| Common Name: | XSORB ROCK SOLID PAINT HARDENER |
| Manufacturer: | IMPACT ABSORBENTS |
| SDS Revision Date: | 1/1/2023 |
| SDS Format: | No Format Specified |
| Item Number(s): | 21YX75, 3VYZ8, 3VZA3, 804AE3 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
SAFETY DATA SHEET
XSORB(R*) ROCK SOLID(TM) PAINT HARDENER
SDS REVISION DATE: 01/01/2023
| 1. IDENTIFICATION OF THE SUBSTANCE/MIXTURE |  |
AND OF THE COMPANY/UNDERTAKING
1.1. PRODUCT IDENTIFIER:
PRODUCT IDENTITY: XSORB(R*) ROCK SOLID(TM) PAINT HARDENER
ALTERNATE NAMES: XSORB ROCK SOLID PAINT HARDENER
1.2. RELEVANT IDENTIFIED USES OF THE SUBSTANCE OR MIXTURE AND USES ADVISED
AGAINST:
INTENDED USE: SEE TECHNICAL DATA SHEET.
APPLICATION METHOD: SEE TECHNICAL DATA SHEET.
1.3. DETAILS OF THE SUPPLIER OF THE SAFETY DATA SHEET:
COMPANY NAME:
IMPACT ABSORBENTS, INC
5255 TRAFFIC WAY
ATASCADERO, CA 93422.
USA
EMERGENCY:
CHEMTREC (USA) (800): 424-9300
CUSTOMER SERVICE:
IMPACT ABSORBENTS, INC: 805-466-4709
| 2. HAZARD IDENTIFICATION OF THE PRODUCT | |
2.1. CLASSIFICATION OF THE SUBSTANCE OR MIXTURE:
NO APPLICABLE GHS CATEGORIES.
2.2. LABEL ELEMENTS:
USING THE TOXICITY DATA LISTED IN SECTION 11 AND 12 THE PRODUCT IS LABELED
AS FOLLOWS.
NO APPLICABLE GHS CATEGORIES.
[PREVENTION]: NO GHS PREVENTION STATEMENTS
[RESPONSE]: NO GHS RESPONSE STATEMENTS
[STORAGE]: NO GHS STORAGE STATEMENTS
[DISPOSAL]: NO GHS DISPOSAL STATEMENTS
| 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
THIS PRODUCT CONTAINS THE FOLLOWING SUBSTANCES THAT PRESENT A HAZARD
WITHIN THE MEANING OF THE RELEVANT STATE AND FEDERAL HAZARDOUS SUBSTANCES
REGULATIONS.
INGREDIENT/CHEMICAL WEIGHT % GHS CLASSIFICATION NOTES
DESIGNATIONS
2-PROPENOIC ACID, POLYMER 50 - 75 NOT CLASSIFIED [1]
WITH SODIUM 2-PROPENOATE
CAS NUMBER: 0009033-79-8
AMORPHOUS ALUMINA 50 - 75 NOT CLASSIFIED [1][2]
SILICATE PERLITE
CAS NUMBER: 0093763-70-3
[1] SUBSTANCE CLASSIFIED WITH A HEALTH OR ENVIRONMENTAL HAZARD.
[2] SUBSTANCE WITH A WORKPLACE EXPOSURE LIMIT.
[3] PBT-SUBSTANCE OR VPVB-SUBSTANCE.
*THE FULL TEXTS OF THE PHRASES ARE SHOWN IN SECTION 16.
| 4. FIRST AID MEASURES | |
4.1. DESCRIPTION OF FIRST AID MEASURES:
GENERAL:
IN ALL CASES OF DOUBT, OR WHEN SYMPTOMS PERSIST, SEEK MEDICAL ATTENTION.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
INHALATION:
REMOVE THE PERSON TO FRESH AIR. GET MEDICAL ATTENTION IF IRRITATION OR
DISCOMFORT PERSISTS.
EYES:
IRRIGATE COPIOUSLY WITH CLEAN WATER FOR AT LEAST 15 MINUTES, HOLDING THE
EYELIDS APART AND SEEK MEDICAL ATTENTION.
SKIN: NO HAZARDS WHICH REQUIRE SPECIAL FIRST AID MEASURES.
INGESTION:
THE PRODUCT IS NOT CONSIDERED TOXIC BASED ON STUDIES ON LABORATORY
ANIMALS.
4.2. MOST IMPORTANT SYMPTOMS AND EFFECTS, BOTH ACUTE AND DELAYED:
OVERVIEW:
POTENTIAL ACUTE HEALTH EFFECTS:
INHALATION OF HEAVY CONCENTRATIONS MAY CAUSE MILD IRRITATION OF UPPER
RESPIRATORY TRACT AND LUNGS.
TARGET ORGANS: EYES, LUNGS
POTENTIAL CHRONIC HEALTH EFFECTS:
INHALING OVER LONG PERIODS OF HIGH AMOUNTS OF ANY NUISANCE DUST MAY
OVERLOAD LUNG CLEARANCE MECHANISM AND MAKE LUNGS MORE VULNERABLE TO
RESPIRATORY DISEASE.
| 5. FIRE-FIGHTING MEASURES | |
5.1. EXTINGUISHING MEDIA: WATER, CO2, AND DRY CHEMICAL
5.2. SPECIAL HAZARDS ARISING FROM THE SUBSTANCE OR MIXTURE:
HAZARDOUS DECOMPOSITION:
REACTS WITH HYDROFLUORIC ACID TO FORM TOXIC SILICON TETRA FLUORIDE GAS.
THERMAL DECOMPOSITION MAY PRODUCE NITROGEN OXIDES (NOX), CARBON OXIDES.
5.3. ADVICE FOR FIRE-FIGHTERS:
NONE APPLICABLE IF PRODUCT IS UNUSED. IF USED TO ABSORB FLAMMABLE LIQUIDS,
THEN CONSULT MSDS OF THE FLAMMABLE LIQUID. SLIPPERY CONDITIONS MAY BE
CREATED IF SPILL PRODUCT COMES IN CONTACT WITH WATER.
ERG GUIDE NO.:
| 6. ACCIDENTAL RELEASE MEASURES | |
6.1. PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
PUT ON APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT (SEE SECTION 8).
6.2. ENVIRONMENTAL PRECAUTIONS:
USE GOOD PERSONAL HYGIENE PRACTICES. WASH HANDS BEFORE EATING, DRINKING,
SMOKING OR USING TOILET. PROMPTLY REMOVE SOILED CLOTHING AND WASH
THOROUGHLY BEFORE REUSE.
6.3. METHODS AND MATERIAL FOR CONTAINMENT AND CLEANING UP:
SWEEP WITH BROOM OR VACUUM INTO A SUITABLE DISPOSAL CONTAINER. WEAR
APPROPRIATE PERSONAL PROTECTION. AVOID CREATING DUSTY CONDITIONS.
COMPLY WITH STATE AND LOCAL REGULATIONS FOR DISPOSAL OF THESE PRODUCTS.
IF USED TO COLLECT LIQUID MATERIAL, DISPOSE IN COMPLIANCE WITH MSDS OF
COLLECTED LIQUID.
| 7. HANDLING AND STORAGE | |
7.1. PRECAUTIONS FOR SAFE HANDLING:
WEAR APPROPRIATE PERSONAL PROTECTION. REMOVE MATERIAL AFTER ABSORPTION HAS
TAKEN PLACE. RESEAL CONTAINER AFTER USE TO PREVENT EVAPORATION OF WETTING
AGENT. WASH THOROUGHLY AFTER USE.
7.2. CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
HANDLE CONTAINERS CAREFULLY TO PREVENT DAMAGE AND SPILLAGE.
STORE IN A COOL DRY PLACE.
KEEP CONTAINERS TIGHTLY CLOSED.
INCOMPATIBLE MATERIALS: HYDROFLUORIC ACID AND STRONG BASES SUCH AS SODIUM
HYDROXIDE.
KEEP IN A DRY, COOL PLACE. STORE IN A CLOSED CONTAINER.
7.3. SPECIFIC END USE(S): NO DATA AVAILABLE.
| 8. EXPOSURE CONTROLS AND PERSONAL PROTECTION | |
8.1. CONTROL PARAMETERS:
EXPOSURE:
CAS NO. INGREDIENT SOURCE VALUE
0009033-79-8 2-PROPENOIC ACID, OSHA NO ESTABLISHED LIMIT
POLYMER WITH SODIUM
2-PROPENOATE ACGIH NO ESTABLISHED LIMIT
NIOSH NO ESTABLISHED LIMIT
SUPPLIER NO ESTABLISHED LIMIT
0093763-70-3 AMORPHOUS ALUMINA OSHA TWA 15 MG/M3 (TOTAL)
SILICATE PERLITE TWA 5 MG/M3 (RESP)
ACGIH NO ESTABLISHED LIMIT
NIOSH TWA 10 MG/M3 (TOTAL)
TWA 5 MG/M3 (RESP)
SUPPLIER NO ESTABLISHED LIMIT
CARCINOGEN DATA:
CAS NO. INGREDIENT SOURCE VALUE
0009033-79-8 2-PROPENOIC ACID, OSHA SELECT CARCINOGEN: NO
POLYMER WITH SODIUM
2-PROPENOATE NTP KNOWN: NO
SUSPECTED: NO
IARC GROUP 1: NO
GROUP 2A: NO
GROUP 2B: NO
GROUP 3: NO
GROUP 4: NO
0093763-70-3 AMORPHOUS ALUMINA OSHA SELECT CARCINOGEN: NO
SILICATE PERLITE
NTP KNOWN: NO
SUSPECTED: NO
IARC GROUP 1: NO
GROUP 2A: NO
GROUP 2B: NO
GROUP 3: NO
GROUP 4: NO
8.2. EXPOSURE CONTROLS:
RESPIRATORY:
IF RESPIRABLE DUST EXCEEDS 0.05 MG/M3, USE A VENTILATED RESPIRATOR WITH P3
FILTER CARTRIDGE.
EYES:
SAFETY GLASSES WITH SIDE SHIELDS/GOGGLES ARE RECOMMENDED. DO NOT WEAR
CONTACT LENSES.
SKIN:
GLOVES ARE RECOMMENDED. NO SPECIAL PROTECTIVE CLOTHING REQUIRED.
IMPERVIOUS GLOVES WITH NON-SLIP COATING OR SURFACE.
ENGINEERING CONTROLS:
A SYSTEM OF LOCAL EXHAUST MAY BE USED TO KEEP EXPOSURES AS LOW AS
POSSIBLE.
OTHER WORK PRACTICES:
USE GOOD PERSONAL HYGIENE PRACTICES. WASH HANDS BEFORE EATING, DRINKING,
SMOKING OR USING TOILET. PROMPTLY REMOVE SOILED CLOTHING AND WASH
THOROUGHLY BEFORE REUSE.
SEE SECTION 2 FOR FURTHER DETAILS. - [PREVENTION]:
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: WHITE OR BUFF AGGREGATE OR POWDER SOLID
ODOR: ODORLESS
ODOR THRESHOLD: NOT MEASURED
PH: 5-7
MELTING POINT / FREEZING POINT: >2000 DEGREES F
INITIAL BOILING POINT AND BOILING RANGE: NOT MEASURED
FLASH POINT: NON-FLAMMABLE
EVAPORATION RATE (ETHER = 1): NOT MEASURED
FLAMMABILITY (SOLID, GAS): NOT APPLICABLE
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS:
LOWER EXPLOSIVE LIMIT: NOT MEASURED
UPPER EXPLOSIVE LIMIT: NOT MEASURED
VAPOR PRESSURE (PA): NEGLIGIBLE
VAPOR DENSITY: NOT MEASURED
SPECIFIC GRAVITY: NEUTRAL=2.28
SOLUBILITY IN WATER: <1% SLIGHTLY
PARTITION COEFFICIENT N-OCTANOL/WATER (LOG KOW): NOT MEASURED
AUTO-IGNITION TEMPERATURE: NOT MEASURED
DECOMPOSITION TEMPERATURE: NOT MEASURED
VISCOSITY (CST): NOT MEASURED
VOC %: NOT APPLICABLE
% VOLATILE: NO APPLICABLE
9.2. OTHER INFORMATION: NO OTHER RELEVANT INFORMATION.
| 10. STABILITY AND REACTIVITY | |
10.1. REACTIVITY: HAZARDOUS POLYMERIZATION WILL NOT OCCUR.
10.2. CHEMICAL STABILITY: STABLE UNDER NORMAL CIRCUMSTANCES.
10.3. POSSIBILITY OF HAZARDOUS REACTIONS: NO DATA AVAILABLE.
10.4. CONDITIONS TO AVOID: NO DATA AVAILABLE.
10.5. INCOMPATIBLE MATERIALS:
HYDROFLUORIC ACID AND STRONG BASES SUCH AS SODIUM HYDROXIDE.
10.6. HAZARDOUS DECOMPOSITION PRODUCTS:
REACTS WITH HYDROFLUORIC ACID TO FORM TOXIC SILICON TETRA FLUORIDE GAS.
THERMAL DECOMPOSITION MAY PRODUCE NITROGEN OXIDES (NOX), CARBON OXIDES.
| 11. TOXICOLOGICAL INFORMATION | |
ACUTE TOXICITY:
INGREDIENT ORAL LD50, SKIN LD50, INHALATION
MG/KG MG/KG VAPOR LD50,
MG/L/4HR
2-PROPENOIC ACID, POLYMER >5,000.00, NO DATA NO DATA
WITH SODIUM 2-PROPENOATE - RAT - CATEGORY: AVAILABLE AVAILABLE
(9033-79-8) NA
AMORPHOUS ALUMINA NO DATA NO DATA NO DATA
SILICATE PERLITE - AVAILABLE AVAILABLE AVAILABLE
(93763-70-3)
INGREDIENT INHALATION INHALATION
DUST/MIST LD50, MG/L/4HR GAS LD50, PPM
2-PROPENOIC ACID, POLYMER NO DATA AVAILABLE NO DATA AVAILABLE
WITH SODIUM 2-PROPENOATE
AMORPHOUS ALUMINA NO DATA AVAILABLE NO DATA AVAILABLE
SILICATE PERLITE
NOTE:
WHEN NO ROUTE SPECIFIC LD50 DATA IS AVAILABLE FOR AN ACUTE TOXIN, THE
CONVERTED ACUTE TOXICITY POINT ESTIMATE WAS USED IN THE CALCULATION OF
THE PRODUCT'S ATE (ACUTE TOXICITY ESTIMATE).
CLASSIFICATION CATEGORY HAZARD DESCRIPTION
ACUTE TOXICITY (ORAL) NOT APPLICABLE
ACUTE TOXICITY (DERMAL) NOT APPLICABLE
ACUTE TOXICITY (INHALATION) NOT APPLICABLE
SKIN CORROSION/IRRITATION NOT APPLICABLE
SERIOUS EYE DAMAGE/IRRITATION NOT APPLICABLE
RESPIRATORY SENSITIZATION NOT APPLICABLE
SKIN SENSITIZATION NOT APPLICABLE
GERM CELL MUTAGENICITY NOT APPLICABLE
CARCINOGENICITY NOT APPLICABLE
REPRODUCTIVE TOXICITY NOT APPLICABLE
STOT-SINGLE EXPOSURE NOT APPLICABLE
STOT-REPEATED EXPOSURE NOT APPLICABLE
ASPIRATION HAZARD NOT APPLICABLE
| 12. ECOLOGICAL INFORMATION | |
12.1. TOXICITY:
NO ADDITIONAL INFORMATION PROVIDED FOR THIS PRODUCT. SEE SECTION 3 FOR
CHEMICAL SPECIFIC DATA.
AQUATIC ECO TOXICITY:
INGREDIENT 96 HR LC50 48 HR EC50 ERC50
FISH, MG/L CRUSTACEA, MG/L ALGAE, MG/L
2-PROPENOIC ACID, POLYMER NOT AVAILABLE NOT AVAILABLE NOT AVAILABLE
WITH SODIUM 2-PROPENOATE -
(9033-79-8)
AMORPHOUS ALUMINA NOT AVAILABLE NOT AVAILABLE NOT AVAILABLE
SILICATE PERLITE -
(93763-70-3)
12.2. PERSISTENCE AND DEGRADABILITY:
THERE IS NO DATA AVAILABLE ON THE PREPARATION ITSELF.
12.3. BIO ACCUMULATIVE POTENTIAL: NOT MEASURED
12.4. MOBILITY IN SOIL: NO DATA AVAILABLE.
12.5. RESULTS OF PBT AND VPVB ASSESSMENT:
THIS PRODUCT CONTAINS NO PBT/VPVB CHEMICALS.
12.6. OTHER ADVERSE EFFECTS: NO DATA AVAILABLE.
| 13. DISPOSAL CONSIDERATIONS | |
13.1. WASTE TREATMENT METHODS:
OBSERVE ALL FEDERAL, STATE AND LOCAL REGULATIONS WHEN DISPOSING OF THIS
SUBSTANCE.
| 14. TRANSPORT INFORMATION | |
DOT (DOMESTIC SURFACE IMO / IMDG (OCEAN ICAO/IATA
TRANSPORTATION) TRANSPORTATION)
14.1. UN NUMBER NOT APPLICABLE NOT REGULATED NOT REGULATED
14.2. UN PROPER NOT REGULATED NOT REGULATED NOT REGULATED
SHIPPING NAME
14.3. TRANSPORT DOT HAZARD CLASS: IMDG: AIR CLASS:
HAZARD CLASS(ES) NOT APPLICABLE NOT APPLICABLE NOT APPLICABLE
DOT LABEL: SUB CLASS:
NOT APPLICABLE
14.4. PACKING NOT APPLICABLE NOT APPLICABLE NOT APPLICABLE
GROUP
14.5. ENVIRONMENTAL HAZARDS:
IMDG:
MARINE POLLUTANT: NO
14.6. SPECIAL PRECAUTIONS FOR USER: NO FURTHER INFORMATION
| 15. REGULATORY INFORMATION | |
REGULATORY OVERVIEW THE REGULATORY DATA IN SECTION 15 IS NOT INTENDED TO
BE ALL-INCLUSIVE, ONLY SELECTED REGULATIONS ARE REPRESENTED.
TOXIC SUBSTANCE CONTROL ACT ( TSCA):
ALL COMPONENTS OF THIS MATERIAL ARE EITHER LISTED OR EXEMPT FROM LISTING
ON THE TSCA INVENTORY.
WHMIS CLASSIFICATION: NOT REGULATED
US EPA TIER II HAZARDS:
FIRE: NO
SUDDEN RELEASE OF PRESSURE: NO
REACTIVE: NO
IMMEDIATE (ACUTE): NO
DELAYED (CHRONIC): NO
EPCRA 311/312 CHEMICALS AND RQS:
TO THE BEST OF OUR KNOWLEDGE, THERE ARE NO CHEMICALS AT LEVELS WHICH
REQUIRE REPORTING UNDER THIS STATUTE.
EPCRA 302 EXTREMELY HAZARDOUS:
TO THE BEST OF OUR KNOWLEDGE, THERE ARE NO CHEMICALS AT LEVELS WHICH
REQUIRE REPORTING UNDER THIS STATUTE.
EPCRA 313 TOXIC CHEMICALS:
TO THE BEST OF OUR KNOWLEDGE, THERE ARE NO CHEMICALS AT LEVELS WHICH
REQUIRE REPORTING UNDER THIS STATUTE.
PROPOSITION 65 - CARCINOGENS (>0.0%):
TO THE BEST OF OUR KNOWLEDGE, THERE ARE NO CHEMICALS AT LEVELS WHICH
REQUIRE REPORTING UNDER THIS STATUTE.
PROPOSITION 65 - DEVELOPMENTAL TOXINS (>0.0%):
TO THE BEST OF OUR KNOWLEDGE, THERE ARE NO CHEMICALS AT LEVELS WHICH
REQUIRE REPORTING UNDER THIS STATUTE.
PROPOSITION 65 - FEMALE REPRO TOXINS (>0.0%):
TO THE BEST OF OUR KNOWLEDGE, THERE ARE NO CHEMICALS AT LEVELS WHICH
REQUIRE REPORTING UNDER THIS STATUTE.
PROPOSITION 65 - MALE REPRO TOXINS (>0.0%):
TO THE BEST OF OUR KNOWLEDGE, THERE ARE NO CHEMICALS AT LEVELS WHICH
REQUIRE REPORTING UNDER THIS STATUTE.
N.J. RTK SUBSTANCES (>1%): AMORPHOUS ALUMINA SILICATE PERLITE
PENN RTK SUBSTANCES (>1%): AMORPHOUS ALUMINA SILICATE PERLITE
| 16. OTHER INFORMATION | |
THE INFORMATION AND RECOMMENDATIONS CONTAINED HEREIN ARE BASED UPON DATA
BELIEVED TO BE CORRECT. HOWEVER, NO GUARANTEE OR WARRANTY OF ANY KIND,
EXPRESSED OR IMPLIED, IS MADE WITH RESPECT TO THE INFORMATION CONTAINED
HEREIN. WE ACCEPT NO RESPONSIBILITY AND DISCLAIM ALL LIABILITY FOR ANY
HARMFUL EFFECTS WHICH MAY BE CAUSED BY EXPOSURE TO OUR PRODUCTS. CUSTOMERS
/USERS OF THIS PRODUCT MUST COMPLY WITH ALL APPLICABLE HEALTH AND SAFETY
LAWS, REGULATIONS, AND ORDERS.
THE FULL TEXT OF THE PHRASES APPEARING IN SECTION 3 IS: NOT APPLICABLE
THIS IS THE FIRST VERSION IN THE GHS SDS FORMAT. LISTINGS OF CHANGES FROM
PREVIOUS VERSIONS IN OTHER FORMATS ARE NOT APPLICABLE.
THE INFORMATION HEREIN IS PRESENTED IN GOOD FAITH AND BELIEVED TO BE
ACCURATE AS OF THE EFFECTIVE DATE GIVEN. HOWEVER, NO WARRANTY, EXPRESSED
OR IMPLIED, IS GIVEN. IT IS THE BUYER'S RESPONSIBILITY TO ENSURE THAT ITS
ACTIVITIES COMPLY WITH FEDERAL, STATE OR PROVINCIAL AND LOCAL LAWS.