| Common Name: | ROOT-BAN DRAIN PIPE ADHESIVE |
| Manufacturer: | T CHRISTY ENTERPRISES |
| SDS Revision Date: | 11/1/2014 |
| SDS Format: | GHS-US |
| Item Number(s): | 45RF94, 45RF95 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
CHRISTY'S(TM)
SAFETY DATA SHEET
CHRISTY'S(R*) ROOT-BAN(TM) DRAIN PIPE ADHESIVE
DATE REVISED: NOV 2014
SUPERSEDES: ORIGINAL
| SECTION 1 - PRODUCT AND COMPANY IDENTIFICATION |  |
PRODUCT NAME: CHRISTY'S(R*) ROOT-BAN(TM) DRAIN PIPE ADHESIVE
PRODUCT USE: SYNTHETIC RUBBER BASED ADHESIVE
SYNONYMS:
SUPPLIER AND MANUFACTURER:
T CHRISTY ENTERPRISES, INC.
655 EAST BALL ROAD
ANAHEIM, CA 92805-5910
TEL.: 1-714-507-3300 (NORTH AMERICA)
TEL.: 1 714-507-3300 (INTERNATIONAL)
EMERGENCY:
TRANSPORTATION/MEDICAL ISSUES:
TEL.: 800.535.5053 INFOTRAC
| SECTION 2 - HAZARDS IDENTIFICATION | |
GHS CLASSIFICATION:
HEALTH:
ACUTE TOXICITY: CATEGORY 2
SKIN CORROSION/IRRITATION: CATEGORY 2
SKIN SENSITIZATION: YES
EYE: CATEGORY 2A
ENVIRONMENTAL:
ACUTE TOXICITY: NONE KNOWN
CHRONIC TOXICITY: NONE KNOWN
PHYSICAL:
FLAMMABLE LIQUID/AEROSOL/GAS: CATEGORY 2
SIGNAL WORD: DANGER
GHS LABEL:
FLAME
EXCLAMATION MARK
HEALTH HAZARD
WHMIS CLASSIFICATION:
CONTROLLED PRODUCT
CLASS B, DIVISION 2
CLASS D, DIVISION 2B
HAZARD STATEMENTS:
H225: HIGHLY FLAMMABLE LIQUID AND VAPOUR
H305: MAY BE HARMFUL IF SWALLOWED AND ENTERS AIRWAYS
H315: CAUSES SKIN IRRITATION
H319: CAUSES SERIOUS EYE IRRITATION
H336: MAY CAUSE DROWSINESS OR DIZZINESS
PRECAUTIONARY STATEMENTS (SEE SECTION 15 FOR ALL ADVISORY AND REQUIRED
PRECAUTIONS):
P210:
KEEP AWAY FROM HEAT, HOT SURFACES, OPEN FLAMES AND OTHER IGNITION SOURCES.
NO SMOKING
P261: AVOID BREATHING DUST/FUME/GAS/MIST/VAPOURS/SPRAY
P264: WASH HANDS THOROUGHLY AFTER HANDLING.
P271: USE ONLY OUTDOORS OR IN A WELL-VENTILATED AREA.
P280:
WEAR PROTECTIVE GLOVES/PROTECTIVE/CLOTHING/EYE PROTECTION/FACE PROTECTION
P301+P310:
IF SWALLOWED IMMEDIATELY CALL A POISON CONTROL CENTER OR DOCTOR/PHYSICIAN
P304 + P340:
IF INHALED: REMOVE PERSON TO FRESH AIR AND KEEP COMFORTABLE FOR BREATHING.
P305+P351+P338:
IF IN EYES:
RINSE CAUTIOUSLY WITH WATER FOR SEVERAL MINUTES.
REMOVE CONTACT LENSES, IF PRESENT AND EASY TO DO. CONTINUE RINSING.
P312: CALL A POISON CENTER/DOCTOR IF YOU FEEL UNWELL.
P331: DO NOT INDUCE VOMITING
P332+P337+P313:
IF SKIN OR EYE IRRITATION OCCURS: GET MEDICAL ADVICE/ATTENTION
P362+P364: TAKE OFF CONTAMINATED CLOTHES AND WASH IT BEFORE REUSE.
P405: STORE LOCKED UP
P403+P233+P235:
STORE IN A WELL-VENTILATED PLACE. KEEP CONTAINER TIGHTLY CLOSED. KEEP COOL
P501: DISPOSE OF CONTENTS/CONTAINER IN ACCORDANCE WITH LOCAL REGULATIONS.
| SECTION 3 - COMPOSITION/INFORMATION ON INGREDIENTS | |
CAS# EINECS # REACH CONCENTRATION
PRE-REGISTRATION % BY WEIGHT
NUMBER
ROSIN BASED 8050-26-8 13-30
RESIN
ACETONE 67-64-1 200-662-2 05-2116297713-35-0000 10-40
HEPTANE* 142-82-5 20-60
GLOBALPRENE SBS 9003-55-8 5-30
ALL OF THE CONSTITUENTS OF THIS ADHESIVE PRODUCT ARE LISTED ON THE TSCA
INVENTORY OF CHEMICAL SUBSTANCES MAINTAINED BY THE US EPA, OR ARE EXEMPT
FROM THAT LISTING.
*THIS CHEMICAL IS SUBJECT TO THE REPORTING REQUIREMENTS OF SECTION 313
OF THE EMERGENCY PLANNING AND COMMUNITY RIGHT-TO-KNOW ACT OF 1986
(40 CFR 372).
| SECTION 4 - FIRST AID MEASURES | |
CONTACT WITH EYES:
FLUSH EYES IMMEDIATELY WITH PLENTY OF WATER FOR 15 MINUTES AND SEEK MEDICAL
ADVICE IMMEDIATELY.
SKIN CONTACT:
REMOVE CONTAMINATED CLOTHING AND SHOES. WASH SKIN THOROUGHLY WITH SOAP AND
WATER. IF IRRITATION DEVELOPS, SEEK MEDICAL ADVICE.
INHALATION:
REMOVE TO FRESH AIR. IF BREATHING IS STOPPED, GIVE ARTIFICIAL RESPIRATION.
IF BREATHING IS DIFFICULT, GIVE OXYGEN. SEEK MEDICAL ADVICE.
INGESTION:
RINSE MOUTH WITH WATER. GIVE 1 OR 2 GLASSES OF WATER OR MILK TO DILUTE. DO
NOT INDUCE VOMITING. SEEK MEDICAL ADVICE IMMEDIATELY.
| SECTION 5 - FIREFIGHTING MEASURES | |
SUITABLE EXTINGUISHING MEDIA:
DRY CHEMICAL POWDER, CARBON DIOXIDE GAS, FOAM, HALON, WATER FOG.
UNSUITABLE EXTINGUISHING MEDIA: WATER SPRAY OR STREAM.
EXPOSURE HAZARDS:
CARBON MONOXIDE, CARBON DIOXIDE, HYDROGEN CHLORIDE AND SMOKE
COMBUSTION PRODUCTS:
CARBON MONOXIDE, CARBON DIOXIDE, HYDROGEN CHLORIDE AND SMOKE
PROTECTION FOR FIREFIGHTERS:
SELF-CONTAINED BREATHING APPARATUS OR FULL-FACE POSITIVE PRESSURE AIRLINE
MASKS.
HMIS NFPA
HEALTH 2 2
FLAMMABILITY 3 3
REACTIVITY 1 1
0-MINIMAL
1-SLIGHT
2-MODERATE
3-SERIOUS
4-SEVERE
| SECTION 6 - ACCIDENTAL RELEASE MEASURES | |
PERSONAL PRECAUTIONS:
KEEP AWAY FROM HEAT, SPARKS AND OPEN FLAME.
PROVIDE SUFFICIENT VENTILATION, USE EXPLOSION-PROOF EXHAUST VENTILATION
EQUIPMENT OR WEAR SUITABLE RESPIRATORY PROTECTIVE EQUIPMENT.
PREVENT CONTACT WITH SKIN OR EYES (SEE SECTION 8).
ENVIRONMENTAL PRECAUTIONS:
PREVENT PRODUCT OR LIQUIDS CONTAMINATED WITH PRODUCT FROM ENTERING SEWERS,
DRAINS, SOIL OR OPEN WATER COURSE.
METHODS FOR CLEANING UP:
CLEAN UP WITH SAND OR OTHER INERT ABSORBENT MATERIAL. TRANSFER TO A
CLOSABLE METAL CONTAINER
MATERIALS NOT TO BE USED FOR CLEAN UP: ALUMINUM OR PLASTIC CONTAINERS
| SECTION 7 - HANDLING AND STORAGE | |
HANDLING:
AVOID BREATHING OF VAPOR, AVOID CONTACT WITH EYES, SKIN AND CLOTHING.
KEEP AWAY FROM IGNITION SOURCES, USE ONLY ELECTRICALLY GROUNDED HANDLING
EQUIPMENT AND ENSURE ADEQUATE VENTILATION/FUME EXHAUST HOODS.
DO NOT EAT; DRINK OR SMOKE WHILE HANDLING.
STORAGE:
STORE IN VENTILATED ROOM OR SHADE BELOW 27 DEG. C (80 DEG. F) AND AWAY FROM
DIRECT SUNLIGHT.
KEEP AWAY FROM IGNITION SOURCES AND INCOMPATIBLE MATERIALS:
CAUSTICS, AMMONIA, INORGANIC ACIDS, CHLORINATED COMPOUNDS, STRONG OXIDIZERS
AND ISOCYANATES.
FOLLOW ALL PRECAUTIONARY INFORMATION ON CONTAINER LABEL, PRODUCT BULLETINS
AND SOLVENT CEMENTING LITERATURE.
| SECTION 8 - PRECAUTIONS TO CONTROL EXPOSURE / PERSONAL | |
PROTECTION
EXPOSURE LIMITS:
COMPONENT ACGIH TLV ACGIH STEL OSHA PEL OSHA STEL
ACETONE 500 PPM 750 PPM 750 PPM 1000 PPM
HEPTANE 200 PPM 300 PPM 500 PPM
ENGINEERING CONTROLS:
IF VENTILATED CABINET, ENCLOSURE OR FUME HOOD IS NECESSARY, AVERAGE AIRFLOW
SHOULD BE AT LEAST 100 FPM (50.8 CM/SEC).
MONITORING:
MAINTAIN BREATHING ZONE AIRBORNE CONCENTRATIONS BELOW EXPOSURE LIMITS.
PERSONAL PROTECTIVE EQUIPMENT (PPE):
EYE PROTECTION:
AVOID CONTACT WITH EYES, WEAR SPLASH PROOF CHEMICAL GOGGLES, FACE SHIELD,
SAFETY GLASSES (SPECTACLES) WITH BROW GUARDS AND SIDE SHIELDS, ETC. AS MAY
BE APPROPRIATE FOR THE EXPOSURE.
SKIN PROTECTION:
PREVENT CONTACT WITH THE SKIN AS MUCH AS POSSIBLE. POLYETHYLENE OR PVA
COATED RUBBER GLOVES SHOULD BE USED FOR FREQUENT IMMERSION.
USE OF LATEX/NITRILE SURGICAL GLOVES OR SOLVENT-RESISTANT BARRIER CREAM
SHOULD PROVIDE ADEQUATE PROTECTION WHEN NORMAL ADHESIVE APPLICATION
PRACTICES AND PROCEDURES ARE USED FOR MAKING STRUCTURAL BONDS.
RESPIRATORY PROTECTION:
PREVENT INHALATION OF THE SOLVENTS. USE IN A WELL-VENTILATED ROOM. OPEN
DOORS AND/OR WINDOWS TO ENSURE AIRFLOW AND AIR CHANGES. USE LOCAL EXHAUST
VENTILATION TO REMOVE AIRBORNE CONTAMINANTS FROM EMPLOYEE BREATHING ZONE
AND TO KEEP CONTAMINANTS BELOW LEVELS LISTED ABOVE. WITH NORMAL USE, THE
EXPOSURE LIMIT VALUE WILL NOT USUALLY BE REACHED. WHEN LIMITS APPROACHED,
USE RESPIRATORY PROTECTION EQUIPMENT.
| SECTION 9 - PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: GREEN, REGULAR SYRUPY LIQUID
ODOR: ETHEREAL
ODOR THRESHOLD: N/D
P.H.: NOT APPLICABLE
MELTING/FREEZING POINT:
-95 DEG. C (-139 DEG. F) BASED ON FIRST FREEZING COMPONENT: ACETONE
BOILING RANGE: 57 DEG. C (133 DEG. F) TO 98 DEG. C (208 DEG. F)
BOILING POINT:
57 DEG. C (133 DEG. F) BASED ON FIRST BOILING COMPONENT: ACETONE
EVAPORATION RATE: >1.0 (BUAC = 1)
FLASH POINT: -4 DEG. C (24.8 DEG. F) T.C.C. BASED ON HEPTANE
FLAMMABILITY: CATEGORY I
SPECIFIC GRAVITY:
@ 23 DEG. C +/- 2 DEG. (73 DEG. F +/- 3.6 DEG.) TYPICAL 0.833 +/- 0.01
FLAMMABILITY LIMITS:
LEL: 2%
UEL: 11.8%
SOLUBILITY:
SOLVENT PORTION COMPLETELY SOLUBLE IN WATER. RESIN PORTION SEPARATES OUT.
PARTITION COEFFICIENT N-OCTANOL/WATER: NOT AVAILABLE
VAPOR PRESSURE:
181 MMHg @ 20 DEG. C (68 DEG. F): ACETONE
AUTO-IGNITION TEMPERATURE:
203 DEG. C (399 DEG. F): T.C.C. BASED ON HEPTANE
VAPOR DENSITY: <2 (AIR = 1)
DECOMPOSITION TEMPERATURE: NOT APPLICABLE
OTHER DATA:
VISCOSITY: REGULAR BODIED
VOC CONTENT:
WHEN APPLIED AS DIRECTED, PER SCAQMD RULE 1168, TEST METHOD 316A,
VOC CONTENT IS: </=250 GL/L.
| SECTION 10 - STABILITY AND REACTIVITY | |
STABILITY: STABLE
HAZARDOUS DECOMPOSITION PRODUCTS:
NONE IN NORMAL USE. WHEN FORCED TO BURN, THIS PRODUCT GIVES OFF CARBON
MONOXIDE (CO), CARBON DIOXIDE (CO2), HYDROGEN CHLORIDE (HCL) AND SMOKE.
CONDITIONS TO AVOID:
KEEP AWAY FROM HEAT, SPARKS, OPEN FLAME AND OTHER IGNITION SOURCES.
INCOMPATIBLE MATERIALS:
CAUSTICS, AMMONIA, INORGANIC ACIDS, CHLORINATED COMPOUNDS, STRONG OXIDIZERS
AND ISOCYANATES.
| SECTION 11 - TOXICOLOGICAL INFORMATION | |
LIKELY ROUTES OF EXPOSURE: INHALATION, EYE AND SKIN CONTACT
ACUTE SYMPTOMS AND EFFECTS:
INHALATION:
SEVERE OVEREXPOSURE MAY RESULT IN NAUSEA, DIZZINESS, HEADACHE. CAN CAUSE
DROWSINESS, IRRITATION OF EYES AND NASAL PASSAGES.
EYE CONTACT:
VAPORS SLIGHTLY UNCOMFORTABLE. OVEREXPOSURE MAY RESULT IN SEVERE EYE INJURY
WITH CORNEAL OR CONJUNCTIVAL INFLAMMATION ON CONTACT WITH THE LIQUID.
SKIN CONTACT:
LIQUID CONTACT MAY REMOVE NATURAL SKIN OILS RESULTING IN SKIN IRRITATION.
DERMATITIS MAY OCCUR WITH PROLONGED CONTACT.
INGESTION: MAY CAUSE NAUSEA, VOMITING, DIARRHEA AND MENTAL SLUGGISHNESS.
CHRONIC (LONG-TERM) EFFECTS: NONE KNOWN TO HUMANS
TOXICITY:
LD50 LC50
ACETONE ORAL: 9.75 G/KG (RAT) INHALATION LCLO 4 HRS.:
DERMAL: 20 G/KG (RABBIT) 16,000 PPM (RAT)
HEPTANE ORAL: 5170 MG/KG (RAT) INHALATION LCLO:
4 HRS. 7.63 MG/L (RAT)
REPRODUCTIVE EFFECTS: NOT APPLICABLE
TERATOGENICITY: NOT APPLICABLE
MUTAGENICITY: POSS.
EMBRYOTYXICITY: NOT APPLICABLE
SENSITIZATION TO PRODUCT: NOT APPLICABLE
SYNERGISTIC PRODUCTS; NOT AVAILABLE
| SECTION 12 - ECOLOGICAL INFORMATION | |
ECOTOXICITY: NO KNOWN SIGNIFICANT EFFECTS OR CRITICAL HAZARDS
MOBILITY:
IN NORMAL USE, EMISSION OF VOLATILE ORGANIC COMPOUNDS (VOC'S) TO THE AIR
TAKES PLACE. TYPICALLY AT A RATE OF </= 250 GRAMS/LITER.
MINIMAL OTHER ADVERSE EFFECTS INCLUDE POSSIBLE GROUND WATER CONTAMINATION
FROM RELEASE TO SOIL, SEWERS, DRAINS OR WATER COURSE.
DEGRADABILITY: BIODEGRADABLE
BIOACCUMULATION: MINIMAL TO NONE.
| SECTION 13 - WASTE DISPOSAL CONSIDERATIONS | |
FOLLOW LOCAL AND NATIONAL REGULATIONS. CONSULT DISPOSAL EXPERT. CAN BE
DISPOSED OF BY CONTROLLED INCINERATION. MAY BE ALLOWED TO DRY AND DISPOSED
OF AS TRASH. EXCESSIVE QUANTITIES SHOULD NOT BE PERMITTED TO ENTER DRAINS,
SEWERS OR WATER COURSES. EMPTY CONTAINERS SHOULD BE AIR DRIED BEFORE
DISPOSING.
| SECTION 14 - TRANSPORT INFORMATION | |
DOT, IATA, ADR, IMO/IMDG SHIPPING INFORMATION:
PROPER SHIPPING NAME: ADHESIVES
HAZARD CLASS: 3
SECONDARY RISK: NONE
IDENTIFICATION NUMBER: UN 1133
PACKING GROUP: II
LABEL REQUIRED: FLAMMABLE LIQUID
MARINE POLLUTANT: NO
DOT/IMDG EXCEPTION:
CASE QUANTITIES OF CEMENT IN CONTAINERS OF LESS THAN ONE LITER MAY BE
SHIPPED AS LIMITED QUANTITY WHEN PROPERLY LABELED AND MARKED.
ICAO/IATA:
MAY BE SHIPPED BY AIR AS CONSUMER COMMODITY, ID 8000 WHEN PROPERLY
PACKAGED, LABELED AND MARKED.
TDG INFORMATION:
TDG CLASS: FLAMMABLE LIQUID 3
SHIPPING NAME: ADHESIVES (ACETONE)
UN NUMBER: 1133, PG II
| SECTION 15 - REGULATORY INFORMATION | |
PRECAUTIONARY LABEL INFORMATION: HIGHLY FLAMMABLE, IRRITANT
SYMBOLS: F, XI
INGREDIENT LISTINGS:
USA TSCA, EUROPE EINECS, CANADA DSL, AUSTRALIA AICS, KOREA ECL/TCCL, JAPAN
MITI (ENCS)
RISK PHRASES:
R-11: HIGHLY FLAMMABLE
R-20: HARMFUL BY INHALATION
R-21: HARMFUL IN CONTACT WITH SKIN.
R-22: HARMFUL IF SWALLOWED.
R-36/37/38: IRRITATING TO EYES, RESPIRATORY SYSTEM AND SKIN.
R-41: RISK OF SERIOUS DAMAGE TO THE EYES.
R-43: MAY CAUSE SENSITIZATION BY SKIN CONTACT.
SAFETY PHRASES:
S-2: KEEP OUT OF REACH OF CHILDREN.
S-7: KEEP CONTAINER TIGHTLY CLOSED WHEN NOT IN USE.
S-9: KEEP CONTAINER IN A WELL-VENTILATED PLACE.
S-15/16: KEEP AWAY FROM HEAT AND SOURCES OF IGNITION. NO SMOKING.
S-23: DO NOT BREATHE VAPOR.
S-24/25: AVOID CONTACT WITH SKIN AND EYES.
S-29: DO NOT EMPTY INTO DRAINS.
S-37: WEAR SUITABLE GLOVES.
S-45: IF SEEKING MEDICAL ADVICE SHOW PHYSICIAN LABEL OR SDS.
S-51: USE ONLY IN WELL VENTILATED AREAS.
S-46:
IF SWALLOWED, SEEK MEDICAL ADVICE IMMEDIATELY AND SHOW THIS CONTAINER OR
LABEL
| SECTION 16 - OTHER INFORMATION | |
SPECIFICATION INFORMATION:
DEPARTMENT ISSUING DATA SHEET: ENVIRONMENTAL HEALTH & SAFETY
E-MAIL ADDRESS: <EHSINFO@TCHRISTY.COM>
ALL INGREDIENTS ARE COMPLIANT WITH THE REQUIREMENTS OF THE EUROPEAN
DIRECTIVE ON ROHS (RESTRICTION OF HAZARDOUS SUBSTANCES).
TRAINING NECESSARY:
YES, TRAINING IN PRACTICES AND PROCEDURES CONTAINED IN PRODUCT LITERATURE.
REISSUE DATE / REASON FOR REISSUE: NOV 2014/ORIGINAL
INTENDED USE OF PRODUCT:
CONTACT ADHESIVE FOR POLYETHYLENE, HDPE AND STYRENE DRAIN PIPE AND
FITTINGS.
THIS PRODUCT IS INTENDED FOR USE BY SKILLED INDIVIDUALS AT THEIR OWN RISK.
THE INFORMATION CONTAINED HEREIN IS BASED ON DATA CONSIDERED ACCURATE BASED
ON CURRENT STATE OF KNOWLEDGE AND EXPERIENCE. HOWEVER, NO WARRANTY IS
EXPRESSED OR IMPLIED REGARDING THE ACCURACY OF THIS DATA OR THE RESULTS TO
BE OBTAINED FROM THE USE THEREOF.
FILENAME: DRAIN PIPE 3