| Common Name: | HEAVY DUTY SAE 75W-90 SYNTHETIC GEAR OIL |
| Manufacturer: | VALVOLINE |
| SDS Revision Date: | 5/22/2017 |
| SDS Format: | GHS-US |
| Item Number(s): | 453C28 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
V(TM)
VALVOLINE(TM)
SAFETY DATA SHEET
VALVOLINE(TM) HEAVY DUTY SAE 75W-90 SYNTHETIC GEAR OIL
VV70026
REVISION DATE: 05/22/2017
PRINT DATE: 1/15/2018
SDS NUMBER: R0321818
VERSION: 1.3
29 CFR 1910.1200 (OSHA HAZCOM 2012)
| SECTION 1. PRODUCT AND COMPANY IDENTIFICATION |  |
PRODUCT IDENTIFIER:
TRADE NAME: VALVOLINE(TM) HEAVY DUTY SAE 75W-90 SYNTHETIC GEAR OIL
DETAILS OF THE SUPPLIER OF THE SAFETY DATA SHEET:
VALVOLINE LLC
100 VALVOLINE WAY
LEXINGTON, KY 40509
UNITED STATES OF AMERICA (USA)
1-800-TEAMVAL
EMERGENCY TELEPHONE NUMBER: 1-800-VALVOLINE (1-800-825-8654)
REGULATORY INFORMATION NUMBER: 1-800-TEAMVAL
PRODUCT INFORMATION: 1-800-TEAMVAL
| SECTION 2. HAZARDS IDENTIFICATION | |
GHS CLASSIFICATION:
SKIN SENSITIZATION: CATEGORY 1
GHS LABEL ELEMENTS:
HAZARD PICTOGRAMS: EXCLAMATION MARK
SIGNAL WORD: WARNING
HAZARD STATEMENTS: MAY CAUSE AN ALLERGIC SKIN REACTION.
PRECAUTIONARY STATEMENTS:
IF MEDICAL ADVICE IS NEEDED, HAVE PRODUCT CONTAINER OR LABEL AT HAND.
KEEP OUT OF REACH OF CHILDREN.
READ LABEL BEFORE USE.
PREVENTION:
AVOID BREATHING DUST/ FUME/ GAS/ MIST/ VAPORS/ SPRAY.
CONTAMINATED WORK CLOTHING MUST NOT BE ALLOWED OUT OF THE WORKPLACE.
WEAR PROTECTIVE GLOVES.
RESPONSE:
IF ON SKIN: WASH WITH PLENTY OF SOAP AND WATER.
IF SKIN IRRITATION OR RASH OCCURS: GET MEDICAL ADVICE/ ATTENTION.
WASH CONTAMINATED CLOTHING BEFORE REUSE.
DISPOSAL:
DISPOSE OF CONTENTS/ CONTAINER TO AN APPROVED WASTE DISPOSAL PLANT.
OTHER HAZARDS: NONE KNOWN.
| SECTION 3. COMPOSITION/INFORMATION ON INGREDIENTS | |
SUBSTANCE / MIXTURE: MIXTURE
HAZARDOUS COMPONENTS:
CHEMICAL NAME CAS-NO. CLASSIFICATION CONCENTRATION (%)
OLEFINSULFIDE 68937-96-2 SKIN SENS. 1B; H317 5.00
N-PHENYL-1- 90-30-2 ACUTE TOX. 4; H302 0.9999
NAPHTHYLAMINE SKIN SENS. 1; H317
STOT RE 2; H373
| SECTION 4. FIRST AID MEASURES | |
GENERAL ADVICE:
MOVE OUT OF DANGEROUS AREA.
SHOW THIS SAFETY DATA SHEET TO THE DOCTOR IN ATTENDANCE.
DO NOT LEAVE THE VICTIM UNATTENDED.
IF INHALED:
IF BREATHED IN, MOVE PERSON INTO FRESH AIR.
IF UNCONSCIOUS, PLACE IN RECOVERY POSITION AND SEEK MEDICAL ADVICE.
IF SYMPTOMS PERSIST, CALL A PHYSICIAN.
IN CASE OF SKIN CONTACT:
REMOVE CONTAMINATED CLOTHING. IF IRRITATION DEVELOPS, GET MEDICAL
ATTENTION.
IF ON SKIN, RINSE WELL WITH WATER.
FIRST AID IS NOT NORMALLY REQUIRED. HOWEVER, IT IS RECOMMENDED THAT EXPOSED
AREAS BE CLEANED BY WASHING WITH SOAP AND WATER.
WASH CONTAMINATED CLOTHING BEFORE RE-USE.
IN CASE OF EYE CONTACT:
FLUSH EYES WITH WATER AS A PRECAUTION.
REMOVE CONTACT LENSES.
PROTECT UNHARMED EYE.
IF EYE IRRITATION PERSISTS, CONSULT A SPECIALIST.
IF SWALLOWED:
IF SWALLOWED: CALL A POISON CENTER/DOCTOR IF YOU FEEL UNWELL.
DO NOT GIVE MILK OR ALCOHOLIC BEVERAGES.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
IF SYMPTOMS PERSIST, CALL A PHYSICIAN.
MOST IMPORTANT SYMPTOMS AND EFFECTS, BOTH ACUTE AND DELAYED:
MAY CAUSE AN ALLERGIC SKIN REACTION.
ACUTE ASPIRATION OF LARGE AMOUNTS OF OIL-LADEN MATERIAL MAY PRODUCE A
SERIOUS ASPIRATION PNEUMONIA. PATIENTS WHO ASPIRATE THESE OILS SHOULD BE
FOLLOWED FOR THE DEVELOPMENT OF LONG-TERM SEQUELAE. REPEATED ASPIRATION OF
SMALL QUANTITIES OF MINERAL OIL CAN PRODUCE CHRONIC INFLAMMATION OF THE
LUNGS (I.E. LIPOID PNEUMONIA) THAT MAY PROGRESS TO PULMONARY FIBROSIS.
SYMPTOMS ARE OFTEN SUBTLE AND RADIOLOGICAL CHANGES APPEAR WORSE THAN
CLINICAL ABNORMALITIES. OCCASIONALLY, PERSISTENT COUGH, IRRITATION OF THE
UPPER RESPIRATORY TRACT, SHORTNESS OF BREATH WITH EXERTION, FEVER, AND
BLOODY SPUTUM OCCUR. INHALATION EXPOSURE TO OIL MISTS BELOW CURRENT
WORKPLACE EXPOSURE LIMITS IS UNLIKELY TO CAUSE PULMONARY ABNORMALITIES.
SIGNS AND SYMPTOMS OF EXPOSURE TO THIS MATERIAL THROUGH BREATHING,
SWALLOWING, AND/OR PASSAGE OF THE MATERIAL THROUGH THE SKIN MAY INCLUDE:
STOMACH OR INTESTINAL UPSET (NAUSEA, VOMITING, DIARRHEA)
IRRITATION (NOSE, THROAT, AIRWAYS)
NOTES TO PHYSICIAN: NO HAZARDS WHICH REQUIRE SPECIAL FIRST AID MEASURES.
| SECTION 5. FIREFIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
USE EXTINGUISHING MEASURES THAT ARE APPROPRIATE TO LOCAL CIRCUMSTANCES AND
THE SURROUNDING ENVIRONMENT.
WATER SPRAY
FOAM
CARBON DIOXIDE (CO2)
DRY CHEMICAL
UNSUITABLE EXTINGUISHING MEDIA: HIGH VOLUME WATER JET
SPECIFIC HAZARDS DURING FIREFIGHTING:
DO NOT ALLOW RUN-OFF FROM FIRE FIGHTING TO ENTER DRAINS OR WATER COURSES.
HAZARDOUS COMBUSTION PRODUCTS:
CARBON DIOXIDE AND CARBON MONOXIDE
OXIDES OF SULFUR, NITROGEN AND PHOSPHORUS
SULPHUR OXIDES
SPECIFIC EXTINGUISHING METHODS:
PRODUCT IS COMPATIBLE WITH STANDARD FIRE-FIGHTING AGENTS.
FURTHER INFORMATION:
FIRE RESIDUES AND CONTAMINATED FIRE EXTINGUISHING WATER MUST BE DISPOSED OF
IN ACCORDANCE WITH LOCAL REGULATIONS.
SPECIAL PROTECTIVE EQUIPMENT FOR FIREFIGHTERS:
IN THE EVENT OF FIRE, WEAR SELF-CONTAINED BREATHING APPARATUS.
| SECTION 6. ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
USE PERSONAL PROTECTIVE EQUIPMENT.
PERSONS NOT WEARING PROTECTIVE EQUIPMENT SHOULD BE EXCLUDED FROM AREA OF
SPILL UNTIL CLEAN-UP HAS BEEN COMPLETED.
ENVIRONMENTAL PRECAUTIONS:
PREVENT PRODUCT FROM ENTERING DRAINS.
PREVENT FURTHER LEAKAGE OR SPILLAGE IF SAFE TO DO SO.
IF THE PRODUCT CONTAMINATES RIVERS AND LAKES OR DRAINS INFORM RESPECTIVE
AUTHORITIES.
METHODS AND MATERIALS FOR CONTAINMENT AND CLEANING UP:
SOAK UP WITH INERT ABSORBENT MATERIAL (E.G. SAND, SILICA GEL, ACID BINDER,
UNIVERSAL BINDER, SAWDUST).
KEEP IN SUITABLE, CLOSED CONTAINERS FOR DISPOSAL.
OTHER INFORMATION:
COMPLY WITH ALL APPLICABLE FEDERAL, STATE, AND LOCAL REGULATIONS.
| SECTION 7. HANDLING AND STORAGE | |
ADVICE ON SAFE HANDLING:
DO NOT BREATHE VAPOURS/DUST.
DO NOT SMOKE.
PERSONS SUSCEPTIBLE TO SKIN SENSITISATION PROBLEMS OR ASTHMA, ALLERGIES,
CHRONIC OR RECURRENT RESPIRATORY DISEASE SHOULD NOT BE EMPLOYED IN ANY
PROCESS IN WHICH THIS MIXTURE IS BEING USED.
CONTAINER HAZARDOUS WHEN EMPTY.
AVOID EXPOSURE - OBTAIN SPECIAL INSTRUCTIONS BEFORE USE.
AVOID CONTACT WITH SKIN AND EYES.
SMOKING, EATING AND DRINKING SHOULD BE PROHIBITED IN THE APPLICATION AREA.
FOR PERSONAL PROTECTION SEE SECTION 8.
DISPOSE OF RINSE WATER IN ACCORDANCE WITH LOCAL AND NATIONAL REGULATIONS.
CONDITIONS FOR SAFE STORAGE:
KEEP CONTAINER TIGHTLY CLOSED IN A DRY AND WELL-VENTILATED PLACE.
CONTAINERS WHICH ARE OPENED MUST BE CAREFULLY RESEALED AND KEPT UPRIGHT TO
PREVENT LEAKAGE.
| SECTION 8. EXPOSURE CONTROLS/PERSONAL PROTECTION | |
COMPONENTS WITH WORKPLACE CONTROL PARAMETERS:
CONTAINS NO SUBSTANCES WITH OCCUPATIONAL EXPOSURE LIMIT VALUES.
HAZARDOUS COMPONENTS WITHOUT WORKPLACE CONTROL PARAMETERS:
COMPONENTS CAS-NO.
OLEFINSULFIDE 68937-96-2
N-PHENYL-1-NAPHTHYLAMINE 90-30-2
ENGINEERING MEASURES:
PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL EXHAUST) VENTILATION TO
MAINTAIN EXPOSURE BELOW EXPOSURE GUIDELINES (IF APPLICABLE) OR BELOW LEVELS
THAT CAUSE KNOWN, SUSPECTED OR APPARENT ADVERSE EFFECTS.
PERSONAL PROTECTIVE EQUIPMENT:
HAND PROTECTION:
REMARKS:
THE SUITABILITY FOR A SPECIFIC WORKPLACE SHOULD BE DISCUSSED WITH THE
PRODUCERS OF THE PROTECTIVE GLOVES.
EYE PROTECTION:
NOT REQUIRED UNDER NORMAL CONDITIONS OF USE. WEAR SPLASH-PROOF SAFETY
GOGGLES IF MATERIAL COULD BE MISTED OR SPLASHED INTO EYES.
SKIN AND BODY PROTECTION:
WEAR AS APPROPRIATE:
IMPERVIOUS CLOTHING
SAFETY SHOES
CHOOSE BODY PROTECTION ACCORDING TO THE AMOUNT AND CONCENTRATION OF THE
DANGEROUS SUBSTANCE AT THE WORK PLACE.
DISCARD GLOVES THAT SHOW TEARS, PINHOLES, OR SIGNS OF WEAR.
WEAR RESISTANT GLOVES (CONSULT YOUR SAFETY EQUIPMENT SUPPLIER).
HYGIENE MEASURES:
WASH HANDS BEFORE BREAKS AND AT THE END OF WORKDAY.
WHEN USING DO NOT EAT OR DRINK.
WHEN USING DO NOT SMOKE.
| SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES | |
PHYSICAL STATE: LIQUID
COLOUR: AMBER
ODOUR: PUNGENT
ODOUR THRESHOLD: NO DATA AVAILABLE
PH: NO DATA AVAILABLE
MELTING POINT/FREEZING POINT: NO DATA AVAILABLE
BOILING POINT/BOILING RANGE: NO DATA AVAILABLE
FLASH POINT: 419 DEG. F / 215 DEG. C
METHOD: CLOSED CUP
EVAPORATION RATE: NO DATA AVAILABLE
FLAMMABILITY (SOLID, GAS): NO DATA AVAILABLE
UPPER EXPLOSION LIMIT: NO DATA AVAILABLE
LOWER EXPLOSION LIMIT: NO DATA AVAILABLE
VAPOUR PRESSURE: NO DATA AVAILABLE
RELATIVE VAPOUR DENSITY: NO DATA AVAILABLE
RELATIVE DENSITY: NO DATA AVAILABLE
DENSITY: 0.879 G/CM3 (15.56 DEG. C)
SOLUBILITY(IES):
WATER SOLUBILITY: INSOLUBLE
SOLUBILITY IN OTHER SOLVENTS: NO DATA AVAILABLE
PARTITION COEFFICIENT N-OCTANOL/WATER: NO DATA AVAILABLE
THERMAL DECOMPOSITION: NO DATA AVAILABLE
VISCOSITY:
VISCOSITY, DYNAMIC: NO DATA AVAILABLE
VISCOSITY, KINEMATIC: 122 MM2/S (40 DEG. C)
OXIDIZING PROPERTIES: NO DATA AVAILABLE
| SECTION 10. STABILITY AND REACTIVITY | |
REACTIVITY: NO DECOMPOSITION IF STORED AND APPLIED AS DIRECTED.
CHEMICAL STABILITY: STABLE UNDER RECOMMENDED STORAGE CONDITIONS.
POSSIBILITY OF HAZARDOUS REACTIONS:
PRODUCT WILL NOT UNDERGO HAZARDOUS POLYMERIZATION.
CONDITIONS TO AVOID: EXCESSIVE HEAT
INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS
HAZARDOUS DECOMPOSITION PRODUCTS:
CARBON DIOXIDE AND CARBON MONOXIDE
OXIDES OF SULFUR, NITROGEN AND PHOSPHORUS
SODIUM OXIDES
| SECTION 11. TOXICOLOGICAL INFORMATION | |
INFORMATION ON LIKELY ROUTES OF EXPOSURE:
INHALATION
SKIN CONTACT
EYE CONTACT
INGESTION
ACUTE TOXICITY: NOT CLASSIFIED BASED ON AVAILABLE INFORMATION.
PRODUCT:
ACUTE ORAL TOXICITY:
REMARKS:
NOT TOXIC, NOT KNOWN TO BE TOXIC, NOT EXPECTED TO BE TOXIC BY INGESTION
ACUTE INHALATION TOXICITY:
REMARKS:
NOT TOXIC, NOT KNOWN TO BE TOXIC, NOT EXPECTED TO BE TOXIC BY INHALATION
MILD RESPIRATORY IRRITANT
COMPONENTS:
OLEFINSULFIDE:
ACUTE ORAL TOXICITY:
LD50 (RAT): >2,000 MG/KG
METHOD: OECD TEST GUIDELINE 401
ASSESSMENT: NOT CLASSIFIED AS ACUTELY TOXIC BY INGESTION UNDER GHS.
REMARKS: NO MORTALITY OBSERVED AT THIS DOSE.
ACUTE DERMAL TOXICITY:
LD50 (RAT): >2,000 MG/KG
METHOD: OECD TEST GUIDELINE 402
ASSESSMENT: NOT CLASSIFIED AS ACUTELY TOXIC BY DERMAL ABSORPTION UNDER GHS.
REMARKS: NO MORTALITY OBSERVED AT THIS DOSE.
N-PHENYL-1-NAPHTHYLAMINE:
ACUTE ORAL TOXICITY:
LD50 (RAT, MALE): CA. 1,625 MG/KG
ACUTE DERMAL TOXICITY:
LD50 (RABBIT): >5,000 MG/KG
SKIN CORROSION/IRRITATION: NOT CLASSIFIED BASED ON AVAILABLE INFORMATION.
PRODUCT:
RESULT: NO SKIN IRRITATION
REMARKS: MAY CAUSE SKIN IRRITATION IN SUSCEPTIBLE PERSONS.
COMPONENTS:
OLEFINSULFIDE:
RESULT: MILD SKIN IRRITATION
N-PHENYL-1-NAPHTHYLAMINE:
SPECIES: RABBIT
METHOD: OECD TEST GUIDELINE 404
RESULT: SLIGHT, TRANSIENT IRRITATION
SERIOUS EYE DAMAGE/EYE IRRITATION:
NOT CLASSIFIED BASED ON AVAILABLE INFORMATION.
PRODUCT:
RESULT: SLIGHT, TRANSIENT IRRITATION
REMARKS: UNLIKELY TO CAUSE EYE IRRITATION OR INJURY.
COMPONENTS:
OLEFINSULFIDE:
RESULT: SLIGHT, TRANSIENT IRRITATION
N-PHENYL-1-NAPHTHYLAMINE:
RESULT: SLIGHT, TRANSIENT IRRITATION
METHOD: OECD TEST GUIDELINE 405
RESPIRATORY OR SKIN SENSITISATION:
SKIN SENSITISATION: MAY CAUSE AN ALLERGIC SKIN REACTION.
RESPIRATORY SENSITISATION: NOT CLASSIFIED BASED ON AVAILABLE INFORMATION.
COMPONENTS:
OLEFINSULFIDE:
TEST TYPE: MAXIMISATION TEST
SPECIES: GUINEA PIG
ASSESSMENT: THE PRODUCT IS A SKIN SENSITISER, SUB-CATEGORY 1B.
METHOD: OECD TEST GUIDELINE 406
N-PHENYL-1-NAPHTHYLAMINE:
TEST TYPE: MAXIMISATION TEST
SPECIES: GUINEA PIG
ASSESSMENT: MAY CAUSE SENSITISATION BY SKIN CONTACT.
METHOD: OECD TEST GUIDELINE 406
GERM CELL MUTAGENICITY: NOT CLASSIFIED BASED ON AVAILABLE INFORMATION.
COMPONENTS:
OLEFINSULFIDE:
GENOTOXICITY IN VITRO:
TEST TYPE: IN VITRO ASSAY
RESULT: POSITIVE RESULTS WERE OBTAINED IN SOME IN VITRO TESTS.
GENOTOXICITY IN VIVO:
TEST TYPE: MICRONUCLEUS TEST
TEST SPECIES: MOUSE
CELL TYPE: BONE MARROW
METHOD: OECD TEST GUIDELINE 474
RESULT: NEGATIVE
CARCINOGENICITY: NOT CLASSIFIED BASED ON AVAILABLE INFORMATION.
REPRODUCTIVE TOXICITY: NOT CLASSIFIED BASED ON AVAILABLE INFORMATION.
STOT - SINGLE EXPOSURE: NOT CLASSIFIED BASED ON AVAILABLE INFORMATION.
STOT - REPEATED EXPOSURE: NOT CLASSIFIED BASED ON AVAILABLE INFORMATION.
COMPONENTS:
N-PHENYL-1-NAPHTHYLAMINE:
EXPOSURE ROUTES: INGESTION
TARGET ORGANS: BLOOD
ASSESSMENT:
THE SUBSTANCE OR MIXTURE IS CLASSIFIED AS SPECIFIC TARGET ORGAN TOXICANT,
REPEATED EXPOSURE, CATEGORY 2.
ASPIRATION TOXICITY: NOT CLASSIFIED BASED ON AVAILABLE INFORMATION.
FURTHER INFORMATION:
PRODUCT:
REMARKS: NO DATA AVAILABLE
CARCINOGENICITY:
IARC:
NO COMPONENT OF THIS PRODUCT PRESENT AT LEVELS GREATER THAN OR EQUAL TO
0.1% IS IDENTIFIED AS PROBABLE, POSSIBLE OR CONFIRMED HUMAN CARCINOGEN BY
IARC.
OSHA:
NO COMPONENT OF THIS PRODUCT PRESENT AT LEVELS GREATER THAN OR EQUAL TO
0.1% IS IDENTIFIED AS A CARCINOGEN OR POTENTIAL CARCINOGEN BY OSHA.
NTP:
NO COMPONENT OF THIS PRODUCT PRESENT AT LEVELS GREATER THAN OR EQUAL TO
0.1% IS IDENTIFIED AS A KNOWN OR ANTICIPATED CARCINOGEN BY NTP.
| SECTION 12. ECOLOGICAL INFORMATION | |
ECOTOXICITY:
PRODUCT:
ECOTOXICOLOGY ASSESSMENT:
ACUTE AQUATIC TOXICITY:
ACUTE AQUATIC TOXICITY CATEGORY 3; HARMFUL TO AQUATIC LIFE.
CHRONIC AQUATIC TOXICITY:
CHRONIC AQUATIC TOXICITY CATEGORY 3; HARMFUL TO AQUATIC LIFE WITH LONG
LASTING EFFECTS.
COMPONENTS:
OLEFINSULFIDE:
ECOTOXICOLOGY ASSESSMENT:
ACUTE AQUATIC TOXICITY: HARMFUL TO AQUATIC LIFE.
CHRONIC AQUATIC TOXICITY:
HARMFUL TO AQUATIC LIFE WITH LONG LASTING EFFECTS.
N-PHENYL-1-NAPHTHYLAMINE:
TOXICITY TO FISH:
LC50 (ONCORHYNCHUS MYKISS (RAINBOW TROUT)): 0.44 - 0.74 MG/L
EXPOSURE TIME: 96 H
TEST TYPE: FLOW-THROUGH TEST
TOXICITY TO DAPHNIA AND OTHER AQUATIC INVERTEBRATES:
EC50 (WATER FLEA (DAPHNIA MAGNA)): 0.3 - 0.68 MG/L
EXPOSURE TIME: 48 H
TEST TYPE: STATIC TEST
PERSISTENCE AND DEGRADABILITY:
COMPONENTS:
OLEFINSULFIDE:
BIODEGRADABILITY:
RESULT: NOT READILY BIODEGRADABLE.
BIODEGRADATION: 13%
EXPOSURE TIME: 28 D
METHOD: OECD TEST GUIDELINE 301B
N-PHENYL-1-NAPHTHYLAMINE:
BIODEGRADABILITY:
RESULT: NOT READILY BIODEGRADABLE.
BIODEGRADATION: 0%
EXPOSURE TIME: 28 D
METHOD: OECD TEST GUIDELINE 301C
NO DATA AVAILABLE
BIOACCUMULATIVE POTENTIAL:
COMPONENTS:
N-PHENYL-1-NAPHTHYLAMINE:
PARTITION COEFFICIENT N-OCTANOL/WATER:
LOG POW: 4.20
NO DATA AVAILABLE
MOBILITY IN SOIL:
COMPONENTS: NO DATA AVAILABLE
OTHER ADVERSE EFFECTS: NO DATA AVAILABLE
PRODUCT:
ADDITIONAL ECOLOGICAL INFORMATION:
AN ENVIRONMENTAL HAZARD CANNOT BE EXCLUDED IN THE EVENT OF UNPROFESSIONAL
HANDLING OR DISPOSAL., HARMFUL TO AQUATIC LIFE WITH LONG LASTING EFFECTS.
COMPONENTS:
| SECTION 13. DISPOSAL CONSIDERATIONS | |
DISPOSAL METHODS:
GENERAL ADVICE:
THE PRODUCT SHOULD NOT BE ALLOWED TO ENTER DRAINS, WATER COURSES OR THE
SOIL.
DO NOT CONTAMINATE PONDS, WATERWAYS OR DITCHES WITH CHEMICAL OR USED
CONTAINER.
SEND TO A LICENSED WASTE MANAGEMENT COMPANY.
DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE LOCAL, STATE AND FEDERAL
REGULATIONS.
CONTAMINATED PACKAGING:
EMPTY REMAINING CONTENTS.
DISPOSE OF AS UNUSED PRODUCT.
EMPTY CONTAINERS SHOULD BE TAKEN TO AN APPROVED WASTE HANDLING SITE FOR
RECYCLING OR DISPOSAL.
DO NOT RE-USE EMPTY CONTAINERS.
| SECTION 14. TRANSPORT INFORMATION | |
INTERNATIONAL TRANSPORT REGULATIONS:
REGULATION:
ID NUMBER PROPER SHIPPING NAME *HAZARD SUBSIDIARY PACKING MARINE
CLASS HAZARDS GROUP POLLUTANT /
LTD. QTY.
U.S. DOT - ROAD: NOT DANGEROUS GOODS
CFR_RAIL_C: NOT DANGEROUS GOODS
U.S. DOT - INLAND WATERWAYS: NOT DANGEROUS GOODS
TDG_ROAD_C: NOT DANGEROUS GOODS
TDG_RAIL_C: NOT DANGEROUS GOODS
TDG_INWT_C: NOT DANGEROUS GOODS
INTERNATIONAL MARITIME DANGEROUS GOODS: NOT DANGEROUS GOODS
INTERNATIONAL AIR TRANSPORT ASSOCIATION - CARGO: NOT DANGEROUS GOODS
INTERNATIONAL AIR TRANSPORT ASSOCIATION - PASSENGER: NOT DANGEROUS GOODS
MX_DG: NOT DANGEROUS GOODS
*ORM = ORM-D
CBL = COMBUSTIBLE LIQUID
MARINE POLLUTANT: NO
DANGEROUS GOODS DESCRIPTIONS (IF INDICATED ABOVE) MAY NOT REFLECT QUANTITY,
END-USE OR REGION-SPECIFIC EXCEPTIONS THAT CAN BE APPLIED. CONSULT SHIPPING
DOCUMENTS FOR DESCRIPTIONS THAT ARE SPECIFIC TO THE SHIPMENT.
| SECTION 15. REGULATORY INFORMATION | |
EPCRA - EMERGENCY PLANNING AND COMMUNITY RIGHT-TO-KNOW ACT:
CERCLA REPORTABLE QUANTITY:
THIS MATERIAL DOES NOT CONTAIN ANY COMPONENTS WITH A CERCLA RQ.
SARA 304 EXTREMELY HAZARDOUS SUBSTANCES REPORTABLE QUANTITY:
THIS MATERIAL DOES NOT CONTAIN ANY COMPONENTS WITH A SECTION 304 EHS RQ.
SARA 311/312 HAZARDS: ACUTE HEALTH HAZARD
SARA 313:
THIS MATERIAL DOES NOT CONTAIN ANY CHEMICAL COMPONENTS WITH KNOWN CAS
NUMBERS THAT EXCEED THE THRESHOLD (DE MINIMIS) REPORTING LEVELS ESTABLISHED
BY SARA TITLE III, SECTION 313.
CALIFORNIA PROP 65:
WARNING!
THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER.
2-NAPHTHALENAMINE 91-59-8
THE COMPONENTS OF THIS PRODUCT ARE REPORTED IN THE FOLLOWING INVENTORIES:
TSCA: ON TSCA INVENTORY
DSL: ALL COMPONENTS OF THIS PRODUCT ARE ON THE CANADIAN DSL
AICS: NOT IN COMPLIANCE WITH THE INVENTORY
NZIOC: NOT IN COMPLIANCE WITH THE INVENTORY
ENCS: NOT IN COMPLIANCE WITH THE INVENTORY
KECI: NOT IN COMPLIANCE WITH THE INVENTORY
PICCS: NOT IN COMPLIANCE WITH THE INVENTORY
IECSC: ON THE INVENTORY, OR IN COMPLIANCE WITH THE INVENTORY
INVENTORIES:
AICS (AUSTRALIA), DSL (CANADA), IECSC (CHINA), REACH (EUROPEAN UNION), ENCS
(JAPAN), ISHL (JAPAN), KECI (KOREA), NZIOC (NEW ZEALAND), PICCS
(PHILIPPINES), TCSI (TAIWAN), TSCA (USA)
| SECTION 16. OTHER INFORMATION | |
FURTHER INFORMATION:
REVISION DATE: 05/22/2017
NFPA:
HEALTH 2
FLAMMABILITY 1
INSTABILITY 0
SPECIAL HAZARD.
HMIS III:
HEALTH 2
FLAMMABILITY 1
PHYSICAL HAZARD 0
0 = NOT SIGNIFICANT
1 = SLIGHT
2 = MODERATE
3 = HIGH
4 = EXTREME
* = CHRONIC
NFPA FLAMMABLE AND COMBUSTIBLE LIQUIDS CLASSIFICATION:
COMBUSTIBLE LIQUID CLASS IIIB
FULL TEXT OF H-STATEMENTS:
H302: HARMFUL IF SWALLOWED.
H317: MAY CAUSE AN ALLERGIC SKIN REACTION.
H373:
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE IF
SWALLOWED.
SOURCES OF KEY DATA USED TO COMPILE THE SAFETY DATA SHEET
VALVOLINE INTERNAL DATA INCLUDING OWN AND SPONSORED TEST REPORTS
THE UNECE ADMINISTERS REGIONAL AGREEMENTS IMPLEMENTING HARMONISED
CLASSIFICATION FOR LABELLING (GHS) AND TRANSPORT.
THE INFORMATION ACCUMULATED HEREIN IS BELIEVED TO BE ACCURATE BUT IS NOT
WARRANTED TO BE WHETHER ORIGINATING WITH THE COMPANY OR NOT. RECIPIENTS ARE
ADVISED TO CONFIRM IN ADVANCE OF NEED THAT THE INFORMATION IS CURRENT,
APPLICABLE, AND SUITABLE TO THEIR CIRCUMSTANCES. THIS SDS HAS BEEN PREPARED
BY VALVOLINE'S ENVIRONMENTAL HEALTH AND SAFETY DEPARTMENT
(1-800-VALVOLINE).
LIST OF ABBREVIATIONS AND ACRONYMS THAT COULD BE, BUT NOT NECESSARILY ARE,
USED IN THIS SAFETY DATA SHEET:
ACGIH: AMERICAN CONFERENCE OF INDUSTRIAL HYGIENISTS
BEI: BIOLOGICAL EXPOSURE INDEX
CAS:
CHEMICAL ABSTRACTS SERVICE (DIVISION OF THE AMERICAN CHEMICAL SOCIETY).
CMR: CARCINOGENIC, MUTAGENIC OR TOXIC FOR REPRODUCTION
FG: FOOD GRADE
GHS:
GLOBALLY HARMONIZED SYSTEM OF CLASSIFICATION AND LABELING OF CHEMICALS.
H-STATEMENT: HAZARD STATEMENT
IATA: INTERNATIONAL AIR TRANSPORT ASSOCIATION.
IATA-DGR:
DANGEROUS GOODS REGULATION BY THE "INTERNATIONAL AIR TRANSPORT ASSOCIATION"
(IATA).
ICAO: INTERNATIONAL CIVIL AVIATION ORGANIZATION
ICAO-TI (ICAO):
TECHNICAL INSTRUCTIONS BY THE "INTERNATIONAL CIVIL AVIATION ORGANIZATION"
IMDG: INTERNATIONAL MARITIME CODE FOR DANGEROUS GOODS
ISO: INTERNATIONAL ORGANIZATION FOR STANDARDIZATION
LOGPOW: OCTANOL-WATER PARTITION COEFFICIENT
LCXX: LETHAL CONCENTRATION, FOR XX PERCENT OF TEST POPULATION
LDXX: LETHAL DOSE, FOR XX PERCENT OF TEST POPULATION.
ICXX: INHIBITORY CONCENTRATION FOR XX OF A SUBSTANCE
ECXX: EFFECTIVE CONCENTRATION OF XX
N.O.S.: NOT OTHERWISE SPECIFIED
OECD: ORGANIZATION FOR ECONOMIC CO-OPERATION AND DEVELOPMENT
OEL: OCCUPATIONAL EXPOSURE LIMIT
P-STATEMENT: PRECAUTIONARY STATEMENT
PBT: PERSISTENT, BIOACCUMULATIVE AND TOXIC
PPE: PERSONAL PROTECTIVE EQUIPMENT
STEL: SHORT-TERM EXPOSURE LIMIT
STOT: SPECIFIC TARGET ORGAN TOXICITY
TLV: THRESHOLD LIMIT VALUE
TWA: TIME-WEIGHTED AVERAGE
VPVB: VERY PERSISTENT AND VERY BIOACCUMULATIVE
WEL: WORKPLACE EXPOSURE LEVEL
CERCLA:
COMPREHENSIVE ENVIRONMENTAL RESPONSE, COMPENSATION, AND LIABILITY ACT
DOT: DEPARTMENT OF TRANSPORTATION
FIFRA: FEDERAL INSECTICIDE, FUNGICIDE, AND RODENTICIDE ACT
HMIRC: HAZARDOUS MATERIALS INFORMATION REVIEW COMMISSION
HMIS: HAZARDOUS MATERIALS IDENTIFICATION SYSTEM
NFPA: NATIONAL FIRE PROTECTION ASSOCIATION
NIOSH: NATIONAL INSTITUTE FOR OCCUPATIONAL SAFETY AND HEALTH
OSHA: OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION
PMRA: HEALTH CANADA PEST MANAGEMENT REGULATORY AGENCY
RTK: RIGHT TO KNOW
WHMIS: WORKPLACE HAZARDOUS MATERIALS INFORMATION SYSTEM