| Common Name: | PROSEAL GAS TANK & RADIATOR REPAIR .07 O - RESIN, PROSEAL GAS TANK & RADIATOR RE |
| Manufacturer: | PACER TECHNOLOGY |
| SDS Revision Date: | 9/25/2017 |
| SDS Format: | GHS-US |
| Item Number(s): | 3HHH7 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
AC MARCA
PACER TECHNOLOGY
SAFETY DATA SHEET
DATE PREPARED: 05/28/2009
MSDS NO: 11720043_N62020 - RESIN
DATE-REVISED: 09/25/2017
REVISION NO: 3
| 1. PRODUCT AND COMPANY IDENTIFICATION |  |
PRODUCT DESCRIPTION: PROSEAL GAS TANK & RADIATOR REPAIR .07 O - RESIN
MANUFACTURER:
PACER TECHNOLOGY
3281 E. GUASTI RD., SUITE 260
ONTARIO, CA 91761
EMERGENCY CONTACT: CHEMTREC
EMERGENCY PHONE: 800-424-9300
ALTERNATE EMERGENCY PHONE: 703-527-3887
PRODUCT STEWARDSHIP: 909-987-0550
24 HR. EMERGENCY TELEPHONE NUMBERS:
CHEMTREC: (800) 424-9300
| 2. HAZARDS IDENTIFICATION | |
GHS CLASSIFICATIONS:
HEALTH:
SKIN CORROSION/IRRITATION, CATEGORY 2
SERIOUS EYE DAMAGE/IRRITATION, CATEGORY 2B
SKIN SENSITIZATION, CATEGORY 1
GHS LABEL ELEMENTS:
NOTE:
IF THIS PRODUCT IS A CONSUMER PRODUCT IT IS LABELED IN ACCORDANCE WITH THE
CONSUMER PRODUCT SAFETY COMMISSION REGULATIONS AND NOT OSHA REGULATIONS.
THE REQUIREMENTS FOR THE LABELING OF CONSUMER PRODUCTS TAKE PRECEDENCE OVER
OSHA LABELING SO THE ACTUAL PRODUCT LABEL WILL NOT CONTAIN THE OSHA LABEL
ELEMENTS SHOWN BELOW ON THIS SDS.
EXCLAMATION MARK
SIGNAL WORD: WARNING
HAZARD STATEMENTS:
H315 + H320: CAUSES SKIN AND EYE IRRITATION.
H317: MAY CAUSE AN ALLERGIC SKIN REACTION.
PRECAUTIONARY STATEMENT(S):
PREVENTION:
P261: AVOID BREATHING DUST/FUME/GAS/MIST/VAPOURS/SPRAY.
P264: WASH SKIN AND HANDS THOROUGHLY AFTER HANDLING.
P271: USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA.
P272:
CONTAMINATED WORK CLOTHING SHOULD NOT BE ALLOWED OUT OF THE WORKPLACE.
P280:
WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION.
RESPONSE:
P302+352:
IF ON SKIN: WASH WITH PLENTY OF SOAP AND WATER.
P305+P351+P338:
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
P333+P313:
IF SKIN IRRITATION OR RASH OCCURS: GET MEDICAL ADVICE/ATTENTION.
P337+P313:
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
P362: TAKE OFF CONTAMINATED CLOTHING.
P363: WASH CONTAMINATED CLOTHING BEFORE REUSE.
STORAGE:
P403+P233: STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED.
DISPOSAL:
P501:
DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL, STATE, AND LOCAL
REGULATIONS.
| 3. COMPOSITION / INFORMATION ON INGREDIENTS | |
CHEMICAL NAME WT.% CAS
EPOXY RESIN (BISPHENOL A) 30 - 60 25068-38-6
CHLORINATED PARAFFINS 1 - 5 63449-39-8
CRYSTALLINE SILICA 0.1 - 1 14808-60-7
| 4. FIRST AID MEASURES | |
EYES:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER, OCCASIONALLY LIFTING THE UPPER
AND LOWER EYELIDS. CHECK FOR AND REMOVE ANY CONTACT LENSES. CONTINUE TO
RINSE FOR AT LEAST 10 MINUTES. GET MEDICAL ATTENTION.
SKIN:
WASH WITH PLENTY OF SOAP AND WATER. REMOVE CONTAMINATED CLOTHING AND SHOES.
WASH CONTAMINATED CLOTHING THOROUGHLY WITH WATER BEFORE REMOVING IT, OR
WEAR GLOVES. CONTINUE TO RINSE FOR AT LEAST 10 MINUTES. GET MEDICAL
ATTENTION. IN THE EVENT OF ANY COMPLAINTS OR SYMPTOMS, AVOID FURTHER
EXPOSURE. WASH CLOTHING BEFORE REUSE. CLEAN SHOES THOROUGHLY BEFORE REUSE.
INGESTION:
WASH OUT MOUTH WITH WATER. REMOVE DENTURES IF ANY. REMOVE VICTIM TO FRESH
AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR BREATHING. IF MATERIAL
HAS BEEN SWALLOWED AND THE EXPOSED PERSON IS CONSCIOUS, GIVE SMALL
QUANTITIES OF WATER TO DRINK. STOP IF THE EXPOSED PERSON FEELS SICK AS
VOMITING MAY BE DANGEROUS. IF VOMITING OCCURS, THE HEAD SHOULD BE KEPT LOW
SO THAT VOMIT DOES NOT ENTER THE LUNGS. GET MEDICAL ATTENTION IF ADVERSE
HEALTH EFFECTS PERSIST OR ARE SEVERE. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. IF UNCONSCIOUS, PLACE IN RECOVERY POSITION AND GET
MEDICAL ATTENTION IMMEDIATELY. MAINTAIN AN OPEN AIRWAY. LOOSEN TIGHT
CLOTHING SUCH AS A COLLAR, TIE, BELT, OR WAISTBAND.
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. IF NOT BREATHING, IF BREATHING IS IRREGULAR OR IF RESPIRATORY
ARREST OCCURS, PROVIDE ARTIFICIAL RESPIRATION OR OXYGEN BY TRAINED
PERSONNEL. IT MAY BE DANGEROUS TO THE PERSON PROVIDING AID TO GIVE
MOUTH-TO-MOUTH RESUSCITATION. GET MEDICAL ATTENTION IF ADVERSE HEALTH
EFFECTS PERSIST OR ARE SEVERE. IF UNCONSCIOUS, PLACE IN RECOVERY POSITION
AND GET MEDICAL ATTENTION IMMEDIATELY. MAINTAIN OPEN AIRWAY. LOOSEN TIGHT
CLOTHING SUCH AS COLLAR, TIE, BELT, OR WAISTBAND. IN CASE OF INHALATION OF
DECOMPOSITION PRODUCTS IN A FIRE, SYMPTOMS MAY BE DELAYED. THE EXPOSED
PERSON MAY NEED TO BE KEPT UNDER MEDICAL SURVEILLANCE FOR 48 HOURS.
SIGNS AND SYMPTOMS OF OVEREXPOSURE:
EYES: CAUSES SERIOUS EYE IRRITATION.
SKIN: CAUSES SKIN IRRITATION. MAY CAUSE AN ALLERGIC SKIN REACTION.
SKIN ABSORPTION:
THIS MATERIAL IS A WATER POLLUTANT AND SHOULD BE PREVENTED FROM
CONTAMINATING SOIL OR FROM ENTERING SEWAGE AND DRAINAGE SYSTEMS
AND BODIES OF WATER.
INGESTION: IRRITATING TO MOUTH, THROAT, AND STOMACH.
INHALATION: NO SPECIFIC DATA.
NOTES TO PHYSICIAN:
IN CASE OF INHALATION OF DECOMPOSITION PRODUCTS IN A FIRE, SYMPTOMS MAY BE
DELAYED. THE EXPOSED PERSON MAY NEED TO BE KEPT UNDER MEDICAL SURVEILLANCE
FOR 48 HOURS.
| 5. FIRE FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
USE AN EXTINGUISHING AGENT SUITABLE FOR THE SURROUNDING FIRE.
HAZARDOUS COMBUSTION PRODUCTS: NONE KNOWN
FIRE FIGHTING PROCEDURES:
PROMPTLY ISOLATE THE SCENE BY REMOVING ALL PERSONS FROM THE VICINITY OF
THE INCIDENT IF THERE IS A FIRE. NO ACTION SHALL BE TAKEN INVOLVING ANY
PERSONAL RISK OR WITHOUT SUITABLE TRAINING.
FIRE FIGHTING EQUIPMENT:
AS IN ANY FIRE, WEAR SELF-CONTAINED BREATHING APPARATUS PRESSURE-DEMAND,
(MSHA/NIOSH APPROVED OR EQUIVALENT) AND FULL PROTECTIVE GEAR.
FIRE EXPLOSION: NONE KNOWN.
SENSITIVE TO STATIC DISCHARGE: NOT APPLICABLE.
SENSITIVITY TO IMPACT: NOT APPLICABLE.
HAZARDOUS DECOMPOSITION PRODUCTS:
CARBON DIOXIDE, CARBON MONOXIDE, HALOGENATED COMPOUNDS, CARBONYL HALIDES,
METAL OXIDE(S).
| 6. ACCIDENTAL RELEASE MEASURES | |
SMALL SPILL: ABSORB LIQUID AND PLACE IN SEALED CONTAINER FOR DISPOSAL.
LARGE SPILL:
ABSORB THE LIQUID AND SCRUB THE AREA WITH DETERGENT AND WATER. AVOID RUNOFF
INTO STORM SEWERS AND DITCHES WHICH LEAD TO WATERWAYS.
ENVIRONMENTAL PRECAUTIONS:
WATER SPILL:
AVOID RUNOFF INTO STORM SEWERS AND DITCHES WHICH LEAD TO WATERWAYS.
LAND SPILL:
PREVENT CONTAMINATION OF SOIL, DRAINS AND SURFACE WATERS. DIKE AND CONTAIN
MATERIAL. SOAK UP RESIDUE WITH ABSORBENT (CLAY, SAND) MATERIALS AND DISPOSE
OF PROPERLY.
AIR SPILL:
THIS MATERIAL IS A WATER POLLUTANT AND SHOULD BE PREVENTED FROM
CONTAMINATING SOIL OR FROM ENTERING SEWAGE AND DRAINAGE SYSTEMS AND BODIES
OF WATER.
GENERAL PROCEDURES:
IMPLEMENT CLEANUP PROCEDURES.
IF IN PUBLIC AREA, KEEP PUBLIC AWAY AND ADVISE AUTHORITIES.
RECOVER BY PUMPING (USE AN EXPLOSION PROOF OR HAND PUMP) OR WITH A
SUITABLE ABSORBENT.
| 7. HANDLING AND STORAGE | |
GENERAL PROCEDURES:
USE WITH ADEQUATE VENTILATION. AVOID CONTACT WITH EYES, SKIN AND CLOTHING.
HANDLING:
AVOID BREATHING (DUST, VAPOR, MIST, GAS). AVOID CONTACT WITH SKIN, EYES AND
CLOTHING. KEEP CONTAINER CLOSED WHEN NOT IN USE.
STORAGE:
STORE IN TIGHTLY CLOSED CONTAINERS AT AMBIENT TEMPERATURE. PROTECT FROM
FREEZING.
STORAGE TEMPERATURE:
SUGGESTED STORAGE CONDITIONS: LESS THAN 77F/25C. PROTECT FROM FREEZING.
LOADING TEMPERATURE: NOT ESTABLISHED
LOADING/UNLOADING VISCOSITY: NOT ESTABLISHED
STORAGE PRESSURE:
PREVENT CONTAMINATION OF SOIL, DRAINS AND SURFACE WATERS. DIKE AND CONTAIN
MATERIAL. SOAK UP RESIDUE WITH ABSORBENT (CLAY, SAND) MATERIALS AND DISPOSE
OF PROPERLY.
ELECTROSTATIC ACCUMULATION HAZARD:
THIS MATERIAL IS A WATER POLLUTANT AND SHOULD BE PREVENTED FROM
CONTAMINATING SOIL OR FROM ENTERING SEWAGE AND DRAINAGE SYSTEMS AND BODIES
OF WATER.
| 8. EXPOSURE CONTROLS / PERSONAL PROTECTION | |
EXPOSURE GUIDELINES:
OSHA HAZARDOUS COMPONENTS (29 CFR 1910.1200):
CHEMICAL NAME EXPOSURE LIMITS
TYPE PPM MG/M3
CRYSTALLINE SILICA OSHA PEL TWA 250 MPP PPM [1] 10 MG/M3 [1]
STEL PPM MG/M3
ACGIH TLV TWA PPM 0.025 MG/M3
STEL PPM MG/M3
SUPPLIER OEL TWA NL PPM NL MG/M3
STEL NL PPM NL MG/M3
OSHA TABLE COMMENTS: 1. NL = NOT LISTED
ENGINEERING CONTROLS: USE ONLY IN A WELL VENTILATED AREA.
PERSONAL PROTECTIVE EQUIPMENT:
EYES AND FACE:
FOR NORMAL CONDITIONS, WEAR SAFETY GLASSES. WHERE THERE IS REASONABLE
PROBABILITY OF LIQUID CONTACT, WEAR SPLASH-PROOF GOGGLES.
SKIN: WEAR RUBBER GLOVES & APRON.
RESPIRATORY: USE ONLY IN A WELL VENTILATED AREA.
PROTECTIVE CLOTHING: LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
WORK HYGIENIC PRACTICES:
AVOID CONTACT WITH SKIN AND EYES. WASH THOROUGHLY AFTER HANDLING.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
PHYSICAL STATE: PASTE
ODOR: IRRITATING ODOR.
ODOR THRESHOLD: NO DATA AVAILABLE
APPEARANCE: GRAY PUTTY WITH EPOXY ODOR.
PH: NO DATA AVAILABLE
PERCENT VOLATILE: NO DATA AVAILABLE
FLASHPOINT AND METHOD: NO DATA AVAILABLE
AUTOIGNITION TEMPERATURE: NO DATA AVAILABLE
VAPOR PRESSURE: NO DATA AVAILABLE
VAPOR DENSITY: NO DATA AVAILABLE
BOILING POINT: NO DATA AVAILABLE
FREEZING POINT: NO DATA AVAILABLE
MELTING POINT: NO DATA AVAILABLE
POUR POINT: NO DATA AVAILABLE
THERMAL DECOMPOSITION: NO DATA AVAILABLE
SOLUBILITY IN WATER: NO DATA AVAILABLE
EVAPORATION RATE: NO DATA AVAILABLE
DENSITY: NO DATA AVAILABLE
SPECIFIC GRAVITY: NO DATA AVAILABLE
VISCOSITY: NO DATA AVAILABLE
MOLECULAR WEIGHT: NO DATA AVAILABLE
(VOC): NO DATA AVAILABLE
| 10. STABILITY AND REACTIVITY | |
REACTIVITY: YES
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR.
STABILITY: STABLE
CONDITIONS TO AVOID: AVOID TEMPERATURES ABOVE (300) F (148) C.
POSSIBILITY OF HAZARDOUS REACTIONS:
HAZARDOUS REACTIONS ARE POSSIBLE WHEN EXPOSED TO INCOMPATIBLE MATERIALS
SUCH AS NITRATES, CHLORINE, AMMONIA, STRONG OXIDIZERS, ALKALIS, AND ACIDS
HAZARDOUS DECOMPOSITION PRODUCTS:
CARBON MONOXIDE, ALDEHYDES, ACIDS AND OTHER ORGANIC SUBSTANCES MAY BE
FORMED DURING COMBUSTION (>500F) TEMPERATURE DEGRADATION.
INCOMPATIBLE MATERIALS:
STRONG ACIDS, OXIDIZING AGENTS, MINERAL AND ORGANIC BASES, AND ESPECIALLY
ALIPHATIC AMINES.
| 11. TOXICOLOGICAL INFORMATION | |
ACUTE TOXICITY:
CHEMICAL NAME ORAL LD50 (RAT) DERMAL LD50 (RABBIT)
EPOXY RESIN (BISPHENOL A) >2000 MG/KG (RAT) >2000 MG/KG (RAT)
CHLORINATED PARAFFINS 26100 MG/KG (RAT)
DERMAL LD50: NO DATA AVAILABLE
ORAL LD50: NO DATA AVAILABLE
INHALATION LC50: NO DATA AVAILABLE
CARCINOGENICITY:
CHEMICAL NAME NTP STATUS IARC STATUS
CRYSTALLINE SILICA 1 1
| 12. ECOLOGICAL INFORMATION | |
ENVIRONMENTAL DATA:
USE PRECAUTIONS TO AVOID RELEASE TO SEWERS/DRAINS/SURFACE WATER AND SOIL.
ECOTOXICOLOGICAL INFORMATION:
PREVENT CONTAMINATION OF SOIL, DRAINS AND SURFACE WATERS. DIKE AND CONTAIN
MATERIAL. SOAK UP RESIDUE WITH ABSORBENT (CLAY, SAND) MATERIALS AND DISPOSE
OF PROPERLY.
BIOACCUMULATION/ACCUMULATION:
PREVENT CONTAMINATION OF SOIL, DRAINS AND SURFACE WATERS. DIKE AND CONTAIN
MATERIAL. SOAK UP RESIDUE WITH ABSORBENT (CLAY, SAND) MATERIALS AND DISPOSE
OF PROPERLY.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL METHOD:
DISPOSE OF FOLLOWING ALL LOCAL AUTHORITY REQUIREMENTS FOR DISPOSAL.
FOR LARGE SPILLS:
DIKE AREA TO CONTAIN SPILL. TAKE PRECAUTIONS AS NECESSARY TO PREVENT
CONTAMINATION OF GROUND AND SURFACE WATERS. RECOVER SPILLED MATERIAL ON
ADSORBENT, SUCH AS SAWDUST OR VERMICULITE, AND SWEEP INTO CLOSED CONTAINERS
FOR DISPOSAL. AFTER ALL VISIBLE TRACES, INCLUDING IGNITIBLE VAPORS, HAVE
BEEN REMOVED THOROUGHLY WET VACUUM THE AREA. DO NOT FLUSH TO SEWER. IF AREA
OF SPILL IS POROUS, REMOVE AS MUCH CONTAMINATED EARTH AND GRAVEL, ETC. AS
NECESSARY AND PLACE IN CLOSED CONTAINERS FOR DISPOSAL.
PRODUCT DISPOSAL:
DISPOSE OF FOLLOWING ALL LOCAL AUTHORITY REQUIREMENTS FOR DISPOSAL.
EMPTY CONTAINER:
DISPOSE OF FOLLOWING ALL LOCAL AUTHORITY REQUIREMENTS FOR DISPOSAL.
| 14. TRANSPORT INFORMATION | |
DOT (DEPARTMENT OF TRANSPORTATION):
PROPER SHIPPING NAME: NOT RESTRICTED BY DOT
ROAD AND RAIL (ADR/RID):
PROPER SHIPPING NAME: NOT APPLICABLE.
AIR (ICAO/IATA):
SHIPPING NAME: NOT APPLICABLE.
VESSEL (IMO/IMDG):
SHIPPING NAME: NOT APPLICABLE.
CANADA TRANSPORT OF DANGEROUS GOODS:
SHIPPING NAME: NOT APPLICABLE.
| 15. REGULATORY INFORMATION | |
UNITED STATES:
SARA TITLE III (SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT):
FIRE: NO
PRESSURE GENERATING: NO
REACTIVITY: NO
ACUTE: YES
CHRONIC: NO
TSCA (TOXIC SUBSTANCE CONTROL ACT):
CHEMICAL NAME CAS
EPOXY RESIN (BISPHENOL A) 25068-38-6
CHLORINATED PARAFFINS 63449-39-8
CRYSTALLINE SILICA 14808-60-7
TSCA STATUS: ALL INGREDIENTS IN THIS MIXTURE ARE IN COMPLIANCE WITH TSCA.
CALIFORNIA PROPOSITION 65:
WARNING:
THIS PRODUCT CAN EXPOSE YOU TO CHEMICALS INCLUDING CRYSTALLINE SILICA,
WHICH IS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER, AND BISPHENOL A,
WHICH IS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE BIRTH DEFECTS OTHER
REPRODUCTIVE HARM. FOR MORE INFORMATION GO TO WWW.P65WARNINGS.CA.GOV.
CHEMICAL NAME WT.% LISTED
EPOXY RESIN (BISPHENOL A) 30 - 60 FEMALE REPRODUCTIVE
CRYSTALLINE SILICA 0.1 - 1 CANCER
| 16. OTHER INFORMATION | |
APPROVED BY: PACER TECHNOLOGY REGULATORY DEPARTMENT
PREPARED BY: PACER TECHNOLOGY REGULATORY DEPARTMENT
DATE-REVISED: 09/25/2017
REVISION SUMMARY: THIS MSDS REPLACES THE 12/10/2014 MSDS.
REVISED:
SECTION 1:
APPROVED BY, DATE ISSUED, DATE-REVISED, 24 HR. EMERGENCY TELEPHONE NUMBERS,
MSDS NO, PREPARED BY, TITLE.
SECTION 2:
SECTION 3: WT.%.
SECTION 4:
EYES, INGESTION, INHALATION, SIGNS AND SYMPTOMS OF OVEREXPOSURE (INGESTION,
INHALATION, SKIN), SKIN.
SECTION 5:
EXPLOSION HAZARDS, EXTINGUISHING MEDIA, FIRE FIGHTING PROCEDURES, FLAMMABLE
CLASS, HAZARDOUS DECOMPOSITION PRODUCTS.
SECTION 9:
AUTOIGNITION TEMPERATURE, BOILING POINT, DENSITY, EVAPORATION RATE,
FLASHPOINT AND METHOD, FREEZING POINT, MELTING POINT, MOLECULAR WEIGHT,
ODOR THRESHOLD, PERCENT VOLATILE, PH, SOLUBILITY IN WATER, SPECIFIC
GRAVITY, VAPOR DENSITY, VAPOR PRESSURE, VISCOSITY, (VOC), THERMAL
DECOMPOSITION,.
SECTION 11:
ACUTE (DERMAL LD50 (RABBIT), SKIN ABSORPTION, ORAL LD50 (RAT), INHALATION
LC50 (RAT)), CARCINOGENICITY.
SECTION 13: EMPTY CONTAINER, PRODUCT DISPOSAL.
SECTION 15: CALIFORNIA PROPOSITION 65, WHMIS CLASS.
HMIS RATING:
HEALTH 2
FLAMMABILITY 1
PHYSICAL HAZARD 0
PERSONAL PROTECTION
NFPA CODES:
2
1
0
MANUFACTURER DISCLAIMER:
TO THE BEST OF OUR KNOWLEDGE, THE INFORMATION CONTAINED HEREIN IS ACCURATE.
HOWEVER, PACER TECHNOLOGY DOES NOT ASSUME ANY LIABILITY FOR THE ACCURACY OR
COMPLETENESS OF THE INFORMATION CONTAINED HEREIN. FINAL DETERMINATION OF
SUITABILITY OF ANY MATERIAL IS THE SOLE RESPONSIBILITY OF THE USER. ALL
MATERIALS MAY PRESENT UNKNOWN HAZARDS AND SHOULD BE USED WITH CAUTION.
ALTHOUGH CERTAIN HAZARDS ARE DESCRIBED HEREIN, WE CANNOT GUARANTEE THAT
THESE ARE THE ONLY HAZARDS WHICH EXIST.
AC MARCA
PACER TECHNOLOGY
SAFETY DATA SHEET
DATE PREPARED: 05/28/2009
MSDS NO: 11720043_N62020 - HARDENER
DATE-REVISED: 09/25/2017
REVISION NO: 3
| 1. PRODUCT AND COMPANY IDENTIFICATION | |
PRODUCT DESCRIPTION: PROSEAL GAS TANK & RADIATOR REPAIR .07 O - HARDENER
MANUFACTURER:
PACER TECHNOLOGY
3281 E. GUASTI RD., SUITE 260
ONTARIO, CA 91761
EMERGENCY CONTACT: CHEMTREC
EMERGENCY PHONE: 800-424-9300
ALTERNATE EMERGENCY PHONE: 703-527-3887
PRODUCT STEWARDSHIP: 909-987-0550
| 2. HAZARDS IDENTIFICATION | |
GHS CLASSIFICATIONS:
HEALTH:
SKIN IRRITATION, CATEGORY 2
EYE IRRITATION, CATEGORY 2
SKIN SENSITIZATION, CATEGORY 1
TARGET ORGAN TOXICITY (SINGLE EXPOSURE), CATEGORY 3
GHS LABEL ELEMENTS:
NOTE:
IF THIS PRODUCT IS A CONSUMER PRODUCT IT IS LABELED IN ACCORDANCE WITH THE
CONSUMER PRODUCT SAFETY COMMISSION REGULATIONS AND NOT OSHA REGULATIONS.
THE REQUIREMENTS FOR THE LABELING OF CONSUMER PRODUCTS TAKE PRECEDENCE OVER
OSHA LABELING SO THE ACTUAL PRODUCT LABEL WILL NOT CONTAIN THE OSHA LABEL
ELEMENTS SHOWN BELOW ON THIS SDS.
EXCLAMATION MARK
SIGNAL WORD: WARNING
HAZARD STATEMENTS:
H315: CAUSES SKIN IRRITATION.
H317: MAY CAUSE AN ALLERGIC SKIN REACTION.
H319: CAUSES SERIOUS EYE IRRITATION.
H335: MAY CAUSE RESPIRATORY IRRITATION.
PRECAUTIONARY STATEMENT(S):
PREVENTION:
5468C4VS: CONTAINS EPOXY CONSTITUENTS. MAY PRODUCE AN ALLERGIC REACTION.
P261: AVOID BREATHING DUST/FUME/GAS/MIST/VAPOURS/SPRAY.
P280:
WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION.
P271: USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA.
RESPONSE:
P302+352:
IF ON SKIN: WASH WITH PLENTY OF SOAP AND WATER.
P304+P340:
IF INHALED: REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING.
P305+P351+P338:
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
P333+P313:
IF SKIN IRRITATION OR RASH OCCURS: GET MEDICAL ADVICE/ATTENTION.
P309+P311:
IF EXPOSED OR IF YOU FEEL UNWELL: CALL A POISON CENTER OR DOCTOR/PHYSICIAN.
STORAGE:
P403+P233: STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED.
DISPOSAL:
P501:
DISPOSE OF IN A MANNER CONSISTENT WITH FEDERAL, STATE, AND LOCAL
REGULATIONS.
| 3. COMPOSITION / INFORMATION ON INGREDIENTS | |
CHEMICAL NAME WT.% CAS
FATTY ACIDS, C18-UNSATD., DIMERS, REACTION 10 - 30 68410-23-1
PRODUCTS WITH POLYETHYLENEPOLYAMINES
CRYSTALLINE SILICA 0.1 - 1 14808-60-7
| 4. FIRST AID MEASURES | |
EYES: FLUSH EYE WITH WATER FOR 15 MINUTES. GET MEDICAL ATTENTION.
SKIN:
IMMEDIATELY WASH SKIN WITH SOAP AND PLENTY OF WATER. REMOVE CONTAMINATED
CLOTHING. GET MEDICAL ATTENTION IF SYMPTOMS REOCCUR. WASH CLOTHING BEFORE
REUSE.
INGESTION: DO NOT INDUCE VOMITING. CONTACT PHYSICIAN AT ONCE.
INHALATION:
REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. GET MEDICAL ATTENTION.
SIGNS AND SYMPTOMS OF OVEREXPOSURE:
EYES: CAUSES EYE IRRITATION.
SKIN: CONTACT CAUSES SKIN IRRITATION.
SKIN ABSORPTION:
PREVENT CONTAMINATION OF SOIL, DRAINS AND SURFACE WATERS. DIKE AND CONTAIN
MATERIAL. SOAK UP RESIDUE WITH ABSORBENT (CLAY, SAND) MATERIALS AND DISPOSE
OF PROPERLY.
INGESTION:
INGESTION OF THIS MATERIAL CAN CAUSE MOUTH, THROAT, ESOPHAGEAL, AND
GASTROINTESTINAL TRACT IRRITATION.
INHALATION:
PROLONGED OR EXCESSIVE INHALATION MAY CAUSE RESPIRATORY TRACT IRRITATION.
ACUTE EFFECTS: IRRITATING TO EYES, RESPIRATORY SYSTEM AND SKIN.
CHRONIC EFFECTS:
AVOID CONTACT WITH EYES; MAY CAUSE REDNESS, IRRITATION AND CONJUNCTIVITIS.
NOTES TO PHYSICIAN:
IN CASE OF INHALATION OF DECOMPOSITION PRODUCTS IN A FIRE, SYMPTOMS MAY BE
DELAYED. THE EXPOSED PERSON MAY NEED TO BE KEPT UNDER MEDICAL SURVEILLANCE
FOR 48 HOURS.
| 5. FIRE FIGHTING MEASURES | |
FLAMMABLE CLASS: NOT FLAMMABLE
EXTINGUISHING MEDIA:
USE ALCOHOL FOAM, CARBON DIOXIDE, OR WATER SPRAY WHEN FIGHTING FIRES
INVOLVING THIS MATERIAL.
HAZARDOUS COMBUSTION PRODUCTS: CAN BURN IN FIRE, RELEASING TOXIC VAPORS.
EXPLOSION HAZARDS:
CONTAINERS MAY RUPTURE VIOLENTLY UNDER FIRE TEMPERATURES. COOL CONTAINERS
WITH WATER IF EXPOSED TO FIRE CONDITIONS.
FIRE FIGHTING PROCEDURES:
USE WATER SPRAY TO KEEP FIRE-EXPOSED CONTAINERS COOL AND TO KNOCK DOWN
VAPORS WHICH MAY RESULT FROM PRODUCT DECOMPOSITION.
FIRE FIGHTING EQUIPMENT:
AS IN ANY FIRE, WEAR SELF-CONTAINED BREATHING APPARATUS PRESSURE-DEMAND,
(MSHA/NIOSH APPROVED OR EQUIVALENT) AND FULL PROTECTIVE GEAR.
FIRE EXPLOSION:
PRODUCT IS FLAMMABLE. RESPIRATORY PROTECTION REQUIRED FOR FIREFIGHTERS.
STAY UPWIND FROM FIRE IF POSSIBLE WHEN FIRE-FIGHTING.
HAZARDOUS DECOMPOSITION PRODUCTS:
COMBUSTIBLE BY-PRODUCTS OF CARBON MONOXIDE/DIOXIDE AND NITROGEN OXIDES.
| 6. ACCIDENTAL RELEASE MEASURES | |
SMALL SPILL: ABSORB LIQUID AND PLACE IN SEALED CONTAINER FOR DISPOSAL.
LARGE SPILL:
DIKE AREA TO CONTAIN SPILL. TAKE PRECAUTIONS AS NECESSARY TO PREVENT
CONTAMINATION OF GROUND AND SURFACE WATERS. RECOVER SPILLED MATERIAL ON
ADSORBENT, SUCH AS SAWDUST OR VERMICULITE, AND SWEEP INTO CLOSED CONTAINERS
FOR DISPOSAL. AFTER ALL VISIBLE TRACES, INCLUDING IGNITIBLE VAPORS, HAVE
BEEN REMOVED THOROUGHLY WET VACUUM THE AREA. DO NOT FLUSH TO SEWER. IF AREA
OF SPILL IS POROUS, REMOVE AS MUCH CONTAMINATED EARTH AND GRAVEL, ETC. AS
NECESSARY AND PLACE IN CLOSED CONTAINERS FOR DISPOSAL.
ENVIRONMENTAL PRECAUTIONS:
WATER SPILL:
PREVENT CONTAMINATION OF SOIL, DRAINS AND SURFACE WATERS. DIKE AND CONTAIN
MATERIAL. SOAK UP RESIDUE WITH ABSORBENT (CLAY, SAND) MATERIALS AND DISPOSE
OF PROPERLY.
LAND SPILL:
PREVENT FROM ENTERING INTO SOIL, DITCHES, SEWERS, WATERWAYS AND/OR GROUND
WATER. SEE SECTION 12, ECOLOGICAL INFORMATION.
AIR SPILL: NONE KNOWN
GENERAL PROCEDURES:
POLYMERIZE WITH WATER. INCREASE VENTILATION TO AREA. SOLID MATERIAL MAY BE
SCRAPED FROM SURFACE.
SPECIAL PROTECTIVE EQUIPMENT:
USE PLASTIC/RUBBER GLOVES, CHEMICAL SPLASH GOGGLES OR SAFETY GLASSES WITH
SIDE SHIELDS.
| 7. HANDLING AND STORAGE | |
GENERAL PROCEDURES:
USE WITH ADEQUATE VENTILATION. AVOID CONTACT WITH EYES, SKIN AND CLOTHING.
HANDLING:
AVOID BREATHING (DUST, VAPOR, MIST, GAS). AVOID CONTACT WITH SKIN, EYES AND
CLOTHING. KEEP CONTAINER CLOSED WHEN NOT IN USE.
STORAGE:
STORE IN A COOL PLACE IN ORIGINAL CONTAINER AND PROTECT FROM SUNLIGHT. KEEP
AWAY FROM SOURCES OF IGNITION.
STORAGE TEMPERATURE: AMBIENT ROOM TEMPERATURE (70F/21C).
LOADING TEMPERATURE:
PREVENT CONTAMINATION OF SOIL, DRAINS AND SURFACE WATERS. DIKE AND CONTAIN
MATERIAL. SOAK UP RESIDUE WITH ABSORBENT (CLAY, SAND) MATERIALS AND DISPOSE
OF PROPERLY.
LOADING/UNLOADING VISCOSITY:
PREVENT CONTAMINATION OF SOIL, DRAINS AND SURFACE WATERS. DIKE AND CONTAIN
MATERIAL. SOAK UP RESIDUE WITH ABSORBENT (CLAY, SAND) MATERIALS AND DISPOSE
OF PROPERLY.
STORAGE PRESSURE:
PREVENT CONTAMINATION OF SOIL, DRAINS AND SURFACE WATERS. DIKE AND CONTAIN
MATERIAL. SOAK UP RESIDUE WITH ABSORBENT (CLAY, SAND) MATERIALS AND DISPOSE
OF PROPERLY.
ELECTROSTATIC ACCUMULATION HAZARD:
THIS MATERIAL IS A WATER POLLUTANT AND SHOULD BE PREVENTED FROM
CONTAMINATING SOIL OR FROM ENTERING SEWAGE AND DRAINAGE SYSTEMS AND BODIES
OF WATER.
| 8. EXPOSURE CONTROLS / PERSONAL PROTECTION | |
EXPOSURE GUIDELINES:
OSHA HAZARDOUS COMPONENTS (29 CFR 1910.1200):
CHEMICAL NAME EXPOSURE LIMITS
TYPE PPM MG/M3
CRYSTALLINE SILICA OSHA PEL TWA 250 MPP PPM [1] 10 MG/M3 [1]
STEL PPM MG/M3
ACGIH TLV TWA PPM 0.025 MG/M3
STEL PPM MG/M3
SUPPLIER OEL TWA NL PPM NL MG/M3
STEL NL PPM NL MG/M3
OSHA TABLE COMMENTS: 1. NL = NOT LISTED
ENGINEERING CONTROLS: USE ONLY IN A WELL VENTILATED AREA.
PERSONAL PROTECTIVE EQUIPMENT:
EYES AND FACE:
FOR NORMAL CONDITIONS, WEAR SAFETY GLASSES. WHERE THERE IS REASONABLE
PROBABILITY OF LIQUID CONTACT, WEAR SPLASH-PROOF GOGGLES.
SKIN:
WEAR CHEMICAL RESISTANT GLOVES (BUNA-N OR POLYVINYL ALCOHOL) AND APRON TO
PROTECT SKIN AND CLOTHING.
RESPIRATORY:
USE ONLY IN A WELL-VENTILATED AREA. IN CASE OF INSUFFICIENT VENTILATION,
WEAR SUITABLE RESPIRATORY EQUIPMENT.
RECOMMENDED:
FULL-FACE NIOSH-APPROVED RESPIRATOR WITH ORGANIC VAPOR CARTRIDGE.
PROTECTIVE CLOTHING:
WEAR PROTECTIVE CLOTHING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
WORK HYGIENIC PRACTICES:
AVOID CONTACT WITH SKIN AND EYES. WASH THOROUGHLY AFTER HANDLING.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
PHYSICAL STATE: PASTE
ODOR: NO DATA AVAILABLE
ODOR THRESHOLD: NO DATA AVAILABLE
APPEARANCE: BLACK PUTTY WITH EPOXY ODOR.
COLOR: NO DATA AVAILABLE
PH: NO DATA AVAILABLE
PERCENT VOLATILE: NO DATA AVAILABLE
FLASHPOINT AND METHOD: NO DATA AVAILABLE
AUTOIGNITION TEMPERATURE: NO DATA AVAILABLE
VAPOR PRESSURE: NO DATA AVAILABLE
BOILING POINT: NO DATA AVAILABLE
FREEZING POINT: NO DATA AVAILABLE
MELTING POINT: NO DATA AVAILABLE
POUR POINT: NO DATA AVAILABLE
THERMAL DECOMPOSITION: NO DATA AVAILABLE
SOLUBILITY IN WATER: NO DATA AVAILABLE
EVAPORATION RATE: NO DATA AVAILABLE
DENSITY: NO DATA AVAILABLE
SPECIFIC GRAVITY: NO DATA AVAILABLE
VISCOSITY: NO DATA AVAILABLE
MOLECULAR WEIGHT: NO DATA AVAILABLE
(VOC): NO DATA AVAILABLE
| 10. STABILITY AND REACTIVITY | |
REACTIVITY: YES
HAZARDOUS POLYMERIZATION: NO
STABILITY: STABLE
CONDITIONS TO AVOID: AVOID STORAGE NEAR LARGE MASSES OF EPOXY RESINS.
POSSIBILITY OF HAZARDOUS REACTIONS:
UNDER NORMAL CONDITIONS OF STORAGE AND USE, HAZARDOUS REACTIONS WILL NOT
OCCUR.
HAZARDOUS DECOMPOSITION PRODUCTS:
COMBUSTIBLE BY-PRODUCTS OF CARBON MONOXIDE/DIOXIDE AND NITROGEN OXIDES.
INCOMPATIBLE MATERIALS:
AVOID STRONG OXIDIZING AGENTS AND AMINES ESPECIALLY WHEN HOT.
| 11. TOXICOLOGICAL INFORMATION | |
ACUTE TOXICITY:
DERMAL LD50: NO DATA AVAILABLE
ORAL LD50: NO DATA AVAILABLE
INHALATION LC50: NO DATA AVAILABLE.
SERIOUS EYE DAMAGE/IRRITATION:
IRRITATING TO EYES, RESPIRATORY SYSTEM AND SKIN.
RESPIRATORY OR SKIN SENSITIZATION:
IRRITATING TO SKIN. MAY CAUSE ALLERGIC SKIN REACTION WITH PROLONGED
CONTACT.
CARCINOGENICITY:
CHEMICAL NAME NTP STATUS IARC STATUS
CRYSTALLINE SILICA 1 1
| 12. ECOLOGICAL INFORMATION | |
ENVIRONMENTAL DATA:
USE PRECAUTIONS TO AVOID RELEASE TO SEWERS/DRAINS/SURFACE WATER AND SOIL.
ECOTOXICOLOGICAL INFORMATION:
PREVENT CONTAMINATION OF SOIL, DRAINS AND SURFACE WATERS. DIKE AND CONTAIN
MATERIAL. SOAK UP RESIDUE WITH ABSORBENT (CLAY, SAND) MATERIALS AND
DISPOSE OF PROPERLY.
BIOACCUMULATION/ACCUMULATION:
PREVENT CONTAMINATION OF SOIL, DRAINS AND SURFACE WATERS. DIKE AND CONTAIN
MATERIAL. SOAK UP RESIDUE WITH ABSORBENT (CLAY, SAND) MATERIALS AND
DISPOSE OF PROPERLY.
| 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL METHOD:
DISPOSE OF FOLLOWING ALL LOCAL AUTHORITY REQUIREMENTS FOR DISPOSAL.
FOR LARGE SPILLS:
DIKE AREA TO CONTAIN SPILL. TAKE PRECAUTIONS AS NECESSARY TO PREVENT
CONTAMINATION OF GROUND AND SURFACE WATERS. RECOVER SPILLED MATERIAL ON
ADSORBENT, SUCH AS SAWDUST OR VERMICULITE, AND SWEEP INTO CLOSED CONTAINERS
FOR DISPOSAL. AFTER ALL VISIBLE TRACES, INCLUDING IGNITIBLE VAPORS, HAVE
BEEN REMOVED THOROUGHLY WET VACUUM THE AREA. DO NOT FLUSH TO SEWER. IF AREA
OF SPILL IS POROUS, REMOVE AS MUCH CONTAMINATED EARTH AND GRAVEL, ETC. AS
NECESSARY AND PLACE IN CLOSED CONTAINERS FOR DISPOSAL.
PRODUCT DISPOSAL:
DISPOSE OF FOLLOWING ALL LOCAL AUTHORITY REQUIREMENTS FOR DISPOSAL.
EMPTY CONTAINER:
DISPOSE OF FOLLOWING ALL LOCAL AUTHORITY REQUIREMENTS FOR DISPOSAL.
| 14. TRANSPORT INFORMATION | |
DOT (DEPARTMENT OF TRANSPORTATION):
PROPER SHIPPING NAME: NOT RESTRICTED BY DOT
ROAD AND RAIL (ADR/RID):
PROPER SHIPPING NAME: NOT RESTRICTED
AIR (ICAO/IATA):
SHIPPING NAME: NOT APPLICABLE.
VESSEL (IMO/IMDG):
SHIPPING NAME: NOT APPLICABLE.
CANADA TRANSPORT OF DANGEROUS GOODS:
SHIPPING NAME: NOT RESTRICTED
| 15. REGULATORY INFORMATION | |
UNITED STATES:
SARA TITLE III (SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT):
FIRE: NO
PRESSURE GENERATING: NO
REACTIVITY: NO
ACUTE: YES
CHRONIC: NO
TSCA (TOXIC SUBSTANCE CONTROL ACT):
CHEMICAL NAME CAS
FATTY ACIDS, C18-UNSATD., DIMERS, REACTION PRODUCTS 68410-23-1
WITH POLYETHYLENEPOLYAMINES
CRYSTALLINE SILICA 14808-60-7
TSCA STATUS: ALL INGREDIENTS IN THIS MIXTURE ARE IN COMPLIANCE WITH TSCA.
CALIFORNIA PROPOSITION 65:
WARNING:
THIS PRODUCT CAN EXPOSE YOU TO CHEMICALS INCLUDING CRYSTALLINE SILICA,
WHICH IS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER. FOR MORE
INFORMATION GO TO WWW.P65WARNINGS.CA.GOV.
CHEMICAL NAME WT.% LISTED
CRYSTALLINE SILICA 0.1 - 1 CANCER
| 16. OTHER INFORMATION | |
APPROVED BY: PACER TECHNOLOGY REGULATORY DEPARTMENT
PREPARED BY: PACER TECHNOLOGY REGULATORY DEPARTMENT
DATE-REVISED: 09/25/2017
REVISION SUMMARY: THIS MSDS REPLACES THE 12/10/2014 MSDS.
REVISED:
SECTION 1:
APPROVED BY, DATE ISSUED, DATE-REVISED, MSDS NO, PREPARED BY, TITLE.
SECTION 2:
SECTION 3: WT.%.
SECTION 5: SENSITIVE TO STATIC DISCHARGE, SENSITIVITY TO IMPACT.
SECTION 9:
AUTOIGNITION TEMPERATURE, BOILING POINT, COLOR, DENSITY, EVAPORATION RATE,
FLASHPOINT AND METHOD, FREEZING POINT, MELTING POINT, MOLECULAR WEIGHT,
ODOR, ODOR THRESHOLD, PERCENT VOLATILE, PH, POUR POINT, SOLUBILITY IN
WATER, SPECIFIC GRAVITY, VAPOR DENSITY, VAPOR PRESSURE, VISCOSITY, (VOC),
THERMAL DECOMPOSITION,.
SECTION 11:
ACUTE (DERMAL LD50 (RABBIT), SKIN ABSORPTION, ORAL LD50 (RAT), INHALATION
LC50 (RAT)), CARCINOGENICITY, GERM CELL MUTAGENICITY, SKIN
CORROSION/IRRITATION.
SECTION 15: CALIFORNIA PROPOSITION 65, WHMIS CLASS.
HMIS RATING:
HEALTH 2
FLAMMABILITY 1
PHYSICAL HAZARD 0
PERSONAL PROTECTION
NFPA CODES:
2
1
0
MANUFACTURER DISCLAIMER:
TO THE BEST OF OUR KNOWLEDGE, THE INFORMATION CONTAINED HEREIN IS ACCURATE.
HOWEVER, PACER TECHNOLOGY DOES NOT ASSUME ANY LIABILITY FOR THE ACCURACY OR
COMPLETENESS OF THE INFORMATION CONTAINED HEREIN. FINAL DETERMINATION OF
SUITABILITY OF ANY MATERIAL IS THE SOLE RESPONSIBILITY OF THE USER. ALL
MATERIALS MAY PRESENT UNKNOWN HAZARDS AND SHOULD BE USED WITH CAUTION.
ALTHOUGH CERTAIN HAZARDS ARE DESCRIBED HEREIN, WE CANNOT GUARANTEE THAT
THESE ARE THE ONLY HAZARDS WHICH EXIST.