| Common Name: | VEXOR PEPPER SPRAY STREAM PEPPER SPRAY |
| Manufacturer: | ZARC INTERNATIONAL |
| SDS Revision Date: | 2/1/2021 |
| SDS Format: | No Format Specified |
| Item Number(s): | 45KR16 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
Z(R*)
ZARC INTERNATIONAL, INC
WWW.ZARC.COM
SAFETY DATA SHEET
ACCORDING TO FEDERAL REGISTER / VOL. 77, NO. 58 / MONDAY, MARCH 26, 2012 /
RULES AND REGULATIONS
DATE OF ISSUE: 02/01/2021
VERSION: 1.2
| SECTION 1: IDENTIFICATION |  |
PRODUCT NAME: VEXOR PEPPER SPRAY STREAM PEPPER SPRAY
PRODUCT CODE(S):
V-9133-2ACS, V-9133-3FTS,-V9133-4FTS,V-9133-9AKS,V-9133-9XAKS
INTENDED USE: PEPPER SPRAY
COMPANY:
ZARC INTERNATIONAL, INC.
529. S. PETRI DRIVE
MINONK, IL 61760
309-807-2565
EMERGENCY:
CHEM TEL 1-813-248-0585 ZARC INTERNATIONAL, INC. CONTRACT NUMBER
PHONE: MIS8310109
| SECTION 2: HAZARDS IDENTIFICATION | |
GHS04 GHS07
HAZARD PICTOGRAMS GAS CYLINDER EXCLAMATION MARK
SIGNAL WORD WARNING WARNING
HAZARD CATEGORY:
SKIN IRRITATION
EYE IRRITATION
RESPIRATORY IRRITATION
HAZARD STATEMENTS:
H315: CAUSES SKIN IRRITATION
H319: CAUSES SERIOUS EYE IRRITATION
H335: MAY CAUSE RESPIRATORY IRRITATION
PRECAUTIONARY STATEMENTS:
P305 + P338 + P351:
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT
P337: IF EYE IRRITATION PERS
P313: GET MEDICAL ADVICE/ATTENTION
P302:
IF ON SKIN:
P353: RINSE SKIN WITH WATER/SHOWER
P304 + P340:
IF INHALED:
REMOVE VICTIM TO FRESH AIR AND KEEP AT REST IN A POSITION COMFORTABLE FOR
P271: USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA
P337+313: IF EYE IRRITATION PERSISTS GET MEDICAL ADVICE/ATTENTION
P342+311:
IF EXPERIENCING RESPIRATORY SYMPTOMS:
CALL A POISON CENTER OR DOCTOR/PHYSICIAN
P280:
WEAR PROTECTIVE GLOVES/PROTECTIVE CLOTHING/EYE PROTECTION/FACE PROTECTION
P410+412:
PROTECT FROM SUNLIGHT. DO NOT EXPOSE TO TEMPERATURES EXCEEDING
50 DEG. C/122 DEG. F
P501:
DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH
LOCAL/REGIONAL/NATIONAL/INTERNATIONAL RULES.
P102: KEEP OUT OF REACH OF CHILDREN
HAZARDS NOT OTHERWISE CLASSIFIED: NOT APPLICABLE, NONE KNOWN.
| SECTION 3: COMPOSITION / INFORMATION ON INGREDIENTS | |
HAZARDOUS SUBSTANCE (NAME) CAS# WEIGHT % OSHA TWA CARCINOGEN
OLEORESIN CAPSICUM 8023-77-6 10-13% NA NO
DIETHYLENE GLYCOL 112-34-5 25-35% 1000 PPM NO
PROPYLENE GLYCOL 57-55-6 40-55% NA NO
INERT INGREDIENTS 20-30%
NITROGEN, COMPRESSED 7727-37-9 <1 NA NO
MAJOR CAPSAICINOIDS ARE DETERMINED VIA ASTM. METHOD 995.03.
** OTHER INGREDIENTS ARE TRADE SECRETS AS DEFINED IN THE HAZARD
10% @ 1.33% MAJOR CAPSACINOIDS
| SECTION 4: FIRST AID MEASURES | |
GENERAL INFO:
WHEN SYMPTOMS PERSIST OR IN ALL CASES OF DOUBT SEEK MEDICAL ADVICE.
NOTABLE EXPOSURE SYMPTOMS:
COUGHING, BREATHING DIFFICULTY, IRRITANT TO EYES. MAY CAUSE RESPIRATORY
IRRITATION.
IF INGESTED:
TREAT SYMPTOMATICALLY. IF CONSCIOUS, RINSE MOUTH WITH WATER. GET MEDICAL
ATTENTION. DO NOT INDUCE VOMITING
IF INHALED:
REMOVE TO FRESH AIR. OBTAIN MEDICAL ATTENTION IF ASTHMA-LIKE SYMPTOMS OR
OTHER SYMPTOMS DEVELOP.
EYE CONTACT:
IMMEDIATELY FLUSH EYES WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES.
EMERGENCY MEDIAL SERVICE SHOULD REMOVE CONTACT
SKIN CONTACT:
IN CASE OF CONTACT, IMMEDIATELY FLUSH SKIN WITH PLENTY OF WATER FOR AT
LEAST 15 MINUTES. TAKE OFF ALL CONTAMINATED
ADDITIONAL INFO:
OBSERVE FOR ANY SYMPTOMS FOR SEVERAL HOURS AFTER EXPOSURE. FOLLOW UP WITH
MEDICAL ATTENTION IF SYMPTOMS DEVELOP.
NOTES TO PHYSICIAN:
BECAUSE OF POSSIBLE DISTURBANCES OF CARDIAC RHYTHM, CATECHOLAMINE DRUGS,
SUCH AS EPINEPHRINE, THAT MAY BE USED IN SITUATIONS OF EMERGENCY LIFE
SUPPORT SHOULD BE USED WITH SPECIAL CAUTION.
| SECTION 5: FIGHTING MEASURES | |
GENERAL INFO: NON-FLAMMABLE
EXTINGUISHING METHOD / EQUIPMENT:
USE DRY CHEMICAL, CO2, WATER SPRAY (FOG) OR FOAM. USE EXTINGUISHING
MEASURES THAT ARE APPROPRIATE TO LOCAL CIRCUMSTANCES AND THE SURROUNDING
ENVIRONMENT. IN THE EVENT OF FIRE, WEAR SELF-CONTAINED BREATHING
APPARATUS. USE PERSONAL PROTECTIVE EQUIPMENT. WEAR NEOPRENE GLOVES DURING
CLEANING UP WORK AFTER A FIRE. EXPOSURE TO DECOMPOSITION
OTHER FIRE FIGHTING HAZZARDS:
SMOKE CAN BE IRRITAING TO EYES AND MEMBRANES. CONTAINERS MAY BURST
IN HEAT OF FIRE.
| SECTION 6: ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND PROCEDURES:
EVACUATE PERSONNEL TO SAFE AREAS. VENTILATE AREA, ESPECIALLY LOW OR
ENCLOSED PLACES WHERE HEAVY VAPOURS MIGHT COLLECT. SPILLS OF THIS
MATERIAL SHOULD BE HANDLED CAREFULLY. DO NOT SUBJECT MATERIALS TO
MECHANICAL SHOCK OR EXTREME HEAT.
CONTAINMENT EQUIPMENT AND PROCEDURES:
A SPILL OF THIS MATERIAL WILL NORMALLY NOT REQUIRE EMERGENCY RESPONSE
TEAM CAPABILITIES. WEAR PROTECTIVE EQUIPMENT. KEEP UNPROTECTED PERSONS
AWAY. USE RESPIRATORY PROTECTIVE DEVICE AGAINST THE EFFECTS OF
FUMES/DUST/AEROSOL.
CLEANUP PROCEDURES:
DISPOSE CONTAMINATED MATERIAL AS WASTE ACCORDING TO ITEM 13. ENSURE
ADEQUATE VENTILATION. SEND FOR RECOVERY OR DISPOSAL IN SUITABLE
RECEPTACLES.
| SECTION 7: HANDLING AND STORAGE | |
SAFE HANDLING PRECAUTIONS:
USE SUFFICIENT VENTILATION TO KEEP EMPLOYEE EXPOSURE BELOW RECOMMENDED
LIMITS. FOR PERSONAL PROTECTION SEE SECTION 8. HANDLE IN ACCORDANCE WITH
GOOD INDUSTRIAL HYGIENE AND SAFETY PRACTICE. STORE AND USE AWAY FROM HEAT,
SPARKS, OPEN
RECOMMENDATIONS FOR STORAGE:
STORE IN ORIGINAL CONTAINER PROTECTED FROM DIRECT SUNLIGHT IN A DRY, COOL
AND WELL-VENTILATEDAREA, AWAY FROM INCOMPATIBLE MATERIALS AND FOOD AND
DRINK.
INCOMPATIBILITIES: STORE AWAY FROM OXIDISING AGENTS.
| SECTION 8: EXPOSURE CONTROL / PERSONAL PROTECTION | |
GENERAL / ENGINEERING CONTROLS:
NORMAL VENTILATION FOR STANDARD MANUFACTURING PROCEDURES IS GENERALLY
ADEQUATE. LOCAL EXHAUST SHOULD BE USED WHEN LARGE AMOUNTS ARE RELEASED.
MECHANICAL VENTILATION SHOULD BE USED IN LOW OR ENCLOSED PLACES.
WORK CLOTHING: SUGGESTED (NOT REQUIRED)
EYE/FACE PROTECTION:
YES. EXPOSURE WITHOUT PROTECTION IN TRAINING ENVIRONMENT IS ACCEPTABLE.
SKIN PROTECTION: SUGGESTED (NOT REQUIRED)
RESPIRATORY PROTECTION:
NOT NORMALLY REQUIRED IN WELL-VENTILATED AREAS, HOWEVER, NIOSH APPROVED
RESPIRATORY PROTECTION MAY BE REQUIRED WHEN THE MATERIAL IS USED IN
CONFINED AREAS. AVOID OVEREXPOSURE
ADDITIONAL INFORMATION:
OBSERVE GOOD CHEMICAL HYGIENE PRACTICES. WASH HANDS OR EXPOSED SKIN AFTER
USING THE PRODUCT.
| SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES | |
STATE: LIQUID
APPEARANCE & COLOR: RED/ ORANGE
SP GRAV: 0.95
VAPOR PRESSURE: 140 PSI
ODOR: PUNGENT
WATER SOLUBILITY: YES WATER SOLUABLE
FLASH POINT: 74.5 C
| SECTION 10: STABILITY AND REACTIVITY | |
GENERAL: PRODUCT REMAILS STABLE
DECOMPOSITION PRODUCTS:
UNDER NORMAL CONDITIONS OF STORAGE AND USE, HAZARDOUS DECOMPOSITION
PRODUCTS SHOULD NOT BE PRODUCED.
| SECTION 11: TOXICOLOGICAL INFORMATION | |
TOXICOLOGICAL INFORMATION (PRODUCT):
PROLONGED INHALATION MAY BE HARMFUL TO HUMAN HEALTH. IRRITATING IN CASE OF
SKIN OR EYE CONTACT. MAY BE HARMFUL IF SWALLOWED OR IN CONTACT WITH SKIN.
CARCINOGENICITY OR MUTAGENICITY:
NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS.
| SECTION 12: ECOLOGICAL INFORMATION | |
OZONE: INGREDIENTS ARE NON-OZONE DEPLETING PROPELLANT
| SECTION 13: DISPOSAL INFORMATION | |
PRODUCT DISPOSAL:
COMPLETE EMPTY CANISTERS MAY DISPOSED OF IN TRASH (NO PRODUCT/PROPELLENT
REMAINS IN CAN, EMPTY CONTENTS IN A SAFE AREA)
| SECTION 14: TRANSPORT INFORMATION | |
GROUND AIR IATA IMO/IMDG
UN NUMBER ID8000 ID8000 UN1950
PROPER SHIPPING CONSUMER CONSUMER AEROSOLS NON-FLAMMABLE
NAME COMMODITY COMMODITY
TRANSPORT HAZARD NONE 9 2.2
CLASS(ES)
PACKING GROUP NONE Y963 NONE
LABEL LIMITED QTY CLASS 9 / AEROSOL NON-FLAMABLE.
REQUIREMENT LIMITED QTY Y
| SECTION 15: REGULATORY INFORMATION | |
TSCA:
THIS PRODUCT IS IN COMPLIANCE WITH THE U.S. TOXIC SUBSTANCES CONTROL ACT
(TSCA) INVENTORY REQUIREMENTS.
SARA 304: NOT LISTED
CALIFORNIA PROP 65: NOT LISTED
CANADIAN DSL: NOT LISTED
WHMIS: NOT LISTED
| SECTION 16: OTHER INFORMATION | |
DISCLAIMER:
THE INFORMATION CONTAINED HEREIN IS BASED UPON DATA PROVIDED TO US BY OUR
SUPPLIERS, AND REFLECTS OUR BEST JUDGEMENT. HOWEVER, NO WARRANTY OF
MERCHANTABILITY, FITNESS FOR ANY USE, OR ANY OTHER WARRANTY IS EXPRESSED
OR IMMPLIED REGARDING THE ACCURACY OF SUCH DATA, OR THE RESULTS TO BE
OBTAINED FROM THE USE THEREOF. SINCE THE INFORMATION CONTAINED HEREIN MAY
BE APPLIED UNDER CONDITIONS BEYOND OUR CONTROL AND WITH WHICH WE MAY BE
UNFAMILIAR, WE DO NOT ASSUME ANY RESPONSIBILITY FOR THE RESULTS OF SUCH
APPLICATION. THE INFORMATION IS FURNISHED UPON THE CONDITION THAT THE
PERSONS RECEIVING IT SHALL MAKE THEIR OWN DETERMINATION OF THE SUITABILITY
OF THE MATERIAL FOR ANY PARTICULAR PURPOSE.
V-010