| Common Name: | BESTUFF 1 CS 12 QTS |
| Manufacturer: | ZEP MANUFACTURING |
| SDS Revision Date: | 4/20/2015 |
| SDS Format: | GHS-US |
| Item Number(s): | 43NR85 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
ZEP INC
SAFETY DATA SHEET
ZEP BESTUFF 1 CS 12 QTS
VERSION: 1.1
REVISION DATE: 04/20/2015
PRINT DATE: 01/18/2016
| SECTION 1. PRODUCT AND COMPANY IDENTIFICATION |  |
MATERIAL NAME: ZEP BESTUFF 1 CS 12 QTS
MATERIAL NUMBER: 000000000000106601
MANUFACTURER OR SUPPLIER'S DETAILS:
COMPANY: ZEP INC.
ADDRESS:
1310 SEABOARD INDUSTRIAL BLVD., NW
ATLANTA, GA 30318
TELEPHONE: 404-352-1680
EMERGENCY TELEPHONE NUMBERS:
FOR SDS INFORMATION:
COMPLIANCE SERVICES: 1-877-428-9937
FOR A MEDICAL EMERGENCY: 877-541-2016 TOLL FREE - ALL CALLS RECORDED
FOR A TRANSPORTATION EMERGENCY:
CHEMTREC: 800-424-9300 - ALL CALLS RECORDED.
IN THE DISTRICT OF COLUMBIA: 202-483-7616
| SECTION 2. HAZARDS IDENTIFICATION | |
EMERGENCY OVERVIEW:
APPEARANCE: LIQUID
COLOUR:
OPAQUE
GREEN
ODOUR: CHARACTERISTIC
GHS CLASSIFICATION:
EYE IRRITATION: CATEGORY 2A
GHS LABEL ELEMENT:
HAZARD PICTOGRAMS: EXCLAMATION MARK
SIGNAL WORD: WARNING
HAZARD STATEMENTS:
H319: CAUSES SERIOUS EYE IRRITATION.
PRECAUTIONARY STATEMENTS:
PREVENTION:
P264: WASH SKIN THOROUGHLY AFTER HANDLING.
P280: WEAR EYE PROTECTION/FACE PROTECTION.
RESPONSE:
P305 + P351 + P338:
IF IN EYES: RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE
CONTACT LENSES, IF PRESENT AND EASY TO DO. CONTINUE RINSING.
P337 + P313:
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
POTENTIAL HEALTH EFFECTS:
CARCINOGENICITY:
IARC:
NO COMPONENT OF THIS PRODUCT PRESENT AT LEVELS GREATER THAN OR EQUAL TO
0.1% IS IDENTIFIED AS PROBABLE, POSSIBLE OR CONFIRMED HUMAN CARCINOGEN BY
IARC.
ACGIH:
NO COMPONENT OF THIS PRODUCT PRESENT AT LEVELS GREATER THAN OR EQUAL TO
0.1% IS IDENTIFIED AS A CARCINOGEN OR POTENTIAL CARCINOGEN BY ACGIH.
OSHA:
NO COMPONENT OF THIS PRODUCT PRESENT AT LEVELS GREATER THAN OR EQUAL TO
0.1% IS IDENTIFIED AS A CARCINOGEN OR POTENTIAL CARCINOGEN BY OSHA.
NTP:
NO COMPONENT OF THIS PRODUCT PRESENT AT LEVELS GREATER THAN OR EQUAL TO
0.1% IS IDENTIFIED AS A KNOWN OR ANTICIPATED CARCINOGEN BY NTP.
| SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
SUBSTANCE / MIXTURE: MIXTURE
HAZARDOUS COMPONENTS:
CHEMICAL NAME CAS-NO. CONCENTRATION [%]
CALCIUM CARBONATE 1317-65-3 >=20 - <30
TETRASODIUM ETHYLENEDIAMINETETRAACETATE 64-02-8 >=1 - <5
PINE OIL 8002-09-3 >=1 - <5
METHACRYLIC ACID, POLYMER WITH ETHYL ACR 25212-88-8 >=1 - <5
| SECTION 4. FIRST AID MEASURES | |
GENERAL ADVICE:
MOVE OUT OF DANGEROUS AREA.
SHOW THIS SAFETY DATA SHEET TO THE DOCTOR IN ATTENDANCE.
DO NOT LEAVE THE VICTIM UNATTENDED.
IF INHALED:
IF UNCONSCIOUS PLACE IN RECOVERY POSITION AND SEEK MEDICAL ADVICE.
IF SYMPTOMS PERSIST, CALL A PHYSICIAN.
MOVE TO FRESH AIR.
IN CASE OF SKIN CONTACT:
TAKE OFF CONTAMINATED CLOTHING AND SHOES IMMEDIATELY.
GET MEDICAL ATTENTION IF IRRITATION DEVELOPS AND PERSISTS.
WASH CONTAMINATED CLOTHING BEFORE RE-USE.
WASH OFF IMMEDIATELY WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.
IF SYMPTOMS PERSIST, CALL A PHYSICIAN.
IN CASE OF EYE CONTACT:
IF EASY TO DO, REMOVE CONTACT LENS, IF WORN.
IF EYE IRRITATION PERSISTS, CONSULT A SPECIALIST.
IF IN EYES, RINSE WITH WATER FOR 15 MINUTES.
IF SWALLOWED:
IF SYMPTOMS PERSIST, CALL A PHYSICIAN.
DRINK PLENTY OF WATER.
DO NOT INDUCE VOMITING UNLESS DIRECTED TO DO SO BY A PHYSICIAN OR POISON
CONTROL CENTER.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON. TAKE VICTIM
IMMEDIATELY TO HOSPITAL.
| SECTION 5. FIREFIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
DRY CHEMICAL
WATER
CARBON DIOXIDE (CO2)
FOAM
UNSUITABLE EXTINGUISHING MEDIA: HIGH VOLUME WATER JET
HAZARDOUS COMBUSTION PRODUCTS:
CARBON DIOXIDE (CO2)
CARBON MONOXIDE
NITROGEN OXIDES (NOX)
SMOKE
SPECIFIC EXTINGUISHING METHODS:
USE EXTINGUISHING MEASURES THAT ARE APPROPRIATE TO LOCAL CIRCUMSTANCES AND
THE SURROUNDING ENVIRONMENT.
FURTHER INFORMATION:
STANDARD PROCEDURE FOR CHEMICAL FIRES.
STANDARD PROCEDURE FOR CHEMICAL FIRES.
USE EXTINGUISHING MEASURES THAT ARE APPROPRIATE TO LOCAL
CIRCUMSTANCES AND THE SURROUNDING ENVIRONMENT.
SPECIAL PROTECTIVE EQUIPMENT FOR FIREFIGHTERS:
WEAR SELF-CONTAINED BREATHING APPARATUS FOR FIREFIGHTING IF NECESSARY.
| SECTION 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
USE PERSONAL PROTECTIVE EQUIPMENT.
ENVIRONMENTAL PRECAUTIONS:
PREVENT FURTHER LEAKAGE OR SPILLAGE IF SAFE TO DO SO.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
SOAK UP WITH INERT ABSORBENT MATERIAL (E.G. SAND, SILICA GEL, ACID BINDER,
UNIVERSAL BINDER, SAWDUST).
SWEEP UP OR VACUUM UP SPILLAGE AND COLLECT IN SUITABLE CONTAINER FOR
DISPOSAL.
KEEP IN SUITABLE, CLOSED CONTAINERS FOR DISPOSAL.
| SECTION 7. HANDLING AND STORAGE | |
ADVICE ON SAFE HANDLING:
DO NOT BREATHE VAPOURS/DUST.
AVOID CONTACT WITH SKIN AND EYES.
FOR PERSONAL PROTECTION SEE SECTION 8.
SMOKING, EATING AND DRINKING SHOULD BE PROHIBITED IN THE APPLICATION AREA.
DISPOSE OF RINSE WATER IN ACCORDANCE WITH LOCAL AND NATIONAL REGULATIONS.
CONDITIONS FOR SAFE STORAGE:
KEEP CONTAINER TIGHTLY CLOSED IN A DRY AND WELL-VENTILATED PLACE.
ELECTRICAL INSTALLATIONS / WORKING MATERIALS MUST COMPLY WITH THE
TECHNOLOGICAL SAFETY STANDARDS.
MATERIALS TO AVOID:
OXIDIZING AGENTS
DO NOT FREEZE.
DO NOT STORE NEAR ACIDS.
| SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
COMPONENTS WITH WORKPLACE CONTROL PARAMETERS:
COMPONENTS CAS-NO. VALUE TYPE CONTROL BASIS
(FORM OF PARAMETERS /
EXPOSURE) PERMISSIBLE
CONCENTRATION
| CALCIUM CARBONATE 1317-65-3 TWA 5 MG/M3 NIOSH REL
| (RESPIRABLE)
TWA (TOTAL) 10 MG/M3 NIOSH REL
| TWA 5 MG/M3 NIOSH REL
| (RESPIRABLE)
| TWA (TOTAL) 10 MG/M3 NIOSH REL
| TWA 5 MG/M3 NIOSH REL
| (RESPIRABLE)
| TWA (TOTAL) 10 MG/M3 NIOSH REL
| TWA 15 MG/M3 OSHA Z-1
| (TOTAL DUST)
TWA 5 MG/M3 OSHA Z-1
| (RESPIRABLE
| FRACTION)
PERSONAL PROTECTIVE EQUIPMENT:
RESPIRATORY PROTECTION:
USE RESPIRATORY PROTECTION UNLESS ADEQUATE LOCAL EXHAUST VENTILATION IS
PROVIDED OR EXPOSURE ASSESSMENT DEMONSTRATES THAT EXPOSURES ARE WITHIN
RECOMMENDED EXPOSURE GUIDELINES.
HAND PROTECTION:
REMARKS:
SKIN SHOULD BE WASHED AFTER CONTACT. FOR PROLONGED OR REPEATED CONTACT USE
PROTECTIVE GLOVES. THE SUITABILITY FOR A SPECIFIC WORKPLACE SHOULD BE
DISCUSSED WITH THE PRODUCERS OF THE PROTECTIVE GLOVES.
THE SUITABILITY FOR A SPECIFIC WORKPLACE SHOULD BE DISCUSSED WITH THE
PRODUCERS OF THE PROTECTIVE GLOVES.
EYE PROTECTION:
ENSURE THAT EYEWASH STATIONS AND SAFETY SHOWERS ARE CLOSE TO THE
WORKSTATION LOCATION.
SAFETY GLASSES
SKIN AND BODY PROTECTION:
IMPERVIOUS CLOTHING
CHOOSE BODY PROTECTION ACCORDING TO THE AMOUNT AND CONCENTRATION OF THE
DANGEROUS SUBSTANCE AT THE WORK PLACE.
HYGIENE MEASURES:
WHEN USING DO NOT EAT OR DRINK.
WHEN USING DO NOT SMOKE.
WASH HANDS BEFORE BREAKS AND AT THE END OF WORKDAY.
| SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: LIQUID
COLOUR:
OPAQUE
GREEN
ODOUR: CHARACTERISTIC
ODOUR THRESHOLD: NO DATA AVAILABLE
PH: 9.5 - 10.5
MELTING POINT/FREEZING POINT: NOT APPLICABLE
BOILING POINT: 100 DEG. C
FLASH POINT: DOES NOT FLASH
EVAPORATION RATE: <1
UPPER EXPLOSION LIMIT: NO DATA AVAILABLE
LOWER EXPLOSION LIMIT: NO DATA AVAILABLE
VAPOUR PRESSURE: NO DATA AVAILABLE
RELATIVE VAPOUR DENSITY: NO DATA AVAILABLE
DENSITY: 1.22 G/CM3
SOLUBILITY(IES):
WATER SOLUBILITY: INSOLUBLE
SOLUBILITY IN OTHER SOLVENTS: NOT DETERMINED
PARTITION COEFFICIENT N-OCTANOL/WATER: NO DATA AVAILABLE
AUTO-IGNITION TEMPERATURE: NOT DETERMINED
THERMAL DECOMPOSITION: NO DATA AVAILABLE
VISCOSITY:
VISCOSITY, KINEMATIC: NO DATA AVAILABLE
| SECTION 10. STABILITY AND REACTIVITY | |
REACTIVITY: STABLE
CHEMICAL STABILITY: STABLE UNDER NORMAL CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS:
NO DECOMPOSITION IF STORED AND APPLIED AS DIRECTED.
CONDITIONS TO AVOID:
EXTREMES OF TEMPERATURE AND DIRECT SUNLIGHT.
NO DATA AVAILABLE
INCOMPATIBLE MATERIALS:
ACIDS
OXIDIZING AGENTS
HAZARDOUS DECOMPOSITION PRODUCTS:
CARBON MONOXIDE, CARBON DIOXIDE AND UNBURNED HYDROCARBONS (SMOKE).
NITROGEN OXIDES (NOX)
| SECTION 11. TOXICOLOGICAL INFORMATION | |
ACUTE TOXICITY:
PRODUCT:
ACUTE ORAL TOXICITY:
ACUTE TOXICITY ESTIMATE: >5,000 MG/KG
METHOD: CALCULATION METHOD
ACUTE INHALATION TOXICITY:
ACUTE TOXICITY ESTIMATE: >40 MG/L
EXPOSURE TIME: 4 H
TEST ATMOSPHERE: VAPOUR
METHOD: CALCULATION METHOD
SKIN CORROSION/IRRITATION:
PRODUCT:
REMARKS: MAY CAUSE SKIN IRRITATION AND/OR DERMATITIS.
SERIOUS EYE DAMAGE/EYE IRRITATION:
PRODUCT:
REMARKS: EYE IRRITATION
RESPIRATORY OR SKIN SENSITISATION: NO DATA AVAILABLE
GERM CELL MUTAGENICITY: NO DATA AVAILABLE
CARCINOGENICITY: NO DATA AVAILABLE
REPRODUCTIVE TOXICITY: NO DATA AVAILABLE
CALCIUM CARBONATE:
TETRASODIUM ETHYLENEDIAMINETETRAACETATE:
PINE OIL:
METHACRYLIC ACID, POLYMER WITH ETHYL ACR:
STOT - SINGLE EXPOSURE: NO DATA AVAILABLE
STOT - REPEATED EXPOSURE: NO DATA AVAILABLE
ASPIRATION TOXICITY: NO DATA AVAILABLE
FURTHER INFORMATION:
PRODUCT:
REMARKS: NO DATA AVAILABLE
| SECTION 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY: NO DATA AVAILABLE
PERSISTENCE AND DEGRADABILITY: NO DATA AVAILABLE
BIOACCUMULATIVE POTENTIAL:
PRODUCT:
PARTITION COEFFICIENT N-OCTANOL/WATER:
REMARKS: NO DATA AVAILABLE
MOBILITY IN SOIL: NO DATA AVAILABLE
OTHER ADVERSE EFFECTS: NO DATA AVAILABLE
PRODUCT:
REGULATION:
40 CFR PROTECTION OF ENVIRONMENT; PART 82 PROTECTION OF STRATOSPHERIC
OZONE - CAA SECTION 602 CLASS I SUBSTANCES
REMARKS:
THIS PRODUCT NEITHER CONTAINS, NOR WAS MANUFACTURED WITH A CLASS I OR
CLASS II ODS AS DEFINED BY THE U.S. CLEAN AIR ACT SECTION 602 (40 CFR 82,
SUBPT. A, APP.A + B).
ADDITIONAL ECOLOGICAL INFORMATION: NO DATA AVAILABLE
| SECTION 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL METHODS:
WASTE FROM RESIDUES:
DO NOT DISPOSE OF WASTE INTO SEWER.
DO NOT CONTAMINATE PONDS, WATERWAYS OR DITCHES WITH
CHEMICAL OR USED CONTAINER.
DISPOSE OF IN ACCORDANCE WITH LOCAL REGULATIONS.
CONTAMINATED PACKAGING:
EMPTY REMAINING CONTENTS.
DISPOSE OF AS UNUSED PRODUCT.
DO NOT RE-USE EMPTY CONTAINERS.
| SECTION 14. TRANSPORT INFORMATION | |
TRANSPORTATION REGULATION 49 CFR (USA):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
TRANSPORTATION REGULATION IMDG (VESSEL):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
TRANSPORTATION REGULATION IATA (CARGO AIR):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
TRANSPORTATION REGULATION IATA (PASSENGER AIR):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
TRANSPORTATION REGULATION TDG (CANADA):
NOT REGULATED AS DANGEROUS GOODS OR HAZARDOUS MATERIAL
| SECTION 15. REGULATORY INFORMATION | |
EPCRA - EMERGENCY PLANNING AND COMMUNITY RIGHT-TO-KNOW ACT:
CERCLA REPORTABLE QUANTITY:
COMPONENTS CAS-NO. COMPONENT RQ CALCULATED PRODUCT RQ
(LBS) (LBS)
SODIUM HYDROXIDE 1310-73-2 1000 *
*: CALCULATED RQ EXCEEDS REASONABLY ATTAINABLE UPPER LIMIT.
SARA 304 EXTREMELY HAZARDOUS SUBSTANCES REPORTABLE QUANTITY:
THIS MATERIAL DOES NOT CONTAIN ANY COMPONENTS WITH A SECTION 304 EHS RQ.
SARA 311/312 HAZARDS: ACUTE HEALTH HAZARD
SARA 302:
SARA 302:
NO CHEMICALS IN THIS MATERIAL ARE SUBJECT TO THE REPORTING REQUIREMENTS OF
SARA TITLE III, SECTION 302.
SARA 313:
SARA 313:
THIS MATERIAL DOES NOT CONTAIN ANY CHEMICAL COMPONENTS WITH KNOWN CAS
NUMBERS THAT EXCEED THE THRESHOLD (DE MINIMIS) REPORTING LEVELS
ESTABLISHED BY SARA TITLE III, SECTION 313.
CALIFORNIA PROP 65:
THIS PRODUCT DOES NOT CONTAIN ANY CHEMICALS KNOWN TO STATE OF CALIFORNIA
TO CAUSE CANCER, BIRTH DEFECTS, OR ANY OTHER REPRODUCTIVE HARM.
THE COMPONENTS OF THIS PRODUCT ARE REPORTED IN THE FOLLOWING INVENTORIES:
TSCA: ON TSCA INVENTORY
DSL:
THIS PRODUCT CONTAINS ONE OR SEVERAL COMPONENTS THAT ARE NOT ON THE
CANADIAN DSL NOR NDSL.
AICS: NOT IN COMPLIANCE WITH THE INVENTORY
NZIOC: NOT IN COMPLIANCE WITH THE INVENTORY
PICCS: NOT IN COMPLIANCE WITH THE INVENTORY
IECSC: NOT IN COMPLIANCE WITH THE INVENTORY
INVENTORY ACRONYM AND VALIDITY AREA LEGEND:
AICS (AUSTRALIA), DSL (CANADA), IECSC (CHINA), REACH (EUROPEAN UNION),
ENCS (JAPAN), ISHL (JAPAN), KECI (KOREA), NZIOC (NEW ZEALAND),
PICCS (PHILIPPINES), TSCA (USA)
| SECTION 16. OTHER INFORMATION | |
FURTHER INFORMATION:
NFPA:
HEALTH 2
FLAMMABILITY 0
INSTABILITY 0
SPECIAL HAZARD.
HMIS III:
HEALTH 2
FLAMMABILITY 0
PHYSICAL HAZARD 0
0 = NOT SIGNIFICANT
1 = SLIGHT
2 = MODERATE
3 = HIGH
4 = EXTREME
* = CHRONIC
OSHA GHS LABEL INFORMATION:
HAZARD PICTOGRAMS: EXCLAMATION MARK
SIGNAL WORD: WARNING
HAZARD STATEMENTS: CAUSES SERIOUS EYE IRRITATION.
PRECAUTIONARY STATEMENTS:
PREVENTION:
WASH SKIN THOROUGHLY AFTER HANDLING. WEAR EYE PROTECTION/FACE PROTECTION.
RESPONSE:
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES,
IF PRESENT AND EASY TO DO. CONTINUE RINSING.
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
WE BELIEVE THE STATEMENTS, TECHNICAL INFORMATION AND RECOMMENDATIONS
CONTAINED HEREIN ARE RELIABLE, BUT THEY ARE GIVEN WITHOUT WARRANTY OR
GUARANTEE OF ANY KIND. THE INFORMATION IN THIS DOCUMENT APPLIES TO THIS
SPECIFIC MATERIAL AS SUPPLIED. IT MAY NOT BE VALID FOR THIS MATERIAL IF IT
IS USED IN COMBINATION WITH ANY OTHER MATERIALS. USERS SHOULD MAKE THEIR
OWN INVESTIGATIONS TO DETERMINE THE SUITABILITY AND APPLICABILITY OF THE
INFORMATION FOR THEIR PARTICULAR PURPOSES. THIS SDS HAS BEEN PREPARED BY
THE COMPLIANCE SERVICES ORGANIZATION SUPPORTING THIS MANUFACTURER,
SUPPLIER OR DISTRIBUTOR.
ZEP INC. MARKETS PRODUCTS UNDER WELL RECOGNIZED AND ESTABLISHED BRAND
NAMES SUCH AS ZEP(R*), ZEP COMMERCIAL(R*), ZEP PROFESSIONAL(R*),
ENFORCER(R*), NATIONAL CHEMICAL(TM), SELIG(TM), MISTY(R*), NEXT
DIMENSION(TM), PETRO(R*), I-CHEM(R*), TIMEMIST(R*), TIMEWICK(TM),
MICROBEMAX(R*), COUNTRY VET(R*), KONK(R*), ORIGINAL BIKE SPIRITS(R*), BLUE
CORAL(R*), BLACK MAGIC(R*), RAIN-X(R*), NIAGARA NATIONAL(TM), FC FORWARD
CHEMICALS(R*), REXODAN(R*), MYKAL(TM), AND A NUMBER OF PRIVATE LABELED
BRANDS.