| Common Name: | TRACE TECHNOLOGIES CONDUCTIVE PEN |
| Manufacturer: | TECHSPRAY |
| SDS Revision Date: | 5/11/2015 |
| SDS Format: | GHS-US |
| Item Number(s): | 3JDK9 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
SAFETY DATA SHEET
TRACE TECHNOLOGIES CONDUCTIVE PEN
| SECTION 1. IDENTIFICATION |  |
GHS PRODUCT IDENTIFIER: TRACE TECHNOLOGIES CONDUCTIVE PEN
OTHER MEANS OF IDENTIFICATION: SILVER CONDUCTIVE INK
PRODUCT TYPE:
ELECTRIC AND ELECTROMECHANICAL COMPONENTS - CONDUCTIVE MATERIALS
RELEVANT IDENTIFIED USES OF THE SUBSTANCE OR MIXTURE AND USES ADVISED
AGAINST: NOT APPLICABLE.
SUPPLIER'S DETAILS:
TECHSPRAY
8125 COBB CENTER DRIVE
KENNESAW, GA 30152
TEL:
800-858-4043
1 703-527-3887
EMERGENCY TELEPHONE NUMBER (WITH HOURS OF OPERATION):
CHEMTREC: 1-800-858-4043
CANTUC (CANADIAN TRANSPORTATION): (613) 996-6666
EMERGENCY PHONE: (800) 858-4043 24/7
| SECTION 2. HAZARDS IDENTIFICATION | |
OSHA/HCS STATUS:
THIS MATERIAL IS CONSIDERED HAZARDOUS BY THE OSHA HAZARD COMMUNICATION
STANDARD (29 CFR 1910.1200).
CLASSIFICATION OF THE SUBSTANCE OR MIXTURE:
FLAMMABLE LIQUIDS: CATEGORY 2
SPECIFIC TARGET ORGAN TOXICITY (SINGLE EXPOSURE) (NARCOTIC EFFECTS):
CATEGORY 3
PERCENTAGE OF THE MIXTURE CONSISTING OF INGREDIENT(S) OF UNKNOWN TOXICITY:
67.5%
GHS LABEL ELEMENTS:
HAZARD PICTOGRAMS:
FLAME
EXCLAMATION MARK
SIGNAL WORD: DANGER
HAZARD STATEMENTS:
HIGHLY FLAMMABLE LIQUID AND VAPOR.
MAY CAUSE DROWSINESS AND DIZZINESS.
PRECAUTIONARY STATEMENTS:
PREVENTION:
WEAR PROTECTIVE GLOVES. WEAR EYE OR FACE PROTECTION. KEEP AWAY FROM HEAT,
HOT SURFACES, SPARKS, OPEN FLAMES AND OTHER IGNITION SOURCES. NO SMOKING.
USE EXPLOSION-PROOF ELECTRICAL, VENTILATING, LIGHTING AND ALL
MATERIAL-HANDLING EQUIPMENT. USE ONLY NON-SPARKING TOOLS. TAKE
PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGE. KEEP CONTAINER TIGHTLY
CLOSED. USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA. AVOID BREATHING
VAPOR.
RESPONSE:
IF INHALED:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. CALL A POISON CENTER OR PHYSICIAN IF YOU FEEL UNWELL.
IF ON SKIN (OR HAIR):
TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. RINSE SKIN WITH WATER OR
SHOWER.
STORAGE: STORE LOCKED UP. STORE IN A WELL-VENTILATED PLACE. KEEP COOL.
DISPOSAL:
DISPOSE OF CONTENTS AND CONTAINER IN ACCORDANCE WITH ALL LOCAL, REGIONAL,
NATIONAL AND INTERNATIONAL REGULATIONS.
HAZARDS NOT OTHERWISE CLASSIFIED: NONE KNOWN.
| SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
SUBSTANCE/MIXTURE: MIXTURE
OTHER MEANS OF IDENTIFICATION: SILVER CONDUCTIVE INK
CAS NUMBER/OTHER IDENTIFIERS:
CAS NUMBER: NOT APPLICABLE.
PRODUCT CODE: 2505-N
INGREDIENT NAME % CAS NUMBER
BUTYL ACETATE 36 - 45 123-86-4
ANY CONCENTRATION SHOWN AS A RANGE IS TO PROTECT CONFIDENTIALITY OR IS DUE
TO BATCH VARIATION.
THERE ARE NO ADDITIONAL INGREDIENTS PRESENT WHICH, WITHIN THE CURRENT
KNOWLEDGE OF THE SUPPLIER AND IN THE CONCENTRATIONS APPLICABLE, ARE
CLASSIFIED AS HAZARDOUS TO HEALTH OR THE ENVIRONMENT AND HENCE REQUIRE
REPORTING IN THIS SECTION.
OCCUPATIONAL EXPOSURE LIMITS, IF AVAILABLE, ARE LISTED IN SECTION 8.
| SECTION 4. FIRST AID MEASURES | |
DESCRIPTION OF NECESSARY FIRST AID MEASURES:
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER, OCCASIONALLY LIFTING THE UPPER
AND LOWER EYELIDS. CHECK FOR AND REMOVE ANY CONTACT LENSES. CONTINUE TO
RINSE FOR AT LEAST 10 MINUTES. GET MEDICAL ATTENTION IF IRRITATION OCCURS.
INHALATION:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING. IF IT IS SUSPECTED THAT FUMES ARE STILL PRESENT, THE RESCUER
SHOULD WEAR AN APPROPRIATE MASK OR SELF-CONTAINED BREATHING APPARATUS. IF
NOT BREATHING, IF BREATHING IS IRREGULAR OR IF RESPIRATORY ARREST OCCURS,
PROVIDE ARTIFICIAL RESPIRATION OR OXYGEN BY TRAINED PERSONNEL. IT MAY BE
DANGEROUS TO THE PERSON PROVIDING AID TO GIVE MOUTH-TO-MOUTH RESUSCITATION.
GET MEDICAL ATTENTION. IF NECESSARY, CALL A POISON CENTER OR PHYSICIAN. IF
UNCONSCIOUS, PLACE IN RECOVERY POSITION AND GET MEDICAL ATTENTION
IMMEDIATELY. MAINTAIN AN OPEN AIRWAY. LOOSEN TIGHT CLOTHING SUCH AS A
COLLAR, TIE, BELT OR WAISTBAND.
SKIN CONTACT:
FLUSH CONTAMINATED SKIN WITH PLENTY OF WATER. REMOVE CONTAMINATED CLOTHING
AND SHOES. GET MEDICAL ATTENTION IF SYMPTOMS OCCUR. WASH CLOTHING BEFORE
REUSE. CLEAN SHOES THOROUGHLY BEFORE REUSE.
INGESTION:
WASH OUT MOUTH WITH WATER. REMOVE DENTURES IF ANY. REMOVE VICTIM TO FRESH
AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR BREATHING. IF MATERIAL
HAS BEEN SWALLOWED AND THE EXPOSED PERSON IS CONSCIOUS, GIVE SMALL
QUANTITIES OF WATER TO DRINK. STOP IF THE EXPOSED PERSON FEELS SICK AS
VOMITING MAY BE DANGEROUS. DO NOT INDUCE VOMITING UNLESS DIRECTED TO DO SO
BY MEDICAL PERSONNEL. IF VOMITING OCCURS, THE HEAD SHOULD BE KEPT LOW SO
THAT VOMIT DOES NOT ENTER THE LUNGS. GET MEDICAL ATTENTION. IF NECESSARY,
CALL A POISON CENTER OR PHYSICIAN. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. IF UNCONSCIOUS, PLACE IN RECOVERY POSITION AND GET
MEDICAL ATTENTION IMMEDIATELY. MAINTAIN AN OPEN AIRWAY. LOOSEN TIGHT
CLOTHING SUCH AS A COLLAR, TIE, BELT OR WAISTBAND.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
POTENTIAL ACUTE HEALTH EFFECTS:
EYE CONTACT: MAY CAUSE EYE IRRITATION.
INHALATION:
CAN CAUSE CENTRAL NERVOUS SYSTEM (CNS) DEPRESSION. MAY CAUSE DROWSINESS AND
DIZZINESS.
SKIN CONTACT: MAY CAUSE SKIN IRRITATION.
INGESTION: CAN CAUSE CENTRAL NERVOUS SYSTEM (CNS) DEPRESSION.
OVER-EXPOSURE SIGNS/SYMPTOMS:
EYE CONTACT:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
IRRITATION
REDNESS
WATERING
INHALATION:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
NAUSEA OR VOMITING
HEADACHE
DROWSINESS/FATIGUE
DIZZINESS/VERTIGO
UNCONSCIOUSNESS
SKIN CONTACT:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
IRRITATION
REDNESS
INGESTION:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
STOMACH PAINS
NAUSEA OR VOMITING
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED, IF
NECESSARY:
NOTES TO PHYSICIAN:
TREAT SYMPTOMATICALLY. CONTACT POISON TREATMENT SPECIALIST IMMEDIATELY IF
LARGE QUANTITIES HAVE BEEN INGESTED OR INHALED.
SPECIFIC TREATMENTS: NO SPECIFIC TREATMENT.
PROTECTION OF FIRST-AIDERS:
NO ACTION SHALL BE TAKEN INVOLVING ANY PERSONAL RISK OR WITHOUT SUITABLE
TRAINING. IF IT IS SUSPECTED THAT FUMES ARE STILL PRESENT, THE RESCUER
SHOULD WEAR AN APPROPRIATE MASK OR SELF-CONTAINED BREATHING APPARATUS. IT
MAY BE DANGEROUS TO THE PERSON PROVIDING AID TO GIVE MOUTH-TO-MOUTH
RESUSCITATION.
SEE TOXICOLOGICAL INFORMATION (SECTION 11)
| SECTION 5. FIRE-FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
SUITABLE EXTINGUISHING MEDIA:
USE DRY CHEMICAL, CO2, WATER SPRAY (FOG) OR FOAM.
UNSUITABLE EXTINGUISHING MEDIA: DO NOT USE WATER JET.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
HIGHLY FLAMMABLE LIQUID AND VAPOR. IN A FIRE OR IF HEATED, A PRESSURE
INCREASE WILL OCCUR AND THE CONTAINER MAY BURST, WITH THE RISK OF A
SUBSEQUENT EXPLOSION. RUNOFF TO SEWER MAY CREATE FIRE OR EXPLOSION HAZARD.
HAZARDOUS THERMAL DECOMPOSITION PRODUCTS:
DECOMPOSITION PRODUCTS MAY INCLUDE THE FOLLOWING MATERIALS:
CARBON DIOXIDE
CARBON MONOXIDE
METAL OXIDE/OXIDES
SPECIAL PROTECTIVE ACTIONS FOR FIRE-FIGHTERS:
PROMPTLY ISOLATE THE SCENE BY REMOVING ALL PERSONS FROM THE VICINITY OF THE
INCIDENT IF THERE IS A FIRE. NO ACTION SHALL BE TAKEN INVOLVING ANY
PERSONAL RISK OR WITHOUT SUITABLE TRAINING. MOVE CONTAINERS FROM FIRE AREA
IF THIS CAN BE DONE WITHOUT RISK. USE WATER SPRAY TO KEEP FIRE-EXPOSED
CONTAINERS COOL.
SPECIAL PROTECTIVE EQUIPMENT FOR FIRE-FIGHTERS:
FIRE-FIGHTERS SHOULD WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND
SELF-CONTAINED BREATHING APPARATUS (SCBA) WITH A FULL FACE-PIECE OPERATED
IN POSITIVE PRESSURE MODE.
| SECTION 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
FOR NON-EMERGENCY PERSONNEL:
NO ACTION SHALL BE TAKEN INVOLVING ANY PERSONAL RISK OR WITHOUT SUITABLE
TRAINING. EVACUATE SURROUNDING AREAS. KEEP UNNECESSARY AND UNPROTECTED
PERSONNEL FROM ENTERING. DO NOT TOUCH OR WALK THROUGH SPILLED MATERIAL.
SHUT OFF ALL IGNITION SOURCES. NO FLARES, SMOKING OR FLAMES IN HAZARD AREA.
AVOID BREATHING VAPOR OR MIST. PROVIDE ADEQUATE VENTILATION. WEAR
APPROPRIATE RESPIRATOR WHEN VENTILATION IS INADEQUATE. PUT ON APPROPRIATE
PERSONAL PROTECTIVE EQUIPMENT.
FOR EMERGENCY RESPONDERS:
IF SPECIALISED CLOTHING IS REQUIRED TO DEAL WITH THE SPILLAGE, TAKE NOTE OF
ANY INFORMATION IN SECTION 8 ON SUITABLE AND UNSUITABLE MATERIALS. SEE ALSO
THE INFORMATION IN "FOR NON-EMERGENCY PERSONNEL".
ENVIRONMENTAL PRECAUTIONS:
AVOID DISPERSAL OF SPILLED MATERIAL AND RUNOFF AND CONTACT WITH SOIL,
WATERWAYS, DRAINS AND SEWERS. INFORM THE RELEVANT AUTHORITIES IF THE
PRODUCT HAS CAUSED ENVIRONMENTAL POLLUTION (SEWERS, WATERWAYS, SOIL OR
AIR).
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
SMALL SPILL:
STOP LEAK IF WITHOUT RISK. MOVE CONTAINERS FROM SPILL AREA. USE SPARK-PROOF
TOOLS AND EXPLOSION-PROOF EQUIPMENT. DILUTE WITH WATER AND MOP UP IF
WATER-SOLUBLE. ALTERNATIVELY, OR IF WATER-INSOLUBLE, ABSORB WITH AN INERT
DRY MATERIAL AND PLACE IN AN APPROPRIATE WASTE DISPOSAL CONTAINER. DISPOSE
OF VIA A LICENSED WASTE DISPOSAL CONTRACTOR.
LARGE SPILL:
STOP LEAK IF WITHOUT RISK. MOVE CONTAINERS FROM SPILL AREA. USE SPARK-PROOF
TOOLS AND EXPLOSION-PROOF EQUIPMENT. APPROACH RELEASE FROM UPWIND. PREVENT
ENTRY INTO SEWERS, WATER COURSES, BASEMENTS OR CONFINED AREAS. WASH
SPILLAGES INTO AN EFFLUENT TREATMENT PLANT OR PROCEED AS FOLLOWS. CONTAIN
AND COLLECT SPILLAGE WITH NON-COMBUSTIBLE, ABSORBENT MATERIAL E.G. SAND,
EARTH, VERMICULITE OR DIATOMACEOUS EARTH AND PLACE IN CONTAINER FOR
DISPOSAL ACCORDING TO LOCAL REGULATIONS (SEE SECTION 13). DISPOSE OF VIA A
LICENSED WASTE DISPOSAL CONTRACTOR. CONTAMINATED ABSORBENT MATERIAL MAY
POSE THE SAME HAZARD AS THE SPILLED PRODUCT.
NOTE:
SEE SECTION 1 FOR EMERGENCY CONTACT INFORMATION AND SECTION 13 FOR WASTE
DISPOSAL.
| SECTION 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
PROTECTIVE MEASURES:
PUT ON APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT (SEE SECTION 8). DO NOT
INGEST. AVOID CONTACT WITH EYES, SKIN AND CLOTHING. AVOID BREATHING VAPOR
OR MIST. USE ONLY WITH ADEQUATE VENTILATION. WEAR APPROPRIATE RESPIRATOR
WHEN VENTILATION IS INADEQUATE. DO NOT ENTER STORAGE AREAS AND CONFINED
SPACES UNLESS ADEQUATELY VENTILATED. KEEP IN THE ORIGINAL CONTAINER OR AN
APPROVED ALTERNATIVE MADE FROM A COMPATIBLE MATERIAL, KEPT TIGHTLY CLOSED
WHEN NOT IN USE. STORE AND USE AWAY FROM HEAT, SPARKS, OPEN FLAME OR ANY
OTHER IGNITION SOURCE. USE EXPLOSION-PROOF ELECTRICAL (VENTILATING,
LIGHTING AND MATERIAL HANDLING) EQUIPMENT. USE ONLY NON-SPARKING TOOLS.
TAKE PRECAUTIONARY MEASURES AGAINST ELECTROSTATIC DISCHARGES. EMPTY
CONTAINERS RETAIN PRODUCT RESIDUE AND CAN BE HAZARDOUS. DO NOT REUSE
CONTAINER.
ADVICE ON GENERAL OCCUPATIONAL HYGIENE:
EATING, DRINKING AND SMOKING SHOULD BE PROHIBITED IN AREAS WHERE THIS
MATERIAL IS HANDLED, STORED AND PROCESSED. WORKERS SHOULD WASH HANDS AND
FACE BEFORE EATING, DRINKING AND SMOKING. REMOVE CONTAMINATED CLOTHING AND
PROTECTIVE EQUIPMENT BEFORE ENTERING EATING AREAS. SEE ALSO SECTION 8 FOR
ADDITIONAL INFORMATION ON HYGIENE MEASURES.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
STORE IN ACCORDANCE WITH LOCAL REGULATIONS. STORE IN A SEGREGATED AND
APPROVED AREA. STORE IN ORIGINAL CONTAINER PROTECTED FROM DIRECT SUNLIGHT
IN A DRY, COOL AND WELL-VENTILATED AREA, AWAY FROM INCOMPATIBLE MATERIALS
(SEE SECTION 10) AND FOOD AND DRINK. STORE LOCKED UP. ELIMINATE ALL
IGNITION SOURCES. SEPARATE FROM OXIDIZING MATERIALS. KEEP CONTAINER TIGHTLY
CLOSED AND SEALED UNTIL READY FOR USE. CONTAINERS THAT HAVE BEEN OPENED
MUST BE CAREFULLY RESEALED AND KEPT UPRIGHT TO PREVENT LEAKAGE. DO NOT
STORE IN UNLABELED CONTAINERS. USE APPROPRIATE CONTAINMENT TO AVOID
ENVIRONMENTAL CONTAMINATION.
| SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
CONTROL PARAMETERS:
OCCUPATIONAL EXPOSURE LIMITS:
INGREDIENT NAME EXPOSURE LIMITS
BUTYL ACETATE ACGIH TLV (UNITED STATES, 4/2014).
STEL: 200 PPM 15 MINUTES.
TWA: 150 PPM 8 HOURS.
NIOSH REL (UNITED STATES, 10/2013).
STEL: 950 MG/M3 15 MINUTES.
STEL: 200 PPM 15 MINUTES.
TWA: 710 MG/M3 10 HOURS.
TWA: 150 PPM 10 HOURS.
OSHA PEL (UNITED STATES, 2/2013).
TWA: 710 MG/M3 8 HOURS.
TWA: 150 PPM 8 HOURS.
OSHA PEL 1989 (UNITED STATES, 3/1989).
STEL: 950 MG/M3 15 MINUTES.
STEL: 200 PPM 15 MINUTES.
TWA: 710 MG/M3 8 HOURS.
TWA: 150 PPM 8 HOURS.
APPROPRIATE ENGINEERING CONTROLS:
USE ONLY WITH ADEQUATE VENTILATION. USE PROCESS ENCLOSURES, LOCAL EXHAUST
VENTILATION OR OTHER ENGINEERING CONTROLS TO KEEP WORKER EXPOSURE TO
AIRBORNE CONTAMINANTS BELOW ANY RECOMMENDED OR STATUTORY LIMITS. THE
ENGINEERING CONTROLS ALSO NEED TO KEEP GAS, VAPOR OR DUST CONCENTRATIONS
BELOW ANY LOWER EXPLOSIVE LIMITS. USE EXPLOSION-PROOF VENTILATION
EQUIPMENT.
ENVIRONMENTAL EXPOSURE CONTROLS:
EMISSIONS FROM VENTILATION OR WORK PROCESS EQUIPMENT SHOULD BE CHECKED TO
ENSURE THEY COMPLY WITH THE REQUIREMENTS OF ENVIRONMENTAL PROTECTION
LEGISLATION. IN SOME CASES, FUME SCRUBBERS, FILTERS OR ENGINEERING
MODIFICATIONS TO THE PROCESS EQUIPMENT WILL BE NECESSARY TO REDUCE
EMISSIONS TO ACCEPTABLE LEVELS.
INDIVIDUAL PROTECTION MEASURES:
HYGIENE MEASURES:
WASH HANDS, FOREARMS AND FACE THOROUGHLY AFTER HANDLING CHEMICAL PRODUCTS,
BEFORE EATING, SMOKING AND USING THE LAVATORY AND AT THE END OF THE WORKING
PERIOD. APPROPRIATE TECHNIQUES SHOULD BE USED TO REMOVE POTENTIALLY
CONTAMINATED CLOTHING. WASH CONTAMINATED CLOTHING BEFORE REUSING. ENSURE
THAT EYEWASH STATIONS AND SAFETY SHOWERS ARE CLOSE TO THE WORKSTATION
LOCATION.
EYE/FACE PROTECTION:
SAFETY EYEWEAR COMPLYING WITH AN APPROVED STANDARD SHOULD BE USED WHEN A
RISK ASSESSMENT INDICATES THIS IS NECESSARY TO AVOID EXPOSURE TO LIQUID
SPLASHES, MISTS, GASES OR DUSTS. IF CONTACT IS POSSIBLE, THE FOLLOWING
PROTECTION SHOULD BE WORN, UNLESS THE ASSESSMENT INDICATES A HIGHER DEGREE
OF PROTECTION: SAFETY GLASSES WITH SIDE-SHIELDS.
SKIN PROTECTION:
HAND PROTECTION:
CHEMICAL-RESISTANT, IMPERVIOUS GLOVES COMPLYING WITH AN APPROVED STANDARD
SHOULD BE WORN AT ALL TIMES WHEN HANDLING CHEMICAL PRODUCTS IF A RISK
ASSESSMENT INDICATES THIS IS NECESSARY. CONSIDERING THE PARAMETERS
SPECIFIED BY THE GLOVE MANUFACTURER, CHECK DURING USE THAT THE GLOVES ARE
STILL RETAINING THEIR PROTECTIVE PROPERTIES. IT SHOULD BE NOTED THAT THE
TIME TO BREAKTHROUGH FOR ANY GLOVE MATERIAL MAY BE DIFFERENT FOR DIFFERENT
GLOVE MANUFACTURERS. IN THE CASE OF MIXTURES, CONSISTING OF SEVERAL
SUBSTANCES, THE PROTECTION TIME OF THE GLOVES CANNOT BE ACCURATELY
ESTIMATED.
BODY PROTECTION:
PERSONAL PROTECTIVE EQUIPMENT FOR THE BODY SHOULD BE SELECTED BASED ON THE
TASK BEING PERFORMED AND THE RISKS INVOLVED AND SHOULD BE APPROVED BY A
SPECIALIST BEFORE HANDLING THIS PRODUCT. WHEN THERE IS A RISK OF IGNITION
FROM STATIC ELECTRICITY, WEAR ANTISTATIC PROTECTIVE CLOTHING. FOR THE
GREATEST PROTECTION FROM STATIC DISCHARGES, CLOTHING SHOULD INCLUDE
ANTI-STATIC OVERALLS, BOOTS AND GLOVES.
OTHER SKIN PROTECTION:
APPROPRIATE FOOTWEAR AND ANY ADDITIONAL SKIN PROTECTION MEASURES SHOULD BE
SELECTED BASED ON THE TASK BEING PERFORMED AND THE RISKS INVOLVED AND
SHOULD BE APPROVED BY A SPECIALIST BEFORE HANDLING THIS PRODUCT.
RESPIRATORY PROTECTION:
USE A PROPERLY FITTED, AIR-PURIFYING OR AIR-FED RESPIRATOR COMPLYING WITH
AN APPROVED STANDARD IF A RISK ASSESSMENT INDICATES THIS IS NECESSARY.
RESPIRATOR SELECTION MUST BE BASED ON KNOWN OR ANTICIPATED EXPOSURE LEVELS,
THE HAZARDS OF THE PRODUCT AND THE SAFE WORKING LIMITS OF THE SELECTED
RESPIRATOR.
| SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: LIQUID.
COLOR: SILVER. COLORED, PAINT
ODOR: AROMATIC. HYDROCARBON.
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT APPLICABLE.
MELTING POINT: NOT AVAILABLE.
BOILING POINT: 126 DEG. C (258.8 DEG. F)
FLASH POINT:
CLOSED CUP: 22 DEG. C (71.6 DEG. F) [TAGLIABUE.]
EVAPORATION RATE: >1 (BUTYL ACETATE = 1)
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
LOWER AND UPPER EXPLOSIVE (FLAMMABLE) LIMITS: NOT AVAILABLE.
VAPOR PRESSURE: 0.67 KPA (5 MMHg) [ROOM TEMPERATURE]
VAPOR DENSITY: NOT AVAILABLE.
RELATIVE DENSITY: 2
SOLUBILITY: NOT AVAILABLE.
PARTITION COEFFICIENT N-OCTANOL/WATER: NOT AVAILABLE.
AUTO-IGNITION TEMPERATURE: >425 DEG. C (>797 DEG. F)
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
VISCOSITY: NOT AVAILABLE.
| SECTION 10. STABILITY AND REACTIVITY | |
REACTIVITY:
NO SPECIFIC TEST DATA RELATED TO REACTIVITY AVAILABLE FOR THIS PRODUCT OR
ITS INGREDIENTS.
CHEMICAL STABILITY: THE PRODUCT IS STABLE.
POSSIBILITY OF HAZARDOUS REACTIONS:
UNDER NORMAL CONDITIONS OF STORAGE AND USE, HAZARDOUS REACTIONS WILL NOT
OCCUR.
CONDITIONS TO AVOID:
AVOID ALL POSSIBLE SOURCES OF IGNITION (SPARK OR FLAME). DO NOT PRESSURIZE,
CUT, WELD, BRAZE, SOLDER, DRILL, GRIND OR EXPOSE CONTAINERS TO HEAT OR
SOURCES OF IGNITION.
INCOMPATIBLE MATERIALS:
REACTIVE OR INCOMPATIBLE WITH THE FOLLOWING MATERIALS: OXIDIZING MATERIALS
HAZARDOUS DECOMPOSITION PRODUCTS:
UNDER NORMAL CONDITIONS OF STORAGE AND USE, HAZARDOUS DECOMPOSITION
PRODUCTS SHOULD NOT BE PRODUCED.
| SECTION 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY:
PRODUCT/INGREDIENT RESULT SPECIES DOSE EXPOSURE
NAME
BUTYL ACETATE LC50 INHALATION GAS. RAT 390 PPM 4 HOURS
LD50 DERMAL RABBIT >17600 MG/KG
LD50 ORAL RAT 10768 MG/KG
IRRITATION/CORROSION:
PRODUCT/ RESULT SPECIES SCORE EXPOSURE OBSERVATION
INGREDIENT
NAME
BUTYL EYES: RABBIT 100 MILLIGRAMS
ACETATE MODERATE
IRRITANT
SKIN: RABBIT 24 HOURS
MODERATE 500 MILLIGRAMS
IRRITANT
SENSITIZATION: NOT AVAILABLE.
MUTAGENICITY: NOT AVAILABLE.
CARCINOGENICITY: NOT AVAILABLE.
REPRODUCTIVE TOXICITY: NOT AVAILABLE.
TERATOGENICITY: NOT AVAILABLE.
SPECIFIC TARGET ORGAN TOXICITY (SINGLE EXPOSURE):
NAME CATEGORY ROUTE OF TARGET ORGANS
EXPOSURE
BUTYL ACETATE CATEGORY 3 NOT APPLICABLE. NARCOTIC EFFECTS
SPECIFIC TARGET ORGAN TOXICITY (REPEATED EXPOSURE): NOT AVAILABLE.
ASPIRATION HAZARD: NOT AVAILABLE.
INFORMATION ON THE LIKELY ROUTES OF EXPOSURE: NOT AVAILABLE.
POTENTIAL ACUTE HEALTH EFFECTS:
EYE CONTACT: MAY CAUSE EYE IRRITATION.
INHALATION:
CAN CAUSE CENTRAL NERVOUS SYSTEM (CNS) DEPRESSION. MAY CAUSE DROWSINESS AND
DIZZINESS.
SKIN CONTACT: MAY CAUSE SKIN IRRITATION.
INGESTION: CAN CAUSE CENTRAL NERVOUS SYSTEM (CNS) DEPRESSION.
SYMPTOMS RELATED TO THE PHYSICAL, CHEMICAL AND TOXICOLOGICAL
CHARACTERISTICS:
EYE CONTACT:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
IRRITATION
REDNESS
WATERING
INHALATION:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
NAUSEA OR VOMITING
HEADACHE
DROWSINESS/FATIGUE
DIZZINESS/VERTIGO
UNCONSCIOUSNESS
SKIN CONTACT:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
IRRITATION
REDNESS
INGESTION:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
STOMACH PAINS
NAUSEA OR VOMITING
DELAYED AND IMMEDIATE EFFECTS AND ALSO CHRONIC EFFECTS FROM SHORT AND LONG
TERM EXPOSURE:
SHORT TERM EXPOSURE:
POTENTIAL IMMEDIATE EFFECTS: NOT AVAILABLE.
POTENTIAL DELAYED EFFECTS: NOT AVAILABLE.
LONG TERM EXPOSURE:
POTENTIAL IMMEDIATE EFFECTS: NOT AVAILABLE.
POTENTIAL DELAYED EFFECTS: NOT AVAILABLE.
POTENTIAL CHRONIC HEALTH EFFECTS: NOT AVAILABLE.
GENERAL: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
CARCINOGENICITY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
MUTAGENICITY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
TERATOGENICITY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
DEVELOPMENTAL EFFECTS: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
FERTILITY EFFECTS: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
NUMERICAL MEASURES OF TOXICITY:
ACUTE TOXICITY ESTIMATES: NOT AVAILABLE.
| SECTION 12. ECOLOGICAL INFORMATION | |
TOXICITY:
PRODUCT/INGREDIENT RESULT SPECIES EXPOSURE
NAME
BUTYL ACETATE ACUTE LC50: CRUSTACEANS - ARTEMIA 48 HOURS
32000 (MICRO)G/L SALINA - NAUPLII
MARINE WATER
ACUTE LC50: FISH - DANIO RERIO 96 HOURS
62000 (MICRO)G/L
PERSISTENCE AND DEGRADABILITY: NOT AVAILABLE.
BIOACCUMULATIVE POTENTIAL:
PRODUCT/INGREDIENT NAME LOGPOW BCF POTENTIAL
BUTYL ACETATE 2.3 LOW
MOBILITY IN SOIL:
SOIL/WATER PARTITION COEFFICIENT (KOC): NOT AVAILABLE.
OTHER ADVERSE EFFECTS: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
| SECTION 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL METHODS:
THE GENERATION OF WASTE SHOULD BE AVOIDED OR MINIMIZED WHEREVER POSSIBLE.
DISPOSAL OF THIS PRODUCT, SOLUTIONS AND ANY BY-PRODUCTS SHOULD AT ALL TIMES
COMPLY WITH THE REQUIREMENTS OF ENVIRONMENTAL PROTECTION AND WASTE DISPOSAL
LEGISLATION AND ANY REGIONAL LOCAL AUTHORITY REQUIREMENTS. DISPOSE OF
SURPLUS AND NON-RECYCLABLE PRODUCTS VIA A LICENSED WASTE DISPOSAL
CONTRACTOR. WASTE SHOULD NOT BE DISPOSED OF UNTREATED TO THE SEWER UNLESS
FULLY COMPLIANT WITH THE REQUIREMENTS OF ALL AUTHORITIES WITH JURISDICTION.
WASTE PACKAGING SHOULD BE RECYCLED. INCINERATION OR LANDFILL SHOULD ONLY BE
CONSIDERED WHEN RECYCLING IS NOT FEASIBLE. THIS MATERIAL AND ITS CONTAINER
MUST BE DISPOSED OF IN A SAFE WAY. CARE SHOULD BE TAKEN WHEN HANDLING
EMPTIED CONTAINERS THAT HAVE NOT BEEN CLEANED OR RINSED OUT. EMPTY
CONTAINERS OR LINERS MAY RETAIN SOME PRODUCT RESIDUES. VAPOR FROM PRODUCT
RESIDUES MAY CREATE A HIGHLY FLAMMABLE OR EXPLOSIVE ATMOSPHERE INSIDE THE
CONTAINER. DO NOT CUT, WELD OR GRIND USED CONTAINERS UNLESS THEY HAVE BEEN
CLEANED THOROUGHLY INTERNALLY. AVOID DISPERSAL OF SPILLED MATERIAL AND
RUNOFF AND CONTACT WITH SOIL, WATERWAYS, DRAINS AND SEWERS.
| SECTION 14. TRANSPORT INFORMATION | |
DOT TDG MEXICO
CLASSIFICATION CLASSIFICATION CLASSIFICATION
UN NUMBER UN1993 UN1993 UN1993
UN PROPER FLAMMABLE FLAMMABLE FLAMMABLE
SHIPPING NAME LIQUID, N.O.S. LIQUID, N.O.S. LIQUID, N.O.S.
TRANSPORT HAZARD 3 3 3
CLASS(ES)
FLAMMABLE LIQUID, CLASS 3, CLASS 3,
CLASS/DIVISION FLAMMABLE FLAMMABLE
3.1, 3.2, 3.3 LIQUIDS LIQUIDS
PACKING GROUP II II II
ENVIRONMENTAL NO. NO. NO.
HAZARDS
ADDITIONAL REPORTABLE
INFORMATION QUANTITY:
2000 LBS / 908 KG
[119.93 GAL /
454 L] PACKAGE
SIZES SHIPPED IN
QUANTITIES LESS
THAN THE PRODUCT
REPORTABLE
QUANTITY ARE NOT
SUBJECT TO THE RQ
(REPORTABLE
QUANTITY)
TRANSPORTATION
REQUIREMENTS.
ADR/RID IMDG IATA
UN NUMBER UN1993 UN1993 UN1993
UN PROPER FLAMMABLE FLAMMABLE FLAMMABLE
SHIPPING NAME LIQUID, N.O.S. LIQUID, N.O.S. LIQUID, N.O.S.
TRANSPORT HAZARD 3 3 3
CLASS(ES)
CLASS 3, FLAMMABLE CLASS 3 - CLASS 3,
LIQUIDS FLAMMABLE FLAMMABLE
LIQUIDS LIQUIDS
PACKING GROUP II II II
ENVIRONMENTAL YES. YES. NO.
HAZARDS
ADDITIONAL THE LIMITED QUANTITY THE
INFORMATION ENVIRONMENTALLY ENVIRONMENTALLY
HAZARDOUS SUBSTANCE HAZARDOUS
MARK IS NOT SUBSTANCE MARK
REQUIRED WHEN MAY APPEAR IF
TRANSPORTED IN REQUIRED BY
SIZES OF </=5 L OR OTHER
</=5 KG. TRANSPORTATION
REGULATIONS.
SPECIAL
PROVISIONS:
640 (C)
TUNNEL CODE:
(D/E)
SPECIAL PRECAUTIONS FOR USER:
TRANSPORT WITHIN USER'S PREMISES:
ALWAYS TRANSPORT IN CLOSED CONTAINERS THAT ARE UPRIGHT AND SECURE. ENSURE
THAT PERSONS TRANSPORTING THE PRODUCT KNOW WHAT TO DO IN THE EVENT OF AN
ACCIDENT OR SPILLAGE.
TRANSPORT IN BULK ACCORDING TO ANNEX II OF MARPOL 73/78 AND THE IBC CODE:
NOT AVAILABLE.
| SECTION 15. REGULATORY INFORMATION | |
U.S. FEDERAL REGULATIONS:
TSCA 8(A) CDR EXEMPT/PARTIAL EXEMPTION: NOT DETERMINED
NOT DETERMINED.
CLEAN WATER ACT (CWA) 307: SILVER
CLEAN WATER ACT (CWA) 311: N-BUTYL ACETATE
CLEAN AIR ACT SECTION 112 (B) HAZARDOUS AIR POLLUTANTS (HAPS): NOT LISTED
CLEAN AIR ACT SECTION 602 CLASS I SUBSTANCES: NOT LISTED
CLEAN AIR ACT SECTION 602 CLASS II SUBSTANCES: NOT LISTED
DEA LIST I CHEMICALS (PRECURSOR CHEMICALS): NOT LISTED
DEA LIST II CHEMICALS (ESSENTIAL CHEMICALS): NOT LISTED
SARA 302/304:
COMPOSITION/INFORMATION ON INGREDIENTS: NO PRODUCTS WERE FOUND.
SARA 304 RQ: NOT APPLICABLE.
SARA 311/312:
CLASSIFICATION:
FIRE HAZARD
IMMEDIATE (ACUTE) HEALTH HAZARD
COMPOSITION/INFORMATION ON INGREDIENTS:
NAME % FIRE SUDDEN REACTIVE IMMEDIATE DELAYED
HAZARD RELEASE OF (ACUTE) (CHRONIC)
PRESSURE HEALTH HEALTH
HAZARD HAZARD
BUTYL 36 - 45 YES. NO. NO. YES. NO.
ACETATE
SARA 313:
PRODUCT NAME CAS NUMBER %
FORM R - REPORTING REQUIREMENTS:
SILVER 7440-22-4 45 - 55
SUPPLIER NOTIFICATION:
SILVER 7440-22-4 45 - 55
SARA 313 NOTIFICATIONS MUST NOT BE DETACHED FROM THE SDS AND ANY COPYING
AND REDISTRIBUTION OF THE SDS SHALL INCLUDE COPYING AND REDISTRIBUTION OF
THE NOTICE ATTACHED TO COPIES OF THE SDS SUBSEQUENTLY REDISTRIBUTED.
STATE REGULATIONS:
MASSACHUSETTS:
THE FOLLOWING COMPONENTS ARE LISTED: SILVER; BUTYL ACETATE
NEW YORK:
THE FOLLOWING COMPONENTS ARE LISTED: SILVER; BUTYL ACETATE
NEW JERSEY:
THE FOLLOWING COMPONENTS ARE LISTED:
SILVER; N-BUTYL ACETATE; ACETIC ACID, BUTYL ESTER
PENNSYLVANIA:
THE FOLLOWING COMPONENTS ARE LISTED: SILVER; ACETIC ACID, BUTYL ESTER
INTERNATIONAL REGULATIONS:
CHEMICAL WEAPON CONVENTION LIST SCHEDULES I, II & III CHEMICALS:
NOT LISTED.
MONTREAL PROTOCOL (ANNEXES A, B, C, E): NOT LISTED.
STOCKHOLM CONVENTION ON PERSISTENT ORGANIC POLLUTANTS: NOT LISTED.
ROTTERDAM CONVENTION ON PRIOR INFORM CONSENT (PIC): NOT LISTED.
UNECE AARHUS PROTOCOL ON POPS AND HEAVY METALS: NOT LISTED.
INTERNATIONAL LISTS:
NATIONAL INVENTORY:
AUSTRALIA: NOT DETERMINED.
CANADA: NOT DETERMINED.
CHINA: NOT DETERMINED.
EUROPE: NOT DETERMINED.
JAPAN: NOT DETERMINED.
MALAYSIA: NOT DETERMINED.
NEW ZEALAND: NOT DETERMINED.
PHILIPPINES: NOT DETERMINED.
REPUBLIC OF KOREA: NOT DETERMINED.
TAIWAN: NOT DETERMINED.
| SECTION 16. OTHER INFORMATION | |
HAZARDOUS MATERIAL INFORMATION SYSTEM (U.S.A.):
HEALTH 1
FLAMMABILITY 3
PHYSICAL HAZARDS 1
CAUTION:
HMIS(R*) RATINGS ARE BASED ON A 0-4 RATING SCALE, WITH 0 REPRESENTING
MINIMAL HAZARDS OR RISKS, AND 4 REPRESENTING SIGNIFICANT HAZARDS OR RISKS
ALTHOUGH HMIS(R*) RATINGS ARE NOT REQUIRED ON SDSS UNDER 29 CFR 1910.1200,
THE PREPARER MAY CHOOSE TO PROVIDE THEM. HMIS(R*) RATINGS ARE TO BE USED
WITH A FULLY IMPLEMENTED HMIS(R*) PROGRAM. HMIS(R*) IS A REGISTERED MARK OF
THE NATIONAL PAINT & COATINGS ASSOCIATION (NPCA). HMIS(R*) MATERIALS MAY BE
PURCHASED EXCLUSIVELY FROM J. J. KELLER (800) 327-6868.
THE CUSTOMER IS RESPONSIBLE FOR DETERMINING THE PPE CODE FOR THIS MATERIAL.
NATIONAL FIRE PROTECTION ASSOCIATION (U.S.A.):
HEALTH 1
FLAMMABILITY 3
INSTABILITY/REACTIVITY 1
SPECIAL
REPRINTED WITH PERMISSION FROM NFPA 704-2001, IDENTIFICATION OF THE HAZARDS
OF MATERIALS FOR EMERGENCY RESPONSE COPYRIGHT (C)1997, NATIONAL FIRE
PROTECTION ASSOCIATION, QUINCY, MA 02269. THIS REPRINTED MATERIAL IS NOT
THE COMPLETE AND OFFICIAL POSITION OF THE NATIONAL FIRE PROTECTION
ASSOCIATION, ON THE REFERENCED SUBJECT WHICH IS REPRESENTED ONLY BY THE
STANDARD IN ITS ENTIRETY.
COPYRIGHT (C)2001, NATIONAL FIRE PROTECTION ASSOCIATION, QUINCY, MA 02269.
THIS WARNING SYSTEM IS INTENDED TO BE INTERPRETED AND APPLIED ONLY BY
PROPERLY TRAINED INDIVIDUALS TO IDENTIFY FIRE, HEALTH AND REACTIVITY
HAZARDS OF CHEMICALS. THE USER IS REFERRED TO CERTAIN LIMITED NUMBER OF
CHEMICALS WITH RECOMMENDED CLASSIFICATIONS IN NFPA 49 AND NFPA 325, WHICH
WOULD BE USED AS A GUIDELINE ONLY. WHETHER THE CHEMICALS ARE CLASSIFIED BY
NFPA OR NOT, ANYONE USING THE 704 SYSTEMS TO CLASSIFY CHEMICALS DOES SO AT
THEIR OWN RISK.
HISTORY:
DATE OF PRINTING: 5/11/2015.
DATE OF ISSUE/DATE OF REVISION: 5/11/2015.
DATE OF PREVIOUS ISSUE: 1/8/2015.
VERSION: 3
KEY TO ABBREVIATIONS:
ATE: ACUTE TOXICITY ESTIMATE
BCF: BIOCONCENTRATION FACTOR
GHS:
GLOBALLY HARMONIZED SYSTEM OF CLASSIFICATION AND LABELLING OF CHEMICALS
IATA: INTERNATIONAL AIR TRANSPORT ASSOCIATION
IBC: INTERMEDIATE BULK CONTAINER
IMDG: INTERNATIONAL MARITIME DANGEROUS GOODS
LOGPOW: LOGARITHM OF THE OCTANOL/WATER PARTITION COEFFICIENT
MARPOL 73/78:
INTERNATIONAL CONVENTION FOR THE PREVENTION OF POLLUTION FROM SHIPS, 1973
AS MODIFIED BY THE PROTOCOL OF 1978. ("MARPOL" = MARINE POLLUTION)
UN: UNITED NATIONS
REFERENCES: NOT AVAILABLE.
| INDICATES INFORMATION THAT HAS CHANGED FROM PREVIOUSLY ISSUED VERSION.
NOTICE TO READER:
TO THE BEST OF OUR KNOWLEDGE, THE INFORMATION CONTAINED HEREIN IS ACCURATE.
HOWEVER, NEITHER THE ABOVE-NAMED SUPPLIER, NOR ANY OF ITS SUBSIDIARIES,
ASSUMES ANY LIABILITY WHATSOEVER FOR THE ACCURACY OR COMPLETENESS OF THE
INFORMATION CONTAINED HEREIN.
FINAL DETERMINATION OF SUITABILITY OF ANY MATERIAL IS THE SOLE
RESPONSIBILITY OF THE USER. ALL MATERIALS MAY PRESENT UNKNOWN HAZARDS AND
SHOULD BE USED WITH CAUTION. ALTHOUGH CERTAIN HAZARDS ARE DESCRIBED HEREIN,
WE CANNOT GUARANTEE THAT THESE ARE THE ONLY HAZARDS THAT EXIST.