
ATTENTION IF IRRITATION PERSISTS.
SKIN CONTACT:
WASH WITH SOAP AND WATER. IF IRRITATION DEVELOPS AND PERSISTS, GET MEDICAL
ATTENTION.
INHALATION (BREATHING):
IF IRRITATION IS EXPERIENCED, MOVE TO FRESH AIR. GET MEDICAL ATTENTION IF
IRRITATION OR OTHER SYMPTOMS DEVELOP AND PERSIST.
SIGNS AND SYMPTOMS OF EXPOSURE:
HARMFUL OR FATAL IF SWALLOWED. IF SWALLOWED, MAY BE ASPIRATED AND CAUSE
LUNG DAMAGE. MAY CAUSE EYE AND RESPIRATORY IRRITATION. INHALATION MAY
CAUSE COUGHING, HEADACHE AND DIZZINESS. SKIN CONTACT MAY CAUSE DRYING
OF THE SKIN.
INDICATION OF IMMEDIATE MEDICAL ATTENTION/SPECIAL TREATMENT NEEDED:
IMMEDIATE MEDICAL ATTENTION IS NEEDED FOR INGESTION.
| 5 - FIRE FIGHTING MEASURES | |
SUITABLE (AND UNSUITABLE) EXTINGUISHING MEDIA:
USE WATER FOG, DRY CHEMICAL, CARBON DIOXIDE OR FOAM. DO NOT USE WATER JET
OR FLOODING AMOUNTS OF WATER. BURNING PRODUCT WILL FLOAT ON THE SURFACE AND
SPREAD FIRE.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
EXTREMELY FLAMMABLE AEROSOL. CONTENTS UNDER PRESSURE. KEEP AWAY FROM
IGNITION SOURCES AND OPEN FLAMES. EXPOSURE OF CONTAINERS TO EXTREME HEAT
AND FLAMES CAN CAUSE THEM TO RUPTURE OFTEN WITH VIOLENT FORCE. COMBUSTIBLE
LIQUID AND VAPOR. THIS MATERIAL CAN RELEASE FLAMMABLE VAPORS WHEN HEATED
ABOVE AMBIENT TEMPERATURES. VAPORS CAN CAUSE A FLASH FIRE. VAPORS ARE
HEAVIER THAN AIR AND MAY TRAVEL ALONG SURFACES TO REMOTE IGNITION SOURCES
AND FLASH BACK. A VAPOR AND AIR MIXTURE CAN CREATE AN EXPLOSION HAZARD IN
CONFINED SPACES.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIRE-FIGHTERS:
FIREFIGHTERS SHOULD ALWAYS WEAR POSITIVE PRESSURE SELF-CONTAINED BREATHING
APPARATUS AND FULL PROTECTIVE CLOTHING IN AREAS WHERE CHEMICALS ARE USED
AND STORED. COOL FIRE-EXPOSED CONTAINERS WITH WATER. USE SHIELDING TO
PROTECT AGAINST BURSTING CONTAINERS.
| 6 - ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
WEAR APPROPRIATE PROTECTIVE CLOTHING (SEE SECTION 8). ELIMINATE ALL SOURCES
OF IGNITION AND VENTILATE AREA.
METHODS AND MATERIALS FOR CONTAINMENT/CLEANUP:
LEAKING CANS SHOULD BE PLACED IN A PLASTIC BAG OR OPEN PAIL UNTIL THE
PRESSURE HAS DISSIPATED. CONTAIN AND COLLECT LIQUID WITH AN INERT ABSORBENT
AND PLACE IN A CONTAINER FOR DISPOSAL. CLEAN SPILL AREA THOROUGHLY. REPORT
SPILLS TO AUTHORITIES AS REQUIRED.
| 7 - HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
AVOID CONTACT WITH EYES. AVOID PROLONGED CONTACT WITH SKIN. AVOID BREATHING
VAPORS OR AEROSOLS. USE ONLY WITH ADEQUATE VENTILATION. KEEP AWAY FROM
HEAT, SPARKS, PILOT LIGHTS, HOT SURFACES AND OPEN FLAMES. UNPLUG ELECTRICAL
TOOLS, MOTORS AND APPLIANCES BEFORE SPRAYING OR BRINGING THE CAN NEAR ANY
SOURCE OF ELECTRICITY. ELECTRICITY CAN BURN A HOLE IN THE CAN AND CAUSE
CONTENTS TO BURST INTO FLAMES. TO AVOID SERIOUS BURN INJURY, DO NOT LET THE
CAN TOUCH BATTERY TERMINALS, ELECTRICAL CONNECTIONS ON MOTORS OR APPLIANCES
OR ANY OTHER SOURCE OF ELECTRICITY. WASH THOROUGHLY WITH SOAP AND WATER
AFTER HANDLING. KEEP CONTAINERS CLOSED WHEN NOT IN USE. KEEP OUT OF THE
REACH OF CHILDREN. DO NOT PUNCTURE, CRUSH OR INCINERATE CONTAINERS, EVEN
WHEN EMPTY. INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING VAPORS AND
INHALING CAN BE HARMFUL OR FATAL.
CONDITIONS FOR SAFE STORAGE:
DO NOT STORE ABOVE 120 DEG. F OR IN DIRECT SUNLIGHT. U.F.C (NFPA 30B) LEVEL
3 AEROSOL. DO NOT PLACE CAN IN HOT WATER OR NEAR RADIATORS, STOVES OR OTHER
SOURCES OF HEAT. PROTECT FROM PHYSICAL DAMAGE.
| 8 - EXPOSURE CONTROLS/PERSONAL PROTECTION | |
CHEMICAL OCCUPATIONAL EXPOSURE LIMITS
ALIPHATIC PETROLEUM DISTILLATES 1200 MG/M3 TWA (MANUFACTURER RECOMMENDED)
LIQUEFIED PETROLEUM GAS 1000 PPM STEL ACGIH TLV (AS BUTANE)
1000 PPM TWA OSHA PEL (AS PROPANE)
POLYDIMETHYLSILOXANE NONE ESTABLISHED
WHITE MINERAL OIL 5 MG/M3 (INHALABLE) TWA ACGIH TLV
5 MG/M3 TWA OSHA PEL
THE FOLLOWING CONTROLS ARE RECOMMENDED FOR NORMAL CONSUMER USE OF THIS
PRODUCT
APPROPRIATE ENGINEERING CONTROLS: USE IN A WELL-VENTILATED AREA.
PERSONAL PROTECTION:
EYE PROTECTION: AVOID EYE CONTACT. ALWAYS SPRAY AWAY FROM YOUR FACE.
SKIN PROTECTION:
AVOID PROLONGED SKIN CONTACT. CHEMICAL RESISTANT GLOVES RECOMMENDED FOR
OPERATIONS WHERE SKIN CONTACT IS LIKELY.
RESPIRATORY PROTECTION:
NONE NEEDED FOR NORMAL USE WITH ADEQUATE VENTILATION.
FOR BULK PROCESSING OR WORKPLACE USE THE FOLLOWING CONTROLS ARE
RECOMMENDED:
APPROPRIATE ENGINEERING CONTROLS:
USE ADEQUATE GENERAL AND LOCAL EXHAUST VENTILATION TO MAINTAIN EXPOSURE
LEVELS BELOW THAT OCCUPATIONAL EXPOSURE LIMITS.
PERSONAL PROTECTION:
EYE PROTECTION: SAFETY GOGGLES RECOMMENDED WHERE EYE CONTACT IS POSSIBLE.
SKIN PROTECTION: WEAR CHEMICAL RESISTANT GLOVES.
RESPIRATORY PROTECTION:
NONE REQUIRED IF VENTILATION IS ADEQUATE. IF THE OCCUPATIONAL EXPOSURE
LIMITS ARE EXCEEDED, WEAR A NIOSH APPROVED RESPIRATOR. RESPIRATOR SELECTION
AND USE SHOULD BE BASED ON CONTAMINANT TYPE, FORM AND CONCENTRATION. FOLLOW
OSHA 1910.134, ANSI Z88.2 AND GOOD INDUSTRIAL HYGIENE PRACTICE.
WORK/HYGIENE PRACTICES: WASH WITH SOAP AND WATER AFTER HANDLING.
| 9 - PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: CLEAR, AEROSOL SPRAY
ODOR: PETROLEUM ODOR
ODOR THRESHOLD: NOT ESTABLISHED
PH: NOT APPLICABLE
MELTING/FREEZING POINT: NOT ESTABLISHED
BOILING POINT/RANGE: 161-257 DEG. C (322-495 DEG. F) (PETROLEUM SOLVENT)
FLASH POINT: -34 DEG. C (-29.2 DEG. F) (CLOSED CUP) LIQUID
EVAPORATION RATE: NOT ESTABLISHED
FLAMMABILITY (SOLID, GAS): FLAMMABLE AEROSOL
VOC: 49%
FLAMMABLE LIMITS: (SOLVENT PORTION)
LEL: 0.6%
UEL: 9.5%
VAPOR PRESSURE: 40-60 PSIG @ 21.1 DEG. C (70 DEG. F)
VAPOR DENSITY: GREATER THAN 1 (AIR=1)
RELATIVE DENSITY: 0.81
SOLUBILITIES: INSOLUBLE IN WATER
PARTITION COEFFICIENT; N-OCTANOL/WATER: NOT ESTABLISHED
AUTOIGNITION TEMPERATURE: NOT ESTABLISHED
DECOMPOSITION TEMPERATURE: NOT ESTABLISHED
VISCOSITY: NOT ESTABLISHED
POUR POINT: NOT ESTABLISHED
| 10 - STABILITY AND REACTIVITY | |
REACTIVITY: NOT REACTIVE UNDER NORMAL CONDITIONS
CHEMICAL STABILITY: STABLE
POSSIBILITY OF HAZARDOUS REACTIONS:
MAY REACT WITH STRONG OXIDIZERS GENERATING HEAT.
CONDITIONS TO AVOID:
AVOID HEAT, SPARKS, FLAMES AND OTHER SOURCES OF IGNITION. DO NOT PUNCTURE
OR INCINERATE CONTAINERS.
INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS:
CARBON MONOXIDE, CARBON DIOXIDE, SILICON OXIDES, FORMALDEHYDE, SMOKE, FUMES
AND UNBURNED HYDROCARBONS.
| 11 - TOXICOLOGICAL INFORMATION | |
SYMPTOMS OF OVEREXPOSURE:
INHALATION:
HIGH CONCENTRATIONS MAY CAUSE NASAL AND RESPIRATORY IRRITATION AND CENTRAL
NERVOUS SYSTEM EFFECTS SUCH AS HEADACHE, DIZZINESS AND NAUSEA. INTENTIONAL
ABUSE MAY BE HARMFUL OR FATAL.
SKIN CONTACT:
MAY CAUSE SKIN IRRITATION WITH SHORT-TERM EXPOSURE WITH REDNESS, ITCHING
AND BURNING OF THE SKIN. PROLONGED AND/OR REPEATED CONTACT MAY PRODUCE
DEFATTING AND POSSIBLE DERMATITIS. REPEATED CONTACT MAY CAUSE AN ALLERGIC
SKIN REACTION AND/OR A PHOTOSENSITIZATION (SENSITIVITY TO SUNLIGHT).
EYE CONTACT:
CONTACT MAY BE IRRITATING TO EYES. MAY CAUSE REDNESS, STINGING, SWELLING
AND TEARING.
INGESTION:
THIS PRODUCT HAS LOW ORAL TOXICITY. IF SWALLOWED, THIS MATERIAL MAY CAUSE
IRRITATION OF THE MOUTH, THROAT AND ESOPHAGUS. SWALLOWING MAY CAUSE
GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING, DIARRHEA, DIZZINESS,
DROWSINESS, LOSS OF CONSCIOUSNESS, DELIRIUM AND OTHER CENTRAL NERVOUS
SYSTEM EFFECTS. THIS PRODUCT IS AN ASPIRATION HAZARD. IF SWALLOWED, CAN
ENTER THE LUNGS AND MAY CAUSE CHEMICAL PNEUMONITIS, SEVERE LUNG DAMAGE
AND DEATH.
CHRONIC EFFECTS: NONE EXPECTED.
CARCINOGEN STATUS:
NONE OF THE COMPONENTS ARE LISTED AS A CARCINOGEN OR SUSPECT CARCINOGEN BY
IARC, NTP, ACGIH OR OSHA.
REPRODUCTIVE TOXICITY:
NONE OF THE COMPONENTS IS CONSIDERED A REPRODUCTIVE HAZARD.
NUMERICAL MEASURES OF TOXICITY:
THE ORAL TOXICITY OF THIS PRODUCT IS ESTIMATED TO BE GREATER THAN 5,000
MG/KG BASED ON AN ASSESSMENT OF THE INGREDIENTS. THIS PRODUCT IS NOT
CLASSIFIED AS TOXIC BY ESTABLISHED CRITERIA. IT IS AN ASPIRATION HAZARD.
| 12 - ECOLOGICAL INFORMATION | |
ECOTOXICITY:
NO SPECIFIC AQUATIC TOXICITY DATA IS CURRENTLY AVAILABLE; HOWEVER
COMPONENTS OF THIS PRODUCT ARE NOT EXPECTED TO BE HARMFUL TO AQUATIC
ORGANISMS
PERSISTENCE AND DEGRADABILITY:
THE MAJORITY OF COMPONENTS ARE READILY BIODEGRADABLE.
BIOACCUMULATIVE POTENTIAL:
BIOACCUMULATION IS NOT EXPECTED BASED ON AN ASSESSMENT OF THE INGREDIENTS.
MOBILITY IN SOIL: NO DATA AVAILABLE
OTHER ADVERSE EFFECTS: NONE KNOWN
| 13 - DISPOSAL CONSIDERATIONS | |
IF THIS PRODUCT BECOMES A WASTE, IT WOULD BE EXPECTED TO MEET THE CRITERIA
OF A RCRA IGNITABLE HAZARDOUS WASTE (D001). HOWEVER, IT IS THE
RESPONSIBILITY OF THE GENERATOR TO DETERMINE AT THE TIME OF DISPOSAL THE
PROPER CLASSIFICATION AND METHOD OF DISPOSAL. DO NOT PUNCTURE OR INCINERATE
CONTAINERS, EVEN EMPTY. DISPOSE IN ACCORDANCE WITH FEDERAL, STATE, AND
LOCAL REGULATIONS.
| 14 - TRANSPORTATION INFORMATION | |
DOT SURFACE SHIPPING DESCRIPTION: UN1950, AEROSOLS, 2.1 LTD. QTY
(NOTE: SHIPPING PAPERS ARE NOT REQUIRED FOR LIMITED QUANTITIES UNLESS
TRANSPORTED BY AIR OR VESSEL - EACH PACKAGE MUST BE MARKED WITH THE LIMITED
QUANTITY MARK)
IMDG SHIPPING DESCRIPTION: UN1950, AEROSOLS, 2.1, LTD QTY
ICAO SHIPPING DESCRIPTION: UN1950, AEROSOLS, FLAMMABLE, 2.1
NOTE:
WD-40 COMPANY DOES NOT TEST AEROSOL CANS TO ASSURE THAT THEY MEET THE
PRESSURE AND OTHER REQUIREMENTS FOR TRANSPORT BY AIR. WE DO NOT RECOMMEND
THAT OUR AEROSOL PRODUCTS BE TRANSPORTED BY AIR.
| 15 - REGULATORY INFORMATION | |
U.S. FEDERAL REGULATIONS:
CERCLA 103 REPORTABLE QUANTITY:
THIS PRODUCT IS NOT SUBJECT TO CERCLA REPORTING REQUIREMENTS, HOWEVER, OIL
SPILLS ARE REPORTABLE TO THE NATIONAL RESPONSE CENTER UNDER THE CLEAN WATER
ACT AND MANY STATES HAVE MORE STRINGENT RELEASE REPORTING REQUIREMENTS.
REPORT SPILLS REQUIRED UNDER FEDERAL, STATE AND LOCAL REGULATIONS.
SARA TITLE III:
HAZARD CATEGORY FOR SECTION 311/312:
ACUTE HEALTH, FIRE HAZARD, SUDDEN RELEASE OF PRESSURE
SECTION 313 TOXIC CHEMICALS:
THIS PRODUCT CONTAINS THE FOLLOWING CHEMICALS SUBJECT TO SARA TITLE III
SECTION 313 REPORTING REQUIREMENTS: NONE
SECTION 302 EXTREMELY HAZARDOUS SUBSTANCES (TPQ): NONE
EPA TOXIC SUBSTANCES CONTROL ACT (TSCA) STATUS:
ALL OF THE COMPONENTS OF THIS PRODUCT ARE LISTED ON THE TSCA INVENTORY.
CALIFORNIA SAFE DRINKING WATER AND TOXIC ENFORCEMENT ACT (PROPOSITION 65):
THIS PRODUCT DOES NOT REQUIRE A CALIFORNIA PROPOSITION 65 WARNING.
VOC REGULATIONS:
THIS PRODUCT COMPLIES WITH THE CONSUMER PRODUCT VOC LIMITS OF CARB, THE US
EPA AND STATES ADOPTING THE OTC VOC RULES.
CANADIAN ENVIRONMENTAL PROTECTION ACT:
ALL OF THE INGREDIENTS ARE LISTED ON THE CANADIAN DOMESTIC SUBSTANCES LIST,
THE CANADIAN NON-DOMESTIC SUBSTANCES LIST OR EXEMPT FROM NOTIFICATION
CANADIAN WHMIS CLASSIFICATION:
CLASS A (COMPRESSED GAS), CLASS B-5 (FLAMMABLE AEROSOL), CLASS D-2-B (TOXIC
MATERIAL CAUSING OTHER TOXIC EFFECTS)
THIS MSDS HAS BEEN PREPARED ACCORDING TO THE CRITERIA OF THE CONTROLLED
PRODUCTS REGULATION (CPR) AND THE MSDS CONTAINS ALL OF THE INFORMATION
REQUIRED BY THE CPR.
| 16 - OTHER INFORMATION | |
HMIS HAZARD RATING:
HEALTH 1 (SLIGHT HAZARD)
FIRE HAZARD 4 (SEVERE HAZARD)
PHYSICAL HAZARD 0 (MINIMAL HAZARD)
REVISION DATE: JULY 18, 2018
SUPERSEDES: JUNE 16, 2015
REVISION SUMMARY: ADDRESS AND TELEPHONE NUMBER UPDATE IN SECTION 1.
PREPARED BY:
INDUSTRIAL HEALTH & SAFETY CONSULTANTS, INC.
SHELTON, CT
USA
REVIEWED BY:
I. KOWALSKI
REGULATORY AFFAIRS MANAGER
4090100/NO.0015004