| Common Name: | LAVA BAR |
| Manufacturer: | WD-40 |
| SDS Revision Date: | 7/18/2018 |
| SDS Format: | GHS-US |
| Item Number(s): | 392C98, 41D708 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
LAV(R*)
WD-40 COMPANY
SAFETY DATA SHEET
| 1 - IDENTIFICATION |  |
PRODUCT NAME: LAVA BAR
PRODUCT USE: HAND CLEANER
RESTRICTIONS ON USE: NONE IDENTIFIED
SDS DATE OF PREPARATION: JULY 18, 2018
MANUFACTURER: WD-40 COMPANY
ADDRESS:
9715 BUSINESS PARK AVENUE
SAN DIEGO, CALIFORNIA 92131
USA
TELEPHONE:
EMERGENCY: 1-888-324-7596
INFORMATION: 1-888-324-7596
CHEMICAL SPILLS:
1-800-424-9300 (CHEMTREC)
1-703-527-3887 (INTERNATIONAL CALLS)
| 2 - HAZARDS IDENTIFICATION | |
HAZCOM 2012/GHS CLASSIFICATION:
EYE IRRITANT: CATEGORY 2A
NOTE:
THIS PRODUCT IS A CONSUMER PRODUCT AND IS LABELED IN ACCORDANCE WITH THE US
CONSUMER PRODUCT SAFETY COMMISSION REGULATIONS WHICH TAKE PRECEDENCE OVER
OSHA HAZARD COMMUNICATION LABELING. THE ACTUAL CONTAINER LABEL WILL NOT
INCLUDE THE LABEL ELEMENTS BELOW. THE LABELING BELOW APPLIES TO
INDUSTRIAL/PROFESSIONAL PRODUCTS.
LABEL ELEMENTS: EXCLAMATION MARK
WARNING!
CAUSES SERIOUS EYE IRRITATION.
PREVENTION: RINSE HANDS THOROUGHLY AFTER USE.
RESPONSE:
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE OR ATTENTION.
| 3 - COMPOSITION/INFORMATION ON INGREDIENTS | |
INGREDIENT CAS # WEIGHT US HAZCOM 2012/
PERCENT GHS CLASSIFICATION
PUMICE 1332-09-8 10-30% NOT HAZARDOUS
COCONUT ACID MIXTURE <3% EYE DAMAGE CATEGORY 1
TITANIUM DIOXIDE 13463-67-7 0.1-1% CARCINOGEN CATEGORY 2*
NON-HAZARDOUS INGREDIENTS MIXTURE BALANCE NOT HAZARDOUS
NOTE: THE EXACT PERCENTAGES ARE A TRADE SECRET.
* CARCINOGEN CLASSIFICATION APPLIES TO RESPIRABLE FORMS ONLY. NOT
APPLICABLE TO THIS PRODUCT.
| 4 - FIRST AID MEASURES | |
INGESTION (SWALLOWED):
IF LARGE AMOUNT IS SWALLOWED AND SYMPTOMS OCCUR, CALL A PHYSICIAN, POISON
CONTROL CENTER, OR THE WD-40 SAFETY HOTLINE AT 1-888-324-7596. RINSE MOUTH
WITH WATER AND GIVE ONE EIGHT-OUNCE GLASS OF WATER TO DRINK IF THE PATIENT
IF CONSCIOUS AND RESPONSIVE.
EYE CONTACT:
DO NOT RUB EYES. FLUSH IMMEDIATELY WITH LARGE AMOUNTS OF WATER. GET MEDICAL
ATTENTION IF IRRITATION PERSISTS.
SKIN CONTACT:
THIS PRODUCT IS INTENDED FOR SKIN CONTACT. DISCONTINUE USE AND CONSULT A
PHYSICIAN IF IRRITATION DEVELOPS AND PERSISTS.
INHALATION (BREATHING): NO FIRST AID SHOULD BE REQUIRED.
SIGNS AND SYMPTOMS OF EXPOSURE: MAY CAUSE EYE IRRITATION.
INDICATION OF IMMEDIATE MEDICAL ATTENTION/SPECIAL TREATMENT NEEDED:
IMMEDIATE MEDICAL ATTENTION IS NOT REQUIRED.
| 5 - FIRE FIGHTING MEASURES | |
SUITABLE (AND UNSUITABLE) EXTINGUISHING MEDIA:
USE ANY MEDIA THAT IS APPROPRIATE FOR THE SURROUNDING FIRE.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL: NONE KNOWN.
SPECIAL PROTECTIVE EQUIPMENT AND PRECAUTIONS FOR FIRE-FIGHTERS:
NONE REQUIRED.
| 6 - ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
NONE REQUIRED.
METHODS AND MATERIALS FOR CONTAINMENT/CLEANUP:
PICK UP FOR USE OR PLACE IN TRASH.
| 7 - HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING: AVOID CONTACT WITH EYES.
CONDITIONS FOR SAFE STORAGE: NO SPECIAL STORAGE REQUIRED.
| 8 - EXPOSURE CONTROLS/PERSONAL PROTECTION | |
CHEMICAL OCCUPATIONAL EXPOSURE LIMITS
PUMICE 5 MG/M3 (RESPIRABLE), 15 MG/M3 (TOTAL DUST)TWA
OSHA PEL
COCONUT ACID NONE ESTABLISHED
TITANIUM DIOXIDE 10 MG/M3 TWA ACGIH TLV
15 MG/M3 (TOTAL DUST) TWA OSHA PEL
NON-HAZARDOUS INGREDIENTS NONE ESTABLISHED
THE FOLLOWING CONTROLS ARE RECOMMENDED FOR NORMAL CONSUMER USE OF THIS
PRODUCT
APPROPRIATE ENGINEERING CONTROLS: NONE REQUIRED
PERSONAL PROTECTION:
EYE PROTECTION: NONE REQUIRED, AVOID EYE CONTACT.
SKIN PROTECTION: NONE REQUIRED, THIS PRODUCT IS INTENDED FOR SKIN CONTACT.
RESPIRATORY PROTECTION: NONE REQUIRED.
FOR BULK PROCESSING OR WORKPLACE USE THE FOLLOWING CONTROLS ARE
RECOMMENDED:
APPROPRIATE ENGINEERING CONTROLS:
GOOD GENERAL VENTILATION SHOULD BE ADEQUATE.
PERSONAL PROTECTION:
EYE PROTECTION: SAFETY GOGGLES RECOMMENDED IF DUST OR MISTS ARE GENERATED.
SKIN PROTECTION:
NONE REQUIRED FOR ANTICIPATED USE, THIS PRODUCT IS INTENDED FOR SKIN
CONTACT.
RESPIRATORY PROTECTION: NONE REQUIRED.
WORK/HYGIENE PRACTICES: RINSE THOROUGHLY AFTER WASHING OR HANDLING.
| 9 - PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: GREEN SOLID
ODOR: PLEASANT FRAGRANCE
ODOR THRESHOLD: NOT ESTABLISHED
PH: NOT APPLICABLE
MELTING/FREEZING POINT: NOT APPLICABLE
BOILING POINT/RANGE: NOT APPLICABLE
FLASH POINT: NONE
EVAPORATION RATE: NOT APPLICABLE
FLAMMABILITY (SOLID, GAS): NOT FLAMMABLE
VOC: 0%
FLAMMABLE LIMITS: NOT APPLICABLE
VAPOR PRESSURE: NOT APPLICABLE
VAPOR DENSITY: NOT APPLICABLE
RELATIVE DENSITY: >1
SOLUBILITIES: SOLUBLE IN WATER
PARTITION COEFFICIENT; N-OCTANOL/WATER: NOT ESTABLISHED
AUTOIGNITION TEMPERATURE: NOT ESTABLISHED
DECOMPOSITION TEMPERATURE: NOT ESTABLISHED
VISCOSITY: NOT APPLICABLE
POUR POINT: NOT APPLICABLE
| 10 - STABILITY AND REACTIVITY | |
REACTIVITY: NOT REACTIVE UNDER NORMAL CONDITIONS
CHEMICAL STABILITY: STABLE
POSSIBILITY OF HAZARDOUS REACTIONS: NONE KNOWN.
CONDITIONS TO AVOID: NONE KNOWN.
INCOMPATIBLE MATERIALS: NONE KNOWN.
HAZARDOUS DECOMPOSITION PRODUCTS:
COMBUSTION WILL PRODUCE OXIDES OF CARBON AND NITROGEN.
| 11 - TOXICOLOGICAL INFORMATION | |
SYMPTOMS OF OVEREXPOSURE:
INHALATION: NONE KNOWN
SKIN CONTACT:
PROLONGED CONTACT MAY CAUSE IRRITATION IN SENSITIVE INDIVIDUALS.
EYE CONTACT:
MAY CAUSE IRRITATION WITH REDNESS, STINGING AND TEARING. PUMICE MAY CAUSE
ABRASIVE INJURY TO THE EYE.
INGESTION:
NOT INTENDED FOR INGESTION, HOWEVER, NOT EXPECTED TO BE TOXIC. MAY CAUSE
GASTROINTESTINAL IRRITATION.
CHRONIC EFFECTS: NONE KNOWN.
CARCINOGEN STATUS:
THIS PRODUCT CONTAINS SMALL AMOUNT OF TITANIUM DIOXIDE, WHICH IS LISTED BY
IARC AS A SUSPECTED CARCINOGEN (GROUP 2B). TITANIUM DIOXIDE ONLY PRESENTS A
RISK OF CANCER BY INHALATION OF VERY FINE DUST. IN THIS PRODUCT, THE
TITANIUM DIOXIDE IS INCORPORATED INTO THE SOAP AND IS NOT PRESENT AS A
RESPIRABLE DUST. THERE IS NO EXPOSURE TO RESPIRABLE TITANIUM DIOXIDE DUST
IN THE NORMAL USE OF THIS PRODUCT. NONE OF THE OTHER COMPONENTS ARE LISTED
AS A CARCINOGEN OR SUSPECT CARCINOGEN BY IARC, NTP, ACGIH OR OSHA.
REPRODUCTIVE TOXICITY:
NONE OF THE COMPONENTS IS CONSIDERED A REPRODUCTIVE HAZARD.
NUMERICAL MEASURES OF TOXICITY:
THE ORAL TOXICITY OF THIS PRODUCT IS ESTIMATED TO BE GREATER THAN 5,000
MG/KG AND THE DERMAL TOXICITY GREATER THAN 2,000 MG/KG BASED ON AN
ASSESSMENT OF THE INGREDIENTS. THIS PRODUCT IS NOT CLASSIFIED AS TOXIC
BY ESTABLISHED CRITERIA.
| 12 - ECOLOGICAL INFORMATION | |
ECOTOXICITY:
NO SPECIFIC AQUATIC TOXICITY DATA IS CURRENTLY AVAILABLE, HOWEVER
COMPONENTS OF THIS PRODUCT ARE NOT EXPECTED TO BE HARMFUL TO AQUATIC
ORGANISMS
PERSISTENCE AND DEGRADABILITY: NO DATA AVAILABLE.
BIOACCUMULATIVE POTENTIAL: NO DATA AVAILABLE.
MOBILITY IN SOIL: NO DATA AVAILABLE
OTHER ADVERSE EFFECTS: NONE KNOWN
| 13 - DISPOSAL CONSIDERATIONS | |
DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS.
| 14 - TRANSPORTATION INFORMATION | |
NOT REGULATED FOR TRANSPORTATION BY ANY MODE
| 15 - REGULATORY INFORMATION | |
U.S. FEDERAL REGULATIONS:
CERCLA 103 REPORTABLE QUANTITY:
THIS PRODUCT IS NOT SUBJECT TO CERCLA REPORTING REQUIREMENT. MANY STATES
HAVE MORE STRINGENT RELEASE REPORTING REQUIREMENTS. REPORT SPILLS REQUIRED
UNDER FEDERAL, STATE AND LOCAL REGULATIONS.
SARA TITLE III:
HAZARD CATEGORY FOR SECTION 311/312:
SEE OSHA HAZARD CLASSIFICATION IN SECTION 2.
SECTION 313 TOXIC CHEMICALS:
THIS PRODUCT CONTAINS THE FOLLOWING CHEMICALS SUBJECT TO SARA TITLE III
SECTION 313 REPORTING REQUIREMENTS: NONE
SECTION 302 EXTREMELY HAZARDOUS SUBSTANCES (TPQ): NONE
EPA TOXIC SUBSTANCES CONTROL ACT (TSCA) STATUS:
ALL OF THE COMPONENTS OF THIS PRODUCT ARE LISTED ON THE TSCA INVENTORY.
CALIFORNIA SAFE DRINKING WATER AND TOXIC ENFORCEMENT ACT (PROPOSITION 65):
THIS PRODUCT DOES NOT REQUIRE A CALIFORNIA PROPOSITION 65 WARNING.
| 16 - OTHER INFORMATION | |
HMIS HAZARD RATING:
HEALTH 1 (SLIGHT HAZARD)
FIRE HAZARD 0 (MINIMAL HAZARD)
PHYSICAL HAZARD 0 (MINIMAL HAZARD)
REVISION DATE: JULY 18, 2018
SUPERSEDES: SEPTEMBER 21, 2017
REVISION SUMMARY: ADDRESS AND TELEPHONE NUMBER UPDATE IN SECTION 1.
PREPARED BY:
INDUSTRIAL HEALTH & SAFETY CONSULTANTS, INC.
SHELTON, CT
USA
REVIEWED BY:
I. KOWALSKI
REGULATORY AFFAIRS
3042200/NO.0098003