| Common Name: | CASE POWER TAN, 0000160272 |
| Manufacturer: | SEYMOUR OF SYCAMORE |
| SDS Revision Date: | 3/1/2017 |
| SDS Format: | GHS-US |
| Item Number(s): | 459V74 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
SAFETY DATA SHEET
PRINTING DATE: 03/17/2017
REVISED ON: 03/01/2017
| 1 IDENTIFICATION OF THE SUBSTANCE AND MANUFACTURER |  |
TRADE NAME: CASE POWER TAN
PRODUCT CODE: 0000160272
PRODUCT CATEGORY: PC9A PAINTS AND COATINGS.
MANUFACTURER/SUPPLIER:
SEYMOUR OF SYCAMORE
917 CROSBY AVENUE
SYCAMORE, IL 60178
PHONE: 815-895-9101
WWW.SEYMOURPAINT.COM
EMERGENCY TELEPHONE NUMBER:
CHEMTEL: 1-800-255-3924, OR 813-248-0585.
| 2 HAZARD(S) IDENTIFICATION | |
CLASSIFICATION OF THE SUBSTANCE OR MIXTURE:
FLAM. AEROSOL 1:
H222: EXTREMELY FLAMMABLE AEROSOL.
PRESS. GAS:
H280: CONTAINS GAS UNDER PRESSURE; MAY EXPLODE IF HEATED.
EYE IRRIT. 2A:
H319: CAUSES SERIOUS EYE IRRITATION.
STOT SE 3:
H336: MAY CAUSE DROWSINESS OR DIZZINESS.
STOT RE 2:
H373: MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
GHS HAZARD PICTOGRAMS:
GHS02: FLAME
GHS04: GAS CYLINDER
GHS07: EXCLAMATION MARK
GHS08: HEALTH HAZARD
SIGNAL WORD: DANGER
HAZARD STATEMENTS:
EXTREMELY FLAMMABLE AEROSOL.
CONTAINS GAS UNDER PRESSURE; MAY EXPLODE IF HEATED.
CAUSES SERIOUS EYE IRRITATION.
MAY CAUSE DROWSINESS OR DIZZINESS.
MAY CAUSE DAMAGE TO ORGANS THROUGH PROLONGED OR REPEATED EXPOSURE.
PRECAUTIONARY STATEMENTS:
KEEP AWAY FROM HEAT/SPARKS/OPEN FLAMES/HOT SURFACES. NO SMOKING.
DO NOT SPRAY ON AN OPEN FLAME OR OTHER IGNITION SOURCE.
DO NOT PIERCE OR BURN, EVEN AFTER USE.
WASH HANDS THOROUGHLY AFTER HANDLING.
USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA.
WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION.
DO NOT BREATHE DUST/FUME/GAS/MIST/VAPORS/SPRAY.
IF INHALED: REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING.
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES,
IF PRESENT AND EASY TO DO. CONTINUE RINSING.
CALL A POISON CENTER/DOCTOR IF YOU FEEL UNWELL.
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE/ATTENTION.
STORE LOCKED UP.
PROTECT FROM SUNLIGHT. DO NOT EXPOSE TO TEMPERATURES EXCEEDING
50 DEG. C/122 DEG. F.
PROTECT FROM SUNLIGHT. STORE IN A WELL-VENTILATED PLACE.
STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED.
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL REGULATIONS.
| 3 COMPOSITION/INFORMATION ON INGREDIENTS | |
CHEMICAL CHARACTERIZATION: MIXTURES
CHEMICAL DESCRIPTION:
THIS PRODUCT IS A MIXTURE OF THE SUBSTANCES LISTED BELOW WITH NONHAZARDOUS
ADDITIONS.
DANGEROUS COMPONENTS:
67-64-1 ACETONE 20.19%
74-98-6 PROPANE 15.75%
106-97-8 N-BUTANE 9.25%
7727-43-7 BARIUM SULFATE 9.08%
110-19-0 ISOBUTYL ACETATE 7.15%
2807-30-9 GLYCOL ETHER EP 6.81%
123-86-4 N-BUTYL ACETATE 3.46%
108-65-6 PM ACETATE 1.63%
107-87-9 METHYL PROPYL KETONE 1.42%
13463-67-7 TITANIUM DIOXIDE 1.19%
| 4 FIRST-AID MEASURES | |
AFTER INHALATION: SUPPLY FRESH AIR; CONSULT DOCTOR IN CASE OF COMPLAINTS.
AFTER SKIN CONTACT:
REMOVE CONTAMINATED CLOTHING. WASH EXPOSED AREA WITH SOAP AND WATER.
AFTER EYE CONTACT:
RINSE OPENED EYE FOR SEVERAL MINUTES UNDER RUNNING WATER. IF SYMPTOMS
PERSIST, CONSULT A DOCTOR.
AFTER SWALLOWING:
RINSE OUT MOUTH AND THEN DRINK PLENTY OF WATER.
RINSE MOUTH WITH WATER. DO NOT INDUCE VOMITING.
MOST IMPORTANT SYMPTOMS AND EFFECTS: DIZZINESS
INDICATION OF ANY IMMEDIATE MEDICAL ATTENTION NEEDED:
NO FURTHER RELEVANT INFORMATION AVAILABLE.
| 5 FIRE-FIGHTING MEASURES | |
EXTINGUISHING AGENTS:
CO2, EXTINGUISHING POWDER OR WATER SPRAY. FIGHT LARGER FIRES WITH
WATER SPRAY.
SPECIAL HAZARDS: CAN FORM EXPLOSIVE GAS-AIR MIXTURES.
PROTECTIVE EQUIPMENT FOR FIREFIGHTERS:
A RESPIRATORY PROTECTIVE DEVICE MAY BE NECESSARY.
| 6 ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
WEAR PROTECTIVE EQUIPMENT. KEEP UNPROTECTED PERSONS AWAY.
USE RESPIRATORY PROTECTIVE DEVICE AGAINST THE EFFECTS OF
FUMES/DUST/AEROSOL.
METHODS AND MATERIAL FOR CONTAINMENT AND CLEANING UP:
ENSURE ADEQUATE VENTILATION.
| 7 HANDLING AND STORAGE | |
PRECAUTIONS FOR SAFE HANDLING: USE ONLY IN WELL VENTILATED AREAS.
STORAGE REQUIREMENTS:
KEEP AWAY FROM SOURCES OF HEAT AND DIRECT SUNLIGHT. DO NOT WAREHOUSE
IN SUBFREEZING CONDITIONS. STORE LOCKED UP.
| 8 EXPOSURE CONTROLS/PERSONAL PROTECTION | |
COMPONENTS WITH LIMIT VALUES THAT REQUIRE MONITORING AT THE WORKPLACE:
67-64-1 ACETONE:
PEL (USA):
LONG-TERM VALUE: 2400 MG/M3, 1000 PPM
REL (USA):
LONG-TERM VALUE: 590 MG/M3, 250 PPM
TLV (USA):
SHORT-TERM VALUE: 1187 MG/M3, 500 PPM
LONG-TERM VALUE: 594 MG/M3, 250 PPM
BEI
74-98-6 PROPANE:
PEL (USA):
LONG-TERM VALUE: 1800 MG/M3, 1000 PPM
REL (USA):
LONG-TERM VALUE: 1800 MG/M3, 1000 PPM
TLV (USA): REFER TO APPENDIX F INTLVS&BEIS BOOK; NIC-EX
106-97-8 N-BUTANE:
REL (USA):
LONG-TERM VALUE: 1900 MG/M3, 800 PPM
TLV (USA):
SHORT-TERM VALUE: (2370) MG/M3, (1000) PPM
NIC-EX
7727-43-7 BARIUM SULFATE:
PEL (USA):
LONG-TERM VALUE: 15* 5** MG/M3
*TOTAL DUST **RESPIRABLE FRACTION
REL (USA):
LONG-TERM VALUE: 10* 5** MG/M3
*TOTAL DUST **RESPIRABLE FRACTION
TLV (USA):
LONG-TERM VALUE: 5* MG/M3
*INHALABLE FRACTION; E
110-19-0 ISOBUTYL ACETATE:
PEL (USA):
LONG-TERM VALUE: 700 MG/M3, 150 PPM
REL (USA):
LONG-TERM VALUE: 700 MG/M3, 150 PPM
TLV (USA):
SHORT-TERM VALUE: 172 MG/M3, 150 PPM
LONG-TERM VALUE: 238 MG/M3, 50 PPM
123-86-4 N-BUTYL ACETATE:
PEL (USA):
LONG-TERM VALUE: 710 MG/M3, 150 PPM
REL (USA):
SHORT-TERM VALUE: 950 MG/M3, 200 PPM
LONG-TERM VALUE: 710 MG/M3, 150 PPM
TLV (USA):
SHORT-TERM VALUE: 712 MG/M3, 150 PPM
LONG-TERM VALUE: 238 MG/M3, 50 PPM
108-65-6 PM ACETATE:
WEEL (USA):
LONG-TERM VALUE: 50 PPM
107-87-9 METHYL PROPYL KETONE:
PEL (USA):
LONG-TERM VALUE: 700 MG/M3, 200 PPM
REL (USA):
LONG-TERM VALUE: 530 MG/M3, 150 PPM
TLV (USA):
SHORT-TERM VALUE: 529 MG/M3, 150 PPM
INGREDIENTS WITH BIOLOGICAL LIMIT VALUES:
67-64-1 ACETONE:
BEI (USA):
50 MG/L
MEDIUM: URINE
TIME: END OF SHIFT
PARAMETER: ACETONE (NONSPECIFIC)
HYGIENIC PROTECTION:
KEEP AWAY FROM FOODSTUFFS AND ANIMAL FEED. WASH HANDS AFTER USE.
IMMEDIATELY REMOVE ALL SOILED AND CONTAMINATED CLOTHING.
WASH HANDS AFTER USE.
AVOID CONTACT WITH THE EYES AND SKIN.
DO NOT EAT OR DRINK WHILE WORKING.
BREATHING EQUIPMENT:
A RESPIRATOR IS GENERALLY NOT NECESSARY WHEN USING THIS PRODUCT OUTDOORS
OR IN LARGE OPEN AREAS. IN CASES WHERE SHORT AND/OR LONG TERM OVEREXPOSURE
EXISTS, A CHARCOAL FILTER RESPIRATOR SHOULD BE WORN. IF YOU SUSPECT
OVEREXPOSURE CONDITIONS EXIST, PLEASE CONSULT AN AUTHORITY ON CHEMICAL
HYGEINE.
HAND PROTECTION:
NITRILE GLOVES.
PROTECTIVE GLOVES. THE GLOVE MATERIAL MUST BE IMPERMEABLE AND RESISTANT
TO THE SUBSTANCE.
EYE PROTECTION: TIGHTLY SEALED GOGGLES
| 9 PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: AEROSOL.
ODOR: AROMATIC
ODOR THRESHOLD: NOT DETERMINED.
PH-VALUE: NOT DETERMINED.
MELTING POINT/MELTING RANGE: UNDETERMINED.
BOILING POINT: -44 DEG. C (-47 DEG. F)
FLASH POINT: -19 DEG. C (-2 DEG. F)
FLAMMABILITY (SOLID, GAS): EXTREMELY FLAMMABLE.
DECOMPOSITION TEMPERATURE: NOT DETERMINED.
AUTO IGNITING: PRODUCT IS NOT SELF-IGNITING.
DANGER OF EXPLOSION:
IN USE, MAY FORM FLAMMABLE/EXPLOSIVE VAPOUR-AIR MIXTURE.
LOWER EXPLOSION LIMIT: 1.7 VOL %
UPPER EXPLOSION LIMIT: 10.9 VOL %
VAPOR PRESSURE: NOT DETERMINED.
RELATIVE DENSITY: BETWEEN 0.77 AND 0.85 (WATER EQUALS 1.00)
VAPOR DENSITY: NOT DETERMINED.
EVAPORATION RATE: NOT APPLICABLE.
PARTITION COEFFICIENT N-OCTONAL/WATER: NOT DETERMINED.
SOLUBILITY: NOT DETERMINED.
VISCOSITY: NOT DETERMINED.
VOC CONTENT (LESS EXEMPT SOLVENTS): 47.7 %
SOLIDS CONTENT: 32.7 %
| 10 STABILITY AND REACTIVITY | |
REACTIVITY: STABLE AT NORMAL TEMPERATURES.
CONDITIONS TO AVOID:
DO NOT ALLOW CAN TO EXCEED 120 DEGREES FAHRENHEIT. DO NOT WAREHOUSE IN
SUBFREEZING TEMPERATURES.
CHEMICAL STABILITY: NOT FULLY EVALUATED.
POSSIBILITY OF HAZARDOUS REACTIONS: NO DANGEROUS REACTIONS KNOWN.
INCOMPATIBLE MATERIALS: NO FURTHER RELEVANT INFORMATION AVAILABLE.
HAZARDOUS DECOMPOSITION: NO DANGEROUS DECOMPOSITION PRODUCTS KNOWN.
| 11 TOXICOLOGICAL INFORMATION | |
LD/LC50 VALUES THAT ARE RELEVANT FOR CLASSIFICATION:
106-97-8 N-BUTANE:
INHALATIVE
LC50/4 H: 658 MG/L (RAT)
110-19-0 ISOBUTYL ACETATE:
ORAL:
LD50: 4763 MG/KG (RBT)
123-86-4 N-BUTYL ACETATE:
ORAL:
LD50: 14000 MG/KG (RAT)
INHALATIVE:
LC50/4 H: >21.0 MG/L (RAT)
108-65-6 PM ACETATE:
ORAL:
LD50: 8500 MG/KG (RAT)
INHALATIVE:
LC50/4 H: 35.7 MG/L (RAT)
13463-67-7 TITANIUM DIOXIDE:
ORAL:
LD50: >20000 MG/KG (RAT)
DERMAL:
LD50: >10000 MG/KG (RBT)
INHALATIVE:
LC50/4 H: >6.82 MG/L (RAT)
INFORMATION ON TOXICOLOGICAL EFFECTS: NO DATA AVAILABLE.
SKIN EFFECTS: NO IRRITANT EFFECT.
EYE EFFECTS: IRRITATING EFFECT.
SENSITIZATION: NO SENSITIZING EFFECTS KNOWN.
| 12 ECOLOGICAL INFORMATION | |
AQUATIC TOXICITY: HAZARDOUS FOR WATER, DO NOT EMPTY INTO DRAINS.
PERSISTENCE AND DEGRADABILITY:
THE PRODUCT IS DEGRADABLE AFTER PROLONGED EXPOSURE TO NATURAL WEATHERING
PROCESSES.
BIOACCUMULATIVE POTENTIAL: NO FURTHER RELEVANT INFORMATION AVAILABLE.
MOBILITY IN SOIL: NO FURTHER RELEVANT INFORMATION AVAILABLE.
OTHER ADVERSE EFFECTS: NO FURTHER RELEVANT INFORMATION AVAILABLE.
| 13 DISPOSAL CONSIDERATIONS | |
DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REGULATIONS. DO
NOT PUNCTURE, INCINERATE, OR COMPACT. PARTIALLY EMPTY CANS MUST BE
DISPOSED OF RESPONSIBLY. DO NOT HEAT OR CUT EMPTY CONTAINERS WITH ELECTRIC
OR GAS TORCHES.
RECOMMENDATION: COMPLETELY EMPTY CANS SHOULD BE RECYCLED.
| 14 TRANSPORT INFORMATION | |
UN-NUMBER: UN1950
DOT: N/A
DOT:
CONSUMER COMMODITY ORM-D
AEROSOLS, FLAMMABLE
ADR: 1950 AEROSOLS
TRANSPORT HAZARD CLASS(ES):
CLASS: 2.1
MARINE POLLUTANT: NO
SPECIAL PRECAUTIONS FOR USER:
WARNING: GASES
EMS NUMBER: F-D,S-U
STOWAGE CODE:
SW1: PROTECTED FROM SOURCES OF HEAT.
SW22:
FOR AEROSOLS WITH A MAXIMUM CAPACITY OF 1 LITRE: CATEGORY A. FOR AEROSOLS
WITH A CAPACITY ABOVE 1 LITRE: CATEGORY B. FOR WASTE AEROSOLS: CATEGORY C,
CLEAR OF LIVING QUARTERS.
SEGREGATION CODE:
SG69:
FOR AEROSOLS WITH A MAXIMUM CAPACITY OF 1 LITRE: SEGREGATION AS FOR CLASS
9. STOW "SEPARATED FROM" CLASS 1 EXCEPT FOR DIVISION 1.4. FOR AEROSOLS
WITH A CAPACITY ABOVE 1 LITRE: SEGREGATION AS FOR THE APPROPRIATE
SUBDIVISION OF CLASS 2. FOR WASTE AEROSOLS: SEGREGATION AS FOR THE
APPROPRIATE SUBDIVISION OF CLASS 2.
QUANTITY LIMITATIONS:
ON PASSENGER AIRCRAFT/RAIL: 75 KG
ON CARGO AIRCRAFT ONLY: 150 KG
ADR:
EXCEPTED QUANTITIES (EQ):
CODE: E0
NOT PERMITTED AS EXCEPTED QUANTITY
IMDG:
LIMITED QUANTITIES (LQ): 1L
EXCEPTED QUANTITIES (EQ):
CODE: E0
NOT PERMITTED AS EXCEPTED QUANTITY
PACKAGING GROUP:
UN "MODEL REGULATION": UN1950, AEROSOLS, 2.1
| 15 REGULATORY INFORMATION | |
SARA SECTION 355 (EXTREMELY HAZARDOUS SUBSTANCES):
NONE OF THE INGREDIENTS IN THIS PRODUCT ARE LISTED.
SARA SECTION 313 (SPECIFIC TOXIC CHEMICAL LISTINGS):
7727-43-7 BARIUM SULFATE
TOXIC SUBSTANCES CONTROL ACT (TSCA):
ALL INGREDIENTS FOR THIS PRODUCT ARE FOUND ON THE INVENTORY LIST
OF SUBSTANCES.
CONSUMER PRODUCT SAFETY COMISSION (CPSC):
THIS PRODUCT COMPLIES WITH 16 CFR 1303 AND DOES NOT CONTAIN MORE THAN
90 PPM OF LEAD.
CALIFORNIA PROPOSITION 65 CHEMICALS KNOWN TO CAUSE CANCER:
13463-67-7 TITANIUM DIOXIDE
108-10-1 METHYL ISOBUTYL KETONE
100-41-4 ETHYL BENZENE
CALIFORNIA PROPOSITION 65 CHEMICALS KNOWN TO CAUSE BIRTH DEFECTS OR
REPRODUCTIVE HARM:
108-10-1 METHYL ISOBUTYL KETONE
CANADIAN ENVIRONMENTAL PROTECTION ACT:
ALL HAZARDOUS INGREDIENTS FOR THIS PRODUCT APPEAR ON THE CANADIAN
DOMESTICE SUBSTANCE LIST.
WHMIS SYMBOLS FOR CANADA:
A - COMPRESSED GAS
B - FLAMMABLE AND COMBUSTIBLE MATERIAL
D2B - TOXIC MATERIAL CAUSING OTHER TOXIC EFFECTS
EPA:
67-64-1 ACETONE I
7727-43-7 BARIUM SULFATE D, CBD(INH), NL(ORAL)
110-19-0 ISOBUTYL ACETATE D
| 16 OTHER INFORMATION | |
CONTACT: REGULATORY AFFAIRS
DATE OF PREPARATION / LAST REVISION: 03/17/2017 / -