| Common Name: | UNVRSL SSPR 6PK FLAT MET SOFT IRON, 271473 |
| Manufacturer: | RUST-OLEUM |
| SDS Revision Date: | 11/5/2018 |
| SDS Format: | GHS-US |
| Item Number(s): | 40PM68 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
DATE PRINTED: 11/5/2018
SAFETY DATA SHEET
RUST-OLEUM CORPORATION
TRUSTED QUALITY SINCE 1921
WWW.RUSTOLEUM.COM
| 1. IDENTIFICATION |  |
PRODUCT NAME: UNVRSL SSPR 6PK FLAT MET SOFT IRON
PRODUCT IDENTIFIER: 271473
RECOMMENDED USE: TOPCOAT/AEROSOLS
REVISION DATE: 11/5/2018
SUPERCEDES DATE: 10/30/2017
SUPPLIER:
RUST-OLEUM CORPORATION
11 HAWTHORN PARKWAY
VERNON HILLS, IL 60061
USA
MANUFACTURER:
RUST-OLEUM CORPORATION
11 HAWTHORN PARKWAY
VERNON HILLS, IL 60061
USA
PREPARER: REGULATORY DEPARTMENT
EMERGENCY TELEPHONE:
24 HOUR HOTLINE: 847-367-7700
| 2. HAZARD IDENTIFICATION | |
CLASSIFICATION:
SYMBOL(S) OF PRODUCT:
FLAME
EXCLAMATION MARK
HEALTH HAZARD
GAS CYLINDER
SIGNAL WORD: DANGER
POSSIBLE HAZARDS:
32% OF THE MIXTURE CONSISTS OF INGREDIENT(S) OF UNKNOWN ACUTE TOXICITY.
GHS HAZARD STATEMENTS:
CARCINOGENICITY, CATEGORY 1B:
H350: MAY CAUSE CANCER.
COMPRESSED GAS:
H280: CONTAINS GAS UNDER PRESSURE; MAY EXPLODE IF HEATED.
EYE IRRITATION, CATEGORY 2:
H319: CAUSES SERIOUS EYE IRRITATION.
FLAMMABLE AEROSOL, CATEGORY 1:
H222: EXTREMELY FLAMMABLE AEROSOL.
GERM CELL MUTAGENICITY, CATEGORY 1B:
H340: MAY CAUSE GENETIC DEFECTS.
STOT, REPEATED EXPOSURE, CATEGORY 2:
H373: MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
STOT, SINGLE EXPOSURE, CATEGORY 3, NE:
H336: MAY CAUSE DROWSINESS OR DIZZINESS.
GHS LABEL PRECAUTIONARY STATEMENTS:
P201: OBTAIN SPECIAL INSTRUCTIONS BEFORE USE.
P210:
KEEP AWAY FROM HEAT, HOT SURFACES, SPARKS, OPEN FLAMES AND OTHER IGNITION
SOURCES. NO SMOKING.
P211: DO NOT SPRAY ON AN OPEN FLAME OR OTHER IGNITION SOURCE.
P251: DO NOT PIERCE OR BURN, EVEN AFTER USE.
P260: DO NOT BREATHE DUST/FUME/GAS/MIST/VAPORS/SPRAY.
P264: WASH HANDS THOROUGHLY AFTER HANDLING.
P271: USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA.
P280:
WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION.
P304+P340:
IF INHALED: REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING.
P305+P351+P338:
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
P308+P313:
IF EXPOSED OR CONCERNED: GET MEDICAL ADVICE/ATTENTION.
P312: CALL A POISON CENTER OR DOCTOR/PHYSICIAN IF YOU FEEL UNWELL.
P337+P313:
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
P403+P233: STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED.
P405: STORE LOCKED UP.
P410+P403: PROTECT FROM SUNLIGHT. STORE IN A WELL-VENTILATED PLACE.
P410+P412:
PROTECT FROM SUNLIGHT. DO NOT EXPOSE TO TEMPERATURES EXCEEDING
50 DEG. C / 122 DEG. F.
P501:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH LOCAL, REGIONAL AND
NATIONAL REGULATIONS.
| 3. COMPOSITION / INFORMATION ON INGREDIENTS | |
HAZARDOUS SUBSTANCES:
CHEMICAL NAME CAS-NO. WT.% GHS SYMBOLS GHS STATEMENTS
RANGE
ACETONE 67-64-1 25-50 GHS02-GHS07 H225-319-
332-336
PROPANE 74-98-6 10-25 GHS04 H280
N-BUTYL ACETATE 123-86-4 10-25 GHS02-GHS07 H226-336
N-BUTANE 106-97-8 2.5-10 GHS04 H280
NAPHTHA, PETROLEUM, 64742-49-0 2.5-10 GHS08 H304
HYDROTREATED LIGHT
DIMETHYL CARBONATE 616-38-6 2.5-10 GHS02 H225
XYLENES (O-, M-, 1330-20-7 2.5-10 GHS02-GHS07 H226-315-
P- ISOMERS) 319-332
1-METHOXY-2-PROPYL 108-65-6 1.0-2.5 GHS02 H226
ACETATE
PROPYLENE GLYCOL 5131-66-8 1.0-2.5 GHS07 H302-315-319
MONOBUTYL ETHER
ETHYLBENZENE 100-41-4 1.0-2.5 GHS08-GHS07- H225-304-
332-351-373
SOLVENT NAPHTHA, 64742-95-6 0.1-1.0 GHS07-GHS08 H304-332-
LIGHT AROMATIC 340-350
CARBON BLACK 1333-86-4 0.1-1.0 NOT NOT
AVAILABLE AVAILABLE
ETHANOL 64-17-5 0.1-1.0 GHS02 H225
BIS(1,2,2,6,6- 41556-26-7 0.1-1.0 GHS07 H317
PENTAMETHYL-4-
PIPERIDINYL)
SEBACATE
| 4. FIRST-AID MEASURES | |
FIRST AID - EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES HOLDING
EYELIDS OPEN. GET MEDICAL ATTENTION. DO NOT ALLOW RUBBING OF EYES OR
KEEPING EYES CLOSED.
FIRST AID - SKIN CONTACT:
WASH SKIN WITH SOAP AND WATER. REMOVE CONTAMINATED CLOTHING. GET MEDICAL
ATTENTION IF IRRITATION DEVELOPS OR PERSISTS.
FIRST AID - INHALATION:
REMOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. GET IMMEDIATE MEDICAL ATTENTION. DO
NOT USE MOUTH-TO-MOUTH RESUSCITATION. IF YOU EXPERIENCE DIFFICULTY IN
BREATHING, LEAVE THE AREA TO OBTAIN FRESH AIR. IF CONTINUED DIFFICULTY IS
EXPERIENCED, GET MEDICAL ASSISTANCE IMMEDIATELY.
FIRST AID - INGESTION:
ASPIRATION HAZARD:
DO NOT INDUCE VOMITING OR GIVE ANYTHING BY MOUTH BECAUSE THIS MATERIAL
CAN ENTER THE LUNGS AND CAUSE SEVERE LUNG DAMAGE. GET IMMEDIATE MEDICAL
ATTENTION. IF SWALLOWED, GET MEDICAL ATTENTION.
| 5. FIRE-FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
ALCOHOL FILM FORMING FOAM, CARBON DIOXIDE, DRY CHEMICAL, DRY SAND, WATER
FOG
UNUSUAL FIRE AND EXPLOSION HAZARDS:
FLASH POINT IS LESS THAN 20 DEG. F. EXTREMELY FLAMMABLE LIQUID AND VAPOR!
WATER SPRAY MAY BE INEFFECTIVE. CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED
TO EXTREME HEAT DUE TO BUILDUP OF STEAM. CLOSED CONTAINERS MAY EXPLODE
WHEN EXPOSED TO EXTREME HEAT. VAPORS MAY FORM EXPLOSIVE MIXTURES WITH AIR.
VAPORS CAN TRAVEL TO A SOURCE OF IGNITION AND FLASH BACK. KEEP CONTAINERS
TIGHTLY CLOSED. ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS AND OPEN
FLAME. PERFORATION OF THE PRESSURIZED CONTAINER MAY CAUSE BURSTING OF THE
CAN. NO UNUSUAL FIRE OR EXPLOSION HAZARDS NOTED.
SPECIAL FIREFIGHTING PROCEDURES:
WATER MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT PRESSURE BUILDUP AND
POSSIBLE AUTOIGNITION OR EXPLOSION. FULL PROTECTIVE EQUIPMENT INCLUDING
SELF-CONTAINED BREATHING APPARATUS SHOULD BE USED. EVACUATE AREA AND FIGHT
FIRE FROM A SAFE DISTANCE. USE WATER SPRAY TO KEEP FIRE-EXPOSED CONTAINERS
COOL. CONTAINERS MAY EXPLODE WHEN HEATED.
SPECIAL FIRE AND EXPLOSION HAZARD (COMBUSTIBLE DUST): NO INFORMATION
| 6. ACCIDENTAL RELEASE MEASURES | |
STEPS TO BE TAKEN IF MATERIAL IS RELEASED OR SPILLED:
CONTAIN SPILLED LIQUID WITH SAND OR EARTH. DO NOT USE COMBUSTIBLE MATERIALS
SUCH AS SAWDUST. ISOLATE THE HAZARD AREA AND DENY ENTRY TO UNNECESSARY AND
UNPROTECTED PERSONNEL.
REMOVE ALL SOURCES OF IGNITION, VENTILATE AREA AND REMOVE WITH INERT
ABSORBENT AND NON-SPARKING TOOLS. DISPOSE OF ACCORDING TO LOCAL, STATE
(PROVINCIAL) AND FEDERAL REGULATIONS. DO NOT INCINERATE CLOSED CONTAINERS.
VENTILATE AREA, ISOLATE SPILLED MATERIAL, AND REMOVE WITH INERT ABSORBENT.
DISPOSE OF CONTAMINATED ABSORBENT, CONTAINER, AND UNUSED CONTENTS IN
ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS.
| 7. HANDLING AND STORAGE | |
HANDLING:
WASH THOROUGHLY AFTER HANDLING. WASH HANDS BEFORE EATING. REMOVE
CONTAMINATED CLOTHING AND LAUNDER BEFORE REUSE. USE ONLY IN A
WELL-VENTILATED AREA. USE ONLY WITH ADEQUATE VENTILATION. FOLLOW ALL SDS
AND LABEL PRECAUTIONS EVEN AFTER CONTAINER IS EMPTIED BECAUSE IT MAY RETAIN
PRODUCT RESIDUES. AVOID BREATHING FUMES, VAPORS, OR MIST. AVOID CONTACT
WITH EYES, SKIN AND CLOTHING. STORAGE: STORE IN A DRY, WELL VENTILATED
PLACE. KEEP CONTAINER TIGHTLY CLOSED WHEN NOT IN USE. KEEP CONTAINERS
TIGHTLY CLOSED. ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS AND OPEN
FLAME. CONTENTS UNDER PRESSURE. DO NOT STORE ABOVE 120 DEG. F. STORE LARGE
QUANTITIES IN BUILDINGS DESIGNED AND PROTECTED FOR STORAGE OF FLAMMABLE
AEROSOLS. KEEP AWAY FROM HEAT, SPARKS, FLAME AND SOURCES OF IGNITION.
CONTENTS UNDER PRESSURE. DO NOT EXPOSE TO HEAT OR STORE ABOVE 120 DEG. F.
AVOID EXCESS HEAT. PRODUCT SHOULD BE STORED IN TIGHTLY SEALED CONTAINERS
AND PROTECTED FROM HEAT, MOISTURE, AND FOREIGN MATERIALS.
ADVICE ON SAFE HANDLING OF COMBUSTIBLE DUST: NO INFORMATION
| 8. EXPOSURE CONTROLS / PERSONAL PROTECTION | |
CHEMICAL NAME CAS-NO. WEIGHT % LESS THAN
ACETONE 67-64-1 30.0
PROPANE 74-98-6 25.0
N-BUTYL ACETATE 123-86-4 15.0
N-BUTANE 106-97-8 10.0
NAPHTHA, PETROLEUM, HYDROTREATED LIGHT 64742-49-0 5.0
DIMETHYL CARBONATE 616-38-6 5.0
XYLENES (O-, M-, P- ISOMERS) 1330-20-7 5.0
1-METHOXY-2-PROPYL ACETATE 108-65-6 5.0
PROPYLENE GLYCOL MONOBUTYL ETHER 5131-66-8 5.0
ETHYLBENZENE 100-41-4 5.0
SOLVENT NAPHTHA, LIGHT AROMATIC 64742-95-6 1.0
CARBON BLACK 1333-86-4 1.0
ETHANOL 64-17-5 1.0
BIS(1,2,2,6,6-PENTAMETHYL- 41556-26-7 1.0
4-PIPERIDINYL) SEBACATE
CHEMICAL NAME ACGIH ACGIH OSHA OSHA
TLV-TWA TLV-STEL PEL-TWA PEL-CEILING
ACETONE 250 PPM 500 PPM 1000 PPM N.E.
PROPANE N.E. N.E. 1000 PPM N.E.
N-BUTYL ACETATE 50 PPM 150 PPM 150 PPM N.E.
N-BUTANE N.E. 1000 PPM N.E. N.E.
NAPHTHA, PETROLEUM, N.E. N.E. N.E. N.E.
HYDROTREATED LIGHT
DIMETHYL CARBONATE N.E. N.E. N.E. N.E.
XYLENES (O-, M-, 100 PPM 150 PPM 100 PPM N.E.
P- ISOMERS)
1-METHOXY-2-PROPYL N.E. N.E. N.E. N.E.
ACETATE
PROPYLENE GLYCOL N.E. N.E. N.E. N.E.
MONOBUTYL ETHER
ETHYLBENZENE 20 PPM N.E. 100 PPM N.E.
SOLVENT NAPHTHA, N.E. N.E. N.E. N.E.
LIGHT AROMATIC
CARBON BLACK 3 MG/M3 N.E. 3.5 MG/M3 N.E.
ETHANOL N.E. 1000 PPM 1000 PPM N.E.
BIS(1,2,2,6,6- N.E. N.E. N.E. N.E.
PENTAMETHYL-4-
PIPERIDINYL)
SEBACATE
PERSONAL PROTECTION:
ENGINEERING CONTROLS:
USE PROCESS ENCLOSURES, LOCAL EXHAUST VENTILATION, OR OTHER ENGINEERING
CONTROLS TO CONTROL AIRBORNE LEVELS BELOW RECOMMENDED EXPOSURE LIMITS. USE
EXPLOSION-PROOF VENTILATION EQUIPMENT. PROVIDE GENERAL DILUTION OF LOCAL
EXHAUST VENTILATION IN VOLUME AND PATTERN TO KEEP TLV OF HAZARDOUS
INGREDIENTS BELOW ACCEPTABLE LIMITS. PREVENT BUILD-UP OF VAPORS BY OPENING
ALL DOORS AND WINDOWS TO ACHIEVE CROSS-VENTILATION.
RESPIRATORY PROTECTION:
A RESPIRATORY PROTECTION PROGRAM THAT MEETS OSHA 1910.134 AND ANSI Z88.2
REQUIREMENTS MUST BE FOLLOWED WHENEVER WORKPLACE CONDITIONS WARRANT A
RESPIRATOR'S USE. A NIOSH/MSHA APPROVED AIR PURIFYING RESPIRATOR WITH
ORGANIC VAPOR CARTRIDGE OR CANISTER MAY BE PERMISSIBLE UNDER CERTAIN
CIRCUMSTANCES WHERE AIRBORNE CONCENTRATIONS ARE EXPECTED TO EXCEED
EXPOSURE LIMITS.
SKIN PROTECTION:
USE GLOVES TO PREVENT PROLONGED SKIN CONTACT. USE IMPERVIOUS GLOVES TO
PREVENT SKIN CONTACT AND ABSORPTION OF THIS MATERIAL THROUGH THE SKIN.
NITRILE OR NEOPRENE GLOVES MAY AFFORD ADEQUATE SKIN PROTECTION.
EYE PROTECTION:
USE SAFETY EYEWEAR DESIGNED TO PROTECT AGAINST SPLASH OF LIQUIDS.
OTHER PROTECTIVE EQUIPMENT:
REFER TO SAFETY SUPERVISOR OR INDUSTRIAL HYGIENIST FOR FURTHER GUIDANCE
REGARDING TYPES OF PERSONAL PROTECTIVE EQUIPMENT AND THEIR APPLICATIONS.
REFER TO SAFETY SUPERVISOR OR INDUSTRIAL HYGIENIST FOR FURTHER INFORMATION
REGARDING PERSONAL PROTECTIVE EQUIPMENT AND ITS APPLICATION.
HYGIENIC PRACTICES:
WASH THOROUGHLY WITH SOAP AND WATER BEFORE EATING, DRINKING OR SMOKING.
REMOVE CONTAMINATED CLOTHING IMMEDIATELY AND LAUNDER BEFORE REUSE.
ENGINEERING MEASURES FOR COMBUSTIBLE DUST: NO INFORMATION
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: AEROSOLIZED MIST
PHYSICAL STATE: LIQUID
ODOR: SOLVENT LIKE
ODOR THRESHOLD: N.E.
RELATIVE DENSITY: 0.736
PH: N.A.
FREEZE POINT, DEG. C: N.D.
VISCOSITY: N.D.
SOLUBILITY IN WATER: SLIGHT
PARTITION COEFFICIENT, N-OCTANOL/WATER: N.D.
DECOMPOSITION TEMP., DEG. C: N.D.
BOILING RANGE, DEG. C: -37 - 537
EXPLOSIVE LIMITS, VOL%: 0.9 - 13.0
FLAMMABILITY: SUPPORTS COMBUSTION
FLASH POINT, DEG. C: -96
EVAPORATION RATE: FASTER THAN ETHER
AUTO-IGNITION TEMP., DEG. C: N.D.
VAPOR DENSITY: HEAVIER THAN AIR
VAPOR PRESSURE: N.D.
(SEE "OTHER INFORMATION" SECTION FOR ABBREVIATION LEGEND)
| 10. STABILITY AND REACTIVITY | |
CONDITIONS TO AVOID:
AVOID TEMPERATURES ABOVE 120 DEG. F (49 DEG. C). AVOID ALL POSSIBLE SOURCES
OF IGNITION.
INCOMPATIBILITY:
INCOMPATIBLE WITH STRONG OXIDIZING AGENTS, STRONG ACIDS AND STRONG
ALKALIES.
HAZARDOUS DECOMPOSITION:
BY OPEN FLAME, CARBON MONOXIDE AND CARBON DIOXIDE. WHEN HEATED TO
DECOMPOSITION, IT EMITS ACRID SMOKE AND IRRITATING FUMES. CONTAINS
SOLVENTS WHICH MAY FORM CARBON MONOXIDE, CARBON DIOXIDE, AND FORMALDEHYDE.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR UNDER NORMAL CONDITIONS.
STABILITY: THIS PRODUCT IS STABLE UNDER NORMAL STORAGE CONDITIONS.
| 11. TOXICOLOGICAL INFORMATION | |
EFFECTS OF OVEREXPOSURE - EYE CONTACT: CAUSES SERIOUS EYE IRRITATION
EFFECTS OF OVEREXPOSURE - SKIN CONTACT:
SUBSTANCE MAY CAUSE SLIGHT SKIN IRRITATION. MAY CAUSE SKIN IRRITATION.
ALLERGIC REACTIONS ARE POSSIBLE. MAY CAUSE SKIN SENSITIZATION, AN ALLERGIC
REACTION, WHICH BECOMES EVIDENT UPON RE-EXPOSURE TO THIS MATERIAL.
PROLONGED OR REPEATED CONTACT MAY CAUSE SKIN IRRITATION.
EFFECTS OF OVEREXPOSURE - INHALATION:
HARMFUL IF INHALED. HIGH GAS, VAPOR, MIST OR DUST CONCENTRATIONS MAY BE
HARMFUL IF INHALED. AVOID BREATHING FUMES, SPRAY, VAPORS, OR MIST. HIGH
VAPOR CONCENTRATIONS ARE IRRITATING TO THE EYES, NOSE, THROAT AND LUNGS.
PROLONGED OR EXCESSIVE INHALATION MAY CAUSE RESPIRATORY TRACT IRRITATION.
EFFECTS OF OVEREXPOSURE - INGESTION:
HARMFUL IF SWALLOWED. ASPIRATION HAZARD IF SWALLOWED; CAN ENTER LUNGS AND
CAUSE DAMAGE.
EFFECTS OF OVEREXPOSURE - CHRONIC HAZARDS:
MAY CAUSE CENTRAL NERVOUS SYSTEM DISORDER (E.G., NARCOSIS INVOLVING A LOSS
OF COORDINATION, WEAKNESS, FATIGUE, MENTAL CONFUSION, AND BLURRED VISION)
AND/OR DAMAGE. HIGH CONCENTRATIONS MAY LEAD TO CENTRAL NERVOUS SYSTEM
EFFECTS (DROWSINESS, DIZZINESS, NAUSEA, HEADACHES, PARALYSIS, AND BLURRED
VISION) AND/OR DAMAGE. REPORTS HAVE ASSOCIATED REPEATED AND PROLONGED
OCCUPATIONAL OVEREXPOSURE TO SOLVENTS WITH PERMANENT BRAIN AND NERVOUS
SYSTEM DAMAGE. OVEREXPOSURE TO XYLENE IN LABORATORY ANIMALS HAS BEEN
ASSOCIATED WITH LIVER ABNORMALITIES, KIDNEY, LUNG, SPLEEN, EYE AND BLOOD
DAMAGE AS WELL AS REPRODUCTIVE DISORDERS. EFFECTS IN HUMANS, DUE TO CHRONIC
OVEREXPOSURE, HAVE INCLUDED LIVER, CARDIAC ABNORMALITIES AND NERVOUS SYSTEM
DAMAGE. CONTAINS CARBON BLACK. CHRONIC INFLAMMATION, LUNG FIBROSIS, AND
LUNG TUMORS HAVE BEEN OBSERVED IN SOME RATS EXPERIMENTALLY EXPOSED FOR LONG
PERIODS OF TIME TO EXCESSIVE CONCENTRATIONS OF CARBON BLACK AND SEVERAL
INSOLUBLE FINE DUST PARTICLES. TUMORS HAVE NOT BEEN OBSERVED IN OTHER
ANIMAL SPECIES (I.E., MOUSE AND HAMSTER) UNDER SIMILAR CIRCUMSTANCES AND
STUDY CONDITIONS. EPIDEMIOLOGICAL STUDIES OF NORTH AMERICAN WORKERS SHOW
NO EVIDENCE OF CLINICALLY SIGNIFICANT ADVERSE HEALTH EFFECTS DUE TO
OCCUPATIONAL EXPOSURE TO CARBON BLACK.
CARBON BLACK IS LISTED AS A GROUP 2B-"POSSIBLY CARCINOGENIC TO HUMANS" BY
IARC AND IS PROPOSED TO BE LISTED AS A4- "NOT CLASSIFIED AS A HUMAN
CARCINOGEN" BY THE AMERICAN CONFERENCE OF GOVERNMENTAL INDUSTRIAL
HYGIENISTS. SIGNIFICANT EXPOSURE IS NOT ANTICIPATED DURING BRUSH
APPLICATION OR DRYING. RISK OF OVEREXPOSURE DEPENDS ON DURATION AND LEVEL
OF EXPOSURE TO DUST FROM REPEATED SANDING OF SURFACES OR SPRAY MIST AND
THE ACTUAL CONCENTRATION OF CARBON BLACK IN THE FORMULA. IARC LISTS
ETHYLBENZENE AS A POSSIBLE HUMAN CARCINOGEN (GROUP 2B).
PRIMARY ROUTE(S) OF ENTRY:
EYE CONTACT, INGESTION, INHALATION, SKIN ABSORPTION, SKIN CONTACT
ACUTE TOXICITY VALUES:
THE ACUTE EFFECTS OF THIS PRODUCT HAVE NOT BEEN TESTED. DATA ON INDIVIDUAL
COMPONENTS ARE TABULATED BELOW:
CAS-NO. CHEMICAL NAME ORAL LD50 DERMAL LD50 VAPOR LC50
67-64-1 ACETONE 5800 MG/KG >15700 MG/KG 50.1 MG/L
RAT RABBIT RAT
123-86-4 N-BUTYL ACETATE 10768 MG/KG >17600 MG/KG >21 MG/L
RAT RABBIT RAT
106-97-8 N-BUTANE N.E. N.E. 658 MG/L
RAT
64742-49-0 NAPHTHA, PETROLEUM, >5000 MG/KG >3160 MG/KG >4951 MG/L
HYDROTREATED LIGHT RAT RABBIT RAT
616-38-6 DIMETHYL CARBONATE 13000 MG/KG >5000 MG/KG 140 MG/L
RAT RABBIT RAT
1330-20-7 XYLENES (O-, M-, 3500 MG/KG >4350 MG/KG 29.08 MG/L
P- ISOMERS) RAT RABBIT RAT
108-65-6 1-METHOXY-2-PROPYL 8532 MG/KG >5000 MG/KG N.E.
ACETATE RAT RABBIT
5131-66-8 PROPYLENE GLYCOL 1900 MG/KG N.E. N.E.
MONOBUTYL ETHER RAT
100-41-4 ETHYLBENZENE 3500 MG/KG 15400 MG/KG 17.4 MG/L
RAT RABBIT RAT
64742-95-6 SOLVENT NAPHTHA, 8400 MG/KG >2000 MG/KG N.E.
LIGHT AROMATIC RAT RABBIT
1333-86-4 CARBON BLACK >15400 MG/KG N.E. N.E.
RAT
64-17-5 ETHANOL 7060 MG/KG 15,800 MG/KG 30,000 MG/L
RAT RABBIT RAT
41556-26-7 BIS(1,2,2,6,6- 2615 MG/KG N.E. N.E.
PENTAMETHYL-4- RAT
PIPERIDINYL)
SEBACATE
N.E. - NOT ESTABLISHED
| 12. ECOLOGICAL INFORMATION | |
ECOLOGICAL INFORMATION:
PRODUCT IS A MIXTURE OF LISTED COMPONENTS. PRODUCT IS A MIXTURE OF LISTED
COMPONENTS.
| 13. DISPOSAL INFORMATION | |
DISPOSAL INFORMATION:
DO NOT INCINERATE CLOSED CONTAINERS. DISPOSE OF MATERIAL IN ACCORDANCE TO
LOCAL, STATE, AND FEDERAL REGULATIONS AND ORDINANCES. DO NOT ALLOW TO ENTER
WATERWAYS, WASTEWATER, SOIL, STORM DRAINS OR SEWER SYSTEMS. THIS PRODUCT AS
SUPPLIED IS A USEPA DEFINED IGNITABLE HAZARDOUS WASTE. DISPOSE OF UNUSABLE
PRODUCT AS A HAZARDOUS WASTE (D001) IN ACCORDANCE WITH LOCAL, STATE, AND
FEDERAL REGULATION.
| 14. TRANSPORT INFORMATION | |
DOMESTIC INTERNATIONAL AIR (IATA) TDG (CANADA)
(USDOT) (IMDG)
UN NUMBER N.A. 1950 1950 N.A.
PROPER PAINT AND AEROSOLS AEROSOLS, AEROSOLS
SHIPPING NAME RELATED SPRAY FLAMMABLE
PRODUCTS IN
LTD QTY
HAZARD CLASS N.A. 2 2.1 N.A.
PACKING GROUP N.A. N.A. N.A. N.A.
LIMITED YES YES YES YES
QUANTITY
| 15. REGULATORY INFORMATION | |
U.S. FEDERAL REGULATIONS:
CERCLA - SARA HAZARD CATEGORY:
THIS PRODUCT HAS BEEN REVIEWED ACCORDING TO THE EPA 'HAZARD CATEGORIES'
PROMULGATED UNDER SECTIONS 311 AND 312 OF THE SUPERFUND AMENDMENT AND
REAUTHORIZATION ACT OF 1986 (SARA TITLE III) AND IS CONSIDERED, UNDER
APPLICABLE DEFINITIONS, TO MEET THE FOLLOWING CATEGORIES:
GAS UNDER PRESSURE, CARCINOGENICITY, SERIOUS EYE DAMAGE OR EYE IRRITATION,
SPECIFIC TARGET ORGAN TOXICITY (SINGLE OR REPEATED EXPOSURE), GERM CELL
MUTAGENICITY
SARA SECTION 313:
THIS PRODUCT CONTAINS THE FOLLOWING SUBSTANCES SUBJECT TO THE REPORTING
REQUIREMENTS OF SECTION 313 OF TITLE III OF THE SUPERFUND AMENDMENT AND
REAUTHORIZATION ACT OF 1986 AND 40 CFR PART 372:
CHEMICAL NAME CAS-NO.
XYLENES (O-, M-, P- ISOMERS) 1330-20-7
ETHYLBENZENE 100-41-4
TOXIC SUBSTANCES CONTROL ACT:
THIS PRODUCT CONTAINS THE FOLLOWING CHEMICAL SUBSTANCES SUBJECT TO THE
REPORTING REQUIREMENTS OF TSCA 12(B) IF EXPORTED FROM THE UNITED STATES:
NO TSCA 12(B) COMPONENTS EXIST IN THIS PRODUCT.
U.S. STATE REGULATIONS:
CALIFORNIA PROPOSITION 65:
WARNING: CANCER AND REPRODUCTIVE HARM - WWW.P65WARNINGS.CA.GOV.
| 16. OTHER INFORMATION | |
HMIS RATINGS:
HEALTH 2*
FLAMMABILITY 4
PHYSICAL HAZARD 0
PERSONAL PROTECTION X
NFPA RATINGS:
HEALTH 2
FLAMMABILITY 4
INSTABILITY 0
VOLATILE ORGANIC COMPOUNDS: 567 G/L
SDS REVISION DATE: 11/5/2018
REASON FOR REVISION:
REVISION DESCRIPTION CHANGED
PRODUCT COMPOSITION CHANGED
SUBSTANCE AND/OR PRODUCT PROPERTIES CHANGED IN SECTION(S):
02 - HAZARD IDENTIFICATION
03 - COMPOSITION/INFORMATION ON INGREDIENTS
08 - EXPOSURE CONTROLS/PERSONAL PROTECTION
11 - TOXICOLOGICAL INFORMATION
14 - TRANSPORT INFORMATION
15 - REGULATORY INFORMATION
16 - OTHER INFORMATION
SUBSTANCE CHEMICAL NAME CHANGED
REVISION STATEMENT(S) CHANGED
LEGEND:
N.A. - NOT APPLICABLE
N.E. - NOT ESTABLISHED
N.D. - NOT DETERMINED
RUST-OLEUM CORPORATION BELIEVES, TO THE BEST OF ITS KNOWLEDGE, INFORMATION
AND BELIEF, THE INFORMATION CONTAINED HEREIN TO BE ACCURATE AND RELIABLE AS
OF THE DATE OF THIS SAFETY DATA SHEET. HOWEVER, BECAUSE THE CONDITIONS OF
HANDLING, USE, AND STORAGE OF THESE MATERIALS ARE BEYOND OUR CONTROL, WE
ASSUME NO RESPONSIBILITY OR LIABILITY FOR PERSONAL INJURY OR PROPERTY
DAMAGE INCURRED BY THE USE OF THESE MATERIALS. RUST-OLEUM CORPORATION MAKES
NO WARRANTY, EXPRESSED OR IMPLIED, REGARDING THE ACCURACY OR RELIABILITY OF
THE DATA OR RESULTS OBTAINED FROM THEIR USE. ALL MATERIALS MAY PRESENT
UNKNOWN HAZARDS AND SHOULD BE USED WITH CAUTION. THE INFORMATION AND
RECOMMENDATIONS IN THIS MATERIAL SAFETY DATA SHEET ARE OFFERED FOR THE
USERS' CONSIDERATION AND EXAMINATION. IT IS THE RESPONSIBILITY OF THE USER
TO DETERMINE THE FINAL SUITABILITY OF THIS INFORMATION AND TO COMPLY WITH
ALL APPLICABLE INTERNATIONAL, FEDERAL, STATE, AND LOCAL LAWS AND
REGULATIONS.