| Common Name: | LN-915 TUB SURROUNDS AHE91524CR0 |
| Manufacturer: | PPG INDUSTRIES |
| SDS Revision Date: | 4/1/2017 |
| SDS Format: | GHS-US |
| Item Number(s): | 444D85 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
SAFETY DATA SHEET
PPG
DATE OF ISSUE/DATE OF REVISION: 1 APRIL 2017
VERSION: 9
| SECTION 1. IDENTIFICATION |  |
PRODUCT NAME: LN-915 TUB SURROUNDS AHE91524CR0
PRODUCT CODE: 00407713
OTHER MEANS OF IDENTIFICATION: NOT AVAILABLE.
PRODUCT TYPE: LIQUID.
RELEVANT IDENTIFIED USES OF THE SUBSTANCE OR MIXTURE AND USES ADVISED
AGAINST:
PRODUCT USE: INDUSTRIAL APPLICATIONS.
USE OF THE SUBSTANCE/MIXTURE: ADHESIVE.
USES ADVISED AGAINST: NOT APPLICABLE.
MANUFACTURER:
PPG INDUSTRIES, INC.
ONE PPG PLACE
PITTSBURGH, PA 15272
EMERGENCY TELEPHONE NUMBER:
(412) 434-4515 (U.S.)
(514) 645-1320 (CANADA)
01-800-00-21-400 (MEXICO)
TECHNICAL PHONE NUMBER: 1-800-441-9695 (8:00 AM TO 5:00 PM EST)
| SECTION 2. HAZARDS IDENTIFICATION | |
OSHA/HCS STATUS:
THIS MATERIAL IS CONSIDERED HAZARDOUS BY THE OSHA HAZARD COMMUNICATION
STANDARD (29 CFR 1910.1200).
CLASSIFICATION OF THE SUBSTANCE OR MIXTURE:
FLAMMABLE LIQUIDS: CATEGORY 2
GERM CELL MUTAGENICITY: CATEGORY 1
CARCINOGENICITY: CATEGORY 1A
TOXIC TO REPRODUCTION (FERTILITY): CATEGORY 2
SPECIFIC TARGET ORGAN TOXICITY (REPEATED EXPOSURE): CATEGORY 2
| PERCENTAGE OF THE MIXTURE CONSISTING OF INGREDIENT(S) OF UNKNOWN
| TOXICITY: 58.5%
GHS LABEL ELEMENTS:
HAZARD PICTOGRAMS:
FLAME
HEALTH HAZARD
SIGNAL WORD: DANGER
HAZARD STATEMENTS:
HIGHLY FLAMMABLE LIQUID AND VAPOR.
MAY CAUSE GENETIC DEFECTS.
MAY CAUSE CANCER.
SUSPECTED OF DAMAGING FERTILITY.
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
PRECAUTIONARY STATEMENTS:
PREVENTION:
OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. DO NOT HANDLE UNTIL ALL SAFETY
PRECAUTIONS HAVE BEEN READ AND UNDERSTOOD. WEAR PROTECTIVE GLOVES. WEAR
EYE OR FACE PROTECTION. WEAR PROTECTIVE CLOTHING. KEEP AWAY FROM HEAT,
HOT SURFACES, SPARKS, OPEN FLAMES AND OTHER IGNITION SOURCES. NO SMOKING.
USE EXPLOSION-PROOF ELECTRICAL, VENTILATING, LIGHTING AND ALL
MATERIAL-HANDLING EQUIPMENT. USE ONLY NON-SPARKING TOOLS. TAKE
PRECAUTIONARY MEASURES AGAINST STATIC DISCHARGE. KEEP CONTAINER TIGHTLY
CLOSED. DO NOT BREATHE VAPOR.
RESPONSE:
GET MEDICAL ATTENTION IF YOU FEEL UNWELL.
IF EXPOSED OR CONCERNED: GET MEDICAL ATTENTION.
IF ON SKIN (OR HAIR):
TAKE OFF IMMEDIATELY ALL CONTAMINATED CLOTHING. RINSE SKIN WITH WATER OR
SHOWER.
STORAGE: STORE LOCKED UP. STORE IN A WELL-VENTILATED PLACE. KEEP COOL.
DISPOSAL:
DISPOSE OF CONTENTS AND CONTAINER IN ACCORDANCE WITH ALL LOCAL, REGIONAL,
NATIONAL AND INTERNATIONAL REGULATIONS.
SUPPLEMENTAL LABEL ELEMENTS:
SANDING AND GRINDING DUSTS MAY BE HARMFUL IF INHALED. THIS PRODUCT CONTAINS
CRYSTALLINE SILICA WHICH CAN CAUSE LUNG CANCER OR SILICOSIS. THE RISK OF
CANCER DEPENDS ON THE DURATION AND LEVEL OF EXPOSURE TO DUST FROM SANDING
SURFACES OR MIST FROM SPRAY APPLICATIONS. REPEATED EXPOSURE TO HIGH VAPOR
CONCENTRATIONS MAY CAUSE IRRITATION OF THE RESPIRATORY SYSTEM AND PERMANENT
BRAIN AND NERVOUS SYSTEM DAMAGE. INHALATION OF VAPOR/AEROSOL CONCENTRATIONS
ABOVE THE RECOMMENDED EXPOSURE LIMITS CAUSES HEADACHES, DROWSINESS AND
NAUSEA AND MAY LEAD TO UNCONSCIOUSNESS OR DEATH. AVOID CONTACT WITH SKIN
AND CLOTHING. WASH THOROUGHLY AFTER HANDLING. EMITS TOXIC FUMES WHEN
HEATED.
HAZARDS NOT OTHERWISE CLASSIFIED:
PROLONGED OR REPEATED CONTACT MAY DRY SKIN AND CAUSE IRRITATION.
| SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
SUBSTANCE/MIXTURE: MIXTURE
PRODUCT NAME: LN-915 TUB SURROUNDS AHE91524CR0
INGREDIENT NAME % CAS NUMBER
| LIMESTONE >/=20 - </=50 1317-65-3
DISTILLATES (PETROLEUM), LIGHT DISTILLATE >/=10 - </=20 68410-97-9
HYDROTREATING PROCESS, LOW-BOILING
CYCLOHEXANE >/=5.0 - <10 110-82-7
KAOLIN >/=1.0 - </=5.0 1332-58-7
N-HEXANE <1.0 110-54-3
CRYSTALLINE SILICA, RESPIRABLE POWDER </=1.0 14808-60-7
(>10 MICRONS)
SUB CODES REPRESENT SUBSTANCES WITHOUT REGISTERED CAS NUMBERS.
ANY CONCENTRATION SHOWN AS A RANGE IS TO PROTECT CONFIDENTIALITY OR IS
DUE TO BATCH VARIATION.
THERE ARE NO ADDITIONAL INGREDIENTS PRESENT WHICH, WITHIN THE CURRENT
KNOWLEDGE OF THE SUPPLIER AND IN THE CONCENTRATIONS APPLICABLE, ARE
CLASSIFIED AS HAZARDOUS TO HEALTH OR THE ENVIRONMENT AND HENCE REQUIRE
REPORTING IN THIS SECTION.
OCCUPATIONAL EXPOSURE LIMITS, IF AVAILABLE, ARE LISTED IN SECTION 8.
| SECTION 4. FIRST AID MEASURES | |
IF INGESTION, IRRITATION, ANY TYPE OF OVEREXPOSURE OR SYMPTOMS OF
OVEREXPOSURE OCCUR DURING OR PERSISTS AFTER USE OF THIS PRODUCT, CONTACT
A POISON CONTROL CENTER, EMERGENCY ROOM OR PHYSICIAN IMMEDIATELY; HAVE
SAFETY DATA SHEET INFORMATION AVAILABLE. NEVER GIVE ANYTHING BY MOUTH
TO AN UNCONSCIOUS OR CONVULSING PERSON.
DESCRIPTION OF NECESSARY FIRST AID MEASURES:
EYE CONTACT:
REMOVE CONTACT LENSES, IRRIGATE COPIOUSLY WITH CLEAN, FRESH WATER, HOLDING
THE EYELIDS APART FOR AT LEAST 10 MINUTES AND SEEK IMMEDIATE MEDICAL
ADVICE.
INHALATION:
REMOVE TO FRESH AIR. KEEP PERSON WARM AND AT REST. IF NOT BREATHING, IF
BREATHING IS IRREGULAR OR IF RESPIRATORY ARREST OCCURS, PROVIDE ARTIFICIAL
RESPIRATION OR OXYGEN BY TRAINED PERSONNEL.
SKIN CONTACT:
REMOVE CONTAMINATED CLOTHING AND SHOES. WASH SKIN THOROUGHLY WITH SOAP AND
WATER OR USE RECOGNIZED SKIN CLEANSER. DO NOT USE SOLVENTS OR THINNERS.
INGESTION:
IF SWALLOWED, SEEK MEDICAL ADVICE IMMEDIATELY AND SHOW THIS CONTAINER OR
LABEL. KEEP PERSON WARM AND AT REST. DO NOT INDUCE VOMITING.
MOST IMPORTANT SYMPTOMS/EFFECTS, ACUTE AND DELAYED:
POTENTIAL ACUTE HEALTH EFFECTS:
EYE CONTACT: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
INHALATION: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
SKIN CONTACT: DEFATTING TO THE SKIN. MAY CAUSE SKIN DRYNESS AND IRRITATION.
INGESTION: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
OVER-EXPOSURE SIGNS/SYMPTOMS:
EYE CONTACT: NO SPECIFIC DATA.
INHALATION:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
REDUCED FETAL WEIGHT
INCREASE IN FETAL DEATHS
SKELETAL MALFORMATIONS
SKIN CONTACT:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
IRRITATION
DRYNESS
CRACKING
REDUCED FETAL WEIGHT
INCREASE IN FETAL DEATHS
SKELETAL MALFORMATIONS
INGESTION:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
REDUCED FETAL WEIGHT
INCREASE IN FETAL DEATHS
SKELETAL MALFORMATIONS
INDICATION OF IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED,
IF NECESSARY:
NOTES TO PHYSICIAN:
TREAT SYMPTOMATICALLY. CONTACT POISON TREATMENT SPECIALIST IMMEDIATELY
IF LARGE QUANTITIES HAVE BEEN INGESTED OR INHALED.
SPECIFIC TREATMENTS: NO SPECIFIC TREATMENT.
PROTECTION OF FIRST-AIDERS:
NO ACTION SHALL BE TAKEN INVOLVING ANY PERSONAL RISK OR WITHOUT SUITABLE
TRAINING. IF IT IS SUSPECTED THAT FUMES ARE STILL PRESENT, THE RESCUER
SHOULD WEAR AN APPROPRIATE MASK OR SELF-CONTAINED BREATHING APPARATUS.
IT MAY BE DANGEROUS TO THE PERSON PROVIDING AID TO GIVE MOUTH-TO-MOUTH
RESUSCITATION. WASH CONTAMINATED CLOTHING THOROUGHLY WITH WATER BEFORE
REMOVING IT, OR WEAR GLOVES.
SEE TOXICOLOGICAL INFORMATION (SECTION 11)
| SECTION 5. FIRE-FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
SUITABLE EXTINGUISHING MEDIA:
USE DRY CHEMICAL, CO2, WATER SPRAY (FOG) OR FOAM.
UNSUITABLE EXTINGUISHING MEDIA: DO NOT USE WATER JET.
SPECIFIC HAZARDS ARISING FROM THE CHEMICAL:
HIGHLY FLAMMABLE LIQUID AND VAPOR. IN A FIRE OR IF HEATED, A PRESSURE
INCREASE WILL OCCUR AND THE CONTAINER MAY BURST, WITH THE RISK OF A
SUBSEQUENT EXPLOSION. VAPORS MAY ACCUMULATE IN LOW OR CONFINED AREAS OR
TRAVEL A CONSIDERABLE DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK.
RUNOFF TO SEWER MAY CREATE FIRE OR EXPLOSION HAZARD. THIS MATERIAL IS
TOXIC TO AQUATIC LIFE WITH LONG LASTING EFFECTS. FIRE WATER CONTAMINATED
WITH THIS MATERIAL MUST BE CONTAINED AND PREVENTED FROM BEING DISCHARGED
TO ANY WATERWAY, SEWER OR DRAIN.
HAZARDOUS THERMAL DECOMPOSITION PRODUCTS:
DECOMPOSITION PRODUCTS MAY INCLUDE THE FOLLOWING MATERIALS:
CARBON OXIDES
METAL OXIDE/OXIDES
SPECIAL PROTECTIVE ACTIONS FOR FIRE-FIGHTERS:
PROMPTLY ISOLATE THE SCENE BY REMOVING ALL PERSONS FROM THE VICINITY OF
THE INCIDENT IF THERE IS A FIRE. NO ACTION SHALL BE TAKEN INVOLVING ANY
PERSONAL RISK OR WITHOUT SUITABLE TRAINING. MOVE CONTAINERS FROM FIRE AREA
IF THIS CAN BE DONE WITHOUT RISK. USE WATER SPRAY TO KEEP FIRE-EXPOSED
CONTAINERS COOL.
SPECIAL PROTECTIVE EQUIPMENT FOR FIRE-FIGHTERS:
FIRE-FIGHTERS SHOULD WEAR APPROPRIATE PROTECTIVE EQUIPMENT AND
SELF-CONTAINED BREATHING APPARATUS (SCBA) WITH A FULL FACE-PIECE
OPERATED IN POSITIVE PRESSURE MODE.
| SECTION 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
FOR NON-EMERGENCY PERSONNEL:
NO ACTION SHALL BE TAKEN INVOLVING ANY PERSONAL RISK OR WITHOUT SUITABLE
TRAINING. EVACUATE SURROUNDING AREAS. KEEP UNNECESSARY AND UNPROTECTED
PERSONNEL FROM ENTERING. DO NOT TOUCH OR WALK THROUGH SPILLED MATERIAL.
SHUT OFF ALL IGNITION SOURCES. NO FLARES, SMOKING OR FLAMES IN HAZARD
AREA. AVOID BREATHING VAPOR OR MIST. PROVIDE ADEQUATE VENTILATION. WEAR
APPROPRIATE RESPIRATOR WHEN VENTILATION IS INADEQUATE. PUT ON APPROPRIATE
PERSONAL PROTECTIVE EQUIPMENT.
FOR EMERGENCY RESPONDERS:
IF SPECIALIZED CLOTHING IS REQUIRED TO DEAL WITH THE SPILLAGE, TAKE NOTE
OF ANY INFORMATION IN SECTION 8 ON SUITABLE AND UNSUITABLE MATERIALS.
SEE ALSO THE INFORMATION IN "FOR NON-EMERGENCY PERSONNEL".
ENVIRONMENTAL PRECAUTIONS:
AVOID DISPERSAL OF SPILLED MATERIAL AND RUNOFF AND CONTACT WITH SOIL,
WATERWAYS, DRAINS AND SEWERS. INFORM THE RELEVANT AUTHORITIES IF THE
PRODUCT HAS CAUSED ENVIRONMENTAL POLLUTION (SEWERS, WATERWAYS, SOIL
OR AIR).
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
SMALL SPILL:
STOP LEAK IF WITHOUT RISK. MOVE CONTAINERS FROM SPILL AREA. USE SPARK-PROOF
TOOLS AND EXPLOSION-PROOF EQUIPMENT. DILUTE WITH WATER AND MOP UP IF
WATER-SOLUBLE. ALTERNATIVELY, OR IF WATER-INSOLUBLE, ABSORB WITH AN INERT
DRY MATERIAL AND PLACE IN AN APPROPRIATE WASTE DISPOSAL CONTAINER. DISPOSE
OF VIA A LICENSED WASTE DISPOSAL CONTRACTOR.
LARGE SPILL:
STOP LEAK IF WITHOUT RISK. MOVE CONTAINERS FROM SPILL AREA. USE
SPARK-PROOF TOOLS AND EXPLOSION-PROOF EQUIPMENT. APPROACH RELEASE FROM
UPWIND. PREVENT ENTRY INTO SEWERS, WATER COURSES, BASEMENTS OR CONFINED
AREAS. WASH SPILLAGES INTO AN EFFLUENT TREATMENT PLANT OR PROCEED AS
FOLLOWS. CONTAIN AND COLLECT SPILLAGE WITH NON-COMBUSTIBLE, ABSORBENT
MATERIAL E.G. SAND, EARTH, VERMICULITE OR DIATOMACEOUS EARTH AND PLACE IN
CONTAINER FOR DISPOSAL ACCORDING TO LOCAL REGULATIONS (SEE SECTION 13).
DISPOSE OF VIA A LICENSED WASTE DISPOSAL CONTRACTOR. CONTAMINATED
ABSORBENT MATERIAL MAY POSE THE SAME HAZARD AS THE SPILLED PRODUCT.
NOTE:
SEE SECTION 1 FOR EMERGENCY CONTACT INFORMATION AND SECTION 13 FOR WASTE
DISPOSAL.
| SECTION 7. HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING:
PROTECTIVE MEASURES:
PUT ON APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT (SEE SECTION 8). AVOID
EXPOSURE - OBTAIN SPECIAL INSTRUCTIONS BEFORE USE. AVOID EXPOSURE DURING
PREGNANCY. DO NOT HANDLE UNTIL ALL SAFETY PRECAUTIONS HAVE BEEN READ AND
UNDERSTOOD. DO NOT GET IN EYES OR ON SKIN OR CLOTHING. DO NOT BREATHE
VAPOR OR MIST. DO NOT INGEST. USE ONLY WITH ADEQUATE VENTILATION. WEAR
APPROPRIATE RESPIRATOR WHEN VENTILATION IS INADEQUATE. DO NOT ENTER STORAGE
AREAS AND CONFINED SPACES UNLESS ADEQUATELY VENTILATED. KEEP IN THE
ORIGINAL CONTAINER OR AN APPROVED ALTERNATIVE MADE FROM A COMPATIBLE
MATERIAL, KEPT TIGHTLY CLOSED WHEN NOT IN USE. STORE AND USE AWAY FROM
HEAT, SPARKS, OPEN FLAME OR ANY OTHER IGNITION SOURCE. USE EXPLOSION-PROOF
ELECTRICAL (VENTILATING, LIGHTING AND MATERIAL HANDLING) EQUIPMENT. USE
ONLY NON-SPARKING TOOLS. TAKE PRECAUTIONARY MEASURES AGAINST ELECTROSTATIC
DISCHARGES. EMPTY CONTAINERS RETAIN PRODUCT RESIDUE AND CAN BE HAZARDOUS.
DO NOT REUSE CONTAINER.
SPECIAL PRECAUTIONS:
VAPORS MAY ACCUMULATE IN LOW OR CONFINED AREAS OR TRAVEL A CONSIDERABLE
DISTANCE TO A SOURCE OF IGNITION AND FLASH BACK. VAPORS ARE HEAVIER THAN
AIR AND MAY SPREAD ALONG FLOORS. IF THIS MATERIAL IS PART OF A MULTIPLE
COMPONENT SYSTEM, READ THE SAFETY DATA SHEET(S) FOR THE OTHER COMPONENT OR
COMPONENTS BEFORE BLENDING AS THE RESULTING MIXTURE MAY HAVE THE HAZARDS
OF ALL OF ITS PARTS.
ADVICE ON GENERAL OCCUPATIONAL HYGIENE:
EATING, DRINKING AND SMOKING SHOULD BE PROHIBITED IN AREAS WHERE THIS
MATERIAL IS HANDLED, STORED AND PROCESSED. WORKERS SHOULD WASH HANDS AND
FACE BEFORE EATING, DRINKING AND SMOKING. REMOVE CONTAMINATED CLOTHING
AND PROTECTIVE EQUIPMENT BEFORE ENTERING EATING AREAS. SEE ALSO SECTION 8
FOR ADDITIONAL INFORMATION ON HYGIENE MEASURES.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
DO NOT STORE ABOVE THE FOLLOWING TEMPERATURE: 50 DEG. C (122 DEG. F).
STORE IN ACCORDANCE WITH LOCAL REGULATIONS. STORE IN A SEGREGATED AND
APPROVED AREA. STORE IN ORIGINAL CONTAINER PROTECTED FROM DIRECT SUNLIGHT
IN A DRY, COOL AND WELL-VENTILATED AREA, AWAY FROM INCOMPATIBLE MATERIALS
(SEE SECTION 10) AND FOOD AND DRINK. STORE LOCKED UP. ELIMINATE ALL
IGNITION SOURCES. SEPARATE FROM OXIDIZING MATERIALS. KEEP CONTAINER
TIGHTLY CLOSED AND SEALED UNTIL READY FOR USE. CONTAINERS THAT HAVE BEEN
OPENED MUST BE CAREFULLY RESEALED AND KEPT UPRIGHT TO PREVENT LEAKAGE.
DO NOT STORE IN UNLABELED CONTAINERS. USE APPROPRIATE CONTAINMENT TO AVOID
ENVIRONMENTAL CONTAMINATION.
| SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
CONTROL PARAMETERS:
OCCUPATIONAL EXPOSURE LIMITS:
INGREDIENT NAME EXPOSURE LIMITS
| LIMESTONE OSHA PEL (UNITED STATES, 6/2016).
TWA: 5 MG/M3 8 HOURS.
FORM: RESPIRABLE FRACTION
TWA: 15 MG/M3 8 HOURS.
FORM: TOTAL DUST
DISTILLATES (PETROLEUM), OSHA PEL (UNITED STATES).
LIGHT DISTILLATE HYDROTREATING TWA: 500 PPM
PROCESS, LOW-BOILING
CYCLOHEXANE ACGIH TLV (UNITED STATES, 3/2016).
TWA: 100 PPM 8 HOURS.
OSHA PEL (UNITED STATES, 6/2016).
TWA: 1050 MG/M3 8 HOURS.
TWA: 300 PPM 8 HOURS.
KAOLIN ACGIH TLV (UNITED STATES, 3/2016).
TWA: 2 MG/M3 8 HOURS.
FORM: RESPIRABLE FRACTION
OSHA PEL (UNITED STATES, 6/2016).
TWA: 5 MG/M3 8 HOURS.
FORM: RESPIRABLE FRACTION
TWA: 15 MG/M3 8 HOURS.
FORM: TOTAL DUST
N-HEXANE ACGIH TLV (UNITED STATES, 3/2016).
ABSORBED THROUGH SKIN.
TWA: 50 PPM 8 HOURS.
OSHA PEL (UNITED STATES, 6/2016).
TWA: 1800 MG/M3 8 HOURS.
TWA: 500 PPM 8 HOURS.
CRYSTALLINE SILICA, ACGIH TLV (UNITED STATES, 3/2016).
RESPIRABLE POWDER (>10 MICRONS) TWA: 0.025 MG/M3 8 HOURS.
FORM: RESPIRABLE
OSHA PEL Z3 (UNITED STATES, 6/2016).
TWA: 10 MG/M3 / (%SiO2+2) 8 HOURS.
FORM: RESPIRABLE
TWA: 250 MPPCF / (%SiO2+5) 8 HOURS.
FORM: RESPIRABLE
OSHA PEL (UNITED STATES, 6/2016).
TWA: 50 (MICRO)G/M3 8 HOURS.
FORM: RESPIRABLE DUST
OSHA PEL Z3 (UNITED STATES).
TWA: 30 MG/M3
FORM: TOTAL DUST
KEY TO ABBREVIATIONS:
A = ACCEPTABLE MAXIMUM PEAK
ACGIH = AMERICAN CONFERENCE OF GOVERNMENTAL INDUSTRIAL HYGIENISTS.
C = CEILING LIMIT
F = FUME
IPEL = INTERNAL PERMISSIBLE EXPOSURE LIMIT
OSHA = OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION.
R = RESPIRABLE
S = POTENTIAL SKIN ABSORPTION
SR = RESPIRATORY SENSITIZATION
SS = SKIN SENSITIZATION
STEL = SHORT TERM EXPOSURE LIMIT VALUES
TD = TOTAL DUST
TLV = THRESHOLD LIMIT VALUE
TWA = TIME WEIGHTED AVERAGE
Z = OSHA 29 CFR 1910.1200 SUBPART Z - TOXIC AND HAZARDOUS SUBSTANCES
CONSULT LOCAL AUTHORITIES FOR ACCEPTABLE EXPOSURE LIMITS.
RECOMMENDED MONITORING PROCEDURES:
IF THIS PRODUCT CONTAINS INGREDIENTS WITH EXPOSURE LIMITS, PERSONAL,
WORKPLACE ATMOSPHERE OR BIOLOGICAL MONITORING MAY BE REQUIRED TO DETERMINE
THE EFFECTIVENESS OF THE VENTILATION OR OTHER CONTROL MEASURES AND/OR THE
NECESSITY TO USE RESPIRATORY PROTECTIVE EQUIPMENT. REFERENCE SHOULD BE
MADE TO APPROPRIATE MONITORING STANDARDS. REFERENCE TO NATIONAL GUIDANCE
DOCUMENTS FOR METHODS FOR THE DETERMINATION OF HAZARDOUS SUBSTANCES WILL
ALSO BE REQUIRED.
APPROPRIATE ENGINEERING CONTROLS:
USE ONLY WITH ADEQUATE VENTILATION. USE PROCESS ENCLOSURES, LOCAL EXHAUST
VENTILATION OR OTHER ENGINEERING CONTROLS TO KEEP WORKER EXPOSURE TO
AIRBORNE CONTAMINANTS BELOW ANY RECOMMENDED OR STATUTORY LIMITS. THE
ENGINEERING CONTROLS ALSO NEED TO KEEP GAS, VAPOR OR DUST CONCENTRATIONS
BELOW ANY LOWER EXPLOSIVE LIMITS. USE EXPLOSION-PROOF VENTILATION
EQUIPMENT.
ENVIRONMENTAL EXPOSURE CONTROLS:
EMISSIONS FROM VENTILATION OR WORK PROCESS EQUIPMENT SHOULD BE CHECKED
TO ENSURE THEY COMPLY WITH THE REQUIREMENTS OF ENVIRONMENTAL PROTECTION
LEGISLATION. IN SOME CASES, FUME SCRUBBERS, FILTERS OR ENGINEERING
MODIFICATIONS TO THE PROCESS EQUIPMENT WILL BE NECESSARY TO REDUCE
EMISSIONS TO ACCEPTABLE LEVELS.
INDIVIDUAL PROTECTION MEASURES:
HYGIENE MEASURES:
WASH HANDS, FOREARMS AND FACE THOROUGHLY AFTER HANDLING CHEMICAL PRODUCTS,
BEFORE EATING, SMOKING AND USING THE LAVATORY AND AT THE END OF THE
WORKING PERIOD. APPROPRIATE TECHNIQUES SHOULD BE USED TO REMOVE POTENTIALLY
CONTAMINATED CLOTHING. WASH CONTAMINATED CLOTHING BEFORE REUSING. ENSURE
THAT EYEWASH STATIONS AND SAFETY SHOWERS ARE CLOSE TO THE WORKSTATION
LOCATION.
EYE/FACE PROTECTION: SAFETY GLASSES WITH SIDE SHIELDS.
SKIN PROTECTION:
HAND PROTECTION:
CHEMICAL-RESISTANT, IMPERVIOUS GLOVES COMPLYING WITH AN APPROVED STANDARD
SHOULD BE WORN AT ALL TIMES WHEN HANDLING CHEMICAL PRODUCTS IF A RISK
ASSESSMENT INDICATES THIS IS NECESSARY. CONSIDERING THE PARAMETERS
SPECIFIED BY THE GLOVE MANUFACTURER, CHECK DURING USE THAT THE GLOVES ARE
STILL RETAINING THEIR PROTECTIVE PROPERTIES. IT SHOULD BE NOTED THAT THE
TIME TO BREAKTHROUGH FOR ANY GLOVE MATERIAL MAY BE DIFFERENT FOR DIFFERENT
GLOVE MANUFACTURERS. IN THE CASE OF MIXTURES, CONSISTING OF SEVERAL
SUBSTANCES, THE PROTECTION TIME OF THE GLOVES CANNOT BE ACCURATELY
ESTIMATED.
BODY PROTECTION:
PERSONAL PROTECTIVE EQUIPMENT FOR THE BODY SHOULD BE SELECTED BASED ON THE
TASK BEING PERFORMED AND THE RISKS INVOLVED AND SHOULD BE APPROVED BY A
SPECIALIST BEFORE HANDLING THIS PRODUCT. WHEN THERE IS A RISK OF IGNITION
FROM STATIC ELECTRICITY, WEAR ANTISTATIC PROTECTIVE CLOTHING. FOR THE
GREATEST PROTECTION FROM STATIC DISCHARGES, CLOTHING SHOULD INCLUDE
ANTI-STATIC OVERALLS, BOOTS AND GLOVES.
OTHER SKIN PROTECTION:
APPROPRIATE FOOTWEAR AND ANY ADDITIONAL SKIN PROTECTION MEASURES SHOULD
BE SELECTED BASED ON THE TASK BEING PERFORMED AND THE RISKS INVOLVED AND
SHOULD BE APPROVED BY A SPECIALIST BEFORE HANDLING THIS PRODUCT.
RESPIRATORY PROTECTION:
RESPIRATOR SELECTION MUST BE BASED ON KNOWN OR ANTICIPATED EXPOSURE LEVELS,
THE HAZARDS OF THE PRODUCT AND THE SAFE WORKING LIMITS OF THE SELECTED
RESPIRATOR. IF WORKERS ARE EXPOSED TO CONCENTRATIONS ABOVE THE EXPOSURE
LIMIT, THEY MUST USE APPROPRIATE, CERTIFIED RESPIRATORS. USE A PROPERLY
FITTED, AIR-PURIFYING OR AIR-FED RESPIRATOR COMPLYING WITH AN APPROVED
STANDARD IF A RISK ASSESSMENT INDICATES THIS IS NECESSARY.
| SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE:
PHYSICAL STATE: LIQUID.
COLOR: NOT AVAILABLE.
ODOR: CHARACTERISTIC.
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
MELTING POINT: NOT AVAILABLE.
BOILING POINT: >37.78 DEG. C (>100 DEG. F)
FLASH POINT:
CLOSED CUP: -17 DEG. C (1.4 DEG. F)
MATERIAL SUPPORTS COMBUSTION.: YES.
AUTO-IGNITION TEMPERATURE: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
FLAMMABILITY (SOLID, GAS): NOT AVAILABLE.
LOWER AND UPPER EXPLOSIVE (FLAMMABLE) LIMITS: NOT AVAILABLE.
EVAPORATION RATE: NOT AVAILABLE.
VAPOR PRESSURE: NOT AVAILABLE.
VAPOR DENSITY: NOT AVAILABLE.
RELATIVE DENSITY: 1.27
DENSITY (LBS/GAL): 10.6
SOLUBILITY:
INSOLUBLE IN THE FOLLOWING MATERIALS: COLD WATER.
PARTITION COEFFICIENT N-OCTANOL/WATER: NOT AVAILABLE.
VISCOSITY:
KINEMATIC (40 DEG. C (104 DEG. F)): >0.21 CM2/S (>21 CST)
VOLATILITY: 46% (V/V), 25.713% (W/W)
% SOLID. (W/W): 74.287
| SECTION 10. STABILITY AND REACTIVITY | |
REACTIVITY:
NO SPECIFIC TEST DATA RELATED TO REACTIVITY AVAILABLE FOR THIS PRODUCT OR
ITS INGREDIENTS.
CHEMICAL STABILITY: THE PRODUCT IS STABLE.
POSSIBILITY OF HAZARDOUS REACTIONS:
UNDER NORMAL CONDITIONS OF STORAGE AND USE, HAZARDOUS REACTIONS WILL NOT
OCCUR.
CONDITIONS TO AVOID:
WHEN EXPOSED TO HIGH TEMPERATURES MAY PRODUCE HAZARDOUS DECOMPOSITION
PRODUCTS. REFER TO PROTECTIVE MEASURES LISTED IN SECTIONS 7 AND 8.
INCOMPATIBLE MATERIALS:
KEEP AWAY FROM THE FOLLOWING MATERIALS TO PREVENT STRONG EXOTHERMIC
REACTIONS: OXIDIZING AGENTS, STRONG ALKALIS, STRONG ACIDS.
HAZARDOUS DECOMPOSITION:
DECOMPOSITION PRODUCTS MAY INCLUDE THE FOLLOWING MATERIALS:
CARBON MONOXIDE, CARBON PRODUCTS DIOXIDE, SMOKE, OXIDES OF NITROGEN.
| SECTION 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY:
PRODUCT/INGREDIENT NAME RESULT SPECIES DOSE EXPOSURE
| DISTILLATES (PETROLEUM), LD50 ORAL RAT 5.17 G/KG
| LIGHT DISTILLATE
| HYDROTREATING PROCESS,
| LOW-BOILING
CYCLOHEXANE LD50 ORAL RAT 6240 MG/KG
KAOLIN LD50 ORAL RAT >5000 MG/KG
N-HEXANE LC50 RAT 48000 PPM 4 HOURS
INHALATION
GAS.
LD50 ORAL RAT 15840 MG/KG
CONCLUSION/SUMMARY: THERE ARE NO DATA AVAILABLE ON THE MIXTURE ITSELF.
IRRITATION/CORROSION:
CONCLUSION/SUMMARY:
SKIN: THERE ARE NO DATA AVAILABLE ON THE MIXTURE ITSELF.
EYES: THERE ARE NO DATA AVAILABLE ON THE MIXTURE ITSELF.
RESPIRATORY: THERE ARE NO DATA AVAILABLE ON THE MIXTURE ITSELF.
SENSITIZATION:
CONCLUSION/SUMMARY:
SKIN: THERE ARE NO DATA AVAILABLE ON THE MIXTURE ITSELF.
RESPIRATORY: THERE ARE NO DATA AVAILABLE ON THE MIXTURE ITSELF.
MUTAGENICITY:
CONCLUSION/SUMMARY: THERE ARE NO DATA AVAILABLE ON THE MIXTURE ITSELF.
CARCINOGENICITY:
CONCLUSION/SUMMARY: THERE ARE NO DATA AVAILABLE ON THE MIXTURE ITSELF.
CLASSIFICATION:
PRODUCT/INGREDIENT NAME OSHA IARC NTP
| CRYSTALLINE SILICA, - 1 KNOWN TO BE A HUMAN CARCINOGEN.
| RESPIRABLE POWDER
| (>10 MICRONS)
CARCINOGEN CLASSIFICATION CODE:
IARC: 1, 2A, 2B, 3, 4
NTP:
KNOWN TO BE A HUMAN CARCINOGEN; REASONABLY ANTICIPATED TO BE A HUMAN
CARCINOGEN
OSHA: +
NOT LISTED/NOT REGULATED: -
REPRODUCTIVE TOXICITY:
CONCLUSION/SUMMARY: THERE ARE NO DATA AVAILABLE ON THE MIXTURE ITSELF.
TERATOGENICITY:
CONCLUSION/SUMMARY: THERE ARE NO DATA AVAILABLE ON THE MIXTURE ITSELF.
SPECIFIC TARGET ORGAN TOXICITY (SINGLE EXPOSURE):
NAME CATEGORY
CYCLOHEXANE CATEGORY 3
N-HEXANE CATEGORY 3
SPECIFIC TARGET ORGAN TOXICITY (REPEATED EXPOSURE):
NAME CATEGORY
| CYCLOHEXANE CATEGORY 2
N-HEXANE CATEGORY 2
TARGET ORGANS:
CONTAINS MATERIAL WHICH CAUSES DAMAGE TO THE FOLLOWING ORGANS:
BRAIN, EYES, CENTRAL NERVOUS SYSTEM (CNS).
CONTAINS MATERIAL WHICH MAY CAUSE DAMAGE TO THE FOLLOWING ORGANS:
LUNGS, CARDIOVASCULAR SYSTEM, UPPER RESPIRATORY TRACT, SKIN, STOMACH.
ASPIRATION HAZARD:
NAME RESULT
DISTILLATES (PETROLEUM), LIGHT DISTILLATE ASPIRATION HAZARD - CATEGORY 1
HYDROTREATING PROCESS, LOW-BOILING
CYCLOHEXANE ASPIRATION HAZARD - CATEGORY 1
N-HEXANE ASPIRATION HAZARD - CATEGORY 1
INFORMATION ON THE LIKELY ROUTES OF EXPOSURE:
POTENTIAL ACUTE HEALTH EFFECTS:
EYE CONTACT: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
INHALATION: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
SKIN CONTACT: DEFATTING TO THE SKIN. MAY CAUSE SKIN DRYNESS AND IRRITATION.
INGESTION: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
OVER-EXPOSURE SIGNS/SYMPTOMS:
EYE CONTACT: NO SPECIFIC DATA.
INHALATION:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
REDUCED FETAL WEIGHT
INCREASE IN FETAL DEATHS
SKELETAL MALFORMATIONS
SKIN CONTACT:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
IRRITATION
DRYNESS
CRACKING
REDUCED FETAL WEIGHT
INCREASE IN FETAL DEATHS
SKELETAL MALFORMATIONS
INGESTION:
ADVERSE SYMPTOMS MAY INCLUDE THE FOLLOWING:
REDUCED FETAL WEIGHT
INCREASE IN FETAL DEATHS
SKELETAL MALFORMATIONS
DELAYED AND IMMEDIATE EFFECTS AND ALSO CHRONIC EFFECTS FROM SHORT AND LONG
TERM EXPOSURE:
CONCLUSION/SUMMARY:
THERE ARE NO DATA AVAILABLE ON THE MIXTURE ITSELF. THIS PRODUCT CONTAINS
CRYSTALLINE SILICA WHICH CAN CAUSE LUNG CANCER OR SILICOSIS. THE RISK OF
CANCER DEPENDS ON THE DURATION AND LEVEL OF EXPOSURE TO DUST FROM SANDING
SURFACES OR MIST FROM SPRAY APPLICATIONS. EXPOSURE TO COMPONENT SOLVENT
VAPOR CONCENTRATIONS IN EXCESS OF THE STATED OCCUPATIONAL EXPOSURE LIMIT
MAY RESULT IN ADVERSE HEALTH EFFECTS SUCH AS MUCOUS MEMBRANE AND
RESPIRATORY SYSTEM IRRITATION AND ADVERSE EFFECTS ON THE KIDNEYS, LIVER AND
CENTRAL NERVOUS SYSTEM. SYMPTOMS AND SIGNS INCLUDE HEADACHE, DIZZINESS,
FATIGUE, MUSCULAR WEAKNESS, DROWSINESS AND, IN EXTREME CASES, LOSS OF
CONSCIOUSNESS. SOLVENTS MAY CAUSE SOME OF THE ABOVE EFFECTS BY ABSORPTION
THROUGH THE SKIN. THERE IS SOME EVIDENCE THAT REPEATED EXPOSURE TO ORGANIC
SOLVENT VAPORS IN COMBINATION WITH CONSTANT LOUD NOISE CAN CAUSE GREATER
HEARING LOSS THAN EXPECTED FROM EXPOSURE TO NOISE ALONE. IF SPLASHED IN THE
EYES, THE LIQUID MAY CAUSE IRRITATION AND REVERSIBLE DAMAGE. INGESTION MAY
CAUSE NAUSEA, DIARRHEA AND VOMITING. THIS TAKES INTO ACCOUNT, WHERE KNOWN,
DELAYED AND IMMEDIATE EFFECTS AND ALSO CHRONIC EFFECTS OF COMPONENTS FROM
SHORT-TERM AND LONG-TERM EXPOSURE BY ORAL, INHALATION AND DERMAL ROUTES OF
EXPOSURE AND EYE CONTACT.
SHORT TERM EXPOSURE:
POTENTIAL IMMEDIATE EFFECTS:
THERE ARE NO DATA AVAILABLE ON THE MIXTURE ITSELF.
POTENTIAL DELAYED EFFECTS:
THERE ARE NO DATA AVAILABLE ON THE MIXTURE ITSELF.
LONG TERM EXPOSURE:
POTENTIAL IMMEDIATE EFFECTS:
THERE ARE NO DATA AVAILABLE ON THE MIXTURE ITSELF.
POTENTIAL DELAYED EFFECTS:
THERE ARE NO DATA AVAILABLE ON THE MIXTURE ITSELF.
POTENTIAL CHRONIC HEALTH EFFECTS:
GENERAL:
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
PROLONGED OR REPEATED CONTACT CAN DEFAT THE SKIN AND LEAD TO IRRITATION,
CRACKING AND/OR DERMATITIS.
CARCINOGENICITY:
MAY CAUSE CANCER. RISK OF CANCER DEPENDS ON DURATION AND LEVEL OF EXPOSURE.
MUTAGENICITY: MAY CAUSE GENETIC DEFECTS.
TERATOGENICITY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
DEVELOPMENTAL EFFECTS: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
FERTILITY EFFECTS: SUSPECTED OF DAMAGING FERTILITY.
| SECTION 12. ECOLOGICAL INFORMATION | |
TOXICITY: NOT AVAILABLE.
PERSISTENCE AND DEGRADABILITY: NOT AVAILABLE.
BIOACCUMULATIVE POTENTIAL:
PRODUCT/INGREDIENT NAME LOGPOW BCF POTENTIAL
CYCLOHEXANE 3.44 83.18 LOW
N-HEXANE 3.9 LOW
MOBILITY IN SOIL:
SOIL/WATER PARTITION COEFFICIENT (KOC): NOT AVAILABLE.
| SECTION 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL METHODS:
THE GENERATION OF WASTE SHOULD BE AVOIDED OR MINIMIZED WHEREVER POSSIBLE.
DISPOSAL OF THIS PRODUCT, SOLUTIONS AND ANY BY-PRODUCTS SHOULD AT ALL TIMES
COMPLY WITH THE REQUIREMENTS OF ENVIRONMENTAL PROTECTION AND WASTE DISPOSAL
LEGISLATION AND ANY REGIONAL LOCAL AUTHORITY REQUIREMENTS. DISPOSE OF
SURPLUS AND NON-RECYCLABLE PRODUCTS VIA A LICENSED WASTE DISPOSAL
CONTRACTOR. WASTE SHOULD NOT BE DISPOSED OF UNTREATED TO THE SEWER UNLESS
FULLY COMPLIANT WITH THE REQUIREMENTS OF ALL AUTHORITIES WITH JURISDICTION.
WASTE PACKAGING SHOULD BE RECYCLED. INCINERATION OR LANDFILL SHOULD ONLY BE
CONSIDERED WHEN RECYCLING IS NOT FEASIBLE. THIS MATERIAL AND ITS CONTAINER
MUST BE DISPOSED OF IN A SAFE WAY. CARE SHOULD BE TAKEN WHEN HANDLING
EMPTIED CONTAINERS THAT HAVE NOT BEEN CLEANED OR RINSED OUT. EMPTY
CONTAINERS OR LINERS MAY RETAIN SOME PRODUCT RESIDUES. VAPOR FROM PRODUCT
RESIDUES MAY CREATE A HIGHLY FLAMMABLE OR EXPLOSIVE ATMOSPHERE INSIDE THE
CONTAINER. DO NOT CUT, WELD OR GRIND USED CONTAINERS UNLESS THEY HAVE BEEN
CLEANED THOROUGHLY INTERNALLY. AVOID DISPERSAL OF SPILLED MATERIAL AND
RUNOFF AND CONTACT WITH SOIL, WATERWAYS, DRAINS AND SEWERS.
DISPOSAL SHOULD BE IN ACCORDANCE WITH APPLICABLE REGIONAL, NATIONAL AND
LOCAL LAWS AND REGULATIONS.
REFER TO SECTION 7: HANDLING AND STORAGE AND SECTION 8: EXPOSURE
CONTROLS/PERSONAL PROTECTION FOR ADDITIONAL HANDLING INFORMATION AND
PROTECTION OF EMPLOYEES. SECTION 6. ACCIDENTAL RELEASE MEASURES
| SECTION 14. TRANSPORT INFORMATION | |
DOT IMDG IATA
UN NUMBER UN1133 UN1133 UN1133
UN PROPER SHIPPING ADHESIVES ADHESIVES ADHESIVES
NAME
TRANSPORT HAZARD 3 3 3
CLASS(ES)
PACKING GROUP II II II
ENVIRONMENTAL HAZARDS NO. YES. YES. THE
ENVIRONMENTALLY
HAZARDOUS
SUBSTANCE MARK
IS NOT
REQUIRED.
MARINE POLLUTANT NOT APPLICABLE. (CYCLOHEXANE) NOT APPLICABLE.
SUBSTANCES
PRODUCT RQ (LBS) 10488.8 NOT APPLICABLE. NOT APPLICABLE.
RQ SUBSTANCES (CYCLOHEXANE) NOT APPLICABLE. NOT APPLICABLE.
ADDITIONAL INFORMATION:
DOT:
PACKAGE SIZES SHIPPED IN QUANTITIES LESS THAN THE PRODUCT REPORTABLE
QUANTITY ARE NOT SUBJECT TO THE RQ (REPORTABLE QUANTITY) TRANSPORTATION
REQUIREMENTS.
IMDG:
THE MARINE POLLUTANT MARK IS NOT REQUIRED WHEN TRANSPORTED IN SIZES OF
</=5 L OR </=5 KG.
IATA:
THE ENVIRONMENTALLY HAZARDOUS SUBSTANCE MARK MAY APPEAR IF REQUIRED BY
OTHER TRANSPORTATION REGULATIONS.
SPECIAL PRECAUTIONS FOR USER:
TRANSPORT WITHIN USER'S PREMISES:
ALWAYS TRANSPORT IN CLOSED CONTAINERS THAT ARE UPRIGHT AND SECURE. ENSURE
THAT PERSONS TRANSPORTING THE PRODUCT KNOW WHAT TO DO IN THE EVENT OF AN
ACCIDENT OR SPILLAGE.
| SECTION 15. REGULATORY INFORMATION | |
UNITED STATES:
UNITED STATES INVENTORY (TSCA 8B): ALL COMPONENTS ARE LISTED OR EXEMPTED.
SARA 302/304:
SARA 304 RQ: NOT APPLICABLE.
COMPOSITION/INFORMATION ON INGREDIENTS: NO PRODUCTS WERE FOUND.
SARA 311/312:
CLASSIFICATION:
FIRE HAZARD
IMMEDIATE (ACUTE) HEALTH HAZARD
DELAYED (CHRONIC) HEALTH HAZARD
COMPOSITION/INFORMATION ON INGREDIENTS:
NAME FIRE SUDDEN REACTIVE IMMEDIATE DELAYED
HAZARD RELEASE OF (ACUTE) (CHRONIC)
PRESSURE HEALTH HEALTH
HAZARD HAZARD
| DISTILLATES NO. NO. NO. YES. YES.
| (PETROLEUM), LIGHT
| DISTILLATE
| HYDROTREATING
| PROCESS,
| LOW-BOILING
CYCLOHEXANE YES. NO. NO. YES. YES.
N-HEXANE YES. NO. NO. YES. YES.
CRYSTALLINE SILICA, NO. NO. NO. NO. YES.
RESPIRABLE POWDER
(>10 MICRONS)
SARA 313:
CHEMICAL NAME CAS NUMBER CONCENTRATION
SUPPLIER NOTIFICATION:
CYCLOHEXANE 110-82-7 5 - 10
SARA 313 NOTIFICATIONS MUST NOT BE DETACHED FROM THE SDS AND ANY COPYING
AND REDISTRIBUTION OF THE SDS SHALL INCLUDE COPYING AND REDISTRIBUTION OF
THE NOTICE ATTACHED TO COPIES OF THE SDS SUBSEQUENTLY REDISTRIBUTED.
ADDITIONAL ENVIRONMENTAL INFORMATION IS CONTAINED ON THE ENVIRONMENTAL DATA
SHEET FOR THIS PRODUCT, WHICH CAN BE OBTAINED FROM YOUR PPG REPRESENTATIVE.
CALIFORNIA PROP. 65:
WARNING:
THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER.
| SECTION 16. OTHER INFORMATION | |
HAZARDOUS MATERIAL INFORMATION SYSTEM (U.S.A.):
HEALTH 2*
FLAMMABILITY 3
PHYSICAL HAZARDS 0
(*) - CHRONIC EFFECTS
CAUTION:
HMIS(R*) RATINGS ARE BASED ON A 0-4 RATING SCALE, WITH 0 REPRESENTING
MINIMAL HAZARDS OR RISKS, AND 4 REPRESENTING SIGNIFICANT HAZARDS OR RISKS
ALTHOUGH HMIS(R*) RATINGS ARE NOT REQUIRED ON MSDSS UNDER 29 CFR 1910.1200,
THE PREPARER MAY CHOOSE TO PROVIDE THEM. HMIS(R*) RATINGS ARE TO BE USED
WITH A FULLY IMPLEMENTED HMIS(R*) PROGRAM. HMIS(R*) IS A REGISTERED MARK OF
THE NATIONAL PAINT & COATINGS ASSOCIATION (NPCA). HMIS(R*) MATERIALS MAY BE
PURCHASED EXCLUSIVELY FROM J. J. KELLER (800) 327-6868.
THE CUSTOMER IS RESPONSIBLE FOR DETERMINING THE PPE CODE FOR THIS MATERIAL.
NATIONAL FIRE PROTECTION ASSOCIATION (U.S.A.):
HEALTH 2
FLAMMABILITY 3
INSTABILITY 0
DATE OF PREVIOUS ISSUE: 3/23/2017
ORGANIZATION THAT PREPARED THE MSDS: EHS
KEY TO ABBREVIATIONS:
ATE: ACUTE TOXICITY ESTIMATE
BCF: BIOCONCENTRATION FACTOR
GHS:
GLOBALLY HARMONIZED SYSTEM OF CLASSIFICATION AND LABELLING OF CHEMICALS
IATA: INTERNATIONAL AIR T RANSPORT ASSOCIATION
IBC: INTERMEDIATE BULK CONTAINER
IMDG: INTERNATIONAL MARITIME DANGEROUS GOODS
LOGPOW: LOGARITHM OF THE OCTANOL/WATER PARTITION COEFFICIENT
MARPOL:
INTERNATIONAL CONVENTION FOR THE PREVENTION OF POLLUTION FROM SHIPS, 1973
AS MODIFIED BY THE PROTOCOL OF 1978. ("MARPOL" = MARINE POLLUTION)
UN: UNITED NATIONS
| INDICATES INFORMATION THAT HAS CHANGED FROM PREVIOUSLY ISSUED VERSION.
DISCLAIMER:
THE INFORMATION CONTAINED IN THIS DATA SHEET IS BASED ON PRESENT SCIENTIFIC
AND TECHNICAL KNOWLEDGE. THE PURPOSE OF THIS INFORMATION IS TO DRAW
ATTENTION TO THE HEALTH AND SAFETY ASPECTS CONCERNING THE PRODUCTS SUPPLIED
BY PPG, AND TO RECOMMEND PRECAUTIONARY MEASURES FOR THE STORAGE AND
HANDLING OF THE PRODUCTS. NO WARRANTY OR GUARANTEE IS GIVEN IN RESPECT OF
THE PROPERTIES OF THE PRODUCTS. NO LIABILITY CAN BE ACCEPTED FOR ANY
FAILURE TO OBSERVE THE PRECAUTIONARY MEASURES DESCRIBED IN THIS DATA SHEET
OR FOR ANY MISUSE OF THE PRODUCTS.
UNITED STATES