| Common Name: | CLOVER SILICON CARBIDE PAT GEL WATER MIX, 39566 |
| Manufacturer: | HENKEL |
| SDS Revision Date: | 11/22/2016 |
| SDS Format: | GHS-US |
| Item Number(s): | 45JT25 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
HENKEL
SAFETY DATA SHEET
REVISION NUMBER: 004.0
ISSUE DATE: 11/22/2016
| 1. PRODUCT AND COMPANY IDENTIFICATION |  |
PRODUCT NAME: CLOVER SILICON CARBIDE PAT GEL WATER MIX
PRODUCT TYPE: SHARPENING COMPOUND
RESTRICTION OF USE: NONE IDENTIFIED
IDH NUMBER: 233203
ITEM NUMBER: 39566
REGION: UNITED STATES
COMPANY ADDRESS:
HENKEL CORPORATION
ONE HENKEL WAY
ROCKY HILL, CONNECTICUT 06067
CONTACT INFORMATION:
TELEPHONE: +1 (860) 571-5100
MEDICAL EMERGENCY PHONE:
POISON CONTROL CENTER: 1-877-671-4608 (TOLL FREE) OR 1-303-592-1711
TRANSPORT EMERGENCY PHONE:
CHEMTREC: 1-800-424-9300 (TOLL FREE) OR 1-703-527-3887
INTERNET: WWW.HENKELNA.COM
| 2. HAZARDS IDENTIFICATION | |
EMERGENCY OVERVIEW: NOT CLASSIFIED. READ ENTIRE SAFETY DATA SHEET.
HAZARD CLASS HAZARD CATEGORY
NONE NONE
PICTOGRAM(S): NONE
PRECAUTIONARY STATEMENTS:
PREVENTION: NOT PRESCRIBED
RESPONSE: NOT PRESCRIBED
STORAGE: NOT PRESCRIBED
DISPOSAL: NOT PRESCRIBED
CLASSIFICATION COMPLIES WITH OSHA HAZARD COMMUNICATION STANDARD (29 CFR
1910.1200) AND IS CONSISTENT WITH THE PROVISIONS OF THE UNITED NATIONS
GLOBALLY HARMONIZED SYSTEM OF CLASSIFICATION AND LABELING OF CHEMICALS
(GHS).
SEE SECTION 11 FOR ADDITIONAL TOXICOLOGICAL INFORMATION.
| 3. COMPOSITION / INFORMATION ON INGREDIENTS | |
HAZARDOUS COMPONENT(S) CAS NUMBER PERCENTAGE*
SILICON CARBIDE 409-21-2 10 - 20
TRIETHANOLAMINE 102-71-6 1 - 5
DIETHANOLAMINE 111-42-2 0.1 - 1
* EXACT PERCENTAGES MAY VARY OR ARE TRADE SECRET. CONCENTRATION RANGE IS
PROVIDED TO ASSIST USERS IN PROVIDING APPROPRIATE PROTECTIONS.
| 4. FIRST AID MEASURES | |
INHALATION:
MOVE TO FRESH AIR. IF NOT BREATHING, GIVE ARTIFICIAL RESPIRATION. IF
BREATHING IS DIFFICULT, GIVE OXYGEN. IF SYMPTOMS DEVELOP AND PERSIST,
GET MEDICAL ATTENTION.
SKIN CONTACT:
WASH WITH SOAP AND WATER. IF SKIN IRRITATION PERSISTS, CALL A PHYSICIAN.
EYE CONTACT:
RINSE IMMEDIATELY WITH PLENTY OF WATER, ALSO UNDER THE EYELIDS, FOR AT
LEAST 15 MINUTES. IF EYE IRRITATION PERSISTS, CONSULT A SPECIALIST.
INGESTION:
IF CONSCIOUS, DRINK PLENTY OF WATER. NEVER GIVE ANYTHING BY MOUTH TO AN
UNCONSCIOUS PERSON. IF SYMPTOMS DEVELOP AND PERSIST, GET MEDICAL ATTENTION.
SYMPTOMS: SEE SECTION 11.
| 5. FIRE FIGHTING MEASURES | |
EXTINGUISHING MEDIA: NOT APPLICABLE. PRODUCT IS AN AQUEOUS DISPERSION.
SPECIAL FIREFIGHTING PROCEDURES: NONE
UNUSUAL FIRE OR EXPLOSION HAZARDS: NONE
HAZARDOUS COMBUSTION PRODUCTS: OXIDES OF CARBON.
| 6. ACCIDENTAL RELEASE MEASURES | |
USE PERSONAL PROTECTION RECOMMENDED IN SECTION 8, ISOLATE THE HAZARD AREA
AND DENY ENTRY TO UNNECESSARY AND UNPROTECTED PERSONNEL.
ENVIRONMENTAL PRECAUTIONS:
DO NOT ALLOW PRODUCT TO ENTER SEWER OR WATERWAYS.
CLEAN-UP METHODS:
SOAK UP WITH INERT ABSORBENT MATERIAL (E.G. SAND, SILICA GEL, ACID BINDER,
UNIVERSAL BINDER, SAWDUST). SCRAPE UP SPILLED MATERIAL AND PLACE IN A
CLOSED CONTAINER FOR DISPOSAL.
| 7. HANDLING AND STORAGE | |
HANDLING:
PREVENT CONTACT WITH EYES, SKIN AND CLOTHING. DO NOT BREATHE VAPOR AND
MIST. WASH THOROUGHLY AFTER HANDLING.
STORAGE:
KEEP IN A COOL, WELL VENTILATED AREA AWAY FROM HEAT, SPARKS AND OPEN FLAME.
KEEP CONTAINER TIGHTLY CLOSED UNTIL READY FOR USE.
| 8. EXPOSURE CONTROLS / PERSONAL PROTECTION | |
EMPLOYERS SHOULD COMPLETE AN ASSESSMENT OF ALL WORKPLACES TO DETERMINE THE
NEED FOR, AND SELECTION OF, PROPER EXPOSURE CONTROLS AND PROTECTIVE
EQUIPMENT FOR EACH TASK PERFORMED.
HAZARDOUS ACGIH TLV OSHA PEL AIHA OTHER
COMPONENT(S) WEEL
SILICON CARBIDE 3 MG/M3 TWA 5 MG/M3 PEL NONE NONE
RESPIRABLE FRACTION. RESPIRABLE FRACTION.
10 MG/M3 TWA 15 MG/M3 PEL
INHALABLE FRACTION. TOTAL DUST.
0.1 FIBERS/CM3 5 MG/M3 TWA
TWA FIBER. RESPIRABLE FRACTION.
15 MPPCF TWA
RESPIRABLE FRACTION.
15 MG/M3 TWA
TOTAL DUST.
50 MPPCF TWA
TOTAL DUST.
TRIETHANOLAMINE 5 MG/M3 TWA NONE NONE NONE
DIETHANOLAMINE 1 MG/M3 TWA NONE NONE NONE
INHALABLE FRACTION
AND VAPOR.
(SKIN) INHALABLE
FRACTION AND VAPOR.
ENGINEERING CONTROLS:
LOCAL EXHAUST VENTILATION IS RECOMMENDED WHEN GENERAL VENTILATION IS NOT
SUFFICIENT TO CONTROL AIRBORNE CONTAMINATION.
RESPIRATORY PROTECTION:
USE NIOSH APPROVED RESPIRATOR IF THERE IS POTENTIAL TO EXCEED EXPOSURE
LIMIT(S).
EYE/FACE PROTECTION: SAFETY GOGGLES OR SAFETY GLASSES WITH SIDE SHIELDS.
SKIN PROTECTION:
USE IMPERMEABLE GLOVES AND PROTECTIVE CLOTHING AS NECESSARY TO PREVENT SKIN
CONTACT.
| 9. PHYSICAL AND CHEMICAL PROPERTIES | |
PHYSICAL STATE: LIQUID, PASTE
COLOR: GRAY
ODOR: MILD
ODOR THRESHOLD: NOT AVAILABLE.
PH: NOT AVAILABLE.
VAPOR PRESSURE: NOT AVAILABLE.
BOILING POINT/RANGE: 141 - 482 DEG. C (285.8 - 899.6 DEG. F)
MELTING POINT/ RANGE: NOT AVAILABLE.
SPECIFIC GRAVITY: 1.3089
VAPOR DENSITY: HEAVIER THAN AIR.
FLASH POINT: >93 DEG. C (>199.4 DEG. F) CLEVELAND OPEN CUP
FLAMMABLE/EXPLOSIVE LIMITS - LOWER: NOT AVAILABLE.
FLAMMABLE/EXPLOSIVE LIMITS - UPPER: NOT AVAILABLE.
AUTOIGNITION TEMPERATURE: NOT AVAILABLE.
FLAMMABILITY: NOT APPLICABLE
EVAPORATION RATE: LESS THAN BUTYL ACETATE.
SOLUBILITY IN WATER: NOT AVAILABLE.
PARTITION COEFFICIENT (N-OCTANOL/WATER): NOT AVAILABLE.
VOC CONTENT: ESSENTIALLY ZERO
VISCOSITY: NOT AVAILABLE.
DECOMPOSITION TEMPERATURE: NOT AVAILABLE.
| 10. STABILITY AND REACTIVITY | |
STABILITY: STABLE
HAZARDOUS REACTIONS: WILL NOT OCCUR.
HAZARDOUS DECOMPOSITION PRODUCTS: HYDROCARBONS.
INCOMPATIBLE MATERIALS: STRONG OXIDIZING AGENTS.
REACTIVITY: NOT AVAILABLE.
CONDITIONS TO AVOID: ELEVATED TEMPERATURES.
| 11. TOXICOLOGICAL INFORMATION | |
RELEVANT ROUTES OF EXPOSURE: SKIN, INHALATION, EYES
POTENTIAL HEALTH EFFECTS/SYMPTOMS:
INHALATION: MAY CAUSE RESPIRATORY TRACT IRRITATION.
SKIN CONTACT: MAY CAUSE ALLERGIC SKIN REACTION.
EYE CONTACT: MAY CAUSE EYE IRRITATION.
INGESTION: NOT EXPECTED TO BE HARMFUL BY INGESTION.
HAZARDOUS COMPONENT(S) LD50S AND LC50S IMMEDIATE AND DELAYED
HEALTH EFFECTS
SILICON CARBIDE NONE NUISANCE DUST
TRIETHANOLAMINE ORAL LD50 (RAT): IRRITANT, ALLERGEN
8.0 G/KG
DERMAL LD50 (RABBIT):
>20,000 MG/KG
DIETHANOLAMINE ORAL LD50 (RAT): ALLERGEN, CORROSIVE,
710 MG/KG IRRITANT, LIVER,
RESPIRATORY
ORAL LD50 (RAT):
1.82 G/KG
HAZARDOUS COMPONENT(S) NTP CARCINOGEN IARC CARCINOGEN OSHA CARCINOGEN
(SPECIFICALLY
REGULATED)
SILICON CARBIDE NO GROUP 2A NO
TRIETHANOLAMINE NO NO NO
DIETHANOLAMINE NO GROUP 2B NO
| 12. ECOLOGICAL INFORMATION | |
ECOLOGICAL INFORMATION: NOT AVAILABLE.
| 13. DISPOSAL CONSIDERATIONS | |
INFORMATION PROVIDED IS FOR UNUSED PRODUCT ONLY.
RECOMMENDED METHOD OF DISPOSAL:
FOLLOW ALL LOCAL, STATE, FEDERAL AND PROVINCIAL REGULATIONS FOR DISPOSAL.
HAZARDOUS WASTE NUMBER: NOT A RCRA HAZARDOUS WASTE.
| 14. TRANSPORT INFORMATION | |
THE TRANSPORT INFORMATION PROVIDED IN THIS SECTION ONLY APPLIES TO
THE MATERIAL/FORMULATION ITSELF, AND IS NOT SPECIFIC TO ANY PACKAGE/
CONFIGURATION.
U.S. DEPARTMENT OF TRANSPORTATION GROUND (49 CFR):
PROPER SHIPPING NAME:
RQ, ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID, N.O.S.
HAZARD CLASS OR DIVISION: 9
IDENTIFICATION NUMBER: UN 3082
PACKING GROUP: III
DOT HAZARDOUS SUBSTANCE(S): DIETHANOLAMINE
INTERNATIONAL AIR TRANSPORTATION (ICAO/IATA):
PROPER SHIPPING NAME:
RQ, ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID, N.O.S.
HAZARD CLASS OR DIVISION: 9
IDENTIFICATION NUMBER: UN 3082
PACKING GROUP: III
WATER TRANSPORTATION (IMO/IMDG):
PROPER SHIPPING NAME:
RQ, ENVIRONMENTALLY HAZARDOUS SUBSTANCE, LIQUID, N.O.S.
HAZARD CLASS OR DIVISION: 9
IDENTIFICATION NUMBER: UN 3082
PACKING GROUP: III
| 15. REGULATORY INFORMATION | |
UNITED STATES REGULATORY INFORMATION:
TSCA 8 (B) INVENTORY STATUS:
ALL COMPONENTS ARE LISTED OR ARE EXEMPT FROM LISTING ON THE TOXIC
SUBSTANCES CONTROL ACT INVENTORY.
TSCA 12 (B) EXPORT NOTIFICATION: NONE ABOVE REPORTING DE MINIMIS
CERCLA/SARA SECTION 302 EHS: NONE ABOVE REPORTING DE MINIMIS.
CERCLA/SARA SECTION 311/312: IMMEDIATE HEALTH, DELAYED HEALTH
CERCLA/SARA SECTION 313: NONE ABOVE REPORTING DE MINIMIS.
CERCLA REPORTABLE QUANTITY:
DIETHANOLAMINE (CAS# 111-42-2) 100 LBS. (45.4 KG)
CALIFORNIA PROPOSITION 65:
THIS PRODUCT CONTAINS A CHEMICAL KNOWN IN THE STATE OF CALIFORNIA TO CAUSE
CANCER. THIS PRODUCT CONTAINS A CHEMICAL KNOWN TO THE STATE OF CALIFORNIA
TO CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM.
ADDITIONAL REGULATORY INFORMATION:
THIS PRODUCT IS CONTROLLED FOR EXPORT BY THE UNITED STATES DEPARTMENT OF
COMMERCE. THE EXPORT CLASSIFICATION CONTROL NUMBER (ECCN) IS 1C995.A.2.A
CANADA REGULATORY INFORMATION:
CEPA DSL/NDSL STATUS:
ALL COMPONENTS ARE LISTED ON OR ARE EXEMPT FROM LISTING ON THE CANADIAN
DOMESTIC SUBSTANCES LIST.
| 16. OTHER INFORMATION | |
THIS SAFETY DATA SHEET CONTAINS CHANGES FROM THE PREVIOUS VERSION IN
SECTIONS: NEW SAFETY DATA SHEET FORMAT.
PREPARED BY: CATHERINE BIMLER, REGULATORY AFFAIRS SPECIALIST
ISSUE DATE: 11/22/2016
DISCLAIMER:
THE DATA CONTAINED HEREIN ARE FURNISHED FOR INFORMATION ONLY AND ARE
BELIEVED TO BE RELIABLE. HOWEVER, HENKEL CORPORATION AND ITS AFFILIATES
("HENKEL") DOES NOT ASSUME RESPONSIBILITY FOR ANY RESULTS OBTAINED BY
PERSONS OVER WHOSE METHODS HENKEL HAS NO CONTROL. IT IS THE USER'S
RESPONSIBILITY TO DETERMINE THE SUITABILITY OF HENKEL'S PRODUCTS OR ANY
PRODUCTION METHODS MENTIONED HEREIN FOR A PARTICULAR PURPOSE, AND TO ADOPT
SUCH PRECAUTIONS AS MAY BE ADVISABLE FOR THE PROTECTION OF PROPERTY AND
PERSONS AGAINST ANY HAZARDS THAT MAY BE INVOLVED IN THE HANDLING AND USE OF
ANY HENKEL'S PRODUCTS. IN LIGHT OF THE FOREGOING, HENKEL SPECIFICALLY
DISCLAIMS ALL WARRANTIES, EXPRESS OR IMPLIED, INCLUDING WARRANTIES OF
MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE, ARISING FROM SALE OR
USE OF HENKEL'S PRODUCTS. HENKEL FURTHER DISCLAIMS ANY LIABILITY FOR
CONSEQUENTIAL OR INCIDENTAL DAMAGES OF ANY KIND, INCLUDING LOST PROFITS.