| Common Name: | SUPER LUBE SILICONE AEROSOL |
| Manufacturer: | SYNCO CHEMICAL |
| SDS Revision Date: | 2/11/2016 |
| SDS Format: | GHS-US |
| Item Number(s): | 44N745 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
SYNCO(R*)
SUPER LUBE(R*)
SAFETY DATA SHEET
ACCORDING TO (EU) 2015 / 830 AND OSHA GHS
REVISION: FEBRUARY 11,2016
| 1 IDENTIFICATION |  |
PRODUCT IDENTIFIER:
TRADE NAME: SUPER LUBE(R*) SILICONE AEROSOL
ARTICLE NUMBER: NO OTHER IDENTIFIERS
RECOMMENDED USE AND RESTRICTION ON USE:
RECOMMENDED USE: LUBRICANT
RESTRICTIONS ON USE: SEE SECTIONS 8 AND 10 FOR FURTHER INFORMATION.
DETAILS OF THE SUPPLIER OF THE SAFETY DATA SHEET:
MANUFACTURER/SUPPLIER:
SYNCO CHEMICAL CORPORATION
24 DAVINCI DR.
P.O. BOX 405
BOHEMIA, NY 11716
TELEPHONE: 631-567-5300
EMAIL: INFO@SUPER-LUBE.COM
INFORMATION DEPARTMENT: PRODUCT SAFETY DEPARTMENT
EMERGENCY TELEPHONE NUMBER:
CHEMTREC:
1-800-424-9300 (US/CANADA)
+01 703-527-3887 (INTERNATIONAL)
| 2 HAZARD(S) IDENTIFICATION | |
CLASSIFICATION OF THE SUBSTANCE OR MIXTURE:
GHS02: FLAME
GHS04: GAS CYLINDER
FLAM. AEROSOL 1:
H222: EXTREMELY FLAMMABLE AEROSOL.
GHS04: GAS CYLINDER
PRESS. GAS:
H280: CONTAINS GAS UNDER PRESSURE; MAY EXPLODE IF HEATED.
GHS08: HEALTH HAZARD
ASP. TOX. 1:
H304: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
GHS07: EXCLAMATION MARK
SKIN IRRIT. 2:
H315: CAUSES SKIN IRRITATION.
EYE IRRIT. 2A:
H319: CAUSES SERIOUS EYE IRRITATION.
STOT SE 3:
H336: MAY CAUSE DROWSINESS OR DIZZINESS.
ADDITIONAL INFORMATION:
THERE ARE NO OTHER HAZARDS NOT OTHERWISE CLASSIFIED THAT HAVE BEEN
IDENTIFIED.
0 PERCENT OF THE MIXTURE CONSISTS OF INGREDIENT(S) OF UNKNOWN TOXICITY.
LABEL ELEMENTS:
GHS LABEL ELEMENTS:
THE PRODUCT IS CLASSIFIED AND LABELED ACCORDING TO THE GLOBALLY HARMONIZED
SYSTEM (GHS).
HAZARD PICTOGRAMS:
GHS02: FLAME
GHS04: GAS CYLINDER
GHS07: EXCLAMATION MARK
GHS08: HEALTH HAZARD
SIGNAL WORD: DANGER
HAZARD-DETERMINING COMPONENTS OF LABELING:
HEPTANE
ACETONE
HAZARD STATEMENTS:
H222: EXTREMELY FLAMMABLE AEROSOL.
H280: CONTAINS GAS UNDER PRESSURE; MAY EXPLODE IF HEATED.
H315: CAUSES SKIN IRRITATION.
H319: CAUSES SERIOUS EYE IRRITATION.
H336: MAY CAUSE DROWSINESS OR DIZZINESS.
H304: MAY BE FATAL IF SWALLOWED AND ENTERS AIRWAYS.
PRECAUTIONARY STATEMENTS:
P210:
KEEP AWAY FROM HEAT, SPARKS, OPEN FLAMES, AND HOT SURFACES. - NO SMOKING.
P251:
PRESSURIZED CONTAINER: DO NOT PIERCE OR BURN, EVEN AFTER USE.
P211: DO NOT SPRAY ON AN OPEN FLAME OR OTHER IGNITION SOURCE.
P261: AVOID BREATHING MIST, VAPORS, OR SPRAY.
P280: WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION.
P264: WASH THOROUGHLY AFTER HANDLING.
P271: USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA.
P301+P310:
IF SWALLOWED: IMMEDIATELY CALL A POISON CENTER/DOCTOR.
P305+P351+P338:
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES, IF
PRESENT AND EASY TO DO. CONTINUE RINSING.
P304+P340:
IF INHALED:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
BREATHING.
P312: CALL A POISON CENTER/DOCTOR IF YOU FEEL UNWELL.
P331: DO NOT INDUCE VOMITING.
P302+P352:
IF ON SKIN: WASH WITH PLENTY OF WATER.
P362+P364: TAKE OFF CONTAMINATED CLOTHING AND WASH IT BEFORE REUSE.
P410+P412:
PROTECT FROM SUNLIGHT. DO NOT EXPOSE TO TEMPERATURES EXCEEDING
122 DEG. F (50 DEG. C).
P403+P233: STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED.
P501:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
HAZARD DESCRIPTION:
WHMIS-SYMBOLS:
A - COMPRESSED GAS
B5 - FLAMMABLE AEROSOL
D2B - TOXIC MATERIAL CAUSING OTHER TOXIC EFFECTS
CLASSIFICATION SYSTEM:
NFPA RATINGS (SCALE 0-4):
HEALTH 1
FIRE 4
REACTIVITY 3
HMIS-RATINGS (SCALE 0-4):
HEALTH 1
FIRE 4
REACTIVITY 3
OTHER HAZARDS:
RESULTS OF PBT AND VPVB ASSESSMENT:
PBT: NOT APPLICABLE.
VPVB: NOT APPLICABLE.
| 3 COMPOSITION/INFORMATION ON INGREDIENTS | |
CHEMICAL CHARACTERIZATION: MIXTURES
DESCRIPTION:
MIXTURE OF THE SUBSTANCES LISTED BELOW WITH NONHAZARDOUS ADDITIONS.
DANGEROUS COMPONENTS:
142-82-5 HEPTANE FLAM. LIQ. 2, H225 40-60%
ASP. TOX. 1, H304
SKIN IRRIT. 2, H315;
STOT SE 3, H336
67-64-1 ACETONE FLAM LIQ 2 H225 25-50%
EYE IRRIT. 2A, H319;
STOT SE 3, H336
124-38-9 CARBON DIOXIDE PRESS. GAS, H280 2.5-10%
ADDITIONAL INFORMATION:
FOR THE LISTED INGREDIENTS, THE IDENTITY AND EXACT PERCENTAGES ARE BEING
WITHHELD AS A TRADE SECRET.
| 4 FIRST-AID MEASURES | |
DESCRIPTION OF FIRST AID MEASURES:
GENERAL INFORMATION:
TAKE AFFECTED PERSONS OUT INTO THE FRESH AIR.
IMMEDIATELY REMOVE ANY CLOTHING SOILED BY THE PRODUCT.
AFTER INHALATION:
SUPPLY FRESH AIR; CONSULT DOCTOR IN CASE OF COMPLAINTS.
PROVIDE OXYGEN TREATMENT IF AFFECTED PERSON HAS DIFFICULTY BREATHING.
AFTER SKIN CONTACT:
IMMEDIATELY WASH WITH WATER AND SOAP AND RINSE THOROUGHLY.
IF SKIN IRRITATION CONTINUES, CONSULT A DOCTOR.
IN CASES OF FROSTBITE, RINSE WITH PLENTY OF WATER. DO NOT REMOVE CLOTHING.
AFTER EYE CONTACT:
REMOVE CONTACT LENSES IF WORN.
RINSE OPENED EYE FOR SEVERAL MINUTES UNDER RUNNING WATER. IF SYMPTOMS
PERSIST, CONSULT A DOCTOR.
AFTER SWALLOWING:
UNLIKELY ROUTE OF EXPOSURE.
RINSE OUT MOUTH AND THEN DRINK PLENTY OF WATER.
DO NOT INDUCE VOMITING; IMMEDIATELY CALL FOR MEDICAL HELP.
A PERSON VOMITING WHILE LYING ON THEIR BACK SHOULD BE TURNED ONTO THEIR
SIDE.
INFORMATION FOR DOCTOR:
MOST IMPORTANT SYMPTOMS AND EFFECTS, BOTH ACUTE AND DELAYED:
HEADACHE
BREATHING DIFFICULTY
FROSTBITE
DIZZINESS
COUGHING
IRRITANT TO SKIN AND MUCOUS MEMBRANES.
IRRITANT TO EYES.
DANGER:
VAPORS HAVE NARCOTIC EFFECT.
DANGER OF DISTURBED CARDIAC RHYTHM.
CONDITION MAY DETERIORATE WITH ALCOHOL CONSUMPTION.
DANGER OF IMPAIRED BREATHING.
INDICATION OF ANY IMMEDIATE MEDICAL ATTENTION AND SPECIAL TREATMENT NEEDED:
LATER OBSERVATION FOR PNEUMONIA AND PULMONARY EDEMA.
TREAT FROST-BITTEN AREAS APPROPRIATELY.
IF SWALLOWED OR IN CASE OF VOMITING, DANGER OF ENTERING THE LUNGS.
MEDICAL SUPERVISION FOR AT LEAST 48 HOURS.
IF NECESSARY OXYGEN RESPIRATION TREATMENT.
| 5 FIRE-FIGHTING MEASURES | |
EXTINGUISHING MEDIA:
SUITABLE EXTINGUISHING AGENTS:
ALCOHOL RESISTANT FOAM
CARBON DIOXIDE
FIRE-EXTINGUISHING POWDER
GASEOUS EXTINGUISHING AGENTS
FOR SAFETY REASONS UNSUITABLE EXTINGUISHING AGENTS: WATER
SPECIAL HAZARDS ARISING FROM THE SUBSTANCE OR MIXTURE:
FORMATION OF TOXIC GASES IS POSSIBLE DURING HEATING OR IN CASE OF FIRE.
DANGER OF RECEPTACLES BURSTING BECAUSE OF HIGH VAPOR PRESSURE IF HEATED.
ADVICE FOR FIREFIGHTERS:
PROTECTIVE EQUIPMENT:
WEAR SELF-CONTAINED RESPIRATORY PROTECTIVE DEVICE.
WEAR FULLY PROTECTIVE SUIT.
ADDITIONAL INFORMATION:
ELIMINATE ALL IGNITION SOURCES IF SAFE TO DO SO.
COOL ENDANGERED RECEPTACLES WITH WATER FOG.
LEAKING GAS FIRE: DO NOT EXTINGUISH, UNLESS LEAK CAN BE STOPPED SAFELY.
| 6 ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
USE RESPIRATORY PROTECTIVE DEVICE AGAINST THE EFFECTS OF FUMES/DUST/
AEROSOL.
ENSURE ADEQUATE VENTILATION.
WEAR PROTECTIVE EQUIPMENT. KEEP UNPROTECTED PERSONS AWAY.
KEEP AWAY FROM IGNITION SOURCES.
PROTECT FROM HEAT.
ENVIRONMENTAL PRECAUTIONS:
DO NOT ALLOW TO ENTER SEWERS/ SURFACE OR GROUND WATER.
INFORM RESPECTIVE AUTHORITIES IN CASE OF SEEPAGE INTO WATER COURSE OR
SEWAGE SYSTEM.
METHODS AND MATERIAL FOR CONTAINMENT AND CLEANING UP:
ALLOW TO EVAPORATE.
ABSORB WITH NON-COMBUSTIBLE LIQUID-BINDING MATERIAL (SAND, DIATOMITE, ACID
BINDERS, UNIVERSAL BINDERS).
DISPOSE CONTAMINATED MATERIAL AS WASTE ACCORDING TO ITEM 13.
SEND FOR RECOVERY OR DISPOSAL IN SUITABLE RECEPTACLES.
REFERENCE TO OTHER SECTIONS:
SEE SECTION 7 FOR INFORMATION ON SAFE HANDLING.
SEE SECTION 8 FOR INFORMATION ON PERSONAL PROTECTION EQUIPMENT.
SEE SECTION 13 FOR DISPOSAL INFORMATION.
| 7 HANDLING AND STORAGE | |
HANDLING:
PRECAUTIONS FOR SAFE HANDLING:
USE ONLY IN WELL VENTILATED AREAS.
KEEP AWAY FROM HEAT AND DIRECT SUNLIGHT.
INFORMATION ABOUT PROTECTION AGAINST EXPLOSIONS AND FIRES:
DO NOT SPRAY ON A NAKED FLAME OR ANY INCANDESCENT MATERIAL.
KEEP IGNITION SOURCES AWAY - DO NOT SMOKE.
PRESSURIZED CONTAINER:
PROTECT FROM SUNLIGHT AND DO NOT EXPOSE TO TEMPERATURES EXCEEDING
120 DEG. F / 49 DEG. C, I.E. ELECTRIC LIGHTS. DO NOT PIERCE OR BURN, EVEN
AFTER USE.
EMERGENCY COOLING MUST BE AVAILABLE IN CASE OF NEARBY FIRE.
KEEP RESPIRATORY PROTECTIVE DEVICE AVAILABLE.
CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
STORAGE:
REQUIREMENTS TO BE MET BY STOREROOMS AND RECEPTACLES:
STORE IN A COOL LOCATION.
PROVIDE VENTILATION FOR RECEPTACLES.
OBSERVE OFFICIAL REGULATIONS ON STORING PACKAGINGS WITH PRESSURIZED
CONTAINERS.
AVOID STORAGE NEAR EXTREME HEAT, IGNITION SOURCES OR OPEN FLAME.
INFORMATION ABOUT STORAGE IN ONE COMMON STORAGE FACILITY:
STORE AWAY FROM FOODSTUFFS.
STORE AWAY FROM OXIDIZING AGENTS.
FURTHER INFORMATION ABOUT STORAGE CONDITIONS:
STORE IN A COOL PLACE. HEAT WILL INCREASE PRESSURE AND MAY LEAD TO THE
RECEPTACLE BURSTING.
KEEP RECEPTACLE TIGHTLY SEALED.
PROTECT FROM HEAT AND DIRECT SUNLIGHT.
STORAGE TEMPERATURES: <122 DEG. F / <50 DEG. C.
SPECIFIC END USE(S): NO FURTHER RELEVANT INFORMATION AVAILABLE.
| 8 EXPOSURE CONTROLS/PERSONAL PROTECTION | |
ADDITIONAL INFORMATION ABOUT DESIGN OF TECHNICAL SYSTEMS:
NO FURTHER DATA; SEE ITEM 7.
CONTROL PARAMETERS:
COMPONENTS WITH LIMIT VALUES THAT REQUIRE MONITORING AT THE WORKPLACE:
142-82-5 HEPTANE:
PEL (USA):
LONG-TERM VALUE: 2000 MG/M3, 500 PPM
REL (USA):
LONG-TERM VALUE: 350 MG/M3, 85 PPM
CEILING LIMIT VALUE: 1800* MG/M3, 440* PPM
*15-MIN
TLV (USA):
SHORT-TERM VALUE: 2050 MG/M3, 500 PPM
LONG-TERM VALUE: 1640 MG/M3, 400 PPM
EL (CANADA):
SHORT-TERM VALUE: 500 PPM
LONG-TERM VALUE: 400 PPM
EV (CANADA):
SHORT-TERM VALUE: 2.045 MG/M3, 500 PPM
LONG-TERM VALUE: 1.635 MG/M3, 400 PPM
LMPE (MEXICO):
SHORT-TERM VALUE: 500 PPM
LONG-TERM VALUE: 400 PPM
67-64-1 ACETONE:
PEL (USA):
LONG-TERM VALUE: 2400 MG/M3, 1000 PPM
REL (USA):
LONG-TERM VALUE: 590 MG/M3, 250 PPM
TLV (USA):
SHORT-TERM VALUE: (1782) NIC-1187 MG/M3, (750) NIC-500 PPM
LONG-TERM VALUE: (1188) NIC-594 MG/M3, (500) NIC-250 PPM BEI
EL (CANADA):
SHORT-TERM VALUE: 500 PPM
LONG-TERM VALUE: 250 PPM
EV (CANADA):
SHORT-TERM VALUE: 750 PPM
LONG-TERM VALUE: 500 PPM
LMPE (MEXICO):
SHORT-TERM VALUE: 750 PPM
LONG-TERM VALUE: 500 PPM
A4, IBE
124-38-9 CARBON DIOXIDE:
PEL (USA):
LONG-TERM VALUE: 9000 MG/M3, 5000 PPM
REL (USA):
SHORT-TERM VALUE: 54.000 MG/M3, 30.000 PPM
LONG-TERM VALUE: 9000 MG/M3, 5000 PPM
TLV (USA):
SHORT-TERM VALUE: 54.000 MG/M3, 30.000 PPM
LONG-TERM VALUE: 9000 MG/M3, 5000 PPM
EL (CANADA):
SHORT-TERM VALUE: 15000 PPM
LONG-TERM VALUE: 5000 PPM
EV (CANADA):
SHORT-TERM VALUE: 54.000 MG/M3, 30.000 PPM
LONG-TERM VALUE: 9.000 MG/M3, 5.000 PPM
LMPE (MEXICO):
SHORT-TERM VALUE: 30000 PPM
LONG-TERM VALUE: 5000 PPM
INGREDIENTS WITH BIOLOGICAL LIMIT VALUES:
67-64-1 ACETONE:
BEI (USA):
50 MG/L
MEDIUM: URINE
TIME: END OF SHIFT
PARAMETER: ACETONE (NONSPECIFIC)
ADDITIONAL INFORMATION:
THE LISTS THAT WERE VALID DURING THE CREATION WERE USED AS BASIS.
EXPOSURE CONTROLS:
PERSONAL PROTECTIVE EQUIPMENT:
GENERAL PROTECTIVE AND HYGIENIC MEASURES:
THE USUAL PRECAUTIONARY MEASURES FOR HANDLING CHEMICALS SHOULD BE FOLLOWED.
KEEP AWAY FROM FOODSTUFFS, BEVERAGES AND FEED.
IMMEDIATELY REMOVE ALL SOILED AND CONTAMINATED CLOTHING.
WASH HANDS BEFORE BREAKS AND AT THE END OF WORK.
DO NOT INHALE GASES / FUMES / AEROSOLS.
AVOID CONTACT WITH THE EYES AND SKIN.
ENGINEERING CONTROLS: NO FURTHER RELEVANT INFORMATION AVAILABLE.
BREATHING EQUIPMENT:
WEAR APPROPRIATE NIOSH RESPIRATOR WHEN VENTILATION IS INADEQUATE AND
OCCUPATIONAL EXPOSURE LIMITS ARE EXCEEDED.
USE SUITABLE RESPIRATORY PROTECTIVE DEVICE IN CASE OF INSUFFICIENT
VENTILATION.
PROTECTION OF HANDS:
PROTECTIVE GLOVES:
THE GLOVE MATERIAL HAS TO BE IMPERMEABLE AND RESISTANT TO THE PRODUCT/ THE
SUBSTANCE/ THE PREPARATION. SELECTION OF THE GLOVE MATERIAL ON
CONSIDERATION OF THE PENETRATION TIMES, RATES OF DIFFUSION AND THE
DEGRADATION
MATERIAL OF GLOVES:
THE SELECTION OF THE SUITABLE GLOVES DOES NOT ONLY DEPEND ON THE MATERIAL,
BUT ALSO ON FURTHER MARKS OF QUALITY AND VARIES FROM MANUFACTURER TO
MANUFACTURER. AS THE PRODUCT IS A PREPARATION OF SEVERAL SUBSTANCES, THE
RESISTANCE OF THE GLOVE MATERIAL CAN NOT BE CALCULATED IN ADVANCE AND HAS
THEREFORE TO BE CHECKED PRIOR TO THE APPLICATION.
PENETRATION TIME OF GLOVE MATERIAL:
THE EXACT BREAK THROUGH TIME HAS TO BE FOUND OUT BY THE MANUFACTURER OF THE
PROTECTIVE GLOVES AND HAS TO BE OBSERVED.
EYE PROTECTION: SAFETY GLASSES
BODY PROTECTION:
NOT REQUIRED UNDER NORMAL CONDITIONS OF USE.
PROTECTION MAY BE REQUIRED FOR SPILLS.
LIMITATION AND SUPERVISION OF EXPOSURE INTO THE ENVIRONMENT:
AVOID RELEASE TO THE ENVIRONMENT.
| 9 PHYSICAL AND CHEMICAL PROPERTIES | |
INFORMATION ON BASIC PHYSICAL AND CHEMICAL PROPERTIES:
GENERAL INFORMATION:
APPEARANCE:
FORM: AEROSOL
COLOR: TRANSPARENT
ODOR: SOLVENT-LIKE
ODOR THRESHOLD: NOT DETERMINED.
PH-VALUE: NOT DETERMINED.
CHANGE IN CONDITION:
MELTING POINT/MELTING RANGE: NOT APPLICABLE, AS AEROSOL.
BOILING POINT/BOILING RANGE: NOT APPLICABLE, AS AEROSOL.
FLASH POINT:
-4 DEG. C (25 DEG. F)
EXTREMELY FLAMMABLE AEROSOL.
FLAMMABILITY (SOLID, GASEOUS): NOT APPLICABLE.
AUTO-IGNITION TEMPERATURE: NOT DETERMINED.
DECOMPOSITION TEMPERATURE: NOT DETERMINED.
AUTO IGNITING: PRODUCT IS NOT SELF-IGNITING.
DANGER OF EXPLOSION:
IN USE, MAY FORM FLAMMABLE/EXPLOSIVE VAPOUR-AIR MIXTURE.
EXPLOSION LIMITS:
LOWER: NOT DETERMINED.
UPPER: NOT DETERMINED.
VAPOR PRESSURE AT 20 DEG. C (68 DEG. F): 80-90 PSIG
DENSITY AT 20 DEG. C (68 DEG. F): 0.866 G/CM3 (7.227 LBS/GAL)
RELATIVE DENSITY: NOT DETERMINED.
VAPOUR DENSITY: NOT DETERMINED.
EVAPORATION RATE: NOT APPLICABLE.
SOLUBILITY IN / MISCIBILITY WITH WATER: NOT MISCIBLE OR DIFFICULT TO MIX.
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT DETERMINED.
VISCOSITY:
DYNAMIC: NOT DETERMINED.
KINEMATIC: NOT DETERMINED.
SOLVENT CONTENT:
VOC (CALIFORNIA):
<60%
EXEMPT VOCS ARE EXCLUDED FROM THIS VALUE
OTHER INFORMATION: NO FURTHER RELEVANT INFORMATION AVAILABLE.
| 10 STABILITY AND REACTIVITY | |
REACTIVITY:
CHEMICAL STABILITY:
THERMAL DECOMPOSITION / CONDITIONS TO BE AVOIDED:
KEEP AWAY FROM HEAT, SPARKS, OPEN FLAMES, AND HOT SURFACES. - NO SMOKING.
POSSIBILITY OF HAZARDOUS REACTIONS:
EXTREMELY FLAMMABLE AEROSOL.
DEVELOPS READILY FLAMMABLE GASES / FUMES.
DANGER OF RECEPTACLES BURSTING BECAUSE OF HIGH VAPOR PRESSURE IF HEATED.
REACTS WITH PEROXIDES AND OTHER RADICAL FORMING SUBSTANCES.
CAN FORM EXPLOSIVE MIXTURES IN AIR IF HEATED ABOVE FLASH POINT AND/OR WHEN
SPRAYED OR ATOMIZED.
CONDITIONS TO AVOID:
KEEP IGNITION SOURCES AWAY - DO NOT SMOKE.
STORE AWAY FROM OXIDIZING AGENTS.
INCOMPATIBLE MATERIALS: OXIDIZING AGENTS
HAZARDOUS DECOMPOSITION PRODUCTS: CARBON MONOXIDE AND CARBON DIOXIDE
| 11 TOXICOLOGICAL INFORMATION | |
INFORMATION ON TOXICOLOGICAL EFFECTS:
ACUTE TOXICITY:
LD/LC50 VALUES THAT ARE RELEVANT FOR CLASSIFICATION:
142-82-5 HEPTANE:
ORAL:
LD50: >5000 MG/KG (RAT) (ESTIMATE)
INHALATIVE:
LC50/4H: 103 MG/L (RAT)
PRIMARY IRRITANT EFFECT:
ON THE SKIN: IRRITANT TO SKIN AND MUCOUS MEMBRANES.
ON THE EYE: IRRITATING EFFECT.
SENSITIZATION: NO SENSITIZING EFFECTS KNOWN.
SUBACUTE TO CHRONIC TOXICITY: NO FURTHER RELEVANT INFORMATION AVAILABLE.
ADDITIONAL TOXICOLOGICAL INFORMATION:
IRRITANT
INHALATION OF CONCENTRATED VAPORS AS WELL AS ORAL INTAKE WILL LEAD TO
ANAESTHESIA-LIKE CONDITIONS AND HEADACHE, DIZZINESS, ETC.
CARCINOGENIC CATEGORIES:
NTP (NATIONAL TOXICOLOGY PROGRAM): NONE OF THE INGREDIENTS IS LISTED.
OSHA-CA (OCCUPATIONAL SAFETY & HEALTH ADMINISTRATION):
NONE OF THE INGREDIENTS IS LISTED.
PROBABLE ROUTES OF EXPOSURE:
INHALATION.
EYE CONTACT.
SKIN CONTACT.
ACUTE EFFECTS (ACUTE TOXICITY, IRRITATION AND CORROSIVITY):
VAPORS HAVE NARCOTIC EFFECT.
IRRITATING TO EYES.
IRRITATING TO SKIN.
REPEATED DOSE TOXICITY: NO FURTHER RELEVANT INFORMATION AVAILABLE.
| 12 ECOLOGICAL INFORMATION | |
TOXICITY:
AQUATIC TOXICITY: TOXIC FOR AQUATIC ORGANISMS
PERSISTENCE AND DEGRADABILITY:
THE ORGANIC PORTION OF THE PRODUCT IS BIODEGRADABLE.
BEHAVIOR IN ENVIRONMENTAL SYSTEMS:
BIOACCUMULATIVE POTENTIAL: DOES NOT ACCUMULATE IN ORGANISMS
MOBILITY IN SOIL: NO FURTHER RELEVANT INFORMATION AVAILABLE.
ECOTOXICAL EFFECTS:
REMARK: VERY TOXIC FOR FISH
ADDITIONAL ECOLOGICAL INFORMATION:
GENERAL NOTES:
THIS STATEMENT WAS DEDUCED FROM THE PROPERTIES OF THE SINGLE COMPONENTS.
DO NOT ALLOW PRODUCT TO REACH GROUND WATER, WATER COURSE OR SEWAGE SYSTEM.
DANGER TO DRINKING WATER IF EVEN SMALL QUANTITIES LEAK INTO THE GROUND.
DUE TO AVAILABLE DATA ON ELIMINABILITY/DECOMPOSITION AND BIOACCUMULATION
POTENTIAL PROLONGED TERM DAMAGE OF THE ENVIRONMENT CAN NOT BE EXCLUDED.
RESULTS OF PBT AND VPVB ASSESSMENT:
PBT: NOT APPLICABLE.
VPVB: NOT APPLICABLE.
OTHER ADVERSE EFFECTS: NO FURTHER RELEVANT INFORMATION AVAILABLE.
| 13 DISPOSAL CONSIDERATIONS | |
WASTE TREATMENT METHODS:
RECOMMENDATION:
CONTACT WASTE PROCESSORS FOR RECYCLING INFORMATION.
THE USER OF THIS MATERIAL HAS THE RESPONSIBILITY TO DISPOSE OF UNUSED
MATERIAL, RESIDUES AND CONTAINERS IN COMPLIANCE WITH ALL RELEVANT LOCAL,
STATE AND FEDERAL LAWS AND REGULATIONS REGARDING TREATMENT, STORAGE AND
DISPOSAL FOR HAZARDOUS AND NONHAZARDOUS WASTES. RESIDUAL MATERIALS SHOULD
BE TREATED AS HAZARDOUS.
UNCLEANED PACKAGINGS:
RECOMMENDATION: DISPOSAL MUST BE MADE ACCORDING TO OFFICIAL REGULATIONS.
| 14 TRANSPORT INFORMATION | |
UN-NUMBER:
DOT, ADR, IMDG, IATA: UN1950
UN PROPER SHIPPING NAME:
LIMITED QUANTITY FOR PACKAGES LESS THAN 30 KG (66 LB) AND INNER PACKAGINGS
LESS THAN 1 L (0.3 GAL).
DOT, IATA: AEROSOLS, FLAMMABLE
ADR: 1950 AEROSOLS, ENVIRONMENTALLY HAZARDOUS
IMDG: AEROSOLS, MARINE POLLUTANT
TRANSPORT HAZARD CLASS(ES):
DOT: FLAMMABLE GAS, CLASS/DIVISION 2.1
CLASS: 2.1
LABEL: 2.1
ADR:
CLASS 2.1, FLAMMABLE GASES
ENVIRONMENT
CLASS: 2 5F GASES
LABEL: 2.1
IMDG:
CLASS 2.1 - FLAMMABLE GASES
ENVIRONMENT
CLASS: 2.1
LABEL: 2.1
IATA: CLASS 2.1, FLAMMABLE GASES
CLASS: 2.1
LABEL: 2.1
PACKING GROUP:
DOT, ADR, IMDG, IATA: NOT REGULATED
ENVIRONMENTAL HAZARDS:
PRODUCT CONTAINS ENVIRONMENTALLY HAZARDOUS SUBSTANCES:
HEPTANE, DISTILLATES (PETROLEUM), HYDROTREATED LIGHT
MARINE POLLUTANT:
YES
SYMBOL (FISH AND TREE)
SPECIAL MARKING (ADR): SYMBOL (FISH AND TREE)
SPECIAL PRECAUTIONS FOR USER:
WARNING: GASES
DANGER CODE (KEMLER):
EMS NUMBER: F-D, S-U
TRANSPORT IN BULK ACCORDING TO ANNEX II OF MARPOL73/78 AND THE IBC CODE:
NOT APPLICABLE.
TRANSPORT/ADDITIONAL INFORMATION:
DOT:
QUANTITY LIMITATIONS:
ON PASSENGER AIRCRAFT/RAIL: 75 KG
ON CARGO AIRCRAFT ONLY: 150 KG
UN "MODEL REGULATION": UN1950, AEROSOLS, ENVIRONMENTALLY HAZARDOUS, 2.1
| 15 REGULATORY INFORMATION | |
SAFETY, HEALTH AND ENVIRONMENTAL REGULATIONS/LEGISLATION SPECIFIC FOR THE
SUBSTANCE OR MIXTURE:
UNITED STATES (USA):
SARA:
SECTION 355 (EXTREMELY HAZARDOUS SUBSTANCES):
NONE OF THE INGREDIENTS IS LISTED.
SECTION 313 (SPECIFIC TOXIC CHEMICAL LISTINGS):
NONE OF THE INGREDIENTS ARE LISTED.
TSCA (TOXIC SUBSTANCES CONTROL ACT): ALL INGREDIENTS ARE LISTED.
PROPOSITION 65 (CALIFORNIA):
CHEMICALS KNOWN TO CAUSE CANCER: NONE OF THE INGREDIENTS ARE LISTED.
CHEMICALS KNOWN TO CAUSE REPRODUCTIVE TOXICITY FOR FEMALES:
NONE OF THE INGREDIENTS ARE LISTED.
CHEMICALS KNOWN TO CAUSE REPRODUCTIVE TOXICITY FOR MALES:
NONE OF THE INGREDIENTS IS LISTED.
CHEMICALS KNOWN TO CAUSE DEVELOPMENTAL TOXICITY:
NONE OF THE INGREDIENTS IS LISTED.
CARCINOGENIC CATEGORIES:
EPA (ENVIRONMENTAL PROTECTION AGENCY):
142-82-5 HEPTANE D
67-64-1 ACETONE I
IARC (INTERNATIONAL AGENCY FOR RESEARCH ON CANCER):
NONE OF THE INGREDIENTS IS LISTED.
TLV (THRESHOLD LIMIT VALUE ESTABLISHED BY ACGIH):
67-64-1 ACETONE A4
NIOSH-CA (NATIONAL INSTITUTE FOR OCCUPATIONAL SAFETY AND HEALTH):
NONE OF THE INGREDIENTS IS LISTED.
STATE RIGHT TO KNOW LISTINGS: NONE OF THE INGREDIENTS IS LISTED.
CANADIAN SUBSTANCE LISTINGS:
CANADIAN DOMESTIC SUBSTANCES LIST (DSL): ALL INGREDIENTS ARE LISTED.
CANADIAN INGREDIENT DISCLOSURE LIST (LIMIT 0.1%):
NONE OF THE INGREDIENTS IS LISTED.
CANADIAN INGREDIENT DISCLOSURE LIST (LIMIT 1%):
142-82-5 HEPTANE
67-64-1 ACETONE
124-38-9 CARBON DIOXIDE
OTHER REGULATIONS, LIMITATIONS AND PROHIBITIVE REGULATIONS:
THIS PRODUCT HAS BEEN CLASSIFIED IN ACCORDANCE WITH HAZARD CRITERIA OF THE
CONTROLLED PRODUCTS REGULATIONS AND THE SDS CONTAINS ALL THE INFORMATION
REQUIRED BY THE CONTROLLED PRODUCTS REGULATIONS.
CHEMICAL SAFETY ASSESSMENT:
A CHEMICAL SAFETY ASSESSMENT HAS NOT BEEN CARRIED OUT.
| 16 OTHER INFORMATION | |
THIS INFORMATION IS BASED ON OUR PRESENT KNOWLEDGE. HOWEVER, THIS SHALL NOT
CONSTITUTE A GUARANTEE FOR ANY SPECIFIC PRODUCT FEATURES AND SHALL NOT
ESTABLISH A LEGALLY VALID CONTRACTUAL RELATIONSHIP.
DATE OF PREPARATION / LAST REVISION: 03/11/2015 / 06/18/2015
ABBREVIATIONS AND ACRONYMS:
ADR:
ACCORD EUROPEEN SUR LE TRANSPORT DES MARCHANDISES DANGEREUSES PAR ROUTE
(EUROPEAN AGREEMENT CONCERNING THE INTERNATIONAL CARRIAGE OF DANGEROUS
GOODS BY ROAD)
IMDG: INTERNATIONAL MARITIME CODE FOR DANGEROUS GOODS
DOT: US DEPARTMENT OF TRANSPORTATION
IATA: INTERNATIONAL AIR TRANSPORT ASSOCIATION
ACGIH: AMERICAN CONFERENCE OF GOVERNMENTAL INDUSTRIAL HYGIENISTS
EINECS: EUROPEAN INVENTORY OF EXISTING COMMERCIAL CHEMICAL SUBSTANCES
ELINCS: EUROPEAN LIST OF NOTIFIED CHEMICAL SUBSTANCES
CAS: CHEMICAL ABSTRACTS SERVICE (DIVISION OF THE AMERICAN CHEMICAL SOCIETY)
NFPA: NATIONAL FIRE PROTECTION ASSOCIATION (USA)
HMIS: HAZARDOUS MATERIALS IDENTIFICATION SYSTEM (USA)
WHMIS: WORKPLACE HAZARDOUS MATERIALS INFORMATION SYSTEM (CANADA)
LC50: LETHAL CONCENTRATION, 50 PERCENT
LD50: LETHAL DOSE, 50 PERCENT
FLAM. AEROSOL 1: FLAMMABLE AEROSOLS, HAZARD CATEGORY 1
PRESS. GAS:
GASES UNDER PRESSURE: COMPRESSED GAS
PRESS. GAS:
GASES UNDER PRESSURE: LIQUEFIED GAS
FLAM. LIQ. 2: FLAMMABLE LIQUIDS, HAZARD CATEGORY 2
SKIN IRRIT. 2: SKIN CORROSION/IRRITATION, HAZARD CATEGORY 2
EYE IRRIT. 2A: SERIOUS EYE DAMAGE/EYE IRRITATION, HAZARD CATEGORY 2A
STOT SE 3:
SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE, HAZARD CATEGORY 3
ASP. TOX. 1: ASPIRATION HAZARD, HAZARD CATEGORY 1
SOURCES:
SDS PREPARED BY:
CHEMTEL INC.
1305 NORTH FLORIDA AVENUE
TAMPA, FLORIDA 33602-2902
USA
TOLL FREE NORTH AMERICA: 1-888-255-3924
INTL.: +01 813-248-0573
WEBSITE: WWW.CHEMTELINC.COM