| Common Name: | ACID NEUTRALIZING ABSORBENT |
| Manufacturer: | SPILL MAGIC |
| SDS Revision Date: | 12/23/2014 |
| SDS Format: | GHS-US |
| Item Number(s): | 487C48, 487C49, 487C55 |
| Manufacturer Model Number(s): |
SDS Table of Contents
Click the desired link below to jump directly to that section in the SDS.
SAFETY DATA SHEET
ACID NEUTRALIZING ABSORBENT
SDS REVISION DATE: 12/23/2014
| SECTION 1. IDENTIFICATION OF THE SUBSTANCE/MIXTURE |  |
AND OF THE COMPANY/UNDERTAKING
PRODUCT NAME: ACID NEUTRALIZING ABSORBENT
MANUFACTURER:
SPILL MAGIC INC.
630 YOUNG STREET
SANTA ANNA, CA 92705
TELEPHONE NUMBER:
INFORMATION: (800) 969-1467
24 HR EMERGENCY: (800) 969-1467
RECOMMENDED USES: ABSORBENT AND DISINFECTING MATERIAL
RECOMMENDED RESTRICTION: USE ONLY AS DIRECTED
DATE OF PREPARATION: DECEMBER 23, 2014
| SECTION 2. HAZARD IDENTIFICATION OF THE PRODUCT | |
2.1. CLASSIFICATION OF THE SUBSTANCE OR MIXTURE:
EYE IRRIT. 2:
H319: CAUSES SERIOUS EYE IRRITATION.
2.2. LABEL ELEMENTS: EXCLAMATION MARK
WARNING!
H319: CAUSES SERIOUS EYE IRRITATION
PREVENTION]:
P264: WASH THOROUGHLY AFTER HANDLING.
P280: WEAR PROTECTIVE GLOVES / EYE PROTECTION / FACE PROTECTION.
[RESPONSE]:
P305+351+338:
IF IN EYES:
RINSE CONTINUOUSLY WITH WATER FOR SEVERAL MINUTES. REMOVE CONTACT LENSES IF
PRESENT AND EASY TO DO - CONTINUE RINSING.
P337+313:
IF EYE IRRITATION PERSISTS: GET MEDICAL ADVICE / ATTENTION.
[STORAGE]: NO GHS STORAGE STATEMENTS
[DISPOSAL]: NO GHS DISPOSAL STATEMENTS
| SECTION 3. COMPOSITION / INFORMATION ON INGREDIENTS | |
THIS PRODUCT CONTAINS THE FOLLOWING SUBSTANCES THAT PRESENT A HAZARD WITHIN
THE MEANING OF THE RELEVANT STATE AND FEDERAL HAZARDOUS SUBSTANCES
REGULATIONS.
INGREDIENT/CHEMICAL DESIGNATIONS WEIGHT % GHS CLASSIFICATION NOTES
AMORPHOUS ALUMINA SILICATE PERLITE 50 - 75 [1][2]
CAS NUMBER: 0093763-70-3
SODIUM CARBONATE 25 - 50 EYE IRRIT. 2; H319 [1]
CAS NUMBER: 0000497-19-8
[1] SUBSTANCE CLASSIFIED WITH A HEALTH OR ENVIRONMENTAL HAZARD.
[2] SUBSTANCE WITH A WORKPLACE EXPOSURE LIMIT.
[3] PBT-SUBSTANCE OR VPVB-SUBSTANCE.
*THE FULL TEXTS OF THE PHRASES ARE SHOWN IN SECTION 16.
| SECTION 4. FIRST-AID MEASURES | |
4.1. DESCRIPTION OF FIRST AID MEASURES:
GENERAL:
IN ALL CASES OF DOUBT, OR WHEN SYMPTOMS PERSIST, SEEK MEDICAL ATTENTION.
NEVER GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS PERSON.
INHALATION:
REMOVE THE PERSON TO FRESH AIR. GET MEDICAL ATTENTION IF IRRITATION OR
DISCOMFORT PERSISTS.
EYES:
IRRIGATE COPIOUSLY WITH CLEAN WATER FOR AT LEAST 15 MINUTES, HOLDING THE
EYELIDS APART AND SEEK MEDICAL ATTENTION
SKIN:
WASH WITH PLENTY OF SOAP AND WATER. COVER THE IRRITATED SKIN WITH AN
EMOLLIENT. REMOVE AND WASH CONTAMINATED CLOTHING AND SHOES. GET MEDICAL
ATTENTION IF IRRITATION PERSISTS.
INGESTION:
DRINK LARGE AMOUNTS OF WATER. DO NOT INDUCE VOMITING. GET MEDICAL ATTENTION
4.2. MOST IMPORTANT SYMPTOMS AND EFFECTS, BOTH ACUTE AND DELAYED:
OVERVIEW:
POTENTIAL ACUTE HEALTH EFFECTS:
HAZARDOUS IN CASE OF SKIN CONTACT (IRRITANT), OF EYE CONTACT (IRRITANT), OF
INGESTION, OF INHALATION (LUNG IRRITANT).
TARGET ORGANS: EYES, SKIN, AND LUNGS
POTENTIAL CHRONIC HEALTH EFFECTS:
REPEATED OR PROLONGED EXPOSURE TO THE SUBSTANCE CAN PRODUCE TARGET ORGAN
DAMAGE. SEE SECTION 2 FOR FURTHER DETAILS.
EYES: CAUSES SERIOUS EYE IRRITATION.
| SECTION 5. FIRE-FIGHTING MEASURES | |
5.1 EXTINGUISHING MEDIA:
SUBSTANCE IS NONCOMBUSTIBLE; USE AGENT MOST APPROPRIATE TO EXTINGUISH
SURROUNDING FIRE.
5.2. SPECIAL HAZARDS ARISING FROM THE SUBSTANCE OR MIXTURE:
HAZARDOUS DECOMPOSITION:
REACTS WITH HYDROFLUORIC ACID TO FORM TOXIC SILICON TETRA FLUORIDE GAS,
CARBON MONOXIDE, CARBON DIOXIDE, TOXIC FUMES OF SODIUM OXIDE.
5.3. ADVICE FOR FIRE-FIGHTERS:
SUBSTANCE IS NONCOMBUSTIBLE; USE AGENT MOST APPROPRIATE TO EXTINGUISH
SURROUNDING FIRE.
SODIUM CARBONATE MAY EXPLODE WHEN APPLIED TO RED-HOT ALUMINUM. SODIUM
CARBONATE CAN IGNITE AND BURN FIERCELY IN CONTACT WITH FLUORIDE. SODIUM
CARBONATE IN CONTACT WITH FLUORINE DECOMPOSED AT ORDINARY TEMPERATURE WITH
INCANDESCENCE.
NONE APPLICABLE IF PRODUCT IS UNUSED. IF USED TO ABSORB FLAMMABLE LIQUIDS,
THEN CONSULT SDS OF THE FLAMMABLE LIQUID.
| SECTION 6. ACCIDENTAL RELEASE MEASURES | |
6.1. PERSONAL PRECAUTIONS, PROTECTIVE EQUIPMENT AND EMERGENCY PROCEDURES:
PUT ON APPROPRIATE PERSONAL PROTECTIVE EQUIPMENT (SEE SECTION 8).
6.2. ENVIRONMENTAL PRECAUTIONS:
USE GOOD PERSONAL HYGIENE PRACTICES. WASH HANDS BEFORE EATING, DRINKING,
SMOKING OR USING TOILET. PROMPTLY REMOVE SOILED CLOTHING AND WASH
THOROUGHLY BEFORE REUSE.
6.3. METHODS AND MATERIAL FOR CONTAINMENT AND CLEANING UP:
SWEEP WITH BROOM OR VACUUM INTO A SUITABLE DISPOSAL CONTAINER. WEAR
APPROPRIATE PERSONAL PROTECTION. AVOID CREATING DUSTY CONDITIONS. COMPLY
WITH STATE AND LOCAL REGULATIONS FOR DISPOSAL OF THESE PRODUCTS. IF USED TO
COLLECT LIQUID MATERIAL, DISPOSE IN COMPLIANCE WITH SDS OF COLLECTED
LIQUID.
| SECTION 7. HANDLING AND STORAGE | |
7.1. PRECAUTIONS FOR SAFE HANDLING:
WEAR APPROPRIATE PERSONAL PROTECTION. REMOVE MATERIAL AFTER ABSORPTION HAS
TAKEN PLACE. RESEAL CONTAINER AFTER USE TO PREVENT EVAPORATION OF WETTING
AGENT. WASH THOROUGHLY AFTER USE.
SEE SECTION 2 FOR FURTHER DETAILS. - [PREVENTION]:
7.2. CONDITIONS FOR SAFE STORAGE, INCLUDING ANY INCOMPATIBILITIES:
HANDLE CONTAINERS CAREFULLY TO PREVENT DAMAGE AND SPILLAGE.
INCOMPATIBLE MATERIALS:
HYDROFLUORIC ACID, STRONG OXIDIZING AGENTS, METALS, FLUORINE, HYDROGEN
PEROXIDE, PHOSPHORUS PENTOXIDE, 2, 4, 6-TRINITROTOLUENE, 2,
-4-DINITROTOLUENE, LIME DUST + MOISTURE.
STORE IN A CLOSED CONTAINER IN A DRY PLACE AWAY FROM INCOMPATIBLE
MATERIALS. SEE SECTION 2 FOR FURTHER DETAILS. - [STORAGE]:
7.3. SPECIFIC END USE(S): NO DATA AVAILABLE
| SECTION 8. EXPOSURE CONTROLS / PERSONAL PROTECTION | |
8.1 CONTROL PARAMETERS EXPOSURE GUIDELINES:
CAS NO. INGREDIENT SOURCE VALUE
0000497-19-8 SODIUM CARBONATE OSHA NO ESTABLISHED LIMIT
ACGIH NO ESTABLISHED LIMIT
NIOSH NO ESTABLISHED LIMIT
SUPPLIER NO ESTABLISHED LIMIT
0093763-70-3 AMORPHOUS ALUMINA OSHA TWA: 15 MG/M3 (TOTAL)
SILICATE FERTILE TWA: 5 MG/M3 (RESP)
ACGIH NO ESTABLISHED LIMIT
NIOSH TWA: 10 MG/M3 (TOTAL)
TWA: 5 MG/M3 (RESP)
SUPPLIER NO ESTABLISHED LIMIT
0000497-19-8 SODIUM CARBONATE OSHA SELECT CARCINOGEN: NO
NTP KNOWN: NO
SUSPECTED: NO
IARC GROUP 1: NO
GROUP 2A: NO
GROUP 2B: NO
GROUP 3: NO
GROUP 4: NO
0093763-70-3 AMORPHOUS ALUMINA OSHA SELECT CARCINOGEN: NO
SILICATE PERLITE
NTP KNOWN: NO
SUSPECTED: NO
IARC GROUP 1: NO
GROUP 2A: NO
GROUP 2B: NO
GROUP 3: NO
GROUP 4: NO
8.2. EXPOSURE CONTROLS:
RESPIRATORY: WE RECOMMEND USE OF NIOSH APPROVED DUST RESPIRATOR.
EYES: SAFETY GLASSES/GOGGLES ARE RECOMMENDED.
SKIN: WEAR GLOVES AND BODY COVERING CLOTHING TO PREVENT SKIN EXPOSURE.
ENGINEERING CONTROLS:
A SYSTEM OF LOCAL AND/OR GENERAL EXHAUST MAY BE USED TO KEEP EXPOSURES AS
LOW AS POSSIBLE.
OTHER WORK PRACTICES:
USE GOOD PERSONAL HYGIENE PRACTICES. WASH HANDS BEFORE EATING, DRINKING,
SMOKING OR USING TOILET. PROMPTLY REMOVE SOILED CLOTHING AND WASH
THOROUGHLY BEFORE REUSE.
SEE SECTION 2 FOR FURTHER DETAILS: PREVENTION
| SECTION 9. PHYSICAL AND CHEMICAL PROPERTIES | |
APPEARANCE: WHITE OR BUFF AGGREGATE OR POWDER SOLID
ODOR: ODORLESS
ODOR THRESHOLD: NOT MEASURED
PH: 11.3
INITIAL BOILING POINT AND BOILING RANGE: 1600 DEGREES F
FLASH POINT: NON-FLAMMABLE
EVAPORATION RATE (ETHER = 1): NOT MEASURED
FLAMMABILITY (SOLID, GAS): NOT APPLICABLE
UPPER/LOWER FLAMMABILITY OR EXPLOSIVE LIMITS:
LOWER EXPLOSIVE LIMIT: NOT MEASURED
UPPER EXPLOSIVE LIMIT: NOT MEASURED
VAPOR PRESSURE (PA): NEGLIGIBLE
VAPOR DENSITY: NOT MEASURED
SPECIFIC GRAVITY: NEUTRAL=2.28
SOLUBILITY IN WATER: 8% SLIGHTLY
PARTITION COEFFICIENT N-OCTANOL/WATER (LOG KOW): NOT MEASURED
AUTO-IGNITION TEMPERATURE: NOT MEASURED
DECOMPOSITION TEMPERATURE: NOT MEASURED
VISCOSITY (CST): NOT MEASURED
9.2. OTHER INFORMATION: NO OTHER RELEVANT INFORMATION.
| SECTION 10. STABILITY AND REACTIVITY | |
10.1 REACTIVITY: HAZARDOUS POLYMERIZATION WILL NOT OCCUR.
10.2. CHEMICAL STABILITY: STABLE UNDER NORMAL CIRCUMSTANCES.
10.3. POSSIBILITY OF HAZARDOUS REACTIONS: NO DATA AVAILABLE.
10.4. CONDITIONS TO AVOID:
INCOMPATIBLE MATERIALS, DUST GENERATION, EXCESS HEAT, MOIST AIR.
10.5. INCOMPATIBLE MATERIALS:
HYDROFLUORIC ACID, STRONG OXIDIZING AGENTS, METALS, FLUORINE, HYDROGEN
PEROXIDE, PHOSPHORUS PENTOXIDE, 2,4,6-TRINITROTOLUENE, 2,-4-DINITROTOLUENE,
LIME DUST + MOISTURE
10.6. HAZARDOUS DECOMPOSITION PRODUCTS:
REACTS WITH HYDROFLUORIC ACID TO FORM TOXIC SILICON TETRA FLUORIDE GAS,
CARBON MONOXIDE, CARBON DIOXIDE, TOXIC FUMES OF SODIUM OXIDE.
| SECTION 11. TOXICOLOGICAL INFORMATION | |
ACUTE TOXICITY:
INGREDIENT ORAL LD50, SKIN LD50, INHALATION INHALATION INHALATION
MG/KG MG/KG VAPOR DUST/MIST GAS LD50,
LD50, LD50, PPM
MG/L/4 HR MG/L/4HR
AMORPHOUS NO DATA NO DATA NO DATA NO DATA NO DATA
ALUMINA AVAILABLE AVAILABLE AVAILABLE AVAILABLE AVAILABLE
SILICATE
PERLITE -
(93763-70-3)
SODIUM 4,090.00, NO DATA NO DATA NO DATA NO DATA
CARBONATE - RAT - AVAILABLE AVAILABLE AVAILABLE AVAILABLE
(497-19-8) CATEGORY:
5
NOTE:
WHEN NO ROUTE SPECIFIC LD50 DATA IS AVAILABLE FOR AN ACUTE TOXIN, THE
CONVERTED ACUTE TOXICITY POINT ESTIMATE WAS USED IN THE CALCULATION OF THE
PRODUCT'S ATE (ACUTE TOXICITY ESTIMATE).
CLASSIFICATION CATEGORY HAZARD DESCRIPTION
ACUTE TOXICITY (ORAL) NOT APPLICABLE
ACUTE TOXICITY (DERMAL) NOT APPLICABLE
ACUTE TOXICITY (INHALATION) NOT APPLICABLE
SKIN CORROSION/IRRITATION NOT APPLICABLE
SERIOUS EYE DAMAGE/IRRITATION 2 CAUSES SERIOUS EYE IRRITATION.
RESPIRATORY SENSITIZATION NOT APPLICABLE
SKIN SENSITIZATION NOT APPLICABLE
GERM CELL MUTAGENICITY NOT APPLICABLE
CARCINOGENICITY NOT APPLICABLE
REPRODUCTIVE TOXICITY NOT APPLICABLE
STOT-SINGLE EXPOSURE NOT APPLICABLE
STOT-REPEATED EXPOSURE NOT APPLICABLE
ASPIRATION HAZARD NOT APPLICABLE
| SECTION 12. ECOLOGICAL INFORMATION | |
12.1 TOXICITY:
NO ADDITIONAL INFORMATION PROVIDED FOR THIS PRODUCT. SEE SECTION 3 FOR
CHEMICAL SPECIFIC DATA.
AQUATIC ECOTOXICITY:
INGREDIENT 96 HR LC50 FISH, 48 HR EC50 ERC50 ALGAE,
MG/L CRUSTA MG/L
AMORPHOUS ALUMINA NOT AVAILABLE NOT AVAILABLE NOT AVAILABLE
SILICATE PERLITE -
SODIUM CARBONATE - 300.00, LEPOMIS 265.00, DAPHNIA 242.00 (72 HR),
(497-19-8) MACROCHIRUS MAGNA FRESHWATER ALGAE
12.2. PERSISTENCE AND DEGRADABILITY:
THERE IS NO DATA AVAILABLE ON THE PREPARATION ITSELF
12.3. BIOACCUMULATIVE POTENTIAL: NOT MEASURED
12.4. MOBILITY IN SOIL: NO DATA AVAILABLE.
12.5. RESULTS OF PBT AND VPVB ASSESSMENT:
THIS PRODUCT CONTAINS NO PBT/VPVB CHEMICALS.
12.6. OTHER ADVERSE EFFECTS: NO DATA AVAILABLE
| SECTION 13. DISPOSAL CONSIDERATIONS | |
13.1. WASTE TREATMENT METHODS:
OBSERVE ALL FEDERAL, STATE AND LOCAL REGULATIONS WHEN DISPOSING OF THIS
SUBSTANCE.
| SECTION 14. TRANSPORT INFORMATION | |
14.1 UN 14.2 PROPER 14.3 HAZARD 14.4 PACKING 14.5
NUMBER SHIPPING NAME CLASS GROUP ENVIRON-
MENTAL
HAZARD
DOT NOT NOT REGULATED NOT APPLICABLE NOT NO
APPLICABLE APPLICABLE
IMDG NOT NOT REGULATED NOT APPLICABLE NOT NO
APPLICABLE APPLICABLE
IATA NOT NOT REGULATED NOT APPLICABLE NOT NO
APPLICABLE APPLICABLE
14.6 SPECIAL PRECAUTIONS: NO FURTHER INFORMATION
| SECTION 15. REGULATORY INFORMATION | |
REGULATORY OVERVIEW:
THE REGULATORY DATA IN SECTION 15 IS NOT INTENDED TO BE ALL-INCLUSIVE, ONLY
SELECTED REGULATIONS ARE REPRESENTED.
TOXIC SUBSTANCE CONTROL ACT (TSCA):
ALL COMPONENTS OF THIS MATERIAL ARE EITHER LISTED OR EXEMPT FROM LISTING ON
THE TSCA INVENTORY.
WHMIS CLASSIFICATION: D2B
US EPA TIER II HAZARDS:
FIRE: NO
REACTIVE: NO
SUDDEN RELEASE OF PRESSURE: NO
IMMEDIATE (ACUTE): YES
TO THE BEST OF OUR KNOWLEDGE, THERE ARE NO CHEMICALS AT LEVELS WHICH
REQUIRE REPORTING UNDER THIS STATUTE.
EPCRA 302 EXTREMELY HAZARDOUS:
TO THE BEST OF OUR KNOWLEDGE, THERE ARE NO CHEMICALS AT LEVELS WHICH
REQUIRE REPORTING UNDER THIS STATUTE.
EPCRA 313 TOXIC CHEMICALS:
TO THE BEST OF OUR KNOWLEDGE, THERE ARE NO CHEMICALS AT LEVELS WHICH
REQUIRE REPORTING UNDER THIS STATUTE.
PROPOSITION 65 - CARCINOGENS (>0.0%):
TO THE BEST OF OUR KNOWLEDGE, THERE ARE NO CHEMICALS AT LEVELS WHICH
REQUIRE REPORTING UNDER THIS STATUTE.
PROPOSITION 65 - DEVELOPMENTAL TOXINS (>0.0%):
TO THE BEST OF OUR KNOWLEDGE, THERE ARE NO CHEMICALS AT LEVELS WHICH
REQUIRE REPORTING UNDER THIS STATUTE.
PROPOSITION 65 - FEMALE REPRO TOXINS (>0.0%):
TO THE BEST OF OUR KNOWLEDGE, THERE ARE NO CHEMICALS AT LEVELS WHICH
REQUIRE REPORTING UNDER THIS STATUTE.
PROPOSITION 65 - MALE REPRO TOXINS (>0.0%):
TO THE BEST OF OUR KNOWLEDGE, THERE ARE NO CHEMICALS AT LEVELS WHICH
REQUIRE REPORTING UNDER THIS STATUTE.
N.J. RTK SUBSTANCES (>1%): AMORPHOUS ALUMINA SILICATE PERLITE
PENN RTK SUBSTANCES (>1%): AMORPHOUS ALUMINA SILICATE PERLITE
| SECTION 16. OTHER INFORMATION | |
THE INFORMATION AND RECOMMENDATIONS CONTAINED HEREIN ARE BASED UPON DATA
BELIEVED TO BE CORRECT. HOWEVER, NO GUARANTEE OR WARRANTY OF ANY KIND,
EXPRESSED OR IMPLIED, IS MADE WITH RESPECT TO THE INFORMATION CONTAINED
HEREIN. WE ACCEPT NO RESPONSIBILITY AND DISCLAIM ALL LIABILITY FOR ANY
HARMFUL EFFECTS WHICH MAY BE CAUSED BY EXPOSURE TO OUR PRODUCTS.
CUSTOMERS/USERS OF THIS PRODUCT MUST COMPLY WITH ALL APPLICABLE HEALTH AND
SAFETY LAWS, REGULATIONS, AND ORDERS.
THE FULL TEXT OF THE PHRASES APPEARING IN SECTION 3 IS:
H319: CAUSES SERIOUS EYE IRRITATION.
THIS IS THE FIRST VERSION IN THE GHS SDS FORMAT. LISTINGS OF CHANGES FROM
PREVIOUS VERSIONS IN OTHER FORMATS ARE NOT APPLICABLE.
THE INFORMATION HEREIN IS PRESENTED IN GOOD FAITH AND BELIEVED TO BE
ACCURATE AS OF THE EFFECTIVE DATE GIVEN. HOWEVER, NO WARRANTY, EXPRESSED OR
IMPLIED, IS GIVEN. IT IS THE BUYER'S RESPONSIBILITY TO ENSURE THAT ITS
ACTIVITIES COMPLY WITH FEDERAL, STATE OR PROVINCIAL AND LOCAL LAWS.